Long-term maintenance of a transgenic Catharanthus roseus hairy root line

Stably transformed transgenic hairy root cultures have the potential to be a valuable production platform for a variety of secondary metabolites. This study reports that a transgenic hairy root culture of Catharanthus roseus has been stably maintained for over 4.5 years. This culture carries a transgene that expresses the green fluorescent protein under the control of the glucocorticoid-inducible promoter. Genomic PCR confirmed the presence of the GFP insert within the hairy roots, and induction with dexamethasone caused a significant (p < 0.02) increase in GFP levels.     

Determination of metabolic rate-limitations by precursor feeding in Catharanthus roseus hairy root cultures

Precursors from the terpenoid and tryptophan branches were fed to Catharanthus roseus to determine which of the two branches limits metabolic flux to indole alkaloids. The feeding of tryptophan at 17 days of the culture cycle produced auxin-like effects. Addition of low levels of auxin or tryptophan resulted in significant increases in flux to the indole alkaloids. Conversely, feeding higher levels of auxin or tryptophan resulted in increased branching and thickening of the hairy root cultures. A dramatic reduction in flux to the alkaloids was also observed. However, feeding tryptamine or terpenoid precursors had no effect. Therefore, neither pathway tested revealed to be rate-limiting during the late growth phase. Feeding of either geraniol, 10-hydroxygeraniol, or loganin at 21 days each resulted in significant increases in the accumulation of tabersonine. The addition of tryptophan or tryptamine had no effect during the stationary phase of the growth cycle. Thus, during the early stationary phase of growth the terpenoid pathway appears to be rate-limiting. Combined elicitation with jasmonic acid and feeding either loganin or tryptamine did not further enhance the accumulation of indole alkaloids.     

Indole alkaloid production by hairy root cultures of Catharanthus roseus

Hairy root cultures of Catharanthus roseus were established by infection with six different Agrobacterium rhizogenes strains. Two plant varieties were used and found to exhibit significantly different responses to infection. Forty-seven hairy root clones derived from normal plants and two derived from the flowerless variety were screened for their growth and indole alkaloid production. The growth rate and morphological appearance showed wide variations between the clones. The alkaloid spectra observed were qualitatively but not quantitatively very similar to that of the corresponding normal plant roots. No vindoline or deacetyltransferase activity could be detected in any of the cultures studied. O-acetylval-lesamine, an alkaloid which has not been previously observed in C. roseus was identified from extracts of hairy root clone No. 8. Two root clones were examined for their growth and alkaloid accumulation during a 26-day culture period. Alkaloid accumulation parallelled growth in both clones with ca. 2 mg ajmalicine and catharanthine per g dry weight being observed.Dedicated to Dr. Friedrich Constabel on the occasion of his 60th birthday     

Nutrient consumption and alkaloid accumulation in a hairy root line of Catharanthus roseus

A hairy root line from Catharanthus roseus was cultured in a 14 l bioreactor. Nitrate and phosphate uptakes were similar to the same root line cultured in a 250 ml Erlenmeyer flask. However, sucrose consumption rate was slower in roots cultured in the bioreactor. These results show that it is feasible to upgrade this hairy root line to bioreactor level and, although carbon utilization has to be improved, ajmalicine and catharanthine were still produced and were retained within the biomass tissue.     

Production of indole alkaloids by selected hairy root lines of Catharanthus roseus

Hairy root cultures of Catharanthus roseus were established by infection of seedlings with Agrobacterium rhizogenes 15834. Approximately 150 transformants from four different. C. roseus cultivars were screened for desirable traits in growth and indole alkaloid production. Five hairy root clones grew well in liquid culture with doubling times similar to those reported for cell suspensions. Fast growing clones had similar morphologies, characterized by thin, straight, and regular branches with thin tips. The levels of key alkaloids, ajmalicine, serpentine, and catharanthine, in these five clones, also compared well with literature data from cell suspensions, yet HPLC and GC-MS data indicate the presence of vindoline in two clones at levels over three orders of magnitude greater than the minute amounts reported in cell culture. These results suggest that further optimization may result in hairy roots as a potential source of vindoline and catharanthine, the two monomers necessary to synthesize that antineoplastic drug, vinblastine. (c) 1993 John Wiley & Sons, Inc.     

Bioreactor studies on hairy root cultures of Catharanthus roseus: Comparison of three bioreactor types

Summary Hairy roots of Catharanthus roseus were cultivated in three different types of bioreactors. The best growth and indole alkaloid production was achieved in an airsparged bioreactor with no other mixing. In the stirred bioreactor or in the bioreactor with medium circulation the roots did not grow, suggesting that hairy roots of C. roseus are more sensitive to stress than root cultures of many other plant species.     

Jasmonate-induced epoxidation of tabersonine by a cytochrome P-450 in hairy root cultures of Catharanthus roseus

Methyl jasmonate, a chemical inducer of secondary metabolism, was shown to promote tabersonine 2 biosynthesis in hairy root cultures of Catharanthus roseus. Tabersonine 6,7-epoxidase activity was detected in total protein extract of jasmonate-induced hairy root cultures using labeled 14C-tabersonine 2. This enzyme converted tabersonine 2 to lochnericine 3 by selective epoxidation at positions 6 and 7 via a reaction dependent on NADPH and molecular oxygen. Carbon monoxide, clotrimazole, miconazole, and cytochrome C were shown to be strong inhibitors of the enzyme. The activity was found in microsomes, indicating that tabersonine 6,7-epoxidase was a cytochrome P-450-dependent monooxygenase.     

Manipulating indole alkaloid production by Catharanthus roseus cell cultures in bioreactors: from biochemical processing to metabolic engineering

Catharanthus roseus plants produce many pharmaceutically important indole alkaloids, of which the bisindole alkaloids vinblastine and vincristine are antineoplastic medicines and the monoindole alkaloids ajmalicine and serpentine are antihypertension drugs. C. roseus cell cultures have been studied for producing these medicines or precursors catharanthine and vindoline for almost four decades but so far without a commercially successful process due to biological and technological limitations. The research thus focused on the one hand on engineering the bioreactor process on the other engineering the cell factory itself. This review mainly summarizes the progress made on biochemical engineering aspects of C. roseus cell cultures in bioreactors in the past decades and metabolic engineering of indole alkaloid production in recent years. The paper also attempts to highlight new strategies and technologies to improve alkaloid production and bioreactor performance. Perspectives of metabolic engineering to create new cell lines for large-scale production of indole alkaloids in bioreactors and effective combination of these up- and down-stream processing are presented.     

Effect of substrate competition in kinetic models of metabolic networks

Substrate competition can be found in many types of biological processes, ranging from gene expression to signal transduction and metabolic pathways. Although several experimental and in silico studies have shown the impact of substrate competition on these processes, it is still often neglected, especially in modelling approaches. Using toy models that exemplify different metabolic pathway scenarios, we show that substrate competition can influence the dynamics and the steady state concentrations of a metabolic pathway. We have additionally derived rate laws for substrate competition in reversible reactions and summarise existing rate laws for substrate competition in irreversible reactions.     

Studies on the optimization of growth and indole alkaloid production by hairy root cultures of Catharanthus roseus

Catharanthus roseus hairy root cultures, genetically transformed with Agrobacterium rhizogenes, produce a wide variety of indole alkaloids. The effect of sucrose, phosphate, nitrate, and ammonia concentrations on growth and indole alkaloid production of C. roseus hairy root cultures were studied by using statistical experimental designs and linear regression analysis. Contradictory effects of these nutrients on growth and indole alkaloid production were found. The maximal growth was obtained by having 77. 8 mg NaH(2)PO(4) . H(2)O/L and 1. 311 g KNO(3)/L in the medium, whereas the specific production of alkaloids was highest at the lowest levels of all the nutrients studied. The maximal dry weight was obtained with high values of sucrose and ammonia, but clear optimum concentrations could not be found. When having enough nutrients to support reasonable growth, it appeared difficult to affect the specific alkaloid production rates considerably. The growth (dry wt.) with the optimized nutrient concentrations in the medium was more than 50% better than in the control medium with about the same alkaloid production.     

Development of two stage culture process by optimization of inorganic salts for improving catharanthine production in hairy root cultures of Catharanthus roseus

The effects of the concentrations of inorganic salts in Schenk and Hildebrandt (SH) medium on catharanthine production in hairy root cultures of Catharanthus roseus were investigated. The inorganic salt components could be categorized into four groups. The first group (nitrate) supported both the growth of and catharanthine production by hairy roots with incremental increases in the concentration. The second (ammonium and phosphate) yielded contradictory effects with respect to growth and production. The third (borate and molibdate) inhibited both growth and production, while the fourth (potassium iodide, sulfate, and iron) did not exhibit any significant effects. Through optimization of the concentrations of inorganic salts in the medium, a two stage process of hairy root cultures with different media for growth and production was developed which enabled us to enhance the volumetric yield of catharanthine up to 60.5 mg/l. This productivity was 5.4 times higher than that of a one stage culture in the original SH medium.     

The effect of temperature on hairy root cultures of Catharanthus roseus: Growth,indole alkaloid accumulation and membrane lipid composition

Cultivation of Catharanthus roseus hairy root cultures at different temperatures was found to have an effect on growth rate and indole alkaloid content as well as lipid composition. When lowering the temperature, the roots responded by increasing the degree of unsaturation of cellular lipids, which was mainly due to an increased proportion of linolenic acid in the main lipid classes. The modifications in lipid composition were obviously necessary for the roots to retain the proper cell membrane fluidity at each temperature. Despite of changes in membrane lipids, no effect on the distribution of indole alkaloids between the roots and the medium could be detected. Instead, the level of alkaloid accumulation showed a clear increase with lowering temperature.Abbreviations PC phosphatidylcholine - PE phosphatidylethanolamine - PI phosphatidylinositol - PS phosphatidylserine - PG phosphatidylglycerol - CL cardiolipin - DGD digalactosyldiglyceride - MGD monogalactosyldiglyceride - NL neutral lipids - DU degree of fatty acid unsaturation     

Anthocyanins in Catharanthus roseus in vivo and in vitro: a review

The production of anthocyanin in Catharanthus roseus flowers from both field-grown and regenerated by somatic embryogenesis plants and cell cultures was described. The anthocyanins were identified as the 3-O-glucosides, and the 3-O-(6-O-p-coumaroyl) glucosides of hirsutidin, malvidin and petunidin, respectively both in vivo and in vitro. The influence of environmental conditions on in vitro anthocyanin accumulation is described. The relationship between in vivo and in vitro anthocyanin production is discussed.     

A kinetic model of Escherichia coli core metabolism satisfying multiple sets of mutant flux data

In contrast to stoichiometric-based models, the development of large-scale kinetic models of metabolism has been hindered by the challenge of identifying kinetic parameter values and kinetic rate laws applicable to a wide range of environmental and/or genetic perturbations. The recently introduced ensemble modeling (EM) procedure provides a promising remedy to address these challenges by decomposing metabolic reactions into elementary reaction steps and incorporating all phenotypic observations, upon perturbation, in its model parameterization scheme. Here, we present a kinetic model of Escherichia coli core metabolism that satisfies the fluxomic data for wild-type and seven mutant strains by making use of the EM concepts. This model encompasses 138 reactions, 93 metabolites and 60 substrate-level regulatory interactions accounting for glycolysis/gluconeogenesis, pentose phosphate pathway, TCA cycle, major pyruvate metabolism, anaplerotic reactions and a number of reactions in other parts of the metabolism. Parameterization is performed using a formal optimization approach that minimizes the discrepancies between model predictions and flux measurements. The predicted fluxes by the model are within the uncertainty range of experimental flux data for 78% of the reactions (with measured fluxes) for both the wild-type and seven mutant strains. The remaining flux predictions are mostly within three standard deviations of reported ranges. Converting the EM-based parameters into a Michaelis–Menten equivalent formalism revealed that 35% of K_m and 77% of k_cat parameters are within uncertainty range of the literature-reported values. The predicted metabolite concentrations by the model are also within uncertainty ranges of metabolomic data for 68% of the metabolites. A leave-one-out cross-validation test to evaluate the flux prediction performance of the model showed that metabolic fluxes for the mutants located in the proximity of mutations used for training the model can be predicted more accurately. The constructed model and the parameterization procedure presented in this study pave the way for the construction of larger-scale kinetic models with more narrowly distributed parameter values as new metabolomic/fluxomic data sets are becoming available for E. coli and other organisms.     

Synchrony induced by double phosphate starvation in a suspension culture of Catharanthus roseus

A synchronous cell division system was established using the double phosphate starvation method, based on the observation that one of the limiting factors in the growth of a suspension culture of Catharanthus roseus (L.) G. Don cells in the medium of Murashige and Skoog was phosphate. In the system, an increase in cell number took place in a short period of only 4 h, while the cell number remained almost constant during other periods of the cell cycle. The synchrony of the culture was confirmed by changes in mitotic index, which increased sharply prior to the increase in cell number. The S phase was determined by measuring incorporation of [³H]-thymidine into the DNA fraction during the cell cycle and synchrony of DNA synthesis was verified likewise. Synchronization by phosphate starvation is discussed in relation to the function of phosphate as a nutrient. The synchronous system thus established will be useful in biochemical studies of the cell cycle in higher plants.