溶剂稳定性蛋白酶产生菌的筛选和鉴定

自油污土样等样品中分离获得一株具有产胞外溶剂稳定性蛋白酶的耐有机溶剂极端微生物,经BIOLOG系统鉴定及16S rDNA序列(GenBank,EF105377)分析,该菌株为Bacillus licheniformis YP1。该菌株能耐受中浓度盐、强碱性环境(pH12)及多种不同浓度的有机溶剂,但对多种抗生素敏感。在YP1产蛋白酶发酵过程中添加各种有机溶剂结果表明,丙酮虽抑制了菌体生物量的生长却促进了单位菌体的蛋白酶分泌,而长链烷醇如辛醇、十二醇等能强烈抑制该蛋白酶的分泌。该菌株所产蛋白酶经11种50%(V/V)有机溶剂处理后均能保留高活力。该溶剂稳定性蛋白酶在有机相生物催化等领域具有良好的应用前景。     

Screening and isolation of an organic solvent-tolerant bacterium for high-yield production of organic solvent-stable protease

Forty-three strains were screened from crude oil-contaminated samples by toluene and cyclohexane enrichment in medium. Ten of these strains demonstrated high protease activity on skim-milk agar. Among them, the PT121 isolate, identified as Pseudomonas aeruginosa, was selected based on its extracellular protease stability in the presence of hydrophilic organic solvents. The crude protease also retained most of its activity up to at least 14 days in the presence of various organic solvents at 50% concentration, and the protease activity in production medium was 10,876U/ml after 72h incubation. This protease showed high activity as a catalyst for aspartame precursor Cbz-Asp-Phe-NH2 synthesis in the presence of 50% dimethylsulfoxide (DMSO).     

Highly soluble expression and molecular characterization of an organic solvent-stable and thermotolerant lipase originating from the metagenome

A novel organic solvent-stable and thermotolerant lipase gene (designated ostl28) was cloned from a metagenomic library and overexpressed in Escherichia coli BL21 (DE3) in soluble form. OSTL28 contained 262 amino acids with relative molecular mass 30.1 kDa and isoelectric point 9.7. The optimum pH and temperature of the OSTL28 were 7.5 and 60 °C, respectively. OSTL28 was stable in the pH range of 4.5–9.5 and at temperatures below 65 °C. The enzyme could hydrolyze a wide range of ρ-nitrophenyl esters, but its best substrate is ρ-nitrophenyl laurate with the highest activity of 236 U/mg (54,000 U/L). The recombinant OSTL28 was highly resisted to organic solvents, especially glycerol and methanol. The metal ions, with the exception of Hg²⁺ and Ag⁺, did not have any influence on enzyme activity, whereas non-ionic surfactants and Al³⁺ slightly activated the enzyme. These features indicate that it is a potential biocatalyst for biodiesel production.     

Cloning and expression of gene, and activation of an organic solvent-stable lipase from Pseudomonas aeruginosa LST-03

Organic solvent-tolerant Pseudomonas aeruginosa LST-03 secretes an organic solvent-stable lipase, LST-03 lipase. The gene of the LST-03 lipase (Lip9) and the gene of the lipase-specific foldase (Lif9) were cloned and expressed in Escherichia coli. In the cloned 2.6 kbps DNA fragment, two open reading frames, Lip9 consisting of 933 nucleotides which encoded 311 amino acids and Lif9 consisting of 1,020 nucleotides which encoded 340 amino acids, were found. The overexpression of the lipase gene (lip9) was achieved when T7 promoter was used and the signal peptide of the lipase was deleted. The expressed amount of the lipase was greatly increased and overexpressed lipase formed inclusion body in E. coli cell. The collected inclusion body of the lipase from the cell was easily solubilized by urea and activated by using lipase-specific foldase of which 52 or 58 amino acids of N-terminal were deleted. Especially, the N-terminal methionine of the lipase of which the signal peptide was deleted was released in E. coli and the amino acid sequence was in agreement with that of the originally-produced lipase by P. aeruginosa LST-03. Furthermore, the overexpressed and solubilized lipase of which the signal peptide was deleted was more effectively activated by lipase-specific foldase.     

Screening and identification of a novel lipase from Burkholderia sp. YY62 which hydrolyzes t-butyl esters effectively

Fatty acid esters composed of sterically hindered alcohol are very poor substrates for known lipases. In order to obtain a novel lipase, t-butyl octanoate (TBO) was selected as a model substrate to screen for bacteria-producing lipase(s) which can preferentially hydrolyze bulky esters. Of 279 strains isolated from 350 soil samples based on the ability to grow with TBO as a sole carbon source, one strain (YY62) was chosen for its strong TBO-hydrolyzing activity. Strain YY62 is a Gram-negative motile rod and was identified as Burkholderia sp. from the taxonomic characters and phylogenetic analysis of 16S rDNA nucleotide sequences. Using the activity ratio between TBO and p-nitrophenyl acetate as a measure for preference to bulky esters, we confirmed that the lipase of strain YY62 was 100-fold superior to commercial lipases in terms of TBO-hydrolyzing activity.     

Screening of filamentous fungi for lipase production: Hypocrea pseudokoningii a new producer with a high biotechnological potential

Abstract

Filamentous fungi isolated from soil samples were screened for extracellular lipase production. The best producer was Hypocrea pseudokoningii identified by taxonomical criteria, and by rDNA sequencing of the variable internal transcribed spacers (ITS I and II) and the intervening 5.8S gene. The fungus was grown in a complex medium supplemented with 1% Tween 80 and 0.2% yeast extract, for 4 days. The optimum pH for extracellular and intracellular lipases was 7.0 and 8.0, respectively. Both enzymes exhibited maximum activity at 40°C. Extracellular and intracellular lipase activities were highly stable in the pH range 3.0–8.0 at room temperature. The intracellular lipase was thermostable up to 60°C, for 15 min and the extracellular, for 107 min, at the same temperature. The intracellular lipase was stimulated by silver ions. Extracellular lipase was stable in organic solvents, such as DMSO, alcohols, acetone, and acetonitrile, for 24 hours. Lipase activity increased around 80% when detergents were added to the enzymatic assay, such as Tween 80, Triton X-100, and SDS.     

Cytophysiology of Penicillium solitum: a producer of lipase

The cell population of Penicillin solitum was studied during maximum accumulation of lipase in the medium with electron microscopic and immunofluorescence methods. The data provided a conclusion that 2 types of lypolytic enzymes with various substrate and antigenic characteristics formed in the cells of P. solitum. It is likely that there is a specific inductor for exolipase synthesis as well as relationship endoenzymatic systems.     

Screening and identification of a novel esterase EstPE from a metagenomic DNA library

Esterases represent a large family of hydrolases with broad substrate specificity and functional sequence space. Although many attempts to screen new esterases have been conducted, there have been few reports conducted to discriminate unique enzymes from typical ones based on novel structure and function. In this study, we discovered an esterase and a novel family through a successive assay of whole cells and crude lysates (oxidative open condition). The screened putative esterases from the metagenomic DNA of salted shrimp consisted of 753 bp encoding 27 kDa of polypeptide, namely PE esterase. Sequence analyses revealed that an identical gene was reported from whole genome sequencing of Stenotrophomonas maltophilia K279a. However, its biochemical and phylogenetic characteristics have not yet been evaluated. PE esterase was overexpressed only by the MBP fusion state in E. coli and was easily purified using an affinity column. This enzyme showed a typical spectrum of substrate specificity and possessed the consensus motifs, Ser-Asp-His and GXSXG, which are essential for most esterase/lipase superfamilies. Interestingly, the entire organization of the ORF and consensus sequence around the active site were distinct from the related enzymes, and its structure could be affected by a reducing agent, DTT.     

Purification and characterization of thermostable organic solvent-stable protease from Aeromonas veronii PG01

A mesophilic bacterium, Aeromonas veronii PG01, isolated from industrial wastes produced an extracellular thermostable organic solvent tolerant protease. The optimum condition for cell growth and protease production was pH 7.0 and 30 °C. The protease produced was purified 53-fold to homogeneity with overall yield of 32%, through ammonium sulphate precipitation, ion-exchange and gel permeation chromatography (GPC). The molecular weight, as determined by GPC–HPLC, was found to be about 67 kDa. SDS-PAGE revealed that the enzyme consisted of two subunits, with molecular weight of 33 kDa. The protease was active in broad range of pH from 6.0 to 10.0 with optimum activity at pH 7.5. The optimum temperature for this protease was 60 °C. The enzyme remained active after incubation at 50–60 °C for 1 h. This enzyme was stable and active after incubation with benzene and it was activated 1.3- and 1.5-fold by n-hexane and n-dodecane, respectively. This protease was inhibited completely by the classic metalloprotease inhibitor 1,10-phenanthroline and partially by the metal chelator EDTA but not by the serine protease inhibitor PMSF. The PG01 protease was found to contain 1.901 mol of zinc per mole of enzyme upon analysis by Inductively coupled plasma-optical emission spectroscopy. The thermostable and solvent tolerance property make it an attractive and promising biocatalyst for enzyme mediated synthesis.     

Purification and characterization of a novel organic solvent-tolerant and cold-adapted lipase from Psychrobacter sp. ZY124

By screening 25 different psychrophilic strains isolated from the Arctic habitat, we isolated a strain capable of producing lipase. We identified this strain as Psychrobacter sp. ZY124 based on the amplified 16S rDNA sequence. The lipase, named as Lipase ZC12, produced from the supernatant of Psychrobacter sp. ZY124 cultured at 15 °C was purified to homogeneity by ammonium sulfate precipitation followed by Phenyl Sepharose FF gel hydrophobic chromatography. Based on the obtained amino acid sequence, Lipase ZC12 is classified as a member of the Proteus/psychrophilic subfamily of lipase family I.1; it has a molecular weight of 37.9 kDa. We also determined that the apparent optimum temperature for Lipase ZC12 activity is 40 °C. Lipase ZC12 shows remarkable organic solvent tolerance by remaining more 50% after incubated with 10–90% different organic solvents. In addition, acyl chain esters with C12 or longer were confirmed to be preferable substrates for Lipase ZC12. Lipase ZC12 also shows better stereoselectivity for (R, S)-1-phenylethanol chiral resolution in n-hexane solvent with (S)-1-phenylethanol (ee_p 92%) and conversion rate (39%) by transesterification reactions. These properties may provide potential applications in biocatalysis and biotransformation in non-aqueous media, such as in detergent, transesterification or esterification and chiral resolution.

     

A novel organic solvent tolerant lipase from Bacillus sphaericus 205y: extracellular expression of a novel OST-lipase gene

An organic solvent tolerant (OST) lipase gene from Bacillus sphaericus 205y was successfully expressed extracellularly. The expressed lipase was purified using two steps purification; ultrafiltration and hydrophobic interaction chromatography (HIC) to 8-fold purity and 32% recovery. The purified 205y lipase revealed homogeneity on denaturing gel electrophoresis and the molecular mass was at approximately 30 kDa. The optimum pH for the purified 205y lipase was 7.0-8.0 and its stability showed a broad range of pH value between pH 5.0 to 13.0 at 37 degrees C. The purified 205y lipase exhibited an optimum temperature of 55 degrees C. The activity of the purified lipase was stimulated in the presence of Ca2+ and Mg2+. Ethylenediaminetetraacetic acid (EDTA) has no effect on its activity; however inhibition was observed with phenylmethane sulfonoyl fluoride (PMSF) a serine hydrolase inhibitor. Organic solvents such as dimethylsulfoxide (DMSO), methanol, p-xylene and n-decane enhanced the activity. Studies on the effect of oil showed that the lipase was most active in the presence of tricaprin (C10). The lipase exhibited 1,3 positional specificity. Keywords: Bacter     

一株产生淀粉分解酶犁头霉的分离鉴定及其酶学性质

从保宁麸醋醋曲中定向筛选得到一株产生淀粉分解酶的菌株CQB43,其酶活力为105.2 U/mL,RDA值达到27.9%。通过形态观察和分子生物学鉴定确定该菌株为伞枝犁头霉Absidia corymbifera。对该菌株分泌生淀粉酶酶学性质的研究结果表明,该酶在pH为4.0-5.6的范围相对稳定,最适pH是5.0;在60°C以下的范围内具有较好的热稳定性,最适作用温度为40°C。研究金属离子对其活力影响的结果表明,Co2+对该生淀粉糖化酶有激活作用,Fe3+和Ca2+对该酶有抑制作用。     

Determination of lipoprotein lipase activity using a novel fluorescent lipase assay

A novel, real-time, homogeneous fluorogenic lipoprotein lipase (LPL) assay was developed using a commercially available substrate, the EnzChek lipase substrate, which is solubilized in Zwittergent. The triglyceride analog substrate does not fluoresce, owing to apposition of fluorescent and fluorescent quenching groups at the sn-1 and sn-2 positions, respectively, fluorescence becoming unquenched upon release of the sn-1 BODIPY FA derivative following hydrolysis. Increase in fluorescence intensity at 37°C was proportional to LPL concentration. The assay was more sensitive than a similar assay using 1,2-O-dilauryl-rac-glycero-3-glutaric acid-(6-methylresorufin ester) and was validated in biological samples, including determination of LPL-specific activity in postheparin mouse plasma. The simplicity and reproducibility of the assay make it ideal for in vitro, high-throughput screening for inhibitors and activators of LPL, thus expediting discovery of drugs of potential clinical value.     

一株降解煤油菌株的筛选与鉴定

本文通过从污水处理厂活性污泥中分离得到一株高效降解轻油(煤油)细菌5092-2,通过形态学、16S rRNA鉴定该菌为Mangroveibacter sp.。进一步对其生长条件进行了研究,发现该菌在23℃到38℃、pH为5.0到9.0范围内生长无明显差异。在温度为35℃,pH 7.2~7.4,160 r/min培养7 d,菌株降解煤油的能力达到52.3%,具有进一步研究的价值。     

Role of intermolecular disulfide bonds of the organic solvent-stable PST-01 protease in its organic solvent stability

The PST-01 protease is secreted by the organic solvent-tolerant microorganism Pseudomonas aeruginosa PST-01 and is stable in the presence of various organic solvents. Therefore, the PST-01 strain and the PST-01 protease are very useful for fermentation and reactions in the presence of organic solvents, respectively. The organic solvent-stable PST-01 protease has two disulfide bonds (between Cys-30 and Cys-58 and between Cys-270 and Cys-297) in its molecule. Mutant PST-01 proteases in which one or both of the disulfide bonds were deleted were constructed by site-directed mutagenesis, and the effect of the disulfide bonds on the activity and the various stabilities was investigated. The disulfide bond between Cys-270 and Cys-297 in the PST-01 protease was found to be essential for its activity. The disulfide bond between Cys-30 and Cys-58 played an important role in the organic solvent stability of the PST-01 protease.     

Screening and characterization of trehalose-oleate hydrolyzing lipase

Various soil samples were collected to screen the presence of microorganisms which have ability to degrade TOE. One strain (AKU-883) with good TOE degrading activity was isolated and identified as Burkholderia cepacia and the extracellular enzyme was purified to homogeneity. The purification was achieved by ultrafiltration, Super Q anion-exchange chromatography and Superdex 200HR gel-filtration in the presence of Triton X. The enzyme was purified to 85-fold, and specific activity of 4.910 kU mg protein(-1). The peak preparation on gel filtration showed a single band of 34 kDa on SDS-PAGE and native PAGE which indicate the monomeric nature of the enzyme. The pI of the enzyme was 6.3. The enzyme showed the maximum activity at pH 9 and 65 degrees C, and was stable in the range of pH 5--10 and up to 60 degrees C. Almost all the activity (92%) was kept after incubation for more than 1 week at 50 degrees C (pH 7.3). High activities remained even in water-miscible solvents such as ethanol, dimethyl formamide, diisopropyl ether, and dioxane. The N-terminal 16 amino acid residues were determined as A-N-G-Y-A-A-T-R-Y-P-I-I-L-V-G-G, which showed a consensus sequence for lipases from Burkholderia species. Thus the enzyme was concluded to be a kind of lipase.     

Screening and catalytic activity in organic synthesis of novel fungal and yeast lipases

A total of 969 microbial strains were isolated from soil samples and tested to determine their lipolytic activity by employing screening techniques on solid and in liquid media. Ten lipase-producing microorganisms were selected and their taxonomic identification was carried out. From these strains Achremonium murorum, Monascus mucoroides, Arthroderma ciferri, Fusarium poae, Ovadendron sulphureo-ochraceum and Rhodotorula araucariae are described as lipase-producers for the first time. Hydrolysis activity of the crude lipases against both tributyrin and olive oil was measured. Heptyl oleate synthesis was carried out to test the activity of the selected lipases as biocatalysts in organic medium. All the selected lipases were tested as biocatalysts in several organic reactions using unnatural substrates. Lipases from the fungi Fusarium. oxysporum and O. sulphureo-ochraceum gave the best yields and enantioselectivities in the esterification of carboxylic acids. F. oxysporum and Penicillium chrysogenum lipases were the most active ones for the acylation of alcohols without steric hindrance. A. murorum lipase is very useful for the esterification of menthol. F. oxysporum and Fusarium. solani lipases were very stereoselective in the synthesis of carbamates.     

D-Aminoacylase from a novel producer: Stenotrophomonas maltophilia ITV-0595

A novel bacterial strain producing D-aminoacylase was isolated from organic waste and identified as Stenotrophomonas maltophilia ITV-0595. The isolation was performed using N-acetyl-D-phenylglycine (NAcDPG) as the sole source of C and N. The optimum pH for enzyme expression was 8 at 37°C. Using N-Ac-DPG concentrations from 0.5 up to 3% w/v, it was observed that at the 1% level, the microorganism showed acceptable responses in both enzyme activities and cell growth. From the different tested compounds N-acetyl-D-methionine (1%) was the best enzyme inducer (Sp. act. = 4.14 U mg⁻¹ protein, Vol. act. = 0.17 U ml⁻¹) and the only one that increased cell growth. Received 13 June 1997/ Accepted in revised form 29 October 1998     

Isolation identification and biochemical characterization of a novel halo-tolerant lipase from the metagenome of the marine sponge Haliclona simulans

ABSTRACT: BACKGROUND: Lipases (EC 3.1.1.3) catalyze the hydrolysis of triacyl glycerol to glycerol and are involved in the synthesis of both short chain and long chain acylglycerols. They are widely used industrially in various applications, such as baking, laundry detergents and as biocatalysts in alternative energy strategies. Marine ecosystems are known to represent a large reservoir of biodiversity with respect to industrially useful enzymes. However the vast majority of microorganisms within these ecosystems are not readily culturable. Functional metagenomic based approaches provide a solution to this problem by facilitating the identification of novel enzymes such as the halo-tolerant lipase identified in this study from a marine sponge metagenome. RESULTS: A metagenomic library was constructed from the marine sponge Haliclona simulans in the pCC1fos vector, containing approximately 48,000 fosmid clones. High throughput plate screening on 1% tributyrin agar resulted in the identification of 58 positive lipase clones. Following sequence analysis of the 10 most highly active fosmid clones the pCC1fos53E1 clone was found to contain a putative lipase gene lpc53E1, encoded by 387 amino acids and with a predicted molecular mass of 41.87 kDa. Sequence analysis of the predicted amino acid sequence of Lpc53E1 revealed that it is a member of the group VIII family of lipases possessing the SXTK motif, related to type C beta-lactamases. Heterologous expression of lpc53E1 in E. coli and the subsequent biochemical characterization of the recombinant protein, showed an enzyme with the highest substrate specificity for long chain fatty acyl esters. Optimal activity was observed with p- nitrophenyl palmitate (C16) at 40degreesC, in the presence of 5 M NaCl at pH 7; while in addition the recombinant enzyme displayed activity across broad pH (3-12) and temperature (4 -60degreesC) ranges and high levels of stability in the presence of various solvents at NaCl concentrations as high as 5 M and at temperatures ranging from 10 to 80degreesC. A maximum lipase activity of 2,700 U/mg was observed with 10 mM p-nitrophenyl palmitate as substrate, in the presence of 5 mM Ca 2+ and 5 M NaCl, and a reaction time of 15 min at pH 7 and 40degreesC; while KM and Vmax values were calculated to be 1.093 mM-1and 50 umol/min, respectively. CONCLUSION: We have isolated a novel halo tolerant lipase following a functional screen of a marine sponge fosmid metagenomic library. The activity and stability profile of the recombinant enzyme over a wide range of salinity, pH and temperature; and in the presence of organic solvent and metal ions suggests a utility for this enzyme in a variety of industrial applications.