Screening, mutagenesis and protoplast fusion of Aspergillus niger for the enhancement of extracellular glucose oxidase production

Various strains of Aspergillus niger were screened for extracellular glucose oxidase (GOD) activity. The most effective producer, strain FS-3 (15.9 U mL^–1), was mutagenized using UV-irradiation or ethyl methane sulfonate. Of the 400 mutants obtained, 32 were found to be resistant to 2-deoxy d-glucose, and 17 of these exhibited higher GOD activities (from 114.5 to 332.1%) than the original FS-3 strain. Following determination of antifungal resistance of the highest producing mutants, four mutants were selected and used in protoplast fusions in three different intraspecific crosses. All fusants showed higher activities (from 285.5 to 394.2%) than the original strain. Moreover, of the 30 fusants isolated, 19 showed higher GOD activity than their corresponding higher-producing parent strain.     

ARTP诱变猴头菌株的发酵菌丝体多糖理化性质及体外免疫活性

为探讨常压室温等离子体诱变的3株高产多糖猴头菌和出发菌株的多糖组分差异,通过液体发酵获得的菌丝体经水提、分级醇沉获得8个胞内多糖组分,对它们的理化性质、结构特征及体外免疫活性进行了研究。结果表明,3株ARTP诱变菌株414、321、236菌丝体多糖含量较出发菌株有较明显提升;ARTP诱变的猴头菌20%醇沉多糖组分较出发菌株分子量大,所占比例增加;诱变菌株60%醇沉多糖组分的分子量略大于出发菌株,所占比例相近。20%醇沉多糖主要由半乳糖、葡萄糖、甘露糖构成,诱变菌株该多糖组分中葡萄糖和甘露糖的比例较出发菌株均有明显提升,60%醇沉多糖组分单糖组成无明显差异;8个多糖组分均具有体外刺激巨噬细胞释放NO的活性,其中20%醇沉多糖的活性优于60%醇沉多糖,诱变菌株的生物活性优于出发菌株。本研究探讨了ARTP诱变对猴头菌胞内多糖结构及活性的影响,为猴头菌相关产品的开发提供了优质资源。     

Screening and Mutagenesis of Aspergillus niger for the Improvement of Glucose-6-Phosphate Dehydrogenase Production

The Aspergillus niger strain ZBY-7 was selected as the original strain of glucose-6-phosphate dehydrogenase production. After mutagenesis of the strain by means of UV irradiation and nitrosoguanidine, mutants of Aspergillus niger resistant to a certain metabolic inhibitor were obtained. Five of the mutants showed increased glucose-6-phosphate dehydrogenase production. The mutant resistant to antimycin A (Aspergillus niger AM-23) produced the highest level of glucose-6-phosphate dehydrogenase (695.9% of that produced by the original strain).     

定向进化Rho1提高酿酒酵母的乙醇耐受性和超高浓度乙醇发酵性能

燃料乙醇发酵过程中酿酒酵母细胞活性被高浓度乙醇严重抑制而导致发酵提前终止，生产强度严重降低，因此构建同时具有高耐受性、高发酵性能的菌株一直是发酵工业追求的目标。选取酿酒酵母细胞形态调节关键基因小GTP酶家族成员Rho1,构建易错PCR产物文库，以酿酒酵母S288c为出发菌株采取“富集-自然生长-复筛”的筛选策略，成功筛选得到两株乙醇胁迫耐受性与发酵性能均提高的突变株M2和M5。测序发现突变株过表达的Rho1序列出现了3～5个氨基酸的突变和大片段的缺失突变。以300 g/L起始葡萄糖进行乙醇发酵，72 h时，M2和M5的乙醇滴度比对照菌株分别提高了19.4%和22.3%,超高浓度乙醇发酵能力显著提高。本研究为利用蛋白定向进化方法改良酵母菌复杂表型提供了新的作用靶点。     

农用抗生素TS99高产菌株的选育

在明确链霉素对农抗TS99产生菌Streptomyces fungicidicus YH04孢子的致死浓度为1.2μg/mL的基础上,以链霉素致死浓度为选择压力,采用不同剂量的紫外线照射对菌株孢子进行诱变处理,获得了大量的链霉素抗性基因突变株,进而从中筛选到发酵效价较出发菌株提高60%以上,且遗传稳定性良好的高产菌株Streptomyces fungicidicus YH9407.     

Cellulase production on glucose-based media by the UV-irradiated mutants of Trichoderma reesei

From 22,791 mutants of a cellulase hyper-producing strain of Trichoderma reesei (Hypocrea jecorina), ATCC66589, as the parent, we selected two mutants, M2-1 and M3-1, that produce cellulases in media containing both cellulose and glucose. The mutation enabled the mutants to produce cellulases, which were measured as p-nitrophenyl β-d-lactopyranoside-hydrolyzing activities, in media with glucose as a sole carbon source, although M2-1 exhibited different sensitivities to glucose from M3-1. When the mutants were grown for 8 days on a medium with cellulose as a sole carbon source, the filter-paper-degrading activities (FPAs) per gram of cellulose were 257 and 281 U for M2-1 and M3-1, respectively, values that were 1.1–1.2 times higher than that of the parental strain. Cellulase production by M2-1 and M3-1 on a medium with a continuously fed mixture of glucose and cellobiose resulted in 214 and 210 U of FPA/gram carbon sources, respectively, whereas less efficient production (140 U of FPA/gram carbon source) was achieved by the parental strain. The improved cellulase productivity of the mutants allows us to use glucose as a carbon source for efficient on-site production of cellulases with quality/quantity-controlled feeding of soluble carbon sources and inducers.     

Improvement of the basidiomyceteCoprinus sp.

Coprinus sp. C-1 (obtained from uranium mines) was subjected to improvement procedures with the aim of preparing a strain that could degrade cellulose in the straw substrate more rapidly and effectively. The original C-1 strain was highly resistant to UV and X radiation but it was rather sensitive to tris(2-chloroethyl)amine, the effect of which increased when applying simultaneously compounds reacting with mercapto groups of some enzymes. The mutants obtained synthesized during the same interval by up to 94% more N compounds than the original strain the rate of cellulose degradation increasing by about 40%. In certain mutants the content of some essential amino acids simultaneously increased by up to 110%.     

Drug resistance marker-aided genome shuffling to improve acetic acid tolerance in <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis>

Acetic acid existing in a culture medium is one of the most limiting constraints in yeast growth and viability during ethanol fermentation. To improve acetic acid tolerance in Saccharomyces cerevisiae strains, a drug resistance marker-aided genome shuffling approach with higher screen efficiency of shuffled mutants was developed in this work. Through two rounds of genome shuffling of ultraviolet mutants derived from the original strain 308, we obtained a shuffled strain YZ2, which shows significantly faster growth and higher cell viability under acetic acid stress. Ethanol production of YZ2 (within 60 h) was 21.6% higher than that of 308 when 0.5% (v/v) acetic acid was added to fermentation medium. Membrane integrity, higher in vivo activity of the H⁺-ATPase, and lower oxidative damage after acetic acid treatment are the possible reasons for the acetic acid-tolerance phenotype of YZ2. These results indicated that this novel genome shuffling approach is powerful to rapidly improve the complex traits of industrial yeast strains.     

原生质体融合提高农抗武夷菌素的效价

从农抗武夷菌素产生菌不吸水链霉菌武夷变种菌株Co-N-31诱变获得两个突变株M35(Leu^-,孢子颜色灰色)和M46(ser^-.孢子颜色灰白色),并以此两突变株为直接亲本在25％ PEG1000诱导下进行种内原生质体融合。M35和M46原生质体再生率分别为3.72％和0.248％,重组频率为55.20％。采用间接法选择营养标记互补的稳定的原养型重组子,并从中获得一株高产菌株F31-24;其效价比原始亲本Co-N-31提高了82％。薄层层析结果表明,菌株F31-24和Co-N-31的发效产物在Rf值为0.50和0.26处均有斑点,但含量有异。测定斑点生物活性证明其均有抑菌活性。温室试验表明,菌株F31-24发酵产物对小麦白粉病的防治效果优于菌株Co-N-31。     

Strain improvement of a mildiomycin producer,Streptoverticillium rimofaciens B-98891

Summary Aminopterin (10 g/ml) was found to inhibit the formation of 5-hydroxymethylcytosine (HMC), a constituent of mildiomycin, without affecting the growth ofStreptoverticillium rimofaciens. This was available for selecting high-producing mutants.d-Cycloserine caused its morphological mutations at high frequency. In addition, mildiomycin (MIL) production varied widely among the strains picked up from colonies that developed on agar medium containing cycloserine at the inhibitory concentration to the growth. Consequently, we selected the mutants which were capable of producing MIL on agar medium containing 10 g/ml of aminopterin, among mutants enriched by cycloserine. A high-producing mutant thus obtained, C _R ⁴ -257, exhibited higher enzymatic activity of the HMC formation and higher resistance todl-serine hydroxamate than the original strain.l-Canavanine resistant mutants were furthermore selected to enhance the biosynthetic activity of the arginine-like moiety of MIL. Among them, we finally obtained an excellent mutant, CV^R-48, with an MIL production 2.6 times that of the original strain,S. rimofaciens B-98891.     

纳豆芽孢杆菌产VK2菌株的NTG与N＋注入复合诱变选育

以纳豆芽孢杆菌BN-2-6为出发菌株,利用亚硝基胍（NTG）和N＋注入复合诱变选育产维生素K2的突变株。经过NTG诱变后得到突变株BN-N30—1,其维生素K2的产量提高了53％,继而采用低能N＋注入技术进行处理得到突变株BN-P15—11-1,维生素K2的产量比BN—N30—1提高了96％,比原始菌株提高了166％。结果表明,对纳豆芽孢杆菌BN-2-6进行NTG和低能N＋注入复合诱变的效果明显,突变菌株维生素K2的产量显著提高。     

内切葡聚糖酶高产菌株的诱变选育

【目的】建立里氏木霉(Trichoderma reesei)高产突变菌株的快速筛选方法,选育出高产内切葡聚糖酶的突变株。【方法】对里氏木霉T306菌株的初筛培养基进行优化,建立快速筛选方法;通过紫外诱变手段选育内切葡聚糖酶高产突变菌株,并对突变菌株的产酶培养基进行优化。【结果】在初筛培养基中添加浓度为0.1%(W/V)的乳糖、蛋白胨及脱氧胆酸钠有利于菌株的筛选。诱变后筛选出菌落形态发生明显变化的内切葡聚糖酶高产突变株0516,其羧甲基纤维素酶活力(CMC酶)较出发菌株提高了38.9%。其产酶培养基经优化后,得到最适碳、氮源分别为:乳糖1.50%、硫酸铵0.14%、尿素0.05%、蛋白胨0.10%,优化后CMC酶活力达64.2 U/mL,较优化前提高了2.3倍。【结论】建立了里氏木霉高产突变菌株的快速筛选方法,通过紫外诱变育种获得了产内切葡聚糖酶能力高且遗传稳定的突变株0516。     

Breeding of a 5-Fluorouridine-resistant Mutant with Increased Cellulose Production from Acetobacter xylinum subsp. nonacetoxidans

UDP-glucose (UDP-G), the direct precursor of cellulose, is known to be produced from UTP and glucose-1-phosphate. In an attempt to increase UTP biosynthesis, 5-fluorouridine (5-FUR: a pyrimidine analog)-resistant mutants were obtained using Acetobacter xylinum subsp. nonacetoxidans 757 as the parent strain. One of the 5-FUR-resistant mutants, FUR-35, showed about 40% higher cellulose productivion compared to the parent strain. Intracellular levels of UTP and UDP-G in FUR-35 was found to be higher than those in the parent strain. The carbamyl phosphate synthetase II (CPS) activity of FUR-35 was higher than that of the parent strain and the feedback inhibition of CPS by UTP in FUR-35 had been released compared with that in the parent strain. These results suggest that the increased cellulose production of FUR-35 was attributable to its higher of intracellular UDP-G level resulting from increased UTP biosynthesis.     

Strain improvement ofArthrobacter simplex by protoplast fusion

Anl-tryptophan auxotroph and milky mutants were derived from an inducible cholesterol oxidase-producing bacterium,Arthrobacter simplex USA18, via UV-mutagenesis. Protoplasts of these mutants and a constitutive cholesterol oxidase producer, strain US3011, were prepared by growing cells in the presence of ampicillin (20g ml^–1) followed by digestion with lysozyme. Protoplast fusion between tested strains with complementary characteristics was achieved in the presence of 20–40% polyethylene glycol 6000. The fusion frequency was about 1.5–1.7×10^–3. The cholesterol oxidase activity of four fusants in a cholesterol-containing medium was 20–60% higher than that of parental strains. This study demonstrated that protoplast fusion is applicable to strain improvement ofArthrobacter strains for enzyme production.     

Mutants of Streptococcus gordonii Challis over-producing glucosyltransferase

Two mutants of Streptococcus gordonii which over-produced extracellular polysaccharide when grown on sucrose-containing medium were isolated after mutagenesis of strain Challis with ethyl methanesulphonate. The mutants, designated strains OB20 and OB30, expressed 2.6-fold and 4.7-fold respectively more glucosyltransferase (GTF) activities than the wild-type strain. Transformation experiments suggested that the two mutants carried different mutations, denoted gtf-20 and gtf-30. A double mutant (gtf-20 gtf-30) was constructed and this strain produced 6.4-fold more GTF. Enzymes from wild-type and mutant strains were biochemically indistinguishable and they synthesized structurally identical glucans. Increasing the Na+ concentration of the bacterial growth medium reduced GTF production in all strains by about 60%. Tween 80 also inhibited enzyme production and more specifically reduced GTF synthesis by the mutants. The mutations gtf-20 and gtf-30 appear to define separate genetic loci involved in regulating expression of GTF activity in S. gordonii.     

Properties of heterozygous diploids between strains ofPenicillium chrysogenum selected for high penicillin yield

Three strains ofPenicillium chrysogenum selected for high penicillin yield and of independent lineage were marked with suitable genetical characters prior to the synthesis of several heterozygous diploids. These parental strains had domestic codes, C, D and Y. Two diploids, between differently labelled mutants of strain C and Y, produced similar amounts of penicillin to strain C, which was less than that produced by strain Y. Previous work had indicated that genes responsible for increased penicillin yield were recessive and the present results suggested that such genes in strains C and Y were allelic, apart from the presence of one or more additional recessive mutations leading to greater penicillin production in the higher yielding parent. Three diploids made between mutants of strains D and Y were lower in penicillin yield than either original parent and only in the case of one diploid compared with one of the parental strains was this difference not significant. In strains D and Y, therefore, there may have been some recessive genes concerned with increasing penicillin yield which were non-allelic. However, no first order segregants arising spontaneously or subsequent to X-ray treatment produced higher levels of penicillin than the better yielding original parent in any cross.     

结合缺陷型菌株显色法采用离子束诱变筛选高产L-精氨酸突变株

为快速高效筛选L-精氨酸高产突变株,建立一种缺陷菌株平板显色法并采用低能N+离子束对L-精氨酸生产用菌株钝齿棒杆菌SYPA5-5进行诱变处理,通过上述平板显色法筛选获得高产突变株.对突变株进行摇瓶发酵实验,最终选育出一株L-精氨酸产量较高且产酸性能比较稳定的突变菌株钝齿棒杆菌SYPA5-5-36.该菌株摇瓶发酵L-精氨酸产量可达35.85 g/L,比出发菌株提高了19.5％.因此,缺陷型菌株平板显色法可以用于快速、高效筛选高产L-精氨酸突变株.     

Ethanol and glycerol production under aerobic conditions by wild-type,respiratory-deficient mutants and a fusion product of Saccharomyces cerevisiae

Summary Experiments were performed to investigate growth, ethanol and glycerol production by wild-type strains (RHO) and respiratory-deficient (rho) mutants of Saccharomyces cerevisiae. Furthermore protoplasts were fused in order to enhance the fermentation capacity of a flocculent strain. At high substrate conditions, 150 g/l of saccharose, there is no difference in cell growth. However, at a glucose concentration of 10–20 g/l the mutants grow much slower. After 3 days of incubation at 28° C in a complete medium the viability of the two strains is the same. In minimal medium on the other hand the number of viable cells of the mutant is 100-fold reduced. All mutants tested showed a higher specific activity of alcohol dehydrogenase (ADH I) and an enhanced production of glycerol compared with the wild-type strain. By protoplast fusion a modified flocculent strain was obtained with higher specific activity of ADH I and a reduced biosynthesis of glycerol. However, the yields of ethanol (75–78%) are about the same for the wild-type strain and the rho mutants under aerobic conditions in absence of catabolite repression.     

大肠杆菌酪氨酸转运系统基因敲除对酪氨酸生产的影响

酪氨酸是三大芳香族氨基酸之一,广泛用于食品、医药和化工等领域。转运系统工程为代谢工程改造大肠杆菌选育酪氨酸生产菌株提供了一种重要的研究策略。大肠杆菌中酪氨酸胞内转运主要通过aroP和tyrP基因编码的通透酶进行调控。以酪氨酸生产菌株HGXP为出发菌株,利用CRISPR-Cas9技术成功构建了aroP和tyrP基因敲除菌,并通过发酵试验考察了调节转运系统对酪氨酸生产的影响。发酵结果表明,aroP和tyrP基因敲除菌酪氨酸产量分别达到3.74 g/L和3.45 g/L,较出发菌株酪氨酸产量分别提高了19%和10%。对诱导温度进行了优化,结果表明38℃为最佳诱导温度。在3 L发酵罐上进行了补料分批发酵,aroP和tyrP基因敲除菌酪氨酸产量进一步提高至44.5 g/L和35.1 g/L,较出发菌株酪氨酸产量分别提高了57%和24%。研究结果对代谢工程强化大肠杆菌生产酪氨酸具有重要的参考价值。