Growth and enzymological characteristics of a pink-pigmented facultative methylotrophMethylobacterium sp. MB1

Growth characteristics of batch and continuous cultures of the pink facultative methylotrophMethylobacterium sp. MB1 were determined. The response of a chemostat culture to a pulse increase of methanol concentration was studied. Malate, succinate and oxaloacetate additions to the methanol-supplemented medium decreased batch culture growth inhibition by methanol. The carotenoid content in cells grown in a chemostat decreased with increasing growth rate. The key enzyme activities of C₁-metabolism were measured in a chemostat culture at different dilution rates.     

Regulation of ammonia assimilation in an obligate methylotroph Methylobacillus flagellatum under steady-state and transient growth conditions

The obligate methylotroph Methylobacillus flagellatum was grown in the presence of different ammonium concentrations and the regulation of the enzymes associated with ammonium assimilation was investigated in steady-state and transient growth regimes. As the medium changed from C-limitation to dual C/N- and finally to N-limitation, the culture passed through three definite growth phases. The NADP⁺-dependent glutamate dehydrogenase (GDH) was present under ammonium limitation of the culture growth (at 2 mmol l^-1 of ammonium in the growth medium) and increased in response to an increase in nitrogen availability. Glutamine synthetase (GS) and glutamate synthase (GOGAT) activities were negligible during C- and C/N-limitation. In N-limited cells the GOGAT activity increased as the dilution rate increased up to 0.35 h^-1, and then sharply dropped. In the N-sufficient cultures both NAD⁺- and NADP⁺-dependent isocitrate dehydrogenase (NAD-ICDH and NADP-ICDH) activities were up-regulated as dilution rate increased, but in the N-limited culture the NAD-ICDH activity was up-regulated whereas NADP-ICDH one was down-regulated. Pulse additions of ammonium and methanol demonstrated the coordinate regulation of the GDH and ICDHs activities. When pulses were added to the C/N-limited cultures, there was an immediate utilization of the nutrients, resulting in an increase in biomass; at the same time the GDH and ICDH activities increased and the GS and GOGAT activities decreased. When the same ammonium/methanol pulse was added into the N-limited culture, there was a 3-hours delay in the culture response, after which the substrates were utilized at rates close to the ones shown by the C/N-limited culture after the analogous pulse.     

Regulation of alcohol oxidase of a recombinant Pichia pastoris Mut+ strain in transient continuous cultures

In the methylotrophic yeast Pichia pastoris, alcohol oxidase (AOX) is a key enzyme involved in the dissimilation of methanol. Heterologous proteins are usually expressed under the control of the AOX1 promoter, which drives the expression of alcohol oxidase 1 in the wild-type strain. This study investigates the regulation of the alcohol oxidase enzyme of a recombinant P. pastoris Mut+ strain in cultures on glycerol and methanol as sole carbon sources and in mixed substrate cultures on both substrates. The aim was to have a better insight in the transition from growth on glycerol to growth on methanol, which is a key step in standard high cell density P. pastoris cultures for the production of foreign proteins. Nutrient shifts in chemostat cultures showed that after growth on glycerol use of mixed feeds of glycerol and methanol allowed faster induction of alcohol oxidase and faster adaptation of cellular metabolism than with a feed containing methanol as sole carbon source. The results of this study showed also how critical it is to avoid transient methanol accumulation during P. pastoris cultures operated at low residual methanol concentrations. Indeed, pulse experiments during chemostat cultures showed that sudden increase in methanol concentrations in cultures performed under methanol-limited or dual methanol and glycerol-limited growth conditions leads to wash-out of the culture because of too high consumption rate of methanol, which leads to excretion of toxic intermediates. High rate of methanol consumption was due to high specific AOX activities observed at low residual methanol concentrations.     

Regulation of methanol metabolism in the facultative methylotroph Nocardia sp. 239 during growth on mixed substrates in batch- and continuous cultures

The regulation of methanol metabolism in Nocardia sp. 239 was investigated. Growth on mixtures of glucose or acetate plus methanol in batch cultures resulted in simultaneous utilization of the substrates. The presence of glucose, but not of acetate, repressed synthesis of the ribulose monophosphate (RuMP) cycle enzymes hexulose-6-phosphate synthase (HPS) and hexulose-6-phosphate isomerase (HPI), and methanol was used as an energy source only. Comparable results were obtained following addition of formaldehyde (fed-batch system) to a culture growing on glucose. The synthesis of the methanol dissimilatory and assimilatory enzymes in Nocardia sp. 239 thus appears to be controlled differently. Methanol and/or formaldehyde induce the synthesis of these enzymes, but under carbon-excess conditions their inducing effect on HPS and HPI synthesis is completely overruled by glucose, or metabolites derived from it. Repression of the synthesis of these RuMP cycle enzymes was of minor importance under carbon- and energy-limiting conditions in chemostat cultures. Addition of a pulse of glucose to a formaldehyde-limited (2.5 mmol l^–1 h^–1) fed-batch culture resulted in a decrease in the levels of several enzymes of methanol metabolism (including HPI), whereas the HPS levels remained relatively constant. Increasing HPS/HPI activity ratios were also observed with increasing growth rates in formaldehyde-limited chemostat cultures. The data indicate that additional mechanisms, the identity of which remains to be elucidated, are involved in controlling the levels of these C₁-specific enzymes in Nocardia sp. 239.Abbreviations HPS hexulose-6-phosphate synthase - HPI hexulose-6-phosphate isomerase - RuMP ribulose monophosphate - FBP fructose-1,6-bisphosphate - PFK 6-phosphofructokinase     

Photosynthetic carbon dioxide assimilation by Rhodospirillum rubrum

Summary Although Rhodospirillum rubrum, grown photoheterotrophically on malate, assimilates carbon dioxide less rapidly than it does when grown autotrophically, the difference is less marked than previously suggested.The rate of photoassimilation of carbon dioxide varies during batch culture on malate, reaching a maximum at about mid-exponential phase. It also varies with density and growth rate in a turbidostat continuous-flow culture on malate and increases with decreasing growth rate in a chemostat continuous-flow culture growing with limiting malate concentrations.The changing rates of carbon dioxide photoassimilation during photoheterotrophic growth under the various conditions are paralleled by changing activities of ribulose diphosphate carboxylase.Under conditions of maximum carbon dioxide fixation the rate by photoheterotrophic cultures approaches that shown by the bacterium growing autotrophically and is assimilated eight to ten times more slowly than is malate in chemostat cultures.The rate of carbon dioxide fixation also increases to that shown by autotrophic cells when photoheterotrophic cultures are deprived of malate, but without subjecting them to the conditions required for autotrophic growth.     

The process utility of thermotolerant methylotrophic bacteria: II. An evaluation of transient responses

In Part II, the process utility of a thermotolerant methylotrophic bacterium is evaluated with respect to its dynamic response when various substrate or nutrient pulses are imposed on it while growing under steady-state conditions in a chemostat. The pulses investigated were methanol pulses on methanol-, methanol/formaldehyde-, and dual methanol/ammonia-limited cultures and an ammonia pulse on a severely nitrogen (ammonia)-limited culture. The results obtained, although exemplifying the complex biochemistry of such bacteria, clearly demonstrate the bacteriums flexibility and versatility in handling process transients. Its lack of fastidiousness in unsteady state continuous culture make it a most promising candidate for inclusion in process cultures for elevated temperature industrial wastewater treatment.     

Regulation of the synthesis of methanol oxidizing enzymes inKloeckera sp. 2201 andHansenula polymorpha,a comparison

A comparative study was made of the regulation of the synthesis of methanol dissimilating enzymes inkloeckera sp. 2201 andHansenula polymorpha using chemostat and batch growth conditions and methanol or glucose as carbon sources. During growth in methanol-limited chemostat cultures similar enzyme patterns for alcohol oxidase, catalase, formaldehyde dehydrogenase and formate dehydrogenase in the two yeasts were found. When growing in batch culture with glucoseH. polymorpha, but notKloeckera sp. 2201, was found to produce ethanol which might affect the synthesis of these enzymes.     

Physiological analysis of Methylobacterium extorquens AM1 grown in continuous and batch cultures

Chemostat cultures of Methylobacterium extorquens AM1 grown on methanol or succinate at a range of dilution rates were compared to batch cultures in terms of enzyme levels, poly-β-hydroxybutyrate content, and intracellular concentrations of adenine and pyridine nucleotides. In both chemostat and batch cultures, enzymes specific to C₁ metabolism were up-regulated during growth on methanol and down-regulated during growth on succinate, polyhydroxybutyrate levels were higher on succinate, intracellular ATP levels and the energy charge were higher during growth on methanol, while the pools of reducing equivalents were higher during growth on succinate. For most of the tested parameters, little alteration occurred in response to growth rate. Overall, we conclude that the chemostat cultivation conditions developed in this study roughly mimic the growth in batch cultures, but provide a better control over the culturing conditions and a better data reproducibility, which are important for integrative functional studies. This study provides baseline data for future work using chemostat cultures, defining key similarities and differences in the physiology compared to existing batch culture data.     

Kinetic analysis of batch and continuous culture of Streptococcus cremoris HP1.

The growth of Streptococcus cremoris on a semidefined medium was studied at initial lactose concentrations of 0.2-5.0% in batch culture, and in lactose-limited chemostat cultures at 0.5% lactose. Kinetic analysis of the batch data, using statisitcal techniques, indicated the importance of lactose limitation and lactic acid inhibition of the growth of S. cremoris. A model for the biomass production, lactose utilization, and lactic acid production in batch culture was proposed. In continuous culture, it was found that steady state populations were maintained at higher dilution rates (D = 0.6-0.7 h-1) than the maximum predicted by batch culture (0.56h-1). No evidence for a selection of fast growing mutants was obtained. Copious growth adhering to the walls of the fermentor (i.e. wall growth) occurred very rapidly at higher dilution rates and this undoubtedly affected steady-state growth and wash-out and, as a consequence, the apparent maximum dilution rate.     

Metabolic aspects of the growth of a pink-pigmented facultative methylotroph in carbon-limited chemostat culture

Summary The regulation of carbon metabolism in a pink-pigmented facultative methylotroph has been studied. In methanol-limited chemostat culture a pH optimum at 7.0 with a narrow growth rate optimum with respect to growth yield and metabolic uncoupling was revealed. The average growth yield was 14±0.036 g·mol^–1 and the organism displayed a low maintenance energy and high maximum specific growth rate. When the carbon concentration in the feed remained constant and the dilution rate increased a deviation from linearity between substrate consumption and growth rate was found at higher growth rates. The addition of a pulse of methanol to a carbon-limited culture showed that anabolism could be dissociated from catabolism with the resulting accumulation of formaldehyde in concentrations which were not lethal. Offprint requests to: F. M. Girio     

Isolation of a yeast-lyzing Arthrobacter species and the production of the lytic enzyme complex in batch and continuous-flow fermentors

A gram-negative bacterium strongly lytic toward living cells of the food yeast Saccharomyces fragilis was isolated by continuous-flow enrichment from compost. The organism was identified as a species of Arthrobacter. The extracellular lytic enzyme complex produced by this bacterium contained β-1,3-glucanase, mannan mannohydrolase, and proteolytic activities. The polysaccharases were inducible by whole yeast cells. In chemostat cultures on chemically defined media, synthesis of the polysaccharases was very slight and only detectable at dilution rates below 0.02 hr^?1. Enzyme production in defined media was not solely dependent on growth rate but also was influenced by the growth limiting substrate and the culture history. The production of individual depolymerases and of the lytic activity was studied in batch and chemostat cultures containing yeast as the limiting substrate. The maximum specific growth rate of the Arthrobacter under these conditions was 0.22 hr^?1. β-1,3-Glucanase and proteolytic activities were synthesized by exponentially growing bacteria but maximum lytic titers did not develop until the specific growth rate was declining, at which time mannan mannohydrolase syntheses was induced. In yeast limited chemostats polysaccharase syntheses were greatest at the lowest dilution rates examined, namely 0.02 hr^?1. Further optimization of enzyme production was achieved by feeding the Arthrobacter culture to a second-stage chemostat. A comparison of lytic enzyme productivities in batch and chemostat cultures has been made.     

Control of respiration and metabolism in growing Klebsiella aerogenes. The role of adenine nucleotides

1. A rapid-sampling technique was used to obtain perchloric acid extracts of cells growing in a chemostat culture, so that meaningful values for ATP content could be obtained in spite of the fact that the turnover time for the total ATP content was about 1sec. 2. For steady-state growth, it was found that, in a glucose-limited chemostat culture, the ATP/ADP concentration ratio was approximately constant with changes in dissolved-oxygen tensions above the critical value, but fell when the culture was grown under oxygen-limited conditions and was at a minimum in anaerobically grown cultures. The steady-state ATP content was lower in cells growing under nitrogen-limited conditions with glucose in excess than in glucose-limited cells. The steady-state ATP content was independent of growth rate at growth rates over 0.1hr.(-1). 3. When the respiration rate of the cells was stimulated by lowering the oxygen tension the ATP content did not increase, indicating either an increased turnover rate of ATP or a fall in the P/O ratio. The sudden addition of extra glucose or succinate to a glucose-limited culture increased the respiration rate of the cells, but the ATP content quickly returned to the steady-state value after initial perturbations. This control over ATP content is explained in terms of regulation by adenine nucleotides of the catabolism and anabolism of glucose. An exception to this control over ATP content was found when the respiration rate was stimulated by addition of an antifoam.     

Optimisation of culture conditions with respect to biotin requirement for the production of recombinant avidin in Pichia pastoris

Due to its very high affinity to biotin, avidin is one of the most widely exploited proteins in modern biotechnological and biomedical applications. Since biotin is an essential vitamin for the growth of many microorganisms, we examined the effect of biotin deficiency on growth for a recombinant Pichia pastoris strain expressing and secreting a recombinant glycosylated avidin. The results showed that biotin deficiency lowers growth rate and biomass yield for P. pastoris. Substitution of biotin in the medium by the two structurally unrelated compounds, aspartic acid and oleic acid, which do not bind to recombinant avidin was analyzed quantitatively. These two compounds had a growth promoting effect in biotin-deficient medium, but did not replace biotin completely. Indeed, in chemostat culture, wash-out occurred after about six liquid residence times and recombinant avidin productivity was lowered. However, addition of low amounts of biotin (20 microg L(-1) of biotin for a cell density of 8 g L(-1)) resulted in stable chemostat cultures on methanol with the production of recombinant biotin-free avidin. The specific avidin production rate was 22 microg g(-1) h(-1) at a dilution rate of 0.06 h(-1).     

Turbidostat culture of yeast during transition from a resting state to active growth

The age components of a Saccharomyces cerevisiae 14 culture and the kinetics of its growth were studied afer the quiescent state at the onset active growth. The following factors induced the quiescent state: the cessation of a chemostat flow for 24 h, growth inhibition with 2,4-dinitrophenol (DNP) for 24 h, the storage of a culture growing on agar in a refrigerator during 24 h. The process of transition from the point of growth activation to the maximum rate of growth was then studied in turbidostat. This process took the shortest time in a refrigerated culture as well as in a culture that had been limited with a phosphorus source and in a culture limited with a nitrogen source and grown in chemostat at D = 0.26 h-1. The process was longer in cultures that had been either limited with glucose or inhibited with DNP and longest in a chemostat culture limited with a nitrogen source at D = 0.15 and 0.05 h-1. The rate of initial mitosis phases in the yeast is presumed to exert the greatest effect on the duration of this transition process.     

Sand administration as an instrument for biofilm control of Pseudomonas putida ATCC 11172 in chemostat cultures

Pseudomonas putida ATCC 11172 was grown in chemostat on L-asparagine or phenol as the sole, limiting carbon and energy source. The growth characteristics of a culture where a biofilm was present, were compared with one where the biofilm was strongly reduced by the grinding and shearing effect of sand suspended in the culture. In the presence of the intact biofilm, the curve of steady-state biomass versus dilution rate diverged greatly from the theoretical pattern predicted by conventional chemostat models. The sand strongly retarded the biofilm formation and to a high degree restored the shape of the biomass versus dilution rate curve to a more conventional pattern. The maximum specific growth rate (mu(max)) could not be calculated from the biofilm cultures. However using the sand cultures, mu(max) was determined to 0.64 h(-1) with L-asparagine as the carbon source and 0.49 h(-1) with phenol which compare favorably with the respective mu(max) values calculated from batch cultures.Incorporation of sand into strongly agitated cultures is recommended as an efficient and simple means of controlling biofilm formation in continuous cultures. The method may enable the gathering of basic kinetic data difficult to obtain in the presence of biofilm.     

Growth-rate-independent production of recombinant glucoamylase by Fusarium venenatum JeRS 325

Most recombinant proteins generated in filamentous fungi are produced in fed-batch cultures, in which specific growth rate normally decreases progressively with time. Because of this, such cultures are more suited to the production of products that are produced efficiently at low-growth rates (e.g., penicillin) than to products which are produced more efficiently at high-growth rates (e. g., glucoamylase). Fusarium venenatum A3/5 has been transformed (JeRS 325) to produce Aspergillus niger glucoamylase (GAM) under the control of the Fusarium oxysporum trypsin-like protease promoter. No glucoamylase was detected in the culture supernatant during exponential growth of F. venenatum JeRS 325 in batch culture. In glucose-limited chemostat cultures, GAM concentration increased with decrease in dilution rate, but the specific production rate of GAM (g GAM [g biomass](-1) h(-1)) remained approximately constant over the dilution-rate range 0.05 h to 0.19 h(-1), i.e., the recombinant protein was produced in a growth-rate-independent manner. The specific production rate decreased at dilution rates of 0.04 h(-1) and below. Specific production rates of 5.8 mg and 4.0 mg GAM [g biomass](-1) h(-1) were observed in glucose-limited chemostat cultures in the presence and absence of 1 g mycological peptone L(-1). Compared to production in batch culture, and for the same final volume of medium, there was no increase in glucoamylase production when cultures were grown in fed-batch culture. The results suggested that a chemostat operated at a slow dilution rate would be the most productive culture system for enzyme production under this trypsin-like promoter.     

Growth characteristics and oxidative capacity of<Emphasis Type="Italic"> Acetobacter aceti</Emphasis> IFO 3281: implications for <Emphasis Type="SmallCaps">l</Emphasis>-ribulose production

We studied the growth characteristics and oxidative capacities of Acetobacter aceti IFO 3281 in batch and chemostat cultures. In batch culture, glycerol was the best growth substrate and growth on ethanol occurred only after 6 days delay, although ethanol was rapidly oxidized to acetic acid. In continuous culture, both glycerol and ethanol were good growth substrates with similar characteristics. Resting cells in a bioreactor oxidized ribitol to l-ribulose with a maximal specific rate of 1.2 g g^–1 h^–1). The oxidation of ribitol was inhibited by ethanol but not by glycerol. Biomass yield (Y_SX; C-mmol/C-mmol) on ethanol and glycerol was low (0.21 and 0.17, respectively). In the presence of ribitol the yield was somewhat higher (0.25) with ethanol but lower (0.13) with glycerol, with respectively lower and higher CO₂ production. In chemostat cultures the oxidation rate of ribitol was unaffected by ethanol or glycerol. Cell-free extract oxidized ethanol very slowly but not ribitol; the oxidative activity was located in the cell membrane fraction. Enzymatic activities of some key metabolic enzymes were determined from steady-state chemostat with ethanol, glycerol, or ethanol/glycerol mixture as a growth limiting substrate. Based on the measured enzyme activities, metabolic pathways are proposed for ethanol and glycerol metabolism.     

Methanol metabolism in a peroxisome-deficient mutant of Hansenula polymorpha: a physiological study

We have studied methanol-utilization in a peroxisome-deficient (PER) mutant of Hansenula polymorphoa. In spite of the fact that in carbon-limited chemostat cultures under induced conditions the enzymes involved in methanol metabolism were present at wild-type (WT) levels, this mutant is unable to grow on methanol as a sole carbon and energy source. Addition of methanol to glucose-limited (S_R=12.5mM) chemostat cultures of the PER mutant only resulted in an increase in yield when small amounts were used (up to 22.5 mM). At increasing amounts however, a gradual decrease in cell density was observed which, at 80 mM methanol in the feed, had dropped below the original value of the glucose-limited culture. This reduction in yield was not observed when increasing amounts of formate instead of methanol were used as supplements for the glucose-limited mutant culture and also not in WT cells, used as control in these experiments. The effect of addition of methanol to a glucose-limited PER culture was also studied in the transient state during adaptation of the cells to methanol. The enzyme patterns obtained suggested that the ultimate decrease in yield observed at enhanced methanol concentrations was due to an inefficient methanolmetabolism as a consequence of the absence of peroxisomes. The absence of intact peroxisomes results in two major problems namely i) in H₂O₂-metabolism, which most probably is no longer mediated by catalase and ii) the inability of the cell to control the fluxes of formaldehyde, generated from methanol. The energetic consequences of this metabolism, compared to the WT situation with intact peroxisomes, are discussed.Abbreviations AO alcohol oxidase - DHAS dihydroxyacetone synthase - WT wild-type - PER peroxisome-deficient - GSH reduced glutathione - GSSG glutathione disulphide     

Regulation by ammonium and glucose of Arthrobacter fluorescens alanine dehydrogenase

Alanine dehydrogenase in Arthrobacter fluorescens exhibited an allosteric behaviour and two K _m values for ammonium were estimated. In batch cultures at different ammonium concentrations and in continuous culture following an NH₄ ⁺ pulse, the level of ADH activity seems to be regulated by the ammonium concentration, high activities being observed when extracellular ammonium was in excess. The response to the growth rate of an ammonium-limited chemostat culture of A. fluorescens seems to indicate that alanine dehydrogenase and glutamine synthetase activities were inversely related. High activities of glutamate oxaloacetate transaminase and glutamate pyruvate transaminase have been found in crude extract of ammonium-limited cultures. From the results obtained in batch cultures grown at different glucose concentrations and in carbon-limited chemostat culture it appeared that the limitation by glucose influenced alanine dehydrogenase activity negatively. No glutamate dehydrogenase activity and no glutamate synthase activity could be detected with either NADH or NADPH as coenzymes.Abbreviations ADH alanine dehydrogenase - GS glutamine synthetase - GDH glutamate dehydrogenase - GOGAT glutamine oxoglutarate aminotransferase - GOT glutamate oxaloacetate transaminase - GPT glutamate pyruvate transaminase     

Siderophore production by Fusarium venenatum A3/5

Fusarium venenatum A3/5 was grown in iron-restricted batch cultures and iron-limited chemostat cultures to determine how environmental conditions affected siderophore production. The specific growth rate in iron-restricted batch cultures was 0.22 h(-1), which was reduced to 0.12 h(-1) when no iron was added to the culture. D(crit) in iron-limited chemostat culture was 0.1 h(-1). Siderophore production was correlated with specific growth rate, with the highest siderophore production occurring at D=0.08 h(-1) and the lowest at D=0.03 h(-1). Siderophore production was greatest at pH 4.7 and was significantly reduced at pHs above 6.0. Siderophore production could be enhanced by providing insoluble iron instead of soluble iron in continuous flow cultures.