Production of Biomass and Ginsenosides from Adventitious Roots of Panax ginseng in Bioreactor Cultures

Organic nutrients play a central role during Panax ginseng adventitious root culture in bioreactor systems. To understand how the nutrient elements were uptaken during the adventitious root growth as well as the production of biomass and natural ginsenosides, a biotechnological approach to identifying the nutritional physiology of ginseng in a commercial‐scale bioreactor was necessary. Normal MS medium nutrient in the bioreactor culture of adventitious roots resulted in slow growth, low biomass, and Rg and Rb ginsenoside contents. When the ginsenoside production increased to higher levels, a group of regulatory nutritional elements that have the potential to interact with biomass was identified. The effects of the salt strength of the medium, of macroelements, metal elements, the ammonia/nitrate ratio, sucrose concentration, and osmotic agents on the growth, the formation of biomass and the production of ginsenosides from adventitious roots were investigated. Appropriate conditions allowed for a maximum ginsenoide production of up to 12.42 [mg/g DW] to be obtained after 5 weeks of culture. The results demonstrated that the key organic nutrients can be regulated to improve the biomass and growth, and increase the ginsenoside yield in bioreactor cultures of P. ginseng adventitious roots.     

小型生物反应器内人参不定根的人参皂苷累积

对小型生物反应器(3~10 L)培养人参不定根的生长和人参皂苷(Rg1、Re、Rb1)的累积规律,以及蔗糖浓度、初始接种量对其生长和人参皂苷累积的影响进行研究。结果表明:小型生物反应器内人参不定根的最佳收获周期为7周。初始接种量和蔗糖浓度影响生物反应器内人参不定根的生长和人参皂苷的累积,20或40 g/L蔗糖对人参不定根的生长和人参皂苷的累积优于60 g/L蔗糖;5和10 L生物反应器内最佳初始接种量分别为15和30g,其不定根的生长量分别为9.29和19.17 g,人参皂苷含量分别为5.16和4.58 mg/g。生物反应器内培养7周的人参与栽培4年的人参相比,人参皂苷Rg1和Re含量相差不大,但栽培人参中Rb1的含量远高于生物反应器中所培养的人参不定根。     

Selection and optimization of a high-producing tissue culture of <Emphasis Type="Italic">Panax ginseng</Emphasis> C. A. Meyer

Biomass growth, ginsenoside and polysaccharide production in different ginseng tissue cultures, including callus culture, adventitious root culture and hairy root culture, were studied, and the active component contents were compared with that of native ginseng roots. The adventitious root culture was confirmed to be a very nice system, which grew fast and contained a rather high content of ginsenosides. Then, the culture conditions of adventitious root culture were optimized. The results showed that salt strength, various sucrose concentrations, ammonia/nitrate ratios and phosphate concentrations had significant influences on adventitious roots growth, secondary metabolite and polysaccharide synthesis in ginseng. The best culture conditions for ginsenoside production seemed to be 0.75 salt strength Murashige and Skoog medium, 4% sucrose, 9 mM ammonia to 36 mM nitrate, and 1.25 mM phosphate, while the optimization for polysaccharide accumulation seemed to be 0.75 salt strength, 6% sucrose, 9 mM ammonia to 36 mM nitrate and 3.75 mM phosphate source. Appropriate conditions allowed for a maximum ginsenoside yield of up to 132.90 mg/L and polysaccharide yield of 407.63 mg/L to be obtained after 4 weeks of culture.     

Production of adventitious root biomass and secondary metabolites of Hypericum perforatum L. in a balloon type airlift reactor

The effects of inoculum density, aeration volume and culture period on accumulation of biomass and secondary metabolites in adventitious roots of Hypericum perforatum in balloon type airlift bioreactors (3 l capacity) were investigated. The greatest increment of biomass as well as metabolite content occurred at an inoculum density of 3 g l⁻¹ and an aeration volume of 0.1 vvm. After 6 weeks of culture, an approximately 50-fold increase in biomass was recorded containing 60.11 mg g⁻¹ dry weight (DW) of phenolics, 42.7 mg g⁻¹ DW of flavonoids and 0.80 mg g⁻¹ DW of chlorogenic acid. Liquid chromatography–mass spectroscopy/mass spectroscopy demonstrated that the presence of quercetin and hyperoside in adventitious roots at a level of 1.33 and 14.01 μg g⁻¹ DW, respectively after 6 weeks of culture. The results suggest scale-up of adventitious root culture of H. perforatum for the production of chlorogenic acid, quercetin and hyperoside is feasible.     

Inoculum size and auxin concentration influence the growth of adventitious roots and accumulation of ginsenosides in suspension cultures of ginseng ( Panax ginseng C.A. Meyer)

The effect of the root-inoculum size and axuin concentration on growth of adventitious roots and accumulation of ginsenosides were studied during suspension cultures of ginseng (Panax ginseng C.A. Meyer). Of the various concentrations of indole-3-butyric acid (IBA) and γ-naphthaleneacetic acid (NAA) used as supplementary growth regulators along with Murashige and Skoog medium, 25 μM IBA was found suitable for lateral root induction and growth, as well as accumulation of ginsenosides. Inoculum size of 5 g L⁻¹ was found suitable for optimal biomass (10.5 g L⁻¹ dry biomass) and ginsenosides (5.4 mg g⁻¹ DW) accumulation. Of the various length of root inocula tested (chopped to 1–3, 4–6, 7–10 mm and un-chopped), root inocula of 7–10 mm was found suitable for biomass and ginsenoside accumulation.     

Sucrose-induced osmotic stress affects biomass,metabolite, and antioxidant levels in root suspension cultures of <Emphasis Type="Italic">Hypericum perforatum</Emphasis> L.

In this study, we investigated the influence of initial sucrose concentration on the accumulation of biomass, phenols, flavonoids, chlorogenic acid, and hypericin in adventitious root cultures of Hypericum perforatum L. Cultures were initiated in shake flasks by using half-strength Murashige and Skoog (MS) medium, 1.0 mg l⁻¹ indolebutyric acid (IBA), 0.1 m g l⁻¹ kinetin, and different concentrations 0, 1, 3, 5, 7, or 9% in w/v) of sucrose and were maintained in darkness. The medium supplemented with 3% (w/v) sucrose resulted in the optimum biomass accumulation, but higher sucrose concentrations (5, 7, and 9%) inhibited biomass accumulation due to the relatively higher osmotic pressure. However, the amount of total phenols, flavonoids, chlorogenic acid, and total hypericin was increased with the roots grown in the medium supplemented with 5, 7, and 9% (w/v) sucrose. The antioxidant potential of methanolic extract [1,1-diphenyl-2-picrylhydrazyl (DPPH) and 2,2-azino-bis-(3-ethylbenzothiazoline-6-sulfonic acid; ABTS) radical scavenging activities] of H. perforatum adventitious roots was also assessed and correlated with the metabolite accumulation. Cultures maintained with higher initial sucrose concentration (5, 7, and 9% w/v) showed increased accumulation of phenols, flavonoids, chlorogenic acid, and total hypericin, and this might be due to the osmotic stress at elevated sucrose concentrations. To verify the effect of osmotic stress on lipid peroxidation, the levels of hydrogen peroxide (H₂O₂), malondialdehyde (MDA), and proline were determined in the adventitious roots and the results revealed a marked increase in the concentrations of these compounds. These results suggest that optimal adventitious root biomass could be achieved in the MS medium with 3% (w/v) sucrose and increased sucrose concentration resulted in osmotic stress and, in turn, induces the accumulation of secondary metabolites.     

Effects of macro elements and nitrogen source on adventitious root growth and ginsenoside production in ginseng (Panax ginseng C. A. Meyer)

We investigated the effects on ginseng adventitious root growth and ginsenoside production when macro-element concentrations and nitrogen source were manipulated in the culture media. Biomass growth was greatest in the medium supplemented with 0.5-strength NH₄PO₃, whereas ginsenoside accumulation was highest (9.90 mg g^-1 DW) in the absence of NH₄PO₃. At levels of 1.0-strength KNO₃, root growth was maximum, but a 2.0 strength of KNO₃ led to the greatest ginsenoside content (9.85 mg g^-l). High concentrations of MgSO₄ were most favorable for both root growth and ginsenoside accumulation (up to 8.89 mg g^-1 DW). Root growth and ginsenoside content also increased in proportion to the concentration of CaCI₂ in the medium, with the greatest accumulation of ginsenoside (8.91 mg g^-1 DW) occurring at a 2.0 strength. The NH₄/NO₃ ^-- ratio also influenced adventitious root growth and ginsenoside production; both parameters were greater when the NO₃ ^- concentration was higher than that of NH₄ ⁺. Maximum root growth was achieved at an NH₄ ⁺/NO₃ ^- ratio of 7.19/18.50, while ginsenoside production was greatest (83.37 mg L^-1) when NO₃ ^- was used as the sole N source.     

Improvement of ginsenoside production by jasmonic acid and some other elicitors in hairy root culture of ginseng (Panax ginseng C. A. Meyer)

Summary Hairy root cultures of Panax ginseng, established after the infection of root sections with Agrobacterium rhizogenes KCTC 2703, were cultured in phytohormone-free Murashige and Skoog (MS) liquid medium containing different concentrations of jasmonic acid and some other elicitors, in order to promote ginsenoside accumulation. Jasmonic acid in the range 1.0−5.0 mg l⁻¹ (4.8–23.8 μM) strongly improved total ginsenoside production in ginseng hairy roots. Peptone (300 mg l⁻¹) also showed some effect on ginsenoside improvement; however its effect was much weaker than that of jasmonic acid. Ginsenoside content and productivity were 58.65 and 504.39 mg g⁻¹, respectively. The Rb group of ginsenoside content was increased remarkably by jasmonic acid, while Rg group ginsenoside content changed only slightly compared to controls. However, jasmonic acid also strongly inhibited ginseng hairy root growth.     

Effect of polyploidy induction on biomass and ginsenoside accumulations in adventitious roots of ginseng

Adventitious roots ofPanax ginseng C.A. Meyer (a natural tetraploid) were treated with 50 or 100 mg L^-1 colchicine for 12, 24,36, 48, or 60 h to induce polyploid (octoploid) roots. The largest number of octoploid roots was obtained with a 100 mg L^-1 colchicine treatment over 60 h. To verify that ginsenoside was being accumulated in the developing tissues, the tetraploid (control) and octoploid roots were cultured for 40 d in Murashige and Skoog media that lacked NH₄NO₃ but was supplemented with 2 mg L^-1 naphthaleneacetic acid and 50 g L_-1 sucrose. Levels of fresh and dry biomass were greater in the octoploid roots. Although total ginsenoside and Rb-group ginsenoside contents were less in the octoploid roots than in the tetraploids, the former had a higher amount of Rg-group ginsenosides (especially Rg1). These results demonstrate the benefit that polyploid adventitious roots provide in enhancing the production of secondary metabolites in ginseng.     

Adventitious root growth and ginsenoside accumulation in Panax ginseng cultures as affected by methyl jasmonate

Adventitious roots of ginseng were treated with methyl jasmonate (MJ) up to 150 microM and cultured for 40 days. Up to 100 microM MJ inhibited the root growth but increase ginsenoside accumulation. In a two-stage bioreactor culture, total ginsenosides, after elicitation with 100 microM MJ peaked after 10 days at 48 mg g(-1) dry wt and then dropped sharply. Of the two groups of ginsenosides (Rb and Rg), higher amounts of Rb accumulated in the adventitious roots.     

Gradually scale-up culture in a bioreactor promotes radical scavenging activity of <Emphasis Type="Italic">Panax ginseng</Emphasis> (C. A. Meyer) adventitious roots on 1,1-diphenyl-2-picrylhydrazyl

A scale-up culture of adventitious roots of ginseng was established using a balloon-type bubble bioreactor (BTBB). Maximum growth rates of ~52-fold and ~50-fold in 3 and 5 L BTBBs were obtained, respectively after 40 days of inoculation, which was significantly higher than that in 0.5 L conical flask (~15-fold). Gradually scale-up culture of adventitious roots increased the root biomass, while the contents of ginsenoside and polysaccharides were not affected. This study also revealed that radical scavenging activity of dried adventitious roots on 1,1-diphenyl-2-picrylhydrazyl was higher than that of native roots at 20–100 mg L⁻¹ methanolic extract.     

Impacts of methyl jasmonate and phenyl acetic acid on biomass accumulation and antioxidant potential in adventitious roots of <Emphasis Type="Italic">Ajuga bracteosa</Emphasis> Wall ex Benth., a high valued endangered medicinal plant

Ajuga bracteosa is a medicinally important plant globally used in the folk medicine against many serious ailments. In the present study, effects of two significant elicitors, methyl jasmonate (Me-J) and phenyl acetic acid (PAA) were studied on growth parameters, secondary metabolites production, and antioxidant potential in adventitious root suspension cultures of A. bracteosa. The results showed a substantial increase in biomass accumulation, exhibiting longer log phases of cultures growth in response to elicitor treatments, in comparison to control. Maximum dry biomass formation (8.88 DW g/L) was recorded on 32nd day in log phase of culture when  0.6 mg/L Me-J was applied; however, PAA at 1.2 mg/L produced maximum biomass (8.24 DW g/L) on day 40 of culture.  Furthermore, we observed the elicitors-induced enhancement in phenolic content (total phenolic content), flavonoid content (total flavonoid content) and antioxidant activity (free radical scavenging activity) in root suspension cultures of A. bracteosa. Application of 0.6 mg/L and 1.2 mg/L of Me-J, root cultures accumulated higher TPC levels (3.6 mg GAE/g DW) and (3.7 mg GAE/g DW) in the log phase and stationary phase, respectively, while 2.5 mg/L Me-J produced lower levels (1.4 mg GAE/g DW) in stationary phase of growth stages. Moreover, TFC and FRSA values were found in correspondence to TPC values in the respective growth phases at the similar elicitor treatment. Thus, a feasible protocol for establishment of adventitious roots in A. bracteosa was developed and enhancement in biomass and metabolite content in adventitious root was promoted through elicitation.     

Large-scale cultivation of adventitious roots of Echinacea purpurea in airlift bioreactors for the production of chichoric acid, chlorogenic acid and caftaric acid

Adventitious roots of Echinacea purpurea were cultured in airlift bioreactors (20 l, 500 l balloon-type, bubble bioreactors and 1,000 l drum-type bubble bioreactor) using Murashige and Skoog (MS) medium with 2 mg indole butyric acid l⁻¹ and 50 g sucrose l⁻¹ for the production of chichoric acid, chlorogenic acid and caftaric acid. In the 20 l bioreactor (containing 14 l MS medium) a maximum yield of 11 g dry biomass l⁻¹ was achieved after 60 days. However, the amount of total phenolics (57 mg g⁻¹ DW), flavonoids (34 mg g⁻¹ DW) and caffeic acid derivatives (38 mg g⁻¹ DW) were highest after 50 days. Based on these studies, pilot-scale cultures were established and 3.6 kg and 5.1 kg dry biomass were achieved in the 500 l and 1,000 l bioreactors, respectively. The accumulation of 5 mg chlorogenic acid g⁻¹ DW, 22 mg chichoric acid g⁻¹ DW and 4 mg caftaric acids g⁻¹ DW were achieved with adventitious roots grown in 1,000 l bioreactors.     

Enhanced Ginsenoside Productivity by Combination of Ethephon and Methyl Jasmoante in Ginseng (Panax ginseng C.A. Meyer) Adventitious Root Cultures

Ethephon at 50 μM enhanced both root growth and ginsenoside accumulation in ginseng (Panax ginseng C.A. Meyer) adventitious root cultures, but at 100 μM it inhibited only ginsenoside accumulation. Ginsenoside productivity with 50 μM ethephon was the highest at 1.7 mg l⁻¹ d⁻¹ after 8 days of elicitation. However, elicitation with 50 μM ethephon and 100 μM methyl jasmonate (MJ) improved productivity (6.3 mg l⁻¹ d⁻¹) whereas elicitation with 100 μM MJ alone gave only 2.9 mg l⁻¹ d⁻¹.     

Establishment of adventitious root co-culture of Ginseng and Echinacea for the production of secondary metabolites

We have successfully established the co-culture of ginseng (Panax ginseng C.A. Meyer) and echinacea [Echiancea purpurea (L.) Moench.] adventitious roots for the production secondary metabolites. Adventitious roots of ginseng and echinacea were cultured in different proportions (5 g L⁻¹; 4:1, 3:2 and 2:1 ginseng and echinacea, respectively) in 5-L capacity airlift bioreactors containing 4 L Murashige and Skoog medium supplemented with 25 μM indole-3-butyric acid and 50 g sucrose L⁻¹ and maintained at 25°C in the dark for 40 days. Results showed the negative effect of echinacea adventitious roots on the growth of ginseng roots, however, by limiting the inoculum density of echinacea, it was possible to establish the co-cultures. To enhance the accumulation of secondary metabolites, co-cultures were treated with 200 μM methyl jasmonate after 30 days of culture initiation. Methyl jasmonate elicitation promoted the accumulation of ginsenosides in the co-cultures. It was possible to produce ginsenosides and caffeic acid derivatives in higher amounts by establishing co-cultures with higher inoculum proportion of ginseng to echinacea (4:1 and 3:2) followed by elicitation treatment. This work demonstrates the effectiveness of interspecies adventitious root co-cultures for the production of plant secondary metabolites.     

Scale-up of adventitious root cultures of Echinacea angustifolia in a pilot-scale bioreactor for the production of biomass and caffeic acid derivatives

In an attempt to scale-up of adventitious root cultures of Echinacea angustifolia for the production of biomass and caffeic acid derivatives, i.e. echinacoside, chlorogenic acid, cichoric acid, caftaric acid, and cynarin, the effects of Murashige and Skoog (MS) medium dilutions, and initial sucrose concentrations were investigated in a 5-L airlift bioreactor. In addition, the kinetics of adventitious root growth and accumulation of secondary metabolites were also studied. The greatest root dry weight (6.50 g L^?l) and accumulation of total phenolics [22.06 mg g^?1 DW (dry weight)], total flavonoids (5.77 mg g^?1 DW) and total caffeic acid derivatives (10.63 mg g^?1 DW) were obtained at quarter-strength MS medium. Of the various gradients of sucrose tested, 5 % sucrose supplementation was regarded as an optimal concentration for enhancing productivity of biomass and bioactive compounds. Neither higher salt strength (3/4–2 MS) nor sucrose concentrations (7 and 9 %) showed promotive effect on root growth and metabolite production. The kinetic studies revealed that 4 weeks of culture period is the optimal time to achieve highest productivity of metabolites. Based on these results, a large-scale (20 L) and a pilot-scale (500 L) adventitious root culture system was established. In the pilot-scale bioreactor, adventitious roots were elicitor-treated with 100 μM methyl jasmonate (MJ) on day 28. After 1 week of elicitation, 1.75 kg dry root biomass was harvested containing 60.41 mg g^?1 DW of total phenolics, 16.45 mg g^?1 DW of total flavonoids, and 33.44 mg g^?1 DW of total caffeic acid derivatives. Among the caffeic acid derivatives, the accumulation of echinacoside (the major bioactive compound) in MJ-treated adventitious roots grown in the 500-L bioreactor was the highest (12.3 mg g^?1 DW), which is approximately threefold more than the non-MJ-treated roots cultured in 5- and 20-L bioreactors.     

Cell culture system versus adventitious root culture system in Asian and American ginseng: a collation

Panax ginseng and Panax quinquefolius of Panax genus are valuable as health foods as well as pharmaceuticals for the treatment of cancer, diabetes and ageing as these plants possess saponins. In the current study, Cell and adventitious root cultures of P. ginseng and P. quinquefolius were investigated for the biomass, cell division, saponin content and ginsenosides profile from four lines namely P. quinquefolius (AM), P. ginseng mountain (Mt.) Baekdu line, P. ginseng Cheong-sol line (CS) and P. ginseng CBN line (CBN) with the objective of comparing cell and adventitious root systems to check their efficacy for the production of ginseng saponins. Additionally, genes related to ginsenoside biosynthesis were also analyzed concerning to cell and adventitious root lines. The results indicated that various cell lines were better in multiplication and growth compared to adventitious root lines. However, adventitious root lines showed higher accumulation of dry biomass (1.5–2 fold) than that of cell lines. CS adventitious root line showed higher saponin content and ginsenoside productivity (10.48 mg·g^?1 DW, 12.88 mg·L^?1, respectively) than that of CS cell line (9.50 mg·g^?1 DW, 2.39 mg·L^?1, respectively). Especially, Rd ginsenoside productivity of CS adventitious root line recorded fourfold higher than CS cell line. Genes which are related to ginsenoside biosynthesis such as P. ginseng squalene synthase (PgSS2), P. ginseng squalene epoxidase (PgSE2), P. ginseng protopanaxadial synthase (PgPPDS) and P. ginseng protopanaxatriol synthase (PgPPTS) were analyzed by real time quantitative polymerase chain reaction to support ginsenoside production. The adventitious root culture system described in this study is useful system for biomass and ginsenoside production.     

Spectral lights trigger biomass accumulation and production of antioxidant secondary metabolites in adventitious root cultures of Stevia rebaudiana (Bert.)

Stevia rebaudiana (S. rebaudiana) is the most important therapeutic plant species and has been accepted as such worldwide. It has a tendency to accumulate steviol glycosides, which are 300 times sweeter than marketable sugar. Recently, diabetic patients commonly use this plant as a sugar substitute for sweet taste. In the present study, the effects of different spectral lights were investigated on biomass accumulation and production of secondary metabolites in adventitious root cultures of S. rebaudiana. For callus development, leaf explants were excised from seed-derived plantlets and inoculated on a Murashige and Skoog (MS) medium containing the combination of 2,4-dichlorophenoxy acetic acid (2, 4-D, 2.0 mg/l) and 6-benzyladenine (BA, 2.0 mg/l), while 0.5 mg/l naphthalene acetic acid (NAA) was used for adventitious root culture. Adventitious root cultures were exposed to different spectral lights (blue, green, violet, red and yellow) for a 30-day period. White light was used as control. The growth kinetics was studied for 30 days with 3-day intervals. In this study, the violet light showed the maximum accumulation of fresh biomass (2.495 g/flask) as compared to control (1.63 g/flask), while red light showed growth inhibition (1.025 g/flask) as compared to control. The blue light enhanced the highest accumulation of phenolic content (TPC; 6.56 mg GAE/g DW), total phenolic production (TPP; 101 mg/flask) as compared to control (5.44 mg GAE/g DW; 82.2 mg GAE/g DW), and exhibited a strong correlation with dry biomass. Blue light also improved the accumulation of total flavonoid content (TFC; 4.33 mg RE/g DW) and total flavonoid production (TFP; 65 mg/flask) as compared to control. The violet light showed the highest DPPH inhibition (79.72%), while the lowest antioxidant activity was observed for control roots (73.81%). Hence, we concluded that the application of spectral lights is an auspicious strategy for the enhancement of the required antioxidant secondary metabolites in adventitious root cultures of S. rebaudiana and of other medicinal plants.     

Enhancement of ginsenoside biosynthesis in high-density cultivation of Panax notoginseng cells by various strategies of methyl jasmonate elicitation

A single addition of 200 M methyl jasmonate (MJA) to high-density cell cultures of Panax notoginseng enhanced ginsenoside production in both shake-flask (250 ml) and airlift bioreactor (ALR; 1 l working volume). Repeated elicitation with two additions of 200 M MJA during cultivation further induced the ginsenoside biosynthesis in both cultivation vessels. The content of ginsenosides Rg₁, Re, Rb₁ and Rd in the ALR was increased from, respectively, 0.18±0.01, 0.21±0.01, 0.21±0.02 and 0 mg per100 mg dry cell weight (DW) in untreated cell cultures (control) to 0.32±0.02, 0.36±0.02, 0.72±0.06 and 0.08±0.01 mg per100 mg DW with a single addition of MJA and further increased to 0.43±0.02, 0.46±0.03, 1.09±0.07 and 0.14±0.02 mg per100 mg DW with two additions of MJA. Interestingly, the activity of the Rb₁ biosynthetic enzyme (UDPG-ginsenoside Rd glucosyltransferase), was also increased with a single elicitation by MJA and increased again by a repeated elicitation, which coincided well with the trend in the increase in Rb₁ content. In order to further improve the cell density and ginsenoside production, a strategy of MJA repeated elicitation combined with sucrose feeding was adopted. The final cell density and total ginsenoside content in the ALR reached 27.3±1.5 g/l and 2.02±0.06 mg per100 mg DW; and the maximum production of ginsenoside Rg₁, Re, Rb₁ and Rd was 111.8±4.7, 117.2±4.6, 290.2±5.1 and 32.7±8.1 mg/l, respectively. The strategies demonstrated and the information obtained in this work are useful for the efficient large-scale production of bioactive ginsenosides by plant cell cultures.     

Linoleic and α-linolenic fatty acids affect biomass and secondary metabolite production and nutritive properties of Panax ginseng adventitious roots cultured in bioreactors

The effect of elicitation with linoleic (C18:2) and α-linolenic (C18:3) fatty acids (LLA and α-LNA) was investigated in Panax ginseng C.A. Meyer adventitious roots cultured in 5 l balloon-type bioreactors. Fatty acids were added in culture medium at 0.0, 1.0, 2.5, 5.0, 10.0, and 20.0 μmol l⁻¹ at day 40, at the end of exponential growth phase. Roots were harvested and assayed at day 47. Elicitation with both LLA and α-LNA enhanced accumulation of total polyphenolics and flavonoids in roots compared with control without elicitation. The highest accumulation of flavonoids was observed at 5.0 μmol l⁻¹ for both elicitors. Total phenolics production reached its highest value of about 4.0 mg g⁻¹ DW under the elicitation with 5.0 μmol l⁻¹ LLA and 5.0–20.0 μmol l⁻¹ α-LNA. Meanwhile, α-LNA was more effective than LLA for increasing biomass and ginsenoside production. The biomass of 11.1 g DW l⁻¹ and maximal total ginsenoside content of 7.9 mg g⁻¹ DW were achieved at 5 μmol l⁻¹ α-linolenic acid. The essential polyunsaturated linoleic (C18:2) and α-linolenic (C18:3) fatty acids were accumulated in roots in response to elicitation while content of palmitic (C16:0) and oleic (C18:1) acids declined. The activities of SOD, G-POD and CAT were enhanced by two elicitors to similar extent while APX activity was preferably stimulated by α-LNA. Our results demonstrate that elicitation with α-linolenic acid stimulates production of biomass and secondary metabolites in bioreactor-cultured P. ginseng adventitious roots.