Efficacy of natamycin for control of growth and ochratoxin A production by Aspergillus carbonarius strains under different environmental conditions

AIMS: To examine the efficacy of natamycin produced by Streptomyces natalensis against strains of Aspergillus carbonarius growth and ochratoxin A (OTA) production under different environmental factors on a grape juice-based medium. METHODS AND RESULTS: Detailed studies in the range 0-20 ng ml(-1) for control of growth and ochratoxin production by strains of A. carbonarius at 0.98, 0.96 and 0.94 water availabilities (a(w)) and 15-25 degrees C on a fresh red grape extract medium were examined. Inhibition of growth was depending on temperature and a(w) level. At 15 degrees C, 5-10 ng ml(-1) natamycin was effective in reducing growth almost completely. However, at 20-25 degrees C and all the three a(w) levels, growth was only slightly inhibited by 5-10 ng ml(-1) natamycin. There were strain differences with regard to inhibition of OTA production. At 15 degrees C and 0.98 a(w), 10 ng ml(-1) was required to inhibit production by >90%. However, at 0.96 and 0.94 a(w), almost complete inhibition occurred. At 20 degrees C, OTA production was only significantly inhibited by 10 ng ml(-1) natamycin at 0.94 a(w). At 0.96 and 0.98 a(w), some inhibition occurred with 5-10 ng ml(-1), but greater concentrations would be required for effective inhibition. At 25 degrees C, 5 ng ml(-1) was effective at all a(w) levels. However, at 15 degrees C and 25 degrees C and a wide range of a(w) levels, natamycin effectively controlled OTA production. CONCLUSIONS: Natamycin appears to be a very effective for controlling growth and OTA production by strains of A. carbonarius over a range of a(w) and temperature conditions on grape-based media. SIGNIFICANCE AND IMPACT OF THE STUDY: This is the first detailed study to demonstrate the impact of natamycin against A. carbonarius. This study suggests that use of natamycin at 50-100 ng ml(-1) can give complete inhibition of growth of A. carbonarius and OTA production over a range of environmental conditions. Natamycin could be an important component of a system to prevent OTA contamination of wine as well during the drying and production of vine fruits.     

Fungi and ochratoxin A detected in healthy grapes for wine production

AIMS: The mycoflora of healthy grapes (i.e. without visible symptoms of rot) for wine production in Portuguese wine-making regions was assessed and its potential for ochratoxin A (OTA) production evaluated. The OTA content of grapes was also determined. METHODS AND RESULTS: A total of 386 fungal strains were isolated by plating methods. The most frequent genera found in grapes were non-ochratoxigenic species: Cladosporium (28%), Penicillium (24%), Botrytis (13%) and Aspergillus (9%). Two OTA-producing strains were isolated, belonging to the species Aspergillus carbonarius and Aspergillus ochraceus. OTA was detected in three of four grape samples, up to 116 ng l(-1). CONCLUSIONS: OTA is being produced in healthy berries by Aspergillus species, namely A. carbonarius, at levels below the maximum recommended limit of 2,000 ng l(-1) in wine. SIGNIFICANCE AND IMPACT OF THE STUDY: The OTA concentration detected in healthy Portuguese grapes does not represent a risk to wine regarding the legal limit established.     

Study of Spanish grape mycobiota and ochratoxin A production by Isolates of Aspergillus tubingensis and other members of Aspergillus section Nigri

The native mycobiota of five grape varieties grown in Spain has been studied. Four (Bobal, Tempranillo, Garnacha, and Monastrell) were red varieties and one (Moscatel) was white. The main fungal genera isolated were Alternaria, Cladosporium, and Aspergillus. The isolation frequency of Aspergillus spp. section Nigri in contaminated samples was 82%. Ochratoxin A (OTA) production was assessed using yeast extract-sucrose broth supplemented with 5% bee pollen. Cultures of 205 isolates from this section showed that 74.2% of Aspergillus carbonarius and 14.3% of Aspergillus tubingensis isolates produced OTA at levels ranging from 1.2 to 3,530 ng/ml and from 46.4 to 111.5 ng/ml, respectively. No Aspergillus niger isolate had the ability to produce this toxin under the conditions assayed. Identification of the A. niger aggregate isolates was based on PCR amplification of 5.8S rRNA genes and its two intergenic spacers, internal transcribed spacer 1 (ITS1) and ITS2, followed by digestion with restriction endonuclease RsaI of the PCR products. The restriction patterns were compared with those from strains of A. niger CECT 2807 and A. tubingensis CECT 20393, held at the Spanish Collection of Type Cultures. DNA sequencing of the ITS1-5.8S rRNA gene-ITS2 region of the OTA-producing isolates of A. tubingensis matched 99 to 100% with the nucleotide sequence of strain A. tubingensis CBS 643.92. OTA determination was accomplished by liquid chromatography with fluorescence detection. OTA confirmation was carried out by liquid chromatography coupled to ion trap mass spectrometry. The results showed that there are significant differences with regard to the isolation frequency of ochratoxinogenic fungi in the different grape varieties. These differences were uncorrelated to berry color. The ability of A. tubingensis to produce OTA and the influence of grape variety on the occurrence of OTA-producing fungi in grapes are described in this report for the first time.     

Effect of preharvest fungicides and interacting fungi on Aspergillus carbonarius growth and ochratoxin A synthesis in dehydrating grapes

AIMS: To evaluate the effect of preharvest grape pesticides in Aspergillus section Nigri infection in dehydrating grapes and the final ochratoxin A (OTA) content. Additionally, the effect of coinoculation of moulds frequently isolated from grapes and raisins on Aspergillus section Nigri infection was studied. METHODS AND RESULTS: Fungicide-treated grapes were inoculated with Aspergillus carbonarius, Aspergillus niger aggregate, Eurotium amstelodami and Penicillium janthinellum in different combinations, then dehydrated by reducing a(w) for 20 days. The percentages of colonized grapes treated with fungicides were, in general, lower, but no differences were observed among fungicides. The untreated grapes always showed higher concentrations of OTA, regardless of the inoculum applied. In general, Chorus was the most effective antifungal treatment in reducing OTA accumulation in grapes during dehydration. Penicillium janthinellum reduced Aspergillus section Nigri colonization and OTA accumulation in grapes during dehydration. CONCLUSIONS: The four preharvest fungicides studied reduced the Aspergillus section Nigri growth and OTA production by A. carbonarius during dehydration of grapes. SIGNIFICANCE AND IMPACT OF THE STUDY: The success of these chemical treatments might depend on the mycobiota composition of grapes.     

Predictive assessment of ochratoxin A accumulation in grape juice based-medium by Aspergillus carbonarius using neural networks

Aims:  To study the ability of multi-layer perceptron artificial neural networks (MLP-ANN) and radial-basis function networks (RBFNs) to predict ochratoxin A (OTA) concentration over time in grape-based cultures of Aspergillus carbonarius under different conditions of temperature, water activity ( a _w) and sub-inhibitory doses of the fungicide carbendazim.
Methods and Results:  A strain of A. carbonarius was cultured in a red grape juice-based medium. The input variables to the network were temperature (20–28°C), a _w (0·94–0·98), carbendazim level (0–450 ng ml⁻¹) and time (3–15 days after the lag phase). The output of the ANNs was OTA level determined by liquid chromatography. Three algorithms were comparatively tested for MLP. The lowest error was obtained by MLP without validation. Performance decreased when hold-out validation was accomplished but the risk of over-fitting is also lower. The best MLP architecture was determined. RBFNs provided similar performances but a substantially higher number of hidden nodes were needed.
Conclusions:  ANNs are useful to predict OTA level in grape juice cultures of A. carbonarius over a range of a _w, temperature and carbendazim doses.
Significance and Impact of the Study:  This is a pioneering study on the application of ANNs to forecast OTA accumulation in food based substrates. These models can be similarly applied to other mycotoxins and fungal species.     

Low levels of ochratocin A in wines from Piedmont

Ochratoxin A (OTA) is a mycotoxin mainly produced by a number of species of Aspergillus, commonly found in warm and tropical climates. OTA poses risks for the human health because of its nephrotoxic, teratogenic, immunotoxic and neurotoxic activity. The mycotoxin, classified as possible human carcinogen (Group 2B) by the IARC, naturally occurs in a wide range of foods, including wine, where the main producer is A. carbonarius. The aim of this work was the validation of a procedure for the analysis of OTA in Piedmontese red and white wines produced after vintage 2003 and 2004, in relationship with the limit of 2.0 microg l(-1) introduced by European Union for wine, must or grape juice (Regulation CE N. 123/2005). An analytical method based on immunoaffinity column (IAC) for clean-up and liquid chromatography with fluorescence detection (LC-FLD) was used to determine the occurrence of OTA in wines. Detection limit (LOD) and quantification Limit (LOQ) were 7.18 pg/ml and 9.31 pg/ml based on statistical method (IUPAC). Average recoveries of OTA from wine samples spiked at levels from 0.1 to 10 ng/ml ranged from 90.8% to 92.4%, with relative standard deviations (RSDs) between 2.64 and 2.71%. Repeatability limit was 8.73 pg/ml for samples spiked with 0.1 ng/ml of OTA. Ninety-one Denomination of Controlled Origin (DOC) wines were analysed, including 41 Barbera (red), 38 Dolcetto (red), and 16 white wines, such as Erbaluce, Cortese and Roero Arneis. The study focused on wines commercialized in Italian supermarkets and wine shops. The white wines resulted, as expected, less contaminated than the red ones. Wines produced after vintage 2003, a season particularly conducive to the growth of A. carbonorius, contained higher levels of OTA than the wines produced in 2004. The samples, resulting positive, contained a concentration of OTA highly inferior to the threshold limits introduced by the European Union. The sample of the highest level of OTA was a Dolcetto produced in 2004, with 1.10 ng/ml of mycotoxin.     

Water and temperature relations of growth and ochratoxin A production by Aspergillus carbonarius strains from grapes in Europe and Israel

AIMS: This study investigated the in vitro effects of water activity (a(w); 0.85-0.987) and temperature (10-40 degrees C) on growth and ochratoxin A (OTA) production by two strains of Aspergillus carbonarius isolated from wine grapes from three different European countries and Israel on a synthetic grape juice medium representative of mid-veraison (total of eight strains). METHODS AND RESULTS: The synthetic grape juice medium was modified with glycerol or glucose and experiments carried out for up to 56 days for growth and 25 days for OTA production. The lag phase prior to growth, growth rates and ochratoxin production were quantified. Statistical comparisons were made of all factors and multiple regression analysis used to obtain surface response curves of a(w) x temperature for the eight strains and optimum growth and OTA production by A. carbonarius. The lag phase increased from <1 day at 25-35 degrees C and 0.98 a(w) to >20 days at marginal temperatures and water availabilities. Generally, most A. carbonarius strains grew optimally at 30-35 degrees C, regardless of solute used to modify a(w), with no growth at <15 degrees C. The optimum a(w) for growth varied from 0.93 to 0.987 depending on the strain, with the widest a(w) tolerance at 25-30 degrees C. There was no direct relationship among growth, environmental factors and country of origin of individual strains. Optimum conditions for OTA production varied with strain. Some strains produced optimal OTA at 15-20 degrees C and 0.95-98 a(w). The maximum OTA produced after 10 days was about 0.6-0.7 microg g(-1), with a mean production over all eight strains of 0.2 microg g(-1) at optimum environmental conditions. CONCLUSIONS: This work demonstrates that optimum conditions for OTA production are very different from those for growth. While growth rates differed significantly between strains, integration of the OTA production data suggests possible benefits for use of the information on a regional basis. SIGNIFICANCE AND IMPACT OF THE STUDY: Very little detailed information has previously been available on the ecology of A. carbonarius. This knowledge is critical in the development and prediction of the risk models of contamination of grapes and grape products by this species under fluctuating and interacting environmental parameters.     

Mycelial growth and ochratoxin A production by Aspergillus section Nigri on simulated grape medium in modified atmospheres

Aims:  To evaluate the impact of modified atmosphere packaging on in vitro growth of Aspergillus carbonarius and Aspergillus niger , and possible effects on ochratoxin A (OTA) biosynthesis.
Methods and Results:  Ochratoxigenic isolates belonging to the species A. carbonarius and A. niger were grown on a synthetic grapejuice medium (SNM) and packaged in combinations of controlled O₂ (1% and 5%) and CO₂ levels (0% and 15%), and in air as a control. Colony diameters were recorded every 3 days up to 21 days, and OTA was analysed after 7, 14 and 21 days. The greatest reductions in mycelial growth rate were observed at 1% O₂ followed by 1% O₂/15% CO₂, whereas 5% O₂ stimulated the growth of all isolates. OTA production by A. carbonarius and A. niger isolates was minimized at 1% O₂/15% CO₂ and 1% O₂, respectively, after 7 days of incubation. Maximal OTA accumulation after 7 days was observed for all isolates in the control pack and at 5% O₂.
Conclusions:  Of the atmospheres tested, only 1% O₂ combined with 15% CO₂ consistently reduced fungal growth and OTA synthesis by A. carbonarius and A. niger .
Significance and Impact of the Study:  Storage under modified atmospheres is unlikely to be suitable as the sole method for OTA minimization and grape preservation; other inhibitory factors are necessary.     

Biodegradation of ochratoxin A by Aspergillus section Nigri species isolated from French grapes: a potential means of ochratoxin A decontamination in grape juices and musts

Ochratoxin A (OTA) is a very dangerous mycotoxin, the presence of which is often reported in different foods, as well as in beverages such as grapes, grape juices and wines. Detoxifying these products is therefore of prime importance in protecting consumer health, and biological approaches have been the most promising methods. In this report, 40 isolates representing the black apergilli species Aspergillus carbonarius, A. niger aggregate and A. japonicus, isolated on French grapes, were assessed for OTA degradation capacities in CZAPEK yeast extract broth (CYB) and in a synthetic grape juice medium (SGM) contaminated with OTA at 2 mg L(-1) (5 microM). It was clearly observed that in both media these fungi had the ability to degrade OTA to OTalpha (ochratoxinalpha). However, there were differences between the media used and species tested during OTA degradation. In SGM and CYB, 77% and 45% of the isolates, respectively were able to degrade more than 80% of the OTA. Despite a better growth on SGM, specific OTA degradation was higher on CYB for most of the isolates. Kinetic studies carried out on SGM with three black Aspergillus isolates all showed different OTA degradation rates. After 9 days of incubation, OTalpha had decreased, whereas an unknown compound appeared. A. niger could be the first interesting species for OTA detoxification processes, followed by A. japonicus.     

Specific detection of Aspergillus carbonarius by SYBR® Green and TaqMan® quantitative PCR assays based on the multicopy ITS2 region of the rRNA gene

Agroproducts contaminated by ochratoxin A (OTA) represent a risk for human and animal health and, therefore, maximum limits have been established by Food Safety Authorities. Reduction of OTA contamination may be accomplished by early detection of OTA-producing fungal species using rapid, specific and sensitive detection and quantification by PCR-based methods. Aspergillus carbonarius is one of the most important OTA-producing species, in particular in grapes and derivatives from Mediterranean regions. In this work, highly efficient quantitative PCR assays using SYBR Green I and TaqMan methods were developed for specific detection of A. carbonarius to be used in grapes. The primers and the TaqMan probe were based on the internal transcribed region 2 multicopy region (internal 2 sequence of the rRNA gene). The specificity and sensitivity of both assays were tested on genomic DNA mixtures of several A. carbonarius strains and other fungal species frequently present in grapes. Both methods were also compared using grapes inoculated with different spore concentrations of A. carbonarius , detecting up to 0.4 pg DNA g⁻¹ grape berries. The efficiency and sensitivity of both methods were comparable and only the lower cost of SYBR Green might favour its use in routine screenings.     

Partitioning of ochratoxin A in mycelium and conidia of Aspergillus carbonarius and the impact on toxin contamination of grapes and wine

AIMS: Aspergillus carbonarius is an important ochratoxin A (OTA)-producing fungus which is responsible for toxin contamination of grapes and wine. The objectives of this study were to examine the partitioning of OTA in mycelium and conidia of a range of A. carbonarius strains on artificial grape juice and defined media, to determine the excretion patterns of OTA from these spores, and the effect of organic acids used in wine production on OTA excretion from conidia. METHODS AND RESULTS: The results showed that 60-70% of the OTA was accumulated in the conidia of a number of different isolates of A. carbonarius. Calculations showed that on different defined media, an amount of 0.011- to 0.1-pg OTA was present per conidium. The OTA in spores was found to be rapidly excreted into the medium during the initial few hours after conidial germination leading to an increase of OTA in must during maceration for wine production. The presence of tartaric acid inhibited OTA production, but malic acid enhanced this production during mycelial growth. These acids were also shown to affect the time course of germination and the rate of OTA excretion from conidia during germination. CONCLUSIONS: This study is the first to examine and show the partitioning of OTA into spores of strains of A. carbonarius and that rapid excretion of OTA from spores could be a reason for OTA accumulation in musts during wine production. SIGNIFICANCE AND IMPACT OF THE STUDY: Conidia of A. carbonarius could be a major source of OTA contamination of grapes used in wine production. This information could help in the development of effective prevention strategies to minimize wine contamination with this important mycotoxin.     

OTA-producing fungi isolated from stored cocoa beans

Aims:  The aim of this study was to identify fungal populations in unroasted cocoa beans stored in Spain in order to evaluate the ochratoxin A (OTA)-production ability of certain Aspergillus isolates.
Methods and Results:  Twenty batches of cocoa beans from different origins and with different OTA content were selected for this study. Three Aspergillus carbonarius and 13 Aspergillus niger aggregate strains isolated from these cocoa bean samples were selected to evaluate their OTA synthesis ability, being the only A. carbonarius isolates which are OTA producers [−1 culture medium; LOD = 6  μ g kg⁻¹ culture medium].
Conclusions:  No correspondence was found between the OTA levels in cocoa beans and the presence of OTA-producing fungi. Nonetheless, some samples contained A. carbonarius with a high OTA-producing ability and, consequently, specific fungal controls should be set up during storage to avoid this toxin.
Significance and Impact of the Study:  Toxigenic fungi in cocoa beans are not well understood. This study attempted to identify these fungi and evaluate their OTA-producing ability.     

Polyaniline Langmuir-Blodgett film based aptasensor for ochratoxin A detection

Ochratoxin A (OTA) produced by Aspergillus Ochraceus and Penicillium verrucosum is a very dangerous toxin due to its toxic effects in human beings and its presence in a wide range of food products and cereals. A Langmuir-Blodgett (polyaniline (PANI)-stearic acid (SA)) film based highly sensitive and robust impedimetric aptasensor has been developed for ochratoxin A (OTA) detection. DNA Aptamer (Apt-DNA) specific to OTA has been covalently immobilized onto mixed Langmuir-Blodgett (LB) monolayer comprising of PANI-SA deposited onto indium tin-oxide (ITO) coated glass plates. This Apt-DNA/PANI-SA/ITO aptaelectrode has been characterized using scanning electron microscopy, Fourier transform-infrared spectroscopy, contact angle measurements, cyclic voltammetry and electrochemical impedance spectroscopy, respectively. The Apt-DNA/PANI-SA/ITO aptasensor shows detection of OTA by electrochemical impedance spectroscopy in the linear range of 0.0001 μg/ml (0.1 ng/ml) to 0.01 μg/ml (10 ng/ml) and 1 μg/ml-25 μg/ml with detection limit of 0.1 ng/ml in 15 min. The Apt-DNA/PANI-SA/ITO aptasensor can be reused ～13 times. The binding or affinity constant (K(a)) of aptamer with OTA, calculated using Langmuir adsorption isotherm, is found be 1.21×10(7) M(-1).     

Study of Spanish Grape Mycobiota and Ochratoxin A Production by Isolates of Aspergillus tubingensis and Other Members of Aspergillus Section Nigri

The native mycobiota of five grape varieties grown in Spain has been studied. Four (Bobal, Tempranillo, Garnacha, and Monastrell) were red varieties and one (Moscatel) was white. The main fungal genera isolated were Alternaria, Cladosporium, and Aspergillus. The isolation frequency of Aspergillus spp. section Nigri in contaminated samples was 82%. Ochratoxin A (OTA) production was assessed using yeast extract-sucrose broth supplemented with 5% bee pollen. Cultures of 205 isolates from this section showed that 74.2% of Aspergillus carbonarius and 14.3% of Aspergillus tubingensis isolates produced OTA at levels ranging from 1.2 to 3,530 ng/ml and from 46.4 to 111.5 ng/ml, respectively. No Aspergillus niger isolate had the ability to produce this toxin under the conditions assayed. Identification of the A. niger aggregate isolates was based on PCR amplification of 5.8S rRNA genes and its two intergenic spacers, internal transcribed spacer 1 (ITS1) and ITS2, followed by digestion with restriction endonuclease RsaI of the PCR products. The restriction patterns were compared with those from strains of A. niger CECT 2807 and A. tubingensis CECT 20393, held at the Spanish Collection of Type Cultures. DNA sequencing of the ITS1-5.8S rRNA gene-ITS2 region of the OTA-producing isolates of A. tubingensis matched 99 to 100% with the nucleotide sequence of strain A. tubingensis CBS 643.92. OTA determination was accomplished by liquid chromatography with fluorescence detection. OTA confirmation was carried out by liquid chromatography coupled to ion trap mass spectrometry. The results showed that there are significant differences with regard to the isolation frequency of ochratoxinogenic fungi in the different grape varieties. These differences were uncorrelated to berry color. The ability of A. tubingensis to produce OTA and the influence of grape variety on the occurrence of OTA-producing fungi in grapes are described in this report for the first time.     

The level of ochratoxin a in patients after nephrectomy

Ochratoxin A (OTA) was analyzed in human serum and kidney samples, collected in Poland in the Pomeranian region from March to September 2005. OTA was determined using reversed phase liquid chromatography with fluorescence detection. The collected samples were from patients after nephrectomy (9 from men and 11 from women) and control serum samples from people without kidney diseases (3 and 3, respectively). The mean concentration OTA in serum of the healthy group was 0.37 ng/ml in both men and women. In patients subjected to nephrectomy it reached 1.06 ng/ml in men and 0.94 ng/ml in women, the mean content of ochratoxin A in kidneys was 0.23 ng/g and 0.20 ng/g, respectively. The highest concentration of OTA in serum among the patients subjected to nephrectomy was 3.77 ng/ml in men and 2.27 ng/ml in women while in kidneys 0.45 ng/g and 0.39 ng/g, respectively. Presented at the 28^th Mykotoxin-Workshop, Bydgoszcz, Poland, May 29–31, 2006     

Incubation time and water activity effects on ochratoxin A production by Aspergillus section Nigri strains isolated from grapes

AIMS: The objective of this study was to determine the temporal ochratoxin A (OTA) accumulation profile of Aspergillus section Nigri at different water activity (aw) levels. METHODS AND RESULTS: Two Aspergillus carbonarius and two Aspergillus niger aggregate strains isolated from grapes were tested in vitro for OTA accumulation at 25 degrees C on synthetic nutrient medium, over periods of 20 days at different aw levels. Results were modelled by a multiple linear regression and response surface predictive models were obtained. High levels of aw favoured OTA production by these moulds. Maximum amounts of OTA were found at the earlier growth states (5 days for A. carbonarius and 7-13 days for A. niger aggregate). CONCLUSIONS: Provided that A. section Nigri, and mainly A. carbonarius, play the main role in OTA presence in grapes, it would be critical to adjust the harvest and processing time to significantly reduce the chances for OTA accumulation. SIGNIFICANCE AND IMPACT OF THE STUDY: Ochratoxin A production by A. section Nigri has been shown for the first time to occur optimally after as little as 5 days on a grape-like medium.     

Utilization of AFLP markers for PCR-based identification of Aspergillus carbonarius and indication of its presence in green coffee samples

AIMS: The objective of this work was to test whether ochratoxin A (OTA) production of Aspergillus niger and A. carbonarius is linked to a certain genotype and to identify marker sequences with diagnostic value aiding identification of A. carbonarius, a fungus of major concern regarding OTA production in food and food raw materials. METHODS AND RESULTS: Aspergillus niger and A. carbonarius were isolated mainly from Brazilian coffee sources. The ability of isolates to produce OTA was tested by thin layer chromatography (TLC). Strains were genetically characterized by AFLP fingerprinting and compared with each other and with reference strains. Cluster analysis of fingerprints showed clear separation of A. niger from A. carbonarius strains. To obtain marker sequences, AFLP fragments were isolated from silver stained polyacrylamide gels, cloned and sequenced. Sequences obtained were used to develop species- specific PCR primers for the identification of A. carbonarius in pure culture and in artificially and naturally infected samples of green coffee. CONCLUSIONS: No clear correlation between genetic similarity of the strains studied and their potential to produce OTA was found. The PCR assays designed are a useful and specific tool for identification and highly sensitive detection of A. carbonarius. SIGNIFICANCE AND IMPACT OF THE STUDY: The developed PCR assays allow specific and sensitive detection and identification of A. carbonarius, a fungus considered to be one of the major causative agents for OTA in coffee and grape-derived products. Assays may provide powerful tools to improve quality control and consumer safety in the food processing industry.     

Aspergillus carbonarius growth and ochratoxin A production on a synthetic grape medium in relation to environmental factors

AIMS: The effects of water activity (0.90-0.99 a(w)), temperature (15-37 degrees C), and their interaction on growth and ochratoxin A (OTA) production by eight isolates of Aspergillus carbonarius were investigated on synthetic nutrient medium (SNM) with composition similar to grapes. METHODS AND RESULTS: Growth data were modelled by an multiple linear regression and response surface models were obtained. Aspergillus carbonarius grew much faster at 30 degrees C than at the other temperature levels tested and its growth rate increased with increasing a(w), maximum growth rate being between 0.95 and 0.99 a(w). In general, isolates grew faster at 35-37 degrees C than at 20 degrees C, although no significant differences were found between these temperatures. OTA accumulation was also favoured by high a(w) levels, and although it was observed in the whole range of temperatures, maximum amounts were detected at 20 degrees C. No OTA was found at the most unfavourable growth conditions. CONCLUSIONS: Optimum a(w) level for growth seems to correspond with optimum for OTA production, meanwhile the most propitious temperature for the toxin production was below the best one for growth. SIGNIFICANCE AND IMPACT OF THE STUDY: Prediction of A. carbonarius growth would allow estimating their presence and therefore, the OTA production, as it was found that conditions for the toxin production were more limited than those permitting growth.     

Aspergillus ibericus: a new species of section Nigri isolated from grapes

As part of a study on the ochratoxin producing mycoflora of grapes, several Aspergillus strains were isolated and tested for their ochratoxin A (OTA) producing abilities. Aspergillus strains of the section Nigri, which did not produce detectable amounts of OTA but which had a similar morphology to A. carbonarius, were isolated from wine grapes and/or dried vine fruit in Portugal and Spain. These strains, however, have characters that allow morphological distinction from the other species in the section, particularly the conidia size (5-7 microm), which allows separation of the species from the two most common biseriate species in section Nigri: A. carbonarius (7-9 microm) and A. niger and its aggregate species (3-5 microm). The strains are described here as belonging to a new species, named A. ibericus. The validation of this new taxon is supported further by analysis of the ITS-5.8S rDNA and calmodulin gene sequences and by analysis of the amplified fragment length polymorphism (AFLP) patterns, which were consistent in separating these strains from other species in the section. A. ibericus strains do not produce OTA therefore they are interesting for biotechnological exploration because many metabolites with commercial value are produced by other species in the section.     

Effect of germicidal UVC light on fungi isolated from grapes and raisins

AIMS: To examine how UVC affects the different genera of fungi commonly isolated from grapes, with the aim of understanding changes in mycobiota during grape ripening and possible applications for preventing grape decay during storage. METHODS AND RESULTS: Spores of Aspergillus carbonarius, Aspergillus niger, Cladosporium herbarum, Penicillium janthinellum and Alternaria alternata (between 100-250 spores/plate agar) were UVC irradiated for 0 (control), 10, 20, 30, 60, 300 and 600 s. Plates were incubated at 25 degrees C and colonies were counted daily up to 7 days. Alternaria alternata and Aspergillus carbonarius were the most resistant fungi. Conidial germination in these species was reduced by approx. 25% after 10 s of exposure, compared with greater than 70% reduction for the remaining species tested. Penicillium janthinellum spores were the most susceptible at this wavelength. UVC exposures of 300 s prevented growth of all isolates studied, except for Alternaria alternata. CONCLUSIONS: UVC irradiation plays a major role in selecting for particular fungi that dominate the mycobiota of drying grapes. SIGNIFICANCE AND IMPACT OF THE STUDY: The UVC irradiation of harvested grapes could prevent germination of contaminant fungi during storage or further dehydration.