Comparative study of amylolytic enzymes production byAspergillus niger in liquid and solid-state cultivation

Summary Amylolytic enzymes produced by a strain ofAspergillus niger cultivated on cassava starch in liquid or solid culture were found to be mainly glucoamylases. For the same initial amount of substrate, the glucoamylase activity increased even after 60 h of culture on solid medium whereas it decreased in liquid culture. Some characteristics of the amylases produced in both culture conditions were compared. The pH optima for enzymes produced in solid and liquid cultures were 4.5 and 5.0 respectively. Glucoamylase synthetized in solid cultures was significantly more thermostable than that from liquid culture and was maximally active at 70°C compared to 50°C for the enzyme from liquid cultures. The Km values expressed as mg soluble starch/100 ml were 0.1% for crude enzyme from solid culture and 0.057% for crude enzyme from liquid culture.     

Aerobiological,biochemical and immunological studies on some of the dominant <Emphasis Type="Italic">Aspergillus</Emphasis> species of South Assam (India)

Two years atmospheric survey of air-borne Aspergillus was carried out in the environmental conditions of South Assam. The survey revealed a total of 16 different species of Aspergillus with marked seasonal and annual variations. Aspergillus fumigatus was found to be the dominant atmospheric fungal species followed by Aspergillus flavus, Aspergillus niger, etc. Among the sample extracts tested, highest quantity of soluble protein was recorded in Aspergillus fumigatus (95.0 mg/g) whereas highest quantity of soluble carbohydrate (40.8 mg/g) and free amino acid (135.0 mg/g) was recorded in the sample extract of Aspergillus niger per gram of dry weight, respectively. The highest numbers of protein polypeptide bands were detected in the sample extract of Aspergillus fumigatus followed by Aspergillus flavus and lowest in Aspergillus niger. The maximum numbers of immunoglobulin E binding protein fractions were found in Aspergillus fumigatus, followed by Aspergillus flavus, Aspergillus clavatus, etc.     

Production of amylase by a submerged culture ofAspergillus wentii

Soluble starch was hydrolysed to maltose byAspergillus wentii Wehmer (IMI 17295). Studies on nutritional requirements ofAspergillus wentii for production of amylase revealed that the optimum conditions were achieved in fermentation culture medium containing 1% starch, and incubated at 20 °C for 3 days at pH 6.0. Tryptophan was the best nitrogen source. The amylase activity was completely inhibited when 1 mm sodium iodoacetate was incorporated into the medium. With 10 mm sodium citrate the amylase activity was increased from 3.51 to 6.0 mg/ml.     

Comparison of four media for the isolation ofAspergillus flavus group fungi

Four agar media used to isolate aflatoxin producing fungi were compared for utility in isolating fungi in theAspergillus flavus group from agricultural soils collected in 15 fields and four states in the southern United States. The four media wereAspergillus flavus andparasiticus Agar (AFPA, 14), the rose bengal agar described by Bell and Crawford (BCRB; 3), a modified rose bengal agar (M-RB), and Czapek's-Dox Agar supplemented with the antibiotics in BC-RB (CZ-RB). M-RB was the most useful for studying the population biology of this group because it permitted both identification of the greatest number ofA. flavus group strains and growth of the fewest competing fungi. M-RB supported an average of 12% moreA. flavus group colonies than the original rose bengal medium while reducing the number of mucorales colonies and the number of total fungi by 99% and 70%, respectively. M-RB was successfully employed to isolate all three aflatoxin producing species,A. flavus, A. parasiticus andA. nomius, and both the S and L strains ofA. flavus. M-RB is a defined medium without complex nitrogen and carbon sources (e.g. peptone and yeast extract) present in BC-RB. M-RB should be useful for studies on the population biology of theA. flavus group.Abbreviations M-RB Modified Rose Bengal Agar - CZ-RB Czapeks Rose Bengal Agar - BC-RB Bell and Crawford's Rose Bengal Agar - AFPA Aspergillus flavus andparasiticus agar     

A rapid identification method for aflatoxin-producing strains ofAspergillus flavus andA. parasiticus by ammonia vapor

The colony reverse of aflatoxin (AF)-producing strains ofAspergillus flavus andA. parasiticus turned pink when their cultures were exposed to ammonia vapor. The color change was visible for colonies grown on media suitable for AF production such as potato dextrose, coconut, and yeast extract sucrose agars after 2 d incubation at 25°C. Of the 120 strains ofA. flavus, A. parasiticus, and two related species inA. flavus group:A. oryzae andA. sojae tested in this study, only the AF-producing strains ofA. flavus andA. parasiticus showed the pink pigmentation. The color change occurred immediately after the colony was contacted with ammonia vapor. This method was useful for rapid screening the AF-producing strains ofA. flavus andA. parasiticus.     

The 53-kDa proteolytic product of precursor starch-hydrolyzing enzyme of Aspergillus niger has Taka-amylase-like activity

The 53-kDa amylase secreted by Aspergillus niger due to proteolytic processing of the precursor starch-hydrolyzing enzyme was resistant to acarbose, a potent α-glucosidase inhibitor. The enzyme production was induced when A. niger was grown in starch medium containing the inhibitor. Antibodies against the precursor enzyme cross-reacted with the 54-kDa Taka-amylase protein of A. oryzae. It resembled Taka-amylase in most of its properties and also hydrolyzed starch to maltose of α-anomeric configuration. However, it did not degrade maltotriose formed during the reaction and was not inhibited by zinc ions.     

Enhancement of anthocyanin production in callus cultures ofDaucus canota L. under the influence of fungal elicitors

Aqueous extracts of fungal biomass ofAspergillus niger, A. flavus, Penicillium notatum, Fusarium oxysporum and the filtrates of their culture media were analysed for elicitation capability to enhance anthocyanin production in callus cultures ofDaucus carota. The mycelial extract ofA. flavus at the 2.5% level gave maximum elicitation, which resulted in a two-fold increase in anthocyanin with maximal productivity of 23.7% on a dry weight basis. Whereas the media filtrates ofA. flavus induced a 1.25-fold increase in anthocyanin production with a yield of 20.6% on a dry weight basis,P. notatum andF. oxysporum were not as effective asA. flavus orA. niger. The contact time and the concentration required for maximal elicitation of anthocyanin differed with the type of elicitor used. Qualitative analysis of anthocyanins revealed the presence of cyanidin glycosides in control and elicited cultures.     

Behaviour of Aspergillus flavus in presence of Aspergillus niger during biosynthesis of aflatoxin B1

Aspergillus niger or Aspergillus tamarii when grown as mixed cultures with toxigenic A. flavus inhibits biosynthesis of aflatoxin by A. flavus, owing primarily to its ability to produce inhibitors of aflatoxin biosynthesis and to their ability to degrade aflatoxin. Gluconic acid partly prevents aflatoxin production. The other factors such as changes in pH of the medium and the effect on the growth of A. flavus have no role in imparting capabilities to these cultures to inhibit aflatoxin production by A. flavus.     

Saccharification of cassava peels waste for microbial protein enrichment

Cassava waste peels may constitute up to 55% of the original tuber. These waste peels were found to contain 41.8% carbohydrate, 1.1% protein, 12.5% ether extract and 4.9%, 4.9% total ash. and 20.8% crude fibre. Studies were conducted to formulate a fermentation medium to convert the waste peels to reducing sugars and to enrich the peels with microbial protein. Amylase producing microorganisms were isolated from rotten cassava tuber discs buried in the soil at different locations. The microorganisms isolated were Aspergillus fumigatus, A. flavus, A. niger, and a Pseudomonas sp. and A. niger; the level of reducing sugar was 20.5 mg/ml. The lowest was by B. subtilis an isolate from fermenting locust bean. Generally the levels of saccharification were higher when the waste media were supplemented with different nitrogen sourses. The crude protein yield in the cassava peel waste media by different microorganisms varied from 5.6% to 17.5%. The highest protein yield was in the waste medium fermented by A. fumigatus followed by A. niger, B. subtilis, Pseudomonas sp. in decreasing order.     

A preliminary study on the suitability of gum arabic as medium for fungal growth

Summary AlthoughRhizopus stolonifer, Aspergillus niger andRhizoctonia solani could be grown on gum arabic solutions of 1–4% concentrations, yet their growth was poor presumably due to lack of sufficient nitrogen. Gum arabic was found to be a good carbon source when it replaced sucrose in Czapek-Dox medium. The sporulation ofRhizopus was not affected by the presence of gum in the medium, while that ofAspergillus was appreciably affected. The number of sporulating heads was reduced, irregularity in the shape of the head due to variation in the length of spore chains was also noticed. A new medium of pH 5.6 was found satisfactory for fungal growth and could be recommended for soil isolations. Its composition is: 4% gum arabic, 1% peptone, 0.025% sodium chloride and 0.001% ferrous sulphate.     

柚子皮黑曲霉的分离鉴定及产酶特性研究

对柚子皮上自然生长的黑曲霉进行分离鉴定,并探讨其产酶特性。以平板稀释法从柚子皮上分离出一株霉菌菌株,通过观察其形态特征和培养特征,对照《真菌鉴定手册》判定该菌株的种属;采用鉴定培养基法对其产酶特性进行分析。根据柚子皮的成分特性,以干柚子皮为主要原料,该菌为生产菌株,采用固态发酵法探究培养基的成分、柚子皮含量、培养基初始含水量及发酵时间4个因素对纤维素酶活力的影响。结果表明,该菌株为黑曲霉(Aspergillus nige),可产淀粉酶、蛋白酶、纤维素酶、果胶酶;固态发酵培养基中添加柚子皮12g,麸皮0.5 g和(NH_4)_2SO_40.5 g,培养基初始含水量保持在68.5 mL/100 g,培养时间控制在60 h左右时纤维素酶产量较高。     

Citric acid production byAspergillus niger using media containing low concentrations of glucose or corn starch

By using an appropriate ratio of carbon source to mineral components, we obtained comparable citrate yields in media containing different concentrations of glucose. The enzyme system of inoculum passed on gradually from “growth” state to “production” state during the mould growth. In the starch medium, the critical factors of citric acid production are the aeration efficiency of the medium and the amylase formation of the strain. The air interruption exhibited a prolonged inhibition of the production rate but not of the citrate yield in glucose medium while those parameters in starch medium containing excessive urea were briefly but severely inhibited. After being affected by these unfavorable conditions, the production activity ofAspergillus niger could be restored by applying an appropriate fermentation process.     

Production of extracellular enzymes and aflatoxins in solid substrate fermentation with aflatoxigenic<Emphasis Type="Italic">Aspergillus</Emphasis> spp.

AflatoxigenicAspergillus flavus andAspergillus parasiticus were subjected to solid substrate fermentation process for 6 days to determine the formation of aflatoxins and production of extracellular enzymes (amyloglucosidase, cellulase, invertase and proteinase). Both organisms produced enzymes which generally increased with fermentation.Aspergillus flavus produced four enzymes whereasA. parasiticus produced three with no proteinase activity.Aspergillus parasiticus produced aflatoxins B₁, B₂ and G₁ but no G₂ andA. flavus produced aflatoxins B₁ and B₂. Invertase showed the highest activity withA. parasiticus and that corresponded with the highest total toxin produced. The enzyme activities were higher withA. parasiticus thanA. flavus although total toxins produced byA. parasiticus were lower than total toxins produced byA. flavus under the same environmental conditions.     

Production of ethanol from raw cassava starch by a nonconventional fermentation method

Raw cassava root starch was transformed into ethanol in a one-step process of fermentation, in which are combined the conventional processes of liquefaction, saccharification, and fermentation to alcohol. Aspergillus awamori NRRL 3112 and Aspergillus niger were cultivated on wheat bran and used as Koji enzymes. Commercial A. niger amyloglucosidase was also used in this experiment. A raw cassava root homogenate–enzymes–yeast mixture fermented optimally at pH 3.5 and 30°C, for five days and produced ethanol. Alcohol yields from raw cassava roots were between 82.3 and 99.6%. Fungal Koji enzymes effectively decreased the viscosity of cassava root fermentation mashes during incubation. Commercial A. niger amyloglucosidase decreased the viscosity slightly. Reduction of viscosity of fermentation mashes was 40, 84, and 93% by commercial amyloglucosidase, A. awamori, and A. niger enzymes, respectively. The reduction of viscosity of fermentation mashes is probably due to the hydrolysis of pentosans by Koji enzymes.     

Mycotoxigenic infestation in samples of cereal straw from Bihar, India

A survey of different types of cereal straw samples viz. paddy, maize and wheat, from Bihar State, India, was conducted in order to examine the mould flora and mycotoxin contamination. Out of 170 samples examined for mould flora,Aspergillus flavus group of fungi had highest level of incidence followed byA niger. Isolates ofA flavus, A ochraceus, Fusarium verticillioides andPenicillium citrinum were screened for their mycotoxins producing abilities. Out of 75, 63 and 68 isolates ofA flavus group obtained from stored straw of paddy, maize and wheat samples, respectively, 27 (36%), 14 (22%) and 24 (35%) were found to be toxigenic which produced different combinations of aflatoxins in different concentrations. The percentage toxigenicity was comparatively lower in the isolates of other mycotoxigenic fungi from all types of samples. Out of 222 samples of straw analysed for natural occurrence of different mycotoxins, besides the aflatoxins present, zearalenone, ochratoxin A and citrinin were also recorded alone or as co-contaminants. A conducive climate together with the socioeconomic conditions of this region are important determinants for the high incidence of mycotoxins in cereal straw samples.     

Bacterial and fungal metabolites of rhizospheric microflora of cotton antagonistic to Rhizoctonia solani Kühn

Summary Growth response ofRhizoctonia solani Kühn, the damping-off fungus, to metabolites of selected antagonistic rhizospheric bacteria and fungi of some Egyptian cotton varieties, namely, two strains ofBacillus subtilis Cohn,Aspergillus terreus Thom, andAspergillus flavus Link produced in culture media containing nitrate- or ammonium-nitrogen sources, proved the potency ofB. subtilis metabolites in inhibitingR. solani mycelial growth whether from nitrate- or ammonium-nitrogen culture media. Metabolite filtrates ofB. subtilis (II) are more potent than those ofB. subtilis (I). Increasing concentration of bacterial metabolite filtrates resulted in a decreased mycelial dry weight ofR. solani. The bacterial inhibitory factor forR. solani mycelial growth is partially affected by heat. Metabolite filtrates ofA. terreus from nitrate-nitrogen are slightly more potent than from ammonium-nitrogen culture media while an opposite relation is evident withA. flavus metabolites. Growth responses ofR. solani to different experimental dilutions of metabolite filtrates ofA. terreus andA. flavus proved the intervention of the nutritive factor in witholding growth of the damping-off fungus.     

Fungi associated with dried fish in Sri Lanka

The mycoflora of dried-salted fish from markets in Kandy, Sri Lanka was studied with emphasis on visibly spoiled dried fish. A total of 61 fungal isolates from 25 dried-fish were isolated and identified. The most prevalent fungus wasAspergillus niger. Species ofAspergillus flavus, A. fumigatus, A. glaucus, A. restrictus, Aureobasidium spp.Basipetospora halophila (a genuinely halophilic fungus)Cladosporium herbarum, Gliomastix, spp.,Penicillium chalybeum andPenicillium expansum were present. The isolated fungi did not grow in synthetic media containing more than 30% sodium chloride.Aureobasidium spp. andGliomastix spp. did not grow on dried-fish under laboratory conditions. The protective exoskeleton appeared to prevent fungal growth on dried shrimp. TheA. flavus strains isolated were not aflatoxigenic.     

A study of cornstarch granule digestion by an unusually high molecular weightα-amylase secreted byLactobacillus amylovorus

The cells ofLactobacillus amylovorus (NRRL B-4540), grown in a medium containing 2% cornstarch as the sole carbon source, secreted an amylase activity that rapidly solubilized cornstarch. Fourier transform infrared (FTIR) spectroscopic analyses showed that 80–90% of starch was consumed by bacteria in a 10-day-old culture medium. The remnant of starch granules digested in the culture medium inoculated with the cells ofL. amylovorus have also lost their characteristic iodine-binding capacity as visualized by starch dye-binding microplate assay and light microscopy. Scanning electron miscroscopy (SEM) of granules from a 48-h culture medium showed hollow and fragmented granules with a pitting phenomenon characteristically produced by-amylase activity. Analysis of an enzyme preparation from a culture medium ofL. amylovorus revealed that the putative enzyme appears to be a single protein band of unusually high M_r (150,000) on SDS gels stained for amylase activity. Analysis of starch digestion products by thin layer chromatography (TLC) showed enzyme activity typical of-amylase.The mention of firm names or trade products does not imply that they are endorsed or recommended by the U.S. Department of Agriculture over other firms or similar products not mentioned.     

Effect of some common rhizosphere fungi on root growth of seedlings

Summary The effect of some common rhizosphere fungiviz Aspergillus niger, A. terreus, A. flavus, Fusarium nivale, Cunninghamella echinulata, Trichoderma viride andPaecilomyces fusisporus on the root growth of seedlings ofDichanthium annulatum andSetaria glauca was studied. The seedlings grown in modified Crone's nutrient medium were inoculated with the test fungi. In uninoculated control tubes, seedlings showed normal root growth. The different fungi exceptF. nivale were found to reduce root growth considerably. WithA. niger besides reduction in root length, the leaves of the seedlings were found to turn yellow. The reduction in root growth in the presence of fungi was statistically significant.     

Production of a raw starch saccharifying amylase byBacillus alvei grown on different agricultural substrates

Maximum activity of the amylase ofBacillus alvei was attained after growth of the organism on sorghum starch. Rice, corn, yam, cassava and potato starch gave high enzyme activities as did soluble starch. Glucose, maltose and glycerol were less effective. Optimum conditions for both growth and enzyme production were pH 6.8 at 40°C.