首页 | 本学科首页   官方微博 | 高级检索  
相似文献
 共查询到20条相似文献,搜索用时 31 毫秒
1.
为实现转小鼠金属硫蛋白基因-I聚球藻7002的高密度培养, 并将其应用于实际的重金属废水处理过程, 首先需要对培养基的成分进行优化。本文利用响应面这一多因素过程优化的有效工具, 通过全因子实验、最陡爬坡实验和中心组合实验, 对转小鼠金属硫蛋白基因-I聚球藻7002培养基的主要成分以及初始pH进行了优化。优化后的培养基组成为: NaHCO3 1.696 g/L, NaNO3 8.57 g/L, 初始pH为8.57, 其他成分同Medium A。优化条件分别在2 L和20 L气升式光生物反应器中得到了验证, 最大细胞浓度分别达到每升4.16 g干重和每升3.12 g干重, 分别比优化前提高了9倍和7倍, 从而为其产业化应用打下基础。  相似文献   

2.
无机碳源对小球藻自养产油脂的影响   总被引:3,自引:1,他引:3  
旨在研究小球藻利用无机碳自养产油脂,考察了3种无机碳源 (Na2CO3、NaHCO3和CO2) 及其初始浓度对小球藻产油特性的影响。结果表明,小球藻能利用Na2CO3、NaHCO3和CO2产油;经Na2CO3、NaHCO3和CO2培养10 d后,随着每种无机碳源浓度的增加,小球藻产量均先增加后减少。小球藻经3种无机碳源培养后,其培养液pH值上升。最适宜的Na2CO3和NaHCO3添加量均为40 mmol/L,其生物量分别达到0.52 g/L和0.67 g/L,产油量分别达到0.19 g/L和0.22 g/L。在3种无机碳源中,CO2是最佳无机碳源,当CO2浓度为6%时,小球藻生长最快,生物量达2.42 g/L,产油量最高达0.72 g/L;当CO2浓度过低时,无机碳供应不足,油脂产量低;当CO2浓度过高时,培养液pH偏低,小球藻油脂积累受到抑制。Na2CO3和NaHCO3较CO2更有利于小球藻积累不饱和脂肪酸。  相似文献   

3.
Motile intensity of the cells, defined as the specific mean kinetic energy, was measured by image analysis and used to formulate a suitable medium for the cultivation of a motile microalga. Nitrogen source at 60 mg/L was used as the target component. The cells grown in a medium containing urea showed the highest motile intensities during cultivation when compared to the cells grown with NH(4)Cl or (NH(4))(2)SO(4) as the nitrogen source. The urea culture gave the highest biomass yield and lipid content of 1.06+/-0.12 g/L and 22.34+/-2.56%, respectively after 150 h of cultivation. These results indicated a strong dependence of motile intensity on the nitrogen source used in the growth medium. This concept, which requires only a small droplet of the sample, can find potential application in the design and optimization of culture media.  相似文献   

4.
The feasibility of using two fertilizers (urea plus superphosphate) in tap water as a medium for the mass culture of green algae (Scenedesmus and Ankistrodesmus) in outdoor plastic-enclosed minipond systems was investigated. Experiments in which the basic fertilizer-tap water medium was enriched with micro- and/or macronutrients revealed no nutrient deficiency symptoms in the algal biomass produced. Biomass production was found to be quantitatively related to the concentration of fertilizer added and maximal production (> 15 g/m(2) day) was achieved following the addition of 30 mg N/L (1.89 g N/m(2) day) and 4.5 mg P/L (0.28 g P/m(2)/day).  相似文献   

5.
利用基于统计学的方法对不透明红球菌(Rhodococcus opacus)DSM 43250转化合成α-酮异己酸(KIC)的培养环境进行优化。采用Plackett-Burman(PB)设计筛选获得对KIC产量具有显著影响的关键营养因子:(NH4)2SO4、麦芽膏和NaNO3。通过最陡爬坡实验、Box-Behnken实验设计和SAS软件回归分析建立了KIC产量关于3个关键营养因子的二次多项式模型,并以模型求解确定最佳培养条件(g/L):(NH4)2SO4 0.23,麦芽膏2.42,NaNO3 1.43。在此培养条件下,KIC的理论最高产量为23.98 mg/L,在验证实验中KIC最高产量为23.93 mg/L,比优化前(3.72 mg/L)提高了6.43倍。  相似文献   

6.
以聚乙烯醇-海藻酸钠复合材料为载体,Ca(NO3)2为交联剂对氧化亚铁硫杆菌进行包埋固定化。该固定化细胞的连续培养技术可以用于处理H2S、SO2,为了减少减少固定化细胞培养过程中带来许多不利效应的黄铁矾沉淀 (NH4Fe3(SO4)2(OH)6),采取了改变初始pH值和目前普遍采用的9K培养基中的(NH4)2SO4浓度,K2HPO4浓度三种方法。结果显示:在三种方法中,降低(NH4)2SO4浓度是比较可行的一种方法,当(NH4)2SO4从3.0 g/L降低到0.5g/L,Fe2+氧化速率几乎没有受到影响,沉淀形成速率却减少了45%。在固定化细胞连续运行时,降低9K培养基中(NH4)2SO4的含量,当稀释率为0.4 h-1,运行时间为96 h,Fe2+氧化速率高达3.75 g/L.H,结果显示反应柱内沉淀明显减少,同时Fe2+氧化速率并没有明显变化。  相似文献   

7.
新月弯孢霉菌丝球对染料脱色作用的研究   总被引:1,自引:1,他引:1  
郑楠  赵敏  梅丽艳  王玮  张嘉亮 《菌物学报》2010,29(5):746-752
研究了新月弯孢霉Curvularia lunata JQH-100液体培养时产生的菌丝球对多种染料的脱色能力。结果表明,多种染料在24h内的脱色率均达到80%以上,且菌丝球稳定性良好,可重复使用6次;以菌丝球对孔雀绿脱色效果为优化指标,正交实验优化获得制备菌丝球的最佳条件为:葡萄糖20g/L、硫酸铵5g/L、马铃薯200g/L、KH2PO43g/L、MgSO45mg/L、CuSO40.5mg/L、VB15mg/L及pH5、摇床转速120r/min。在上述优化后的基础培养基(不含MgSO4、CuSO4)中分别添加微量元素Cu2+、Mn2+、Mg2+或Ca2+制备的菌丝球,对孔雀绿脱色能力增强;添加Fe2+制备的菌丝球,对孔雀绿脱色能力下降;分别添加Zn2+、Al3+或Na+制备的菌丝球对孔雀绿脱色能力与对照相近。应用优化后培养条件制备的菌丝球处理含多种染料的混合废水,也获得了较好的脱色效果。  相似文献   

8.
钝顶螺旋藻富硒培养条件的优化   总被引:20,自引:0,他引:20  
硒是人和动物必需的微量元素 ,补硒可以防治多种疾病。有机硒具有低毒、高生物利用度的优点 ,目前主要寄希望于生物转化的途径来获得有机硒[1 ] 。植物对硒的生物有机化作用已有综述[2 ] ,并开发有富硒酵母[3 ] 、富硒菇类[4] 、富硒大蒜、富硒黄芪、富硒西洋参、富硒麦芽、富硒茶以及富硒鸡蛋、富硒牛奶等[5] 。螺旋藻是一种很有开发利用前景的藻类 ,但其含硒量极微 ,实验报道富硒螺旋藻对60 Co γ射线胸部照射大鼠诱发肺炎和早期肺、肝纤维增生有防治作用[6] 。在培养液中添加亚硒酸钠可以实现藻类对硒的富集和转化 ,而且螺旋藻对无机硒…  相似文献   

9.
研究了三种碳源Na2CO3、NaHCO3、葡萄糖对眼点拟微绿球藻生长密度和油旨含量的影响,实验结果表明相对于葡萄糖,无机碳源NaHCO3更利于眼点拟微绿球藻的生长.以NaHCO3为碳源,研究了在不同的接种密度、NaNO3浓度下,C/N对眼点拟微绿球藻生长密度和油脂含量的影响.实验结果表明,C/N对眼点拟微绿球藻生长密度的影响与接种密度和NaNO3浓度有关,在高的NaNO3浓度时,C/N对眼点拟微绿球藻生长密度的影响很小;在低的NaNO3浓度时,随着C/N比的增加,微绿球藻的生长密度先增加后下降,存在最佳的C/N比.最佳的C/N比随接种密度而变化,在接种密度为OD440=0.10时,最佳C/N比为3,当接种密度提高到OD440=0.70时,最佳C/N比增加到5.NaNO3浓度和C/N对微藻油脂含量均有较大影响,在不同的接种密度和NaNO3浓度下都表现为C/N=1时最利于微藻油脂的积累,这与卡尔文循环过程中核酮糖-1,5-二磷酸羧化酶/加氧酶的活性有关.本实验的最佳产油培养条件为以NaHCO3为碳源,初始接种密度为OD440=0.70,C/N=1∶1,CNaNO3=0.225g/L,此时油脂产率为56.7 mg/(L·d),EPA产率为6.5 mg/(L·d).  相似文献   

10.
Growth of Aeropyrum pernix, the first reported aerobic neutrophilic hyperthermophilic archaeon, was investigated under different cultivation parameters. Different sources of seawater, pH, and the cultivation methods were tested with the aim to improve the biomass production. A 1-L glass flask fitted with a condenser and air diffuser was used as a bioreactor. The optimum conditions for maximizing A. pernix biomass were obtained when Na2S2O3.5H2O (1 g/L) with added marine broth 2216 at pH 7.0 (20 mmol HEPES buffer/L) was used as a growing medium in a 1-L flask. The biomass production was 0.45 g dry cell mass/L in 40 h under the optimum conditions, which is more than the 0.42 g dry cell mass/L in 60 h previously obtained.  相似文献   

11.
The wood-degrading basidiomycete Cerrena unicolor C-139 has been suggested as a potential producer of the industrially important enzyme laccase. Basic culture parameters influencing the enzyme synthesis in shaken-flask and aerated bioreactor cultures were evaluated to improve the yields of the process. Production of extracellular laccase was considerably enhanced by the addition of Cu2+ in the micromolar range to a carbon-sufficient and nitrogen-sufficient culture medium (C/N = 16.69). When an optimised medium containing glucose (10 g/L) and l-asparagine (1.5 g/L) was used, and enzyme synthesis was stimulated by addition of 10 μM Cu2+ to the culture medium on days 3, 6 and 9, maximal laccase productivity obtained after 17 days’ cultivation in shaken flask cultures was above 100,000 nkat/L. In fermenter fungal cultures, the influence of stabilisation of medium pH on laccase activity was additionally studied. The use of a bioreactor with an automatic pH control set at pH 6.5 after 48-h incubation resulted in the enzyme activity of 65,000 nkat/L after 8 days’ cultivation.  相似文献   

12.
Wu JY  Yeh KL  Lu WB  Lin CL  Chang JS 《Bioresource technology》2008,99(5):1157-1164
Rhamnolipid is one of the most effective and commonly used biosurfactant with wide industrial applications. Systematic strategies were applied to improve rhamnolipid (RL) production with a newly isolated indigenous strain Pseudomonas aeruginosa EM1 originating from an oil-contaminated site located in southern Taiwan. Seven carbon substrates and four nitrogen sources were examined for their effects on RL production. In addition, the effect of carbon to nitrogen (C/N) ratio on RL production was also studied. Single-factor experiments show that the most favorable carbon sources for RL production were glucose and glycerol (both at 40 g/L), giving a RL yield of 7.5 and 4.9 g/L, respectively. Meanwhile, sodium nitrate appeared to be the preferable nitrogen source, resulting in a RL production of 8.6g/L. Using NaNO(3) as the nitrogen source, an optimal C/N ratio of 26 and 52 was obtained for glucose- and glycerol-based culture, respectively. To further optimize the composition of fermentation medium, twenty experiments were designed by response surface methodology (RSM) to explore the favorable concentration of three critical components in the medium (i.e., glucose, glycerol, and NaNO(3)). The RSM analysis gave an optimal concentration of 30.5, 18.1, and 4.9 g/L for glucose, glycerol, and NaNO(3), respectively, predicting a maximum RL yield of 12.6 g/L, which is 47% higher than the best yield (8.6 g/L) obtained from preliminary selection tests and single factor experiments (glucose and NaNO(3) as the carbon and nitrogen source). The NMR and mass spectrometry analysis show that the purified RL product contained L-rhamnosyl-beta-hydroxydecanoyl-beta-hydroxydecanoate (RL1) and L-rhamnosyl L-rhamnosyl-beta-hydroxydecanoyl-beta-hydroxydecanoate (RL2). Meanwhile, HPLC analysis indicates that the molar ratio of RL1 and RL2 in the purified rhamnolipid product was ca. 1:1.  相似文献   

13.
High-density perfusion cultivation of mammalian cells can result in elevated bioreactor CO(2) partial pressure (pCO(2)), a condition that can negatively influence growth, metabolism, productivity, and protein glycosylation. For BHK cells in a perfusion culture at 20 x 10(6) cells/mL, the bioreactor pCO(2) exceeded 225 mm Hg with approximate contributions of 25% from cellular respiration, 35% from medium NaHCO(3), and 40% from NaHCO(3) added for pH control. Recognizing the limitations to the practicality of gas sparging for CO(2) removal in perfusion systems, a strategy based on CO(2) reduction at the source was investigated. The NaHCO(3) in the medium was replaced with a MOPS-Histidine buffer, while Na(2)CO(3) replaced NaHCO(3) for pH control. These changes resulted in 63-70% pCO(2) reductions in multiple 15 L perfusion bioreactors, and were reproducible at the manufacturing-scale. Bioreactor pCO(2) values after these modifications were in the 68-85 mm Hg range, pCO(2) reductions consistent with those theoretically expected. Low bioreactor pCO(2) was accompanied by both 68-123% increased growth rates and 58-92% increased specific productivity. Bioreactor pCO(2) reduction and the resulting positive implications for cell growth and productivity were brought about by process changes that were readily implemented and robust. This philosophy of pCO(2) reduction at the source through medium and base modification should be readily applicable to large-scale fed-batch cultivation of mammalian cells.  相似文献   

14.
红树林溶磷菌的初步鉴定、溶磷能力测定及其优化培养   总被引:10,自引:0,他引:10  
对分离来自华南红树林的溶磷菌进行16S rDNA或ITS等基因水平上的初步鉴定, 测定其溶解无机磷的能力, 并对溶磷菌的生长培养基条件进行优化。结果表明, 溶磷真菌的溶磷效果明显强于溶磷细菌, 且溶磷真菌的溶解无机磷能力与培养液的pH呈极显著负相关, 而溶磷细菌的溶磷能力与pH没显著相关关系。单因素实验表明, 对供试菌株生长的合适碳源为麦芽糖, 氮源为尿素。通过正交实验得到的优化培养基为麦芽糖5 g/L、尿素0.05 g/L、NaCl 5 g/L、pH 5, 在30°C下培养48 h菌落总数可达6.06×  相似文献   

15.
The growth and amino acid contents of the cyanobacterium,Spirulina platensis strain NIES 46, were investigated using ammonium, nitrate, nitrite, or urea as the sole nitrogen source in a batch culture. Chlorophylla concentration was highest at 2,096 μg/L in the nitrate group after 10 days of cultivation, while the dry weight ofS. platensis was highest at 4.5 g/L in the ammonium group after 30 days of cultivation. The total amino acid content was highest at 174 mg/g dry weight ofS. platensis in the urea group at the end of the cultivation period, yet the amino acid patterns forS. platensis were similar for all the experimental groups. Therefore, it seemed that the growth and amino acid composition ofS. platensis varied depending on the type of nitrogen sources, while the amino acid patterns were not changed. Also, the most efficient harvesting time forS. platensis seemed to be approximately 10 days after cultivation.  相似文献   

16.
Summary A new synthetic medium (referred to as GC3) that supports the growth of the Chinese hamster ovary cell line has been developed. It is composed of a 1∶1 mixture of Ham's F12 and modified Eagle's minimum essential (MEM.S) mediums supplemented with transferrin (10 μg/ml), insulin (80 mU/ml), and selenium (1×10−7 M). Other more simple supplementations of our basal medium MEM.S/F12 (transferrin+insulin, transferrin+selenium, ferrous iron+selenium) also give good cell growth responses. Fibronectin or serum pretreatment is not needed for cellular attachment and spreading. Our culture system is characterized by a continuous serum-free cultivation (more than 200 doublings), a clonal growth, a high density proliferation, and a rapid growth rate near that of cells in serum-supplemented medium.  相似文献   

17.
A bacterial strain F-5-2, isolated from soil and identified as Klebsiella pneumoniae, removed NH4+ completely in 24 h of aerobic cultivation in a medium containing 1 mg/ml of NH4NO3. However, 70% of the NO3- originally provided remained. When 100 microM Fe2+ was added to the medium, both NH4+ and NO3- were removed simultaneously and completely from the culture within 6 h of incubation. In addition, the amount of MoO4- in the medium markedly affected the bacterial cell growth and utilization of NH4+ and NO3-. The bacterium could remove 4 mg/ml of NH4NO3 completely in 48 h of aerobic cultivation in a medium containing 100 microM Fe2+ and 0.8 pM MoO4(2-). The total nitrogen in the culture containing its cells was decreased to 14% of that in the NH4NO3 originally provided. GC-MS analysis demonstrated that N2 was generated from the nitrogen atoms of both NH4+ and NO3-.  相似文献   

18.
Yarrowia lipolytica is a potentially useful host for heterologous protein production. To develop an efficient culture method for high cell density cultivation and heterologous gene expression of Y. lipolytica, the effects of medium components and their concentrations on the growth of Y. lipolytica have been investigated. Addition of yeast extract to the culture media was found to significantly reduce the long lag phase encountered when Y. lipolytica was cultivated in synthetic culture media containing high concentrations of glycerol. Therefore, by enriching with 0.3% yeast extract the synthetic culture medium containing 15% glycerol, we could cultivate Y. lipolytica up to 83 g/L dry cell weight in a batch culture. Furthermore, over 100 g/L and 88 units/mL of rice alpha-amylase activity were obtained in less than 50 h with a one-step feeding process in which a recombinant Y. lipolytica expressing rice alpha-amylase was cultivated in the 10% glycerol medium enriched with 0.3% yeast extract and fed only once with the concentrated feeding medium (60% glycerol). The easy cultivation of recombinant Y. lipolytica to a high cell density may strengthen its position as a host for heterologous protein production.  相似文献   

19.
应用正交试验设计法研究基本培养基、植物生长调节剂种类及浓度对文心兰花梗茎段芽再生丛生芽诱导、增殖和生根培养的影响。筛选出最佳基本培养基为1/2 MS;最佳诱导培养基为1/2 MS+6-BA 5.0 mg/L+NAA 0.5 mg/L+蔗糖20 g/L;最佳增殖培养基为1/2 MS+6-BA 3.0 mg/L+NAA 0.5 mg/L+蔗糖30 g/L;最佳生根培养基为1/2 MS+IBA 0.05 mg/L+NAA 0.3 mg/L+香蕉泥100 g/L+蔗糖20 g/L。  相似文献   

20.
Ren J  Lin WT  Shen YJ  Wang JF  Luo XC  Xie MQ 《Bioresource technology》2008,99(17):7923-7927
The sequential statistical experimental design (Plackett-Burman, factorial, response surface and steepest ascent experiment) was applied to optimize the culture medium of nitrite oxidizing bacteria for improving the nitrite oxidizing rate. Estimated optimum medium composition of the nitrite oxidizing rate was as follows: NaHCO(3), 1.86gl(-1); NaNO(2), 2.04gl(-1); Na(2)CO(3), 0.2gl(-1); NaCl, 0.2gl(-1); KH(2)PO(4), 0.1gl(-1); MgSO(4).7H(2)O, 0.1gl(-1); and FeSO(4).7H(2)O, 0.01gl(-1). The nitrite oxidizing rate was increased by 48.0% and reached a maximum at 859.5+/-8.4mgNO(2)-N/gMLSS.d as compared to 580.7+/-25.8mgNO(2)-N/gMLSS.d. In the field trial, 50L of nitrite oxidizing bacteria concentrate (1.99gVSS/L) with 850mgNO(2)-N/gMLSS.d were added to 0.6ha of the aquaculture water. Nitrite level in all treated ponds remained very low compared to the steady increase observed in all of the control ponds during 7 days.  相似文献   

设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号