Evolving improved Synechococcus Rubisco functional expression in Escherichia coli

The photosynthetic CO2-fixing enzyme Rubisco [ribulose-P(2) (D-ribulose-1,5-bisphosphate) carboxylase/oxygenase] has long been a target for engineering kinetic improvements. Towards this goal we used an RDE (Rubisco-dependent Escherichia coli) selection system to evolve Synechococcus PCC6301 Form I Rubisco under different selection pressures. In the fastest growing colonies, the Rubisco L (large) subunit substitutions I174V, Q212L, M262T, F345L or F345I were repeatedly selected and shown to increase functional Rubisco expression 4- to 7-fold in the RDE and 5- to 17-fold when expressed in XL1-Blue E. coli. Introducing the F345I L-subunit substitution into Synechococcus PCC7002 Rubisco improved its functional expression 11-fold in XL1-Blue cells but could not elicit functional Arabidopsis Rubisco expression in the bacterium. The L subunit substitutions L161M and M169L were complementary in improving Rubisco yield 11-fold, whereas individually they improved yield approximately 5-fold. In XL1-Blue cells, additional GroE chaperonin enhanced expression of the I174V, Q212L and M262T mutant Rubiscos but engendered little change in the yield of the more assembly-competent F345I or F345L mutants. In contrast, the Rubisco chaperone RbcX stimulated functional assembly of wild-type and mutant Rubiscos. The kinetic properties of the mutated Rubiscos varied with noticeable reductions in carboxylation and oxygenation efficiency accompanying the Q212L mutation and a 2-fold increase in K(ribulose-P2) (K(M) for the substrate ribulose-P2) for the F345L mutant, which was contrary to the approximately 30% reductions in K(ribulose-P2) for the other mutants. These results confirm the RDE systems versatility for identifying mutations that improve functional Rubisco expression in E. coli and provide an impetus for developing the system to screen for kinetic improvements.     

The rbcX gene product promotes the production and assembly of ribulose-1,5-bisphosphate carboxylase/oxygenase of Synechococcus sp. PCC7002 in Escherichia coli

The operon encoding ribulose-1,5-bisphosphate carboxylase/oxygenase (Rubisco) in the cyanobacterium Synechococcus sp. PCC7002 contains three rbc genes, rbcL, rbcX and rbcS, in this order. Introduction of translational frameshift into the rbcX gene resulted in a significant decrease in the production of large (RbcL) and small (RbcS) subunits of the Rubisco protein in Synechococcus sp. PCC7002 and in Escherichia coli. To investigate the function of the rbcX gene product (RbcX), we constructed the expression plasmid for the rbcX gene and examined the effects of RbcX on the recombinant Rubisco production in Escherichia coli. The coexpression experiments revealed that RbcX had marked effects on the production of large and small subunits of Rubisco without any significant influence on the mRNA level of rbc genes and/or the post-translational assembly of the Rubisco protein. The present rbcX coexpression system provides a novel and useful method for investigating the Rubisco maturation pathway.     

Linked Rubisco subunits can assemble into functional oligomers without impeding catalytic performance

Although transgenic manipulation in higher plants of the catalytic large subunit (L) of the photosynthetic CO2-fixing enzyme ribulose 1,5-bisphospahte carboxylase/oxygenase (Rubisco) is now possible, the manipulation of its cognate small subunit (S) is frustrated by the nuclear location of its multiple gene copies. To examine whether L and S can be engineered simultaneously by fusing them together, the subunits from Synechococcus PCC6301 Rubisco were tethered together by different linker sequences, producing variant fusion peptides. In Escherichia coli the variant PCC6301 LS fusions assembled into catalytically functional octameric ([LS]8) and hexadecameric ([[LS]8]2) quaternary structures that excluded the integration of co-expressed unfused S. Assembly of the LS fusions into Rubisco complexes was impaired 50-90% relative to the assembly of unlinked L and S into L8S8 enzyme. Assembly in E. coli was not emulated using tobacco SL fusions that accumulated entirely as insoluble protein. Catalytic measurements showed the CO2/O2 specificity, carboxylation rate, and Michaelis constants for CO2 and ribulose 1,5-bisphosphate for the cyanobacterial Rubisco complexes comprising fusions where the S was linked to the N terminus of L closely matched those of the wild-type L8S8 enzyme. In contrast, the substrate affinities and carboxylation rate of the Rubisco complexes comprising fusions where L was fused to the N terminus of S or a six-histidine tag was appended to the C terminus of L were compromised. Overall this work provides a framework for implementing an alternative strategy for exploring simultaneous engineering of modified, or foreign, Rubisco L and S subunits in higher plant plastids.     

Construction of a Rubisco Fusion Gene and Its Expression in E. coli

A fusion gene was constructed with the Signal sequence of Rubisco (ribulose-1,5-bisphosphate carboxylase/oxygenase) small subunit from tomato and the coding region of Rubisco large subunit from spinach. The fusion gene was confirmed with restriction endonucleases and DNA sequencing analysis for the open reading frame. The chimeric gene was transferred to E. coli and its expression was induced by addition of IPTG. Expression of the Rubisco fusion gene was detected by Western blotting.     

A point mutation in the N-terminus of ribulose-1,5-bisphosphate carboxylase affects ribulose-1,5-bisphosphate binding

Mutagenesis in vitro of the gene encoding the large subunit of ribulose-1,5-bisphosphate carboxylase/ oxygenase (EC 4.1.1.39) from Anacystis nidulans was used to generate novel enzymes. Two conserved residues, threonine 4 and lysine 11 in the N-terminus were changed. The substitution of threonine 4 with serine or valine had little effect on the kinetic parameters. The substitution of lysine 11 with leucine, which is non-polar, increased the K _m for ribulose-1,5-bisphosphate from 82 to 190 M but its replacement with glutamine, which has polar properties, had no appreciable effect.Abbreviations Rubisco ribulose-1,5-bisphosphate carboxylase/oxygenase - RuBP ribulose-1,5-bisphosphate - LSU large sub-unit of Rubisco - SSU small subunit of Rubisco We thank Dr. S. Gutteridge (DuPont, Wilmington, USA) for structural information and for his comments on the results described. The technical assistance of Mr. A. Cowland and Mr. I. Major was invaluable.     

Mutations in the small subunit of ribulose-1,5-bisphosphate carboxylase/ oxygenase increase the formation of the misfire product xylulose-1,5-bisphosphate.

The small subunit (S) increases the catalytic efficiency of ribulose-1,5-bisphosphate carboxylase/oxygenase (EC 4.1.1.39) by stabilizing the active sites generated by four large subunit (L) dimers. This stabilization appears to be due to an influence of S on the reaction intermediate 2,3-enediol, which is formed after the abstraction of a proton from the substrate ribulose-1,5-bisphosphate. We tested the functional significance of residues that are conserved among most species in the carboxy-terminal part of S and analyzed their influence on the kinetic parameters of Synechococcus holoenzymes. The replacements in S (F92S, Q99G, and P108L) resulted in catalytic activities ranging from 95 to 43% of wild type. The specificity factors for the three mutant enzymes were little affected (90-96% of wild type), but Km(CO2) values increased 0.5- to 2-fold. Mutant enzymes with replacements Q99G and P108L showed increased mis-protonation, relative to carboxylation, of the 2,3-enediol intermediate, forming 2 to 3 times more xylulose-1,5-bisphosphate per ribulose-1,5-bisphosphate utilized than wild-type or F92S enzymes. The results suggest that specific alterations of the L/S interfaces and of the hydrophobic core of S are transmitted to the active site by long-range interactions. S interactions with L may restrict the flexibility of active-site residues in L.     

Pseudoreversion substitution at large-subunit residue 54 influences the CO2/O2 specificity of chloroplast ribulose-bisphosphate carboxylase/oxygenase.

Chlamydomonas reinhardtii mutant 31-4E lacks ribulose-1,5-bisphosphate carboxylase/oxygenase (Rubisco; EC 4.1.1.39) holoenzyme due to a mutation in the chloroplast rbcL gene. This mutation causes a glycine54-to-aspartate substitution within the N-terminal domain of the Rubisco large subunit. In the present study, photosynthesis-competent revertants were selected to determine whether other amino acid substitutions might complement the primary defect. Revertants were found to arise from only true reversion or either of two forms of pseudoreversion affecting residue 54. One pseudorevertant has a glycine54-to-alanine substitution that decreases the accumulation of holoenzyme, but the purified Rubisco has near-normal kinetic properties. The other pseudorevertant has a glycine54-to-valine substitution that causes an even greater decrease in holoenzyme accumulation. Rubisco purified from this strain was found to have an 83% decrease in the Vmax of carboxylation and an 18% decrease in the CO2/O2 specificity factor. These results indicate that small increases in the size of amino acid side chains can influence Rubisco assembly or stability. Even though such changes occur far from the active site, they also play a significant role in determining Rubisco catalytic efficiency.     

Suppressor mutations in the chloroplast-encoded large subunit improve the thermal stability of wild-type ribulose-1,5-bisphosphate carboxylase/oxygenase

A temperature-conditional, photosynthesis-deficient mutant of the green alga Chlamydomonas reinhardtii, previously recovered by genetic screening, results from a leucine 290 to phenylalanine (L290F) substitution in the chloroplast-encoded large subunit of ribulose-1,5-bisphosphate carboxylase/oxygenase (Rubisco, EC ). Rubisco purified from mutant cells grown at 25 degrees C has a reduction in CO(2)/O(2) specificity and is inactivated at lower temperatures than those that inactivate the wild-type enzyme. Second-site alanine 222 to threonine (A222T) or valine 262 to leucine (V262L) substitutions were previously isolated via genetic selection for photosynthetic ability at the 35 degrees C restrictive temperature. These intragenic suppressors improve the CO(2)/O(2) specificity and thermal stability of L290F Rubisco in vivo and in vitro. In the present study, directed mutagenesis and chloroplast transformation were used to create the A222T and V262L substitutions in an otherwise wild-type enzyme. Although neither substitution improves the CO(2)/O(2) specificity above the wild-type value, both improve the thermal stability of wild-type Rubisco in vitro. Based on the x-ray crystal structure of spinach Rubisco, large subunit residues 222, 262, and 290 are far from the active site. They surround a loop of residues in the nuclear-encoded small subunit. Interactions at this subunit interface may substantially contribute to the thermal stability of the Rubisco holoenzyme.     

Purification and characterization of large and small subunits of ribulose 1,5-bisphosphate carboxylase expressed separately in Escherichia coli

Procedures were developed for 95 and 80% purification to homogeneity of the large subunit (L) and small subunit (S) of ribulose 1,5-bisphosphate carboxylase/oxygenase (L8S8) from Synechococcus PCC 6301, each expressed separately in Escherichia coli. Purified L had a low specific activity in the absence of S (0.075 mumol CO2 fixed/mg holoenzyme/min). Following elution on a Pharmacia Superose 6 or 12 gel filtration column, 50% of the purified L appeared as the octamer, L8. The rest was in equilibrium with lower polymeric species and/or was retained on the column. Large and small subunits assembled rapidly into the L8S8 holoenzyme that had high specific activities, 6.2 and 3.1 mumol CO2 fixed/mg holoenzyme/min for the homologous Synechococcus L8S8 and the hybrid Synechococcus L-pea S L8S8, respectively. The CO2 dependence for carbamylation of L8 was compared to that of L8S8 as a function of pH and CO2 concentration. The pH dependence indicated an apparent pKa for L8 of 8.28 and for L8S8 of 8.15, suggesting that S may influence the pKa of the lysine involved in carbamylation. The Kact for CO2 at pH 8.4 were similar for L8 (13.5 microM) and L8S8 (15.5 microM). L8 bound 2-[14C]carboxy-D-arabinitol 1,5-bisphosphate (CABP) tightly so that most of the bound [14C]CABP survived gel filtration. A major amount of the L8-[14C]CABP complex appeared as larger polymeric aggregates when eluted in the presence of E. coli protein.     

Low Activation State of Ribulose-1,5-Bisphosphate Carboxylase/Oxygenase in Carboxysome-Defective Synechococcus Mutants

The high-CO2-requiring mutant of Synechococcus sp. PCC 7942, EK6, was obtained after extension of the C terminus of the small subunit of ribulose-1,5-bisphosphate (RuBP) carboxylase/oxygenase (Rubisco). The carboxysomes in EK6 were much larger than in the wild type, but the cellular distribution of the large and small sub-units of Rubisco was not affected. The kinetic parameters of in vitro-activated Rubisco were similar in EK6 and in the wild type. On the other hand, Rubisco appeared to be in a low state of activation in situ in EK6 cells pretreated with an air level of CO2. This was deduced from the appearance of a lag phase when carboxylation was followed with time in cells permeabilized by detergent and subsequently supplied with saturating CO2 and RuBP. Pretreatment of the cells with high CO2 virtually abolished the lag. After low-CO2 treatment, the internal RuBP pool was much higher in mutant cells than in the wild-type cells; pretreatment with high CO2 reduced the pool in mutant cells. We suggest that the high-CO2-requiring phenotype in mutants that possess aberrant carboxysomes arises from the inactivated state of Rubisco when the cells are exposed to low CO2.     

Analysis of carboxysomes from Synechococcus PCC7942 reveals multiple Rubisco complexes with carboxysomal proteins CcmM and CcaA

In cyanobacteria, the key enzyme for photosynthetic CO(2) fixation, ribulose-1,5-bisphosphate carboxylase/oxygenase (Rubisco), is bound within proteinaceous polyhedral microcompartments called carboxysomes. Cyanobacteria with Form IB Rubisco produce beta-carboxysomes whose putative shell proteins are encoded by the ccm-type genes. To date, very little is known of the protein-protein interactions that form the basis of beta-carboxysome structure. In an effort to identify such interactions within the carboxysomes of the beta-cyanobacterium Synechococcus sp. PCC7942, we have used polyhistidine-tagging approaches to identify at least three carboxysomal subcomplexes that contain active Rubisco. In addition to the expected L(8)S(8) Rubisco, which is the major component of carboxysomes, we have identified two Rubisco complexes containing the putative shell protein CcmM, one of which also contains the carboxysomal carbonic anhydrase, CcaA. The complex containing CcaA consists of Rubisco and the full-length 58-kDa form of CcmM (M58), whereas the other is made up of Rubisco and a short 35-kDa form of CcmM (M35), which is probably translated independently of M58 via an internal ribosomal entry site within the ccmM gene. We also show that the high CO(2)-requiring ccmM deletion mutant (DeltaccmM) can achieve nearly normal growth rates at ambient CO(2) after complementation with both wild type and chimeric (His(6)-tagged) forms of CcmM. Although a significant amount of independent L(8)S(8) Rubisco is confined to the center of the carboxysome, we speculate that the CcmM-CcaA-Rubisco complex forms an important assembly coordination within the carboxysome shell. A speculative carboxysome structural model is presented.     

A hybrid ribulosebisphosphate carboxylase/oxygenase enzyme exhibiting a substantial increase in substrate specificity factor.

Two hybrid ribulose-1,5 bisphosphate carboxylase/oxygenase (RubisCO) enzymes were constructed using RubisCO small subunit genes (rbcS) from two eucaryotic marine organisms, Cylindrotheca sp. N1 and Olisthodiscus luteus, cloned downstream of the RubisCO large subunit gene (rbcL) of the cyanobacterium Synechococcus PCC 6301. The expression products synthesized by Escherichia coli JM107 (pVTAC223 and pANOLI) were purified and examined by polyacrylamide gel electrophoresis and compared to the purified products generated by E. coli MV1190 (pBGL710), containing cyanobacterial rbcL and rbcS genes. Both Cylindrotheca and Olisthodiscus small subunits were able to assemble in vivo with the Synechococcus large subunit octamer to form heterologous hexadecameric L8S8 enzymes, the pVTAC223 and pANOLI hybrid enzymes, respectively. Like the Synechococcus RubisCO, the hybrid enzymes were rapidly activated by Mg2+ plus HCO3-, even in the presence of RuBP. The hybrid enzymes, however, were considerably more sensitive to the competitive inhibitor 6-phosphogluconate. Detailed kinetic analysis indicated that while the carboxylase activity of both chimeric enzymes was severely reduced, in the case of the pVTAC223 hybrid enzyme, the degree of partitioning between carboxylation and oxygenation was increased nearly 60% relative to the Synechococcus RubisCO. Other kinetic properties, including the Michaelis constants for the gaseous substrates and RuBP, were altered in the hybrid proteins. These studies also led to the finding that the substrate specificity factor of the Cylindrotheca RubisCO is unusually high.     

Positive and negative selection of mutant forms of prokaryotic (cyanobacterial) ribulose-1,5-bisphosphate carboxylase/oxygenase

A system for biological selection of randomly mutagenized ribulose 1,5-bisphosphate carboxylase/oxygenase (Rubisco) genes from the cyanobacterium Synechococcus PCC6301 was designed in which a Rubisco deletion mutant of the photosynthetic bacterium Rhodobacter capsulatus served as a host. Trans-complementation with the Synechococcus PCC6301 rbcLS genes enabled anaerobic photoautotrophic growth of the R.capsulatus deletion strain with 5% CO(2), but not with 1.5% CO(2) in the atmosphere, and this strain could not grow under aerobic chemoautotrophic conditions. Phenotypic differences between the R.capsulatus host strain complemented with the wild-type rbcLS genes and transconjugates carrying mutated genes were used to identify mutants that were able to complement to photoautotrophic growth with 1.5% CO(2). These "positive" mutant proteins were unaffected for any measured kinetic properties, with a single exception. A mutant with a valine substitution at phenylalanine 342 had an increased affinity for ribulose-1,5-bisphosphate. Mutants with changes in the affinity for CO(2) were isolated through negative selection, in which mutants incapable of complementing R.capsulatus to photoautotrophic growth with 5% CO(2) were identified. Mutations at aspartate 103 resulted in enzymes that were greatly affected for different kinetic parameters, including an increased K(m) for CO(2). This study demonstrated that random mutagenesis and bioselection procedures could be used to identify mutations that influence important properties of bacterial Rubisco; these residues would not have been identified by other methods.     

Glycine 176 affects catalytic properties and stability of the Synechococcus sp. strain PCC6301 ribulose-1,5-bisphosphate carboxylase/oxygenase

A previously described system for biological selection of randomly mutagenized ribulose-1,5-bisphosphate carboxylase/oxygenase (Rubisco) employing the phototrophic bacterium Rhodobacter capsulatus was used to select a catalytically altered form of a cyanobacterial (Synechococcus sp. strain PCC6301) enzyme. This mutant Rubisco, in which conserved glycine 176 was replaced with an aspartate residue, was not able to support CO(2)-dependent growth of the host strain. Site-directed mutant proteins were also constructed, e.g. asparagine and alanine residues replaced the native glycine with the result that these mutant proteins either greatly reduced the ability of R. capsulatus to support growth or had little effect, respectively. Growth phenotypes were consistent with the Rubisco activity levels associated with these proteins, and this was also borne out with purified recombinant proteins. Despite being catalytically challenged, the G176D and G176N mutant proteins were found to exhibit a more favorable interaction with CO(2) than the wild type protein but exhibited a reduced affinity for the substrate ribulose 1,5-bisphosphate. The G176A enzyme differed little from the wild type protein in these properties. None of the mutants had CO(2)/O(2) specificities that differed markedly from the wild type. Further studies taken from the known structure of the Synechococcus Rubisco indicated that substitutions at Gly-176 affected associations between large subunits. Supporting experimental data included an unusual protein concentration-dependent effect on in vitro activity, differences in thermal stability relative to the wild type protein, and aberrant migration on nondenaturing polyacrylamide gels. From these results, it is apparent that residues not directly located within the active site but near large subunit interfaces can affect key kinetic properties of Rubisco. These results suggest that further bioselection protocols (using these proteins as starting material) might yield novel mutant forms of Rubisco that relate to key functional properties.     

Subsaturating Ribulose-1,5-Bisphosphate Concentration Promotes Inactivation of Ribulose-1,5-Bisphosphate Carboxylase/Oxygenase (Rubisco) (Studies Using Continuous Substrate Addition in the Presence and Absence of Rubisco Activase)

We developed a continuous-addition method for maintaining subsaturating concentrations of ribulose-1,5-bisphosphate (RuBP) for several minutes, while simultaneously monitoring its consumption by ribulose-1,5-bisphosphate carboxylase/oxygenase (Rubisco). This method enabled us to observe the effects of subsaturating RuBP and CO2 concentrations on the activity of Rubisco during much longer periods than previously studied. At saturating CO2, the activity of the enzyme declined faster when RuBP was maintained at concentrations near its Km value than when RuBP was saturating. At saturating RuBP, activity declined faster at limiting than at saturating CO2, in accordance with previous observations. The most rapid decline in activity occurred when both CO2 and RuBP concentrations were subsaturating. The activity loss was accompanied by decarbamylation of the enzyme, even though the enzyme was maintained at the same CO2 concentration before and after exposure to RuBP. Rubisco activase ameliorated the decline in activity at subsaturating CO2 and RuBP concentrations. The results are consistent with a proposed mechanism for regulating the carbamylation of Rubisco, which postulates that Rubisco activase counteracts Rubisco's unfavorable carbamylation equilibrium in the presence of RuBP by accelerating, in an ATP-dependent manner, the release of RuBP from its complex with uncarbamylated sites.     

Biogenesis and Ultrastructure of Carboxysomes from Wild Type and Mutants of Synechococcus sp. Strain PCC 7942

Immature inclusions representing three progressive steps of carboxysome biogenesis have been identified in Synechococcus during the period of adaptation to low-CO2 conditions: (a) ring-shaped structures, (b) electron-translucent inclusions with the shape of a carboxysome and the internal orderly arrangement of ribulose-1,5-bisphosphate carboxylase oxygenase (Rubisco) molecules, and (c) carboxysomes with an internal electron-translucent area, which seem to be the penultimate stage of carboxysome maturation. The ability to build up normal carboxysomes is impaired in three (M3, EK6, and D4) of four high-carbon-requiring mutants studied in this work. M3 and EK6 exhibit abundant immature electron-translucent carboxysomes but no mature ones. This finding supports the contention that an open reading frame located 7.5 kb upstream of the gene encoding the large subunit of Rubisco (altered in M3) is involved in the carboxysome composition and confirms the structural role of the small subunit of Rubisco (slightly modified in EK6) in the assembly of these structures. D4 shows few typical carboxysomes and frequent immature types, its genetic lesion affecting the apparently unrelated gene encoding a subunit of phosphoribosyl aminoamidazole carboxylase of the purine biosynthesis pathway. Revertants EK20 (EK6) and RK13 (D4) have normal carboxysomes, which means that the restoration of the ability to grow under low CO2 coincides with the proper assembling of these structures. N5, a transport mutant due to the alteration of the gene encoding subunit 2 of NADH dehydrogenase, shows an increase in the number and size of carboxysomes and frequent bar-shaped ones.