Survival of a Salmonella typhimurium experimental contaminant during cooking of beef roasts.

Twenty-one raw boneless beef roasts were experimentally injected with 2 X 10(7) cells of a nalidixic acid-resistant strain of Salmonella typhimurium per roast. Contaminated roasts were cooked to center internal temperatures of 137.0 to 147.5 degrees F (58.3 to 64.1 degrees C) in a gas-fired pilot plant food-processing oven. Viable experimental contaminants were recovered from two core samples of the 21 roasts (one cooked to 137.0 degrees F [58.3 degrees C] and one cooked to 141.5 degrees F [ca 60.8 degrees C]). All of 17 cooking net samples taken from the contaminant injection side of roasts were salmonella positive, whereas 7 of 9 net samples from the side opposite injection were positive and all of 11 net samples from the bottom of roasts were positive. The implications of these results are discussed in relation to salmonella contamination of precooked beef roasts.     

EFFECTS OF EXTERNAL FAT COVER, BONE REMOVAL AND ENDPOINT COOKING TEMPERATURE ON SENSORY ATTRIBUTES AND COMPOSITION OF PORK CENTER LOIN CHOPS AND ROASTS

Effects of fat cover, bone removal and endpoint cooking temperature on proximate and sensory characteristics of pork center loin chops were investigated. Only brown color of broiled chops was affected by presence of bone and by endpoint temperature. Fat cover only affected perceived chewiness of chops. Broiled boneless chops contained higher percent fat than bone-in chops. There were no differences in protein, fat or moisture percentages in cooked chops due to fat cover. Higher internal temperature decreased percent moisture and increased percent protein. Percent fat did not differ due to internal temperature. A consumer study to determine the degree of liking of pork center loin roasts showed that consumers preferred roasts with no fat cover more than roasts with 0.6 cm fat cover and roasts cooked to 71.1°C compared to roasts cooked to 76.7°C. There was no difference in preference between boneless and bone-in roasts.     

Survival of Campylobacter jejuni inoculated into ground beef.

Ground beef was inoculated with mixed cultures of Campylobacter jejuni, and the samples were subjected to various cooking and cold-storage temperatures. When samples were heated in an oven at either 190 or 218 degrees C, approximately 10(7) cells of C. jejuni per g were inactivated (less than 30 cells per g) in less than 10 min after the ground beef reached an internal temperature of 70 degrees C. When the samples were held at -15 degrees C over 14 days of storage, the numbers of C. jejuni declined by 3 log10. When inoculated samples were stored with an equal amount of Cary-Blair diluent at 4 degrees C, no changes in viability were observed over 14 days of storage. Twenty-five times as much C. jejuni was recovered from inoculated ground beef when either 10% glycerol or 10% dimethyl sulfoxide was added to an equal amount of ground beef before freezing as was recovered from peptone-diluted ground beef. Twice as much inoculated C. jejuni was recovered from ground beef plus Cary-Blair diluent as was recovered from ground beef plus peptone diluent.     

Growth and survival of Shigella flexneri in common Bangladeshi foods under various conditions of time and temperature.

Survival and growth of Shigella flexneri were assessed in various foods, including boiled rice, lentil soup, milk, cooked beef, cooked fish, mashed potato, mashed brinjal, and raw cucumber. Growth at 25 and 37 degrees C and survival at 5 degrees C were observed by viable counts on MacConkey agar. The organism grew well in all tested foods and growth increased from 10(5) to 10(8) to 10(10) cells per ml or g within 6 to 18 h after inoculation at 25 and 37 degrees C.     

Modified enrichment-serology procedure for detection of salmonellae in soy products.

A modified enrichment-serology (MES) procedure was used to reduce the time necessary for salmonella analysis. Naturally contaminated samples of soy products were preenriched in 1% proteose peptone for 6 h at 37 degrees C followed by inoculation into tetrathionate broth for 18 h at 37 degrees C. Two drops of the tetrathionate sample were inoculated into M broth. After incubation at 37 degrees C for 6 h, 0.85 ml of the mixture was formolized, and 0.1 ml of polyvalent H antiserum was added. After incubation in water bath at 50 degrees C for 1 h, the appearance of a typical floccular flagellar precipitate was observed in tubes positive for salmonellae. Over 3,000 samples were subjected to standard biochemical and serological procedures, and the results were compared with those of the MES method with a 96.7% correlation. Eleven of the samples (0.3%) were false-negative with the MES procedure, and 3% were false-negative with the U.S. Food and Drug Administration Bacteriological Analytical Manual procedure. The 3% negative samples by this latter procedure were subsequently found to be positive by the MES procedure. The MES procedure reduced the time required for salmonella analysis from 4 days to 32 h.     

Inactivation of Escherichia coli O157:H7, salmonellae, and Campylobacter jejuni in raw ground beef by gamma irradiation.

Raw ground beef patties inoculated with stationary-phase cells of Escherichia coli O157:H7, salmonellae, or Campylobacter jejuni were subjected to gamma irradiation (60Co) treatment, with doses ranging from 0 to 2.52 kGy. The influence of two levels of fat (8 to 14% [low fat] and 27 to 28% [high fat]) and temperature (frozen [-17 to -15 degrees C] and refrigerated [3 to 5 degrees C]) on the inactivation of each pathogen by irradiation was investigated. In ascending order of irradiation resistance, the D10 values ranged from 0.175 to 0.235 kGy (C. jejuni), from 0.241 to 0.307 kGy (E. coli O157:H7), and from 0.618 to 0.800 kGy (salmonellae). Statistical analysis revealed that E. coli O157:H7 had a significantly (P < 0.05) higher D10 value when irradiated at -17 to -15 degrees C than when irradiated at 3 to 5 degrees C. Regardless of the temperature during irradiation, the level of fat did not have a significant effect on the D10 value. Salmonellae behaved like E. coli O157:H7 in low-fat beef, but temperature did not have a significant effect when the pathogen was irradiated in high-fat ground beef. Significantly higher D10 values were calculated for C. jejuni irradiated in frozen than in refrigerated low-fat beef. C. jejuni was more resistant to irradiation in low-fat beef than in high-fat beef when treatment was at -17 to -15 degrees C. Regardless of the fat level and temperature during inactivation, these pathogens were highly sensitive to gamma irradiation.(ABSTRACT TRUNCATED AT 250 WORDS)     

Verotoxic Escherichia coli (STEC) from beef and its products

In the present investigation, out of 27 (24.10%) strains of Escherichia coli isolated from 112 beef samples comprising raw meat (45), kabab (36) and kofta (31), 9 (33.33%) belonging to 7 different serotypes were verotoxic as tested by vero cell cytotoxic assay. Serotype O145 was the predominant STEC in raw meat. Interestingly, one STEC-O157 strain was also detected. All the STEC strains were positive for Stx genes by polymerase chain reaction showing stx2 (77.78%) to be most predominant followed by stx1 (22.22%). Phenotypic enterohaemolysin production on washed sheep blood agar supplemented with CaCl2 revealed 6 (66.67%) STEC strains to be positive. Presence of STEC in cooked beef products, viz., kabab and kofta appeared to be a matter of concern and potential threat to public health.     

Impact of inoculum preparation and storage conditions on the response of Escherichia coli O157:H7 populations to undercooking and simulated exposure to gastric fluid

This study evaluated the impact of inoculum preparation and storage conditions on the response of Escherichia coli O157:H7 exposed to consumer-induced stresses simulating undercooking and digestion. Lean beef tissue samples were inoculated with E. coli O157:H7 cultures prepared in tryptic soy broth or meat decontamination runoff fluids (WASH) or detached from moist biofilms or dried biofilms formed on stainless steel coupons immersed in inoculated WASH. After inoculation, the samples were left untreated or dipped for 30 s each in hot (75 degrees C) water followed by lactic acid (2%, 55 degrees C), vacuum packaged, stored at 4 (28 days) or 12 degrees C (16 days), and periodically transferred to aerobic storage (7 degrees C for 5 days). During storage, samples were exposed to sequential heat (55 degrees C; 20 min) and simulated gastric fluid (adjusted to pH 1.0 with HCl; 90 min) stresses simulating consumption of undercooked beef. Under the conditions of this study, cells originating from inocula of planktonic cells were, in general, more resistant to heat and acid than cells from cultures grown as biofilms and detached prior to meat inoculation. Heat and acid tolerance of cells on meat stored at 4 degrees C was lower than that of cells on nondecontaminated meat stored at 12 degrees C, where growth occurred during storage. Decontamination of fresh beef resulted in injury that inhibited subsequent growth of surviving cells at 12 degrees C, as well as in decreases in resistance to subsequent heat and acid stresses. The shift of pathogen cells on beef stored under vacuum at 4 degrees C to aerobic storage did not affect cell populations or subsequent survival after sequential exposure to heat and simulated gastric fluid. However, the transfer of meat stored under vacuum at 12 degrees C to aerobic storage resulted in reduction in pathogen counts during aerobic storage and sensitization of survivors to the effects of sequential heat and acid exposure.     

A comparative heat inactivation study of indigenous microflora in beef with that of Listeria monocytogenes,Salmonella serotypes and Escherichia coli O157:H7

AIMS: Thermal inactivation of a mixture of five strains of Listeria monocytogenes, four strains of Escherichia coli O157:H7 and eight serotypes of Salmonella were compared with that of indigenous microflora in 75% lean ground beef. METHODS AND RESULTS: Inoculated meat was packaged in bags that were completely immersed in a circulating water bath and held at 55, 57.5 and 60 degrees C for predetermined lengths of time. The surviving cell population was enumerated by spiral plating heat-treated samples onto tryptic soya agar supplemented with 0.6% yeast extract and 1% sodium pyruvate. D-values, determined by linear regression, in beef were 77.49, 21.9, and 10.66 min at 55, 57.5, and 60 degrees C, respectively, for indigenous microflora (z = 5.81 degrees C). When either of the three pathogens were heated in beef, their D-values calculated were significantly lower (P < 0.05) than those of indigenous microflora at all temperatures. The slope of the thermal death time curve for L. monocytogenes, E. coli O157:H7 and indigenous microflora were similar. Using a survival model for nonlinear survival curves, the D1-values at all temperatures for L. monocytogenes were significantly higher (P < 0.05) compared with those for Salmonella serotypes, E. coli O157:H7 or indigenous microflora. However, higher recovery of a subpopulation of the indigenous microflora in beef exposed to heating at 55, 57.5 or 60 degrees C resulted in significantly higher (P < 0.05) D2-values at all three temperatures, compared with those of the three pathogens at the same test temperatures. CONCLUSIONS: If the thermal process is designed to ensure destruction of indigenous microbial flora, it should also provide an adequate degree of protection against L. monocytogenes, Salmonella serotypes or E. coli O157:H7. SIGNIFICANCE AND IMPACT OF THE STUDY: The results of this study will assist the retail food industry in designing acceptance limits on critical control points that ensure safety, without introducing pathogens in a retail food environment, against L. monocytogenes, E. coli O157:H7 and Salmonella in cooked ground beef.     

Formation of a mutagen, 2-amino-1-methyl-6-phenylimidazo[4,5-b]-pyridine (PhIP) in cooked beef, by heating a mixture containing creatinine, phenylalanine and glucose

When a mixture of creatinine, phenylalanine and glucose in diethylene glycol-water solution was heated for 2 h at 128 degrees C, a mutagen, 2-amino-1-methyl-6-phenylimidazo[4,5-b]pyridine (PhIP), was found to be produced, identified by high-performance liquid chromatography, and UV-visible and mass spectrometries. The yield of PhIP was 3.6 nmoles/mmole original creatinine. PhIP was originally isolated from cooked beef, and this study shows creatinine, phenylalanine and glucose to be the probable precursors of PhIP in beef.     

DETECTION of ENTEROTOXIGENIC CLOSTRIDIUM PERFRINGENS IN GROUND BEEF

Clostridium perfringens is widely distributed in foods. This experiment was performed to assess occurrence of C. perfringens cultures and toxigenic strains isolated from ground beef Samples (118) were collected from 20 locations in Northeast Kansas and the number of C. perfringens was enumerated in these samples by Fung's Double-tube method with tryptose sulfite cycloserine agar medium. Out of 118 samples, 54 (46%) were found positive for C. perfringens. Pure isolates of C. perfringens were further grown in cooked meat medium for 24 h at 42C then heat shocked at 75C for 20 min and inoculated into modified Duncan and Strong medium for production of C. perfringens enterotoxin. Presence of enterotoxin was tested by the reverse passive latex agglutination test (Oxoid), which can detect enterotoxin up to a minimum level of 2 ng/mL. the data indicate that 46% of the beef samples harbored C. perfringens , but only 32 (6%) of 525 isolates were found to produce enterotoxin. This study emphasized the importance of continued surveillance of C. perfringens in meats and meat products and assessment of the toxigenesis of isolates.     

Growth of and toxin production by nonproteolytic Clostridium botulinum in cooked puréed vegetables at refrigeration temperatures.

Seven strains of nonproteolytic Clostridium botulinum (types B, E, and F) were each inoculated into a range of anaerobic cooked puréed vegetables. After incubation at 10 degrees C for 15 to 60 days, all seven strains formed toxin in mushrooms, five did so in broccoli, four did so in cauliflower, three did so in asparagus, and one did so in kale. Growth kinetics of nonproteolytic C. botulinum type B in cooked mushrooms, cauliflower, and potatoes were determined at 16, 10, 8, and 5 degrees C. Growth and toxin production occurred in cooked cauliflower and mushrooms at all temperatures and in potatoes at 16 and 8 degrees C. The C. botulinum neurotoxin was detected within 3 to 5 days at 16 degrees C, 11 to 13 days at 10 degrees C, 10 to 34 days at 8 degrees C, and 17 to 20 days at 5 degrees C.     

Detection and production of verotoxin 1 of Escherichia coli O157:H7 in food.

Verotoxin 1 (VT1) is a recognized virulence factor of Escherichia coli O157:H7, a cause of severe food-borne disease. The public health significance of preformed verotoxin in food is unknown, and relatively little research has been done to determine the production of VT1 in food. The purposes of this study were to develop a sensitive method to detect VT1 in milk and in ground beef and to determine the conditions for VT1 production in these foods. A sandwich enzyme-linked immunosorbent assay in which we used VT1-specific monoclonal antibody 9C9F5 as the capture antibody and a rabbit polyclonal antibody raised against VT2 as the detection antibody was developed for the detection and quantification of VT1 in milk and in ground beef. The enzyme-linked immunosorbent assay was sensitive to a minimum of 0.5 ng of VT1 per ml of milk and 1.0 ng of VT1 per g of ground beef. The greatest amount of VT1 detected in milk (306 ng/ml) was detected in samples that were incubated at 37 degrees C with agitation (160 rpm) for 48 h. Very little toxin (1 ng/ml) was produced at 25 or 30 degrees C within 96 h. VT1 production was greater in ground beef than in milk; 452 ng of VT1 per g was produced in beef at 37 degrees C in 48 h. Relatively little VT1 was produced in beef within 96 h at 25 and 30 degrees C (2.1 and 9.8 ng of VT1 per g, respectively). Our results indicate that ground beef is a better medium for VT1 production than milk.(ABSTRACT TRUNCATED AT 250 WORDS)     

Detection and production of verotoxin 1 of Escherichia coli O157:H7 in food.

Verotoxin 1 (VT1) is a recognized virulence factor of Escherichia coli O157:H7, a cause of severe food-borne disease. The public health significance of preformed verotoxin in food is unknown, and relatively little research has been done to determine the production of VT1 in food. The purposes of this study were to develop a sensitive method to detect VT1 in milk and in ground beef and to determine the conditions for VT1 production in these foods. A sandwich enzyme-linked immunosorbent assay in which we used VT1-specific monoclonal antibody 9C9F5 as the capture antibody and a rabbit polyclonal antibody raised against VT2 as the detection antibody was developed for the detection and quantification of VT1 in milk and in ground beef. The enzyme-linked immunosorbent assay was sensitive to a minimum of 0.5 ng of VT1 per ml of milk and 1.0 ng of VT1 per g of ground beef. The greatest amount of VT1 detected in milk (306 ng/ml) was detected in samples that were incubated at 37 degrees C with agitation (160 rpm) for 48 h. Very little toxin (1 ng/ml) was produced at 25 or 30 degrees C within 96 h. VT1 production was greater in ground beef than in milk; 452 ng of VT1 per g was produced in beef at 37 degrees C in 48 h. Relatively little VT1 was produced in beef within 96 h at 25 and 30 degrees C (2.1 and 9.8 ng of VT1 per g, respectively). Our results indicate that ground beef is a better medium for VT1 production than milk.(ABSTRACT TRUNCATED AT 250 WORDS)     

Review: The variability of the eating quality of beef can be reduced by predicting consumer satisfaction

The Meat Standards Australia (MSA) grading scheme has the ability to predict beef eating quality for each ‘cut×cooking method combination’ from animal and carcass traits such as sex, age, breed, marbling, hot carcass weight and fatness, ageing time, etc. Following MSA testing protocols, a total of 22 different muscles, cooked by four different cooking methods and to three different degrees of doneness, were tasted by over 19 000 consumers from Northern Ireland, Poland, Ireland, France and Australia. Consumers scored the sensory characteristics (tenderness, flavor liking, juiciness and overall liking) and then allocated samples to one of four quality grades: unsatisfactory, good-every-day, better-than-every-day and premium. We observed that 26% of the beef was unsatisfactory. As previously reported, 68% of samples were allocated to the correct quality grades using the MSA grading scheme. Furthermore, only 7% of the beef unsatisfactory to consumers was misclassified as acceptable. Overall, we concluded that an MSA-like grading scheme could be used to predict beef eating quality and hence underpin commercial brands or labels in a number of European countries, and possibly the whole of Europe. In addition, such an eating quality guarantee system may allow the implementation of an MSA genetic index to improve eating quality through genetics as well as through management. Finally, such an eating quality guarantee system is likely to generate economic benefits to be shared along the beef supply chain from farmers to retailors, as consumers are willing to pay more for a better quality product.     

Microbiological quality and safety of zoo food

Two types of commercial products for feeding zoo animals (a frozen meat product, referred to as zoo food, and a dry product, referred to as dry food) were microbiologically examined for spoilage organisms (aerobic, psychrotrophic, coliform, Escherichia coli, mold, and yeasts) and pathogens (Salmonella spp., Listeria monocytogenes, and Campylobacter jejuni). Levels of microorganisms in frozen ground zoo food were compared with those in frozen ground beef and frozen ground turkey meat. The level of microbial contaminants in frozen ground zoo meat was found to be similar to that in frozen ground beef and higher than that in frozen ground turkey meat. Sixty percent of the frozen zoo meat samples were Salmonella positive, and all of the samples were L. monocytogenes positive. Dry zoo food was documented to have microbial levels lower than those in frozen zoo meat; the pathogen levels were less than 1/25 g of food. Defrosting zoo meat at 10, 25, and 37 degrees C for 24 h showed that 10 degrees C is the best temperature for defrosting frozen ground zoo meat loaves (length, 9 in. [22.8 cm]; radius, 2 in. [5.1 cm]) without affecting the microbiological quality or safety of the product.     

Microbiological quality and safety of zoo food.

Two types of commercial products for feeding zoo animals (a frozen meat product, referred to as zoo food, and a dry product, referred to as dry food) were microbiologically examined for spoilage organisms (aerobic, psychrotrophic, coliform, Escherichia coli, mold, and yeasts) and pathogens (Salmonella spp., Listeria monocytogenes, and Campylobacter jejuni). Levels of microorganisms in frozen ground zoo food were compared with those in frozen ground beef and frozen ground turkey meat. The level of microbial contaminants in frozen ground zoo meat was found to be similar to that in frozen ground beef and higher than that in frozen ground turkey meat. Sixty percent of the frozen zoo meat samples were Salmonella positive, and all of the samples were L. monocytogenes positive. Dry zoo food was documented to have microbial levels lower than those in frozen zoo meat; the pathogen levels were less than 1/25 g of food. Defrosting zoo meat at 10, 25, and 37 degrees C for 24 h showed that 10 degrees C is the best temperature for defrosting frozen ground zoo meat loaves (length, 9 in. [22.8 cm]; radius, 2 in. [5.1 cm]) without affecting the microbiological quality or safety of the product.     

Effects of storage and the presence of a beef microflora on the thermal resistance of Salmonella Typhimurium DT104 in beef and broth systems

AIMS: To investigate the effects of storage and the presence of a beef microflora on the thermal resistance of Salmonella serotype Typhimurium DT104 on beef surfaces and in a broth system during subsequent heat treatments after extended low-temperature storage (4 degrees C for 14 days) or mild temperature abuse (10 degrees C for 7 days). METHODS AND RESULTS: Surviving Salm. Typhimurium DT104 cells were estimated after heating in a water bath (55 degrees C) by plating beef and broth samples on tryptone soya agar and overlaying with xylose-lysine-deoxycholate agar. In beef and broth systems, D(55) values for Salm. Typhimurium DT104 stored at 4 degrees C or 10 degrees C in the presence or absence of a beef microflora were significantly lower (P < 0.01) than the D values for this organism heat-treated immediately after inoculation. In beef systems, the D(55) values were significantly lower (P < 0.05) in the presence of a beef microflora than the D(55) values obtained in 'pure' culture under all temperature/storage combinations. However, in broth systems, there was no significant difference between the D(55) values obtained in 'pure' culture and the D(55) values obtained from systems containing beef microflora. CONCLUSIONS: Storage of Salm. Typhimurium DT104 significantly reduced the thermal resistance of the pathogen in beef and broth systems. In the presence of high numbers of a Gram-negative beef microflora, the heat sensitivity of the pathogen was further increased on beef surfaces but not in broth. SIGNIFICANCE AND IMPACT OF THE STUDY: Studies investigating the survival of Salm. Typhimurium DT104 in different food systems will help define safe food preservation processes and will aid in the elimination this pathogen from the food production environments.     

Growth kinetics of mixed culture in salmonella enrichment media

A technique for investigating the kinetics of salmonella enrichment is reported. Its use with four enrichment media (Rappaport's medium, Muller-Kauffmann tetrathionate broth (MKT) tetrathionate broth and selenite F) is described and the effect of elevated temperature on the growth kinetics shown. Rappaport's medium at 37 degrees C and MKT at either 37 degrees C or 42 degrees C were far superior to selenite F and tetrathionate broth in their selective properties and, with the exception of Rappaport's medium, the use of elevated temperature increased the selectivity of the media.     

The effect of temperature on the formation of mutagens in heated beef stock and cooked ground beef

The microsome-activatable mutagens (chromatographically distinguishable from benzo[a]pyrene and from the mutagens produced from pyrolysed amino acids and proteins) previously found in beef extract and in bacterial nutrients which contain beef extract are produced when beef stock is heated. Reflux boiling of beef stock at 100°C results in a linear increase in mutagenic activity toward Salmonella strain TA1538. The rate of production of mutagenic activity at temperatures between 68°C and 98°C conforms closely to the Arrhenius equation, yielding an activation energy of 23 738 calories per mole. Extrapolation from these data predicts a sharp rise in the rate of mutagen formation between 140 and 180°C. This expectation is confirmed when ground beef patties (hamburgers) are prepared in various conventional electrically-heated appliances which operate at different cooking temperatures within this range. The mutagenic activity of hamburger cooked at high temperatures is limited to the surface layers; the temperature of the inside of the hamburger does not exceed 100°C during cooking. No mutagenic activity is found in comparable samples of uncooked meat. The results indicated that the mutagens may be formed as a result of the temperatures encountered in certain conventional cooking procedures.