Characterization of the germination of Bacillus megaterium spores lacking enzymes that degrade the spore cortex

Aims:  To determine roles of cortex lytic enzymes (CLEs) in Bacillus megaterium spore germination.
Methods and Results:  Genes for B. megaterium CLEs CwlJ and SleB were inactivated and effects of loss of one or both on germination were assessed. Loss of CwlJ or SleB did not prevent completion of germination with agents that activate the spore's germinant receptors, but loss of CwlJ slowed the release of dipicolinic acid (DPA). Loss of both CLEs also did not prevent release of DPA and glutamate during germination with KBr. However, cwlJ sleB spores had decreased viability, and could not complete germination. Loss of CwlJ eliminated spore germination with Ca²⁺ chelated to DPA (Ca-DPA), but loss of CwlJ and SleB did not affect DPA release in dodecylamine germination.
Conclusions:  CwlJ and SleB play redundant roles in cortex degradation during B. megaterium spore germination, and CwlJ accelerates DPA release and is essential for Ca-DPA germination. The roles of these CLEs are similar in germination of B. megaterium and Bacillus subtilis spores.
Significance and Impact of the Study:  These results indicate that redundant roles of CwlJ and SleB in cortex degradation during germination are similar in spores of Bacillus species; consequently, inhibition of these enzymes will prevent germination of Bacillus spores.     

Changes in spores of Bacillus megaterium treated with thioglycolate at a low pH and restoration of germinability and heat resistance by cations

Spores of Bacillus megaterium QM B1551 treated with thioglycolate (0.4 m, pH 2.6) at 50 C for 30 min remained refractile, but they became stainable, lysozymesensitive, and nonviable, and they lost dipicolinic acid (DPA). The loss of DPA and of viability were functions of the time and temperature of exposure to thioglycolate. Spores treated with thioglycolate at a lower temperature and for a shorter time (30 C, 5 min) retained DPA, viability, and nonstainability. Although these spores also retained their resistance to gamma radiation and to lysozyme, they lost thermo-resistance. Their percentage of germination over a 2-hr period in glucose was markedly reduced. Germinability and heat resistance were restored by exogenous cations, suggesting that the thioglycolate treatment (30 C, 5 min) resulted in the loss of spore ions essential for normal germination in glucose and for heat resistance.     

Sequence of events during germination of putrefactive anaerobe 3679 spores

The sequence of changes during germination of putrefactive anaerobe 3679h spores was studied under aerobic conditions in a solution containing l-alanine and sodium pyrophosphate. Evidence that specific changes occurred in two distinct regions of the spore is given by data on several criteria that were used to measure germination. During the initial stage of germination, the absorbancy decreased, dipicolinic acid was released, the spores lost their resistance to heat and toxic chemicals, and the spore periphery (cortex) darkened gradually under phase-contrast microscopy. The final stage of germination was characterized by changes in the central spore region (core), notably phase darkening of the spore center and stainability with mercurochrome, and by a slight additional absorbancy decrease.     

Analysis of the Loss in Heat and Acid Resistance during Germination of Spores of Bacillus Species

A major event in the nutrient germination of spores of Bacillus species is release of the spores'' large depot of dipicolinic acid (DPA). This event is preceded by both commitment, in which spores continue through germination even if germinants are removed, and loss of spore heat resistance. The latter event is puzzling, since spore heat resistance is due largely to core water content, which does not change until DPA is released during germination. We now find that for spores of two Bacillus species, the early loss in heat resistance during germination is most likely due to release of committed spores'' DPA at temperatures not lethal for dormant spores. Loss in spore acid resistance during germination also paralleled commitment and was also associated with the release of DPA from committed spores at acid concentrations not lethal for dormant spores. These observations plus previous findings that DPA release during germination is preceded by a significant release of spore core cations suggest that there is a significant change in spore inner membrane permeability at commitment. Presumably, this altered membrane cannot retain DPA during heat or acid treatments innocuous for dormant spores, resulting in DPA-less spores that are rapidly killed.     

Endospores of Sporosarcina halophila: characteristics and ultrastructure

Sporosarcina halophila forms endospores. Electron micrographs revealed ultrastructural similarity to spores of S. ureae. Spore germination indicated by loss of refractility, darkening, swelling and formation of new vegetative cells was followed by phase contrast light microscopy. To induce spore germination, the endospores needed to be heat avtivated. After activation, they were inoculated into nutrient broth medium supplemented with sea-water. Double concentrated sea-water was found to be optimal for germination. Similar to other bacterial endospores, the spores were found to be resistant to heat and ethanol. An ultraviolet absorbing substance was isolated from suspensions of free spores; it was identified to be pyridine-2,6-dicarboxylic acid (DPA) usually present in bacterial spores. DPA was detected in amounts ranging from 5–7% of the spore dry weight; it was not detected in extracts of vegetative cells.Abbreviation DPA 2,6-pyridine-dicarboxylic acid     

Correlation between spore structure and spore properties in Bacillus megaterium

The spores of six strains of Bacillus megaterium were divided into two distinct groups on the basis of germination. Three of the strains germinated in a mixture of l-alanine and inosine (AL type spores), and three strains germinated in a mixture of glucose and potassium nitrate (GN type spores); recriprocal germination in the respective solutions did not occur. The AL spores and the GN spores were morphologically distinct. Other differences between the two spore groups included germination inhibition characteristics, dipicolinic acid content, hexosamine content, phosphorus and magnesium content, spore coat features, ion exchange properties, and heat resistance. A correlation appears to exist between spore morphology and certain other spore properties in strains of B. megaterium.     

Biochemical analysis of the Bacillus subtilis 1604 spore germination response

Germination at 37 degrees C of spores of Bacillus subtilis 1604 in the L-alanine and potassium phosphate (ALA) and the glucose, fructose, L-asparagine, potassium chloride (GFAK) germinant systems was triggered following heat activation at 70 degrees C for 1 h. In these conditions, 50% of the spore population became committed to germinate after exposure for 10 min and 14 min to ALA and GFAK, respectively, at which time 38% and 30% losses of OD600 had taken place. Dipicolinic acid (DPA) release, loss of heat resistance and release of soluble hexosamine-containing fragments occurred after commitment and were closely associated with loss of refractility in both the ALA and GFAK pathways. Net ATP synthesis could not be detected until 3-4 min after initiation of germination in both ALA and GFAK, by which time greater than 20% of the spore population was committed to germinate. The ALA and GFAK germination pathways were greater than 99% inhibited by 3 and 1 mM-HgCl2, respectively, as measured by OD600 loss. Reversible post-commitment HgCl2-sensitive sites were present in the ALA and GFAK pathways which were 50% inhibited by 0.125 mM and 0.05 mM-HgCl2, respectively. A pre-commitment HgCl2-sensitive site was identified in the ALA pathway which was 55% inhibited by 6 mM-HgCl2. At 3 mM-HgCl2, 70% of the spore population became committed to germinate in the ALA pathway, whereas less than 5% OD600 loss occurred. In this system, loss of heat resistance was associated with commitment, whereas OD600 loss and DPA release were identified as post-commitment events. The ALA and GFAK pathways were insensitive to a variety of metabolic inhibitors. Protease inhibitors had different effects on the ALA and GFAK pathways: phenylmethanesulphonyl fluoride (PMSF) solely inhibited ALA germination at a pre-commitment site and had little effect on GFAK germination, whereas N alpha-p-tosyl-L-arginine methyl ester (TAME) inhibited both the ALA and GFAK pathways at pre- and post-commitment sites. These results are discussed in relation to a recently proposed model for the triggering of Bacillus megaterium KM spore germination.     

Spore pool glutamic acid as a metabolite in germination

Spore glutamic acid pools were examined in dormant and germinating spores using colorimetric and (14)C analytical procedures. Germination of spores of Bacillus megaterium (parent strain), initiated by d-glucose, was accompanied by a rapid drop in the level of spore pool glutamate, from 12.0 mug/mg of dry spores to 7.7 mug/mg of dry spores after 30 sec of germination. Similar decreases in extractable spore pool glutamate were observed with l-alanine-initiated germination of B. licheniformis spores. On the other hand, glutamate pools of mutant spores of B. megaterium, with a requirement of gamma-aminobutyric acid for spore germination, remained unchanged for 9 min of germination, at which time more than 50% of the spore population had germinated. Evidence for conversion of spore pool glutamate to gamma-aminobutyric acid during germination of spores of B. megaterium (parent strain) was obtained.     

High calcium content in Streptomyces spores and its release as an early event during spore germination.

The metal ion content of spores of five Streptomyces species was studied. A general feature of this study was the finding of a very high calcium content (1.1 to 2.1% of the dry weight). Accumulation of calcium occurred preferentially during the sporulation process. Spore calcium was located in the integument fraction, and more than 95% of the calcium was removed from intact spores by ethylene glycol-bis(beta-aminoethyl ether)-N,N-tetraacetic acid. Several divalent cations (Mg2+, Mn2+, Zn2+, and Fe2+) which induced darkening of spores and loss of heat resistance also caused the release of calcium from spores. In addition, darkening of spores was blocked by metabolic inhibitors, whereas calcium excretion was not affected. Two different categories of events in the initiation of germination may be differentiated; first, calcium release from spores which is not energy dependent and is a consequence of triggering of germination by some divalent cations, and second, some other events including loss of heat resistance, loss of spore refractility, and a decrease in absorbance, with at least one energy-dependent step.     

Conditions Affecting Germination of Clostridium botulinum 62A Spores in a Chemically Defined Medium

Spores of Clostridium botulinum type 62A were germinated in a chemically defined medium (8 mm l-cysteine, 11.9 mm sodium bicarbonate, 4.4 mm sodium thioglycolate; buffered with 100 mm TES, pH 7.0). The rate and extent of germination were increased when an aqueous spore suspension was heated sublethally (80 C, 60 min) before addition to the germination medium. Neither sublethal nor lethal doses of gamma radiation had any marked effect on subsequent germination. Maximum germination (>90% in 2 hr) in the defined medium occurred in the pH range of 6.5 to 7.5, at 30 to 37 C, with an l-cysteine level of 8 mm. Increasing l-cysteine to 32 mm increased the rate (over that with 8 mm l-cysteine) but not the extent of germination. The rate and extent of germination increased with NaHCO(3) addition to 8.3 mm, but increasing levels to 11.9 mm had no further effect. For maximum germination, 2.2 mm sodium thioglycolate was required and higher levels (to 8.8 mm) had no further enhancing or inhibitory effect. Under optimal conditions for germination, 97% of the spores had become heat sensitive; 98% had become sensitive to radiation; 88 and 91% had become phase dark and stainable, respectively, and the spore suspension had lost 46% of its initial optical density by 2 hr. Loss of heat resistance preceded loss of radiation resistance, acquisition of stainability, and phase darkening by about 12 min.     

Analysis of the action of compounds that inhibit the germination of spores of Bacillus species

AIMS: To determine the mechanism of action of inhibitors of the germination of spores of Bacillus species, and where these inhibitors act in the germination process. METHODS AND RESULTS: Spores of various Bacillus species are significant agents of food spoilage and food-borne disease, and inhibition of spore germination is a potential means of reducing such problems. Germination of the following spores was studied: (i) wild-type B. subtilis spores; (ii) B. subtilis spores with a nutrient receptor variant allowing recognition of a novel germinant; (iii) B. subtilis spores with elevated levels of either the variant nutrient receptor or its wild-type allele; (iv) B. subtilis spores lacking all nutrient receptors and (v) wild-type B. megaterium spores. Spores were germinated with a variety of nutrient germinants, Ca2+-dipicolinic acid (DPA) and dodecylamine for B. subtilis spores, and KBr for B. megaterium spores. Compounds tested as inhibitors of germination included alkyl alcohols, a phenol derivative, a fatty acid, ion channel blockers, enzyme inhibitors and several other compounds. Assays used to assess rates of spore germination monitored: (i) the fall in optical density at 600 nm of spore suspensions; (ii) the release of the dormant spore's large depot of DPA; (iii) hydrolysis of the dormant spore's peptidoglycan cortex and (iv) generation of CFU from spores that lacked all nutrient receptors. The results with B. subtilis spores allowed the assignment of inhibitory compounds into two general groups: (i) those that inhibited the action of, or response to, one nutrient receptor and (ii) those that blocked the action of, or response to, several or all of the nutrient receptors. Some of the compounds in groups 1 and 2 also blocked action of at least one cortex lytic enzyme, however, this does not appear to be the primary site of their action in inhibiting spore germination. The inhibitors had rather different effects on germination of B. subtilis spores with nutrients or non-nutrients, consistent with previous work indicating that germination of B. subtilis spores by non-nutrients does not involve the spore's nutrient receptors. In particular, none of the compounds tested inhibited spore germination with dodecylamine, and only three compounds inhibited Ca2+-DPA germination. In contrast, all compounds had very similar effects on the germination of B. megaterium spores with either glucose or KBr. The effects of the inhibitors tested on spores of both Bacillus species were largely reversible. CONCLUSIONS: This work indicates that inhibitors of B. subtilis spore germination fall into two classes: (i) compounds (most alkyl alcohols, N-ethylmaleimide, nifedipine, phenols, potassium sorbate) that inhibit the action of, or response to, primarily one nutrient receptor and (ii) compounds [amiloride, HgCl2, octanoic acid, octanol, phenylmethylsulphonylfluoride (PMSF), quinine, tetracaine, tosyl-l-arginine methyl ester, trifluoperazine] that inhibit the action of, or response to, several nutrient receptors. Action of these inhibitors, is reversible. The similar effects of inhibitors on B. megaterium spore germination by glucose or KBr indicate that inorganic salts likely trigger germination by activating one or more nutrient receptors. The lack of effect of all inhibitors on dodecylamine germination suggests that this compound stimulates germination by creating channels in the spore's inner membrane allowing DPA release. SIGNIFICANCE AND IMPACT OF THE STUDY: This work provides new insight into the steps in spore germination that are inhibited by various chemicals, and the mechanism of action of these inhibitors. The work also provides new insights into the process of spore germination itself.     

Analysis of factors influencing the rate of germination of spores of Bacillus subtilis by very high pressure

AIMS: To elucidate the factors that determine the rate of germination of Bacillus subtilis spores with very high pressure (VHP) and the mechanism of VHP germination. METHODS AND RESULTS: Spores of B. subtilis were germinated rapidly with a VHP of 500 MPa at 50 degrees C. This VHP germination did not require the spore's nutrient-germinant receptors, as found previously, and did not require diacylglycerylation of membrane proteins. However, the spore's pool of dipicolinic acid (DPA) was essential. Either of the two redundant enzymes that degrade the spore's peptidoglycan cortex, and thus allow completion of spore germination, was essential for completion of VHP germination. However, neither of these enzymes was needed for DPA release triggered by VHP treatment. Completion of spore germination as well as DPA release with VHP had an optimum temperature of approx. 60 degrees C, in contrast to an optimum temperature of 40 degrees C for germination with the moderately high pressure of 150 MPa. The rate of spore germination by VHP decreased approx. fourfold when the sporulation temperature increased from 23 degrees C to 44 degrees C, and decreased twofold when 1 mol l(-1) salt was present in sporulation. However, large variations in levels of unsaturated fatty acids in the spore's inner membranes did not affect rates of VHP germination. Complete germination of spores by VHP was not inhibited significantly by killing of spores with several oxidizing agents, and was not inhibited by ethanol, octanol or o-chlorophenol at concentrations that abolish nutrient germination. Completion of spore germination by VHP was also inhibited by Hg(2+), but this ion did not inhibit DPA release caused by VHP. In contrast, dodecylamine, a surfactant that can trigger spore germination, strongly inhibited DPA release caused by VHP treatment. CONCLUSIONS: VHP does not cause spore germination by acting upon the spore's nutrient-germinant receptors, but by directly causing DPA release. This DPA release then leads to subsequent completion of germination. VHP likely acts on the spore's inner membrane to cause DPA release, targeting either a membrane protein or the membrane itself. However, the precise identity of this target is not yet clear. SIGNIFICANCE AND IMPACT OF THE STUDY: There is significant interest in the use of VHP to eliminate or reduce levels of bacterial spores in foods. As at least partial spore germination by pressure is almost certainly essential for subsequent spore killing, knowledge of factors involved and the mechanism of VHP germination are crucial to the understanding of spore killing by VHP. This work provides new insight into factors that can affect the rate of B. subtilis spore germination by VHP, and into the mechanism of VHP germination itself.     

Isolation and characterization of Bacillus megaterium mutants containing decreased levels of spore protease.

A proteolytic activity present in spores of Bacillus megaterium has previously been implicated in the initiation of hydrolysis of the A, B, and C proteins which are degraded during spore germination. Four mutants of B. megaterium containing 20 to 30% of the normal level of spore proteolytic activity have been isolated. Partial purification of the protease from wild-type spores by a reviewed procedure resulted in the resolution of spore protease activity on the A, B, and C proteins into two peaks--a major one (protease II) and a minor one (protease I). The protease mutants tested lacked active protease II. All of the mutants exhibited a decreased rate of degradation of the A, B, and C proteins during spore germination at 30 degrees C, but degradation of the proteins did occur. Degradation of the A, B, and C proteins during germination of the mutant spores was decreased neither by blockade of ATP production nor by germination at 44 degrees C. Initiation of spore germination was normal in all four mutants, and all four mutants went through outgrowth, grew, and sporulated normally in rich medium. Similarly, outgrowth of spores of two of the four mutants was normal in minimal medium at 30 degrees C. In the two mutants studied, the kinetics of loss of spore heat resistance and spore UV light resistance during germination were identical to those of wild-type spores. This indicates that the A, B, and C proteins alone are not sufficient to account for the heat or UV light resistance of the dormant spore.     

Characterization of spores of Bacillus subtilis which lack dipicolinic acid

Spores of Bacillus subtilis with a mutation in spoVF cannot synthesize dipicolinic acid (DPA) and are too unstable to be purified and studied in detail. However, the spores of a strain lacking the three major germinant receptors (termed Deltager3), as well as spoVF, can be isolated, although they spontaneously germinate much more readily than Deltager3 spores. The Deltager3 spoVF spores lack DPA and have higher levels of core water than Deltager3 spores, although sporulation with DPA restores close to normal levels of DPA and core water to Deltager3 spoVF spores. The DPA-less spores have normal cortical and coat layers, as observed with an electron microscope, but their core region appears to be more hydrated than that of spores with DPA. The Deltager3 spoVF spores also contain minimal levels of the processed active form (termed P(41)) of the germination protease, GPR, a finding consistent with the known requirement for DPA and dehydration for GPR autoprocessing. However, any P(41) formed in Deltager3 spoVF spores may be at least transiently active on one of this protease's small acid-soluble spore protein (SASP) substrates, SASP-gamma. Analysis of the resistance of wild-type, Deltager3, and Deltager3 spoVF spores to various agents led to the following conclusions: (i) DPA and core water content play no role in spore resistance to dry heat, dessication, or glutaraldehyde; (ii) an elevated core water content is associated with decreased spore resistance to wet heat, hydrogen peroxide, formaldehyde, and the iodine-based disinfectant Betadine; (iii) the absence of DPA increases spore resistance to UV radiation; and (iv) wild-type spores are more resistant than Deltager3 spores to Betadine and glutaraldehyde. These results are discussed in view of current models of spore resistance and spore germination.     

Pressure inactivation of Bacillus endospores

The inactivation of bacterial endospores by hydrostatic pressure requires the combined application of heat and pressure. We have determined the resistance of spores of 14 food isolates and 5 laboratory strains of Bacillus subtilis, B. amyloliquefaciens, and B. licheniformis to treatments with pressure and temperature (200 to 800 MPa and 60 to 80 degrees C) in mashed carrots. A large variation in the pressure resistance of spores was observed, and their reduction by treatments with 800 MPa and 70 degrees C for 4 min ranged from more than 6 log units to no reduction. The sporulation conditions further influenced their pressure resistance. The loss of dipicolinic acid (DPA) from spores that varied in their pressure resistance was determined, and spore sublethal injury was assessed by determination of the detection times for individual spores. Treatment of spores with pressure and temperature resulted in DPA-free, phase-bright spores. These spores were sensitive to moderate heat and exhibited strongly increased detection times as judged by the time required for single spores to grow to visible turbidity of the growth medium. The role of DPA in heat and pressure resistance was further substantiated by the use of the DPA-deficient mutant strain B. subtilis CIP 76.26. Taken together, these results indicate that inactivation of spores by combined pressure and temperature processing is achieved by a two-stage mechanism that does not involve germination. At a pressure between 600 and 800 MPa and a temperature greater than 60 degrees C, DPA is released predominantly by a physicochemical rather than a physiological process, and the DPA-free spores are inactivated by moderate heat independent of the pressure level. Relevant target organisms for pressure and temperature treatment of foods are proposed, namely, strains of B. amyloliquefaciens, which form highly pressure-resistant spores.     

Inhibition of cortex hydrolysis during spore germination by CdCl2

When the spores of Bacillus megaterium QM B1551 (ATCC 12872) were incubated with 5 mM CdCl2 at 30 C, they underwent the early germination events, such as loss of heat resistance and release of calcium dipicolinate, in the same way as when they were germinated by glucose + KNO3. However, germination by CdCl2 caused no increase in the reducing groups in the cortex and no excretion of glucosamine-containing materials due to the hydrolysis of the cortex peptidoglycan. Addition of CdCl2 at any time during germination by glucose + KNO3 inhibited the release of glucosamine-containing materials from the spores, whereas removal of cadmium from the CdCl2-germinated spores by treatment with cysteine restored the hydrolysis of peptidoglycan. These results suggested that CdCl2 caused the early events of spore germination but prevented the spores from undergoing the events following germination by inhibiting the enzymatic lysis of the cortex peptidoglycan. The conclusion from the study is that cortex degradation is not always required for the initiation of germination.     

Microgermination of Bacillus cereus spores

The biphasic nature of germination curves of individual Bacillus cereus T spores was further characterized by assessing the effects of temperature, concentration of germinants, and some inorganic cations on microgermination. Temperature was shown to affect both phases of microgermination as well as the microlag period, whereas the concentration of l-alanine and supplementation with adenosine exerted a significant effect only on the microlag period. The germination curves of individual spores induced by inosine were also biphasic and resembled those of spores induced by l-alanine. High concentrations (0.1 m or higher) of calcium and other inorganic cations prolonged both phases of microgermination, particularly the second phase, and had a less pronounced effect on the microlag period. The second phase of microgermination was completely inhibited when spores were germinated either in the presence of 0.3 m CaCl(2) or at a temperature of 43 C; this inhibition was reversible. Observations on the germination of spore suspensions (kinetics of the release of dipicolinic acid and mucopeptides, loss of heat resistance, increase in stainability, decrease in turbidity and refractility) were interpreted on the basis of the biphasic nature of microgermination. Dye uptake by individual spores during germination appeared also to be a biphasic process.     

Characterization of Clostridium perfringens spores that lack SpoVA proteins and dipicolinic acid

Spores of Clostridium perfringens possess high heat resistance, and when these spores germinate and return to active growth, they can cause gastrointestinal disease. Work with Bacillus subtilis has shown that the spore's dipicolinic acid (DPA) level can markedly influence both spore germination and resistance and that the proteins encoded by the spoVA operon are essential for DPA uptake by the developing spore during sporulation. We now find that proteins encoded by the spoVA operon are also essential for the uptake of Ca(2+) and DPA into the developing spore during C. perfringens sporulation. Spores of a spoVA mutant had little, if any, Ca(2+) and DPA, and their core water content was approximately twofold higher than that of wild-type spores. These DPA-less spores did not germinate spontaneously, as DPA-less B. subtilis spores do. Indeed, wild-type and spoVA C. perfringens spores germinated similarly with a mixture of l-asparagine and KCl (AK), KCl alone, or a 1:1 chelate of Ca(2+) and DPA (Ca-DPA). However, the viability of C. perfringens spoVA spores was 20-fold lower than the viability of wild-type spores. Decoated wild-type and spoVA spores exhibited little, if any, germination with AK, KCl, or exogenous Ca-DPA, and their colony-forming efficiency was 10(3)- to 10(4)-fold lower than that of intact spores. However, lysozyme treatment rescued these decoated spores. Although the levels of DNA-protective alpha/beta-type, small, acid-soluble spore proteins in spoVA spores were similar to those in wild-type spores, spoVA spores exhibited markedly lower resistance to moist heat, formaldehyde, HCl, hydrogen peroxide, nitrous acid, and UV radiation than wild-type spores did. In sum, these results suggest the following. (i) SpoVA proteins are essential for Ca-DPA uptake by developing spores during C. perfringens sporulation. (ii) SpoVA proteins and Ca-DPA release are not required for C. perfringens spore germination. (iii) A low spore core water content is essential for full resistance of C. perfringens spores to moist heat, UV radiation, and chemicals.     

Pressure Inactivation of Bacillus Endospores

The inactivation of bacterial endospores by hydrostatic pressure requires the combined application of heat and pressure. We have determined the resistance of spores of 14 food isolates and 5 laboratory strains of Bacillus subtilis, B. amyloliquefaciens, and B. licheniformis to treatments with pressure and temperature (200 to 800 MPa and 60 to 80°C) in mashed carrots. A large variation in the pressure resistance of spores was observed, and their reduction by treatments with 800 MPa and 70°C for 4 min ranged from more than 6 log units to no reduction. The sporulation conditions further influenced their pressure resistance. The loss of dipicolinic acid (DPA) from spores that varied in their pressure resistance was determined, and spore sublethal injury was assessed by determination of the detection times for individual spores. Treatment of spores with pressure and temperature resulted in DPA-free, phase-bright spores. These spores were sensitive to moderate heat and exhibited strongly increased detection times as judged by the time required for single spores to grow to visible turbidity of the growth medium. The role of DPA in heat and pressure resistance was further substantiated by the use of the DPA-deficient mutant strain B. subtilis CIP 76.26. Taken together, these results indicate that inactivation of spores by combined pressure and temperature processing is achieved by a two-stage mechanism that does not involve germination. At a pressure between 600 and 800 MPa and a temperature greater than 60°C, DPA is released predominantly by a physicochemical rather than a physiological process, and the DPA-free spores are inactivated by moderate heat independent of the pressure level. Relevant target organisms for pressure and temperature treatment of foods are proposed, namely, strains of B. amyloliquefaciens, which form highly pressure-resistant spores.     

Mechanisms of killing of Bacillus subtilis spores by Decon and Oxone, two general decontaminants for biological agents

AIMS: To determine the mechanisms of Bacillus subtilis spore killing by and resistance to the general biological decontamination agents, Decon and Oxone. METHODS AND RESULTS: Spores of B. subtilis treated with Decon or Oxone did not accumulate DNA damage and were not mutagenized. Spore killing by these agents was increased if spores were decoated. Spores prepared at higher temperatures were more resistant to these agents, consistent with a major role for spore coats in this resistance. Neither Decon nor Oxone released the spore core's depot of dipicolinic acid (DPA), but Decon- and Oxone-treated spores more readily released DPA upon a subsequent normally sublethal heat treatment. Decon- and Oxone-killed spores initiated germination with dodecylamine more rapidly than untreated spores, but could not complete germination triggered by nutrients or Ca(2+)-DPA and did not degrade their peptidoglycan cortex. However, lysozyme treatment did not recover these spores. CONCLUSIONS: Decon and Oxone do not kill B. subtilis spores by DNA damage, and a major factor in spore resistance to these agents is the spore coat. Spore killing by both agents renders spores defective in germination, possibly because of damage to the inner membrane of spore. SIGNIFICANCE AND IMPACT OF STUDY: These results provide information on the mechanisms of the killing of bacterial spores by Decon and Oxone.