Isolation and characterization of a Trichodermastrain capable of fermenting cellulose to ethanol

The direct fermentation of cellulosic biomass to ethanol has long been a desired goal. To this end, we screened the environment for fungal strains capable of this conversion when grown on minimal medium. One strain, identified as a member of the genus Trichoderma and designated strain A10, was isolated from cow dung and initially produced about 0.4 g ethanol l(-1). This strain cannot grow on any substrate under anaerobic conditions, but can ferment microcrystalline cellulose or several sugars to ethanol. Ethanol accumulation was eventually increased, by selection and the use of a vented fermentation flask, to 2 g l(-1) when the fermentation was carried out in submerged culture in minimal medium. The highest levels of ethanol, >5.0 g l(-1), were obtained by the fermentation of glucose. Little ethanol was produced by the fermentation of xylose, although other fermentation products such as succinate and acetate were observed. Strain A10 was also found to utilize (aerobically) a wide range of carbon sources. In addition, auxotrophic mutants were generated and used to demonstrate parasexuality by complementation between auxotrophs and between morphological mutants. The ability of this strain to use a wide variety of carbohydrates (including crystalline cellulose) combined with its minimal nutrient requirements and the availability of a genetic system suggests that the strain merits further investigation of its ability to convert biomass to ethanol.     

Intraspecific protoplast fusion of Candida tropicalis for enhancing phenol degradation

Auxotrophic mutants and phenol-degrading defective mutants were separately isolated in a phenol-utilizing strain of Candida tropicalis M4, and were hybridized through protoplast fusion. Some protoplast fusants with phenol-degrading ability were obtained and were very stable. Two of the fusants exhibited slightly higher rates of growth than did the wild strain when the cells were grown on phenol medium, and they possessed about 1.9 and 2.2 times respectively higher phenol hydroxylase activity than the wild strain.     

Auxotrophic mutants in the selection of the rubomycin producer, Actinomyces coeruleorubidus

A total of 351 auxotrophic mutants with different antibiotic activity, including several mutants with activity higher than that of the parent prototrophic strains were obtained under the effect of gamma-rays from 3 prototrophic strains of Act. coeruleorubidus. It was shown that most of the auxotrophic mutants did not preserve the property of biochemical insufficiency on passages on complete media. A mutant strain 1059-32 with activity 2 times higher than that of the prototrophic strain 2-39 and the parent auxotrophic culture was obtained from the revertants. Requirements in 29 growth factors including 17 amino acids, 4 nitrous bases, 8 vitamins and coenzymes were determined in 46 stable auxotrophic mutants isolated. The effect of the specific and non-specific growth factors on the culture antibiotic production was studied.     

Gluconic acid production by Aspergillus niger mutant ORS-4.410 in submerged and solid state surface fermentation

Aspergillus niger ORS-4.410, a mutant of Aspergillus niger ORS-4 was produced by repeated irradiation with UV rays. Treatments with chemical mutagnes also resulted into mutant strains. The mutants differed from the parent strain morphologically and in gluconic acid production. The relationship between UV treatment dosage, conidial survival and frequency of mutation showed the maximum frequency of positive mutants (25%) was obtained along with a conidial survival of 59% after second stage of UV irradiation. Comparison of gluconic acid production of the parent and mutant ORS-4.410 strain showed a significant increase in gluconic acid production that was 87% higher than the wild type strain. ORS-4.410 strain when transferred every 15 days and monitored for gluconic acid levels for a total period of ten months appeared stable. Mutant ORS-4.410 at 12% substrate concentration resulted into significantly higher i.e. 85-87 and 94-97% yields of gluconic acid under submerged and solid state surface conditions respectively. Further increase in substrate concentration appeared inhibitory. Maximum yield of gluconic acid was obtained after 6 days under submerged condition and decreased on further cultivation. Solid state surface culture condition on the other hand resulted into higher yield after 12 days of cultivation and similar levels of yields continued thereafter.     

粗糙脉孢菌纤维素酶液体发酵优良形态突变体筛选

丝状真菌被广泛地用于包括纤维素酶在内的工业酶生产过程。在液体深层发酵中,丝状真菌菌丝形态直接影响发酵液的流变特性,进而与目标酶蛋白产量存在着重要的关联。目前,针对丝状真菌工业酶液体发酵菌丝形态的研究依然是从传统的发酵工程学角度出发,对与发酵水平紧密相关的形态、粘度等性状相关基因的认识远远不够。为了挖掘深层发酵中对丝状真菌发酵产酶性能具有重要影响的形态发育相关基因,以粗糙脉孢菌Neurospora crassa单基因突变体库中的95株形态突变株为研究对象,在结晶纤维素为碳源的条件下进行筛选,探寻与野生型菌株蛋白产量有显著差异的突变株。同时,对这些突变株的内切-β-1,4-葡聚糖酶酶活、β-葡萄糖苷酶酶活、发酵液粘度和菌丝干重进行了测定,并观察了发酵液中突变株的菌丝形态。实验结果表明,与野生型菌株相比,突变株SZY32、SZY35、SZY39和SZY43发酵液中蛋白浓度显著降低,突变株SZY11、SZY63、SZY69和SZY87发酵液中蛋白浓度显著性提高。值得注意的是,突变株SZY11和SZY43发酵液菌丝体主要形态为菌球状,其发酵液粘度分别降低75%和50%,突变株SZY87在发酵液中呈长丝状,发酵液粘度显著升高至少2倍。这些与产酶水平相关的形态、粘度基因的获得将有助于丝状真菌纤维素酶等工业酶高产工程菌株的理性构建。     

Screening, mutagenesis and protoplast fusion of Aspergillus niger for the enhancement of extracellular glucose oxidase production

Various strains of Aspergillus niger were screened for extracellular glucose oxidase (GOD) activity. The most effective producer, strain FS-3 (15.9 U mL^–1), was mutagenized using UV-irradiation or ethyl methane sulfonate. Of the 400 mutants obtained, 32 were found to be resistant to 2-deoxy d-glucose, and 17 of these exhibited higher GOD activities (from 114.5 to 332.1%) than the original FS-3 strain. Following determination of antifungal resistance of the highest producing mutants, four mutants were selected and used in protoplast fusions in three different intraspecific crosses. All fusants showed higher activities (from 285.5 to 394.2%) than the original strain. Moreover, of the 30 fusants isolated, 19 showed higher GOD activity than their corresponding higher-producing parent strain.     

纤维素酶固态发酵过程中菌体生长量的测定

纤维素酶在植物再生资源的利用中占有重要地位,目前世界各地均在进行广泛而深入的研究。纤维素酶的生产有固态发酵和液体深层发酵两种方法,由于前者与后者相比具有许多优点,因此纤维素酶的生产主要采用固态发酵法。 根据Durand等给出的固态发酵定义,在固态发酵中微生物的菌丝体紧密地结合于固体基质上,这种情况给菌体生长量的测定带来了极大的困难。与液体深层发酵不同,其菌丝体无法定量地与固体基质相分     

Intraspecific fusion ofAspergillus niger strains producing citric acid using heat-inactivated and living protoplasts

Protoplasts from a prototrophicAspergillus niger strain were first inactivated at 55°C for 12 min with a regeneration frequency of 3.5×10⁻⁶, and then fused with living protoplasts from an auxotrophic strain. The fusion frequency was 1.1×10⁻⁵. Some fusants segregated sectors of prototrophic recombinants Citric acid production in submerged cultivation of these recombinants was examined. More recombinants were obtained by further treating the fusants with (+)-camphor, a diploidization inducer.     

降低光滑球拟酵母电子传递链活性加速丙酮酸合成

光滑球拟酵母CCTCCM2 0 2 0 19经溴化乙锭诱变 ,挑选假阳性呼吸缺陷型菌株共 4 0株。对其中 7株丙酮酸产量提高的突变株进行发酵性底物 (葡萄糖 )和非发酵性底物 (甘油、乙酸 )的利用能力测试 ,鉴定得到 3株呼吸缺陷型突变株RD 16、RD 17和RD 18。相对于出发菌株 ,呼吸缺陷型突变株生长速率下降 ,最终菌体浓度降低 2 1%～2 9% ,胞内ATP含量下降 15 %～ 2 1% ,但单位细胞耗葡萄糖能力和单位细胞产丙酮酸能力分别提高了 2 0 7%～30 7%和 30 7%～ 5 5 5 %。进一步研究发现 ,呼吸缺陷型突变株线粒体复合体Ⅰ、Ⅰ Ⅲ、Ⅱ Ⅲ和Ⅳ的活性分别下降了 34%～ 4 1%、38 6 %～ 5 2 6 %、2 1%～ 2 5 %、15 0 %～ 6 30 % ,表明线粒体电子传递链氧化NADH的功能受到抑制。为使酵解产生的NADH正常氧化 ,在RD 18菌株的对数生长期流加 2 1mmol L外源电子受体乙醛。发现细胞合成丙酮酸能力提高 2 1 6 % ,且葡萄糖消耗速度明显加快 ,发酵周期缩短 14h。结果表明适当削弱能量代谢能够提高真核微生物中心代谢途径的速度     

Biosynthesis of tannin acyl hydrolase from tannin-rich forest residue under different fermentation conditions

Caesalpinia digyna, a tannin-rich forest residue, was used as substrate for production of tannase and gallic acid. Media engineering was carried out under solid-state fermentation, submerged fermentation and modified solid state fermentation conditions for optimum synthesis of tannase and gallic acid (based on 58% tannin content in the raw material). Tannase vis-à-vis gallic acid recovery under modified solid-state fermentation condition was maximum. Conversions of tannin to gallic acid under solid-state fermentation, submerged fermentation and modified solid-state fermentation conditions were 30.5%, 27.5% and 90.9%, respectively. Journal of Industrial Microbiology & Biotechnology (2000) 25, 29–38. Received 02 November 1999/ Accepted in revised form 12 February 2000     

Improvement of the cell volume ofCandida blankii through protoplast fusion

Summary The yeastCandida blankii ESP-94, capable of utilizing xylose as substrate, was isolated for the production of single-cell protein (SCP) on bagasse hydrolysates. However, the small cell volume of strain ESP-94 would complicate harvesting of the cells during a continuous fermentation process. Auxotrophic mutants of strain ESP-94 were generated and intraspecific protoplast fusion experiments performed in an attempt to increase the cell volume of strain ESP-94. The fusion products were characterised with respect to cell volume, DNA content and genetic stability. Six genetically stable fusants with bigger cell volumes and higher DNA contents were obtained. One such fusant, fusant F17, had a cell volume 3-times that of strain ESP-94, while exhibiting similar growth rates to strain ESP-94 ond-xylose as carbon source.     

Highly Efficient Mutagenesis of Claviceps purpurea by Using Protoplasts

Claviceps purpurea ATCC 20102, which is aconidial under laboratory conditions, was grown in submerged culture in the presence of mutagens and various nutritional additives. Protoplasts from such cultures were prepared and regenerated on solid medium to obtain colonies from single cell units. Frequencies of auxotrophs and high alkaloid producers were on the order of 1 to 2%. Some of the auxotrophic mutants derived from strain ATCC 20102 were constantly segregating prototrophs. High-alkaloid-producing derivatives showed sclerotia-like morphology and violet-brown pigmentation, in contrast to the parent strain; some of them also showed segregation sectors when grown as giant colonies. Mutagenesis of strain 1029, isolated during this study and having an increased level of alkaloid synthesis and sclerotia-like cell morphology, was done in the same fashion as with the original parent strain, ATCC 20102. Mutants obtained from this strain were all stable with respect to their genotypes. However, a large proportion of colonies derived from regenerated protoplasts, even in the mutagen-free controls, showed a lowered level of alkaloid production and were morphologically more similar to the original wild type, ATCC 20102. The influence of protoplast preparation or regeneration or both on the stability of genes involved in differentiation is discussed.     

Beta-fructofuranosidase production by 2-deoxyglucose resistant mutants of aspergillus niger in submerged and solid-state fermentation

Aspergillus niger produces extracellular beta-fructofuranosidase under submerged (SmF) and solid state fermentation (SSF) conditions. After UV mutagenesis of conidiospores of A. niger, 2-deoxyglucose (10 g/l) resistant mutants were isolated on Czapek's minimal medium containing glycerol as a carbon source and the mutants were examined for improved production of beta-fructofuranosidase in SmF and SSF conditions. One of such mutant DGRA-1 overproduced beta-fructofuranosidase in both SmF and SSF conditions. In SmF, the mutant DGRA-1 showed higher beta-fructofuranosidase productivity (110.8 U/l/hr) than the wild type (48.3 U/l/hr). While in SSF the same strain produced 322 U/l/hr of beta-fructofuranosidase, 2 times higher than that of wild type (154.2 U/l/hr). In SmF, both wild type and mutants produced relatively low level of beta-fructofuranosidase in medium containing sucrose with glucose than from the sucrose medium. However in SSF, the DGRA-1 mutant grown in sucrose and sucrose+ glucose did not show any difference with respect to beta-fructofuranosidase production. These results indicate that the catabolite repression of beta-fructofuranosidase synthesis is observed in SmF whereas in SSF such regulation was not prominent.     

Effect of water activity on invertase production in solid state fermentation by improved diploid strains of Aspergillus niger

Invertase production under solid state fermentation (SSF) was determined using two overproducing mutants (Aw96-3 and Aw96-4) isolated previously from the wild type strain Aspergillus niger C28B25, as well as one diploid (DAR1) and two autodiploid strains (AD96-3 and AD96-4) constructed by parasexual crossings among these mutants. Using polyurethane foam (PUF) as an inert carrier, two initial water activity (Aw) values were evaluated (0.99 and 0.96). At Aw=0.99, maximal activity was reached by diploid AD96-4 (48.91 IU/ml) representing 30- and 13-fold increases with respect to maximal values achieved by the wild type and the haploid parental mutant (Aw96-4), respectively. Similar levels were achieved by this strain at Aw=0.96. However, diploid DAR1 only produced high levels of invertase at Aw=0.96 (43.90 IU/ml), whereas strain AD96-3 reached its highest production (31.10 IU/ml) at Aw=0.99. Both productivity and yields were also analysed for every strain at each Aw value.     

Intraspecific protoplast fusion of amylase-producing strains of Candida fennica

The production of -amylase was increased by protoplast fusion of auxotrophic mutants of Candida fennica FTPT-8903. One prototrophic fusant was 90% and 32% more efficient in producing -amylase in semi-solid and liquid fermentation, respectively, than the parental strains. Protoplast fusion did not significantly stimulate the synthesis of glucoamylase in the fusants.     

Correlation between extracellular polysaccharide composition and nodulating ability inRhizobium trifolii

Summary Two auxotrophic mutants ofRhizobium trifolii which are deficient in nodulating ability have been isolated. Both mutants (strain RS 164 His^– and strain RS213 Leu^–) appear to synthesize abnormal extracellular polysaccharides as compared with the wild type strain RS 55. Simultaneous recovery of nodulating ability and wild type polysaccharide composition has been found in a Leu⁺ revertant of strain RS 213.Abbreviation EPS Extracellular Polysaccharide - NIG N-Methyl-N-Nitro-N-Nitrosoguanidine     

Selection of biochemical mutants of Aspergillus niger with enhanced catalase production

 The production of extracellular catalase in a submerged culture by a number of biochemical mutants has been evaluated. Eight of these mutants showed increased extracellular catalase, the level of which ranged widely in individual cases from 44% to over 94% in comparison with the parental strain. Studies of the relationship between a criterion of selection and the frequency of mutation showed that the highest frequency of positive mutations (15.8% and 24.2%) was obtained with respect to mutants resistant to ethidium bromide (1 mmol/l) and sodium gluconate (45%) respectively. The time course of growth and enzyme production by the most active mutant, AM-20, showed extra- and intracellular catalase activities increasing about 2- and 2.6-fold respectively, compared with the parental strain. Received: 4 September 1996 / Received revision: 29 October 1996 / Accepted: 2 November 1996     

Isolation and Characterization of Clostridium butyricum DSM 5431 Mutants with Increased Resistance to 1,3-Propanediol and Altered Production of Acids

Clostridium butyricum mutants were isolated from the parent strain DSM 5431 after mutagenesis with N-methyl-N(prm1)-nitro-N-nitrosoguanidine and two selection procedures: osmotic pressure and the proton suicide method. Isolated mutants were more resistant to glycerol and to 1,3-propanediol (1,3-PD) than was the wild type, and they produced more biomass. In batch culture on 62 g of glycerol per liter, the wild type produced more acetic acid than butyrate, with an acetate/butyrate ratio of 5.0, whereas the mutants produced almost the same quantities of both acids or more butyrate than acetate with acetate/butyrate ratios from 0.6 to 1.1. The total acid formation was higher in the wild-type strain. Results of analysis of key metabolic enzymatic activities were in accordance with the pattern of fermentation product formation: either the butyrate kinase activity increased or the acetate kinase activity decreased in cell extracts of the mutants. A decreased level of the hydrogenase and NADH-ferredoxin activities concomitant with an increase in ferredoxin-NAD(sup+) reductase activities supports the conclusion that the maximum percentage of NADH available and used for the formation of 1,3-PD was higher for the mutants (97 to 100%) than for the wild type (70%). In fed-batch culture, at the end of the fermentation (72 h for the wild-type strain and 80 to 85 h for the mutants), 44% more glycerol was consumed and 50% more 1,3-PD was produced by the mutants than by the wild-type strain.     

Isolation and characterization of CHO cell mutants with altered asparagine synthetase.

Two asparagine auxotrophic mutants (N3, N4) were isolated from the Gat- strain of Chinese hamster ovary cells, using a selection procedure modified from that of Goldfarb et al. (1). The defect in these mutants is due to a deficiency in asparagine synthetase activity. N3, in particular, had no measurable enzyme activity. Complementation analysis by PEG-mediated cell fusion showed that the auxotrophic phenotype behaved as a recessive trait; complementation was obtained between N3 or N4 and the pseudoauxotroph, Asn3, which has a temperature-sensitive asparagyl-tRNA synthetase activity. Revertants obtained by plating N3 or N4 in asparagine-free medium had about normal levels of asparagine synthetase activity and were produced with a probability of about 10(-6) per cell per generation. Three particular revertants of N3 and one revertant of N4 were shown to have asparagine synthetase activities that were different in thermolability from that of the wild type. This observation is consistent with the suggestion that N3 and N4 have defective structural genes rather than defective regulatory genes for asparagine synthetase.     

Isolation of auxotrophic mutants ofAspergillus niger by ethylmethane sulphonate treatment

The alkylating agent EMS can be employed for the isolation of auxotrophic mutants of theAspergillus niger strain K 10. The maximum number of auxotrophic mutants (2.9–5.1%) corresponded approximately to the number of mutants obtained by EMS treatment of yeasts, but it was by order lower than the number of mutants generally obtained by EMS treatment in bacteria. The majority of isolated mutants grew worse than the parent strain in the liquid medium and also formed lower amount of organic acids. The organic acid which was most frequently accumulated by mutants was citric acid.