Harvest date and leaf:stem ratio determine methane hectare yield of miscanthus biomass

The suitability of miscanthus biomass for anaerobic digestion has already been confirmed by several studies. However, it is rarely used as feedstock in biogas plants, mainly due to uncertainty about the optimal harvest regime with regard to the long‐term methane hectare yield and resilience of the crop to green cutting. The recommended green‐cut date for the only commercially available genotype Miscanthus × giganteus (M×g) ranges from September to November. This timeframe is too broad for agricultural practice and needs to be both narrowed down and further specified for different genotypes. The aim of this study was to identify the most suitable harvest window for an autumn green cut of miscanthus, which delivers both a high dry matter and methane yield while securing the long‐term productivity of the crop. A further objective was to quantify the effect of genotypic differences, such as leaf to stem ratio, on the substrate‐specific biogas and methane yield. For these purposes, a field trial with four genotypes (M×g, GNT1, GNT3, Sin55) was conducted over 2 years (2016/2017) and harvested at 2‐week intervals on three dates between mid‐September to mid‐October. Methane hectare yield ranged from 3,183 m³ CH₄ ha^?1 a^?1 (Sin55) to 5,265 m³ CH₄ ha^?1 a^?1 (M×g), which is mainly influenced by dry matter yield. The substrate‐specific methane yield was higher for the leaf (311.0 ml CH₄ (g oDM)^‐1) than the stem fraction (285.1 ml CH₄ (g oDM)^‐1) in all genotypes due to lower lignin content of leaves. Of all genotypes, M×g showed the highest and Sin55 the lowest nutrient use efficiency. We conclude that miscanthus in Germany should be harvested in October to maximize methane yields and nutrient recycling and minimize yield reduction. Additionally, to increase methane hectare yields even further, future miscanthus breeding should focus on a higher leaf proportion.     

Species composition of semi-natural mesic grasslands as a factor influencing the methane yield of plant biomass (Central Europe)

Semi-natural lowland and mountain mesic meadows are grasslands rich in species, and their conservation status depends on treatments such as mowing or grazing livestock. In many countries, the condition of grasslands is deteriorating because of their inappropriate use or abandonment. This study aimed to determine the effects of the species composition of plant communities and functional plant groups on the methane yield from biomass harvested from mesic grasslands in the Sudetes Mountains. Biogas potential analysis was performed based on biomass samples collected from Poland and the Czech Republic. The biogas potential was determined in 40 day-long batch anaerobic digestion tests. The average methane yield obtained from the biomass was 246 ± 16 NL CH₄ kg^?1 VS, whereas the methane yield per hectare was 870 ± 203 m³ CH₄ ha^?1. Plant communities comprising different dominant species had no effect on the methane yield but affected the methane yield per hectare. Additionally, the species composition of grasslands with a higher percentage of forbs had lower biomass yield, resulting in lower methane yields per hectare. The continuity of the low-intensity management of mountain grassland, which can be provided by the utilization of their biomass for bioenergy production, sustains high biodiversity and ensures appropriate meadow conservation.     

An Analysis of the Energy Potential of Anaerobic Digestion of Agricultural By-Products and Organic Waste

Anaerobic digestion is a promising option for recycling agricultural by-products and some organic wastes. While both agricultural by-products and wastes have no direct commercial value, their management is both complicated and costly. One option to simplify by-product management and reduce the costs associated with biogas plant feedstock is to substitute dedicated crops with vegetal by-products. Given that the chemical composition of some of these by-products can differ considerably from more typical biogas plant feedstock (such as maize silage), more complete knowledge of these alternatives to produce environmentally friendly energy is warranted. To this end, batch trials under mesophilic conditions were conducted to evaluate the potential biogas yield of many agricultural by-products: maize stalks, rice chaff, wheat straw, kiwi fruit, onions, and two expired organic waste products (dairy and dry bread) from the retail mass-market. Among the considered biomasses, the highest methane producer was the expired dairy product mixture, which yielded 554 l_NCH₄ kg⁻¹ volatile solids (VS). Maize stalks and wheat straw produced the lowest yields of 214 and 285 l_NCH₄ kg⁻¹VS, respectively. An assessment of the biogas and methane yields of each biomass was also undertaken to account for the specific chemical composition of each biomass as it can affect the anaerobic digestion operating system. Finally, the total Italian green energy production that might be derived from feeding all these biomasses to a biogas digester was estimated, in order to understand its potential impact.     

Biogas production from boreal herbaceous grasses – Specific methane yield and methane yield per hectare

The objective of this study was to determine the specific methane yields of four grass species (cocksfoot, tall fescue, reed canary grass and timothy) cultivated under boreal conditions as well as how harvesting time and year of cultivation affects the specific methane yields per ha. The specific methane yields of all grasses and all harvests varied from 253 to 394 Nl CH₄/kg volatile solids (VS) added. The average specific methane yield of the 1st harvest of all grasses was higher than the 2nd harvests. In this study the methane and energy yields from different harvest years were ranged from 1200 to 3600 Nm³ CH₄/ha/a, corresponding from 12 to 36 MWh_CH4${\text{MWh}}_{{\text{CH}}_4}$/ha/a. The methane yield per hectare of the 1st harvest was always higher than that of the 2nd harvest per hectare because of the higher dry matter yield and specific methane yield. High biomass yield per hectare, good digestibility and regrowth ability after harvesting are important factors when choosing grass species for biogas production. If 30% of fallow and the second harvest of grassland were cultivated grasses and harvested for biogas production in Finland, the energy produced could be 4.9 TWh_CH4${\text{TWh}}_{{\text{CH}}_4}$.     

Effects of ensiling, silage additives and storage period on methane formation of biogas crops

Effects of the ensiling process, storage periods of up to 1 year and several chemical and biological silage additives on biomethanation were assessed for maize, sorghum, forage rye and triticale with the aim to identify optimised conditions for silage production of crops used as feedstock in biogas plants. Ensiling, prolonged storage and biological silage additives showed positive effects on methane yield of up to 11%. These could be attributed to increases in organic acids and alcohols during ensiling. A regression model including acetic acid, butyric acid and ethanol accounts for 75-96% of the variation in methane yield. Storage periods of up to 1 year for properly ensiled crops could be possible without losses in methane production, considering the increase in methane yield and the losses of dry matter during this period. However, taking storage losses into account silage additives showed little effect on methane production.     

Economic and environmental performance of miscanthus cultivated on marginal land for biogas production

Environmental issues surrounding conventional annual biogas crops have led to growing interest in alternative crops, such as miscanthus. In addition to the better environmental performance, miscanthus can be grown on marginal land where no competition with feed and food crops is anticipated. On marginal land however, biomass yields are significantly lower than on good agricultural land. This raises the question of the economic and environmental sustainability of miscanthus cultivated on marginal land for biogas production. This study assessed the environmental and economic performance of miscanthus cultivated on marginal land for biogas production by conducting a Life‐Cycle Assessment and complementary Life‐Cycle Cost analysis. The functional unit chosen was 1 GJ of electricity (GJ_el.). The substitution of a fossil reference was included using a system expansion approach. Electricity generated by the combustion of miscanthus‐based biogas in a combined heat and power has considerably lower impacts on the environment than the fossil reference in most of the categories assessed. In the impact category “climate change”, the substitution of the marginal German electricity mix leads to a carbon mitigation potential of 256 kg CO₂e/GJ_el.. At 45.12 €/GJ_el., the costs of miscanthus‐based biogas generation and utilization are considerably lower than those of maize (61.30 €/GJ_el.). The results of this study clearly show that it can make economic and environmental sense to cultivate miscanthus on marginal land as a substrate for biogas production. The economic sustainability is however limited by the biomass yield. By contrast, there are no clear thresholds limiting the environmental performance. The decision needs to be made on a case‐by‐case basis depending on site‐specific conditions such as local biodiversity.     

The Possibility of Meeting Greenhouse Energy and CO<Subscript>2</Subscript> Demands Through Utilisation of Cucumber and Tomato Residues

The article examines the possibility of using residues from greenhouse cucumber and tomato cultivation as biomass for energy and CO₂ production in order to meet greenhouse needs. Methane fermentation and combustion were compared. Moreover, the legitimacy of ensiling as a storage method for biogas plant was evaluated. The tested waste was found to be an unsuitable feedstock for the production of silage due to low sugar and high protein content. Fresh waste had a higher biogas yield than silage; however, its fermentation lasted longer. Furthermore, the results showed that, in the case of fresh residues, the methane fermentation proved to be a more energy-efficient process, while air-dry biomass is a more sustainable feedstock for combustion. The energy and CO₂ balance showed that, regardless of the method used, the available quantity of waste is too small to meet the greenhouse needs.     

Effect of Harvest Time and Frequency on Biomass Quality and Biomethane Potential of Common Reed (<Emphasis Type="Italic">Phragmites australis</Emphasis>) Under Paludiculture Conditions

This study examined the effect of harvest time (from May to September) and dry matter partitioning on biomethane potential and methane yield per unit area of Phragmites australis cultivation under paludiculture conditions. The experimental site is part of a larger experimental platform (San Niccolò, Pisa) located within the Massaciuccoli Lake Basin in Central Italy (Tuscany, IT). The study also took into account the double cut strategy by evaluating the regrowth from June to September. Biomethane potentials ranged from 384 to 315 and from 412 to 283 NL CH₄ kg VS^?1 (normal liters of methane per kg of volatile solids) for leaves and stems, respectively. About digestion kinetics, maximum daily production rate (R _max) was significantly affected by harvest time and not by plant partitioning. Along the harvest season, biomethane yield per unit area was mostly driven by the biomass yield showing an increasing trend from May (1659 Nm³ ha^?1) to September (3817 Nm³ ha^?1). The highest value was obtained with the double harvest option (4383 Nm³ ha^?1), although it was not statistically different from the single harvest carried out in September. Owing to its remarkably lower yields, P. australis cannot be considered along the same lines as crops conventionally used for biogas production, but it may represent an interesting option for paludiculture cropping systems by coupling peatland restoration with bioenergy production. September harvest management seemed the most feasible option, although further investigation on crop lifespan is needed.     

Biogas production and valorization by means of a two-step biological process

The scope of this research work was to investigate biogas production and purification by a two-step bench-scale biological system, consisting of fed-batch pulse-feeding anaerobic digestion of mixed sludge, followed by methane enrichment of biogas by the use of the cyanobacterium Arthrospira platensis. The composition of biogas was nearly constant, and methane and carbon dioxide percentages ranged between 70.5–76.0% and 13.2–19.5%, respectively. Biogas yield reached a maximum value (about 0.4 m³_biogas/kgCOD_i) at 50 days-retention time and then gradually decreased with a decrease in the retention time. Biogas CO₂ was then used as a carbon source for A. platensis cultivation either under batch or fed-batch conditions. The mean cell productivity of fed-batch cultivation was about 15% higher than that observed during the last batch phase (0.035 ± 0.006 g_DM/L/d), likely due to the occurrence of some shading effect under batch growth conditions. The data of carbon dioxide removal from biogas revealed the existence of a linear relationship between the rates of A. platensis growth and carbon dioxide removal from biogas and allowed calculating carbon utilization efficiency for biomass production of almost 95%.     

Biogas production from different substrates in an experimental Continuously Stirred Tank Reactor anaerobic digester

Different mixtures were digested in a single-stage, batch, mixed, laboratory scale mesophilic anaerobic digester at the Biomass Research Centre Laboratory (University of Perugia). The yield and the composition of biogas from the different substrates were evaluated and the cumulative curves were estimated. Two experimental campaigns were carried out, the first on three mixtures (chicken, pig and bovine manures), the second on animal and vegetal biomasses (chicken and cow manure, olive husk) with different inocula (rumen fluid and digested sludge). In the first campaign pig manure mixture showed the maximum biogas production (0.35 Nm³/kg) and energy content (1.35 kWh/kg VS); in the second one the differences in produced biogas from the different inocula were analyzed: olive husk with piggery manure anaerobically digested as inoculum showed the higher biogas (0.28 Nm³/kg VS) and methane yield (0.11 Nm³/kg VS), corresponding to an energetic content of 1.07 kWh/kg VS. All data obtained from the laboratory scale anaerobic digester are comparable to the values in literature for several biomass and in particular for olive husk, dairy manure and chicken manure.     

Biogas Production from Steam-Exploded Miscanthus and Utilization of Biogas Energy and CO2 in Greenhouses

The costs of producing protected vegetables comprise up to 78 % of the total operating costs in greenhouses. These expenses mainly result from energy consumption. Increasing energy efficiency and expanding the use of renewable energy sources are essential for global competitiveness. The aim of this study is to optimize methane production from miscanthus and to evaluate the potential use of miscanthus as a source of electrical energy, heat, and CO₂ in vegetable greenhouses. To optimize methane yield, miscanthus was pretreated by steam explosion using different time/temperature combinations. Pretreatment resulted in a more than threefold increase of methane yield from anaerobic digestion (374 l_N?kgVS^?1) compared with untreated miscanthus. Based on technical parameters from two greenhouses (in Northern and Southern Europe), four different energy balances were established. The balances showed that using methane produced by pretreated miscanthus in vegetable greenhouses can enhance the entire process and therefore make it more sustainable.     

Implications of productivity and nutrient requirements on greenhouse gas balance of annual and perennial bioenergy crops

Biomass from dedicated crops is expected to contribute significantly to the replacement of fossil resources. However, sustainable bioenergy cropping systems must provide high biomass production and low environmental impacts. This study aimed at quantifying biomass production, nutrient removal, expected ethanol production, and greenhouse gas (GHG) balance of six bioenergy crops: Miscanthus × giganteus, switchgrass, fescue, alfalfa, triticale, and fiber sorghum. Biomass production and N, P, K balances (input‐output) were measured during 4 years in a long‐term experiment, which included two nitrogen fertilization treatments. These results were used to calculate a posteriori ‘optimized’ fertilization practices, which would ensure a sustainable production with a nil balance of nutrients. A modified version of the cost/benefit approach proposed by Crutzen et al. (2008), comparing the GHG emissions resulting from N‐P‐K fertilization of bioenergy crops and the GHG emissions saved by replacing fossil fuel, was applied to these ‘optimized’ situations. Biomass production varied among crops between 10.0 (fescue) and 26.9 t DM ha^?1 yr^?1 (miscanthus harvested early) and the expected ethanol production between 1.3 (alfalfa) and 6.1 t ha^?1 yr^?1 (miscanthus harvested early). The cost/benefit ratio ranged from 0.10 (miscanthus harvested late) to 0.71 (fescue); it was closely correlated with the N/C ratio of the harvested biomass, except for alfalfa. The amount of saved CO₂ emissions varied from 1.0 (fescue) to 8.6 t CO₂eq ha^?1 yr^?1 (miscanthus harvested early or late). Due to its high biomass production, miscanthus was able to combine a high production of ethanol and a large saving of CO₂ emissions. Miscanthus and switchgrass harvested late gave the best compromise between low N‐P‐K requirements, high GHG saving per unit of biomass, and high productivity per hectare.     

An integrated biogeochemical and economic analysis of bioenergy crops in the Midwestern United States

This study integrates a biophysical model with a county‐specific economic analysis of breakeven prices of bioenergy crop production to assess the biophysical and economic potential of biofuel production in the Midwestern United States. The bioenergy crops considered in this study include a genotype of Miscanthus, Miscanthus×giganteus, and the Cave‐in‐Rock breed of switchgrass (Panicum virgatum). The estimated average peak biomass yield for miscanthus in the Midwestern states ranges between 7 and 48 metric tons dry matter per hectare per year ( t DM ha^?1 yr^?1), while that for switchgrass is between 10 and 16 t DM ha^?1 yr^?1. With the exception of Minnesota and Wisconsin, where miscanthus yields are likely to be low due to cold soil temperatures, the yield of miscanthus is on average more than two times higher than yield of switchgrass. We find that the breakeven price, which includes the cost of producing the crop and the opportunity cost of land, of producing miscanthus ranges from $53 t^?1 DM in Missouri to $153 t^?1 DM in Minnesota in the low‐cost scenario. Corresponding costs for switchgrass are $88 t^?1 DM in Missouri to $144 t^?1 DM in Minnesota. In the high‐cost scenario, the lowest cost for miscanthus is $85 t^?1 DM and for switchgrass is $118 t^?1 DM, both in Missouri. These two scenarios differ in their assumptions about ease of establishing the perennial crops, nutrient requirements and harvesting costs and losses. The differences in the breakeven prices across states and across crops are mainly driven by bioenergy and row crop yields per hectare. Our results suggest that while high yields per unit of land of bioenergy crops are critical for the competitiveness of bioenergy feedstocks, the yields of the row crops they seek to displace are also an important consideration. Even high yielding crops, such as miscanthus, are likely to be economically attractive only in some locations in the Midwest given the high yields of corn and soybean in the region.     

Continuous biomethanization of agrifood industry waste: A case study in Spain

The anaerobic digestion technology is a biological treatment widely used to reduce the pollution load of wet waste biomass. In this work we present the results obtained by performing extensive experiments of anaerobic digestion of slaughterhouse waste, tomato industry waste and olive oil industry waste in continuous mode, which were designed to demonstrate that anaerobic digestion is an effective technology from an environmental and economic point of view.Biogas yields obtained are between 35.22 and 5.45 Nm³ biogas/m³ olive oil industry waste and tomato industry waste respectively and the slaughterhouse wastes achieve intermediate production, 30.86 Nm³ biogas/m³ municipal slaughterhouse waste and 22.53 Nm³ biogas/m³ Iberian pig slaughterhouse waste. Moreover, it possible to degrade between 63.46 and 75.3% of the initial organic matter.If these results are analyzed, the environmental, energetic economic benefits of anaerobic digestion can be quantified. Biomethanation of all these wastes generated annually in Extremadura could prevent the emission of 134,772 t of equivalent carbon dioxide, generate an energy similar to that provided by 2826 toe and reach payback times from 3.29 to 3.75 years for anaerobic digestion plant designed to treat the wastes generated by a medium-sized industry. So, we have fulfilled all the planned aims.     

Influence of nitrogen fertilization on tropical‐grass silage assessed by ensiling process monitoring using chemical and microbial community analyses

Aims: Utilization of silage in livestock farming is expected to increase in developing countries in the tropical and subtropical parts of the world. The aim of this study was to investigate the influence of nitrogen fertilization on the chemical composition of herbage, ensiling process and silage quality, and to contribute to the improvement of tropical‐grass silage preparation. Methods and Results: Guinea grass grown under two different nitrogen‐fertilizer application conditions [1·5 kg N a^?1 (high‐N) and 0·5 kg N a^?1 (low‐N)] was packed in plastic bags, and its ensiling process was investigated by chemical and microbial‐community analyses. Relatively well‐preserved silage was obtained from high‐N herbage, which accumulated a high nitrate concentration. Denaturing gradient gel electrophoresis analysis revealed that Lactobacillus plantarum dominated throughout the ensiling of high‐N herbage and in the early phase of that of low‐N herbage. In low‐N silages prepared from ammonium sulfate‐ and urea‐fertilized herbage, Lact. plantarum was replaced by clostridia after 40 and 15 days of ensiling, respectively. Conclusions: Nitrate content of herbage is an important factor that influences silage quality, and careful fertilization management can facilitate stable and successful fermentation of tropical‐grass silage without any pretreatment. Significance and Impact of the Study: The positive effect of nitrate on the ensiling process of tropical‐grass was proved by microbial‐community analysis.     

Anaerobic digestion of microalgal biomass with ultrasonic disintegration

The use of photosynthetic microalgae for nutrient removal and biofuel production has been widely discussed. Anaerobic digestion of waste microalgal biomass to produce biogas is a promising technology for bioenergy production. However, the methane yield from this anaerobic process was limited because of the hard cell wall of Chlorella vulgaris. The use of ultrasound has proven to be successful at improving the disintegration and anaerobic biodegradability of Chlorella vulgaris. Ultrasonic pretreatment in the range of 5–200 J ml⁻¹ was applied to waste microalgal biomass, which was then used for batch digestion. Ultrasound techniques were successful and showed higher soluble COD at higher applied energy. During batch digestion, cell disintegration due to ultrasound increased in terms of specific biogas production and the degradation rate. Compared to the untreated sample, the specific biogas production was increased in the ultrasound-treated sample by 90% at an energy dose of 200 J ml⁻¹. For the disintegrated samples, volatile solids reduction was also increased according to the energy input and degradation. These results indicate that the hydrolysis of microalgal cells is the rate-limiting step in the anaerobic digestion of microalgal biomass.     

Characterizing the ensiling properties of sugarbeets with dry feedstuffs

A study was conducted to evaluate the ensiling characteristics of chopped sugarbeets with dry feedstuffs and the corresponding change in the nutritive composition of the silages with the addition of dry substrates. Pre-calculated amounts of each feedstuff were weighed individually to achieve desired proportions of each silage product and thoroughly mixed for 5 min. After mixing, the silage was distributed evenly into three 19-L buckets and sealed to provide an anaerobic environment. The treatments for this study were arranged in a 4 × 4 + 1 factorial design to determine the effects of DM level and source of dry feedstuff on the ensiling properties of sugarbeets following a 42-d fermentation period. Treatments were ensiled sugarbeets alone (250 g/kg) or based on (1) formulated silage DM concentrations of 275, 350, 425, and 500 g/kg and (2) the inclusion of dry feedstuffs (alfalfa hay, dry-rolled corn, wheat middlings, and wheat straw). Fermentation and nutritive characteristics of ensiled sugarbeets were influenced with the addition of dry substrates. A linear increase (P<0.001) in silage pH was observed with the addition of alfalfa, dry-rolled corn, wheat middlings, and wheat straw to ensiled sugarbeets. Lactic acid increased (P<0.001) with the addition of wheat middlings. Alfalfa addition to sugarbeet silage did not alter (P<0.001) lactate concentration. Concentration of lactate decreased (P=0.01) when corn was added, while wheat straw addition did not influence (P=0.37) lactate. A contrast was used to compare ensiling characteristics of sugarbeets alone (250 g/kg DM) to 350 g/kg DM (sugarbeets with dry substrates). Results indicated fermentative parameters were altered; pH increased (P<0.001) for all dry substrates while lactate was lower (P=0.003) for the sugarbeets ensiled with dry-rolled corn compared with sugarbeets ensiled alone. Alfalfa, wheat straw, and wheat middlings decreased (P<0.001) while dry-rolled corn did not affect (P=0.54) in vitro DM digestion. These results indicate the inclusion of dry feedstuffs with sugarbeets altered fermentation and with the exception of corn, decreased in vitro DM digestion. Nutrient composition and DM content of ensiled sugarbeets was altered with the addition of dry substrates.     

Valorization of different landrace and commercial sorghum (Sorghum bicolor (L.) Moench) straw varieties by anaerobic digestion

To reduce the impact on the environment and enhance the sustainability of resources, it is necessary to promote and strengthen the use of landrace cultivars that advocate regenerative agriculture. In this study, the growth and development as well as the anaerobic digestion (AD) of six different landrace cultivars, two commercial hybrids cultivars and a public genotype of Sorghum bicolor have been evaluated. The landrace cultivars, in general, presented greater heights, biomass yields and compactness shoots as well as similar or an improvement in grain production compare to the commercial varieties. The AD of the different sorghum straws was performed in batch mode at mesophilic temperature (35°C). The landrace cultivar Zahina (ZH) obtained the highest final methane yield (413 ± 79 NL CH₄ kg⁻¹ VS, volatile solids) but the landrace cultivars Zahina gigante (ZHG) and Trigomillo (TG) were the ones that obtained the highest methane per biomass production (13.7 and 12.7 NL CH₄ shoot unit⁻¹, respectively). By contrast, the commercial varieties were the ones that obtained the lowest methane yields. Two mathematical models, first-order kinetics and the Transference Function model, were used to fit the experimental data with the aim of describing and simulating the anaerobic biodegradation of these S. bicolor straw varieties and obtaining the kinetic constants. Both models allowed for adequately fitting the experimental results of methane production with time. In particular, the fastest biomethanization occurred using the commercial variety PR88Y20 (PR88) (specific rate constant k = 0.148 ± 0.008 days⁻¹), while the slowest one was obtained from Panizo (PAN) variety (k = 0.064 ± 0.005 days⁻¹). In addition, the highest values of the maximum methane production rate, R_m, were attained for the varieties ZH and PR88, which were 87.1% and 71.3% higher than that achieved for the PAN variety, which exhibited the lowest value.     

Biotechnology and the improvement of silage (tropical and temperate) rumen digestion: a mini-review

Summary As with forage diets in general, ensiled tropical residue feeds and temperate grass and legume herbage tend to have lower fibre digestibility, ruminal biomass production and feed bypass, resulting in limited protein nutrition and intake in the animal. Various modified (recombinant and mutated) microbial inculants might be used mainly to: (1) boost lactic acid production in temperate silage to stabilize against further clostridial protein breakdown during the ensiling process and effect silage fibre (lignin, cellulose, and hemicellulose) digestion to increase digestibility and (2) increase microbial digestion of fibre along with boosting microbial protein synthesis to increase microbial biomass production in the rumen.     

Full assessment of Sida (Sida hermaphrodita) biomass as a solid fuel

Due to an increased awareness of climate change and limited fossil resources, the demand for alternative energy carriers such as biomass has risen significantly during the past years. This development is supported by the idea of a transition to a bio‐based economy reducing fossil‐based carbon dioxide emissions. Based on this trend, biomass for energy is expected to be used in the EU mainly for heating until the end of the decade. The perennial herbaceous mallow plant Sida hermaphrodita (L.) Rusby (‘Sida’) has high potential as an alternative biomass plant for energy purposes. Different density cultivation scenarios of Sida accounting for 1, 2, or 4 plants per m² resulted in a total biomass yield of 21, 28, and 34 tons dry matter/ha, respectively, over a 3‐year period under agricultural conditions while the overall investment costs almost doubled from 2 to 4 plants per m². Subsequently, Sida biomass was used as SI) chips, SII) pellets, and SIII) briquettes for combustion studies at pilot plant scale. Pellets outcompeted chips and briquettes by showing low CO emission of 40 mg/Nm³, good burnout, and low slagging behavior, however, with elevated NO_x and SO₂ levels. In contrast, combustion of chips and briquettes displayed high CO emissions of >1,300 mg/Nm³, while SO₂ values were below 100 mg/Nm³. Contents of HCl in the flue gas ranged between 32 and 52 mg/Nm³ for all Sida fuels tested. High contents of alkaline earth metals such as CaO resulted in high ash melting points of up to 1,450°C. Life cycle assessment results showed the lowest ecological impact for Sida pellets taking all production parameters and environmental categories into consideration, showing further advantages of Sida over other alternative biomasses. Overall, the results indicate the improved applicability of pelletized Sida biomass as a renewable biogenic energy carrier for combustion.