Comparison of a membrane surface adhesion recovery method with an IMS method for use in a polymerase chain reaction method to detect Escherichia coli O157:H7 in minced beef

In this study, enrichment procedures and two recovery methods, a membrane surface adhesion technique and an immunomagnetic separation (IMS), were compared for use in conjunction with a multiplex polymerase chain reaction (PCR) method with a view to describing a fast (24 h) and economical test for detection of Escherichia coli O157:H7 in meat samples. The study showed no significant difference between three different enrichment media (BHI, E. coli (E.C.) broth+novobiocin, modified tryptone soya broth (mTSB)+novobiocin) or two incubation temperatures (37 or 41.5 degrees C) for growth of E. coli O157:H7 in minced beef. Minced beef samples inoculated with E. coli O157:H7 at 40 cfu g(-1) were incubated at 37 degrees C for 16 h in E.C. broth+novobiocin reaching numbers of (log(10)7.82-8.70). E. coli O157:H7 were recovered by attachment to polycarbonate membranes immersed in the enriched cultures for 15 min or by immunomagnetic separation. Subsequent treatment of recovered membranes or IMS beads with lysis buffer and phenol/chloroform/isoamyl alcohol was used to extract the DNA from the extracted E. coli O157:H7 cells. The results show when E. coli O157:H7 was present at high levels in the enriched meat sample (log(10)9.6-7.5 cfu ml(-1); >16-h enrichment), the membrane and IMS techniques recovered similar levels of the pathogen and the microorganism was detectable by PCR using both methods. At lower levels of E. coli O157:H7 (log(10)6.4), only the IMS method could recover the pathogen but at levels below this neither method could recover sufficient numbers of the pathogens to allow detection. The conclusion of the study is that with sufficient enrichment time (16 h) the membrane surface adhesion membrane extraction method used in combination with multiplex PCR has the potential for a rapid and economical detection method.     

An adapted ImmunoMagnetic cell separation method for use in quantification of Escherichia coli O157:H7 from bovine faeces

Detection of Escherichia coli O157:H7 organisms in food, clinical or environmental samples is necessary for diagnosis of infection and epidemiological investigations. However, this pathogen may be present in low numbers and difficult to identify among high numbers of other background bacteria. In order to increase the sensitivity of culture- and PCR detection, pre-enrichment of E. coli O157:H7 in broth culture combined with ImmunoMagnetic cell Separation (IMS) is routinely employed. These methods, although able to detect levels as low as 2 cfu/g (from 10 to 25 g samples), are qualitative detection strategies only. If the actual numbers of E. coli O157:H7 are to be quantified, growth enrichment must be excluded and the organisms isolated directly from the sample of interest. Such quantification is necessary, for example, to determinate contamination levels on beef carcasses and for determination of bacterial numbers in in vivo gene expression studies. In the present study, it was not possible to recover organisms from bovine faecal suspensions using the customary IMS system and so a range of alternative buffers and other paramagnetic beads was tested. Combination of a 6.2-microm diameter bead with a detergent-based buffer gave optimal recovery of E. coli O157:H7 organisms from faecal suspensions. This system was validated for recovery of E. coli O157:H7 by comparing it with that obtained with the standard Dynabeads IMS protocol, using both the traditional broth enrichment method and a quantitative detection approach. We conclude that a 6.2-microm diameter Aureon bead can be used for quantitative isolation of E. coli O157:H7 directly from bovine faeces and, for this purpose, is preferred to the 2.8-microm diameter Dynal bead.     

Enumeration of Salmonella and Escherichia coli O157:H7 in ground beef, cattle carcass, hide and faecal samples using direct plating methods

AIM: To develop and validate high throughput methods for the direct enumeration of viable and culturable Salmonella and Escherichia coli O157:H7 in ground beef, carcass, hide and faecal (GCHF) samples from cattle. METHODS AND RESULTS: The hydrophobic grid membrane filtration (HGMF) method and the spiral plate count method (SPCM) were evaluated as rapid tools for the estimation of pathogen load using GCHF samples spiked with known levels of Salmonella serotype Typhimurium. Validation studies showed that for a single determination of each sample type the low end of the detection limits were approx. 2.0 x 10(0) CFU g(-1) for ground beef, 5.0 x 10(-1) CFU (100 cm(2))(-1) for Salmonella and 8.0 x 10(-1) CFU (100 cm(2))(-1) for E. coli O157:H7 on carcasses, 4.0 x 10(1) CFU (100 cm(2))(-1) for hide and 2.0 x 10(2) CFU g(-1) for faecal samples. In addition, ground beef (n = 609), carcass (n = 1520) and hide (n = 3038) samples were collected from beef-processing plants and faecal samples (n = 3190) were collected from feed-lot cattle, and these samples were tested for the presence of Salmonella and E. coli O157:H7 by enrichment and enumeration methods. CONCLUSIONS: The direct enumeration methods described here are amenable to high throughput sample processing and were found to be cost-effective alternatives to other enumeration methods for the estimation of Salmonella and E. coli O157:H7, in samples collected during cattle production and beef processing. SIGNIFICANCE AND IMPACT OF THE STUDY: Use of the methods described here would allow for more routine testing and quantification data collection, providing useful information about the effectiveness of beef processing intervention strategies.     

Fate of enterohemorrhagic Escherichia coli O157:H7 in bovine feces.

Dairy cattle have been identified as a principal reservoir of Escherichia coli O157:H7. The fate of this pathogen in bovine feces at 5, 22, and 37 degrees C was determined. Two levels of inocula (10(3) and 10(5) CFU/g) of a mixture of five nalidixic acid-resistant E. coli O157:H7 strains were used. E. coli O157:H7 survived at 37 degrees C for 42 and 49 days with low and high inocula, respectively, and at 22 degrees C for 49 and 56 days with low and high inocula, respectively. Fecal samples at both temperatures had low moisture contents (about 10%) and water activities ( < 0.5) near the end of the study. E. coli O157:H7 at 5 degrees C survived for 63 to 70 days, with the moisture content (74%) of feces remaining high through the study. Chromosomal DNA fingerprinting of E. coli O157:H7 isolates surviving near the completion of the study revealed that the human isolate strain 932 was the only surviving strain at 22 or 37 degrees C. All five strains were isolated near the end of incubation from feces held at 5 degrees C. Isolates at each temperature were still capable of producing both verotoxin 1 and verotoxin 2. Results indicate that E. coli O157:H7 can survive in feces for a long period of time and retain its ability to produce verotoxins. Hence, bovine feces are a potential vehicle for transmitting E. coli O157:H7 to cattle, food, and the environment. Appropriate handling of bovine feces is important to control the spread of this pathogen.     

The prevalence and spread of Escherichia coli O157:H7 at a commercial beef abattoir

AIMS: To investigate the prevalence and virulence characteristics of Escherichia coli O157:H7 after a number of beef process operations at a commercial Irish abattoir. METHODS AND RESULTS: Two 12-month studies were carried out. The first study (study 1) examined the prevalence of E. coli O157:H7 at up to six sites on carcasses at eight stages of the dressing, washing, chilling and boning process. The second study (study 2) examined the prevalence of E. coli O157:H7 in bovine faeces and rumen contents post-slaughter and on dressed, washed carcasses. Isolates from both studies were phage-typed and the presence of genes encoding verocytotoxin, enterohaemolysin and intimin production was determined. E. coli O157:H7 was isolated from four of 36 carcasses in study 1. E. coli O157:H7 was detected during hide removal and was detected at multiple carcass sites and multiple process stages, including boning. On two carcasses, contamination was first detected at the bung following its freeing and tying. All isolates from study 1 were phage type (PT) 2, eaeAO157 and ehlyA positive, but were verocytotoxin 1 (VT1) and verocytotoxin 2 (VT2) negative. In study 2, E. coli O157:H7 was isolated from 2.4% of faecal, 0.8% of rumen and 3.2% of carcass samples. In some cases, isolates recovered from the faeces of a particular animal, the resulting carcass and adjacent carcasses on the line had the same phage typing and virulence characteristic profile patterns. All isolates from study 2 were eaeAO157 and ehlyA positive and only one isolate was VT1 and VT2 negative. Most isolates were PT 32. A higher frequency of positive isolations was noted from samples taken during spring and late summer. CONCLUSION: These studies show that in a typical Irish beef abattoir, carcass contamination with E. coli O157:H7 can occur during hide removal and bung tying and this contamination can remain on the carcass during subsequent processing. SIGNIFICANCE AND IMPACT OF THE STUDY: This study provides data that is necessary for the understanding of how E. coli O157:H7 contamination of beef occurs.     

A comparison of sensitivity between direct plate culture, immunomagnetic separation and polymerase chain reaction for the isolation of enterohemorrhagic Escherichia coli O157]

Sensitivities of direct plate culture (DPC) method, immunomagnetic separation (IMS) method, and polymerase chain reaction (PCR) assay for successful detection Escherichia coli O157 in the food samples were compared. Three lots of minced beef and three lots of radish sprout, both of which were commercially retailed, were enriched with non-selective broth media at 36 degrees C for 6 h. After enrichment, the cultures of the minced beef and those of the radish sprout were found to have background microflora at ca.10(5)-10(7) CFU/ml and ca.10(8) CFU/ml, respectively. The cultures were then experimentally inoculated with E. coli O157 strains at various final concentrations ranging from ca.10 to 10(7) CFU/ml. The samples thus prepared were subjected to the above three methods to evaluate their detection limits. For the samples of minced beef, the detection limits of the DPC method was 10(2) CFU/ml whilst that of the IMS method was ca.10 CFU/ml. For the samples of radish sprout, the detection limits of the DPC method, the IMS method, and the PCR assay were ca.10(4) CFU/ml, ca.10(2) CFU/ml, and ca.10(6) CFU/ml, respectively. There results strongly suggest that the IMS method is most sensitive method for the detection of O157 from food samples among the methods currently available.     

Fate of pGFP-bearing Escherichia coli O157:H7 in ground beef at 2 and 10 degrees C and effects of lactate, diacetate, and citrate

Although beef has been implicated in the largest outbreaks of Escherichia coli O157:H7 infection in the United States, studies on the fate of this pathogen have been limited. Problems in such studies are associated with detection of the pathogen at levels considerably lower than the levels of the competing microorganisms. In the present study, a green fluorescent protein-expressing E. coli O157:H7 strain was used, and the stable marker allowed us to monitor the behavior of the pathogen in ground beef stored aerobically from freshness to spoilage at 2 and 10 degrees C. In addition, the effects of sodium salts of lactate (SL) (0.9 and 1.8%), diacetate (SDA) (0.1 and 0.2%), and buffered citrate (SC) (1 and 2%) and combinations of SL and SDA were evaluated. SC had negligible antimicrobial activity, and SL delayed microbial growth, while SDA and SL plus SDA were most inhibitory to the total-aerobe population in the meat. At 2 degrees C, the initial numbers of E. coli O157:H7 (3 and 5 log(10) CFU/g) decreased by approximately 1 log(10) CFU/g when spoilage was manifest (>7 log(10) CFU of total aerobes/g), irrespective of the treatment. There was no decline in the numbers of the pathogen during storage at 10 degrees C. Our results showed that the pathogen was resistant to the salts tested and confirmed that refrigerated meat contaminated with the pathogen remains hazardous.     

Sensitive detection of Escherichia coli O157:H7 in food and water by immunomagnetic separation and solid-phase laser cytometry

Rapid, direct methods are needed to assess active bacterial populations in water and foods. Our objective was to determine the efficiency of bacterial detection by immunomagnetic separation (IMS) and the compatibility of IMS with cyanoditolyl tetrazolium chloride (CTC) incubation to determine respiratory activity, using the pathogen Escherichia coli O157:H7. Counterstaining with a specific fluorescein-conjugated anti-O157 antibody (FAb) following CTC incubation was used to allow confirmation and visualization of bacteria by epifluorescence microscopy. Broth-grown E. coli O157:H7 was used to inoculate fresh ground beef (<17% fat), sterile 0.1% peptone, or water. Inoculated meat was diluted and homogenized in a stomacher and then incubated with paramagnetic beads coated with anti-O157 specific antibody. After IMS, cells with magnetic beads attached were stained with CTC and then an anti-O157 antibody-fluorescein isothiocyanate conjugate and filtered for microscopic enumeration or solid-phase laser cytometry. Enumeration by laser scanning permitted detection of ca. 10 CFU/g of ground beef or <10 CFU/ml of liquid sample. With inoculated meat, the regression results for log-transformed respiring FAb-positive counts of cells recovered on beads versus sorbitol-negative plate counts in the inoculum were as follows: intercept = 1.06, slope = 0.89, and r2 = 0. 95 (n = 13). The corresponding results for inoculated peptone were as follows: intercept = 0.67, slope = 0.88, and r2 = 0.98 (n = 24). Recovery of target bacteria on beads by the IMS-CTC-FAb method, compared with recovery by sorbitol MacConkey agar plating, yielded greater numbers (beef, 6.0 times; peptone, 3.0 times; water, 2.4 times). Thus, within 5 to 7 h, the IMS-CTC-FAb method detected greater numbers of E. coli O157 cells than were detected by plating. The results show that the IMS-CTC-FAb technique with enumeration by either fluorescence microscopy or solid-phase laser scanning cytometry gave results that compared favorably with plating following IMS.     

Prevalence of Escherichia coli O157:H7 in industrial minced beef

AIMS: The lack of baseline data on the prevalence of Escherichia coli O157:H7 in retail minced beef in France prompted this survey of industrial minced beef production. METHODS AND RESULTS: An automated enzyme-linked fluorescence immunoassay (ELFA), the VIDAS E. coli O157 method, was used to detect E. coli O157 in industrial minced beef samples. Confirmation of samples positive according to the ELFA was performed using an automated immunoconcentration (ICE) system, VIDAS ICE, which allows the selective capture and release of target organisms. The ICE was followed by culture on cefixime tellurite sorbitol MacConkey agar and a chromogenic medium, O157:H7 ID. Of the 3450 minced beef samples tested, 175 samples were positive with the ELFA method and, of these, four were confirmed by the ICE method. They were identified as sorbitol-negative, O157-positive, H7-positive, mobile, verotoxin-producing E. coli. CONCLUSIONS: The prevalence of E. coli O157:H7 in industrial French minced beef was 0.12%, consistent with many other reports. SIGNIFICANCE AND IMPACT OF THE STUDY: The low infective dose of E. coli O157:H7 presents a major threat. The main means of combating this organism are thermal destruction and good food hygiene covering activities on-farm, in the abattoir and in minced beef industries.     

Shiga-toxigenic Escherichia coli O157 and non-Shiga-toxigenic E. coli O157 respond differently to culture and isolation from naturally contaminated bovine faeces

AIM: To quantify the effect of enrichment, immunomagnetic separation (IMS), and selective plating procedures on isolation of Shiga-toxigenic Escherichia coli O157 (STEC O157) and non-Shiga-toxigenic Escherichia coli O157 (non-STEC O157) from naturally contaminated bovine faeces. METHODS AND RESULTS: Two broth enrichment times, two IMS strategies, and two selective plating media were evaluated. STEC O157 and non-STEC O157 strains were often isolated from the same faecal specimen and responded differently to the isolation protocols. A large-volume IMS system was more sensitive than a conventional small-volume IMS method, but was also more expensive. STEC O157 was more frequently isolated from 6 h enriched broth and ChromAgar plates containing 0.63 mg l(-1) potassium tellurite (TCA). Non-STEC O157 was more frequently isolated from un-enriched broth and ChromAgar plates without tellurite (CA). CONCLUSIONS: The combination of 6-h enrichment in Gram-negative broth containing vancomycin, cefixime and cefsuludin, large volume IMS and selective plating on TCA maximized STEC O157 recovery from naturally contaminated cattle faecal specimens. SIGNIFICANCE AND IMPACT OF THE STUDY: The pairing of proper enrichment with a specific plating procedure is key for STEC O157 recovery from naturally contaminated bovine faeces. Incorporating tellurite into an E. coli O157 detection strategy may select for the subset of E. coli O157 that contains the Shiga-toxin genes.     

Detection and quantification of Escherichia coli O157:H7 in environmental samples by real-time PCR

AIMS: To apply the real-time Polymerase chain reaction (PCR) method to detect and quantify Escherichia coli O157:H7 in soil, manure, faeces and dairy waste washwater. METHODS AND RESULTS: Soil samples were spiked with E. coli O157:H7 and subjected to a single enrichment step prior to multiplex PCR. Other environmental samples suspected of harbouring E.coli O157:H7 were also analysed. The sensitivity of the primers was confirmed with DNA from E.coli O157:H7 strain 3081 spiked into soil by multiplex PCR assay. A linear relationship was measured between the fluorescence threshold cycle (C T ) value and colony counts (CFU ml(-1)) in spiked soil and other environmental samples. The detection limit for E.coli O157:H7 in the real-time PCR assay was 3.5 x 10(3) CFU ml(-1) in pure culture and 2.6 x 10(4) CFU g(-1) in the environmental samples. Use of a 16-h enrichment step for spiked samples enabled detection of <10 CFU g(-1) soil. E. coli colony counts as determined by the real-time PCR assay, were in the range of 2.0 x 10(2) to 6.0 x 10(5) CFU PCR (-1) in manure, faeces and waste washwater. CONCLUSIONS: The real-time PCR-based assay enabled sensitive and rapid quantification of E. coli O157:H7 in soil and other environmental samples. SIGNIFICANCE AND IMPACT OF THE STUDY: The ability to quantitatively determine cell counts of E.coli O157:H7 in large numbers of environmental samples, represents considerable advancement in the area of pathogen quantification for risk assessment and transport studies.     

The optimization of isolation media used in immunomagnetic separation methods for the detection of Escherichia coli O157 in foods

AIMS: To compare media used in immunomagnetic separation (IMS) techniques for the isolation of Escherichia coli O157 from food. METHODS AND RESULTS: Foods, both naturally contaminated and spiked, with low numbers (< 1 g(-1)) of stressed E. coli O157 were enriched in media based on buffered peptone water (BPW), tryptone soya and EC broths incubated at 30, 37, 40 and 42 degrees C. Following immunomagnetic separation, beads were plated on a range of selective agars. CONCLUSION: BPW supplemented with vancomycin (8 mg l(-1)) incubated at 42 degrees C, followed by IMS and subsequent plating of immunobeads onto cefixime tellurite sorbitol MacConkey agar plus either Rainbow or CHROMagar agars, proved optimum for the recovery of spiked, stressed E. coli O157 in minced beef, cheese, apple juice and pepperoni. The same protocol was optimum for recovery from naturally-contaminated minced beef and cheese. SIGNIFICANCE AND IMPACT OF THE STUDY: The optimum protocol would increase isolation rates of E. coli O157 from foods.     

Characterization of glycerol kinase and NAD-independent glycerol-3-phosphate dehydrogenase from Pediococcus pentosaceus N5p

The polymerase chain reaction (PCR) has the potential to detect low levels of the human pathogen Escherichia coli O157 : H7 in bovine faeces. To improve the utility of PCR for this application, several methods for preparing template DNA from bovine faeces, both directly and after non-selective enrichment, were tested. These were boiling, enzyme treatment, enzyme treatment plus phenol-chloroform extraction, and enzyme treatment plus phenol-chloroform extraction plus Geneclean^® purification. Of these, the boiling method was the most consistent and had a sensitivity of approximately 3 cfu g⁻¹ faeces, with an assay time of less than 32 h. The boiling method was also combined with immunomagnetic separation (IMS) to detect E. coli O157 : H7 in less than 8 h, but with a sensitivity of approximately 10³ cfu g⁻¹ faeces. These methods can be used to prepare template for PCR screening of bovine faeces using any appropriate PCR primers.     

Surface decontamination of beef inoculated with Salmonella Typhimurium DT104 or Escherichia coli O157:H7 using dry air in a novel heat treatment apparatus

AIMS: To determine the effectiveness of a novel dry air decontamination apparatus in the deactivation of Salmonella serotype Typhimurium DT104 or Escherichia coli O157:H7 on beef surfaces. METHODS AND RESULTS: A laboratory scale dry air decontamination apparatus, capable of producing repeatable and known heating time-temperature cycles on food surfaces was used in decontamination trials. Beef samples were surface inoculated with 7-8 log10CFU cm(-2) of S. Typhimurium DT104 or E. coli O157:H7 and heated at 60, 75, 90 and 100 degrees C using fast and slow heating rates and subsequently held at these temperatures for up to 600 s. A substantial reduction in pathogen numbers was achieved at higher temperatures (90 and 100 degrees C, 4.18-6.06 log10CFU cm(-2)) using both heating rates, but cell survival at these temperatures was also observed. At the lower temperatures, deactivation was small at 60 degrees C in particular it was less than one log unit after 3 min heating. No significant differences were observed when total reductions in pathogen counts were compared for all the temperature/heat up time combinations tested. During slow heating at 90 degrees C, and both heating rates at 100 degrees C, the pattern of deactivation of S. Typhimurium DT104 or E. coli O157:H7 was triphasic. CONCLUSIONS: This study has shown that heating meat surfaces with dry air can achieve substantial reductions in S. Typhimurium DT104 or E. coli O157:H7. As surface decontamination of beef surfaces with dry air had a negative effect on beef colour and appearance, such a decontamination apparatus would be unsuitable for producing meat for retail sale but it could be used to produce safer meat for use in the catering trade. SIGNIFICANCE AND IMPACT OF THE STUDY: This study provides researchers and food processors with data on the dynamic changes in S. Typhimurium DT104 and E. coli O157:H7 counts on intact beef surfaces during heating with dry air under realistic (time-varying) temperature conditions.     

Frequency of Escherichia coli O157:H7 isolation from stool specimens

During a 6-month period, 7252 faeces specimens were examined for Escherichia coli serotype O157:H7. Forty-nine specimens (0.7%) from 19 patients yielded this organism. Escherichia coli O157:H7 was the third most frequently isolated bacterial pathogen, following Campylobacter jejuni and (or) Salmonella sp. Although regional variation between laboratories determined whether Campylobacter jejuni or Salmonella was the primary bacterial pathogen isolated, E. coli O157:H7 was consistently isolated more frequently than either Shigella or Yersinia enterocolitica.     

Evaluation of a PCR detection method for Escherichia coli O157:H7/H- bovine faecal samples

AIMS: Combinations of PCR primer sets were evaluated to establish a multiplex PCR method to specifically detect Escherichia coli O157:H7 genes in bovine faecal samples. METHODS AND RESULTS: A multiplex PCR method combining three primer sets for the E. coli O157:H7 genes rfbE, uidA and E. coli H7 fliC was developed and tested for sensitivity and specificity with pure cultures of 27 E. coli serotype O157 strains, 88 non-O157 E. coli strains, predominantly bovine in origin and five bacterial strains other than E. coli. The PCR method was very specific in the detection of E. coli O157:H7 and O157:H- strains, and the detection limit in seeded bovine faecal samples was <10 CFU g(-1) faeces, following an 18-h enrichment at 37 degrees C, and could be performed using crude DNA extracts as template. CONCLUSIONS: A new multiplex PCR method was developed to detect E. coli O157:H7 and O157:H-, and was shown to be highly specific and sensitive for these strains both in pure culture and in crude DNA extracts prepared from inoculated bovine faecal samples. SIGNIFICANCE AND IMPACT OF THE STUDY: This new multiplex PCR method is suitable for the rapid detection of E. coli O157:H7 and O157:H- genes in ruminant faecal samples.     

Rapid and sensitive detection of Escherichia coli O157:H7 in bovine faeces by a multiplex PCR

Cattle are considered the major reservoir for Escherichia coli O157:H7, one of the newly emerged foodborne human pathogens of animal origin and a leading cause of haemorrhagic colitis in humans. A sensitive test that can accurately and rapidly detect the organism in the food animal production environment is critically needed to monitor the emergence, transmission, and colonization of this pathogen in the animal reservoir. In this study, a novel multiplex polymerase chain reaction (PCR) assay was developed by using 5 sets of primers that specifically amplify segments of the eaeA, slt-I, slt-II, fliC, rfbE genes, which allowed simultaneous identification of serotype O157:H7 and its virulence factors in a single reaction. Analysis of 82 E. coli strains (49 O157:H7 and 33 non-O157:H7) demonstrated that this PCR system successfully distinguished serotype O157:H7 from other serotypes of E. coli and provided accurate profiling of the shiga-like toxins and the intimin adhesin in individual strains. This multiplex PCR assay did not cross-react with the background bacterial flora in bovine faeces and could detect a single O157:H7 organism per gram of faeces when combined with an enrichment step. Together, these results indicate that the multiplex PCR assay can be used for specific identification and profiling of E. coli O157:H7 isolates, and may be applied to rapid and sensitive detection of E. coli O157:H7 in bovine faeces when combined with an enrichment step.     

Combined effect of high-pressure treatments and bacteriocin-producing lactic acid bacteria on inactivation of Escherichia coli O157:H7 in raw-milk cheese

The effect of high-pressure (HP) treatments combined with bacteriocins of lactic acid bacteria (LAB) produced in situ on the survival of Escherichia coli O157:H7 in cheese was investigated. Cheeses were manufactured from raw milk inoculated with E. coli O157:H7 at approximately 10(5) CFU/ml. Seven different bacteriocin-producing LAB were added at approximately 10(6) CFU/ml as adjuncts to the starter. Cheeses were pressurized on day 2 or 50 at 300 MPa for 10 min or 500 MPa for 5 min, at 10 degrees C in both cases. After 60 days, E. coli O157:H7 counts in cheeses manufactured without bacteriocin-producing LAB and not pressurized were 5.1 log CFU/g. A higher inactivation of E. coli O157:H7 was achieved in cheeses without bacteriocin-producing LAB when 300 MPa was applied on day 50 (3.8-log-unit reduction) than if applied on day 2 (1.3-log-unit reduction). Application of 500 MPa eliminated E. coli O157:H7 in 60-day-old cheeses. Cheeses made with bacteriocin-producing LAB and not pressurized showed a slight reduction of the pathogen. Pressurization at 300 MPa on day 2 and addition of lacticin 481-, nisin A-, bacteriocin TAB 57-, or enterocin AS-48-producing LAB were synergistic and reduced E. coli O157:H7 counts to levels below 2 log units in 60-day-old cheeses. Pressurization at 300 MPa on day 50 and addition of nisin A-, bacteriocin TAB 57-, enterocin I-, or enterocin AS-48-producing LAB completely inactivated E. coli O157:H7 in 60-day-old cheeses. The application of reduced pressures combined with bacteriocin-producing LAB is a feasible procedure to improve cheese safety.     

Comparison of enzyme-linked immunomagnetic chemiluminescence with U.S. Food and Drug Administration's Bacteriological Analytical Manual method for the detection of Escherichia coli O157:H7

Escherichia coli O157:H7, a major foodborne pathogen, has been associated with numerous cases of foodborne illnesses. Rapid methods have been developed for the screening of this pathogen in foods in order to circumvent timely plate culture techniques. Unfortunately, many rapid methods are presumptive and do not claim to confirm the presence of E. coli O157:H7. The previously developed method, enzyme-linked immunomagnetic chemiluminescence (ELIMCL), has been improved upon to allow for fewer incidences of false positives when used to detect E. coli O157:H7 in the presence of mixed cultures. The key feature of this assay is that it combines the highly selective synergism of both anti-O157 and anti-H7 antibodies in the sandwich immunoassay format. This work presents application of a newly semi-automated version of ELIMCL to the detection of E. coli O157:H7 in pristine buffered saline yielding detection limits of approximately 1 x 10(5) to 1 x 10(6) of live cells/mL. ELIMCL was further demonstrated to detect E. coli O157:H7 inoculated into artificially contaminated ground beef at ca. 400 CFU/g after a 5 h enrichment and about 1.5 h assay time for a total detection time of about 6.5 h. Finally, ELIMCL was compared with USFDA's Bacteriological Analytical Manual method for E. coli O157:H7 in a double-blind study. Using McNemar's treatment, the two methods were determined to be statistically similar for the detection of E. coli O157:H7 in ground beef inoculated with mixed cultures of select bacteria.     

Persistence and metabolic activity of Escherichia coli O157:H7 in farm animal faeces

Ruminants, and to a lesser extent monogastric farm animals, are known to be natural reservoirs of Escherichia coli O157:H7, and contact with contaminated faeces has been linked to human infection. This study used a nontoxigenic, chromosomally marked, lux reporter strain to compare the persistence and activity (bioluminescence) of E. coli O157:H7 over 21 days in the faecal liquor of five farm animals: horse, sheep, cow, pig and piglet. Samples were inoculated with the lux E. coli O157:H7 (7.82 log CFU mL(-1)) and stored at 20 +/- 1 degrees C. The organism was recovered from all samples throughout the experimental period, although lower numbers were recovered from horse faecal liquor relative to all other types (P<0.001). The organisms' activity declined in all samples over time and no luminescence could be detected in any sample 21 days postinoculation. However, activity did increase greatly within pig and piglet faeces during initial stages of monitoring and overall luminescence was greater in piglet samples compared with all other samples (P<0.001). This is the first study to demonstrate how both the persistence and metabolic activity of E. coli O157:H7 notably varies within a range of ruminant and nonruminant animal faeces. Further research is needed to elucidate the factors that govern differential persistence and metabolic activity of E. coli O157:H7 within such matrices.