Gliotoxin, a fungistatic metabolic product of Trichoderma viride

Gliotoxin is shown to be a metabolic product of Trichoderma viride , and a semi-continuous apparatus for its production is described. Ammonia nitrogen is preferable to nitrate nitrogen, but a wide range of carbon sources, and organic or inorganic sulphur sources, are suitable for gliotoxin production. No organic supplements to a glucose-mineral medium have been found to affect gliotoxin production beneficially.
Data are presented showing gliotoxin to be moderately toxic to a wide range of bacteria, actinomycetes and fungi. T. viride itself is resistant to its toxic effects. It shows fungicidal activity when applied as a dust to cereal seeds bearing various seed-borne diseases, but is inferior to organomercury compounds for this purpose. Its value as a fungicide for control of plant or animal infections is reduced by the instability of aqueous solutions, except at low p H.     

Studies on Biological Control of Postharvest Rot in Yams (Dioscorea spp.) using Trichoderma viride

From in vitro and in vivo screening tests for antagonism by isolates of Trichoderma against postharvest pathogens of yams (Dioscorea spp.), an isolate of Trichoderma viride Pers. ex S.F. Gray was selected as the most promising candidate for the biocontrol of postharvest rot of yams. Inoculation of white yam (Dioscorea rotundata Poir.) with conidiaspores of T. viride and subsequent storage of the tubers under the ambient environment conditions of a traditional yam barn, resulted in a drastic reduction in the frequency of occurrence of the normal tuber surface mycoflora over a 4‐month (December‐April) storage period. Trichoderma viride on the other hand, maintained a high frequency of occurrence during the same period. Furthermore, whereas up to 52.0%) rot was found among groups of tubers that were artificially inoculated with the postharvest pathogens of yams, Aspergillus niger Van Tiegh., Botryodiplodia theobromae Pat. or Penicillium oxalicum Currie and Thom, and also the group that was not inoculated with any organism (control), among groups of tubers that were inoculated with T. viride the rot was either totally suppressed or only a low percentage of rot occurred. The significance of the findings is discussed in relation to yam storage especially by farmers with limited resources.     

Protoplasts of Trichoderma viride

High yields of protoplasts from the 18-hr old mycelium of Trichoderma viride were obtained by using the lytic system, produced by Streptomyces venezuelae RA and Micromonospora chalcea grown on a synthetic medium containing laminarin and chitin, when 0.7 M MgSO₄ or (NH₄)₂SO₄ were used as osmotic stabilizers. Regeneration of these protoplasts occurred through the production of an abortive tube and direct germination of the protoplasts. Regeneration could also take place in the medium used to produce protoplasts, but the process was different in many details.     

Starch industry wastewater as a substrate for antagonist, Trichoderma viride production

Starch industry wastewater was investigated to assess and improve its potential as a raw material for the conidia production of biocontrol fungi, Trichoderma viride. The wastewater was tested with and without supplements of glucose, soluble starch, meat peptone and probable conidiation inducer chemicals in shake flask culture. Addition of complex carbon source (soluble starch, 1% and 2% w/v) produced maximum conidia ( approximately 3.02 and 4.2 x 10(10)CFU/mL, respectively). On the other hand, glucose addition as a simpler carbon source was either ineffective or, reduced conidia production (from 1.6 x 10(8) in control to 3.0 x 10(7)CFU/mL in 5% w/v glucose supplement). Supplement of nitrogen source showed a small increase of conidia concentration. Propionic, maleic and humic acids, EDTA, pyridine, glycerol and CaCO(3) were examined as probable conidiation inducers and showed effect only on initial rate of conidiation with no increase in final conidia concentration. Intra and extracellular ATP correlation with spore production showed dependence on growth media used and conidia concentration at the end of fermentation. Addition of carbon and nitrogen sources showed an increase in protease activity (from 0.4985 to 2.43 IU/mL) and entomotoxicity (from 10448 to 12335 spruce budworm unit (SBU)/microL). Entomotoxicity was improved by 11% in fermenter over shake flask when starch industry wastewater was supplemented with meat peptone.     

Sterol-Dependent Induction of Plant Defense Responses by a Microbe-Associated Molecular Pattern from Trichoderma viride

Plant-microbe interactions involve numerous regulatory systems essential for plant defense against pathogens. An ethylene-inducing xylanase (Eix) of Trichoderma viride is a potent elicitor of plant defense responses in specific cultivars of tobacco (Nicotiana tabacum) and tomato (Solanum lycopersicum). We demonstrate that tomato cyclopropyl isomerase (SlCPI), an enzyme involved in sterol biosynthesis, interacts with the LeEix2 receptor. Moreover, we examined the role of SlCPI in signaling during the LeEix/Eix defense response. We found that SlCPI is an important factor in the regulation of the induction of defense responses such as the hypersensitive response, ethylene biosynthesis, and the induction of pathogenesis-related protein expression in the case of LeEix/Eix. Our results also suggest that changes in the sterol composition reduce LeEix internalization, thereby attenuating the induction of plant defense responses.Plant innate immunity is activated upon the recognition of pathogen- and microbe-associated molecular patterns by surface-localized immune receptors or the stimulation of cytoplasmic immune receptors by pathogen effector proteins (Jones and Dangl, 2006; Thomma et al., 2011). Leucine-rich repeat (LRR) receptor kinases and leucine-rich repeat receptor proteins (LRR-RLPs) respond to conserved microbe-associated molecular patterns by producing a defense response upon detection (Altenbach and Robatzek, 2007; Bittel and Robatzek, 2007; Robatzek et al., 2007; Geldner and Robatzek, 2008). One such LRR-RLP is the ethylene-inducing xylanase (Eix) receptor LeEix2. The fungal protein Eix (Dean et al., 1989) is a well-known protein elicitor of defense response reactions in tobacco (Nicotiana tabacum) and tomato (Solanum lycopersicum; Bailey et al., 1990; Avni et al., 1994). Eix induces ethylene biosynthesis, extensive electrolyte leakage, pathogenesis-related (PR) gene expression, reactive oxygen species (ROS), and the hypersensitive response (HR; Bailey et al., 1990; Ron et al., 2000). Eix was shown to specifically bind to the plasma membrane of responsive cultivars of both tomato and tobacco (Hanania and Avni, 1997). The response to Eix in tobacco and tomato cultivars is controlled by an LRR-RLP encoded by a single locus, termed LeEix (Ron and Avni, 2004). Previously, we showed that Eix triggers internalization of the LeEix2 receptor and its localization to endosomes (Bar and Avni, 2009).Endocytic processes and vesicular transport in general require the participation of membrane components that form transport vesicles with a capability to store and process a number of molecules known to participate in cell signaling (Anderson, 1993; Patel et al., 2008; Hansen and Nichols, 2010). Sterols are lipophilic membrane components that have many important functions in an array of eukaryotes. Changes in membrane-bound sterol levels and composition can have effects on the activity of membrane proteins and on signal transduction processes. The interaction between sterols and phospholipids forms microdomains termed lipid rafts (Simons and Ikonen, 1997). In response to cellular stimuli, lipid rafts can change the protein microenvironment, leading to the initiation of signaling cascades (Simons and Toomre, 2000; Mongrand et al., 2010; Simon-Plas et al., 2011). Sterols also provide precursors for the biosynthesis of steroid hormones such as mammalian estrogens and glucocorticoids and plant brassinosteroids (Bishop and Yokota, 2001; Benveniste, 2004; Suzuki and Muranaka, 2007). One of the enzymes involved in sterol biosynthesis is cyclopropyl isomerase (CPI; Lovato et al., 2000; Benveniste, 2004).A variety of endocytic pathways have been described in mammalian and fungal cells that differ mainly in the size, shape, and composition of endocytic vesicles and in the participation of different proteins (Conner and Schmid, 2003; Soldati and Schliwa, 2006). Cholesterol, the main mammalian sterol, has an important role in most internalization steps through both caveolae and clathrin-coated pits (Murata et al., 1995; Subtil et al., 1999). Cholesterol depletion alters endocytic structures and reduces the polar delivery of target proteins (Keller and Simons, 1998; Pichler and Riezman, 2004). Plant sterols are reported to be internalized into endosomes and distributed throughout the endocytic pathway in an actin-dependent manner (Grebe et al., 2003). The sterol endocytic pathway has been shown to interrupt the internalization, trafficking, and polar recycling of PIN2, an auxin efflux facilitator and polarity marker, in developing root epidermal cells of Arabidopsis (Arabidopsis thaliana; Grebe et al., 2003; Men et al., 2008). Sterols were shown to function in the trafficking of an ATP-binding cassette (ABCB19) from the trans-Golgi to the plasma membrane (Yang et al., 2013).Here, we report the isolation of SlCPI, which interacts with the LeEix2 receptor. Modulating the expression or function of SlCPI affects the induction of plant defense responses mediated by Eix.     

Continuous cultivation of Trichoderma viride on cellulose

Using ball milled cellulose as the only carbon source Trichoderma viride was grown in a continuous flow culture at pH = 5.0 and T = 30°C. Steady-state values for cell protein, cellulose, and cellulase for different substrate concentrations (4–11 g/liter) and dilution rates (0.033–0.080 hr^?1) were obtained. Under steady-state conditions, 50–75% of the cellulose was consumed indicating a critical dilution rate on 0.17 hr^?1. Cellulase activity (U/ml) in the fermentation broth increased slightly with increasing substrate concentration and decreased with increasing dilution rate, while the specific cellulase productivity (U/mg cell protein·hr) was fairly independent of the dilution rate, with a maximum around D = 0.05 hr^?1. Following step changes in substrate concentration and dilution rate, new steady-state values were reached after three to five residence times (cell protein and cellulose) and four to six residence times (celullase activity).     

Trichoderma viride as a mycoparasite ofAspergillus spp.

Summary Trichoderma viride was found to be parasitic on three species of Aspergillus. The mycoparasitism was characterized by frequent coiling, penetration and hyphal growth of the parasite inside the conidiophores of Aspergillus. The volatile and non-volatile metabolites ofT. viride, more or less, inhibited radial growth of all the testAspergillus spp.     

Enhanced Cellulase Production by a Mutant of Trichoderma viride

A mutant strain that secretes twice as much cellulase as its parent was obtained by irradiating conidia of Trichoderma viride QM 6a with a linear accelerator.     

Molecular action of tricholin, a ribosome-inactivating protein isolated from Trichoderma viride

An extracellular protein was isolated from a species of soil-borne fungi (Trichoderma viride) and its amino acid composition has been determined. The protein is acidic with a molecular mass of 14,200 daltons and is given the trivial name tricholin. Tricholin is a potent inhibitor of cell-free protein synthesis. When rabbit reticulocyte lysate was incubated with tricholin at a concentration of 6.3 x 10(-7) M, it completely abolished the capacity of the lysate to support protein synthesis. The inhibition appears to be due to its reaction to ribosomes, since it generates a specific cleavage product, an alpha-sarcin RNA fragment, from reticulocyte ribosomal RNA. This reaction to ribosomes mimics that of alpha-sarcin. The antibody of alpha-sarcin strongly cross-reacts with tricholin, while the antibody of tricholin shows a weak reaction with alpha-sarcin.     

Cellulase Production by Trichoderma viride on Feedlot Waste

Feedlot waste contains essentially all the necessary nutrients for batch fermentation with the fungus Trichoderma viride. The organism utilizes two-thirds of the carbohydrate in feedlot waste while elaborating cellulase in quantities comparable to commercial preparations. Essentially odor-free, the fermented waste contains all of the original nitrogen but has 24% less organic matter.     

A method for increasing cellulase production by Trichoderma viride

A doubling of cellulase production by Trichoderma viride (QM9414) is possible by increasing the cellulose concentration in the medium from 0.75 to 2%, increasing the nitrogen concentration, and controlling pH during growth. A four-to fivefold increase in β -glucosidase is found with the higher cellulose concentration. Culture filtrates from 2% cellulose cultures can reduce the hydrolysis time in a practical saccharification to one-half that required by culture filtrates from 0.75% cellulose cultures.     

Substrate-velocity relationships for the Trichoderma viride cellulase-catalyzed hydrolysis of cellulose

The influence of substrate and enzyme concentrations on the rate of saccharification of two defined insoluble cellulose substrates, Avicel (FMC Corp., Philadelphia, Pa.) and Solka-Floc (James River Co., Berlin, N.H.), by the cellulase enzyme system of Trichoderma viride was evaluated. In the assays, enzyme concentrations ranging from 0.004 to 0.016 IU/ml and substrate concentrations up to 10% (wt/vol) were used. Analysis by initial velocity methods found the maximum velocity of saccharification to be nearly equivalent for the two substrates and the Km for the two substrates to be of a similar magnitude, i.e., 0.20% (wt/vol) for Solka-Floc and 0.63% (wt/vol) for Avicel. Studies in which relatively high substrate concentrations (greater than 15 times the Km) were used demonstrated that the enzyme exhibited very different apparent substrate inhibition properties for the two substrates. The rate of saccharification of Avicel at relatively high substrate concentrations was up to 35% lower than the maximum rate which was observed at lower substrate concentrations. The Avicel concentration corresponding to the maximum rate of saccharification was dependent on the enzyme concentration. In contrast to the results with Avicel, the enzyme did not exhibit substrate inhibition with the Solka-Floc substrate. Potential differences in the degree of substrate inhibition with different substrates, as reported here, are particularly relevant to the experimental design of comparative studies.     

Strain improvement for enhanced production of cellulase in Trichoderma viride

The filamentous fungi Trichoderma species produce extracellular cellulase. The current study was carried out to obtain an industrial strain with hyperproduction of cellulase. The wild-type strain, Trichoderma viride TL-124, was subjected to successive mutagenic treatments with UV irradiation, low-energy ion beam implantation, atmospheric pressure non-equilibrium discharge plasma (APNEDP), and N-methyl-N'-nitro-N-nitrosoguanidine to generate about 3000 mutants. Among these mutants, T. viride N879 strain exhibited the greatest relevant activity: 2.38-fold filter paper activity and 2.61-fold carboxymethyl cellulase, 2.18-fold beta-glucosidase, and 2.27-fold cellobiohydrolase activities, compared with the respective wild-type activities, under solid-state fermentation using the inexpensive raw material wheat straw as a substrate. This work represents the first application of APNEDP in eukaryotic microorganisms.     

Effect of Cultural Conditions on Cellulase Formation by Trichoderma viride

In order to have increased extracellular production of cellulase by Trichoderma viride ITCC 1433, the organism was grown on various growth factors. Cellulose Powder ?123 was found to be the best C-source while amongst raw materials, alkali-treated rice straw gave the best yield. A combination of peptone, urea and ammonium sulphate gave better production of cellulase than when a single nitrogen source was used. Sugars when added into the cellulose medium, generally suppressed the yield. When the organism was grown on sugars as the sole source of carbon, only lactose and maltose induced any cellulase production. Acetate and ascorbate were conspicuous in increasing cellulase production and when given together they had a cummulative effect and the yeild was doubled.     

Location and Formation of Cellulases in Trichoderma viride

The location and formation of cellulases and β-glucosidase in the fungus Trichoderma viride were studied on different substrates. The cellulases were found to be cell-bound during active growth on cellulose, CMC, and cellobiose. On CMC, much CM-cellulase was found cell-free but sonication released cellulase from the washed mycelium. Analysis of the carbohydrates of the mycelial cell wall after hydrolysis revealed glucose, mannose, and galactose—the same carbohydrates as reported to be present in purified cellulase from the same organism. Glucose repressed the formation of both CM-cellulase and Avicelase and cellobiose apparently the formation of Avicelase. Relatively little CM-cellulase was formed on cellobiose but a straight line was obtained when a differential plot of CM-cellulase versus protein was made.     

Effect of nitrogen source on aroma production by Trichoderma viride

Summary The effect of nitrogen source on the aroma production of a strain of Trichoderma viride was investigated. The compound giving the culture its characteristic coconut-like aroma was identified as 6-pentyl--pyrone. Variation of the nitrogen source affected the quantity of the lactone produced but did not cause a significant difference in the aroma of the culture. The lactone formation was also affected by the method of cultivation, and sporulation was not essential for its formation.