Synergistic effect of enterocin AS-48 in combination with outer membrane permeabilizing treatments against Escherichia coli O157:H7

AIMS: To determine the effects of outer membrane (OM) permeabilizing agents on the antimicrobial activity of enterocin AS-48 against Escherichia coli O157:H7 CECT 4783 strain in buffer and apple juice. METHODS AND RESULTS: We determined the influence of pH, EDTA, sodium tripolyphosphate (STPP) and heat on E. coli O157:H7 CECT 4783 sensitivity to enterocin AS-48 in buffer and in apple juice. Enterocin AS-48 was not active against intact cells of E. coli O157:H7 CECT 4783 at neutral pH. However, cells sublethally injured by OM permeabilizing agents (EDTA, STPP, pH 5, pH 8.6 and heat) became sensitive to AS-48, decreasing the amount of bacteriocin required for inhibition of E. coli O157:H7 CECT 4783. CONCLUSIONS: The results presented indicate that enterocin AS-48 could potentially be applied with a considerably wider range of protective agents, such as OM permeabilizing agents, with increased efficacy in inhibiting E. coli O157:H7. SIGNIFICANCE AND IMPACT OF THE STUDY: Results from this study support the potential use of enterocin AS-48 to control E. coli O157:H7 in combination with other hurdles.     

Effect of combined physico-chemical preservatives on enterocin AS-48 activity against the enterotoxigenic Staphylococcus aureus CECT 976 strain

AIMS: Control of the enterotoxigenic Staphylococcus aureus CECT 976 strain by enterocin AS-48 in laboratory cultures, and behaviour of the AS-48 activity in the presence of food preservatives. METHODS AND RESULTS: Enterocin AS-48 shows inhibitory activity on the majority of the Staphylococcus species tested. This enterocin has a bactericidal and bacteriolytic mode of action on S. aureus CECT 976, a strain selected for this study by its enterotoxigenic character (SEA production). The inhibitory effect of AS-48 was pH and temperature dependent, and enterocin activity was higher at pH 5. The minimum bactericidal concentration (MBC) of AS-48, decreased from 15 microg ml(-1) at 37 degrees C to 10 microg ml(-1) at 15 degrees C. Sublethally injured cells showed an increased sensitivity with a MBC of 5 microg ml(-1). In this way, the highest effectiveness of Ent AS-48 against S. aureus CECT 976 was obtained at 4 degrees C in combination with high concentrations of NaCl (6 and 7%). Interestingly, enterotoxin SEA production by strain CECT 976 was markedly inhibited by subinhibitory concentrations of Ent AS-48. These low concentrations also provoked a delay of bacterial growth. CONCLUSION: The results presented indicated that Ent AS-48 has a potential for application as a protective agent against S. aureus in foods. SIGNIFICANCE AND IMPACT OF THE STUDY: In this study, we have established the conditions for an efficient inhibition of growth and enterotoxin production by S. aureus CECT 976 in culture media by a combination of environmental factors and Ent AS-48.     

Inhibition of bacterial growth, enterotoxin production, and spore outgrowth in strains of Bacillus cereus by bacteriocin AS-48

Bacteriocin AS-48 showed high bactericidal activity for mesophilic and psychrotrophic strains of Bacillus cereus over a broad pH range. AS-48 inhibition of the enterotoxin-producing strain LWL1 was enhanced by sodium nitrite, sodium lactate, and sodium chloride. The latter also enhanced AS-48 activity against strain CECT 131. Bacterial growth and enterotoxin production by strain LWL1 were completely inhibited at bacteriocin concentrations of 7.5 microg/ml. At subinhibitory bacteriocin concentrations, enterotoxin production decreased markedly and sporulation was delayed. Intact spores were resistant to AS-48 but became gradually sensitive to AS-48 during the course of germination.     

Optimization of enterocin P production by batch fermentation of Enterococcus faecium P13 at constant pH

The influence of pH on growth, enterocin P production and glucose consumption by Enterococcus faecium P13 was studied during anaerobic batch fermentation in MRS broth at 32 degrees C in a fermentor. Growth and glucose consumption were maximal at pH 7.0. Enterocin P production displayed primary metabolite kinetics and was strongly dependent on pH. A maximum antimicrobial activity of 1,949 bacteriocin units (BU) ml(-1) was obtained at pH 6.0, which represented a four-fold increase compared with the antimicrobial activity obtained without pH regulation. The pH exerted a marked effect on the decrease in bacteriocin activity, with the decrease being maximal at pH 7.0. In this report, we propose models for the growth of E. faecium P13 as well as enterocin P production and inactivation. Enterocin P production decreased when potentially stress-inducing compounds (NaCl or ethanol) were included in the growth medium.     

Fate of enterohemorrhagic Escherichia coli O157:H7 in apple cider with and without preservatives.

A strain of enterohemorrhagic Escherichia coli serotype O157:H7 isolated from a patient in an apple cider-related outbreak was used to study the fate of E. coli O157:H7 in six different lots of unpasteurized apple cider. In addition, the efficacy of two preservatives, 0.1% sodium benzoate and 0.1% potassium sorbate, used separately and in combination was evaluated for antimicrobial effects on the bacterium. Studies were done at 8 or 25 degrees C with ciders having pH values of 3.6 to 4.0. The results revealed that E. coli O157:H7 populations increased slightly (ca. 1 log10 CFU/ml) and then remained stable for approximately 12 days in lots inoculated with an initial population of 10(5) E. coli O157:H7 organisms per ml and held at 8 degrees C. The bacterium survived from 10 to 31 days or 2 to 3 days at 8 or 25 degrees C, respectively, depending on the lot. Potassium sorbate had minimal effect on E. coli O157:H7 populations, with survivors detected for 15 to 20 days or 1 to 3 days at 8 or 25 degrees C, respectively. In contrast, survivors in cider containing sodium benzoate were detected for only 2 to 10 days or less than 1 to 2 days at 8 or 25 degrees C, respectively. The highest rates of inactivation occurred in the presence of a combination of 0.1% sodium benzoate and 0.1% potassium sorbate. The use of 0.1% sodium benzoate, an approved preservative used by some cider processors, will substantially increase the safety of apple cider in terms of E. coli O157:H7, in addition to suppressing the growth of yeasts and molds.     

Influence of apple cultivars on inactivation of different strains of Escherichia coli O157:H7 in apple cider by UV irradiation

This study examined the effect of different apple cultivars upon the UV inactivation of Escherichia coli O157:H7 strains within unfiltered apple cider. Apple cider was prepared from eight different apple cultivars, inoculated with approximately 10(6) to 10(7) CFU of three strains of E. coli O157:H7 per ml (933, ATCC 43889, and ATCC 43895), and exposed to 14 mJ of UV irradiation per cm(2). Bacterial populations for treated and untreated samples were then enumerated by using nonselective media. E. coli O157:H7 ATCC 43889 showed the most sensitivity to this disinfection process with an average 6.63-log reduction compared to an average log reduction of 5.93 for both strains 933 and ATCC 43895. The highest log reduction seen, 7.19, occurred for strain ATCC 43889 in Rome cider. The same cider produced the lowest log reductions: 5.33 and 5.25 for strains 933 and ATCC 43895, respectively. Among the apple cultivars, an average log reduction range of 5.78 (Red Delicious) to 6.74 (Empire) was observed, with two statistically significant (alpha < or = 0.05) log reduction groups represented. Within the paired cultivar-strain analysis, five of eight ciders showed statistically significant (alpha < or = 0.05) differences in at least two of the E. coli strains used. Comparison of log reductions among the E. coli strains to the cider parameters of (o)Brix, pH, and malic acid content failed to show any statistically significant relationship (R(2) > or = 0.95). However, the results of this study indicate that regardless of the apple cultivar used, a minimum 5-log reduction is achieved for all of the strains of E. coli O157:H7 tested.     

Antimicrobial activity of enterocin EJ97 against 'Bacillus macroides/Bacillus maroccanus' isolated from zucchini purée

AIMS: Activity of the bacteriocin EJ97 produced by Enterococcus faecalis EJ97 against strains of 'Bacillus macroides/B. maroccanus' isolated from spoiled zucchini purée was investigated. METHODS AND RESULTS: The influence of several factors like bacteriocin concentration, incubation temperature, pH, growth medium and chemical perservatives on bacteriocin activity was investigated. Enterocin EJ97 [2 arbitrary units (AU) per millilitre] had a marked bactericidal effect on strain INRA P53-2 after 4 h of incubation at 37 degrees C, 24 h at 15 degrees C or 48 h at 4 degrees C. Activity was markedly reduced at pH values of 5.0 and 9.0, but was potentiated by sodium nitrite, sodium benzoate, sodium lactate and sodium tripolyphosphate. Inhibition of strain INRA P53-2 in a commercial vegetable purée required a 10-fold higher bacteriocin concentration. Strain EJ97 was able to grow and produce bacteriocin on vegetable purée, but no inhibition of strain INRA P53-2 was detected. CONCLUSIONS: The concentration-dependent bactericidal activity of enterocin EJ97 against strain INRA P53-2 was higher at 37 degrees C and neutral pH, and was potentiated by chemical preservatives. Although enterocin EJ97 was less active in vegetable purée, the concentrations providing bactericidal activity in this food matrix are practical for commercial use. SIGNIFICANCE AND IMPACT OF THE STUDY: Enterocin EJ97 may have a potential for use in the prevention of food spoilage caused by 'B. macroides/B. maroccanus'.     

Inhibition of Bacterial Growth, Enterotoxin Production, and Spore Outgrowth in Strains of Bacillus cereus by Bacteriocin AS-48

Bacteriocin AS-48 showed high bactericidal activity for mesophilic and psychrotrophic strains of Bacillus cereus over a broad pH range. AS-48 inhibition of the enterotoxin-producing strain LWL1 was enhanced by sodium nitrite, sodium lactate, and sodium chloride. The latter also enhanced AS-48 activity against strain CECT 131. Bacterial growth and enterotoxin production by strain LWL1 were completely inhibited at bacteriocin concentrations of 7.5 μg/ml. At subinhibitory bacteriocin concentrations, enterotoxin production decreased markedly and sporulation was delayed. Intact spores were resistant to AS-48 but became gradually sensitive to AS-48 during the course of germination.     

Combined effect of high-pressure treatments and bacteriocin-producing lactic acid bacteria on inactivation of Escherichia coli O157:H7 in raw-milk cheese

The effect of high-pressure (HP) treatments combined with bacteriocins of lactic acid bacteria (LAB) produced in situ on the survival of Escherichia coli O157:H7 in cheese was investigated. Cheeses were manufactured from raw milk inoculated with E. coli O157:H7 at approximately 10(5) CFU/ml. Seven different bacteriocin-producing LAB were added at approximately 10(6) CFU/ml as adjuncts to the starter. Cheeses were pressurized on day 2 or 50 at 300 MPa for 10 min or 500 MPa for 5 min, at 10 degrees C in both cases. After 60 days, E. coli O157:H7 counts in cheeses manufactured without bacteriocin-producing LAB and not pressurized were 5.1 log CFU/g. A higher inactivation of E. coli O157:H7 was achieved in cheeses without bacteriocin-producing LAB when 300 MPa was applied on day 50 (3.8-log-unit reduction) than if applied on day 2 (1.3-log-unit reduction). Application of 500 MPa eliminated E. coli O157:H7 in 60-day-old cheeses. Cheeses made with bacteriocin-producing LAB and not pressurized showed a slight reduction of the pathogen. Pressurization at 300 MPa on day 2 and addition of lacticin 481-, nisin A-, bacteriocin TAB 57-, or enterocin AS-48-producing LAB were synergistic and reduced E. coli O157:H7 counts to levels below 2 log units in 60-day-old cheeses. Pressurization at 300 MPa on day 50 and addition of nisin A-, bacteriocin TAB 57-, enterocin I-, or enterocin AS-48-producing LAB completely inactivated E. coli O157:H7 in 60-day-old cheeses. The application of reduced pressures combined with bacteriocin-producing LAB is a feasible procedure to improve cheese safety.     

Effect of immersion solutions containing enterocin AS-48 on Listeria monocytogenes in vegetable foods

The effect of immersion solutions containing enterocin AS-48 alone or in combination with chemical preservatives on survival and proliferation of Listeria monocytogenes CECT 4032 inoculated on fresh alfalfa sprouts, soybean sprouts, and green asparagus was tested. Immersion treatments (5 min at room temperature) with AS-48 solutions (25 microg/ml) reduced listeria counts of artificially contaminated alfalfa and soybean sprouts by approximately 2.0 to 2.4 log CFU/g compared to a control immersion treatment in distilled water. The same bacteriocin immersion treatment applied on green asparagus had a very limited effect. During storage of vegetable samples treated with immersion solutions of 12.5 and 25 microg of AS-48/ml, viable listeria counts were reduced below detection limits at days 1 to 7 for alfalfa and soybean sprouts at 6 and 15 degrees C, as well as green asparagus at 15 degrees C. Only a limited inhibition of listeria proliferation was detected during storage of bacteriocin-treated alfalfa sprouts and green asparagus at 22 degrees C. Treatment with solutions containing AS-48 plus lactic acid, sodium lactate, sodium nitrite, sodium nitrate, trisodium phosphate, trisodium trimetaphosphate, sodium thiosulphate, n-propyl p-hydroxybenzoate, p-hydoxybenzoic acid methyl ester, hexadecylpyridinium chloride, peracetic acid, or sodium hypochlorite reduced viable counts of listeria below detection limits (by approximately 2.6 to 2.7 log CFU/g) upon application of the immersion treatment and/or further storage for 24 h, depending of the chemical preservative concentration. Significant increases of antimicrobial activity were also detected for AS-48 plus potassium permanganate and in some combinations with acetic acid, citric acid, sodium propionate, and potassium sorbate.     

Potential Applications of the Cyclic Peptide Enterocin AS-48 in the Preservation of Vegetable Foods and Beverages

Bacteriocins are antimicrobial peptides produced by bacteria. Among them, the enterococcal bacteriocin (enterocin) AS-48 stands for its peculiar characteristics and broad-spectrum antimicrobial activity. AS-48 belongs to the class of circular bacteriocins and has been studied in depth in several aspects: peptide structure, genetic determinants, and mode of action. Recently, a wealth of knowledge has accumulated on the antibacterial activity of this bacteriocin against foodborne pathogenic and spoilage bacteria in food systems, especially in vegetable foods and drinks. This work provides a general overview on the results from tests carried out with AS-48 in different vegetable food categories (such as fruit juices, ciders, sport and energy drinks, fresh fruits and vegetables, pre-cooked ready to eat foods, canned vegetables, and bakery products). Depending on the food substrate, the bacteriocin has been tested alone or as part of hurdle technology, in combination with physico-chemical treatments (such as mild heat treatments or high-intensity pulsed electric fields) and other antimicrobial substances (such as essential oils, phenolic compounds, and chemical preservatives). Since the work carried out on bacteriocins in preservation of vegetable foods and drinks is much more limited compared to meat and dairy products, the results reported for AS-48 may open new possibilities in the field of bacteriocin applications.     

Purification and characterization of multiple bacteriocins and an inducing peptide produced by Enterococcus faecium NKR-5-3 from Thai fermented fish

Enterocins NKR-5-3A, B, C, and D were purified from the culture supernatant of Enterococcus faecium NKR-5-3 and characterized. Among the four purified peptides, enterocin NKR-5-3A (5242.3 Da) was identical to brochocin A, produced by Brochothrix campestris ATCC 43754, in mature peptides, and its putative synergistic peptide, enterocin NKR-5-3Z, was found to be encoded in ent53Z downstream of ent53A, encoding enterocin NKR-5-3A. Enterocin NKR-5-3B (6316.4 Da) showed a broad antimicrobial spectrum, and enterocin NKR-5-3C (4512.8 Da) showed high activity against Listeria. Enterocin NKR-5-3D (2843.5 Da), showing high homology to an inducing peptide produced by Lactobacillus sakei 5, induced the production of the enterocins. The enterocins showed different antimicrobial spectra and intensities. E. faecium NKR-5-3 concomitantly produced enterocins NKR-5-3A, B, C, and D which probably belong to different classes of bacteriocins. Furthermore, NKR-5-3 production was induced by enterocin NKR-5-3D.     

Purification and characterization of enterocin 4, a bacteriocin produced by Enterococcus faecalis INIA 4.

A simple two-step procedure was developed to obtain pure enterocin 4, a bacteriocin produced by Enterococcus faecalis INIA 4. Chemical and genetic characterization revealed that the primary structure of enterocin 4 is identical to that of peptide antibiotic AS-48 from Enterococcus faecalis S-48. In contrast to the reported inhibitory spectrum of AS-48, enterocin 4 displayed no activity against gram-negative bacteria.     

Metabiotic effect of Bacillus licheniformis on Clostridium botulinum: implications for home-canned tomatoes.

The metabiotic effect of Bacillus licheniformis on Clostridium botulinum was examined. B. licheniformis elevated the pH of a model system with an initial pH of 4.4 so that C. botulinum grew and produced toxin. Toxin production was observed when spores from both species were coinoculated at levels as low as 10 spores per ml. When pint jars of tomatoes were used, canner size contributed to a 10,000-fold difference in the lethality of a boiling water bath process on B. licheniformis spores. Botulinal toxin was not detected in pH-elevated jars of tomatoes containing C. botulinum spores.     

Influence of Apple Cultivars on Inactivation of Different Strains of Escherichia coli O157:H7 in Apple Cider by UV Irradiation

This study examined the effect of different apple cultivars upon the UV inactivation of Escherichia coli O157:H7 strains within unfiltered apple cider. Apple cider was prepared from eight different apple cultivars, inoculated with approximately 10⁶ to 10⁷ CFU of three strains of E. coli O157:H7 per ml (933, ATCC 43889, and ATCC 43895), and exposed to 14 mJ of UV irradiation per cm². Bacterial populations for treated and untreated samples were then enumerated by using nonselective media. E. coli O157:H7 ATCC 43889 showed the most sensitivity to this disinfection process with an average 6.63-log reduction compared to an average log reduction of 5.93 for both strains 933 and ATCC 43895. The highest log reduction seen, 7.19, occurred for strain ATCC 43889 in Rome cider. The same cider produced the lowest log reductions: 5.33 and 5.25 for strains 933 and ATCC 43895, respectively. Among the apple cultivars, an average log reduction range of 5.78 (Red Delicious) to 6.74 (Empire) was observed, with two statistically significant (α ≤ 0.05) log reduction groups represented. Within the paired cultivar-strain analysis, five of eight ciders showed statistically significant (α ≤ 0.05) differences in at least two of the E. coli strains used. Comparison of log reductions among the E. coli strains to the cider parameters of °Brix, pH, and malic acid content failed to show any statistically significant relationship (R² ≥ 0.95). However, the results of this study indicate that regardless of the apple cultivar used, a minimum 5-log reduction is achieved for all of the strains of E. coli O157:H7 tested.     

Effect of sausage ingredients and additives on the production of enterocin A and B by Enterococcus faecium CTC492. Optimization of in vitro production and anti-listerial effect in dry fermented sausages

Enterocin A and B in Enterococcus faecium CTC492 were co-induced by the different factors assayed in this study (r = 0.93) and followed primary metabolic kinetics. Enterocin production was significantly inhibited by sausage ingredients and additives, with the exception of nitrate. The addition of sodium chloride and pepper decreased production 16-fold. The temperature and pH influenced enterocin production, with optima between 25 and 35 degrees C, and from 6.0 to 7.5 of initial pH. The maximum activity was achieved, under favourable growth conditions, with MRS supplemented with sucrose (2%) plus glucose (0.25%) and Tween-80 (1%). MRS concentration, NaCl plus pepper addition, absence of Tween-80 in the growth medium, incubation at 45 degrees C and an initial pH under 5.5 were detrimental to bacteriocin production. Stress conditions did not favour enterocin production. Desadsorption was Tween-dependent. Enterocin A activity in the crude extracts stored at -80 degrees C was better preserved than enterocin B (when tested against their specific indicator strain), but anti-listerial activity remained intact. Applied as anti-listerial additives in dry fermented sausages, enterocins significantly diminished Listeria counts by 1. 13 log (P < 0.001), while Enterococcus faecium CTC492 added as starter culture did not significantly reduce Listeria counts (P > 0. 1) compared with the standard starter culture (Bac-). Enterocins A and B could be considered as extra biopreservative hurdles for listeria prevention in dry fermented sausages.     

Efficacy of enterocin S760 in treatment of mice with anthrax infection due to Bacillus anthracis M-71

The therapeutic efficacy of enterocin S760, a broad spectrum antimicrobial peptide produced by Enterococcus faecium LWP760 was tested on mice infected with Bacillus anthracis M-71 to induce anthrax (second Tsenkovsky's vaccine). Intraperitoneal four-, two- or one-fold administration of the peptide in a dose of 25 mg/kg for 10 days for prophylactic (1 hour after the contamination) and therapeutic (24 hours after the contamination) purposes prevented or cured the infection in 90-100% of the mice versus the 100-percent lethality in the control (untreated animals). The antimicrobial activity of enterocin S760 against B. anthracis M-71 in vivo correlated with activity in vitro. Enterocin S760 is considered a novel promising antimicrobial for the treatment of grampositive and gramnegative infections.