Enzymatic Removal of Diacetyl from Beer: II. Further Studies on the Use of Diacetyl Reductase1

Diacetyl removal from beer was studied with whole cells and crude enzyme extracts of yeasts and bacteria. Cells of Streptococcus diacetilactis 18-16 destroyed diacetyl in solutions at a rate almost equal to that achieved by the addition of whole yeast cells. Yeast cells impregnated in a diatomaceous earth filter bed removed all diacetyl from solutions percolated through the bed. Undialyzed crude enzyme extracts from yeast cells removed diacetyl very slowly from beer at its normal pH (4.1); at a pH of 5.0 or higher, rapid diacetyl removal was achieved. Dialyzed crude enzyme extracts from yeast cells were found to destroy diacetyl in a manner quite similar to that of diacetyl reductase from Aerobacter aerogenes, and both the bacterial and the yeast extracts were stimulated significantly by the addition of reduced nicotinamide adenine dinucleotide (NADH). Diacetyl reductase activity of four strains of A. aerogenes was compared; three of the strains produced enzyme with approximately twice the specific activity of the other strain (8724). Gel electrophoresis results indicated that at least three different NADH-oxidizing enzymes were present in crude extracts of diacetyl reductase. Sephadex-gel chromotography separated NADH oxidase from diacetyl reductase. It was also noted that ethyl alcohol concentrations approximately equivalent to those found in beer were quite inhibitory to diacetyl reductase.     

Acetoin Fermentation by Citrate-Positive Lactococcus lactis subsp. lactis 3022 Grown Aerobically in the Presence of Hemin or Cu

CitrLactococcus lactis subsp. lactis 3022 produced more biomass and converted most of the glucose substrate to diacetyl and acetoin when grown aerobically with hemin and Cu. The activity of diacetyl synthase was greatly stimulated by the addition of hemin or Cu, and the activity of NAD-dependent diacetyl reductase was very high. Hemin did not affect the activities of NADH oxidase and lactate dehydrogenase. These results indicated that the pyruvate formed via glycolysis would be rapidly converted to diacetyl and that the diacetyl would then be converted to acetoin by the NAD-dependent diacetyl reductase to reoxidize NADH when the cells were grown aerobically with hemin or Cu. On the other hand, the Y(Glu) value for the hemincontaining culture was lower than for the culture without hemin, because acetate production was repressed when an excess of glucose was present. However, in the presence of lipoic acid, an essential cofactor of the dihydrolipoamide acetyltransferase part of the pyruvate dehydrogenase complex, hemin or Cu enhanced acetate production and then repressed diacetyl and acetoin production. The activity of diacetyl synthase was lowered by the addition of lipoic acid. These results indicate that hemin or Cu stimulates acetyl coenzyme A (acetyl-CoA) formation from pyruvate and that lipoic acid inhibits the condensation of acetyl-CoA with hydroxyethylthiamine PP(i). In addition, it appears that acetyl-CoA not used for diacetyl synthesis is converted to acetate.     

Influence of temperature on flavour compound production from citrate by Lactobacillus rhamnosus ATCC 7469

The citrate utilization by Lactobacillus rhamnosus ATCC 7469 was found to be temperature-dependent. The maximum citrate utilization and incorporation of [1,5-14C]citrate rate were observed at 37 degreesC. At this temperature, maximum citrate lyase activity and specific diacetyl and acetoin production (Y(DA%)) were observed. The high levels of alpha-acetolactate synthase and low levels of diacetyl reductase, acetoin reductase and L-lactate dehydrogenase found at 37 degreesC led to an accumulation of diacetyl and acetoin. Optimum lactic acid production was observed at 45 degreesC, according to the high lactate dehydrogenase activity. The NADH oxidase activity increased with increasing culture temperature from 22 degreesC to 37 degreesC. Thus there are greater quantities of pyruvate available for the production of alpha-acetolactate, diacetyl and aceotin, and less diacetyl and acetoin are reduced.     

Purification and Properties of a Diacetyl Reductase from Escherichia coli

A reduced nicotinamide adenine dinucleotide phosphate (NADPH)-dependent reductase with the ability to reduce diacetyl has been isolated from Escherichia coli and has been purified 800-fold to near homogeneity. The product of the reduction of diacetyl was shown to be acetoin. The enzyme proved to catalyze the oxidation of NADPH in the presence of both uncharged α- and β-dicarbonyl compounds. Even monocarbonyl compounds showed slight activity with the enzyme. On the basis of its substrate specificity, it is suggested that the enzyme functions as a diacetyl reductase. In contrast to other diacetyl reductases, the one reported here is specific for NADPH and does not possess acetoin reductase activity. The pH optimum of this enzyme was found to be between 6 and 7. The maximal velocity for the NADPH-dependent reduction of diacetyl was determined to be 9.5 μmol per min per mg of protein and the K_m values for diacetyl and NADPH were found to be 4.44 mM and 0.02 mM, respectively. The molecular weight was estimated by gel filtration on Sephadex G-100 to be approximately 10,000.     

Purification and characterization of diacetyl-reducing enzymes from Staphylococcus aureus.

A method was developed to purify diacetyl-reducing enzymes from Staphylococcus aureus. Two enzymes capable of catalysing diacetyl reduction were isolated, neither of which turned out to be a specific diacetyl reductase. One of them is a lactate dehydrogenase similar to the one from Staphylococcus epidermidis, which accepts diacetyl, although poorly. The other one uses as coenzyme beta-NAD and reduces uncharged alpha-dicarbonyls with more than three carbon atoms (especially the alpha-diketones diacetyl and pentane-2,3-dione), producing the L(+) form of the corresponding alpha-hydroxycarbonyls. This enzyme has an Mr of 68,000 and is, most probably, a monomer. Its optimum pH is 6.0. Its shows a high affinity for NADH and a rather low one for diacetyl, which, at least in vitro, does not seem to be as good a substrate as pentane-2,3-dione. We propose for it the systematic name L-alpha-hydroxyketone:NAD+ oxidoreductase and the recommended name of alpha-diketone reductase (NAD). We also suggest that the diacetyl reductase entry in the I.U.B. classification be suppressed.     

Molecular cloning, expression and tissue distribution of hamster diacetyl reductase. Identity with L-xylulose reductase

Using rapid amplification of cDNA ends PCR, a cDNA species for diacetyl reductase (EC 1.1.1.5) was isolated from hamster liver. The encoded protein consisted of 244 amino acids, and showed high sequence identity to mouse lung carbonyl reductase and hamster sperm P26h protein, which belong to the short-chain dehydrogenase/reductase family. The enzyme efficiently reduced L-xylulose as well as diacetyl, and slowly oxidized xylitol. The K(m) values for L-xylulose and xylitol were similar to those reported for L-xylulose reductase (EC 1.1.1.10) of guinea pig liver. The identity of diacetyl reductase with L-xylulose reductase was demonstrated by co-purification of the two enzyme activities from hamster liver and their proportional distribution in other tissues.     

Acetoin Fermentation by Citrate-Positive Lactococcus lactis subsp. lactis 3022 Grown Aerobically in the Presence of Hemin or Cu2+

Citr⁺Lactococcus lactis subsp. lactis 3022 produced more biomass and converted most of the glucose substrate to diacetyl and acetoin when grown aerobically with hemin and Cu²⁺. The activity of diacetyl synthase was greatly stimulated by the addition of hemin or Cu²⁺, and the activity of NAD-dependent diacetyl reductase was very high. Hemin did not affect the activities of NADH oxidase and lactate dehydrogenase. These results indicated that the pyruvate formed via glycolysis would be rapidly converted to diacetyl and that the diacetyl would then be converted to acetoin by the NAD-dependent diacetyl reductase to reoxidize NADH when the cells were grown aerobically with hemin or Cu²⁺. On the other hand, the Y_Glu value for the hemincontaining culture was lower than for the culture without hemin, because acetate production was repressed when an excess of glucose was present. However, in the presence of lipoic acid, an essential cofactor of the dihydrolipoamide acetyltransferase part of the pyruvate dehydrogenase complex, hemin or Cu²⁺ enhanced acetate production and then repressed diacetyl and acetoin production. The activity of diacetyl synthase was lowered by the addition of lipoic acid. These results indicate that hemin or Cu²⁺ stimulates acetyl coenzyme A (acetyl-CoA) formation from pyruvate and that lipoic acid inhibits the condensation of acetyl-CoA with hydroxyethylthiamine PP_i. In addition, it appears that acetyl-CoA not used for diacetyl synthesis is converted to acetate.     

Molecular cloning,expression and tissue distribution of hamster diacetyl reductase. Identity with l-xylulose reductase

Using rapid amplification of cDNA ends PCR, a cDNA species for diacetyl reductase (EC 1.1.1.5) was isolated from hamster liver. The encoded protein consisted of 244 amino acids, and showed high sequence identity to mouse lung carbonyl reductase and hamster sperm P26h protein, which belong to the short-chain dehydrogenase/reductase family. The enzyme efficiently reduced l-xylulose as well as diacetyl, and slowly oxidized xylitol. The K_m values for l-xylulose and xylitol were similar to those reported for l-xylulose reductase (EC 1.1.1.10) of guinea pig liver. The identity of diacetyl reductase with l-xylulose reductase was demonstrated by co-purification of the two enzyme activities from hamster liver and their proportional distribution in other tissues.     

Properties of 2,3-Butanediol Dehydrogenases from Lactococcus lactis subsp. lactis in Relation to Citrate Fermentation

Two 2,3-butanediol dehydrogenases (enzymes 1 and 2; molecular weight of each, 170,000) have been partially purified from Lactococcus lactis subsp. lactis (Streptococcus diacetylactis) D10 and shown to have reductase activity with either diacetyl or acetoin as the substrate. However, the reductase activity with 10 mM diacetyl was far greater for both enzymes (7.0- and 4.7-fold for enzymes 1 and 2, respectively) than with 10 mM acetoin as the substrate. In contrast, when acetoin and diacetyl were present together, acetoin was the preferred substrate for both enzymes, with enzyme 1 showing the more marked preference for acetoin. meso-2,3-Butanediol was the only isomeric product, with enzyme 1 independent of the substrate combinations. For enzyme 2, both the meso and optical isomers of 2,3-butanediol were formed with acetoin as the substrate, but only the optical isomers were produced with diacetyl as the substrate. With batch cultures of strain D10 at or near the point of citrate exhaustion, the main isomers of 2,3-butanediol present were the optical forms. If the pH was sufficiently high (>pH 5), acetoin reduction occurred over time and was followed by diacetyl reduction, and meso-2,3-butanediol became the predominant isomer. Interconversion of the optical isomers into the meso isomer did occur. The properties of 2,3-butanediol dehydrogenases are consistent with diacetyl and acetoin removal and the appearance of the isomers of 2,3-butanediol.     

Enzymatic Removal of Diacetyl from Beer : III. Enzyme Protection and Regeneration of Cofactor

Use of diacetyl reductase, a reduced nicotinamide adenine dinucleotide (NADH)-requiring enzyme, to eliminate diacetyl off-flavor in beer was studied. The crude enzyme was extracted from Aerobacter aerogenes and partially purified by ammonium sulfate precipitation or Sephadex chromatography. In the semipure state, the enzyme was inactivated by lyophilization; in a crude state, the lyophilized extract remained stable for at least 4 months at - 20 C. A 50% reduction in specific activity within 5 min was observed when crude diacetyl reductase was suspended (5 mg of protein/ml) in phosphate buffer at pH 5.5 or below; a similar inactivation rate was observed when the crude enzyme was dissolved in a 5% aqueous ethyl alcohol solution. Effective crude enzyme activity in beer at a natural pH of 4.1 required protection of the enzyme in 10% gelatin. Incorporation of yeast cells with the gel-protected enzyme provided regeneration of NADH. Combinations of yeast, enzyme, and gelatin were tested to obtain data analyzed by regression analysis to determine the optimal concentration of each component of the system required to reduce the level of diacetyl in spiked (0.5 ppm) beer to less than 0.12 ppm within 48 hr at 5 C. The protected enzyme system was also effective in removing diacetyl from orange juice (pH 3.8) and some distilled liquors.     

Characterization of a citrate-negative mutant ofLeuconostoc mesenteroides subsp.mesenteroides: metabolic and plasmidic properties

Summary Comparison of the parental strain of the Leuconostoc mesenteroides subsp. mesenteroides (19D) and its citrate-negative mutant, which has lost a 22-kb plasmid, has confirmed the energetic role of citrate. Fermentation balance analysis showed that citrate led to a change in heterolactic fermentation from glucose. High levels of enzyme activity in both mutant and parental strains were found for NADH oxidase, lactate dehydrogenase, acetate kinase, alcohol dehydrogenase, diacetyl reductase and acetoin reductase, although NADH oxidase, alcohol dehydrogenase, diacetyl reductase and acetoin reductase were partly repressed by citrate. All these enzymes studied were not plasmid linked. In the parental strain, citrate lyase was induced by citrate. No citrate lyase activity was found in the citrate-negative mutant grown in presence of citrate, but this does not provide evidence that citrate lyase is linked to the 22-kb plasmid. Offprint requests to: C. Diviès     

Differences between Lactobacillus casei subsp. casei 2206 and Citrate-Positive Lactococcus lactis subsp. lactis 3022 in the Characteristics of Diacetyl Production

Lactobacillus casei subsp. casei 2206 exhibited much lower levels of diacetyl reductase activity than Citr⁺Lactococcus lactis subsp. lactis 3022 but two-, three-, and more than eightfold-higher levels of diacetyl synthase, lactate dehydrogenase, and NADH oxidase activities, respectively. A requirement for metal ions by the diacetyl synthases in both species was observed. The extracts of strain 2206 but not strain 3022 produced more diacetyl from pyruvate when the reaction for diacetyl synthase was aerated than when it was conducted statically.     

Plasmid-encoded diacetyl (acetoin) reductase in Leuconostoc pseudomesenteroides

A plasmid-borne diacetyl (acetoin) reductase (butA) from Leuconostoc pseudomesenteroides CHCC2114 was sequenced and cloned. Nucleotide sequence analysis revealed an open reading frame encoding a protein of 257 amino acids which had high identity at the amino acid level to diacetyl (acetoin) reductases reported previously. Downstream of the butA gene of L. pseudomesenteroides, but coding in the opposite orientation, a putative DNA recombinase was identified. A two-step PCR approach was used to construct FPR02, a butA mutant of the wild-type strain, CHCC2114. FPR02 had significantly reduced diacetyl (acetoin) reductase activity with NADH as coenzyme, but not with NADPH as coenzyme, suggesting the presence of another diacetyl (acetoin)-reducing activity in L. pseudomesenteroides. Plasmid-curing experiments demonstrated that the butA gene is carried on a 20-kb plasmid in L. pseudomesenteroides.     

Removal of diacetyl from beer by adsorbants and diacetyl reductase

Removal of diacetyl from beer with adsorbants like cellulose, silica gel, activated charcoal, calcium phosphate gel, anion- and cation-exchange resins, and silicylic acid black soil bed (SABSB) was attempted in comparison with the enzyme diacetyl reductase (EC 1.1.1.5). Diacetyl could be removed from beer by the adsorbants but they had undesirable effect on the beer quality such as color, pH, and alcohol levels. These adverse effects were not observed with the use of diacetyl reductase. The results favor the enzymatic removal of diacetyl from beer as a superior approach.     

Incorporation of Radioactive Acetate into Diacetyl by Streptococcus diacetilactis

Streptococcus diacetilactis was grown in a partially defined, lipoic acid-free medium containing radioactive acetate with and without addition of 0.1% unlabeled sodium pyruvate. Labeled carbon was incorporated into diacetyl, but neither the amount of diacetyl produced nor its specific activity was influenced by addition of pyruvate. Acetoin had low specific activity, indicating that it was a mixture of radioactive and nonradioactive acetoin. The specific activity of acetoin was lower when pyruvate, a precursor of unlabeled acetoin, was added to the medium, which indicated that the radioactive acetoin was produced from radioactive diacetyl by diacetyl reductase. Results substantiate condensation of acetyl-coenzyme A with hydroxyethylthiamine pyrophosphate as the in vivo mechanism for synthesis of diacetyl.     

Identification and characterization of a mycobacterial NAD+-dependent alcohol dehydrogenase with superior reduction of diacetyl to (S)-acetoin

An enzyme capable of reducing acetoin in the presence of NADH was purified from Mycobacterium sp. B-009, a non-clinical bacterial strain of soil origin. The enzyme is a homotetramer and can be classified as a medium-chain alcohol dehydrogenase/reductase based on the molecular weight of the monomer. Identification of the structural gene revealed a limited distribution of homologous genes only among actinomycetes. In addition to its activity as a reductase specific for (S)-acetoin (EC 1.1.1.76), the enzyme showed both diacetyl reductase (EC 1.1.1.304) and NAD⁺-dependent alcohol dehydrogenase (EC 1.1.1.1) activities. (S)-Acetoin and diacetyl reductases belong to a group of short-chain alcohol dehydrogenase/reductases but do not have superior abilities to dehydrogenate monoalcohols. Thus, the purified enzyme can be readily distinguished from other enzymes. We used the dual functionality of the enzyme to effectively reduce diacetyl to (S)-acetoin, coupled with the oxidation of 1-butanol.     

Kinetic and structural properties of diacetyl reductase from hamster liver

Kinetic and physicochemical properties of hamster liver diacetyl reductase have been examined. The results of kinetic studies on the reduction of diacetyl and NADPH to acetoin and NADP+ suggest that the reaction follows an Ordered Bi Bi mechanism in which NADPH binds first before diacetyl. The enzyme is a tetrameric glycoprotein of single subunits of a molecular weight of 23,500 with a sedimentation coefficient of 6.0S. The enzyme does not contain Zn, Cu, or Fe. The amino acid composition revealed an unusually low proportion of proline residues (0.9%). p-Chloromercuriphenylsulfonate and phenylglyoxal inactivated the enzyme, but the presence of NADPH prevented the loss of activity due to thiol and arginine modification. The enzyme transferred the pro 4S hydrogen atom of NADPH to the substrate and the binding of the enzyme to NADPH resulted in a red shift of the ultraviolet absorption spectrum of the cofactor.     

Plasmid-Encoded Diacetyl (Acetoin) Reductase in Leuconostoc pseudomesenteroides

A plasmid-borne diacetyl (acetoin) reductase (butA) from Leuconostoc pseudomesenteroides CHCC2114 was sequenced and cloned. Nucleotide sequence analysis revealed an open reading frame encoding a protein of 257 amino acids which had high identity at the amino acid level to diacetyl (acetoin) reductases reported previously. Downstream of the butA gene of L. pseudomesenteroides, but coding in the opposite orientation, a putative DNA recombinase was identified. A two-step PCR approach was used to construct FPR02, a butA mutant of the wild-type strain, CHCC2114. FPR02 had significantly reduced diacetyl (acetoin) reductase activity with NADH as coenzyme, but not with NADPH as coenzyme, suggesting the presence of another diacetyl (acetoin)-reducing activity in L. pseudomesenteroides. Plasmid-curing experiments demonstrated that the butA gene is carried on a 20-kb plasmid in L. pseudomesenteroides.     

Citrate permease gene expression in Lactococcus lactis subsp. lactis strains IL1403 and MG1363

Abstract Citrate permease gene expression in the plasmid-free Lactococcus lactis strains IL1403 and MG1363 was studied. The ability to transport citrate results in diacetyl and acetoin production in IL1403 but not in MG1363. Citrate lyase, α-acetolactate decarboxylase, diacetyl and acetoin reductase were detected in IL1403. These data show that L. lactis ssp. lactis strain IL1403 is a citrate permease mutant of the biovar. diacetylactis . Immunological analysis revealed the α-and β-subunits of citrate lyase not only in IL1403 but also in MG1363 where no citrate lyase activity was found.     

Purification and properties of two multiple forms of dihydrodiol dehydrogenase from guinea-pig testis

NADP+-dependent dihydrodiol dehydrogenase (trans-1,2-dihydrobenzene-1,2-diol: NADP+ oxidoreductase, EC 1.3.1.20) activity in the cytosol of guinea-pig testis was separated into two major and two minor peaks by Q-Sepharose chromatography; one minor form was immunologically cross-reacted with hepatic aldehyde reductase. The two major enzyme forms were purified to homogeneity. One form, which had the highest amount in the tissue, was a monomeric protein with a molecular weight of 32,000 and isoelectric point of 4.2, showed strict specificity for benzene dihydrodiol and NADP+, and reduced pyridine aldehydes, glyceraldehyde and diacetyl at low rates. Another form, with a molecular weight of 36,000 and isoelectric point of 5.0, oxidized n-butanol, glycerol and sorbitol as well as benzene dihydrodiol in the presence of NADP+ or NAD+, and exhibited much higher reductase activity towards various aldehydes, aldoses and diacetyl. The pI 5.0 form was more sensitive to inhibition by sorbinil and p-chloromercuriphenyl sulfonate than the pI 4.2 form and was activated by sulfate ion. The two enzymes did not catalyze the oxidation of hydroxysteroids and xenobiotic alicyclic alcohols and were immunologically different from hepatic 17 beta-hydroxysteroid-dihydrodiol dehydrogenase. The results indicate that guinea-pig testis contains at least two dihydrodiol dehydrogenases distinct from the hepatic enzymes, one of which, the pI 5.0 enzyme form, may be identical to aldose reductase.