Xylanase production in solid state fermentation by Aspergillus niger mutant using statistical experimental designs

The initial moisture content, cultivation time, inoculum size and concentration of basal medium were optimized in solid state fermentation (SSF) for the production of xylanase by an Aspergillus niger mutant using statistical experimental designs. The cultivation time and concentration of basal medium were the most important factors affecting xylanase activity. An inoculum size of 5 x 10(5) spores/g, initial moisture content of 65%, cultivation time of 5 days and 10 times concentration of basal medium containing 50 times concentration of corn steep liquor were optimum for xylanase production in SSF. Under the optimized conditions, the activity and productivity of xylanase obtained after 5 days of fermentation were 5,071 IU/g of rice straw and 14,790 IU l(-1) h(-1), respectively. The xylanase activity predicted by a polynomial model was 5,484 IU/g of rice straw.     

白腐菌及黑曲霉所产的纤维素复合酶对稻草秸秆的生物降解

研究了白腐菌及纤维素复合酶对稻草秸秆的协同生物降解。结果表明,利用黄孢原毛平革菌固态发酵稻草秸秆的过程中,LiP和MnP的最大活力可以达到28.3U/g和12.6U/g,同时,秸秆中的木质素能被有效降解,但纤维素、半纤维素降解率较低。添加黑曲霉所产的纤维素复合酶能有效地促进秸秆腐熟程度。在接入白腐菌培养10天后,每克稻草添加3 IU纤维素酶液并酶解48h可以使稻草秸秆中纤维素降解53.8%,半纤维素降解57.8%,木质素降解44.5%,干物质损失46.3%。此时细胞壁出现大范围破损,整个组织变得松散,秸秆完全腐熟。     

Bioconversion of grape must into modulated gluconic acid production by Aspergillus niger ORS-4.410

AIMS: Analysis of regulators for modulated gluconic acid production under surface fermentation (SF) condition using grape must as the cheap carbohydrate source, by mutant Aspergillus niger ORS-4.410. Replacement of conventional fermentation condition by solid-state surface fermentation (SSF) for semi-continuous production of gluconic acid by pseudo-immobilization of A. niger ORS-4.410. METHODS AND RESULTS: Grape must after rectification was utilized for gluconic acid production in batch fermentation in SF and SSF processes using mutant strain of A. niger ORS-4.410. Use of rectified grape must led to the improved levels of gluconic acid production (80-85 g l(-1)) in the fermentation medium containing 0.075% (NH4)2HPO4; 0.1% KH2PO4 and 0.015% MgSO4.7H2O at an initial pH 6.6 (+/-0.1) under surface fermentation. Gluconic acid production was modulated by incorporating the 2% soybean oil, 2% starch and 1% H2O2 in fermentation medium at continuously high aeration rate (2.0 l min(-1)). Interestingly, 95.8% yield of gluconic acid was obtained when A. niger ORS-4.410 was pseudo-immobilized on cellulose fibres (bagasse) under SSF. Four consecutive fermentation cycles were achieved with a conversion rate of 0.752-0.804 g g(-1) of substrate into gluconic acid under SSF. CONCLUSIONS: Use of additives modulated the gluconic acid production under SF condition. Semi-continuous production of gluconic acid was achieved with pseudo-immobilized mycelia of A. niger ORS-4.410 having a promising yield (95.8%) under SSF condition. SIGNIFICANCE AND IMPACT OF THE STUDY: The bioconversion of grape must into modulated gluconic acid production under SSF conditions can further be employed in fermentation industries by replacing the conventional carbohydrate sources and expensive, energy consuming fermentation processes.     

Improved polygalacturonase production from Bacillus sp. MG-cp-2 under submerged (SmF) and solid state (SSF) fermentation

AIMS: To investigate the effect of amino acids, vitamins and surfactants on polygalacturonase production from Bacillus sp. MG-cp-2 under submerged (SmF) and solid state fermentation (SSF). METHODS AND RESULTS: Bacillus sp. MG-cp-2 was isolated from the outer covering of the seeds of Celastrus paniculatus. Out of the various surfactants, amino acids and vitamins, Tween-60, DL-serine and folic acid maximally enhanced polygalacturonase production by 2.7-fold (240.0 U x ml(-1)), 4.0-fold (360.0 U x ml(-1)) and 3.8-fold (342.0 U x ml(-1)) respectively, under submerged fermentation (SmF). In solid state fermentation (SSF), Tween-80, pyridoxine and DL-ornithine monohydrochloride induced highest enzyme production up to 1.73-fold (6956.5 U x g(-1)), 5.3-fold (21224.4 U x g(-1)) and 5.74-fold (23076.9 U x g(-1)), respectively. CONCLUSION: Amino acids and their analogues, vitamins and surfactants effect significantly polygalacturonase production by Bacillus sp. MG-cp-2 when grown under submerged (SmF) and solid state fermentation (SSF) conditions. SIGNIFICANCE AND IMPACT OF THE STUDY: The study provides useful information about regulation of polygalacturonase biosynthesis in Bacillus sp. MG-cp-2, which appears to be an interplay of nutritional and physical factors. Alkaline polygalacturonase from Bacillus sp. MG-cp-2 will be extremely useful in the treatment of alkaline pectic waste waters from vegetable and fruit processing industries and in degumming of bast fibres.     

Thermophilic protease production by Streptomyces sp. 594 in submerged and solid-state fermentations using feather meal

AIMS: Protease production by Streptomyces sp. 594 in submerged (SF) and solid-state fermentation (SSF) using feather meal, an industrial poultry residue, and partial characterization of the crude enzyme. METHODS AND RESULTS: Streptomyces sp. 594 produced proteases in SF (7.2 +/- 0.2 U ml(-1)) and SSF (15.5 +/- 0.41 U g(-1)), with pH increase in both media. Considering protease activity, values obtained in the liquid extract after SSF (6.3 +/- 0.17 U ml(-1)) were lower than those from SF. The proteases, which belong to serine and metalloproteinase classes, were active over a wide range of pH (5.0-10.0) and high temperatures (55-80 degrees C). Strain 594 was also able to degrade feather in agar and liquid media. Keratinase activity (80 U l(-1)) also confirmed the keratin degrading capacity of this streptomycete. CONCLUSIONS: Proteases produced using residues from poultry industry have shown interesting properties for industrial purposes. SIGNIFICANCE AND IMPACT OF THE STUDY: As far as we are concerned, this is the first contribution towards the production of thermophilic protease by a streptomycete in SSF using a keratinous waste.     

Organic acids associated with saccharification of cellulosic wastes during solid-state fermentation

Saccharification of five cellulosic wastes, i.e. rice husks, wheat bran, corn cobs, wheat straw and rice straw by three cellulytic fungi, i.e. Aspergillus glaums MN1, Aspergillus oryzae MN2 and Penicillium purpurogenum MN3, during solid-state fermentation (SSF) was laboratory studied. Rice husks, wheat bran, and corn cobs were selected as inducers of glucose production in the tested fungi. An incubation interval of 10 days was optimal for glucose production. Maximal activities of the cellulases FP-ase, CMC-ase, and p-glucosidase were detected during SSF of rice husks by P. purpurogenum; however, a-amylase activity (7.2 U/g) was comparatively reduced. Meanwhile, the productivities of FP-ase, CMC-ase, and β-glucosidase were high during SSF of rice husks by A glaucus; however, they decreased during SSF of corn cobs by P. purpurogenum. Addition of rock phosphate (RP) (75 mg P₂O₅) decreased the pH of SSF media. (NH₄)₂SO₄ was found to be less inducer of cellulytic enzymes, during SSF of rice husks by A. glaucus or A. oryzae; it also induced phytase production and solubilization of RP. The organic acids associated with saccharification of the wastes studied have also been investigated. The highest concentration of levulinic acid was detected (46.15 mg/g) during SSF of corn cobs by P. purpurogenum. Likewise, oxalic acid concentration was 43.20 mg/g during SSF of rice husks by P. purpurogenum.     

真空微波诱变结合化学诱变选育酸性纤维素酶高产菌株

以酸性纤维素酶产生菌绿色木霉（Trichoderma viride）WL0512作为原始出发菌株,首先经自然分离筛选出一株产酶较稳定的菌株TVN-18,其羧甲基纤维素酶活（CMC酶活）达2765．8U／g,滤纸酶活（FPA酶活）达48．5U／g。再经真空微波和甲基磺酸乙酯（EMS）逐级诱变处理,获得了一株高产、稳产酸性纤维素酶的E6—1菌株,其CMC酶活达4396．6U／g,FPA酶活达126．0U／g,分别是菌株TVN-18的1．59倍和2．60倍。通过对固态发酵培养基麸皮和稻草比例、料水比以及初始pH值的优化,突变株的产酶能力进一步得到提高,其产的CIVIC酶活和FPA酶活分别提高了22．3％和22．4％。     

Improved mannan-degrading enzymes' production by Aspergillus niger through medium optimization

The effect of different carbon and nitrogen sources on the production of mannan-degrading enzymes, focussing on β-mannanase, by Aspergillus niger was investigated using shake flask culture. The β-mannanase activity obtained during growth of A. niger on guar gum (GG, 1495 nkat mL(-1)) was much higher than those observed on other carbon substrates, locust bean gum (1148 nkat mL(-1)), α-cellulose (10.7 nkat mL(-1)), glucose (8.8 nkat mL(-1)) and carboxymethylcellulose (4.6 nkat mL(-1)). For fermentation using GG as a carbon source, bacteriological peptone gave the highest β-mannanase activity (1744 nkat mL(-1)) followed by peptone from meat (1168 nkat mL(-1)), yeast extract (817 nkat mL(-1)), ammonium sulphate (241 nkat mL(-1)), ammonium nitrate (113 nkat mL(-1)) and ammonium chloride (99 nkat mL(-1)) when used as a nitrogen source. The composition of bacteriological peptone and initial pH of the medium were further optimized using response surface methodology (RSM). Medium consisted of 21.3 g L(-1) GG and 57 g L(-1) peptone with initial culture pH of 5.5 was optimum for β-mannanase production (2063 nkat mL(-1)) by A. niger. The β-mannanase production obtained in this study using A. niger was significantly higher than those reported in the literature.     

Spores of Aspergillus niger as reservoir of glucose oxidase synthesized during solid-state fermentation and their use as catalyst in gluconic acid production

AIMS: To exploit conidiospores of Aspergillus niger as a vector for glucose oxidase extraction from solid media, and their direct use as biocatalyst in the bioconversion of glucose to gluconic acid. METHODS AND RESULTS: Spores of A. niger (200 h old) were shown to fully retain all the glucose oxidase synthesized by the mycelium during solid-state fermentation (SSF). They acted as catalyst and carried out the bioconversion reaction effectively, provided they were permeabilized by freezing and thawing. Glucose oxidase activity was found retained in the spores even after repeated washings. Average rate of reaction was 1.5 g l(-1) h(-1) with 102 g l(-1) of gluconic acid produced out of 100 g l(-1) glucose consumed after approx. 100 h reaction, which corresponded to a molar yield close to 93%. These results were obtained with permeabilized spores in the presence of a germination inhibitor, sodium azide. CONCLUSIONS: Spores of A. niger served as efficient catalyst in the model bioconversion reaction after permeabilization. SIGNIFICANCE AND IMPACT OF THE STUDY: To our knowledge, this is the first detailed study on the ability of A. niger spores to act as reservoir of enzyme synthesized during SSF without its release into solid media. Use of this material served as an innovative concept for enzyme extraction and purification from a solid medium. Moreover, this approach could compete efficiently with the conventional use of mycelial form of the fungus in gluconic acid production.     

Statistical optimization of medium components for the production of xylanase byAspergillus niger KK2 in submerged cultivation

Medium composition was optimized for the production of xylanase byAspergillus niger KK2 using statistical experimental designs. Corn steep liquor (CSL) and industrial yeast extract (IYE) were the most important factors affecting xylanase activity. The medium that produced the optimum conditions for the production of xylanase contained 3% rice straw, 1% wheat bran, 6.3% CSL, 0.15% IYE, and 0.5% KH₂PO₄. After 4 days of cultivation under optimized conditions in a 2.5-L stirred tank reactor the activity and productivity of xylanase were 620 IU/mL and 6,458 IU/L.h, respectively. The highest xylanase activity obtained using the optimized medium was 80% greater than the activity obtained using basal medium. The xylanase activity predicted by a polynomial model was 670 IU/ml.     

Over-production of β-glucosidase by Aspergillus niger mutant from lignocellulosic biomass

The maximum yield of -glucosidase by A. niger KK2 mutant, grown on the basal medium for 7 days, was 514 I U g^–1 ground rice straw, and was about twice those obtained from wheat straw or bran by previous researchers. Optimal activity of -glucosidase was at 60–70 °C and pH 4.8.     

Beta-fructofuranosidase production by 2-deoxyglucose resistant mutants of aspergillus niger in submerged and solid-state fermentation

Aspergillus niger produces extracellular beta-fructofuranosidase under submerged (SmF) and solid state fermentation (SSF) conditions. After UV mutagenesis of conidiospores of A. niger, 2-deoxyglucose (10 g/l) resistant mutants were isolated on Czapek's minimal medium containing glycerol as a carbon source and the mutants were examined for improved production of beta-fructofuranosidase in SmF and SSF conditions. One of such mutant DGRA-1 overproduced beta-fructofuranosidase in both SmF and SSF conditions. In SmF, the mutant DGRA-1 showed higher beta-fructofuranosidase productivity (110.8 U/l/hr) than the wild type (48.3 U/l/hr). While in SSF the same strain produced 322 U/l/hr of beta-fructofuranosidase, 2 times higher than that of wild type (154.2 U/l/hr). In SmF, both wild type and mutants produced relatively low level of beta-fructofuranosidase in medium containing sucrose with glucose than from the sucrose medium. However in SSF, the DGRA-1 mutant grown in sucrose and sucrose+ glucose did not show any difference with respect to beta-fructofuranosidase production. These results indicate that the catabolite repression of beta-fructofuranosidase synthesis is observed in SmF whereas in SSF such regulation was not prominent.     

白腐菌液体和固体培养产生木质纤维素降解酶的比较研究

侧耳sp2(Pleurotus sp．2)和粗毛栓菌(Trametes gallica)是产木质纤维素降解酶能力强,且产酶较快的菌株。对其在液体培养基、固体培养基中产生木质纤维素降解酶能力和行为进行了比较分析和研究。结果表明,Pleurotus sp．2在低氮高碳高无机盐培养基中的锰过氧化物酶(Manganese peroxidases, MnPs)、木质素过氧化物酶(Lignin peroxidases．LiPs)、漆酶(laccases,Lacs)和半纤维素酶(Hemicellulases, Hcels)的活性最高。当该菌株培养在含有低氮无碳高无机盐液体培养基的麦草粉中时,MnPs和Lacs的活性峰值均出现在10d,而Hcels的活性在40d时达到峰值。Trametes gallica在高氮低碳高无机盐培养基中的Lacs和LiPs的活性最高,在低氮高碳高无机盐培养基中的MnPs和Hcels的活性最高。当该菌株培养在含有高氮无碳高无机盐和低氮无碳高无机盐液体培养基的麦草粉中时,MnPs存10d、Lacs和Hcels在40d、LiPs存50d,分别达到峰值。Pleurotus sp．2和Trametes gallica在液体培养基中具有很强的木质纤维素降解酶产生能力且产酶速度较快,在固体培养基中具有很强的降解麦秸生物质能力,但这两株菌在液体和固体培养基中,产木质纤维素降解酶的能力和行为都有较大的差异,相关性小。     

Co-cultivation of mutant Penicillium oxalicum SAU(E)-3.510 and Pleurotus ostreatus for simultaneous biosynthesis of xylanase and laccase under solid-state fermentation

Co-cultivation of mutant Penicillium oxalicum SAU(E)-3.510 and Pleurotus ostreatus MTCC 1804 was evaluated for the production of xylanase-laccase mixture under solid-state fermentation (SSF) condition. Growth compatibility between mutant P. oxalicum SAU(E)-3.510 and white rot fungi (P. ostreatus MTCC 1804, Trametes hirsuta MTCC 136 and Pycnoporus sp. MTCC 137) was analyzed by growing them on potato dextrose agar plate. Extracellular enzyme activities were determined spectrophotometrically. Under derived conditions, paired culturing of mutant P. oxalicum SAU(E)-3.510 and P. ostreatus MTCC 1804 resulted in 58% and 33% higher levels of xylanase and laccase production, respectively. A combination of sugarcane bagasse and black gram husk in a ratio of 3:1 was found to be the most ideal solid substrate and support for fungal colonization and enzyme production during co-cultivation. Maximum levels of xylanase (8205.31 ± 168.31 IU g(-1)) and laccase (375.53 ± 34.17 IU g(-1)) during SSF were obtained by using 4 g of solid support with 80% of moisture content. Furthermore, expressions of both xylanase and laccase were characterized during mixed culture by zymogram analysis. Improved levels of xylanase and laccase biosynthesis were achieved by co-culturing the mutant P. oxalicum SAU(E)-3.510 and P. ostreatus MTCC 1804. This may be because of efficient substrate utilization as compared to their respective monocultures in the presence of lignin degradation compounds because of synergistic action of xylanase and laccase. Understanding and developing the process of co-cultivation appears productive for the development of mixed enzyme preparation with tremendous potential for biobleaching.     

湿氧化爆破稻秆的同步糖化发酵条件研究

探讨了木质纤维素经过湿氧化爆破后在同步糖化发酵过程中酵母产乙醇的基本规律.采用单因素方法对湿氧化爆破条件、酶系组成和添加量以及预酶解时间和温度进行了优化.不同湿氧化爆破预处理条件下的稻秆对同步糖化发酵工艺的影响较大,在预处理温度160 ℃,进氧压力为4×105 Pa,碱用量为6%(w/w),反应时间为20 min的条件...     

In vivo enzymatic digestion, in vitro xylanase digestion, metabolic analogues, surfactants and polyethylene glycol ameliorate laccase production from Ganoderma sp. kk-02

AIMS: The effect of in vivo enzymatic digestion (IVED), in vitro xylanase digestion (IVXD), metabolic analogues, surfactants and polyethylene glycol (PEG) on laccase production from Ganoderma sp. kk-02 was studied. METHODS AND RESULTS: An acidic laccase producing Ganoderma sp. kk-02 produced 16.0 U ml(-1) and 365.0 U g(-1) of laccase, when grown under submerged (SmF) and solid state (SSF) fermentation conditions, respectively. Modification of the substrate (wheat bran) molecular architecture by IVED and IVXD increased subsequent laccase production from Ganoderma sp. kk-02 by 1.31-fold (21.0 U ml(-1)) (SmF); 2.21-fold (810.0 U g(-1)) (SSF) and 1.10-fold (18.0 U ml(-1)) (SmF); 1.78-fold (650.0 U g(-1)) (SSF) when compared with untreated wheat bran. Further enhancement in laccase yield under SmF and SSF was obtained when IVED treated wheat bran was used in conjunction with amino acids [DL-tryptophan, 2.66-fold (56.0 U ml(-1)) SmF; 2.86-fold (2324.0 U g(-1)) SSF], vitamins [biotin, 1.71-fold (36.0 U ml(-1)) SmF; 3.06-fold (2483.0 U g(-1)) SSF], surfactants [Tween-40, 1.85-fold (39.0 U ml(-1)) SmF; 2.25-fold (1828.0 U g(-1)) SSF], and PEG [PEG 6000, 1.93-fold (40.0 U ml(-1)) SmF; 1.58-fold (1284.0 U g(-1)) SSF]. CONCLUSIONS: The IVED of substrate (wheat bran) facilitated hyper laccase production in presence of additives from Ganoderma sp. kk-02. SIGNIFICANCE AND IMPACT OF THE STUDY: The study highlights a new methodology viz. IVED for concomitant and economic production of diverse enzymes using the same substrate. The hyper laccase levels obtained could improve the economic competitiveness of environmentally benign processes applied in varied industries. The work also provides an insight into the regulation of complex metabolic pathways governing the expression of extra cellular proteins from white-rot fungi.     

Chitinolytic and chitosanolytic activities from crude cellulase extract produced by A. niger grown on apple pomace through Koji fermentation

Enzyme extracts of cellulase [filter paper cellulase (FPase) and carboxymethyl cellulase (CMCase)], chitinase, and chitosanase produced by Aspergillus niger NRRL-567 were evaluated. The interactive effects of initial moisture and different inducers for FP cellulase and CMCase production were optimized using response surface methodology. Higher enzyme activities [FPase 79.24+/- 4.22 IU/gram fermented substrate (gfs) and CMCase 124.04+/-7.78 IU/gfs] were achieved after 48 h fermentation in solid-state medium containing apple pomace supplemented with rice husk [1% (w/w)] under optimized conditions [pH 4.5, moisture 55% (v/w), and inducers veratryl alcohol (2 mM/kg), copper sulfate (1.5 mM/kg), and lactose 2% (w/w)] (p<0.05). Koji fermentation in trays was carried out and higher enzyme activities (FPase 96.67+/-4.18 IU/gfs and CMCase 146.50+/-11.92 IU/gfs) were achieved. The nonspecific chitinase and chitosanase activities of cellulase enzyme extract were analyzed using chitin and chitosan substrates with different physicochemical characteristics, such as degree of deacetylation, molecular weight, and viscosity. Higher chitinase and chitosanase activities of 70.28+/-3.34 IU/gfs and 60.18+/-3.82 to 64.20+/-4.12 IU/gfs, respectively, were achieved. Moreover, the enzyme was stable and retained 92-94% activity even after one month. Cellulase enzyme extract obtained from A. niger with chitinolytic and chitosanolytic activities could be potentially used for making low-molecular-weight chitin and chitosan oligomers, having promising applications in biomedicine, pharmaceuticals, food, and agricultural industries, and in biocontrol formulations.     

Screening of a fungus capable of powerful and selective delignification on wheat straw

Aims: To screen and characterize a novel fungus with powerful and selective delignification capability on wheat straw. Methods and Results: A fungus capable of efficient delignification under solid‐state fermentation (SSF) conditions on wheat straw was screened. After 5 days of incubation, 13·07% of the lignin was removed by fungal degradation, and 7·62% of the holocellulose was lost. Furthermore, 46·53% of the alkali lignin was removed after 2 days of liquid fermentation. The fungus was identified as Fusarium concolor based on its morphology and an analysis of its 18S rDNA gene sequence. The molecular weight distribution of lignin was evaluated by gel permeation chromatography. Enzyme assay indicated that the fungus produced laccase, cellobiose dehydrogenase, xylanase and cellulase during the incubation period. Intracellular lignin peroxidase, manganese peroxidase and laccase were produced during liquid fermentation. Conclusions: We have successfully screened a fungus, F. concolor, which can efficiently degrade the lignin of wheat straw, with slight damage to the cellulose, after 5 days of SSF. Significance and Impact of the Study: The newly isolated strain could be used in pretreatment of lignocellulose materials prior to biopulping, bioconversion into fuel and substrates for the chemical industry.     

Optimization of phytase production by solid substrate fermentation

The production of phytase by three feed-grade filamentous fungi (Aspergillus ficuum NRRL 3135, Mucor racemosus NRRL 1994 and Rhizopus oligosporus NRRL 5905) on four commonly used natural feed ingredients (canola meal, cracked corn, soybean meal, wheat bran) was studied in solid substrate fermentation (SSF). A. ficuum NRRL 3135 had the highest yield [15 IU phytase activity/g dry matter (DM)] on wheat bran. By optimizing the supplementation of wheat bran with starch and (NH₄)₂SO₄, phytase production increased to 25 IU/g DM. Optimization was carried out by Plackett-Burman and central composite experimental designs. Using optimized medium, phytase, phosphatase, alpha-amylase and xylanase production by A. ficuum NRRL 3135 was studied in Erlenmeyer flask and tray SSF. By scaling up SSF from flasks to stationary trays, activities of 20 IU phytase activity/g DM were reproducibly obtained. Electronic Publication     

Fungal multienzyme production on industrial by-products of the citrus-processing industry

Orange peels is the principal solid by-product of the citrus processing industry and the disposal of the fresh peels is becoming a major problem to many factories. Dry citrus peels are rich in pectin, cellulose and hemicellulose and may be used as a fermentation substrate. Production of multienzyme preparations containing pectinolytic, cellulolytic and xylanolytic enzymes by the mesophilic fungi Aspergillus niger BTL, Fusarium oxysporum F3, Neurospora crassa DSM 1129 and Penicillium decumbens under solid-state fermentation (SSF) on dry orange peels was enhanced by optimization of initial pH of the culture medium and initial moisture level. Under optimal conditions A. niger BTL was by far the most potent strain in polygalacturonase and pectate lyase, production followed by F. oxysporum F3, N. crassa DSM 1129 and P. decumbens. N. crassa DSM 1129 produced the highest endoglucanase activity and P. decumbens the lowest one. Comparison of xylanase production revealed that A. niger BTL produced the highest activity followed by N. crassa DSM 1129, P. decumbens and F. oxysporum F3. N. crassa DSM 1129 and P. decumbens did not produce any beta-xylosidase activity, while A. niger BTL produced approximately 10 times more beta-xylosidase than F. oxysporum F3. The highest invertase activity was produced by A. niger BTL while the lowest ones by F. oxysporum F3 and P. decumbens. After SSF of the four fungi, under optimal conditions, the fermented substrate was either directly exposed to autohydrolysis or new material was added, and the in situ produced multienzyme systems were successfully used for the partial degradation of orange peels polysaccharides and the liberation of fermentable sugars.