蝙蝠蛾拟青霉菌丝体发酵的研究

用20t发酵罐培养蝙蝠蛾拟青霉。菌粉收率达2．5％,D-甘露醇含量大于8％,腺苷含量大于0．2％．对发酵过程中pH、总糖、还原糖、得率、折光等的变化规律进行了考察．确定以发酵液pH的升高和还原糖含量作为综合判断发酵终点的依据．     

蝙蝠蛾拟青霉菌丝体化学成分的研究

应用梯度提取、反复重结晶及硅胶色谱法分离和纯化,采用NMR等谱学方法鉴定结构对蝙蝠蛾拟青霉(Paecilomyces hepiali)菌丝体进行了化学成分的分析。从蝙蝠蛾拟青霉菌丝体中分离得到6个化合物,分别鉴定为4,6,8(14),22(23)-四烯-3-酮-麦角甾烷(1)、麦角甾醇(2)、β-谷甾醇(3)、麦角甾醇过氧化物(4)、啤酒甾醇(5)、甘露醇(6)和1-油酰基-2-亚油酸-3-棕榈酸甘油(7),并对其石油醚提取物中的油状组分进行GC-MS分析,结果表明其中主要为亚油酸(9,12-十八碳二烯酸,含量41.949%)、反油酸(反9-十八碳烯酸,含量为27.696%);同时采用高效液相色谱法测定其中的麦角甾醇的含量,与海鲜菇、杏鲍菇、香菇、金针菇、滑子蘑、平菇等食用菌子实体比较,结果蝙蝠蛾拟青霉菌丝体中麦角甾醇含量为15.65 mg/g,平菇为21.43 mg/g,杏鲍菇为10.16 mg/g,香菇为13.34 mg/g,金针菇为9.48 mg/g,滑子蘑为10.43 mg/g,海鲜菇为14.42 mg/g。     

古尼拟青霉和蝙蝠蛾拟青霉发酵菌丝体挥发性成分的分析与比较

对蝙蝠蛾拟青霉Paecilomyces hepiali和古尼拟青霉P. gunnii菌丝体的挥发性成分进行了研究,采用同时蒸馏萃取法分别提取两种菌丝体中的挥发性成分,经GC-MS联用仪对挥发性成分进行分离鉴定,分别分析出25种和32种挥发性成分。在蝙蝠蛾拟青霉菌丝体挥发性成分中2,6-二叔丁基对甲酚和1,5-二氢-1-甲基-2H-吡咯-2-酮相对含量较高,分别占65.78%和12.77%;在古尼拟青霉菌丝体中挥发性成分2,6-二叔丁基对甲酚和(E,E)-2,4-癸二烯醛相对含量较高,分别占62.11%和12.32%。两种菌丝粉共有8种共有成分,分别占蝙蝠蛾拟青霉挥发性成分的71.58%,古尼拟青霉挥发性成分的69.67%;由此可见蝙蝠蛾拟青霉和古尼拟青霉菌丝体主要挥发性物质的成分是相同的。通过对蝙蝠蛾拟青霉和古尼拟青霉挥发性成分的研究,为我们进一步了解这两种真菌菌丝体的药理作用提供了实验依据。     

蝙蝠蛾拟青霉发酵滤液的成分组成与急性毒性分析

蝙蝠蛾拟青霉是从新鲜的冬虫夏草上分离获得的虫草菌,可采用生物发酵制备大量菌丝体。该菌丝体具有和冬虫夏草相似的活性成分,具有抗肿瘤、抗病毒等多种功效。本研究对干燥后的蝙蝠蛾拟青霉发酵滤液的主要成分进行了分析,结果显示：干燥后的蝙蝠蛾拟青霉发酵滤液含粗脂肪21.33%,总蛋白27.34%,水解氨基酸16.79%,粗多糖11.16%,不饱和脂肪酸71.21%,其中以油酸、亚油酸为主;该干燥发酵滤液中还含有多种核苷类物质、多糖等生物活性成分以及多种人体必需的矿质元素。此外急性毒性实验的初步结果表明：小鼠在实验期内无死亡现象和明显的中毒反应,主要脏器的形态学正常;谷草转氨酶（AST）和谷丙转氨酶（ALT）活性与对照组相比无统计学差异。蝙蝠蛾拟青霉发酵滤液有望在医药和保健领域进一步研究开发。     

不同品种大豆培养基对蝙蝠蛾拟青霉菌丝体代谢成分的影响

以不同品种大豆为培养基对蝙蝠蛾拟青霉代谢成分影响进行研究,筛选出最佳大豆品种,为蝙蝠蛾拟青霉标准化生产提供参考。首先对15个不同大豆品种培养基的主成分含量进行测定,同时对各品种大豆培养基培养的蝙蝠蛾拟青霉菌丝体生物量、菌丝体腺苷含量及腺苷总量进行测定。采用非靶向代谢组学方法对不同品种大豆培养基培养的蝙蝠蛾拟青霉菌丝体中的代谢成分进行研究。结果表明,15个不同品种大豆豆饼中的粗蛋白和粗脂肪含量以及对应培养基培养的蝙蝠蛾拟青霉菌丝体腺苷含量均有显著性差异(P<0.05),其中9号品种大豆培养基培养的菌丝体腺苷含量最高为(1 089.35±25.51) mg/kg, 5号的最低为(60.68±9.56) mg/kg, 5号、9号和10号培养的菌丝体之间存在显著性差异(P<0.05)。代谢组学研究表明,5号、9号和10号菌丝体代谢成分相对含量差异较大。其中9号菌丝体丙氨酸、谷氨酸、天冬氨酸等氨基酸,水苏糖、半乳糖等糖类,以及三羧酸循环产物2-氧代丁酸、柠檬酸等代谢物相对含量显著高于5号和10号菌丝体。KEGG富集分析表明,9号培养基通过促进天冬氨酸及谷氨酸代谢通路,可增加天冬氨酸和...     

响应面法优化蝙蝠蛾拟青霉发酵培养基配方

为了提高虫草无性型蝙蝠蛾拟青霉(Paecilomyces hepiali)菌丝体中的腺苷含量,采用响应面法对其液体发酵培养基配方进行了优化。首先采用Plackett-Burman设计法对影响蝙蝠蛾拟青霉腺苷收率的8个相关因素进行了筛选,从中确定其主要影响因子为马铃薯和蚕蛹粉。然后用最陡爬坡试验逼近上述2个因素的最大响应区域,并通过中心组合设计和响应面分析法,确定了主要影响因子的最佳浓度。优化后的培养基组成为:马铃薯8.25%,蔗糖1%,玉米粉1%,蛋白胨0.5%,蚕蛹粉0.81%,KH2PO40.1%,MgSO4.7H2O 0.1%,(NH4)2 SO40.1%。该配方所产生的蝙蝠蛾拟青霉菌丝体中腺苷含量由优化前的2.15 mg/g(干重)提高到3.44 mg/g(干重)。     

蝙蝠蛾拟青霉液体发酵工艺优化及菌丝体腺苷含量的检测

通过摇瓶液体培养的方法,以菌丝体生物量为主要考察指标,筛选蝙蝠蛾拟青霉PH-2菌株液体发酵的培养基成分和条件。进一步采用正交试验,以菌丝体生物量和腺苷含量为联合指标,确定PH-2菌株液体发酵高产菌丝体和腺苷的培养基配方。通过试验获得的最佳配方为：玉米淀粉40g/L,葡萄糖5g/L,玉米浆25g/L,硫酸镁·7H₂O 1g/L,磷酸二氢钾1g/L,硫酸锌1.5g/L,维生素B1 25mg/L;培养条件为：初始pH 6.0,装液量150mL/500mL,接种量8%（V/V）,温度26℃,转速120r/min,培养7d。在该工艺下,菌丝体生物量达到25.2g/L。应用高效液相色谱（HPLC）法,检测到菌丝体中腺苷含量为2.76mg/g。该方法简便、快速、准确,可作为蝙蝠蛾拟青霉菌丝体或其相关产品中腺苷的检测手段。本工艺的优化试验获得了较高的菌丝体收率,菌丝体质量良好。     

中国被毛孢和蝙蝠蛾拟青霉小鼠免疫功能调节作用的比较

目的观察中国被毛孢和蝙蝠蛾拟青霉对小鼠免疫功能的影响。方法分别给予中国被毛孢和蝙蝠蛾拟青霉后,测定观察对小鼠碳粒廓清功能、迟发性变态反应、溶血素抗体、淋巴细胞增殖和NK细胞活性等的影响。结果3．0g／kg中国被毛孢和蝙蝠蛾拟青霉可显著提高小鼠吞噬指数和半数溶血值（P〈0．01）、显著提高T、B淋巴细胞增殖能力（P〈0．01,P〈0．05）、显著提高NK细胞活性（P〈0．05）,0．5～1．5g／kg中国被毛孢都能显著抑制小鼠耳廓肿胀（P〈0．01,P〈0．05）,同时还能抑制脾脏和胸腺增大（P〈0．01,P〈0．05）。结论中国被毛孢和蝙蝠蛾拟青霉均具有免疫调节作用,而中国被毛孢免疫抑制及增强天然免疫系统作用要优于蝙蝠蛾拟青霉,而对适应性免疫系统增强作用蝙蝠蛾拟青霉优于中国被毛孢。     

CLSI M38-A2肉汤稀释法对蝙蝠蛾拟青霉(Paecilomyces hepiali)的药敏检测

[目的]对保健食品生产菌株蝙蝠蛾拟青霉(Paecilomyces hepiali)进行6种常见抗真菌药物:伊曲康唑、酮康唑、伏立康唑、环吡酮胺、5-氟胞嘧啶、氟康唑的药敏检测.[方法]参考美国国家临床实验室标准化委员会CLSI M38-A2《肉汤稀释法抗真菌药敏试验参考方案》.[结果]质控菌株MIC值均在参考范围之内,蝙蝠蛾拟青霉(P.hepiali)对以上6种药物的MIC值分别为1 mg/L、0.5 mg/L、0.25 mg/L、≥128 mg/L、64 mg/L、2 mg/L.[结论]M38-A2方案适合用来测定蝙蝠蛾拟青霉(P.hepiali)对抗真菌药物的敏感性,但获得菌株耐药敏感性的判别标准,仍需进一步的试验数据.     

拟青霉属的一个新种

从湖南省桃江县采集的亚香棒虫草(Cordyceps hawkesii Gray)的新鲜子座、单子囊孢子及其寄主,一种蝙蝠蛾(Hepialus sp.)的僵死幼虫,培养获得拟青霉属的一个新种,命名为霍克斯拟青霉(Paecilomyces hawkesii Xiao,T.B.Li et Q.T.Chen,sp.nov.)。本文报道该菌的形态学特征及其与近缘种肉色拟青霉(P.carneus)的关系,并认为它可能是亚香棒虫草的无性阶段。     

液态发酵豆粕制备纳豆激酶方法的优化

纳豆激酶是一种丝氨酸蛋白酶,具有很强的纤溶活性,由于具有安全性好、作用迅速持久、成本低等优点,适合用于开发新一代的溶栓剂或保健食品,具有广阔的市场前景。本研究探讨了以豆粕为原料液态发酵豆粕生产纳豆激酶的发酵方法。首先通过单因素实验发现影响产酶的主要因素有接菌量、发酵时间、培养基pH及豆粕含量,再由正交实验得到最优组合为接菌量1%,豆粕含量2%,pH为7.0,发酵时间48h,该条件下发酵酶活力最高达到4 429.6U/mL。本研究确定了以豆粕为原料制备纳豆激酶的最佳条件,为豆粕的合理使用和纳豆激酶的工业化生产提供了实验依据。     

蝙蝠蛾拟青霉菌Cs-4菌株对腺嘌呤造成肾脏和睾丸损伤的恢复作用

本文用腺嘌呤建立肾脏和睾丸损伤的小鼠模型,探索蝙蝠蛾拟青霉菌Cs-4菌株对腺嘌呤造成的肾脏和睾丸损伤的恢复作用。将小鼠随机分为空白组、模型组和蝙蝠蛾拟青霉菌Cs-4菌粉的5个剂量组（350mg/kg、550mg/kg、750mg/kg、1 500mg/kg、3 000mg/kg）,连续给予相应药物21d,对各组小鼠的肾脏、睾丸通过HE染色、Masson染色,进行组织病理学检查,测定各组小鼠血清中尿素氮（BUN）、肌酐（Cr）、促卵泡刺激素（FSH）、黄体生成素（LH）含量,测定睾丸组织匀浆中的酸性磷酸酶（ACP）、琥珀酸脱氢酶（SDH）和乳酸脱氢酶（LDH）水平。结果表明,蝙蝠蛾拟青霉菌Cs-4菌株具有使小鼠体重逐渐恢复上升趋势、使受损的肾脏和睾丸组织结构恢复的作用,能使BUN、Cr、FSH、LH、ACP、SDH和LDH水平趋于正常化。     

Effect of extrusion on trypsin inhibitor activity and nutrient digestibility of diets based on fish meal,soybean meal and white flakes

Abstract

The effects of moist extrusion processing of diets containing fish meal (FM) and conventional defatted soybean meal (SBM) or untoasted defatted soybean meal (white flakes [WF]) on amino acid composition, trypsin inhibitor activity (TIA), and apparent total tract digestibility of nutrients were studied. Three diets with the nutritional characteristics of feeds for salmonid fish were formulated: one control based on FM as protein source and two others where 40% of total amino acids from FM were substituted by either SBM or WF. Each diet was fed to mink either as an unextruded mixture of the ingredients or as extruded pellets in order to determine the effect of extrusion processing. Extrusion did not change the amino acid composition of the diets significantly, but reduced the TIA of both diets containing soy products by approximately 76%. Intake of the unextruded WF diet was only one-third compared with the other diets. The dry matter concentration in faeces from mink fed diets containing soy products was significantly lower than in mink fed the FM diet. Digestibility of crude protein, all amino acids and fat was lower, but starch higher, in the unextruded WF diet than in the FM and SBM diets, whereas no significant differences were found among the extruded diets. Extrusion of the WF diet increased digestibility of protein and all amino acids. The greatest increase in digestibility after extrusion of the WF diet was observed for cysteine followed by tryptophan. Extrusion of the FM and SBM diets had no significant effect on amino acid digestibility. Digestibility of starch was, in general, increased by extrusion. It is concluded that the heat treatment involved in typical moist extrusion processing used for fish feed may be sufficient to inactivate most of the TIA in unheated soybean meal, and to increase digestibility of the protein in WF to approximately the same level as found for SBM and FM. Still, extrusion is a lenient process with minor effects on nutrient digestibility of diets containing fish meal or toasted soybean meal as major protein sources.     

Nutrient intake,rumen fermentation and growth performance of dairy calves fed extruded full-fat soybean as a replacement for soybean meal

The objective of this study was to investigate the effects of extruded full-fat soybean (ESB) as a replacement for soybean meal (SBM) on nutrient intake, rumen fermentation, and growth performance of dairy calves. A total of 45 male Holstein dairy calves (42.0±0.5 kg of BW) were randomly assigned to one of three experimental diets: (1) 0% ESB (Control): 35.3% SBM no ESB; (2) 25% ESB: 27.0% SBM+9.0% ESB; and (3) 50% ESB: 19.0% SBM+19.0% ESB. All calves were weaned on day 56 of age and remained in the study until day 70 of age. During the pre-weaning and overall periods, substituting of SBM with ESB had no effect on intake of starter feed, metabolizable energy (ME), CP and non-fiber carbohydrate (NFC). Compared with the control, 50% ESB resulted in a decrease in starter feed intake, and intakes of other nutrients including CP, NFC and ME during the post-weaning period. Substituting SBM with ESB decreased intake of C16 : 0 and increased intakes of n-9 C18 : 1, n-6 C18 : 2 and n-3 C18 : 3 during the pre-weaning, post-weaning and overall periods. Using ESB as a replacement for SBM did not affect average daily gain, feed efficiency, rectal temperature and fecal score over the trial periods. Compared with control, the rumen concentration of NH₃-N decreased for 50% ESB on days 35 and 56 of age but not when compared with 25% ESB. Rumen pH, total volatile fatty acids concentrations, and the molar proportions of ruminal acetate, propionate and butyrate were not different among treatments. Body measurements were not affected by the treatments. In conclusion, substitution of SBM with ESB may improve nitrogen utilization efficiency in dairy calves but slightly reduce post-weaning starter intake with no negative outcomes on growth performance and rumen fermentation.     

Effects of fermented soybean meal on carbon and nitrogen metabolisms in large intestine of piglets

Fermented soybean meal (FSM), which has lower anti-nutritional factors and higher active enzyme, probiotic and oligosaccharide contents than its unfermented form, has been reported to improve the feeding value of soybean meal, and hence, the growth performance of piglets. However, whether FSM can affect the bacterial and metabolites in the large intestine of piglets remains unknown. This study supplemented wet-FSM (WFSM) or dry-FSM (DFSM) (5% dry matter basis) in the diet of piglets and investigated its effects on carbon and nitrogen metabolism in the piglets’ large intestines. A total of 75 41-day-old Duroc×Landrace×Yorkshire piglets with an initial BW of 13.14±0.22 kg were used in a 4-week feeding trial. Our results showed that the average daily gain of piglets in the WFSM and DFSM groups increased by 27.08% and 14.58% and that the feed conversion ratio improved by 18.18% and 7.27%, respectively, compared with the control group. Data from the prediction gene function of Phylogenetic Investigation of Communities by Reconstruction of Unobserved States (PICRUSt) based on 16S ribosomal RNA (rRNA) sequencing showed that carbohydrate metabolism function families in the WFSM and DFSM groups increased by 3.46% and 2.68% and that the amino acid metabolism function families decreased by 1.74% and 0.82%, respectively, compared with the control group. These results were consistent with those of other metabolism studies, which showed that dietary supplementation with WFSM and DFSM increased the level of carbohydrate-related metabolites (e.g. 4-aminobutanoate, 5-aminopentanoate, lactic acid, mannitol, threitol and β-alanine) and decreased the levels of those related to protein catabolism (e.g. 1,3-diaminopropane, creatine, glycine and inosine). In conclusion, supplementation with the two forms of FSM improved growth performance, increased metabolites of carbohydrate and reduced metabolites of protein in the large intestine of piglets, and WFSM exhibited a stronger effect than DFSM.