Vermicomposting of tannery sludge mixed with cattle dung into valuable manure using earthworm Eisenia fetida (Savigny)

The present study revealed the role of earthworm in converting tannery sludge into a valuable product. Tannery sludge was toxic to earthworm, therefore it was mixed with cattle dung in different proportions viz. 0:100 (T₀), 10:90 (T₁₀), 25:75 (T₂₅), 50:50 (T₅₀) and 75:25 (T₇₅) on dry weight basis. The minimum mortality and highest population buildup of worms was in T₀ mixture. Nitrogen, sodium, phosphorus and pH increased from initial in the range of 7.3-66.6%, 16.90-70.58%, 8.57-44.8% and 2.8-13.65%, respectively. On the other hand potassium, organic carbon and electrical conductivity decreased in the range of 4.34-28.5%, 7.54-22.35% and 32.35-53.12%, respectively. C:N ratio decreased from 20.53% to 47.36% in the final products. Transition metals increased significantly from the initial value and within the permissible limit. The result indicated that vermicomposting with Eisenia fetida is better for changing this sludge into nutrient rich manure in a short period of time.     

冬小麦根系时空分布动态及产量对不同氮源配施的响应

为了解不同氮(N)源(有机/无机肥)配施对冬小麦(Triticum aestivum)根系时空分布特征和产量的影响, 采用微根管(minirhizotron)动态监测技术, 以强筋小麦品种‘豫麦34’为试验材料, 在等养分条件下, 设置不施肥(T₀)、100%尿素N (T₁)、75%尿素N + 25%鸡粪N (T₂)、50%尿素N + 50%鸡粪N (T₃)、25%尿素N + 75%鸡粪N (T₄)和100%鸡粪N (T₅)等6个有机N与化肥N配施处理, 研究分析了‘豫麦34’在不同生育时期及0-100 cm土层中根系直径、根长密度、根长生长量和死亡量等根系特征参数的变化及其产量表现。结果表明, 施肥不仅有利于各生育时期及不同土层中根系直径、根长密度和根长生长量的增加, 而且增加了根长死亡量, 促进了根系的周转。对不同配施处理进行比较, 发现T₃处理(尿素和鸡粪等氮配施)的效果最为显著, 全生育期平均根长密度、周期生长量与周期死亡量分别较对照T₀增加了55.52%、57.79%和61.61%, 有效分蘖数、穗粒重、经济产量和经济系数也以T₃处理增加最多, 分别较T₀增加了52.63%、43.90%、40.16%和12.02%; 穗粒数在T₄处理下最大, 较T₀增加了45.79%; 生物产量在T₅处理下最高, 比T₀增加了26.95%。因此, 不同氮源合理配施有利于促进冬小麦根系的生长及在不同土层中的扩展, 提高冬小麦产量。尿素和鸡粪为N源时等氮配施(50 : 50)的效果最佳。     

添加污泥对尾矿砂理化性质及香樟生理特性的影响

以香樟作为指示植物,选取黄岩、临海和路桥地区污水处理厂污泥,将污泥与尾矿砂按(污泥质量比例为0%对照、25%、50%和75%)配比进行栽培试验。测定添加污泥对尾矿砂理化性质以及香樟生理特性的影响。结果表明:随着污泥比例的增加,混合基质中的有机质、全氮、全磷明显增加,pH值明显降低,离子交换量明显减少,Cu和Cd总量明显增加,而Pb总量明显减少,Zn总量没有明显变化,Cu、Cd和Zn的DTPA提取量明显增加,而Pb的DTPA提取量明显减少。黄岩和临海污泥在25%和50%比例时,香樟叶和茎的生物量和叶绿素含量明显增加,而根的生物量没有明显变化,在75%比例时,生物量和叶绿素含量均明显减少;而添加路桥污泥使香樟叶、茎和根的生物量和叶绿素含量明显减少。丙二醛含量则与生物量和叶绿素含量呈现相反的变化特征。黄岩和临海污泥在25%和50%比例时,根和叶的Cu、Cd、Pb和Zn含量明显减少,在75%比例时,Cu、Cd和Zn含量则明显增加;而添加路桥污泥使叶和根的Cu、Cd和Zn含量明显增加,Pb含量明显减少。研究表明添加污泥提高了尾矿砂的养分含量,同时改变了其重金属组成,对污泥重金属含量和有机质组成的监控可以准确地预测污泥改良后尾矿砂对植物毒性的变化。     

Effect of initial COD concentration, nutrient addition, temperature and microbial acclimation on anaerobic treatability of broiler and cattle manure

In this study, anaerobic treatability and biogas generation potential of broiler and cattle manure were investigated. For this purpose, seven sets of anaerobic batch reactor experiments were performed using broiler and cattle manure and their mixtures in five different ratios (100% broiler; 75% broiler, 25% cattle; 50% broiler, 50% cattle; 25% broiler, 75% cattle; 100% cattle). These manure mixtures had two different initial chemical oxygen demand (COD) (12,000 and 53,500 mg/l) concentrations. The effects of initial COD concentration, nutrient and trace metal supplementation, microbial acclimation and digestion temperature were investigated. Results revealed that the efficiency of total COD removal was 32.0-43.3% and 37.9-50% for initial COD concentrations of 12,000 and 53,500 mg/l, respectively. The biogas yields observed for initial COD concentrations of 12,000 and 53,500 mg/l were 180-270 and 223-368 ml gas/g COD added, respectively. A decrease in biogas yield was observed as the fraction of broiler manure increased in mixture of broiler and cattle manure at initial COD values of 53,500 mg/l.     

Removal of molecular weight fractions of COD and phenolic compounds in an integrated treatment of olive oil mill effluents

Previous works (Beccari et al. 1999b; Beccari et al. 2001a; Beccari et al. 2001b)on the anaerobic treatment of olive oil mill effluents (OME) have shown: (a) apre-treatment based on the addition of Ca(OH)₂ and bentonite was able toremove lipids (i.e. the most inhibiting substances present in OME) almostquantitatively; (b) the mixture OME – Ca(OH)₂ – bentonite, fed to amethanogenic reactor without providing an intermediate phase separation,gave way to high biogas production even at very low dilution ratios; (c) theeffluent from the methanogenic reactor still contained significant concentrationsof residual phenolic compounds (i.e. the most biorecalcitrant substances present inOME). Consequently, this paper was aimed at evaluating the fate of the phenolicfractions with different molecular weights during the sequence of operations(adsorption on bentonite, methanogenic digestion, activated sludge post-treatment).The results show that a very high percentage (above 80%) of the phenolic fractionbelow 500 D is removed by the methanogenic process whereas the phenolic fractionsabove 1,000 D are significantly adsorbed on bentonite; the 8-day activated sludgepost-treatment allows an additional removal of about 40% of total filtered phenoliccompounds. The complete sequence of treatments was able to remove more than the96% of the phenolic fraction below 500 D (i.e. the most toxic fraction towards plantgermination). Preliminary respirometric tests show low level of inhibition exerted bythe effluent from the methanogenic reactor on aerobic activated sludges taken fromfull-scale municipal wastewater plants.     

Codigestion of solid wastes: a review of its uses and perspectives including modeling

The last two years have witnessed a dramatic increase in the number of papers published on the subject of codigestion, highlighting the relevance of this topic within anaerobic digestion research. Consequently, it seems appropriate to undertake a review of codigestion practices starting from the late 1970s, when the first papers related to this concept were published, and continuing to the present day, demonstrating the exponential growth in the interest shown in this approach in recent years. Following a general analysis of the situation, state-of-the-art codigestion is described, focusing on the two most important areas as regards publication: codigestion involving sewage sludge and the organic fraction of municipal solid waste (including a review of the secondary advantages for wastewater treatment plant related to biological nutrient removal), and codigestion in the agricultural sector, that is, including agricultural - farm wastes, and energy crops. Within these areas, a large number of oversized digesters appear which can be used to codigest other substrates, resulting in economic and environmental advantages. Although the situation may be changing, there is still a need for good examples on an industrial scale, particularly with regard to wastewater treatment plants, in order to extend this beneficial practice. In the last section, a detailed analysis of papers addressing the important aspect of modelisation is included. This analysis includes the first codigestion models to be developed as well as recent applications of the standardised anaerobic digestion model ADM1 to codigestion. (This review includes studies ranging from laboratory to industrial scale.).     

Lipid changes of goat sperm plasma membrane during epididymal maturation

Highly purified plasma membranes of maturing goat caput-, corpus- and cauda-epididymal spermatozoa were isolated by aqueous two-phase polymer methods and their lipid constituents were analysed. Phospholipid (approx. 75% w/w), neutral lipid (approx. 15% w/w) and glycolipid (approx. 10% w/w) were the major sperm membrane lipids. There was a significant decrease in the total lipids (approx. 25% w/w), phospholipid (approx. 30% w/w) and glycolipid (approx. 80% w/w) contents of sperm membrane during epididymal maturation. On the contrary, the mature cauda-sperm membrane showed greater (approx. 50% w/w) neutral lipid content than that of the immature caput sperm. Phosphatidylcholine (PC), phosphatidylethanolamine (PE) and sphingomyelin were the phospholipids of the sperm membrane, the former two being the major lipids. Both PC and PE fractions consisted of three species--diacyl, alkylacyl and alkenylacyl forms, the last one being the dominant species in both PC and PE. Of all the phospholipids, diacyl PE decreased most strikingly (approx. 65% w/w) during sperm maturation. The neutral lipid fraction contained sterols, wax esters, 1-O-alkyl-2,3-diacylglycerol, triacylglycerol and fatty acids. Sterols represented nearly 75% w/w of the neutral lipids and cholesterol was the major component (approx. 95% w/w) of the sterol fraction. The sperm maturity was associated with marked increase of sterol (approx. 60% w/w) and steryl ester (approx. 200% w/w) and decrease (approx. 50-65% w/w) of the other membrane-bound neutral lipids. The glycolipid was identified as monogalactosyldiacylglycerol. The fatty acid profile of the various membrane lipids underwent marked alteration during the epididymal transit of the male gametes. Cholesterol/phospholipid and saturated/unsaturated fatty acid ratios increased greatly in the maturing sperm membrane. The altered lipid profile of the mature sperm membrane leads to changes in its fluidity that play an important role in determining the structure and functions of the biomembrane.     

Biodegradation of sulfamethazine by an isolated thermophile–<Emphasis Type="Italic">Geobacillus</Emphasis> sp. S-07

Sulfamethazine (SM2) is an antimicrobial drug that is frequently detected in manure compost, is difficult to degrade at high temperatures and is potentially threatening to the environment. In this study, a thermophilic bacterium was isolated from the activated sludge of an antibiotics pharmaceutical factory; this bacterium has the ability to degrade SM2 at 70?°C, which is higher than the traditional manure composting temperature. The strain S-07 is closely related to Geobacillus thermoleovorans based on its 16S rRNA gene sequence. The optimal conditions for the degradation of SM2 are 70?°C, pH 6.0, 50 rpm rotation speed and 50 mL of culture volume. More than 95% of the SM2 contained in media was removed via co-metabolism within 24 h, which was a much higher percentage than that of the type strain of G. thermoleovorans. The supernatant from the S-07 culture grown in SM2-containing media showed slightly attenuated antibacterial activity. In addition, strain S-07 was able to degrade other sulfonamides, including sulfadiazine, sulfamethoxazole and sulfamerazine. These results imply that strain S-07 might be a new auxiliary bacterial resource for the biodegradation of sulfonamide residue in manure composting.     

不同培肥措施对红壤茶园土壤微生物量碳的影响

研究了经过4年不同培肥措施后红壤茶园土壤微生物量碳变化.结果表明:稻草覆盖后不同比例有机无机肥配施、间作三叶草以及全施化肥处理对土壤微生物量碳均有明显提高;全年土壤微生物量碳年变化都呈现"低-高-低-高"的趋势,且在不同时期对微生物量碳的影响不同;与对照(CK)相比,稻草覆盖 100%有机肥(T1)、稻草覆盖 75%有机肥 25%化肥(T2)、稻草覆盖 50%有机肥 50%化肥(T3)、稻草覆盖 25%有机肥 75%化肥(T4)、100%化肥(T5)和间作三叶草 不施肥(T6)土壤微生物量碳全年平均值分别高出17.05%、32.38%、32.05%、24.30%、26.23%和24.63%,且差异均达到显著水平(P＜0.05);土壤微生物量碳与活性有机质、土壤全氮、微生物量氮、微生物量磷呈显著正相关,与速效氮、土壤全磷、土壤全钾、土壤含水量之间关系不显著;与单施化肥和全量投入有机物料相比,有机物和化肥配合施用更有利于提高土壤肥力.     

Biogas manufacture from co-digestion of untreated primary sludge with raw chicken manure under anaerobic mesophilic environmental conditions

This work aimed to co-digest various wastes to assess the best combination of all mixing ratio, also at choosing the best ratio between untreated primary sludge (UPS) singly from two sources, (South valley University (SUPS) and Abu tesht wastewater station (AUPS) and raw chicken manure (RCM) and comparing the results in either case. The co-digestions of untreated primary sludge from Abu tesht wastewater treatment stations with different levels of raw chicken manure (0:100, 10:90, 30:70, 50:50, 90:10, and 100:0) to obtain the best mixtures. Also, co-digestion of untreated primary sludge from south valley university with different levels of raw chicken manure at the same ratios, to obtain the best mixtures. Batch digestion tests were applied in 2.5 L digester with a working volume of 2.0 L. The samples in triplicates were separately loaded into the digesters locally fabricated and kept for 20 days as a retention period and diluted with the same amount of water. Mesophilic under 35 °C was adopted for untreated primary sludge as well as mixtures with raw chicken manure based on total solids (TS) and volatile solid (VS) proportions. The average biogas yields from AUPS/RCM mixture obtained ranged from 8570 to 5600 ml, by the following descending order, 10: 90 > 90:10 and so on >100:0, and the average biogas yields from SUPS/RCM obtained ranged from 6330 to 5635 ml, in the order of 90: 10 > 10:90 and so on >100:0. The results showed highest biogas yield from AUPS/RCM and SUPS/RCM mixtures with mixing ratio of 10:90 and 90:10, respectively, however, the lowest biogas production detected in separate digestion of AUPS and SUPS. The results indicated that co-digestion between the sludge and raw chicken manure could increase total biogas production volume, enhance sludge treatment process, and produce eco-friendly sludge because of co-digestion process than separate processing of each feedstock.     

Feasibility of using olive mill effluent (OME) as a wetting agent during the cultivation of oyster mushroom, Pleurotus ostreatus, on wheat straw

In this study, cultivation of oyster mushroom, Pleurotus ostreatus, on wheat straw substrate containing tap water and olive mill effluent (OME) mixture containing varying volume of OME was studied in order to investigate the feasibility of using OME as an alternative wetting agent and OME's impact on some fundamental food quality characteristics of mushrooms. Time period for mycelial colonization, primordium initiation and first harvest were comparatively evaluated with the control group. It was shown that the use of OME and tap water mixture consisting of OME up to 25% volumetrically was possible for the purpose of commercial mushroom production. Experimental results obtained from substrate containing 25% OME mixture showed no statistically significant difference compared to control group. The negative effects of increasing volume of OME in the mixture were also indicated by bioefficiency, which was found to be 13.8% for substrates wetted with 100% OME, whereas bioefficiency was 53.6% for control group. Increasing volume of OME in the mixture resulted in deformation of fruit body shape, whereas no significant difference in food quality was observed due to the higher amount of OME. This work suggested that the use of OME up to 25% as moisturizer could be considered, especially for the locations having significant number of olive mills and mushroom producers, both as an environmentally friendly solution for the safe and ecological disposal of OME and a practical way for recovering OME's economic value thereby.     

Influence of anaerobic culture acclimation on the degradation kinetics of various substrates

The adaptation of an anaerobic culture (anaerobic sludge) to a specific substrate brings significant changes to its microbial population. These changes can be described by the sludge's ability to treat various substrates such as carbohydrates or proteins or "intermediate" products of anaerobic metabolism such as L-lactic, propionic, and acetic acids. The activity of the sludge with respect to a specific substrate is a critical parameter, because the anaerobic degradability of wastewaters depends strongly on it. This work examines and quantifies the differentiation of two anaerobic sludges of the same origin, following an adaptation period of about 18 months to lactose and gelatin, respectively. The acclimation has a significant effect on the maximum specific utilization rates of various compounds and on their apparent consumption kinetics. It is noticeable, however, that even if the anaerobic cultures were not exposed to a specific substrate for a prolonged period of time (more than a year), they still kept the ability of hydrolyzing or degrading it. In addition, the acclimation has an unquestionable effect on the stoichiometry of the production of volatile fatty acids and L-lactate. Finally, from codigestion experiments it is shown that codigestion of lactose and gelatin appears to have no effect on their hydrolysis kinetics in any of the lactose or gelatin acclimated cultures; specifically, the hydrolysis kinetics remained the same as calculated when lactose or gelatin were the only fed substrates. Similarly, the kinetics of L-lactate and D-glucose biodegradation seemed to be unchanged. On the other hand, codigestion has a significant effect on the production of L-lactic, propionic, and acetic acids, which can be attributed to the increased hydrogen production accompanying gelatin biodegradation.     

Gross mineralization and plant N uptake from animal manures under non-N limiting conditions, measured using 15N isotope dilution techniques

To utilise wisely the manure resource, a better understanding of the processes that control the breakdown of organic N to inorganic N (mineralization) is required. ¹⁵N isotope dilution techniques should allow estimates of plant N uptake and gross mineralization from organic manures under non-N limiting conditions to be made. In natural systems the study of organic nitrogen breakdown to inorganic nitrogen, mineralization, is confounded by the processes of nitrification, nitrate leaching, gaseous N losses and plant N uptake. The ¹⁵N isotope dilution approach allows measurement of gross mineralization independently of these processes. Greenhouse experiments were conducted to determine plant N uptake from organic manures under non-N limiting conditions using the soil pre-labelling isotope dilution approach. The soil was pre-labelled with ¹⁵N and maize plants were then grown on the control treatments (no organic amendment) or on the manure treatments. The principle is thus that the control crop has a ¹⁵N abundance which reflects the ¹⁵N status of the soil and the treatment crop has a ¹⁵N enrichment diluted by the contribution of mineralized unlabelled manure N. Using this technique, it was estimated that maize plants derived 17 and 34% of their N from sewage sludge and turkey manure, respectively. The soil pre-labelling isotope dilution approach allowed yield-independent estimation of nitrogen derived from manures under non-N limiting conditions. Estimates of gross N mineralization were made to determine the breakdown of manure under field conditions. Results suggested that there was a rapid mineralization of turkey manure N in the initial weeks after application, in the order of 50 kg N ha^?1, which tailed off in the following weeks. The technique suggested that the soil used in the study had an extremely low basal mineralization rate, and a high nitrification rate.     

Composted grape marc as growing medium for hypostases (Hypostases phyllostagya)

The use of composted grape marc (CGM) as a plant growth medium was investigated with Hypostases (Hypostases phyllostagya). Seven media were prepared using CGM mixed, in different ratios, with native peat and perlite. The following mixtures were used: 100% CGM, 75% CGM + 25% peat, 50% CGM + 50% perlite, 25% CGM + 75% peat, 50% CGM + 25%) peat + 25% perlite, 25%, CGM + 50%, peat + 25% perlite and 100% peat. The experiment was arranged in a randomized plot design with four replicates under greenhouse conditions. After a growing period of three months, some horticultural parameters were measured. Besides, some physical and chemical properties of the growing medium were determined. The mixtures of 50% CGM + 50% peat, 25% CGM + 75% peat and 100% peat were found to be most suitable based on the horticultural parameters. This was confirmed through the physical characteristics. Up to 50% composted grape marc can be used in mixtures with peat on account of its low cost and high nutrient content.     

Composting of spent mushroom compost, carnation wastes, chicken and cattle manures

This study has purposed to determine the optimum mixture ratio of used mushroom compost, chicken manure, cattle manure and carnation waste for composting. For this purpose, these materials have been mixed in seven various ratios (R1-R7) and composted in the experimental composting reactors. The highest dry material losses and temperature values have been obtained by the R4 which contains 50% carnation waste, 25% chicken manure and 25% spent mushroom compost. Beside R4, mixtures of R2, R5 and R6 have also provided high process temperature and dry material loss values. The lowest dry material loss and temperature values have been obtained in the R7 which contains only carnation wastes. In the study, it has also seen that FAS (free air space) parameter is effective on the process and must be in the interval of 24-32%.     

Treatment of beet sugar wastewater by UAFB bioprocess

The aim of this work was to study the treatment of strong beet sugar wastewater by an upflow anaerobic fixed bed (UAFB) at pilot plant scale. Three fixed bed bioreactors (each 60 L) were filled with standard industrial packing, inoculated with anaerobic culture (chicken manure, cow manure, anaerobic sludge digested from domestic wastewater) and operated at 32-34 degrees C with 20 h hydraulic retention time (HRT) and influent COD ranging between 2000-8000 mg/L. Under these conditions the maximum efficiency of organic content reduction in the reactor ranged from 75% to 93%. The reactor filled with standard pall rings made of polypropylene with an effective surface area of 206 m(2)/m(3) performed best in comparison to the reactor filled with cut polyethylene pipe 134 m(2)/m(3) and reactor filled with PVC packing (50 m(2)/m(3)). There was 2-7% decrease in efficiency with PE while it was 10-16% in case of PVC when compared to standard pall rings. The study provided a very good basis for comparing the effect of packing in reduction efficiency of the system.     

Nutritional evaluation of cattle manure silage with molasses for ruminants

Two experiments were conducted to evaluate the nutritional quality of cattle manure silage for ruminants. In experiment 1 a silage containing 50% cattle manure, 20% cane molasses (containing 0.4% urea) mixed with water in a 1:1.5 ratio, and 30% corn stover replaced 0, 50, 75 and 100% of corn stover in isonitrogenous diets (1.92% N) containing 70 or 80% corn stover (dry matter (DM) basis) in a 4×2 factorial arrangement. Forty lambs (34.5±3.2 kg body weight (BW)) were used to measure apparent digestibility and nitrogen balance in a completely randomized design with factorial arrangement (4×2) with five lambs per treatment. The cattle manure silage was also evaluated in growing Holstein heifers (212±32 kg BW) replacing 0, 25 or 37.5% of corn stover with cattle manure silage in isonitrogenous diets (2.24% N). Apparent digestibility of DM, organic matter (OM), neutral detergent fibre (NDF) and acid detergent fibre (ADF) were not affected. According to these results, digestibility is not affected by the level of cattle manure silage; however, intake was depressed at the highest levels of silage in lambs. Cattle manure silage may be considered as a potential by-product to be included in heifer's diet up to 37.5%, apparently without affecting performance. Recycling cattle manure through silage for ruminants is a viable alternative. © 1997 Elsevier Science B.V.     

长江口锋面附近咸淡水混合对浮游植物生长影响的现场培养

通过2009年6月调查航次,获得了营养盐等参数断面分布,表明咸淡水混合是控制营养盐分布的主要因素。为了解不同盐度梯度下浮游植物生长与营养盐吸收的关系,采集两个站位水样分别代表长江冲淡水(C1站)和外海水(I10站),按C1站水样比例,分100%、75%、50%、25%、0%不同比例混合进行现场模拟咸淡水混合培养,有以下认识:(1)平行结果表明培养过程中活体荧光极大值在100%混合组,且淡水比例越低,指数生长期0—48 h内生长速率越低,100%、75%、50%、25%组分别为1.18/d、1.12/d、1.14/d、0.77/d;(2)低于26盐度的水体中PO34-在48 h内可被迅速消耗而产生限制作用,是控制浮游植物生长的潜在限制因子;(3)除0%组外,各混合组DIN/P(DIN:溶解无机氮,Dissolved Inorganic Nitrogen,DIN=NO3-+NO-2+NH4+)比值在浮游植物指数生长期有升高趋势,100%组DIN/P比值增加了一倍。各组培养48 h后DIN/Si比值逐渐降低至原来的0.7左右,初始DIN/Si小于一定时间内硅藻吸收的(ΔDIN/ΔSi)比,是造成各组DIN/Si比值减小的原因。以上结果表明咸淡水混合过程中形成的营养盐梯度可造成浮游植物生长程度和速率差异,且可因局部浮游植物旺发而改变海水营养结构。     

General method for determining anaerobic biodegradation potential.

A simple, generalized method was refined and validated to test whether an organic chemical was susceptible to anaerobic degradation to CH4 + CO2. The method used digested sewage sludge diluted to 10% and incubated anaerobically in 160-ml serum bottles with 50 micrograms of C per ml of test chemical. Biodegradation was determined by the net increase in gas pressure in bottles with test chemicals over the pressure in nonamended sludge bottles. Gas production was measured by gas chromatography and by a pressure transducer. The latter method is recommended because of its speed, accuracy, and low cost. Sewage sludge from municipal digesters with 15- to 30-day retention times was found to be suitable. The sludge could be stored anaerobically at 4 degrees C for up to 4 weeks with satisfactory test results. p-Cresol, phthalic acid, and ethanol are suggested as reference chemicals to confirm sludge activity and method reliability. A revised anaerobic salts medium was developed which minimizes problems of a biological gas production (CO2), avoids precipitation, and meets the requirements of the anaerobic microbiota. When greater than 75% of the theoretical gas production was observed, the chemical was judged to be degradable, and when 30 to 75% of the expected gas was produced, it was termed partially degradable. This method has been tested on more than 100 chemicals of various physical properties and found to reproducibly determine anaerobic biodegradation potential. Of the chemicals tested, 46 were found to be anaerobically degraded. Sludges from nine different municipal treatment plants were surveyed for their ability to degrade nine chemicals which differed in susceptibility to degradation.(ABSTRACT TRUNCATED AT 250 WORDS)     

Strategies for optimizing recovery of the biogas process following ammonia inhibition

Strategies for recovery of ammonia-inhibited thermophilic biogas process, were evaluated in batch and lab-scale reactors. Active methane producing biomass (digested cattle manure) was inhibited with NH(4)Cl and subsequently, 3-5 days later, diluted with 50% of water, or with 50% digested manure, or with 50% fresh manure or kept undiluted. Dilution with fresh cattle manure resulted in the highest methane production rate during the recovery period while dilution with digested cattle manure gave a more balanced recovery according to the fluctuations in volatile fatty acids. Furthermore, the process recovery of a 7600m(3) biogas plant suffering from ammonia inhibition was observed. The ammonia concentration was only gradually lowered via the daily feeding with cattle manure, as is the normal procedure at Danish full-scale biogas plants. Recovery took 31 days with a 40% methane loss and illustrates the need for development of efficient process recovery strategies.