Effect of mechanical agitation on hybridoma cell growth

Hybridoma cells (S3H5/2bA2) were grown in spinner flasks at different agitation speeds. It was found that cells in stationary and decline phases of growth were sensitive to shear force caused by agitation but cells in growth phase seemed less sensitive to the shear forces introduced. The death rate was found to be. 0.007 hr^–1 in T flasks but 0.018 hr^–1 and 0.028 hr^–1 at 100 and 200 rpm, respectively, while the growth rate was about 0.05 hr^–1 for all cases.     

Growth of hybridoma cells under different agitation conditions

Summary The effect of mechanical agitation on hybridoma cell growth was examined in laboratory scale vessels. At an agitation rate four times that required to keep the cells in suspension, both growth rate and growth extent were reduced. However, using the minimum agitation rate required to suspend cells, no adverse effect on cell growth was observed even with a turbine agitator.     

植物生长发育中程序性细胞死亡

本文简要介绍了植物细胞凋亡的一些特点以及植物在营养生长和生殖生长过程中发生的细胞凋亡现象。指出细胞凋亡是植物生长发育过程中正常的生理现象。     

Determinants and rate laws of growth and death of hybridoma cells in continuous culture

Experimental data from six hybridoma cell lines grown under diverse experimental conditions in both normal continuous and perfusion cultures are analyzed with respect to the significance of nutrients and products in determining the growth and death rates of cells and with respect to their mathematical modeling. It is shown that neither nutrients (glucose and glutamine) nor the common products lactic acid, ammonia, and monoclonal antibody can be generally assumed to be the clear-limiting or inhibiting factors for most of the cultures. Correspondingly, none of the unstructured models existing in the literature can be generally applied to describe the experimental data obtained over a relatively wide range of cultivation conditions as considered in this work. Surprisingly, for all cultures the specific growth rate (mu) almost linearly correlates with the ratio of the viable cell concentration (NV) to the dilution (perfusion) rate (D). Similarly, the specific death rate (kd) is a function of the ratio of the total cell concentration (Nt) to the dilution (perfusion) rate. These results strongly suggest the formation of not yet identified critical factors or autoinhibitors that determine both the growth and death rates of hybridoma cells. Based on these observations, simple kinetic models are developed for mu and kd which describe the experimental data satisfactorily. Analysis of the experimental data with the kinetic models reveals that under the current cultivation conditions the formation rate of the autoinhibitor(s) or the sensitivity of cell growth and death to the autoinhibitor(s) is mainly affected by the medium composition. Irrespective of the cell lines, cells grown on serum-containing media have almost the same model parameters, which are distinctively different from those of cells grown on serum-free media. Furthermore, in contrast to the prevailing view, kd is shown to positively correlate with mu if the effects of cell concentration and dilution (perfusion) rate are considered. Several important implications of these findings are discussed for the optimization and control of animal cell culture.     

Iron compounds at high concentrations enable hybridoma growth in A protein-free medium

Summary Soluble iron salts at very high concentrations (50 M to 5 mM), substituting for the only indispensable protein transferrin, enable hybridoma growth and monoclonal antibody production in a chemically defined protein-free medium.     

Comparative characterization of cell death between Sf9 insect cells and hybridoma cultures

Physiological cell death (PCD) in Sf9 insect cell batch cultures was comprehensively characterized using simultaneous determinations of qualitative and quantitative assays, including agarose gel electrophoresis, confocal, epifluorescence, and transmission electron microscopy, and DNA content by flow cytometry. Results were compared to hybridoma cultures where abundant information of apoptosis exists. Both cultures shared some typical apoptosis features, including cell shrinkage, loss of sphericity, swollen endoplasmic reticulum and Golgi apparatus, chromatin condensation, and specific DNA degradation. However, distinctive morphological and kinetic differences between both cultures revealed that Sf9 cells died by an atypical PCD process characterized by absence of nuclear fragmentation, scarce association of condensed chromatin to the nuclear envelope, swollen mitochondria, and high nonspecific DNA degradation. These features, distinctive of necrosis, were not observed in the normal apoptotic process of hybridomas. Glucose depletion marked the appearance of apoptotic Sf9 cells, which there up on increased gradually, whereas apoptotic hybridomas rapidly increased upon glutamine depletion. Furthermore, active phagocytosis was found in Sf9 viable cells, a characteristic phenomenon during in vivo apoptosis but uncommon for in vitro cultures. Sf9 cells contained unusually high numbers of phagosomes, particularly after glucose depletion. Additionally, few apoptotic bodies accumulated in culture, suggesting their elimination by phagocytosis. Other distinctive characteristics of Sf9 cells were the presence of a polynucleated hypertrophic population fraction, polyploidy, cell cycle arrest in G2/M phase, and more necrosis compared to hybridomas. Such phenomena prevented a reliable quantification of apoptosis from determination of the sub-G1 peak. Nonetheless, emergence of a bimodal Sf9 cell size distribution coincided with the increase in the sub-G1 population and onset of death. The fraction of particles in the smaller peak (6-11 microm diameter) closely correlated with the fractions of apoptotic bodies, late apoptotic, and secondary necrotic cells. Accordingly, Sf9 cell size was shown to be an effective, rapid, and simple parameter for quantifying death. Altogether, the results of this study provide new insights into PCD and other phenomena in insect cell culture important for biotechnological applications of Sf9 cells.     

Adaptation of hybridoma cells to higher ammonia concentration

Using two mouse-mouse hybridoma cell lines, the response to ammonia step and serial changes was investigated in batch and continuous cultures with serum-free medium. The inhibitory effect of ammonia on cell growth depended on the cultivation mode, and differed markedly between cell lines. The cell line, 4C10B6 producing IgG monoclonal antibody against Pseudomonas, showed a high adaptation ability to ammonia. The 4C10B6 cells could grow under ammonia concentration as high as 21 mmol/l NH₄Cl with a viability of 80% in the continuous culture with serial increase in ammonia concentration. Whereas, in the batch culture with ammonia step change the cell growth completely ceased at 12 mmol/l NH₄Cl. The other cell line, TO-405 producing IgG monoclonal antibody against hepatitis B surface antigen, could not adapt to ammonia, and the cell growth did not occur at 9 mmol/l NH₄Cl even under the ammonia serial change.List of symbols D_Feed d^-1 Dilution rate of fresh feed medium (=F_o/V) - D_Out d^-1 Dilution rate of cell suspension (=F₁/V) - F₁ ml·d^-1 Volumetric discharge rate of cell suspension - F₀ ml·d^-1 Volumetric flow rate of fresh feed medium - k_D h^-1 Specific death rate - P mmol·l^-1 Product concentration - S mmol·l^-1 Substrate concentration in culture broth - S₀ mmol·l^-1 Substrate concentration in feed medium - t d Cultivation time - V ml Working volume of reactor - X₀ cells·ml^-1 Total cell density - X_V cells·ml^-1 Viable cell density - Y_P/S mmol·mmol^-1 Yield of product from substrate - Y_X/S cells·mmol^-1 Yield of cells from substrate - mmol·cell^-1·h^-1 Specific production rate - h^-1 Specific growth rate - mmol·cell^-1·h^-1 Specific consumption rate of substrate     

Effect of low serum concentrations (0%-2.5%) on growth, production, and shear sensitivity of hybridoma cells

In a stirred culture of hybridoma cells, the effects of serum reduction from 2.5% to 0% on growth and monoclonal antibody porduction have been investigated. The shear sensitivity of cells from the same culture has been tested in a bubble column. Serum reduction does not greatly affect viable-cell concentrations, but cell specific monoclonal-antibody production rate shows a decreasing trend. A gradual increase in sensitivity for sparging, which is nor the result of a long-term biological effect, has beeen measured in a bubble column at decreasing fetal calf serum concentrations. Finally, the hypothetical killing-volume model describing the death rate of insect cells in bubble columns has now been completely validated for the pertinent hybridoma-cell line.     

Effects of cell density and glucose and glutamine levels on the respiration rates of hybridoma cells

The effects of cell density as well as the concentration levels of glucose and glutamine on the specific respiration rate of a hybridoma cell line were investigated. The experimental oxygen consumption rate was found to be constant over a wide range of dissolved oxygen levels if the suspension medium contained glutamine. In glutamine-free medium, however, the rate of oxygen consumption decreased slowly with time.In a stationary flask batch culture, the specific respiration rate decreased from about 7 to 2.9 mumol/min per 10(9) cells as the cell density increased exponentially from 1 x 10(5) to 1.2 x 10(6)/mL. To isolate the effect of cell density, cells were re suspended in fresh culture medium so that nutrient concentrations were the same for all experiments. The specific respiration rate decreased with increasing cell density in the same manner as in the stationary flask culture, falling from 8 to 4 mumol/min per 10(9) cells as the cell density increased from 10(5) to 10(6) cells/mL, then declining to 2 mumol/min per 10(9) cells when the cell density reached 10(7) cells/mL.Cells suspended in Hanks balanced sale solution (HBSS) were used to elucidate the effect of glucose and glutamine levels on respiration. The addition of glucose in concentrations of 0.25, 0.50, and 0.75 g/L had no observable effect on the specific oxygen uptake rate; however, a glucose concentration of 1 g/L reduced the uptake rate by 22%. Glutamine in a concentration of 0.30 g/L increased the specific respiration rate in HBSS containing 0 and 1 g/L glucose by approximately 13%.     

hsp82 is an essential protein that is required in higher concentrations for growth of cells at higher temperatures.

hsp82 is one of the most highly conserved and abundantly synthesized heat shock proteins of eucaryotic cells. The yeast Saccharomyces cerevisiae contains two closely related genes in the HSP82 gene family. HSC82 was expressed constitutively at a very high level and was moderately induced by high temperatures. HSP82 was expressed constitutively at a much lower level and was more strongly induced by heat. Site-directed disruption mutations were produced in both genes. Cells homozygous for both mutations did not grow at any temperature. Cells carrying other combinations of the HSP82 and HSC82 mutations grew well at 25 degrees C, but their ability to grow at higher temperatures varied with gene copy number. Thus, HSP82 and HSC82 constitute an essential gene family in yeast cells. Although the two proteins had different patterns of expression, they appeared to have equivalent functions; growth at higher temperatures required higher concentrations of either protein. Biochemical analysis of hsp82 from vertebrate cells suggests that the protein binds to a variety of other cellular proteins, keeping them inactive until they have reached their proper intracellular location or have received the proper activation signal. We speculate that the reason cells require higher concentrations of hsp82 or hsc82 for growth at higher temperatures is to maintain proper levels of complex formation with these other proteins.     

Rapamycin reduces hybridoma cell death and enhances monoclonal antibody production

Rapamycin was used as a medium additive to slow the progression of CRL 1606 hybridomas through the cell cycle, under the hypothesis that such a modulation might reduce cell death. Cell cycle distributions for CRL hybridomas in the G1 phase of the cell cycle ranged from 20% to 35% during batch, fed-batch, and continuous culture experiments, independent of culture time, dilution rate, growth rates, or death rates. Rapamycin, an mTOR signaling inhibitor, immunosuppressant, and G1-phase arresting agent, was identified and tested for efficacy in restraining cell cycle progression in CRL 1606 hybridoma cultures. However, in the presence of 100 nM rapamycin, the percentage of cells in the G1 phase of the cell cycle during fed-batch cultures was only increased from 28% to 31% in control cultures to 37% to 48% for those with rapamycin. Accordingly, rapamycin only slightly reduced culture growth rate. Instead, the use of rapamycin more notably kept viability higher than that of control cultures by delaying cell death for 48 h, thereby enabling viable proliferation to higher maximum viable cell densities. Furthermore, rapamycin enhanced specific monoclonal antibody production by up to 100% during high-viability growth. Thus, over the course of 6-day fed-batch cultivations, the beneficial effects of rapamycin on viable cell density and specific productivity resulted in an increase in final monoclonal antibody titer from 0.25 to 0.56 g/L (124%). As rapamycin is reported to influence a much broader range of cellular functions than cell cycle alone, these findings are more illustrative of the influence that signal transduction pathways related to mTOR can have on overall cell physiology and culture productivity.     

Correlation between steady-state cell concentration and cell death of hybridoma cultures in chemostat

In the present study, the steady-state cell density (X) of chemostat cultures of murine hybridoma was varied by the concentration of glucose and glutamine in culture medium and the dissolved oxygen partial pressure. Except at low glutamine and low oxygen levels, the specific death rate (k(d)) of the cultures was found to decrease with increasing dilution rate (D). However, the plot of k(d) vs. X/D yielded linear relation, which suggests that cell death was due to a non-growth-linked inhibitory product of the cells. The k(d) value measured at low glutamine and low oxygen levels remained practically unchanged over a wide range of D between 0.020 and 0.029 h(-1). The k(d) for low oxygen cultures was always lower than the values obtained in low glucose and low glutamine cultures. A low-molecular-weight component of possibly less than 3000 MW was detected to be cell-death-inducing in the supernatant of exponentially growing cultures. It was neither lactate nor ammonium. The autoinhibitor was not cell-line specific. (c) 1995 John Wiley & Sons, Inc.     

Bacterial immobilization and remineralization of N at different growth rates and N concentrations

An experiment was designed to resolve two largely unaddressed questions about the turnover of N in soils. One is the influence of microbial growth rate on mobilization and remineralization of cellular N. The other is to what extent heterotrophic immobilization of NO(3)(-) is controlled by the soil concentration of NH(4)(+). Bacteria were extracted from a deciduous forest soil and inoculated into an aqueous medium. Various N pool dilution/enrichment experiments were carried out to: (1) calculate the gross N immobilization and remineralization rates; (2) investigate their dependence on NH(4)(+)and NO(3)(-) concentrations; (3) establish the microbial preference for NH(4)(+)and NO(3)(-) depending on the NH(4)(+)/NO(3)(-) concentration ratio. Remineralization of microbial N occurred mainly at high growth rates and NH(4)(+) concentrations. There was a positive correlation between NH(4)(+) immobilization and remineralization rates, and intracellular recycling of N seemed to be an efficient way for bacteria to withstand low inorganic N concentrations. Thus, extensive remineralization of microbial N is likely to occur only when environmental conditions promote high growth rates. The results support previous observations of high NO(3)(-) immobilization rates, especially at low NH(4)(+) concentrations, but NO(3)(-) was also immobilized at high NH(4) concentrations. The latter can be understood if part of the microbial community has a preference for NO(3)(-) over NH(4)(+).     

Kinetic analysis of hybridoma cell culture in a protein-free medium: Substrate and agitation effects

A kinetic study of a hybridoma cell line that produces monoclonal antibodies against lactoferrin was carried out. A well defined protein-free culture medium was employed to facilitate the subsequent purification of the monoclonal antibodies. It should be highlighted that most of the existing work has been carried out employing culture media enriched with fetal bovine serum (FBS). Cell growth and monoclonal antibody production were monitored and kinetic parameters were determined. Besides, fundamental nutrients such as glucose and glutamine, inhibitory products such as ammonium and lactate, and several amino acids were followed throughout the culture. Additional experiments were carried out supplementing the medium with glutamine and ammonium, none of them resulting the key compound that halted the cell growth under the tested conditions and an unstructured model can be used to describe the system. Finally, agitation of the culture by a rocker set-up has shown high values of the specific death rate.     

Inhibition of lymphoid cell growth by a lipid-like component of macrophage hybridoma cells

Previous studies have shown that plasma membranes of murine lymphocytes and lymphoid tumor cells can reversibly inhibit the growth of both normal and transformed lymphocytes. The inhibitor can be extracted with organic solvents and has properties consistent with it being a lipid or lipid-like component of the membrane. This report identifies a series of cloned macrophage hybridoma cell lines, obtained by fusion of splenic adherent cells and the P388D1 line, which have very high levels of lipid-like growth-inhibitory molecules. Furthermore, a survey of seven cloned lines indicated that the macrophages fell into two distinct groups with regard to their level of growth-inhibitory activity. Group 1 lines had little or no inhibitory activity when cells were examined for their effect on a B lymphocyte proliferative response. Organic extracts from these macrophages had inhibitory activity (on a per cell basis) comparable to that seen with extracts of the P388D1 parental cell line and lymphoid tumor cells. In contrast, relatively low numbers of Group 2 macrophages could profoundly inhibit B macrophage proliferation. The growth-inhibitory activity was quantitatively recovered in organic extracts of the macrophages. Although the precise nature of the lipid moiety remains undefined, the data argue against the involvement of oxidized cholesterol. These findings indicate that lipid-like inhibitors of cell growth are present and functional in these macrophage cell lines. In addition, the results demonstrate that the inhibitory activity found in plasma membranes and liposomes is present and active in the membranes of intact cells, which is in contrast to the possibility that the inhibitor is an artifact generated during subcellular fractionation. Thus, the inhibitor is likely to have a physiologic role in growth control and in macrophage-mediated immunoregulation, probably acting via a mechanism involving cell-cell contact.     

The effect of light direction and suspended cell concentrations on algal biofilm growth rates

Algae biofilms were grown in a semicontinuous flat plate biofilm photobioreactor to study the effects of light direction and suspended algal cell populations on algal biofilm growth. It was determined that, under the growth conditions and biofilm thicknesses studied, light direction had no effect on long-term algal biofilm growth (26 days); however, light direction did affect the concentration of suspended algal cells by influencing the photon flux density in the growth medium in the photobioreactors. This suspended algal cell population affected short-term (7 days) algae cell recruitment and algal biofilm growth, but additional studies showed that enhanced suspended algal cell populations did not affect biofilm growth rates over the long term (26 days). Studying profiles of light transmittance through biofilms as they grew showed that most of the light became attenuated by the biomass after just a few days of growth (88 % after 3 days). The estimated biofilm thicknesses after these few days of growth were approximately 150 μm. The light attenuation data suggests that, although the biofilms grew to 700–900 μm, under these light intensities, only the first few hundred micrometers of the biofilm is receiving enough light to be photosynthetically active. We postulate that this photosynthetically active layer of the biofilm grows adjacent to the light source, while the rest of the biofilm is in a stationary growth phase. The results of this study have implications for algal biofilm photobioreactor design and operation.     

A serum substitute for fed-batch culturing of hybridoma cells

We developed a substitute for serum to produce fed-batch cultures of hybridoma cells in serum-free medium and confirmed that the cells could be successfully cultivated this way. Our substitute consisted of 12 components. The specific production rates of lactate and ammonia, which are harmful byproducts from the cells, were significantly reduced compared with a conventional serum-containing batch culture. This reduction led to a higher cell concentration and a longer production lifetime. As a result, the final concentration of monoclonal antibody was 400 mg/L, or five times greater than that in the conventional serum-containing batch culture. The developed substitute is expected to enable fed-batch cultivation in a serum-free condition.     

Dual effect of nerve growth factor on cell death of PC12 cells Induced by serum deprivation

The effect of nerve growth factor (NGF) on the cell death of PC12 cells that is induced by serum deprivation was examined in the floating and attached cells to the extracellular matrix. NGF suppressed cell death occurred in the floating cells. The onset of cell death in the attached cells was much slower than in the floating cells. Moreover, the cell death in the attached cells was either accelerated in a high-density culture (over approximately 50% confluent), or inhibited in a low-density culture by NGF. While nucleosomal DNA fragmentation and poly (ADP-ribose) polymerase degradation was observed in both the floating and attached cells, the incidence of nuclear fragmentation and chromatin condensation was much lower in the attached cells than in the floating cells. The delayed onset of cell death in the attached cells was due to the signals that are generated from the extracellular matrix that is formed by PC12 cells, together with cell-to-cell interaction. The acceleration of cell death in the NGF-treated cells was anoikis, caused by the loss of the anchorage of the cell via the action of increased activities of matrix metalloproteinases (MMP2, MMP9). These results suggest that NGF has a different role in the cell death of PC12 cells that is induced by serum deprivation, depending on the cell-matrix, as well as the cell-cell interaction.     

Mechanical agitation of hybridoma suspension cultures: Metabolic effects of serum, pluronic F68, and albumin supplements

Metabolic effects of the medium supplements, fetal bovine serum (FBS), Pluronic F68, and bovine serum albumin (BSA) were compared for agitated bioreactor cultures of hybridoma cells. Agitation speeds up to 600 rpm, without entrainment of gas bubbles by sparging or vortex formation, allowed examination of cell interactions with turbulent fluid forces. For cultures in FBS-supplemented RPMI media, there was no significant effect of intense turbulent fluid shear on cell growth, metabolism, or antibody, production. Serum-free cultures (Pluronic F68 or BSA supplements) at 600 rpm demonstrated greatly increased glycolysis rates during exponential growth relative to controls. Nutrient limitations caused increased rates of decline of the viable cell concentrations and a reduction in final antibody titers by around 70%. The Pluronic F68 and BSA supplements did not lead to cell protection by modifying metabolism under conditions of intense turbulent fluid shear. Supplementing the protein-free medium with FBS reduced glycolysis rates in exponential growth phase, but this did not prevent a high rate of viable cell decline and low antibody titers. We concluded that FBS does not have a metabolic effect on cells subjected to intense turbulent fluid shear. Although the agitation conditions employed in this study were more intense than generally required for agitated bioreactor culture of hybridomas, we have demonstrated the importance of considering metabolic effects of turbulent fluid forces on cultures using nutrient-rich basal media, in addition to the considerations of gas bubble effects described by other workers. (c) 1992 John Wiley & Sons, Inc.