Reduction of Cr(VI) by Desulfovibrio vulgaris and Microbacterium sp.

Many industrial wastes contain Cr(VI), a carcinogen and mutagen, the toxicity of which can be ameliorated by reduction to Cr(III). Microbacterium sp. NCIMB 13776 andDesulfovibrio vulgaris NCIMB 8303 reduced Cr(VI) to Cr(III) anoxically using 25 mM sodium citrate buffer (pH 7), with 25 mM sodium acetate and 25 mM sodium formate as electron donors at 30 °C, under which conditions the rates of reduction of 500 M sodium chromate were 77 and 6 nmol h^–1 mg dry cell wt for D. vulgaris and Microbacterium sp., respectively, these being increased to 127 and 17 nmol h^–1 mg dry cell wt in the presence of 20 mM MOPS/NaOH buffer.     

Reduction of Cr(VI) by a Bacillus sp.

A Bacillus sp. RE was resistant to chromium and reduced Cr(VI) without accumulating chromium inside the cell. When Cr(VI) was 10 and 40 μg ml⁻¹, >95% of the total Cr(VI) was reduced in 24 and 72 h of growth, respectively, whereas at 80 μg Cr(VI) ml⁻¹ only 50% of Cr(VI) was reduced. However growth was not affected; the cell mass was 0.7–0.8 mg ml⁻¹ in all cases. The cell-free extract showed Cr(VI) reducing enzyme activity which was enhanced (>5 fold) by NADH and NADPH. Like whole cells the enzyme also reduced Cr(VI) with decreasing efficiency on increasing Cr(VI) concentration. The enzyme activity was optimal at pH 6.0 and 30 °C. The enzyme was stable up to 30 °C and from pH 5.5 to 8, but from pH 4 to 5 the enzyme was severely destabilized. Its K_m and V_max were 14 μm and 3.8 nmol min⁻¹ mg⁻¹ respectively. The enzyme activity was enhanced by Cu²⁺ and Ni²⁺ and inhibited by Hg²⁺. Received 21 September 2005; Revisions requested 5 October 2005; Revisions received 16 November 2005; Accepted 16 November 2005     

Comparative Study of Cr(VI) Removal by Exiguobacterium sp. in Free and Immobilized Forms

Cr(VI) is a toxic environmental pollutant. To determine the potential role of microbes towards chromate bioremediation, two bacterial strains, E1 and E4, that could tolerate Cr(VI) at levels up to 2250 μg ml^?1 were isolated from the soil of a tannery. They were identified as Exiguobacterium sp. To estimate the removal of Cr(VI) using immobilized bacterial cells, 2% sodium alginate and 2.5% agar were used as immobilizing matrices. In the case of sodium alginate, 89% and 93% of Cr(VI) removal by E1 and E4, respectively, were observed. When agar beads were used as an immobilizing matrix, removal was recorded as 39% and 48% for E1 and E4, respectively. Removal of Cr(VI) was also estimated in sterile and nonsterile tannery effluent. More Cr(VI) removal was noted in the nonsterile effluent than in the sterile effluent. The maximum uptake of Cr(VI) of bound cells of E1 and E4 was found to be 17.54 and 20.04 μg ml^?1, respectively. Fourier transform infrared (FTIR) spectra of cells of E4 with Cr(VI), without Cr(VI), and immobilized cells depicted several absorption peaks, mainly for P?OH group, C?H bending, C?O bond, and amide II groups, reflecting the complex nature of the bacterial cells and the contribution of these functional groups to the Cr(VI) binding process.     

异化铁还原细菌LQ25还原重金属Cr (VI)的特性研究

[背景] 异化铁还原细菌能够在还原Fe （III）的同时将毒性较大的Cr （VI）还原成毒性较小的Cr （III）,解决铬污染的问题。[目的] 基于丁酸梭菌（Clostridium butyricum） LQ25异化铁还原过程制备生物磁铁矿,开展异化铁还原细菌还原Cr （VI）的特性研究。[方法] 构建以氢氧化铁为电子受体和葡萄糖为电子供体的异化铁培养体系。菌株LQ25培养结束时制备生物磁铁矿。设置不同初始Cr （VI）浓度（5、10、15、25和30 mg/L）,分别测定菌株LQ25对Cr （VI）还原效率以及生物磁铁矿对Cr （VI）的还原效率。[结果] 菌株LQ25在设置的Cr （VI）浓度范围内都能良好生长。当Cr （VI）浓度为15 mg/L时,在异化铁培养条件下,菌株LQ25对Cr （VI）的还原率为63.45%±5.13%,生物磁铁矿对Cr （VI）的还原率为87.73%±9.12%,相比菌株还原Cr （VI）的效率提高38%。pH变化能影响生物磁铁矿对Cr （VI）的还原率,当pH 2.0时,生物磁铁矿对Cr （VI）的还原率最高,几乎达到100%。电子显微镜观察发现生物磁铁矿表面有许多孔隙,X-射线衍射图谱显示生物磁铁矿中Fe （II）的存在形式是Fe （OH）₂。[结论] 基于异化铁还原细菌制备生物磁铁矿可用于还原Cr （VI）,这是一种有效去除Cr （VI）的途径。     

Concurrent Removal of Mn(II) and Cr(VI) by Achromobacter sp. TY3-4

In this study, we report a bacterium, Achromobacter sp. TY3-4, capable of concurrently removing Mn (II) and Cr (VI) under oxic condition. TY3-4 reduced as much as 2.31?mM of Cr (VI) to Cr (III) in 70?h, and oxidized as much as 20?mM of Mn(II) to Mn oxides in 80?h. When 0.58?mM Cr (VI) and 10?mM Mn(II) were present together, both Cr(VI) and Mn(II) were completely removed by TY3-4 and the generated precipitates are Mn^IIIOOH, Mn^III,IV₃O₄, Mn^IVO₂ and Cr^III(OH)₃. Experiments also show that both biosroption and bioreduction of Mn(II) are the driving forces for Mn(II) removal, whereas bioreduction of Cr(VI) is the driving force for Cr(VI) removal. On the basis of these results, a possible reaction was proposed that TY3-4 concurrently reduces Cr(VI) and oxidizes Mn(II). This study is fundamental for Mn and Cr cycles. The strain shows potential for practical application.     

Degradation of 2-methylnaphthalene by free and immobilized cells of Pseudomonas sp. strain NGK1

A Pseudomonas sp. strain NGK1 (NCIM 5120) capable of utilizing 2-methylnaphthalene (2-MN) was immobilized in various matrices namely, polyurethane foam (PUF), alginate, agar and polyvinyl alcohol (PVA) (1.5 × 10¹² c.f.u. g^–1 beads). The degradation rates of 25 and 50 mM 2-MN by freely suspended cells (2 × 10¹¹ c.f.u. ml^–1) and immobilized cells in batches, semi-continuous with shaken culture and continuous degradation in a packed-bed reactor were compared. The PUF-immobilized cells achieved higher degradation of 25 and 50 mM of 2-MN than freely suspended cells and the cells immobilized in alginate, agar or PVA. The PVA- and PUF-immobilized cells could be reused for more than 30 and 20 cycles respectively, without losing any degradation capacity. The effect of dilution rates on the rate of degradation of 25 and 50 mM 2-MN with freely suspended and immobilized cells were compared in the continuous system. Increase in dilution rate increased the degradation rate only up to 1 h^–1 in free cells with 25 mM 2-MN and no significant increase was observed with 50 mM 2-MN. With immobilized cells, the degradation rate increased with increase in dilution rate up to 1.5 h^–1 for 25 mM and 1 h^–1 for 50 mM 2-MN. These results revealed that the immobilized cell systems are more efficient than freely suspended cells for biodegradation of 2-MN.     

Ochrobactrum tritici strain 5bvl1 - characterization of a Cr(VI)-resistant and Cr(VI)-reducing strain

Bacterial strain 5bvl1, isolated from a chromium-contaminated wastewater treatment plant and identified as Ochrobactrum tritici, was resistant to a broad range of antibiotics, to Cr(VI), Ni(II), Co(II), Cd(II), and Zn(II), and was able to grow in the presence of 5% NaCl and within the pH range 4-10. Characterization showed that strain 5bvl1 could be considered a halotolerant and alkalitolerant microorganism resistant to high concentrations of Cr(VI). This strain was able to grow aerobically in up to 10 mmolxL(-1) Cr(VI). Cr(VI) resistance was independent of sulphate concentration. Under aerobic conditions strain 5bvl1 was also able to reduce high Cr(VI) concentrations (up to 1.7 mmolxL(-1)). Increasing concentrations of Cr(VI) in the medium lowered the growth rate of strain 5bv11 but the reduction in growth rate could not be directly correlated with the amount of Cr(VI) reduced. Unlike the type strain, which was only able to reduce Cr(VI), strain 5bvl1 was resistant to Cr(VI) and able to reduce it. Moreover, in strain 5bvl1, the rate and extent of Cr(VI)-reduction were higher than in the other strains of the genus Ochrobactrum. Ochrobactrum strain 5bvl1 resists high Cr(VI) concentrations and has a high Cr(VI)-reducing ability, making it a valuable tool in bioremediation.     

Removal and assessment of toxicity of Cu and Fe toAnabaena doliolum andChlorella vulgaris using free and immobilized cells

Alginate-immobilized and free cells ofAnabaena doliolum andChlorella vulgaris were compared for their use in the removal and toxicity bioassays of Cu and Fe. A decrease in toxicity with regard to growth and uptake of NO ₃ ^– and NH ₄ ⁺ was noticed following immobilization of both the organisms. In contrast, immobilized cells had higher uptake rates of Cu and Fe suggesting that immobilization offers protection against metal toxicity. Compared with free cells, the immobilized cells showed greater efficiency for metal removal, even over three repeated cycles, though with a gradual decrease in efficiency in the second and third cycles. This reduction in removal efficiency was, however, more pronounced for Fe withA. doliolum and for Cu withC. vulgaris. The ease in harvesting and potential for repeated use makes the immobilized cells good tools for scavenging heavy metals from metal-contaminated environments.     

Cr(Ⅵ)还原菌Microbacterium sp.BD6的分离鉴定及还原特性

【目的】从电镀厂下水道的淤泥中分离筛选Cr(Ⅵ)高效还原菌,并对其生长和还原特性进行研究,以期为Cr(Ⅵ)污染的生物修复提供优质的菌种资源和应用参考。【方法】采用富集培养法从淤泥中分离、筛选出Cr(Ⅵ)还原菌,通过生理生化及16S rRNA基因序列分析进行初步鉴定。采用单因素实验确定菌株的最佳培养条件和抵抗胁迫环境的能力,利用外加电子供体改善菌株的Cr(Ⅵ)还原能力,筛选出最佳电子供体研究对菌株还原的影响。【结果】经分离筛选得到1株Cr(Ⅵ)耐受还原菌,初步鉴定为微杆菌属(Microbacterium sp.),命名为BD6。菌株BD6适宜在中温、偏碱性的环境条件下生长,能耐受50.0 g/L NaCl的高盐环境。Mn^2+对菌种的生长表现出较高的抑制,Ni^2+、Zn^2+、Cd^2+的抑制作用较小,Cu^2)产生了一定的促进作用。Cr(Ⅵ)对BD6的最低抑菌浓度为1700 mg/L。添加甘油、果糖、乳糖、葡萄糖、丙酮酸钠作为电子供体促进了菌株对Cr(Ⅵ)的还原。选择甘油作为菌株还原Cr(Ⅵ)的最佳电子供体,无电子供体添加时菌株96 h内对100 mg/L Cr(Ⅵ)的还原率仅为69.63%,添加2 g/L的甘油菌株在36 h内的还原率达到了100%。通过加大甘油的添加量可以促进菌株对初始浓度较高Cr(Ⅵ)的还原,但要受到Cr(Ⅵ)的毒性限制。菌株的最适还原条件和最适生长条件吻合,在50.0 g/L NaCl的高盐条件和50 mg/L Cd^2+的毒性环境中,添加2 g/L的甘油,菌株对100 mg/L Cr(Ⅵ)的还原率分别为72 h 96.79%、54 h 99.86%。【结论】分离筛选得到的Microbacterium sp.BD6是一株潜在的可用于Cr(Ⅵ)污染生物还原修复的候选菌株。     

Removal of Cr(VI) from ground water by Saccharomyces cerevisiae

Chromium can be removed from ground water by the unicellular yeast, Saccharomyces cerevisiae. Local ground water maintains chromium as CrO₄ ^2- because of bicarbonate buffering and pH and E _h conditions (8.2 and +343 mV, respectively). In laboratory studies, we used commercially available, nonpathogenic S. cerevisiae to remove hexavalent chromium [Cr(VI)] from ground water. The influence of parameters such as temperature, pH, and glucose concentration on Cr(VI) removal by yeast were also examined. S. cerevisiae removed Cr(VI) under aerobic and anaerobic conditions, with a slightly greater rate occurring under anaerobic conditions. Our kinetic studies reveal a reaction rate (V_max) of 0.227 mg h^-1 (g dry wt biomass)^-1 and a Michaelis constant (Km) of 145 mg/l in natural ground water using mature S. cerevisiae cultures. We found a rapid (within 2 minutes) initial removal of Cr(VI) with freshly hydrated cells [55–67 mg h^-1 (g dry wt biomass)^-1] followed by a much slower uptake [0.6–1.1 mg h^-1 (g dry wt biomass)^-1] that diminished with time. A materials-balance for a batch reactor over 24 hours resulted in an overall shift in redox potential from +321 to +90 mV, an increase in the bicarbonate concentration (150–3400 mg/l) and a decrease in the Cr(VI) concentration in the effluent (1.9-0 mg/l).     

A novel isolate of Desulfovibrio sp. with enhanced ability to reduce Cr(VI)

Kinetic analysis of the reduction of Cr(VI) by resting cell suspensions of Desulfovibrio vulgaris ATCC 29579 and a new isolate, Desulfovibrio sp. (`Oz7') was studied using lactate as the electron donor at 30 °C. The apparent K <sub>m</sub> (K <sub>m app</sub>) and V <sub>max</sub> with respect to Cr(VI) reduction was compared for both strains. Desulfovibio sp. `Oz7' had a K _{m app} of 90 M (threefold lower than that of D. vulgaris ATCC 29579) and a V _max of 120 nmol h^–1 mg^–1 biomass dry wt (approx. 30% lower than for the reference strain). The potential of the new isolate for bioremediation of Cr(VI) wastewaters is discussed.     

Removal of skim milk lactose by fermentation using free and immobilized Kluyveromyces marxianus cells

Kluyveromyces marxianus CBS 6164 cells, free or immobilized in Ca-alginate (2%) beads, are able to consume more than 99% of the skim milk lactose in anaerobic conditions. In batches at 30 °C, the lactose consumption after 3.5 h of skim milk fermentation by 30 and 50 g free K. marxianus cells per liter was around 99 and 99.6% respectively, with an approximate conversion of lactose to ethanol and CO₂ of 80%. The immobilized cells, easy to handle and showing a faster and easier separation from the fermented medium compared to the free ones, were used in more than 23 batches (cycles of re-use) without losing their activity.     

Simultaneous bioremediation of Cr(VI) and lindane in soil by actinobacteria

Environments co-contaminated with metals and organic compounds are difficult to remediate. Actinobacteria is an important group of microorganisms found in soils, with high metabolic versatility and potential for bioremediation. In this paper, actinobacteria were used to remediate soil co-contaminated with Cr(VI) and lindane. Five actinobacteria, tolerant to Cr(VI) and lindane mixture were selected: Streptomyces spp. A5, A11, M7, and MC1, and Amycolatopsis tucumanensis DSM 45259. Sterilized soil samples were inoculated with actinobacteria strains, either individually or as a consortium, and contaminated with Cr(VI) and lindane, either immediately or after 7 days of growth, and incubated at 30 °C during 14 days. All actinobacteria were able to grow and remove both contaminants, the consortium formed by Streptomyces spp. A5, M7, MC1, and A. tucumanensis showed the highest Cr(VI) removal, while Streptomyces sp. M7 produced the maximum lindane removal. In non-sterile soil samples, Streptomyces sp. M7 and the consortium removed more than 40% of the lindane, while Streptomyces sp. M7 demonstrated the greatest Cr(VI) removal. The most appropriate strategy for bioremediation of Cr(VI) and lindane co-contaminated soils would be the inoculation with Streptomyces sp. M7.     

Halotolerance studies onChlamydomonas reinhardtii: glycerol excretion by free and immobilized cells

The freshwater green algaChlamydomonas reinhardtii can tolerate a maximum saline concentration of 200 mM NaCl. In response to this osmotic shock, the cells accumulated during the first 24 h 15% of the total glycerol synthesized as osmoregulatory metabolite, to provide the corresponding osmotic balance. After this period all glycerol synthesized was excreted to the medium, 4 g L^-1 at 120 h in optimal conditions, before cell degradation occurred. This excretion was about 2-fold higher in Ca-alginate entrapped cells in the presence of 250 mM NaCl. It was concluded that immobilized cells may be of biotechnological interest for continuous glycerol photoproduction in air-lift bioreactors.     

Nitrilase-catalysed conversion of acrylonitrile by free and immobilized cells of <Emphasis Type="Italic">Streptomyces</Emphasis> sp.

The biotransformation of acrylonitrile was investigated using thermophilic nitrilase produced from a new isolate Streptomyces sp. MTCC 7546 in both the free and immobilized state. Under optimal conditions, the enzyme converts nitriles to acids without the formation of amides. The whole cells of the isolate were immobilized in agar-agar and the beads so formed were evaluated for 25 cycles at 50°C. The enzyme showed a little loss of activity during reuse. Seventy-one per cent of 0.5 M acrylonitrile was converted to acid at 6 h of incubation at a very low density of immobilized cells, while 100% conversion was observed at 3 h by free cells.     

Comparative study of Cr(VI) uptake and reduction in industrial effluent by Ochrobactrum intermedium and Brevibacterium sp.

Two chromium-resistant bacterial strains, CrT-1 and CrT-13, tolerant up to 40mg K₂CrO₄ ml^–1 on nutrient agar, 25mgml^–1 in nutrient broth, and up to 10mgml^–1 in acetate-minimal media, were identified as Ochrobactrum intermedium and Brevibacterium sp., respectively, on the basis of 16S rRNA gene sequencing. Uptake of chromate was greater in living cells than in heat-killed on dried cells. CrT-1 reduced 82%, 28% and 16% of Cr(VI) at 100, 500, and 1000gml^–1 after 24h while CrT-13 reduced 41%, 14% and 9%. Other heavy metals at low concentrations did not affect these reductions. At 150 and 300gml^–1 in an industrial effluent sample Cr(VI) was reduced by 87% and 71%, respectively, with CrT-1 and by 68% and 47% with CrT-13.Revisions requested 17 May 2004; Revisions received 2 July 2004     

Biodegradation of p-cresol by immobilized cells of Bacillus sp. strain PHN 1

The Bacillus sp. strain PHN 1 capable of degrading p-cresol was immobilized in various matrices namely, polyurethane foam (PUF), polyacrylamide, alginate and agar. The degradation rates of 20 and 40 mM p-cresol by the freely suspended cells and immobilized cells in batches and semi-continuous with shaken cultures were compared. The PUF-immobilized cells achieved higher degradation of 20 and 40 mM p-cresol than freely suspended cells and the cells immobilized in polyacrylamide, alginate and agar. The PUF- immobilized cells could be reused for more than 35 cycles, without losing any degradation capacity and showed more tolerance to pH and temperature changes than free cells. These results revealed that the immobilized cell systems are more efficient than freely suspended cells for degradation of p-cresol.     

耐盐菌Staphylococcus sp. YZ-1和Bacillus cereus CC-1的Cr(VI)脱毒特性与机理

[背景]高盐含铬废水的去除过程中,Cr(Ⅵ)还原菌是研究者关注的重点,但目前对耐盐菌株的Cr(Ⅵ)脱毒特性及机理的分析仍较少。[目的]比较两株耐盐菌株的Cr(Ⅵ)移除特性,并区分Cr(Ⅵ)耐受机制的差异;通过基因组测序分析,从基因层面推测铬耐受相关基因;构建铬还原菌的混菌体系,考察两者对去除污染物的协同作用。[方法]从青海茶卡盐湖分离耐盐菌Staphylococcus sp.YZ-1,与Bacillus cereus CC-1进行基础特性和Cr(Ⅵ)去除性能的比较,并通过全基因组序列的分析验证特性测试的结果。[结果]两株菌都具有铬移除特性,但CC-1的铬移除效率更高,在初始Cr(Ⅵ)浓度为0.1 mmol/L情况下,CC-1能在12h内移除95.3%的Cr(Ⅵ),而YZ-1只能移除40.1%。在进一步实验中发现YZ-1只能对Cr(Ⅵ)进行还原,将其转化为可溶的有机态Cr(Ⅲ),而CC-1能同时对Cr(Ⅵ)进行还原和吸附。全基因组分析发现YZ-1具有编码外排泵蛋白的基因和编码NAD(P)H氧化还原酶的基因,而CC-1具有编码铬转运蛋白ChrA和细胞色素C氧化还原酶的基因。两株菌的混菌体系在处理含Cr(Ⅵ)、Te(Ⅳ)的废水时,菌群能将还原产物聚集成团并沉淀到底部。[结论]菌株YZ-1和CC-1均为耐盐铬还原菌,但YZ-1中的铬还原酶为诱导型酶,CC-1则为组成型酶。基因组数据分析鉴别出两者可能同时存在多种铬耐受机制相关编码基因。混合菌群可以结合YZ-1的自絮凝特性和两者均有的Te(Ⅳ)/Cr(Ⅵ)还原活性,具有潜在的实用价值。     

Cr(VI) reduction by Enterobacter sp. DU17 isolated from the tannery waste dump site and characterization of the bacterium and the Cr(VI) reductase

Out of nineteen bacteria screened from the tannery waste dump site, the most effective isolate, strain DU17 was selected for Cr(VI) reduction process among the non-pathogenic once. Based on 16S rRNA gene sequence analysis, the bacterium was identified as Enterobacter sp. DU17. Its amplified Cr(VI) reductase gene showed maximum homology with flavoprotein of Enterobacter cloacae. Enterobacter sp. DU17 reduced Cr(VI) maximally at 37 °C and pH 7.0. Various co-metals, electron (e⁻) donors and inhibitors were tested to study their effect on Cr(VI) reduction. In presence (0.2% each) of glucose and fructose, Enterobacter sp. DU17 reduced Cr(VI) completely after 16 and 20 h, respectively. Since the concentration of total Cr was invariable after remediation as detected through AAS analysis, this experiment disclosed that responsible operation was associated with extracellular Cr(VI) reduction process rather than uptake mechanism. Multiple antibiotic resistance index of 0.08 for this bacterium was very low as compared to standard risk assessment value of 0.20. With high Cr(VI) reducing capability, non-pathogenicity and antibiotic sensitivity, Enterobacter sp. DU17 is found to be very efficient in removing Cr(VI) toxicity from the environment.     

Mass transfer studies on the reduction of Cr(VI) using calcium alginate immobilized Bacillus sp. in packed bed reactor

This study presents the external mass transfer effects on the reduction of hexavalent chromium (Cr(VI)) using calcium alginate immobilized Bacillus sp. in a re-circulated packed bed batch reactor (RPBR). The effect of flow rate on the reduction Cr(VI) was studied. Theoretically calculated rate constants for various flow rates were analyzed using external film diffusion models and compared with experimental values. The external mass transfer coefficients for the bioconversion of Cr(VI) were also investigated. The external mass transfer effect was correlated with a model of the type J_D = K Re⁻⁽¹⁻ⁿ⁾. The model was tested with various K values and the mass transfer correlation J_D = 5.7 Re^−0.70 was found to predict the experimental data accurately. The proposed model would be useful for the design of industrial reactor and scale up.