Aerobic Heterotrophic Bacterial Populations of Sewage and Activated Sludge: I. Enumeration1

Agar plating media containing solely activated sludge extracts yielded, in general, higher viable counts of activated sludge bacteria than any other culture medium tested. Activated sludge extracts made from different treatment plants varied in efficacy in evoking maximal viable counts. Frequently, homologous plating, i.e., plating inocula of activated sludges on extracts made from the same activated sludges, tended to yield lower counts than the heterologous platings tried in this investigation. The counts obtained by homologous plating of activated sludge were not significantly lower and sometimes were even significantly higher than the counts obtained on standard Nutrient Agar, which had been found by previous workers to be a good medium for counting activated sludge bacteria. The higher counts obtained with activated sludge extracts set objectives for formulating reproducible or defined culture media for the enumeration of activated sludge bacteria.     

The phosphorus fractions and alkaline phosphatase activities in sludge

The alkaline phosphatase activities (APA) and phosphorus fractions in activated sludge during wastewater treatment were studied. Our results showed that the phosphorus concentration and fractions in activated sludge were highly correlated with the characteristics of influents. Inorganic phosphorus (IP) and non-apatite inorganic phosphorus (NAIP) were the main phosphorus fractions of sludge. A larger phosphorus concentration was found in activated sludge due to the more readily mobilizable and bio-available forms. The APA in sludge was directly correlated with mixed liquor suspended solids (MLSS) in activated sludge. The APA in the sludge is implicated the depletion of organic phosphorus forms in sludge, whilst also implying its less inhibition of inorganic phosphorus in sludge. The APA and phosphorus fractions in different sludge samples from the same wastewater treatment plant were quite stable. This stability shows their tight interactions in sludge.     

PHA production by activated sludge.

The production of polyhydroxyalkanoate by anaerobic-aerobic activated sludge was reviewed concentrating on the biochemical mechanisms and on the trials to increase polyhydroxyalkanoate (PHA) content in activated sludge. The anaerobic aerobic activated sludge system selects microorganisms with the capabilities to couple glycolysis, polyphosphate degradation, and PHA accumulation for anaerobic substrate uptake. Some of the PHA-related metabolisms observed there have not been seen in pure cultures so far. Such metabolisms are the formation of PHA containing 3-hydroxy-2-methylvalerate, and '3-hydroxyvalerate fermentation' in which glucose or glycogen is converted to 3-hydroxyvalerate-rich PHA while yielding energy. The PHA content of activated sludge can be increased up to 62% by applying a microaerophilic-aerobic activated sludge process. PHA production by activated sludge is worth investigation.     

Biodegradation of naphthalene in the oil refinery wastewater by enriched activated sludge

The main purpose of this paper is to study naphthalene (NAP) biodegradation by acclimated activated sludge, employing the culture-enrichment method in a continuous flow bioreactor of the wastewater treatment process. The effects of various COD loadings and influent flow rates of an artificial wastewater containing 15 mg l⁻¹ NAP on the biodegradation rates of the activated sludge will be investigated, in order to determine the biodegradation kinetics and minimum mean cell residence time of the activated sludge. From the experimental results, it was found that the resulting enriched activated sludge follows the growth rate of the Monod type and can biodegrade those COD and NAP loadings in the influents efficiently, and its bio-treatment efficiency on NAPs increases with the decrease of influent flow rate. The sludge volume index (SVI) of the resulting enriched activated sludge meets the design value required by the convectional activated sludge process for the treatment of wastewater.     

Isolation, characterization of bacteriophages specific to Microlunatus phosphovorus and their application for rapid host detection

AIMS: To isolate and characterize lytic-bacteriophages specific to Microlunatus phosphovorus, and prepare fluorescently labelled phages (FLPs) for the rapid detection of the host bacterium in activated sludge. METHODS AND RESULTS: Isolation of bacteriophages lytic to M. phosphovorus was attempted by applying supernatants of activated sludge processes on the lawn of M. phosphovorus JCM9379 for plaque formation. Thirteen bacteriophage isolates were obtained. The restriction fragment length polymorphism analysis distinguished them into two different bacteriophages designated as phiMP1 and phiMP2. They were found to possess double-stranded DNA and host specificity. Morphological observations were done by electron microscopy. The bacteriophage particles stained by SYBR Green I was shown to be applicable to detect their host bacterial cells mixed with activated sludge. CONCLUSIONS: Two M. phosphovorus-specific bacteriophages were isolated and classified as Siphoviridae. FLPs of them were prepared, and successfully applied to detect the host bacterium added into the activated sludge. SIGNIFICANCE AND IMPACT OF THE STUDY: At least some of bacteria in activated sludge are susceptible to their related bacteriophages. Bacteriophages lytic to activated sludge bacteria could be affecting the bacterial population in activated sludge. The FLPs could be used for the easy-rapid detection of their host bacterium in activated sludge.     

Diversity and dynamics of Archaea in an activated sludge wastewater treatment plant

ABSTRACT: BACKGROUND: The activated sludge process is one of the most widely used methods for treatment of wastewater and the microbial community composition in the sludge is important for the process operation. While the bacterial communities have been characterized in various activated sludge systems little is known about archaeal communities in activated sludge. The diversity and dynamics of the Archaea community in a full-scale activated sludge wastewater treatment plant were investigated by fluorescence in situ hybridization, terminal restriction fragment length polymorphism analysis and cloning and sequencing of 16S rRNA genes. RESULTS: The Archaea community was specialized and dominated by Methanosaeta-like species. During a 15 month period major changes in the community composition were only observed twice despite seasonal variations in environmental and operating conditions. Water temperature appeared to be the process parameter that affected the community composition the most. Several terminal restriction fragments also showed strong correlations with sludge properties and effluent water properties. The Archaea were estimated to make up 1.6-% of total cell numbers in the activated sludge and were present both as single cells and colonies of varying sizes. CONCLUSIONS: The results presented here show that Archaea can constitute a constant and integral part of the activated sludge and that it can therefore be useful to include Archaea in future studies of microbial communities in activated sludge.     

Studies on the effect of inoculation of activated sludge with bacteria actively degrading hydrocarbons on the biodegradation of petroleum products

Eighteen strains of bacteria were isolated from activated sludge purifying petroleum-refining wastewaters. These strains were plated on solidified mineral medium supplemented with oil fraction in concentration 1000 mg/l. Four of the strains that grew best in the presence of oil were selected for further studies. The strains were identified based on Bonde's scheme and microscopic observations. Three of them belonged to the genus Arthrobacter and one to the genus Micrococcus. Stationary cultures of single strains and their mixtures were set up in mineral medium containing oil (sterile and non-sterile) as sole carbon source in concentration 1000 mg/l. The oils were found to be removed the most efficiently by a mixture of the strains. After 14 days of culture the amount of oil was utilized by from 63 to 95%. In the next stage of the studies the bacteria were used to inoculate activated sludge. Stationary cultures of the activated sludge were set up in mineral medium with oil. The utilisation of petroleum products by non-inoculated activated sludge (control), activated sludge inoculated with a single strain or a mixture of all four strains was examined. In both inoculated activated sludge cultures approximately 80% of the oils were removed, compared to 60% in the control activated sludge. Therefore, inoculated activated sludge showed 20% higher effectiveness of removal of petroleum derivatives.     

活性污泥抗生素抗性基因研究进展

抗生素抗性在全球范围内的传播扩散严重威胁人类健康。活性污泥是污水处理系统重要的处理工艺,同时也是抗生素抗性及其发生水平基因转移的一个重要储库和热区。目前,随着研究手段和技术的不断更新,活性污泥中抗生素抗性的研究不断增加,但是仍有许多科学问题亟待解决。本文主要针对活性污泥抗生素抗性的5个主要方面进行深入讨论:(1)活性污泥中抗性基因的丰度和分布的影响因素;(2)污泥抗性基因的研究方法;(3)活性污泥抗性基因的传播与扩散;(4)污泥中抗性基因环境风险评估;(5)研究展望。本综述在活性污泥抗生素抗性研究基础上,阐述了驱动抗生素抗性扩散的基本微生物生态过程研究进展,旨在为污水处理工艺的发展和优化及抗性基因控制政策的制定提供科学基础。     

Strategy for minimization of excess sludge production from the activated sludge process

Increased attention has been given to minimization of sludge production from activated sludge process since environmental regulations are being more and more stringent in relation to excess sludge disposal. In a biological process, the more organic carbon utilized in carbon dioxide production, the fewer sludge produced, and vice versa. This paper, therefore, reviews strategies developed for minimization of excess sludge production, such as oxic-settling-anaerobic process, high dissolved oxygen process, uncoupler-containing activated sludge process, ozonation-combined activated sludge process, control of sludge retention time and biodegradation of sludge in membrane-assisted reactor. In these modified activated sludge processes, excess sludge production can be reduced by 20-100% without significant effect on process efficiency and stability. It is expected that this paper would be helpful for researchers and engineers to develop novel and efficient operation strategy to minimize sludge production from biological systems.     

Detection of anaerobic processes and microorganisms in immobilized activated sludge of a wastewater treatment plant with intense aeration

Attached activated sludge from the Krasnaya Polyana (Sochi) wastewater treatment plant was studied after the reconstruction by increased aeration and water recycle, as well as by the installation of a bristle carrier for activated sludge immobilization. The activated sludge biofilms developing under conditions of intense aeration were shown to contain both aerobic and anaerobic microorganisms. Activity of a strictly anaerobic methanogenic community was revealed, which degraded organic compounds to methane, further oxidized by aerobic methanotrophs. Volatile fatty acids, the intermediates of anaerobic degradation of complex organic compounds, were used by both aerobic and anaerobic microorganisms. Anaerobic oxidation of ammonium with nitrite (anammox) and the presence of obligate anammox bacteria were revealed in attached activated sludge biofilms. Simultaneous aerobic and anaerobic degradation of organic contaminants by attached activated sludge provides for high rates of water treatment, stability of the activated sludge under variable environmental conditions, and decreased excess sludge formation.     

Effect of copper and tri- and hexavalent chromium on the work of an activated sludge.

The effect of metals (Cu2+, Cr3+, Cr6+) on the work of an activated sludge grown in crude oil refining or synthetic wastes was examined. The activated sludge method was found to be applicable for the purification of wastes carrying up to 0.8 mgCu2+/1,15mgCr3+/1, or 20mgCr6+/1. Higher concentrations of these metals inhibited the work of the activated sludge which was evident in inferior purification and reduced intensity of respiration of the activated sludge microorganisms.     

三氯乙酸(TCA)提取法与微波提取法检测活性污泥中三磷酸腺苷(ATP)

【目的】针对活性污泥法中的重要参数ATP进行研究分析,通过在不同条件下检测污泥的活性,得出以ATP为指标的污泥活性状态,为准确判定活性污泥的活性提供依据。【方法】分别运用三氯乙酸(TCA)提取法及微波提取法检测活性污泥中的ATP,并对检测ATP的影响因素(TCA浓度、冰浴时间、p H、微波频率及时间等)进行探讨与优化。【结果】运用TCA提取法检测ATP时,在1.0%-7.0%的TCA体积百分数内,活性污泥中TCA最佳体积百分数为2.5%;在2-60 min的冰浴时间内,最佳冰浴时间为10 min;三羟甲基丙烷-乙二胺四乙酸(Tris-EDTA)缓冲液的最佳p H 7.5;运用微波提取法检测ATP适宜的微波辐射条件为:功率800 W,辐射时间15 s。【结论】TCA提取法和微波提取法均可以检测活性污泥中的ATP,但与微波提取法相比,TCA提取法更能保证从细胞内释放出来的ATP的完整性,因此TCA提取法更适合用于检测活性污泥中的ATP。     

Identification of a functionally important population in phenol-digesting activated sludge with antisera raised against isolated bacterial strains.

Antisera were raised against nine strains which had been isolated from phenol-acclimated oil refinery activated sludge. Although several antisera reacted significantly with the activated sludge during a period of adaptation to phenol, only an antiserum against one of the isolates, Alcaligenes sp. E2, reacted with the activated sludge after the adaptation period. A kinetic pattern of phenol-oxygenating activity of the activated sludge after the adaptation period was similar to that of strain E2. These results suggest that a functionally important population in the phenol-digesting activated sludge was serologically identified.     

Influence of the activated sludge system configuration on heavy metal toxicity reduction

The effect of configuration of activated sludge systems on heavy metal toxicity was investigated. Two bench-scale completely mixed activated sludge systems were operated identically in order to determine the toxic effects of Cr(VI), Zn(II) and industrial wastewater on the activated sludge biomass. One system was operated with an aerobic selector and the other without. Batch experiments based on OECD 209 (Organisation for Economic Cooperation and Development) were performed using a respirometer to find out potential toxicity reduction effect of an aerobic selector. The IC₅₀ (concentration of a chemical that exhibits 50% respiration inhibition) values of Cr(VI), Zn(II) and industrial wastewater in the activated sludge were determined. Results indicated that the heavy metals and industrial wastewater caused less inhibitory effect on the selector activated sludge system in comparison to the conventional activated sludge system. Cr(VI) was found to exert higher inhibition on both systems.     

Activated Sludge Biodegradation of 12 Commercial Phthalate Esters

The activated sludge biodegradability of 12 commercial phthalate esters was evaluated in two test systems: (i) a semicontinuous activated sludge test and (ii) an acclimated 19-day die-away procedure. Both procedures demonstrated that phthalate esters are rapidly biodegraded under activated sludge conditions when loss of the parent phthalate ester (primary degradation) is measured.     

Assessment of physiological state of microorganisms in activated sludge with flow cytometry: application for monitoring sludge production minimization

Many sludge reduction processes have been studied for the minimization of sludge production in biological wastewater treatment. The investigations on most of these processes have monitored the increase of the soluble chemical oxygen demand, the sludge mass reduction, or the decrease of the floc size, but little information has been obtained on cell lysis and the change of the biological cell activity. However, employing any strategy for reducing sludge production may have an impact of microbial community in biological wastewater treatment process. This impact may influence the sludge characteristics and the quality of effluent. The objective of this study concerns the determination of the physiological state of activated sludge microorganisms during a sludge minimization process. A thermal treatment at 80 °C for 5, 20, 40 and 60 min was chosen in this study. Staining bacteria with CTC and SYTOX green was used to evaluate biological cell activity and viability of cell types contained in activated sludge, respectively. The monitoring of cell activity and viability was performed using flow cytometry (FCM) analysis before and after thermal treatment of activated sludge. Results indicated an increase in the number of permeabilized cells and a decrease in the number of active cells, subsequent to the thermal treatment. The study also confirms the potential of FCM to successfully evaluate the physiological heterogeneity of an activated sludge bacterial population. Moreover, the experimentally observed correlations between the FCM results and the organic matter solubilization in activated sludge samples during thermal treatment revealed that the increase in the soluble organic matter concentration was predominantly due to an intracellular material release. Identifying the increase in activated sludge hydrolysis requires a precise knowledge of the involved mechanisms, and this study indicated that the FCM, used in conjunction with specific probes, could be a useful tool.     

活性污泥微生物菌群研究方法进展

活性污泥是活性污泥法处理污水系统的功能主体。人类对活性污泥微生物菌群的认识随着其研究方法的发展而逐步深入。传统培养方法只能检测到活性污泥中1％～15％的微生物。随着一系列基于免培养的分子生物学技术的出现,活性污泥中菌群的复杂性和多样性以惊人的速度被人们认识,大量依靠传统检测方法未能发现却在活性污泥中起关键作用的微生物逐渐被发现。许多模拟活性污泥菌群生存环境条件的现代培养技术开始发展,且已成功培养了一部分传统培养方法不能培养的细菌类群,这为研究基于免培养方法发现的大量新的微生物菌群的生理特性和作用机制提供了可能,也无疑将把人们对活性污泥菌群的认识推向一个新的层次．主要介绍活性污泥微生物菌群研究的一系列方法,从传统培养方法到基于免培养的现代分子生物学技术,再到现代培养技术,着重论述了现代分子生物学技术及其在活性污泥微生物菌群研究中的进展。     

Effect of methyl alcohol and ethylene glycol on the work of activated sludge.

The effect of methyl alcohol and ethylene glycol on the work of activated sludge grown in synthetic wastewater was investigated. Wastewater carrying these compounds could be purified by the activated sludge method, providing the concentration of methyl alcohol and glycol did not exceed 5,000 mg/l and 1,000 mg/l, respectively. At these values reduced purification efficiency, increased volumetric index of the sludge and changes in the structure of the activated sludge flocs could be observed.     

Effect of phenolic tar on the work of activated sludge

The effect of different phenolic tar concentrations on the work of activated sludge in petrochemical and synthetic wastewater was investigated. The concentrations of 440 and 300 mg/l of phenolic tar did not show a destructive effect on the activated sludge and its work. The highest concentration of phenolic tar (880 mg/l) reduced the efficiency of purification and changed the structure of the activated sludge.     

Change in the community structure of ammonia-oxidizing bacteria in activated sludge during selective incubation for MPN determination

We investigated the changes in the community structure of ammonia-oxidizing bacteria (AOB) in activated sludge during incubation of the sludge in a medium selective for AOB. The number of AOB present in the activated sludge sample was enumerated by the most-probable-number (MPN) method. Both the activated sludge sample and the incubated samples for MPN determination were analyzed by polymerase chain reaction and denaturing gradient gel electrophoresis (PCR-DGGE). Universal PCR-DGGE indicated that even after 40-d incubation in a medium selected for AOB, the MPN samples were predominantly composed of heterotrophic bacteria and not AOB. Denitrification by heterotrophic bacteria might lead to the underestimation of the MPN count of AOB. Not dominated in whole bacteria, one species of AOB was detected in both original activated sludge and samples after MPN incubation by PCR-DGGE targeting AOB. Furthermore, two new species of AOB were detected only after incubation. Therefore, the community structure of AOB in the MPN samples partially resembled that in the original activated sludge.