Effects of different nitrogen sources on the biogas production - a lab-scale investigation

For anaerobic digestion processes nitrogen sources are poorly investigated although they are known as possible process limiting factors (in the hydrolysis phase) but also as a source for fermentations for subsequent methane production by methanogenic archaea. In the present study different complex and defined nitrogen sources were investigated in a lab-scale experiment in order to study their potential to build up methane. The outcome of the study can be summarised as follows: from complex nitrogen sources yeast extract and casamino acids showed the highest methane production with approximately 600ml methane per mole of nitrogen, whereas by the use of skim milk no methane production could be observed. From defined nitrogen sources l-arginine showed the highest methane production with almost 1400ml methane per mole of nitrogen. Moreover it could be demonstrated that the carbon content and therefore C/N-ratio has only minor influence for the methane production from the used substrates.     

Lovastatin Biosynthesis by Aspergillus terreus in a Chemically Defined Medium

Lovastatin is a secondary metabolite produced by Aspergillus terreus. A chemically defined medium was developed in order to investigate the influence of carbon and nitrogen sources on lovastatin biosynthesis. Among several organic and inorganic defined nitrogen sources metabolized by A. terreus, glutamate and histidine gave the highest lovastatin biosynthesis level. For cultures on glucose and glutamate, lovastatin synthesis initiated when glucose consumption levelled off. When A. terreus was grown on lactose, lovastatin production initiated in the presence of residual lactose. Experimental results showed that carbon source starvation is required in addition to relief of glucose repression, while glutamate did not repress biosynthesis. A threefold-higher specific productivity was found with the defined medium on glucose and glutamate, compared to growth on complex medium with glucose, peptonized milk, and yeast extract.     

Variations of alcohol dehydrogenase activity and fermentative pyruvate,ethanol production of F. equiseti and F. acuminatum depend on the yeast extract and urea concentrations

In this study, pyruvate production of Fusarium equiseti was significantly increased when the yeast extract concentration was raised from 5 to 25 g/L while it was increased to only up to 10 g/L yeast extract in F. acuminatum. Upon supplementation with urea as an alternative nitrogen source, production of pyruvate for both of the Fusarium species were decreased with respect to increase in urea concentration in medium. On the other hand, ethanol production and alcohol dehydrogenase activity of F. equiseti were decreased approximately 1.9- and 1.6-fold with an increase in yeast concentration from 5 to 25 whereas the levels of F. acuminatum were increased 2.3- and 1.8-fold, respectively. In addition, ethanol productions and ADH activities in F. equiseti and F. acuminatum significantly increased on the 12th day up to 15 and 25 g/L urea concentrations, respectively. However, they were significantly decreased under these conditions at higher nitrogen sources. In addition, ethanol production and alcohol dehydrogenase activity in urea supplemented medium were higher than yeast extract supplemented. The results may suggest that the pyruvate, ethanol production and ADH enzyme activity variations and balance between aerobic and anaerobic respiration in F. equiseti and F. acuminatum were effected from yeast extract and urea concentrations in the nutrient medium.     

Production of β-galactosidase fromkluyveromyces fragilis grown on whey

Optimum conditions for β-galactosidase production byK. fragilis were studied. Enzyme production has a maximum after 8 –12 h of incubation. Composition of whey (from different sources) did not affect enzyme production. Different heat treatments also had no effect. Whey reconstituted to 8 –12 % total solids and adjusted to pH 4.0 afforded maximum enzyme production. Whereas inorganic nitrogen sources (specially ammonium salts) only slightly stimulated enzyme production, organic nitrogen sources (specially partially digested proteins) provided a nearly four-fold increase in enzyme production. Yeast extract and beef extract and industrial by-products like corn-steep liquor significantly stimulated enzyme production. Manganese and magnesium salts had a very little stimulation effect.     

The production of toxic protease by the entomopathogenous fungus Metarhizium anisopliae in submerged culture

The production of a toxic complex of proteolytic enzymes by Metarhizium anisopliae was evaluated with 29 nitrogen sources in modified Czapek-Dox medium in submerged cultures. The proteolytic complex is more constitutive than that of Beauveria bassiana and its production is influenced by the quality of complex natural media. The highest activity was attained with Galleria mellonella proteins. The proteolytic complex manifests proteolytic activity of two pH optima, 5.5 and 8.0. The ratio of these two activities differs markedly with the nitrogen source used, but the major proteolytic activity occurs at pH 5.5.     

Influence of culture conditions on lipase production byBacillus sp. FH5

Lipases are a class of enzymes, which catalyse the hydrolysis of long chain triglycerides. Microbial lipases are currently receiving much attention with the rapid development of enzyme technology. Lipases have industrial potential in the chemical, pharmaceutical, medical, cosmetic, leather and paper manufacturing industries, biosurfactant synthesis, and agrochemicals. ABacillus strain isolated from soil was tested for the production of extracellular lipase, by batch culturing in shake flask. The growth conditions were optimised for the maximum production of enzyme. Various parameters for the production of lipase, such as temperature, incubation period, pH, carbon source, nitrogen source and lipids were studied. Maximum lipase production was found in 48-h-old culture filtrate at 37 °C, pH 8.0. Among all the carbon sources, salicin gave the maximum activity and among all the nitrogen sources yeast extract gave maximum production/activity. Tween (20 and 80) does not stimulate the growth much but assisted in enzyme production.     

戊糖乳杆菌发酵培养基氮源条件的优化

对戊糖乳杆菌发酵培养基的氮源条件进行了优化。通过单因素实验及响应面分析优化利用木糖高产乳酸的戊糖乳杆菌发酵培养基的不同氮源组合。优化得到的牛肉膏与柠檬酸氢二铵复合的最佳组成为牛肉膏17.72 g/L,柠檬酸氢二铵1.91 g/L,得到乳酸实际最大产量42.37 g/L。添加玉米浆与酵母粉和无机氮源复合的最佳组成为玉米浆46.54 g/L,酵母粉21.95 g/L,柠檬酸氢二铵9.95 g/L,可得到乳酸最大产量41.06 g/L。通过响应面优化减少了有机氮源的种类。牛肉膏与柠檬酸氢二铵的复合得到了更高的乳酸产量,且减少了有机氮源用量,节约了成本。玉米浆与酵母粉的复合解决了单一玉米浆造成的木糖利用速率过低的问题,同样得到较高浓度的乳酸。     

Solid state production of polygalacturonase and xylanase by Trichoderma species using cantaloupe and watermelon rinds

Different solid state fermentation (SSF) sources were tested such as cantaloupe and watermelon rinds, orange and banana peels, for the production of polygalacturonase (PG) and xylanase (Xyl) by Trichoderma harzianum and Trichoderma virens. The maximum production of both PG and Xyl were obtained by T. harzianum and T. virnes grown on cantaloupe and watermelon rinds, respectively. Time course, moisture content, temperature, pH, supplementation with carbon and nitrogen sources were optimized to achieve the maximum production of both PG and Xyl of T. harzianum and T. virens using cantaloupe and watermelon rinds, respectively. The maximum production of PG and Xyl of T. harzianum and T. virens was recorded at 4–5 days of incubation, 50–66% moisture, temperature 28–35°C and pH 6–7. The influence of supplementary carbon and nitrogen sources was studied. For T. harzianum, lactose enhanced PG activity from 87 to 120 units/g solid, where starch and maltose enhanced Xyl activity from 40 to 55–60 units/g solid for T. virnes. Among the nitrogen sources, ammonium sulphate, ammonium nitrate, yeast extract and urea increased PG activity from 90 to 110–113 units/g solid for T. harzianum. Similarly, ammonium chloride, ammonium sulphate and yeast extract increased Xyl activity from 45 to 55–70 units/g solid for T. virens.     

Effects of carbon and nitrogen sources on the induction and repression of chitinase enzyme from<Emphasis Type="Italic">Metarhizium anisopliae</Emphasis> isolates

Metarhizium anisopliae, an entomopathogenic hyphomycete, is being used effectively in Integrated Pest Management (IPM) system. Foliar application of these fungi is quite satisfactory as it invades its host by adhering to insect cuticles and formation of penetration structures called appresoria, which produces various extracellular enzymes, including chitinase that causes the insect cuticle breaching. The induction and repression mechanism of chitinase activity is not entirely understood and activity of this enzyme is different in response to different carbon and nitrogen sources. This report illustrates the effect of two carbon sources viz. colloidal chitin and dextrose and a nitrogen source, yeast extract on the chitinase production of fourteenM. Anisopliae isolates. The chitinase activity varied among the isolates and the different media used. A high enzymatic activity was observed in the medium containing an extra nitrogen source (yeast extract) followed by the medium containing colloidal chitin as a sole source of carbon and nitrogen. The exochitinase activity and the chitinase activity gel were also studied for the isolates showing high chitinase enzyme production. An array of chitinase isozymes were observed on chitinase activity gel with a common 14.3 kDa enzyme for all the isolates.     

Effect of nutritional conditions on extracellular protease production by the haloalkaliphilic archaeon Natrialba magadii

AIMS: The effect of various nitrogen sources and nutritional starvation was examined on the production of an extracellular protease secreted by the haloalkaliphilic archaeon Natrialba magadii. METHODS AND RESULTS: Cell growth and proteolytic activity were measured in cells grown with different nitrogen sources. Proteolytic activity was produced in complex and easily metabolized nitrogen sources such as yeast extract, casein and casamino acids; meanwhile, ammonium repressed enzyme production. The time course and amount of protease accumulated showed an inverse correlation with growth rate and nutrient concentration. Starvation did not induce extracellular protease production. CONCLUSION: The accumulation of Nab. magadii extracellular protease is stimulated by nutrient limitation and slow growth rate indicating that it is probably induced in response to a deficit in the energetic status of the cells. Nutritional starvation did not induce protease accumulation suggesting that de novo synthesis of this protease and/or factor/s necessary for its activation are required. This enzyme may be regulated by nitrogen catabolite repression and it does not require protein substrates for induction. SIGNIFICANCE AND IMPACT OF THE STUDY: These results contribute to the basic knowledge on protease regulation in haloalkaliphilic archaea and will help to optimize the production of this extremozyme for biotechnological applications such as protease-catalysed peptide synthesis.     

The effect of supplementation by different nitrogen sources on the production of lactic acid from date juice by Lactobacillus casei subsp. rhamnosus

Production of lactic acid from date juice by fermentation has been studied using Lactobacillus casei subsp. rhamnosus as the producer organism. The optimum substrate concentration, expressed in its glucose content, was 60 g l(-1). Various nitrogen sources were compared with yeast extract in terms of their efficiency for lactic acid production. None of these nitrogen sources gave lactic acid concentrations as high as that obtained with yeast extract. As yeast extract supplementation was not economically attractive, different proportions of (NH4)2SO4 and yeast extract were used. When the elemental nitrogen ratio of(NH4)2SO4 to yeast extract was 4:1, the substrate use and efficiency of lactic acid production were the same as in date juice supplemented with 20 g l(-1) yeast extract (0:5).     

Influence of Environmental Factors on Bacteriocin Production by Human Isolates of <Emphasis Type="Italic">Lactococcus lactis</Emphasis> MM19 and <Emphasis Type="Italic">Pediococcus acidilactici</Emphasis> MM33

The influence of temperature, initial pH, and carbon and nitrogen sources on bacteriocin secreted by Lactococcus lactis MM19 (MM19) and Pediococcus acidilactici MM33 (MM33) was evaluated. It was found that 30 and 45 °C were the growth temperatures for higher nisin and pediocin production by MM19 and MM33, respectively. The initial pH values for higher production of nisin and pediocin were 9 and 6, respectively. Glucose and wheat peptone E430 were found as suitable carbon and nitrogen sources, respectively, for highest nisin production by MM19 at 30 °C and initial pH of 9. In these conditions, nisin production could be increased by 6.7 times as compared to the control medium (de Man, Rogosa, and Sharpe—MRS broth). Similarly, fructose and pea peptone were suitable carbon and nitrogen sources, respectively, for highest production of pediocin by MM33 at 45 °C and initial pH of 6. In these conditions, pediocin production by MM33 was increased by three times as compared to the control medium (tryptone-glucose-yeast extract—TGE broth).     

Antifungal activity of crude extract produced by Bacillus sp. associated with entomopathogenic nematode from media formulated by six nitrogen sources with fructose against Penicillium expansum

A specific symbiotic Bacillus species isolated from a rhabditid entomopathogenic nematode, Rhabditis (Oscheius) sp. was found to produce a number of bioactive compounds. The present study was conducted to determine the effect of six different nitrogen sources in combination with fructose on the production of antifungal crude extract by Bacillus sp. against Penicillium expansum. The yield of crude extract and antifungal activity against the test fungi differed significantly when the nitrogen sources in the fermentation media were changed. The highest yield was recorded for beef extract plus fructose (921?mg/L). The antifungal activity was higher in yeast extract plus fructose [P. expansum (46.5?±?2.12?mm)], followed by beef extract. High performance liquid chromatography analysis of the crude antimicrobial substances revealed different peaks with different retention times indicating that they produced different compounds. When a carbon source was not included in the fermentation medium, the antimicrobial production was substantially reduced almost eight times. Carbon source in the fermentation medium plays a vital role in the production of antimicrobial substances. Yeast extract and fructose as nitrogen and carbon sources in the fermentation medium produced maximum antimicrobial activity.     

Joint effect of nitrogen sources and B vitamin supplementation of date juice on lactic acid production by Lactobacillus casei subsp. rhamnosus

The use of date juice as a substrate for lactic acid production was investigated. Various nitrogen sources were compared with yeast extract for efficient lactic acid production by Lactobacillus casei subsp. rhamnosus. Among different nitrogen sources added to date juice (yeast extract, ammonium sulfate, tryptic soy, urea, peptone, and casein hydrolysate), yeast extract was the most efficient. The effect of yeast extract could have been due to its B vitamin content. The addition of five B vitamins at less than 25 mg/l to date juice with any nitrogen source enhanced lactic acid production to some extent, except for date juice with yeast extract or urea or peptone. The most significant increase was obtained with ammonium sulfate. Half of the yeast extract content (10 g/l) in a supplemented date juice could be replaced by a mixture of B vitamins at less than 25 mg/l, and ammonium sulfate at 2.6 g/l with no significant decrease in lactic acid production.     

Screening and selection of media components for lactic acid production using Plackett–Burman design

Plackett–Burman design was used to efficiently select important media components influencing lactic acid production in a two step screening procedure. A total of 36 screening experiments were conducted for studying the effect of various media components such as carbon and nitrogen (simple and complex) sources, minerals/buffering agents and a specific inducer for the production of lactic acid by Lactobacillus plantarum NCIM 2084. The eleven ingredients chosen after the first screening experiments were further screened by a Plackett-Burman design consisting of 12 experiments. Liquefied starch, wheat bran extract, ammonium nitrate, manganese sulphate and sodium acetate were chosen as promising ingredients for further optimisation studies. The highest yield of 41.9?g/l of lactic acid was obtained at the end of 24 hours of fermentation which corresponded to 90% conversion, on the basis of sugar supplied.     

Biomass hydrolyzing enzymes from plant pathogen Xanthomonas axonopodis pv. punicae: optimizing production and characterization

Xanthomonas axonopodis pv. punicae strain—a potent plant pathogen that causes blight disease in pomegranate—was screened for cellulolytic and xylanolytic enzyme production. This strain produced endo-β-1,4-glucanase, filter paper lyase activity (FPA), β-glucosidase and xylanase activities. Enzyme production was optimized with respect to major nutrient sources like carbon and nitrogen. Carboxy methyl cellulose (CMC) was a better inducer for FPA, CMCase and xylanase production, while starch was found to be best for cellobiase. Soybean meal/yeast extract at 0.5 % were better nitrogen sources for both cellulolytic and xylanolytic enzyme production while cellobiase and xylanase production was higher with peptone. Surfactants had no significant effect on levels of extracellular cellulases and xylanases. A temperature of 28 °C and pH 6–8 were optimum for production of enzyme activities. Growth under optimized conditions resulted in increases in different enzyme activities of around 1.72- to 5-fold. Physico-chemical characterization of enzymes showed that they were active over broad range of pH 4–8 with an optimum at 8. Cellulolytic enzymes showed a temperature optimum at around 55 °C while xylanase had highest activity at 45 °C. Heat treatment of enzyme extract at 75 °C for 1 h showed that xylanase activity was more stable than cellulolytic activities. Xanthomonas enzyme extracts were able to act on biologically pretreated paddy straw to release reducing sugars, and the amount of reducing sugars increased with incubation time. Thus, the enzymes produced by X. axonopodis pv. punicae are more versatile and resilient with respect to their activity at different pH and temperature. These enzymes can be overproduced and find application in different industries including food, pulp and paper and biorefineries for conversion of lignocellulosic biomass.     

Factors affecting aflatoxin production by Aspergillus parasiticus in a chemically defined medium

The optimum levels of sucrose, (NH4)2SO4, MgSO4, KH2PO4 and ZnSO4 for aflatoxin production in a chemically defined medium have been established. The last two were found to be essential for fungal growth and aflatoxin production. The effect of various carbon sources on aflatoxin production was tested using the defined medium. Asparagine was found to be essential for aflatoxin production. Very little aflatoxin was produced in the absence of asparagine with any of the other inorganic nitrogen sources tested. Supplementation with yeast extract, Casamino acids, Casitone and peptone increased the aflatoxin yield, but omission of asparagine led to decreased aflatoxin yields even when complex nitrogen sources were present. Asparagine could be replaced by aspartic acid or alanine.     

Isolation of Aureobasidium pullulans and the effect of different conditions for pullulanase and pullulan production

Isolation and production of pullulahase by a new Aureobasidium pullulans isolate from the Fayoum Governorate (AUMC 2997) which was identified by the Assiut University Mycological Center was investigated. Another isolate from the Aswan Governorate (AUMC 1695) was kindly provided by the Assiut University Mycological Center. Acetone 2× gave better results for the precipitation of protein than 80% ammonium sulfate in the case of the media containing yeast extract. Very low protein production occurred in media without yeast extract. No enzyme production occurred in the first two days and the production of the enzyme started on the third day. Statistical analysis determined that the optimum conditions for the production of pullulanase were: incubation at 25°C for 5 days, pH 5.5, with sucrose as carbon source at 100 g/L and sodium nitrate as nitrogen source at 2 g/L. Addition of manganese chloride to the medium (1, 2 and 3 g/L) caused inhibition of pullulanase. Also, while the lowest pullulan + pigment concentrations were attained at the fifth day, pH 5.5, at 15°C, 100 g/L sucrose, 2 g/L nitrogen sources, the pullulan + pigment production increased with increasing the concentrations of manganese chloride.     

Fermentative production of succinic acid from glucose and corn steep liquor byAnaerobiospirillum succiniciproducens

Anaerobiospirillum succiniciproducens requires expensive complex nitrogen sources such as yeast extract and polypeptone for its growth and succinic acid production. It was found thatA. succiniciproducens was able to grow in a minimal medium containing glucose when supplemented with corn steep liquor (CSL) as the sole complex nitrogen source. The concentration of CSL had a significant effect on the glucose consumption byA. succiniciproducens. When 10–15 g/L of CSL was supplemented, cells were grown to an OD₆₆₀ of 3.5 and produced 17.8 g/L succinic acid with 20 g/L glucose. These results are similar to those obtained by supplementing yeast extract and polypeptone, thereby suggesting that succinic acid can be produced more economically using glucose and CSL.