稻草秸秆预处理方法对烟曲霉产纤维素酶的影响

采用机械粉碎、高温、酸碱处理等方法对稻草秸秆进行预处理,以烟曲霉为实验菌株,研究预处理方法对菌株产纤维素酶的影响。结果表明,取机械粉碎后的稻草（30~120目）进行121℃高压蒸汽处理20min（即灭菌处理）,有利于菌株的生长与纤维素酶的产生;与未粉碎的稻草秸秆相比,烟曲霉羧甲基纤维素钠（CMC）酶、微晶纤维素酶、β-葡萄糖苷酶和滤纸（FPA）酶的活力分别提高了63.2%、164.0%、10.2%和14.1%。而采用不同种类、不同浓度的酸碱常温处理稻草秸秆4d或100℃高温处理30min,纤维素酶活力均出现了不同程度的下降。     

Xylanase and cellulase production byaspergillus fumigatus fresenius

Summary Cultures of Aspergillus fumigatus IMI 246651, ATCC 46324 produced larger amounts of extracellular xylanase and cellulase when grown on hay or straw than when grown on CF11 cellulose. The organism produced xylanase enzymes when grown on partially purified xylans but the amount of cellulase produced was much reduced.     

Gas holdup in an external-loop air-lift fermentor with a contaminated gas distributor

Contamination of the porous-plate gas distributor was observed in an air-lift fermentor used for Aspergillus fumigatus fermentations. Comparisons between gas holdups measured with uncontaminated distributors and the contaminated one showed that the contamination had no effect on gas holdups in water but reduced the holdups in sodium chloride and sodium sulfate solutions, probably due to increased bubble coalescence. A correlation for gas holdups with clean distributors(2) could be used to represent the results for the comtaminated distributor by changing the values used for the characteristic velocities of the electrolyte solutions.     

Optimization of L-malic acid production by Aspergillus flavus in a stirred fermentor

Effects of various nutritional and environmental factors on the accumulation of organic acids (mainly L-malic acid) by the filamentous fungus Aspergillus flavus were studied in a 16-L stirred fermentor. Improvement of the molar yield (moles acid produced per moles glucose consumed) of L-malic acid was obtained mainly by increasing the agitation rate (to 350 rpm) and the Fe(z+) ion concentration (to 12 mg/L) and by lowering the nitrogen (to 271 mg/L) and phosphate concentrations (to 1.5 mM) in the medium. These changes resulted in molar yields for L-malic acid and total C(4) acids (L-malic, succinic, and fumaric acids) of 128 and 155%, respectively. The high molar yields obtained (above 100%) are additional evidence for the operation of part of the reductive branch of the tricarboxylic acid cycle in L-malic acid accumulation by A. flavus. The fermentation conditions developed using the above mentioned factors and 9% CaCO(3) in the medium resulted in a high concentration (113 g/L L-malic acid from 120 g/L glucose utilized) and a high overall productivity (0.59 g/L h) of L-malic acid. These changes in acid accumulation coincide with increases in the activities of NAD(+)-malate dehydrogenase, fumarase, and citrate synthase.     

Itaconic acid production using an air-lift bioreactor in repeated batch culture of Aspergillus terreus

Repeated itaconic acid production using an air-lift bioreactor was carried out by three methods—two with cell recycling by means of centrifugation and filtration by a stainless steel filter set inside the bioreactor and one by repeated batch culture without cell recycling. In a flask culture, repeated itaconic acid production was stable for 9 cycles (45 d) and the production rate was 0.47 g/l/h. However, in the air-lift bioreactor, it was difficult to produce itaconic acid in the repeated batch culture with cell recycling for a long period due to a decrease in fluidity resulting from an increase in mycelium concentration. In the method without cell recycling, however, repeated itaconic acid production was stable for 4 cycles (21 d) and the production rate was 0.37 g/l/h.     

Bidirectional gene transfer between Aspergillus fumigatus and Aspergillus nidulans

Abstract The rpmF-plsX-fabH gene cluster of Rhodobacter capsulatus homologous to that of Escherichia coli was identified. rpmF encodes ribosomal protein L32, plsX plays an undefined role in membrane lipid synthesis, and fabH encodes β-ketoacyl-acyl carrier protein synthase III. The R. capsulatus plsX gene complemented a defect in an E. coli strain with the plsX50 mutation. Overproduction of the fabH gene product of R. capsulatus in E. coli resulted in dramatically increased β-ketoacyl-acyl carrier protein synthase III activity. These results indicate that plsX and fabH apparently function the same in R. capsulatus as in E. coli .     

Comparison of air-lift and stirred tank reactors for itaconic acid production by Aspergillus terreus

In a 2-l stirred tank reactor (STR), maximum production rate ofitaconic acid was 0.48g/l.h , for an agitation rate of 400 rpm andan aeration rate of 0.5 vvm. In an air-lift reactor (ALR) themaximum production rate was 0.64 g/l.h at an O supply rate of0.41 l O /l. min. Power input per unit volume which gave themaximum production rates for STR and ALR were 1180 and 542 W/m 3,respectively. If O -enriched air was used in place of air for ALR,the corre-sponding power input per unit volume was decreased to 34W/m 3 . ALR requires less power input per unit volume in comparisonwith that of STR whether therefore air or O -enriched air is used.ALR would be a suitable bioreactor for a large production of itaconicacid.     

Heterologous production of Aspergillus fumigatus keratinase in Pichia pastoris

Aspergillus fumigatus Fresenius was previously shown to grow in mineral medium containing chicken feather flour as carbon and nitrogen source. Substantial proteolytic keratin-degrading activity was present in the culture supernatant after 24–72 h of growth at 42 °C. The keratinase was successfully purified by a single ion exchange chromatographic procedure and had a molecular mass of 31 kDa as determined by SDS–PAGE. The keratinase cDNA was expressed in Pichia pastoris cells and the recombinant clones were shown to be able to produce substantial caseinolytic, azo-keratinolytic and keratinolytic activities. SDS–PAGE and Western-blotting analysis using antibody against keratinase of A. fumigatus showed the presence of a single protein in the culture supernatants of several recombinant P. pastoris cells. This protein had a molecular mass corresponding to that of the A. fumigatus keratinase. The enzyme production profile showed that theP. pastoris recombinant cells produced an increasing amount of proteolytic and azo-keratinolytic activities over a 72 h growth period. Dry weight determination analysis indicated that 10% of the keratin flour was hydrolysed over a 24 h incubation period with 510 U (caseinolytic activity) of the recombinant keratinase.     

Mastitis by Aspergillus fumigatus in sheep

Several outbreaks of sheep mastitis by Aspergillus fumigatus in Castilla y Leon (Spain), were studied. Only sheep that were treated intramammarily with antibacterial antibiotics during the dry period suffered this mastitis. Mastitis was acute with a morbidity up to 14 % and mortality near 100 %. The udder was markedly enlarged in size, fibrotic, haemorrhagic and with multiple compact nodules, some with purulent material inside; after 30-50 days postpartum, cheesy abscess of several centimetres in diameter were present. Some sheep had granulomatous nodules in the lung. Microscopy and culture shown the presence of A. fumigatus in milk, udder and lung. The route of infection was by intramammary via as a consequence of unhygienic intramammary treatment in the dry period.     

Improvement of trypanocidal metabolites production by Aspergillus fumigatus using neural networks

An optimization procedure using artificial neural networks was developed to determine the optimal combination of parameters, such as medium culture, initial pH, temperature and time of fermentation for maximal trypanocidal metabolites production by Aspergillus fumigatus. A data set of 81 experiments was carried out and an artificial neural network was trained to identify the optimal conditions for this process. Good correlation was obtained between the experimental and predicted values of lysis of the trypomastigote forms of Trypanosoma cruzi (r2 = 0.9990). The simulations of fermentation performance were undertaken on combinations of input variables and the highest level of activity against T. cruzi was obtained from the chloroform extract of the modified Jackson medium culture, initial pH of 6.0, incubated at 40 degrees C for 144 h. It displayed lysis of 95% of the trypomastigote forms of T. cruzi and the red blood cells remained normal.     

Effect of aeration on gliotoxin production by Aspergillus fumigatus in its culture filtrate

Gliotoxin, one of the mycotoxins produced by Aspergillus fumigatus, has various, potent bioactivities. However, it has not been considered to be a toxic (or virulence) factor because of its slow production. The aim of the present study was to investigate the effects of aeration on the cytotoxicity of A. fumigatus culture filtrate, and to determine the optimal condition for the rapid production of gliotoxin from this fungus. Fungal culture filtrates were made in three different containers under various conditions of aeration and O2 concentration. These filtrates were compared in terms of their cytotoxicity on murine macrophages and analyzed by gas chromatography. The culture filtrate showed high cytotoxicity when it was made under highly aerated conditions, but it was significantly less cytotoxic when prepared under non-aerated conditions. The cytotoxic activity became evident within 15 h of culture at 20% O2, when the fungus had already started producing gliotoxin. The culture filtrates also contained some other as yet unidentified substances that might also to some extent contribute to the cytotoxicity. In light of these results, the authors propose that a highly aerated condition is responsible for the rapid production of gliotoxin, and that gliotoxin might play an important role in the respiratory infection by A. fumigatus, with other toxic substances acting additively or synergistically.     

Effect of aeration on gliotoxin production by Aspergillus fumigatus in its culture filtrate

Gliotoxin, one of the mycotoxins produced by Aspergillus fumigatus, has various, potent bioactivities. However, it has not been considered to be a toxic (or virulence) factor because of its slow production. The aim of the present study was to investigate the effects of aeration on the cytotoxicity of A. fumigatus culture filtrate, and to determine the optimal condition for the rapid production of gliotoxin from this fungus. Fungal culture filtrates were made in three different containers under various conditions of aeration and O2 concentration. These filtrates were compared in terms of their cytotoxicity on murine macrophages and analyzed by gas chromatography. The culture filtrate showed high cytotoxicity when it was made under highly aerated conditions, but it was significantly less cytotoxic when prepared under non-aerated conditions. The cytotoxic activity became evident within 15 h of culture at 20% O2, when the fungus had already started producing gliotoxin. The culture filtrates also contained some other as yet unidentified substances that might also to some extent contribute to the cytotoxicity. In light of these results, the authors propose that a highly aerated condition is responsible for the rapid production of gliotoxin, and that gliotoxin might play an important role in the respiratory infection by A. fumigatus, with other toxic substances acting additively or synergistically.     

Effect of cultural factors on cellulase activity and protein production by Aspergillus terreus

Protein production by Aspergillus terreus GN1 grown on 1.0% alkali-treated bagasse was studied under various cultural conditions. The maximum biomass protein content of 20.1% and protein recovery of 11.2% was obtained with an initial pH of 4.0, with 1/5 (v/v) inoculum in continuously shaken cultures grown for seven days. Protein content of the alkali-treated bagasse was 3.0%. Highest crude protein percent also corresponded with highest carboxymethyl cellulase and filter paper enzyme activities.     

Cellulose degradation and carboxymethylcellulase production by Sporocytophaga myxococcoides grown in an air-lift fermenter

Summary Sporocytophaga myxcoccoides was grown in a 31 air-lift fermenter using a medium containing 2% w/v insoluble cellulose. The cellulose content of the medium reduced the k_La of the fermenter but during growth the dissolved oxygen concentration did not fall below 75% saturation. Rates of cellulose degradation and extracellular enzyme production were similar to those reported for a stirred-tank fermenter.     

The interplay between iron and zinc metabolism in Aspergillus fumigatus

Zinc plays a critical role in a diverse array of biochemical processes. However, excess of zinc is deleterious to cells. Therefore, cells require finely tuned homeostatic mechanisms to balance uptake and storage of zinc. Here we show that iron starvation affects zinc metabolism by downregulating expression of the plasma membrane zinc importer encoding zrfB and upregulating the putative vacuolar zinc transporter-encoding zrcA in Aspergillus fumigatus. Nevertheless, the zinc content of iron-starved mycelia exceeded that of iron replete mycelia, possibly due to unspecific metal uptake induced by iron starvation. In agreement with increased zinc excess and zinc toxicity during iron starvation, deficiency in siderophore-mediated high-affinity iron uptake caused hypersensitivity to zinc. Moreover, an increase of zinc uptake by conditional overexpression of zrfB was more toxic under iron depleted compared to iron replete conditions. This deregulated zinc uptake under iron starvation caused a decrease in heme production and an increase in protoporphyrin IX accumulation. Furthermore, zinc excess impaired production of the extracellular siderophore triacetylfusarinine C but not the intracellular siderophore ferricrocin. Taken together, these data demonstrate a fine tuned coordination of zinc and iron metabolism in A. fumigatus.     

Optimization of the composition of the nutrient medium for cellulase and protein biosynthesis by thermophilic Aspergillus fumigatus NRC 272

An active strain of Aspergillus spp. has been selected for the production of cellulolytic enzymes and proteins when grown on peracetic acid-treated wheat straw. This strain produced a considerable amount of cellulase [see 1,4-(1,3;1,4)-β-d-glucan 4-glucanohydrolase, EC 3.2.1.4] in the extracellular supernatant and exhibited good overall cellulolytic activity, as measured using filter paper and Avicel as substrates. Also, under the same conditions the strain showed high activities of β-d-glucosidase (β-d-glucoside glucohydrolase, EC 3.2.1.21) and β-d-xylosidase (1,4-β-d-xylan xylohydrolase, EC 3.2.1.37). The maximum enzyme yields (carboxymethylcellulose activity 26.4 units ml^?1, filter paper activity 2.26 units ml^?1 and Avicel activity 16.82 units ml^?1; β-d-glucosidase 9.09 units ml^?1 and β-d-xylosidase 1.92 units ml^?1) were obtained after 96 h incubation at 45°C.