Aflatoxin contamination in insect damaged seeds of horsegram under storage

Studies on one of the protein rich pulses, horsegram (Dolichos biflorus L.) were carried out to know how far these low risk pulses are free from aflatoxin contamination under severe insect infestation in storage. A total of 150 stored seed samples of horsegram were analyzed for the presence of aflatoxins by collecting 25 samples each of undamaged and insect damaged seeds of all the three varieties (PDM-1, PHG-1 and HG-96). More than 33% of insect damaged seed samples were contaminated with aflatoxin B₁ and B₂, whereas less than 8% of the undamaged seed samples contain only low levels of aflatoxin B₂. Higher levels of aflatoxin B₁ (up to 130 μg/kg) were reported in insect damaged seed samples of all the three varieties under study. The levels of aflatoxin B₂ were always lower than aflatoxin B₁ of the corresponding seed samples with insect damage. Aflatoxin B₁ was reported in both the undamaged and insect damaged seed samples of all the three varieties of horsegram. It is evident from the varietal response studies that PDM-1 and HG-96 varieties of horsegram are highly vulnerable to aflatoxin contamination whereas, PHG-1 variety is relatively less susceptible to it. In general, insect infestation leads to increase in fungal invasion (including aflatoxigenic fungi) and this further enhances the levels of aflatoxin contamination in horsegram seeds.     

Preharvest aflatoxin contamination of groundnuts subjected to terminal drought stress in postrainy season

Groundnuts grown in the postrainy season under terminal drought stress imposed by withholding irrigation, or under a water-deficit gradient created by line-source sprinkler irrigation, were examined for preharvest aflatoxin contamination. High levels of aflatoxin B₁ were found in damaged seeds in both situations. When grown under continuous drought-stress, toxin levels in damaged seed samples ranged from 1480 to 2467 ?g/kg in the 1990/91, and 1.3 to 2000 ?g/kg in the 1991/92 postrainy seasons. Aflatoxin B₁ contamination in all damaged seed samples increased with increasing water deficit; toxin levels ranged from 26 to 850 ?g/kg across the water deficit gradient. Aflatoxin was either absent or almost negligible (1–2 ?g/kg) in apparently undamaged seed samples. Low risk of aflatoxin contamination in apparently undamaged seeds of groundnuts grown in postrainy seasons is indicated, even when there is terminal drought stress.     

The effects of aflatoxin B1 and palmotoxins B0 and G0 on the germination and leaf colour of the cowpea (vigna sinensis)

Aflatoxin B₁, crude aflatoxins and palmotoxins B₀ and G₀ were tested for seed germination and chlorophyll formation using the cowpea. It was found that aflatoxin B and crude aflatoxins inhibited both chlorophyll formation and seed germination and palmotoxins inhibited these processes to a lesser extent. 3 — Indolylacetic acid reduced the inhibitory effects of the aflatoxins in seed germination and chlorophyll formation in the cowpea.     

A survey of aflatoxin B<Subscript>1</Subscript> and total aflatoxin contamination in baby food,peanut and corn products sold at retail in Indonesia analysed by ELISA and HPLC

Aflatoxin contamination has been well known as a world-wide health-threatening problem in tropical countries including Indonesia. This research was undertaken to determine the degree of aflatoxin contamination in different Indonesian foodstuffs. A preliminary survey was carried out to evaluate the level of total aflatoxin (AfT) and aflatoxin B₁ (AfB₁) contamination of baby foods, peanut products, and corn products, which were purchased from traditional markets and supermarkets in Indonesia during the year 2001-2002. Eighty two peanut products, 12 baby foods products, and 11 corn products from different brands were analysed for AfT and AfB₁ using the Enzyme-Linked Immunosorbent Assay (ELISA) method. The results indicate that, of the brands analysed, 35% of the peanut products were contaminated with aflatoxins at various levels (range 5 to 870 μg/kg). Peanut-chilli sauces had the highest percentage of AfT contamination 9/12 (75%), which was followed by traditional snacks 5/11 (45%), peanut butter 4/11 (40%), flour egg coated peanut 6/16 (37%), and peanut cake 3/10 (30%). Fried peanuts and roasted peanut were found to contain aflatoxin at relatively lower percentages of 9% and 8%, respectively. From the 12 analysed baby food samples, on the other hand, no sample was found to be contaminated with aflatoxins. Two of 11 samples (18%) of corn based products were contaminated with AfT, ranging between 5.8 and 12.4 μg/kg. Additionally, 30 selected samples in different concentration ranges were further analysed to verify the correlation between ELISA and HPLC techniques and results were compared.     

Evaluation of the mycological status of luncheon meat with special reference to aflatoxigenic moulds and aflatoxin residues

The luncheon meat samples analyzed, which were produced locally by the two main luncheon meat producing companies in Egypt were relatively highly contaminated either by moulds and yeasts in general, aflatoxigenic species and aflatoxin residues in particular. The most frequently encountered fungi from the samples were yeasts, Aspergillus niger, A. flavus, Penicillium chrysogenum, Rhizopus stolonifer, Mucor circinelloides. Less common were Cladosporium sphaerospermum, Alternaria alternata, Mycosphaerella tassiana, P. aurantiogriseum and P. oxalicum. The most important aflatoxigenic species, A. flavus, was isolated frequently. It was 10% of the total fungal isolates from both samples of the two companies. Seven luncheon meat samples out of 50 analyzed were positive for aflatoxin B₁ or B₁ and G₁, while all samples were negative for aflatoxins B₂, G₂, M₁ and M₂. Aflatoxin B₁ was detected only in 4 and 3 samples out of 25 analyzed from each of company A and B, respectively. The highest detectable level, 11.1 ppb, was recorded in a sample from company B and the least, 0.5 ppb, in a sample from company A. Aflatoxin G₁, at concentration of 3.2 ppb, was detected in only one sample of the aflatoxin B₁ – contaminated 3 samples of company B: this sample also had the highest level of aflatoxin B₁. Some luncheon meat samples had higher numbers of aflatoxigenic A. flavus than others, however these samples were negative for aflatoxins. The hazardous potential of such contamination will be discussed. This revised version was published online in June 2006 with corrections to the Cover Date.     

Incidence of aflatoxin producing strains and aflatoxin contamination in dry fruit slices of quinces (Cydonia oblonga Mill.) from the Indian State of Jammu and Kashmir

An investigation was undertaken to obtain data on the occurrence of aflatoxins and the aflatoxin producing potential of Aspergillus flavus strains isolated from dry fruit slices of quinces produced in jammu and Kashmir, India. A total of 147 A. flavus isolates recovered from dr fruit slices were grown in liquid rice flour medium and screened for the production of various aflatoxins by thin layer chromatography. The results showed that 23.14% of the tested isolates were aflatoxigenic, producing aflatoxins B₁and B₂ in varying amounts. Aflatoxins G₁ and G₂ were not detected. All 25 of the investigated market samples were also found to be aflatoxin B₁ positive and the level of contamination ranged from 96 to 8164 g/kg of the dry fruit which is quite high in comparison to the permissible level of 30 ppb. As per these results biochemical composition of dry fruit slices of quinces, along with climatic conditions seem to be very favourable for aflatoxin production by the toxigenic A. flavus strains. Therefore,monitoring of aflatoxins in dry fruit slices of quincesis recommended for this region.This revised version was published online in October 2005 with corrections to the Cover Date.     

Mycoflora and mycotoxins natural occurrence in corn from entre rios province, Argentina

Corn samples were collected in 1999 from three departments of Entre Réos province, Argentina, and were surveyed for mould contamination and natural occurrence ofFusarium mycotoxins, ochratoxin A and aflatoxins.Fusarium verticillioides was the most prevalent fungal species recorded at all departments. Zearalenone, deoxynivalenol and ochratoxin A were not found in any samples. Only one of the 52 corn samples analysed was contaminated with aflatoxin B₁ (17 μg/kg). Fumonisin B₁ was found in 58 % of samples (range of positive samples: 47– 3,347 μg/kg), fumonisin B₂ in 33.0 % (range of positive samples: 23–537 μg/kg) and fumonisin B₃ in 25.0 % (range of positive samples: 24–287 μg/kg) of them. This is the first report on the natural occurrence of mycotoxins in corn from Entre Ríos province, Argentina. Levels of fumonisins were lower than detected in other Argentinian provinces.     

Comparing aflatoxin contamination in chilies from Punjab,Pakistan produced in summer and winter

A comparison was made of total aflatoxins (AFs) in 43 samples of chilies collected during winter and 42 in summer to determine the effect of season on contamination. The samples were analyzed by HPLC with fluorescence detection. The limits of detection and quantification for AFB₁ and AFG₁ were 0.05 μg/kg and 0.50 μg/kg, whilst for AFG₂ and AFB₂ they were 0.10 μg/kg and 0.60 μg/kg. In the winter samples, AFs were detected in 18 (72%) whole and 14 (60%) ground chilies, with concentration ranges 0.00-52.30 μg/kg and 0.00-74.60 μg/kg respectively. In the summer samples, 17 (64%) whole and 12 (76%) ground chilies were contaminated with AFs at concentrations 0.00-61.50 μg/kg and 0.00-95.90 μg/kg respectively. The percentage of samples greater than the European Union statutory limit for AFB₁ and total AF for whole chilies were 48 and 36%, compared with ground chili values of 50 and 45%, respectively, in the winter season. In the summer season, the samples greater than the European Union limit for AFB₁ and total AF in whole chilies were 52 and 38%, compared with values of 54 and 49% in ground chilies respectively. AF contamination was found to be higher in summer chili samples and hence winter chilies may provide a better quality product with respect to AF contamination. The ability to undertake this analysis in Pakistan will enhance greatly the ability to improve chili production in that country, as described herein.     

Rapid On-Site Sensing Aflatoxin B1 in Food and Feed via a Chromatographic Time-Resolved Fluoroimmunoassay

Aflatoxin B₁ poses grave threats to food and feed safety due to its strong carcinogenesis and toxicity, thus requiring ultrasensitive rapid on-site determination. Herein, a portable immunosensor based on chromatographic time-resolved fluoroimmunoassay was developed for sensitive and on-site determination of aflatoxin B₁ in food and feed samples. Chromatographic time-resolved fluoroimmunoassay offered a magnified positive signal and low signal-to-noise ratio in time-resolved mode due to the absence of noise interference caused by excitation light sources. Compared with the immunosensing performance in previous studies, this platform demonstrated a wider dynamic range of 0.2-60 μg/kg, lower limit of detection from 0.06 to 0.12 µg/kg, and considerable recovery from 80.5% to 116.7% for different food and feed sample matrices. It was found to be little cross-reactivity with other aflatoxins (B₂, G₁, G₂, and M₁). In the case of determination of aflatoxin B₁ in peanuts, corn, soy sauce, vegetable oil, and mouse feed, excellent agreement was found when compared with aflatoxin B₁ determination via the conversational high-performance liquid chromatography method. The chromatographic time-resolved fluoroimmunoassay affords a powerful alternative for rapid on-site determination of aflatoxin B₁ and holds a promise for food safety in consideration of practical food safety and environmental monitoring.     

Aflatoxin-producing Potential of Isolates of the Aspergillus flavus-oryzae Group from Peanuts (Arachis hypogaea)

Seventy-eight samples of farmer stock peanuts, representing peanuts grown in nine different geographical areas during 1964, were assayed for aflatoxin and examined for associated microflora. Only two samples contained more than 50 ppb of aflatoxin. Infestation by members of the Aspergillus flavus-oryzae group varied from 35 to 100% of the kernels per area and from 1 to 100% of the kernels per sample. Aflatoxin production by individual isolates ranged from 0 to 349,143 ppb under the test conditions employed. In general, the isolates produced 8 to 10 times more B₁ than B₂, and no isolate producing aflatoxins G₁ or G₂ was found. The importance of proper postharvest handling of peanuts is emphasized by the prevalence of isolates of A. flavus-oryzae capable of producing aflatoxins on farmers stock peanuts.     

Mycotoxins in several Polish food products in 2004–2005

In 2004–2005, samples of several selected Polish foods such as cereal products, nuts, dried fruits, coffee and culinary spices collected from Warsaw market and taken from food producers were analyzed on presence of aflatoxin B₁, B₂, G₁, G₂ (AF), ochratoxin A (OTA), zearalenone (ZEA) and deoxynivalenol (DON). After extraction and clean-up of extracts on immunoaffinity columns (IAC), mycotoxin analyses were carried out by HPLC using fluorescence and UV detectors. The concentrations of aflatoxins and ochratoxin A depending on the kind of sample ranged from 0.02 to 7.8 (one sample, of peanuts) and 0.02–11.9 μg/kg (one coffee sample), respectively. The levels of ZEA and DON were found to be below 50 °g/kg.     

Incidence of seed-borne fungi and aflatoxins in Sudanese lentil seeds

Thirteen seed samples of lentil (Lens esculenta) were incubated on agar plate and moist filter papers (Moist Chambers) at 28 ± 2 °C for determination of the incidence of seed-borne fungi. Aflatoxins content of the seeds was measured using the bright greenish-yellow fluorescence test (BGYF) and thin-layer chromatography (TLC). Sixty-nine species and seven varieties, which belong to 24 genera of fungi, were isolated from this crop. Of these fungi, 51 species and two varieties are considered new for this crop, whereas seven genera and 13 species are new to the mycoflora of the Sudan. The genus Aspergillus (13 species and 6 varieties) which comprising 44% of the total colony count was the most prevalent genus followed by Rhizopus (2 species, 19%), Penicillium (6 species) and Fusarium (8 species) (12%), Chaetomium (3 species) and Cladosporium (5 species) (6%), where the 18 genera (1–4 species) showed very low level of incidence (19%). Of the possible pathogens of lentil plants, F. oxysporum the main cause of vascular wilt was recovered from seeds of this crop. Thin layer chromatographic analysis of chloroform extracts of 13 seed samples showed that only one samples was naturally contaminated with aflatoxins B₁, B₂, G₁ and G₂ (14.3 μg/kg). This revised version was published online in June 2006 with corrections to the Cover Date.     

Aflatoxins,discolouration and insect damage in dried cowpea and pigeon pea in Malawi and the effectiveness of flotation/washing operation in eliminating the aflatoxins

Aflatoxin contamination and biodeterioration were examined in 302 samples of dry cowpeas and pigeon peas that were randomly purchased from 9 districts of the Southern Region of Malawi during July and November 2015. Further, the impact of flotation/washing on aflatoxin levels on the pulses was elucidated. Aflatoxin analyses involved immunoaffinity column (IAC) clean-up and HPLC quantification with fluorescence detection (FLD) while legume biodeterioration assessments were done by visual inspection. Aflatoxins were frequently detected in cowpea (24%, max., 66 μg/kg) and pigeon pea (22%, max., 80 μg/kg) samples that were collected in the month of July. Lower aflatoxin incidence of 15% in cowpeas (max., 470 μg/kg) and 14% in pigeon peas (max., 377 μg/kg) was recorded in the November collection. Overall, aflatoxin levels were significantly higher in the pulses that were collected in November. However, there were no significant differences in the total aflatoxin (aflatoxin B₁ (AFB₁) + AFB₂ + AFG₁ + AFG₂) levels between the two types of pulses. Remarkably, in 76.2% of the aflatoxin positive cowpea and in 41.7% of the aflatoxin positive pigeon pea samples, aflatoxin G₁ concentration exceeded aflatoxin B_1. Insect damage percentage averaged at 18.1 ± 18.2% (mean ± SD) in the cowpeas and 16.1 ± 19.4% in pigeon peas. Mean discolouration percentage (number of pulses) of the cowpeas and pigeon peas was found to be at 6.7 ± 4.9 and 8.7 ± 6.2%, respectively. Washing and discarding the buoyant fraction was highly efficient in reducing aflatoxin levels; only 5.2 ± 11.1% of the initial aflatoxin level was found in the cleaned samples. In conclusion, cowpeas and pigeon peas sold on the local market in Malawi may constitute a hazard especially if floatation/washing step is skipped.     

Fungi,Aflatoxins, Fumonisin B<Subscript>l</Subscript> and Zearalenone Contaminating Sorghum-based Traditional Malt,Wort and Beer in Botswana

Brewing and consumption of traditional beer have social–economic significance in most African countries including Botswana. Traditional sorghum malt, wort, and beer samples were collected from three villages around Gaborone, Botswana. Forty-six malt samples were analyzed for fungi on three different media and developing colonies were subcultured for identification. Rhizopus, Fusarium, Mucor, and Aspergillus were the most common genera isolated. Out of the 46 malt samples, 72% contained Rhizopus stolonifer, 63% Fusarium verticillioides (syn. Fusarium moniliforme), and 37% Aspergillus flavus. Although Aspergillus flavus was isolated from malt samples, aflatoxins (B₁, B₂, G₁, and G₂) were not detected in any of the samples analyzed. When the malt, wort, and beer samples were analyzed for fumonisin B_l and zearalenone, fumonisin B₁ was detected in 3 malt samples, with concentrations ranging from 47 to 1316 μg/kg, while zearalenone was detected in 56%, 48% and 48% of the malt, wort and beer samples, respectively. Zearalenone concentration in samples ranged from 102 to 2213 μg/kg in malt, 26 to 285 μg/l in wort and 20 to 201 μg/l, in beer. Zearalenone carry-over from wort to beer ranged from 23 to 403%. Therefore, although aflatoxins and fumonisin B₁ do not appear to be major contaminants, zearalenone is common and could pose a potential problem in traditional beer in Botswana.     

Occurrence of aflatoxin in some liver curative herbal medicines

Fifty herbal medicine samples of seven different taxa known to cure liver disorders were analysed for aflatoxin contamination. Twenty-three samples, out of 50, were contaminated with various levels of aflatoxins. Amongst the 23 contaminated samples the maximum level of aflatoxin B¹ recorded was 2.23 μg g^-1 in Asparagus racemosus and the minimum 0.28 μg g^-1 in Emblica officinalis . Aflatoxin G¹ was only found in one species, Terminalia belarica . Aflatoxin production of the isolates of Aspergillus flavus was also examined and the highest levels were produced by isolates from A. racemosus (1.07-2.47 μg ml^-1). Aflatoxin contamination of herbal drugs may be a risk for patients because the level of aflatoxins is much higher than the tolerance level fixed by the WHO for foods.     

Mycotoxins and mycotoxigenic moulds in nuts and sunflower seeds for human consumption

A survey was carried out to obtain data on the occurrence of mycotoxins and the mycotoxin-producing potential of fungi isolated from nuts (almonds, peanuts, hazelnuts, pistachio nuts) and sunflower seeds in Spain. Thin-layer chromatography was used to separate the toxins. Aflatoxins were detected in one sample of almonds (95 ppb aflatoxin B₁ and 15 ppb aflaxtoxin B₂) and in one sample of peanuts at a level below 10 ppb of aflatoxin B1. 100% of samples showed variable incidence of fungal contamination. The predominant fungi present in samples were Penicillium spp, Aspergillus niger, A. flavus, A. glaucus and Rhizopus spp. The results showed that isolates of different species were able to produce aflatoxins B₁, B₂, G₁, and G₂, sterigmatocystin, ochratoxin A, patulin, citrinin, penicillic acid, zearalenone, and griseofulvin.     

Destruction of aflatoxins B1 and G1 in bread making

The effect of processing steps as well preservatives used in French bread making namely propionic acid and/or potassium sorbate (0.2%) on the destruction of aflatoxins B₁ and G₁ was studied. Mixing and baking processes showed marked destruction of aflatoxins B₁ and G₁; being 71.2% and 52.5% for aflatoxin B₁ after mixing and baking steps, while reaching 73.9% and 54.5% for aflatoxin G₁. Fermentation step caused additional 15.3% and 15.0% destruction of aflatoxins B₁ and G₁. On the other hand, aflatoxin B₁ destruction was 79.2% and 50.7% when propionic acid was used and 75.3 and 56.7% in the presence of potassium sorbate and after mixing and baking steps respectively. Concerning aflatoxins G₁ it was found that mixing and baking steps showed destruction of 81.9% and 53.4% in the presence of propionic acid and 75.1 and 49.4% in the presence of potassium sorbate in this respective order. Generally, it can be concluded that using propionic acid as preservative appeared to be more effective on the destruction of aflatoxins B₁ and G₁ than potassium sorbate in French bread making.     

Assessment of mycoflora and infestation of insects,vector of <Emphasis Type="Italic">Aspergillus</Emphasis> section <Emphasis Type="Italic">Flavi</Emphasis>, in stored peanut from Argentina

The occurrence of spoilage fungi and Aspergillus section Flavi populations, the aflatoxins incidence, the role of insects as vectors of mycotoxin-producing fungi and the AFs-producing ability of the isolated species throughout the peanut (Arachis hypogaea L.) storage period were evaluated. Analyses of fungal populations from 95 peanut seed samples did not demonstrate significant differences between the incidences in each sampling period. Aspergillus section Flavi were isolated during all incubation periods. Cryptolestes spp. (Coleoptera: Cucujidae) were collected in August, September and October with 18, 16 and 28% of peanut samples contaminated, respectively. Insects isolated during August showed 69% of Aspergillus section Flavi contamination. A. flavus was the most frequently isolated (79%) from peanut seeds and from insect (59%). The greater levels of AFB₁ were detected in September and October with a mean of 68.86 μg/kg and 69.12 μg/kg respectively. The highest proportion of A. flavus toxigenic strains (87.5%) was obtained in June. The presence of Aspergillus section Flavi and insect vectors of aflatoxigenic fungi presented a potential risk for aflatoxin production during the peanut storage period. Integrated management of fungi and insect vectors is in progress.     

Contamination of Red Chilli with Aflatoxin B1 in Pakistan

A survey of red chilli (Capsicum indicum) for contamination with aflatoxins was performed on different samples comprising whole, crushed and powdered red chilli collected from various stores located in the city of Karachi, Pakistan. Red chilli required rather rigorous clean-up procedure for removal of adulterants and interference resulting from various types of compounds. A modified Romer method followed by bi-directional thin layer chromatography (TLC) was used for the detection of aflatoxins and confirmatory tests were performed by spraying the TLC plates with 50% sulphuric acid and making the derivative with trifluoroacetic acid. Of all the 176 samples of red chilli examined, 66% were found to be contaminated with aflatoxin B₁. Generally, samples of red chilli exammined were found to be fairly low in aflatoxin B₁ content, whereas only seven samples were found to contain concentrations greater than 25 μg/kg of aflatoxin B₁.     

Enzymatic Formation of G-Group Aflatoxins and Biosynthetic Relationship between G- and B-Group Aflatoxins

We detected biosynthetic activity for aflatoxins G₁ and G₂ in cell extracts of Aspergillus parasiticus NIAH-26. We found that in the presence of NADPH, aflatoxins G₁ and G₂ were produced from O-methylsterigmatocystin and dihydro-O-methylsterigmatocystin, respectively. No G-group aflatoxins were produced from aflatoxin B₁, aflatoxin B₂, 5-methoxysterigmatocystin, dimethoxysterigmatocystin, or sterigmatin, confirming that B-group aflatoxins are not the precursors of G-group aflatoxins and that G- and B-group aflatoxins are independently produced from the same substrates (O-methylsterigmatocystin and dihydro-O-methylsterigmatocystin). In competition experiments in which the cell-free system was used, formation of aflatoxin G₂ from dihydro-O-methylsterigmatocystin was suppressed when O-methylsterigmatocystin was added to the reaction mixture, whereas aflatoxin G₁ was newly formed. This result indicates that the same enzymes can catalyze the formation of aflatoxins G₁ and G₂. Inhibition of G-group aflatoxin formation by methyrapone, SKF-525A, or imidazole indicated that a cytochrome P-450 monooxygenase may be involved in the formation of G-group aflatoxins. Both the microsome fraction and a cytosol protein with a native mass of 220 kDa were necessary for the formation of G-group aflatoxins. Due to instability of the microsome fraction, G-group aflatoxin formation was less stable than B-group aflatoxin formation. The ordA gene product, which may catalyze the formation of B-group aflatoxins, also may be required for G-group aflatoxin biosynthesis. We concluded that at least three reactions, catalyzed by the ordA gene product, an unstable microsome enzyme, and a 220-kDa cytosol protein, are involved in the enzymatic formation of G-group aflatoxins from either O-methylsterigmatocystin or dihydro-O-methylsterigmatocystin.