Development of a Biofilm Production-Deficient Escherichia coli Strain as a Host for Biotechnological Applications

Bacteria form biofilms by adhering to biotic or abiotic surfaces. This phenomenon causes several problems, including a reduction in the transport of mass and heat, an increase in resistance to antibiotics, and a shortening of the lifetimes of modules in bioindustrial fermentors. To overcome these difficulties, we created a biofilm production-deficient Escherichia coli strain, BD123, by deleting genes involved in curli biosynthesis and assembly, Δ(csgG-csgC); colanic acid biosynthesis and assembly, Δ(wcaL-wza); and type I pilus biosynthesis, Δ(fimB-fimH). E. coli BD123 remained mostly in the form of planktonic cells under the conditions tested and became more sensitive to the antibiotics streptomycin and rifampin than the wild-type E. coli MG1655: the growth of BD123 was inhibited by one-fourth of the concentrations needed to inhibit MG1655. In addition, the transformation efficiency of BD123 was about 20 times higher than that of MG1655, and the production and secretion of recombinant proteins were ~16% and ~25% greater, respectively, with BD123 than with MG1655. These results indicate that the newly created biofilm production-deficient strain of E. coli displays several key properties that substantially enhance its utility in the biotechnology arena.     

丁醇合成途径关键酶基因在大肠杆菌中的克隆和表达

【目的】克隆丙酮丁醇梭状芽胞杆菌(Clostridium acetobutylicum)ATCC824丁醇合成途径关键酶基因,构建产丁醇的工程大肠杆菌。【方法】以C.acetobutylicum ATCC824基因组为模板,分别扩增丁醇合成途径关键酶基因thil,adhE2和BCS operon(crt-bcd-etfB-etfA-hbd)基因序列,构建BCS operon-adhE2-thil/pTrc99a/MG1655(pBAT)。重组菌E.coli pBAT采用0.1 mmol异丙基-β-硫代半乳糖苷(IPTG)诱导5 h,测定乙酰基转移酶(THL)、3-羟基丁酰辅酶A脱氢酶(HBD)、3-羟基丁酰辅酶A脱水酶(CRT)、丁酰辅酶A脱氢酶(BCD)、醛醇脱氢酶(BYDH/BDH)的酶活。并以该基因工程菌作为发酵菌种,采用好氧、厌氧和微好氧三种培养方式,检测丁醇产量。【结果】酶活测定结果显示:THL酶活达到0.160 U/mg protein,酶活力提高了近30倍;HBD酶活力提高了近5倍;CRT酶活达到1.53 U/mg protein,野生菌株无此酶活;BCD酶活力提高了32倍;BYDH/BDH酶活力无显著提高。3种发酵培养结果显示在微好氧和厌氧条件下,均有丁醇产生,且丁醇的最大产量约为84 mg/L。【结论】本实验通过构建产丁醇基因工程大肠杆菌,实现了丁醇关键酶基因在大肠杆菌中的活性表达以及发酵产丁醇,为发酵法生产丁醇开辟了一条新的途径。     

NotI genomic cleavage map of Escherichia coli K-12 strain MG1655.

Several approaches were used to construct a complete NotI restriction enzyme cleavage map of the genome of Escherichia coli MG1655. The approaches included use of transposable element insertions that created auxotrophic mutations and introduced a NotI site into the genome, hybridization of NotI fragments to the ordered lambda library constructed by Kohara et al. (BioTechniques 10:474-477, 1991), Southern blotting of NotI digests with cloned genes as probes, and analysis of the known E. coli DNA sequence for NotI sites. In all, 22 NotI cleavage sites were mapped along with 26 transposon insertions. These sites were localized to clones in the lambda library and, when possible, sequenced genes. The map was compared with that of strain EMG2, a wild-type E. coli K-12 strain, and several differences were found, including a region of about 600 kb with an altered restriction pattern and an additional fragment in MG1655. Comparison of MG1655 with other strains revealed minor differences but indicated that this map was representative of that for many commonly used E. coli K-12 strains.     

弗氏志贺菌毒力大质粒导入大肠杆菌MG1655

目的:将弗氏2a志贺菌2457T的毒力大质粒pSF导入大肠杆菌MG1655。方法:通过诱动转移技术,将弗氏2a志贺菌2457T的毒力大质粒导入大肠杆菌MG1655。结果:构建了MG1655/pSF:pXL275-virG的毒力大质粒导入突变株,双向电泳初步比较分析表明在重组MG1655中有志贺菌毒力的表达。结论:成功地将弗氏2a志贺菌2457T毒力大质粒pSF导入了大肠杆菌MG1655。     

The complete AvrII restriction map of the Escherichia coli genome and comparisons of several laboratory strains.

The complete 13 site AvrII restriction map of the genome of E coli strain MG1655 is presented and compared with several other E. coli strains. The map was determined primarily by isolating individual AvrII fragments from pulsed-field gels, and hybridizing these large probes to a battery of mapped E. coli clones in lambda vectors. AvrII restriction patterns for eight other laboratory strains were determined and maps for seven of them deduced from the gel and comparisons between the strain genotypes, the MG1655 map, and AvrII sites in E. coli sequences taken from Genbank.     

Physiological studies of Escherichia coli strain MG1655: growth defects and apparent cross-regulation of gene expression

Escherichia coli strain MG1655 was chosen for sequencing because the few mutations it carries (ilvG rfb-50 rph-1) were considered innocuous. However, it has a number of growth defects. Internal pyrimidine starvation due to polarity of the rph-1 allele on pyrE was problematic in continuous culture. Moreover, the isolate of MG1655 obtained from the E. coli Genetic Stock Center also carries a large deletion around the fnr (fumarate-nitrate respiration) regulatory gene. Although studies on DNA microarrays revealed apparent cross-regulation of gene expression between galactose and lactose metabolism in the Stock Center isolate of MG1655, this was due to the occurrence of mutations that increased lacY expression and suppressed slow growth on galactose. The explanation for apparent cross-regulation between galactose and N-acetylglucosamine metabolism was similar. By contrast, cross-regulation between lactose and maltose metabolism appeared to be due to generation of internal maltosaccharides in lactose-grown cells and may be physiologically significant. Lactose is of restricted distribution: it is normally found together with maltosaccharides, which are starch degradation products, in the mammalian intestine. Strains designated MG1655 and obtained from other sources differed from the Stock Center isolate and each other in several respects. We confirmed that use of other E. coli strains with MG1655-based DNA microarrays works well, and hence these arrays can be used to study any strain of interest. The responses to nitrogen limitation of two urinary tract isolates and an intestinal commensal strain isolated recently from humans were remarkably similar to those of MG1655.     

Recombinant protein production in an Escherichia coli reduced genome strain

Recently, efforts have been made to improve the properties of Escherichia coli as a recombinant host by 'genomic surgery'-deleting large segments of the E. coli K12 MG1655 genome without scars. These excised segments included K-islands, which contain a high proportion of transposons, insertion sequences, cryptic phage, damaged, and unknown-function genes. The resulting multiple-deletion strain, designated E. coli MDS40, has a 14% (about 700 genes) smaller genome than the parent strain, E. coli MG1655. The multiple-deletion and parent E. coli strains were cultured in fed-batch fermenters to high cell densities on minimal medium to simulate industrial conditions for evaluating growth and recombinant protein production characteristics. Recombinant protein production and by-product levels were quantified at different controlled growth rates. These results indicate that the multiple-deletion strain's growth behavior and recombinant protein productivity closely matched the parent stain. Thus, the multiple-deletion strain E. coli MDS40 provides a suitable foundation for further genomic reduction.     

Definition of the Escherichia coli MC4100 genome by use of a DNA array

We have used an Escherichia coli K-12 whole-genome array based on the DNA sequence of strain MG1655 as a tool to identify deletions in another E. coli K-12 strain, MC4100, by probing the array with labeled chromosomal DNA. Despite the continued widespread use of MC4100 as an experimental system, the specific genetic relationship of this strain to the sequenced K-12 derivative MG1655 has not been resolved. MC4100 was found to contain four deletions, ranging from 1 to 97 kb in size. The exact nature of three of the deletions was previously unresolved, and the fourth deletion was altogether unknown.     

Emergence of biofilm-forming subpopulations upon exposure of Escherichia coli to environmental bacteriophages

Exposure of Escherichia coli MG1655 to environmental bacteriophages results in rapid selection for phage-tolerant subpopulations displaying increased biofilm formation. Analysis of one phage-tolerant strain revealed large amounts of the DNA-binding Dps protein in the outer membrane protein and production of fimbria-like structures. In dps and fimA mutant derivatives of MG1655, no selection of phage-tolerant bacteria upon exposure to bacteriophages occurred, suggesting a role for Dps and type I pili in bacteriophage tolerance.     

生物膜定量分析仪对不同细菌早期生物膜形成能力的比较研究

目的通过生物膜定量分析仪来观察铜绿假单胞菌(Pseudomonas aeruginosa PAO1),变形链球菌(Streptococcus mutans UA159)以及大肠埃希菌(Escherichia coli MG1655)生物膜形成能力的不同,并以各菌株的吸光度值A600为参考,对3种菌株早期生物膜形成能力进行比较。方法通过向生物膜培养悬液中加入与细菌直径相近的磁性小珠,利用这些小珠在磁场中受到生物膜的位移约束力的原理,采用生物膜定量分析仪,定量比较3种菌株在生物膜形成上的差别。结果实验发现铜绿假单胞菌PAO1和大肠埃希菌MG1655的细菌增长速度基本相同,但铜绿假单胞菌PAO1的生物膜形成明显快于大肠埃希菌MG1655。大肠埃希菌MG1655和变形链球菌UA159的生物膜形成速度基本相同,但大肠埃希菌MG1655的细菌增长速度明显高于变形链球菌UA159。结论不同细菌有各自的生物膜形成模式。生物膜定量分析仪作为一种高效简便的检测手段,可用于生物膜早期形成的动态分析。     

De novo creation of MG1655-derived E. coli strains specifically designed for plasmid DNA production

The interest in plasmid DNA (pDNA) as a biopharmaceutical has been increasing over the last several years, especially after the approval of the first DNA vaccines. New pDNA production strains have been created by rationally mutating genes selected on the basis of Escherichia coli central metabolism and plasmid properties. Nevertheless, the highly mutagenized genetic background of the strains used makes it difficult to ascertain the exact impact of those mutations. To explore the effect of strain genetic background, we investigated single and double knockouts of two genes, pykF and pykA, which were known to enhance pDNA synthesis in two different E. coli strains: MG1655 (wild-type genetic background) and DH5α (highly mutagenized genetic background). The knockouts were only effective in the wild-type strain MG1655, demonstrating the relevance of strain genetic background and the importance of designing new strains specifically for pDNA production. Based on the obtained results, we created a new pDNA production strain starting from MG1655 by knocking out the pgi gene in order to redirect carbon flux to the pentose phosphate pathway, enhance nucleotide synthesis, and, consequently, increase pDNA production. GALG20 (MG1655ΔendAΔrecAΔpgi) produced 25-fold more pDNA (19.1 mg/g dry cell weight, DCW) than its parental strain, MG1655ΔendAΔrecA (0.8 mg/g DCW), in glucose. For the first time, pgi was identified as an important target for constructing a high-yielding pDNA production strain.     

Motility influences biofilm architecture in Escherichia coli

Eight Escherichia coli strains were studied in minimal medium with a continuous flow system using confocal microscopy. K12 wild-type strains ATCC 25404 and MG1655 formed the best biofilms (∼43 μm thick, 21 to 34% surface coverage). JM109, DH5α, and MG1655 motA formed intermediate biofilms (∼13 μm thick, 41 to 58% surface coverage). BW25113, MG1655 qseB, and MG1655 fliA had poor biofilms (surface coverage less than 5%). The best biofilm-formers, ATCC 25404 and MG1655, displayed the highest motility, whereas the worst biofilm former, BW25113, was motility-impaired. The differences in motility were due to differences in expression of the motility loci qseB, flhD, fliA, fliC, and motA (e.g., qseB expression in MG1655 was 139-fold higher than BW25113 and 209-fold higher than JM109). Motility affected the biofilm architecture as those strains which had poor motility (E. coli JM109, E. coli MG1655 motA, and DH5α) formed flatter microcolonies compared with MG1655 and ATCC 25404, which had more dramatic vertical structures as a result of their enhanced motility. The presence of flagella was also found to be important as qseB and fliA mutants (which lack flagella) had less biofilm than the isogenic paralyzed motA strain (threefold less thickness and 15-fold less surface coverage).     

琥珀酸脱氢酶或琥珀酰辅酶A合成酶缺失促进大肠杆菌积累5-氨基乙酰丙酸

5-氨基乙酰丙酸 (ALA) 是生物体内四吡咯类化合物的合成前体,在农业及医药领域应用广泛,是极具开发价值的高附加值生物基化学品。目前利用外源C4途径的重组大肠杆菌发酵生产ALA的研究主要利用LB培养基并添加葡萄糖和琥珀酸、甘氨酸等合成前体,成本较高。琥珀酸在C4途径中以琥珀酰辅酶A的形式直接参与ALA的合成。文中在以葡萄糖为主要碳源的无机盐培养基中研究了琥珀酰辅酶A下游代谢途径琥珀酸脱氢酶编码基因sdhAB和琥珀酰辅酶A合成酶编码基因sucCD缺失对ALA积累的影响。与仅表达异源ALA合成酶的对照菌株相比,sdhAB和sucCD缺失菌株ALA的产量分别提高了25.59%和12.40%,且ALA的积累不依赖于琥珀酸的添加和LB培养基的使用,从而大幅降低了生产成本,显示出良好的工业应用前景。     

An Escherichia coli host strain useful for efficient overproduction of secreted recombinant protein

Periplasmic secretion of overexpressed Bacillus stearothermophilus alpha-amylase was analyzed in batch and fed-batch cultivations of Escherichia coli MG1655:pCSS4-p and the mutant strain CWML2:pCSS4-p. Under all conditions investigated, growth and product formation of MG1655:pCSS4-p were severely impaired by heterologous protein expression and/or processing, while E. coli CWML2:pCSS4-p was found to be more robust and to accumulate 2- to 3-fold higher maximum alpha-amylase levels. While this strain is itself potentially interesting for applications, its properties also illustrate the potential of the selection procedure that was employed to obtain it from its progenitor MG1655 (Weikert, C., Sauer, U., Bailey, J. E., 1997. Microbiol. 143: 1567-1574. Application of this procedure to existing industrial strains may lead to significantly improved process organisms.     

Using genomic sequencing for classical genetics in E. coli K12

We here develop computational methods to facilitate use of 454 whole genome shotgun sequencing to identify mutations in Escherichia coli K12. We had Roche sequence eight related strains derived as spontaneous mutants in a background without a whole genome sequence. They provided difference tables based on assembling each genome to reference strain E. coli MG1655 (NC_000913). Due to the evolutionary distance to MG1655, these contained a large number of both false negatives and positives. By manual analysis of the dataset, we detected all the known mutations (24 at nine locations) and identified and genetically confirmed new mutations necessary and sufficient for the phenotypes we had selected in four strains. We then had Roche assemble contigs de novo, which we further assembled to full-length pseudomolecules based on synteny with MG1655. This hybrid method facilitated detection of insertion mutations and allowed annotation from MG1655. After removing one genome with less than the optimal 20- to 30-fold sequence coverage, we identified 544 putative polymorphisms that included all of the known and selected mutations apart from insertions. Finally, we detected seven new mutations in a total of only 41 candidates by comparing single genomes to composite data for the remaining six and using a ranking system to penalize homopolymer sequencing and misassembly errors. An additional benefit of the analysis is a table of differences between MG1655 and a physiologically robust E. coli wild-type strain NCM3722. Both projects were greatly facilitated by use of comparative genomics tools in the CoGe software package (http://genomevolution.org/).     

Comparison of DeltarelA strains of Escherichia coli and Salmonella enterica serovar Typhimurium suggests a role for ppGpp in attenuation regulation of branched-chain amino acid biosynthesis

The growth recovery of Escherichia coli K-12 and Salmonella enterica serovar Typhimurium DeltarelA mutants were compared after nutritional downshifts requiring derepression of the branched-chain amino acid pathways. Because wild-type E. coli K-12 and S. enterica serovar Typhimurium LT2 strains are defective in the expression of the genes encoding the branch point acetohydroxy acid synthetase II (ilvGM) and III (ilvIH) isozymes, respectively, DeltarelA derivatives corrected for these mutations were also examined. Results indicate that reduced expression of the known global regulatory factors involved in branched-chain amino acid biosynthesis cannot completely explain the observed growth recovery defects of the DeltarelA strains. In the E. coli K-12 MG1655 DeltarelA background, correction of the preexisting rph-1 allele which causes pyrimidine limitations resulted in complete loss of growth recovery. S. enterica serovar Typhimurium LT2 DeltarelA strains were fully complemented by elevated basal ppGpp levels in an S. enterica serovar Typhimurium LT2 DeltarelA spoT1 mutant or in a strain harboring an RNA polymerase mutation conferring a reduced RNA chain elongation rate. The results are best explained by a dependence on the basal levels of ppGpp, which are determined by relA-dependent changes in tRNA synthesis resulting from amino acid starvations. Expression of the branched-chain amino acid operons is suggested to require changes in the RNA chain elongation rate of the RNA polymerase, which can be achieved either by elevation of the basal ppGpp levels or, in the case of the E. coli K-12 MG1655 strain, through pyrimidine limitations which partially compensate for reduced ppGpp levels. Roles for ppGpp in branched-chain amino acid biosynthesis are discussed in terms of effects on the synthesis of known global regulatory proteins and current models for the control of global RNA synthesis by ppGpp.     

利用大肠杆菌细胞工厂生产吲哚-3-乙酸的研究

目的:利用重组大肠杆菌全细胞转化色氨酸生产IAA.方法:在大肠杆菌胞内构建两条全新的IAA合成途径,即吲哚-3-乙酰胺(indole-3-acetamide,IAM)途径和色胺(tryptamine,TRP)途径.结果:IAM途径涉及两个酶,分别是色氨酸-2-单加氧酶(IAAM)和酰胺酶(AMI1),构建好的重组大肠杆...     

Using a multi-faceted approach to determine the changes in bacterial cell surface properties influenced by a biofilm lifestyle

Biofilm formation is a developmental process in which initial reversible adhesion is governed by physico-chemical forces, whilst irreversible adhesion is mediated by biological changes within a cell, such as the production of extracellular polymeric substances. Using two bacteria, E. coli MG1655 and B. cereus ATCC 10987, this study establishes that the surface of the bacterial cell also undergoes specific modifications, which result in biofilm formation and maintenance. Using various surface characterisation techniques and proteomics, an increase in the surface exposed proteins on E. coli cells during biofilm formation was demonstrated, along with an increase in hydrophobicity and a decrease in surface charge. For B. cereus, an increase in the surface polysaccharides during biofilm formation was found as well as a decrease in hydrophobicity and surface charge. This work therefore shows that surface modifications during biofilm formation occur and understanding these specific changes may lead to the formulation of effective biofilm control strategies in the future.     

敲除aceE基因对大肠杆菌生长和丙酮酸代谢的影响

大肠杆菌aceE基因是编码丙酮酸脱氢酶多酶复合体PdhR的关键酶之一。利用Red重组系统敲除大肠杆菌MG1655的aceE基因后,阻断了丙酮酸流向TCA循环,导致丙酮酸的累积,也使菌体生长受到影响,在培养基中补加5 g/L KAc后可以在一定程度上弥补菌株在生长上的缺陷。摇瓶发酵36 h,MG1655没有积累丙酮酸,MG1655ΔaceE∷cat菌株可以积累26.77 g/L丙酮酸,为利用大肠杆菌发酵生产丙酮酸奠定了基础。