内切酶法制取菊苣低聚果糖工艺条件的研究

目的:利用毕赤嗜甲醇酵母表达的重组黑曲霉菊粉内切酶,从菊苣菊粉中制取低聚果糖。方法:用重组黑曲霉菊粉内切酶酶解水提菊粉,用薄层色谱、离子色谱分析酶解产物,研究酶解条件,分析产物组成。结果与结论:菊粉浓度为20～160g/L、酶浓度为12U/g菊粉时,低聚果糖的最大产率逐渐升高然后下降;在接近最大溶解度200g/L时,菊粉寡糖最大产率为62.0%,最大产率与酶的用量无关,但提高酶的浓度可以缩短达到最大产率的时间。pH5.5、50℃、菊粉浓度为40g/L、酶用量为12U/g菊粉时,可达到最大产率64.6%;酶解的产物主要为GF2到GF10的菊粉寡糖。     

微生物菊粉酶的研究进展

综述了微生物菊粉酶在菌种选育,菊粉酶的纯化与性质,基因结构及生产应用等方面研究的进展。     

菊粉酶基因的异源表达、分离纯化及酶学性质

为进一步提高菊粉酶在生物技术领域的应用,研究了来源于马克斯克鲁维酵母Kluyveromyces marxianus YX01的菊粉酶性质。通过在毕赤酵母GS115宿主细胞中异源表达该菊粉酶基因(inu),获得了一种外切型菊粉酶,经聚丙烯酰胺凝胶电泳(SDS-PAGE)验证其分子量为86.0 k Da。进一步在该菊粉酶上增加6个His标签,采用聚乙二醇(PEG)20 000透析浓缩和Ni-NTA Agarose静态亲和吸附作用的方法,完成菊粉酶的分离纯化,纯化倍数和酶回收率分别为3.6和33.1%。比较发现粗酶液与纯酶的酶学性质相似,且菊粉酶的最适反应温度为60℃,最适p H值为4.62,并测得该酶的Km和Vmax值,以菊粉为底物时,Km和Vmax值分别为80.53 g/L和4.49 g/(L·min);以蔗糖底物时,Km和Vmax值分别为183.10 g/L和20.20 g/(L·min)。金属离子Mn2+、Ca2+、Cu2+、Zn2+和Fe2+对酶活力具有不同程度的抑制作用,其中Cu2+、Zn2+和Fe2+的抑制作用最为显著。这些研究为进一步提高菊粉酶在工业化的应用奠定了基础。     

固定化克鲁维酵母Y-179外切菊粉酶的研究

鹰嘴豆孢克鲁维酵母(Kluveromyces cicerisporus Y-179)分泌的糖基化菊粉外切酶经高碘酸钠氧化其分子表面的糖链产生醛基,再共价结合于氨基型固定化载体ZH-HA上,固定化酶活力达到4 000 U/g湿载体。所制备的固定化酶在pH 3.5和70℃温度下表现出最大反应活性,该固定化酶pH稳定性和热稳定性较游离酶明显提高。固定化酶在分批式反应器中重复水解菊粉50批次,活力没有明显损失,表现出良好的工作稳定性。     

克鲁维酵母Y-85菊粉酶的纯化和性质

克鲁维酵母(Kluyveromyces sp.)Y-85产生的胞内菊粉酶(endocellular inulinase)和胞外菊粉酶(exocellular inulinase)粗酶液分别经PEG6000-磷酸盐缓冲液双水相抽提得部分纯化酶液。前者进一步用硫酸铵分级沉淀、Protein-PAK DEAE离子交换、Protein-PAK200SW凝胶过滤后得到两个菊粉酶组分EⅠ和EⅡ;后者采用DEAE-Sephacel离子交换、Sephadex G150凝胶过滤后得到菊粉酶Eexo。经Waters 650E蛋白纯化系统鉴定,三者均呈单一的对称峰;EⅠ和EⅡ达聚丙烯酰胺盘状凝胶电泳纯。EⅠ、EⅡ和Eexo的分子量分别为42kD、65kD和57kD;三者均为糖蛋白,多糖含量分别为30％、35％和25％;I/S(Inulinaseactivity/Sucrase activity)比值分别为0.086、0.078和0.072;三者均属外切菊粉酶。EⅠ、EⅡ和Eexo酶反应最适pH分别为4.6、4.5和4.6,最适温度分别为52℃、52℃和55℃;Ag⁺、Hg2+和PCMB对酶活性有强烈的抑制作用;三者水解菊芋…     

内切型菊粉酶生产菌株的筛选及诱变选育

采用透明圈法筛选得到了产菊粉酶的多株菌株,并得到了1株产内切型菊粉酶较高的隐球酵母属（Cryptococcus)菌株L1,以L1作为出发菌株经Co^60诱变后,得到1株产内切型菊粉酶最好菌株C10,其诱变后低聚果糖得率比诱变前提高了52．6％,酶活力提高了51．9％。     

克鲁维酵母Y-85合成菊粉酶最适条件的研究

采用响应面方法对克鲁维酵母Ｙ－８５产菊粉酶培养基成份进行了优选,和正交试验相比,该法选出的最适培养基的酶发酵水平提高２８％。用１５Ｌ自控发酵罐进行产酶条件控制试验,并在１０００Ｌ罐上进行了５批次酶发酵中试,平均菊粉酶活性达６８．９ｕ／ｍｌ。     

克鲁维酵母Y-85合成菊粉酶最适条件的研究

采用响应面方法（ResponseSurfaceMethod,RSM）对克鲁维酵母（Kluyveromycessp．）Y－85产菊粉酶培养基成份进行了优选,和正交试验相比,该法选出的最适培养基的酶发酵水平提高28％。用15L自控发酵罐进行产酶条件控制试验,并在1000L罐上进行5批次酶发酵中试,平均菊粉酶活性达68.9u／ml。     

产菊粉酶酵母菌株的筛选及菌种鉴定

经过初筛、复筛,得到2株菊粉酶活力较高的酵母菌Y9和Y27,其发酵液酶活分别达到19.4 U/mL和14.1 U/mL,两者胞外菊粉酶分泌较少,主要分布在酵母菌菌体上。通过细胞形态、生理生化特征及Biolog微生物鉴定系统鉴定,将Y9确立为Cryptococcus albidus(浅白隐球酵母),Y27确立为Pichia guilliermondiiA(季也蒙毕赤氏酵母A)。     

一个外切菊粉酶基因的克隆表达及酶学性质

从马克斯克鲁维酵母（Kluyveromycesmarxianus）DSM5418中克隆出外切菊粉酶（INU）的成熟肽编码区域,在毕赤酵母（Pichiapastoris）GS115中实现了高效分泌表达,体积酶活力达到15．27U／mL,进一步对重组酶进行了纯化与表征。经过（NH4）2SO4沉淀、透析和分子筛过滤后,得到了纯度大于95％的纯化重组酶,SDS-PAGE分析发现INU的表观相对分子质量为9．0×10^4,大于理论预测值6．0×10^4。纯化酶液的表征结果表明,INU的最适温度和最适pH分别为55℃和5．0,在此条件下INU对菊粉的K。值和比酶活分别为1．90mmol／L和433．86U／mg,对蔗糖的K。值和比酶活分别为27．81mmol/L和1249．49U／mg,I/S值为0．34;HPLC分析表明,INU酶解菊粉的产物由果糖和葡萄糖组成;金属离子Mn2＋、Fe3｜、K｜和Co2＋对酶有促进作用,而Zn2＋、Cu2＋、Ni2＋、SDS和EDTA对酶活力有不同程度的抑制作用。     

Cloning and sequencing of the inulinase gene of Kluyveromyces marxianus var. marxianus ATCC 12424.

Cell wall inulinase (EC 3.2.1.7) was purified from Kluyveromyces marxianus var. marxianus (formerly K. fragilis) and its N-terminal 33-amino acid sequence was established. PCR amplification of cDNA with 2 sets of degenerate primers yielded a genomic probe which was then used to screen a genomic library established in the YEp351 yeast shuttle vector. One of the selected recombinant plasmids allowed an invertase-negative Saccharomyces cerevisiae mutant to grow on inulin. It was shown to contain an inulinase gene (INU 1) encoding a 555-amino acid precursor protein with a typical N-terminal signal peptide. The sequence of inulinase displays a high similarity (67%) to S. cerevisiae invertase, suggesting a common evolutionary origin for yeast beta-fructosidases with different substrate preferences.     

Optimization of medium and process parameters for the production of inulinase from a newly isolated Kluyveromyces marxianus YS-1

A newly isolated strain of Kluyveromyces marxianus YS-1 was used for the production of extra cellular inulinase in a medium containing inulin, meat extract, CaCl2 and sodium dodecyl sulphate (SDS). Fermentation medium pH 6.5, cultivation temperature 30 degrees C and 5% (v/v) inoculum of 12 h-old culture were optimal for enzyme production (30.8 IU/ml) with a fermentation time of 72 h at shake flask level. Raw inulin (2%, w/v) extracted from dahlia tubers by processing at 15 kg/cm2 for 10 min was optimum for bioreactor studies. Maximum enzyme production (55.4 IU/ml) was obtained at an agitation rate of 200 rpm and aeration of 0.75 vvm in a stirred tank reactor with a fermentation time of 60 h.     

Production, purification and characterization of an extracellular inulinase from Kluyveromyces marxianus var. bulgaricus

The yeast Kluyveromyces marxianus var. bulgaricus produced large amounts of extracellular inulinase activity when grown on inulin, sucrose, fructose and glucose as carbon source. This protein has been purified to homogeneity by using successive DEAE-Trisacryl Plus and Superose 6HR 10/30 columns. The purified enzyme showed a relative molecular weight of 57 kDa by sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE) and 77 kDa by gel filtration in Superose 6 HR 10/30. Analysis by SDS-PAGE showed a unique polypeptide band with Coomassie Blue stain and nondenaturing PAGE of the purified enzyme obtained from media with different carbon sources showed the band, too, when stained for glucose oxidase activity. The optimal hydrolysis temperature for sucrose, raffinose and inulin was 55°C and the optimal pH for sucrose was 4.75. The apparent K _m values for sucrose, raffinose and inulin are 4.58, 7.41 and 86.9 mg/ml, respectively. Thin layer chromatography showed that inulinase from K. marxianus var. bulgaricus was capable of hydrolyzing different substrates (sucrose, raffinose and inulin), releasing monosaccharides and oligosaccharides. The results obtained suggest the hypothesis that enzyme production was constitutive. Journal of Industrial Microbiology & Biotechnology (2000) 25, 63–69. Received 17 November 1999/ Accepted in revised form 30 May 2000     

一步法发酵菊芋产乙醇菌种的筛选及产酶条件、酶学性质的研究

从腐烂的菊芋及实验室保存的菌种中,选育到一株发酵菊芋产乙醇的菌株克鲁维酵母Kluyveromyces marxianus Y1。利用正交实验法对克鲁维酵母产菊粉酶的培养基组成及培养条件进行优化,确定培养基组成（g/L）为：菊粉40,酵母粉4,蛋白胨4,尿素1;初始pH5．0,温度30℃,150r／min条件下培养达到最佳产酶效果（57U／mL）。该菌株所产菊粉酶的性质测定结果表明：以菊粉为底物,该菊粉酶最适反应温度为55℃,在60℃以下稳定性很好,高于60℃时酶迅速失活;最适pH为5．0,pH4．6—5．2范围内酶稳定性很好;该酶属于外切型菊粉酶,体积分数为8％的乙醇对酶活力基本没有影响。     

High-level secretory expression and characterization of the recombinant Kluyveromyces marxianus inulinase

Inulinase is an important enzyme used in the high fructose syrup and other related industries. A more cost-effective approach is required for producing highly active inulinase. In this study, the gene encoding inulinase of the yeast Kluyveromyces marxianus CBS 6556 was expressed in methylotrophic host Pichia pastoris and secretory production of recombinant inulinase (rKmINU) in the yeast under methanol induction was achieved. The purified rKmINU showed a specific activity of 2714 U/mg, which is over 12-fold higher than those of other inulinases described previously. It displayed excellent stability from 30 to 50 °C and pH 3.0-5.0, and the half-life of rKmINU was over 96 h under these conditions. Moreover, rKmINU saccharified Jerusalem artichoke tuber juice effectively.     

Evaluation of the tetracycline promoter system for regulated gene expression in Kluyveromyces marxianus

A tetracycline repressible promoter system designed for Saccharomyces cerevisiae was evaluated for use in Kluyveromyces marxianus. A plasmid was constructed containing the Escherichia coli beta-glucuronidase (gus) gene cloned downstream of the yeast tet-off promoter, the tetR-VP16 activator protein gene, and the URA3 gene for selection. The tet-off promoter-gus construct was integrated into the chromosomal DNA and tested under varying growth conditions in complex medium. The repressors tetracycline and doxycycline were both found to be effective for inhibiting gene expression. Doxycycline levels of 0.5 microg/mL or greater were sufficient to nearly completely suppress Gus synthesis. For most transformants, the induction ratio was approximately 2,000-fold. The tet-off promoter was effective at 30, 37, and 42 degrees C, although the overall Gus activity was highest at 37 degrees C. During exponential growth, little product was formed; expression increased dramatically in late exponential and early stationary phase. The promoter thus shows promise for protein synthesis following cell growth. No inducer is required and the repressor is only needed to prevent expression during the seed culture.