Effect of hydrogen and carbon dioxide partial pressures on growth and sulfide production of the extremely thermophilic archaebacterium Pyrodictium brockii

The effect of hydrogen and carbon dioxide partial pressure on the growth of the extremely thermophilic archaebacterium Pyrodictium brockii at 98 degrees C was investigated. Previous work with this bacterium has been done using an 80:20 hydrogen-carbon dioxide gas phase with a total pressure of 4 atm; no attempt has been made to determine if this mixture is optimal. It was found in this study that reduced hydrogen partial pressures affected cell yield, growth rate, and sulfide production. The effect of hydrogen partial pressure on cell yield and growth rate was less dramatic when compared to the effect on sulfide production, which was not found to be growth-associated. Carbon dioxide was also found to affect growth but only at very low partial pressures. The relationship between growth rate and substrate concentration could be correlated with a Monod-type expression for either carbon dioxide or hydrogen as the limiting substrate. The results from this study indicate that a balance must be struck between cell yields and sulfide production in choosing an optimal hydrogen partial pressure for the growth of P. brockii.     

Pressure Sensitivity of Streptococcal Growth in Relation to Catabolism

The sensitivity of Streptococcus faecalis growth to hydrostatic pressures ranging up to 550 atm was found to depend on the source of adenosine triphosphate for growth. Barotolerance of cultures growing in a complex medium with ribose as major catabolite appeared to be determined primarily by the pressure sensitivity of ribose-degrading enzymes. Apparent activation volumes for growth were nearly identical to those for lactate production from ribose, and yield coefficients per mole of ribose degraded were relatively independent of pressure. In contrast, cultures with glucose as main catabolite were less sensitive to pressure; glycolysis was less severely restricted under high pressure than was growth, and yield coefficients declined with pressure, especially above 400 atm. Thus, two distinct types of barotolerance could be defined-one dominated by catabolic reactions and one dominated by noncatabolic reactions. The results of experiments with a series of other catabolites further supported the view that catabolic reactions can determine streptococcal barotolerance. We also found that growing, glucose-degrading cultures increased in volume under pressure in the same manner that they do at 1 atm. Thus, it appeared that the bacterium has no alternative means of carrying out glycolysis under pressure without dilatation. Also, the observation that cultures grown under pressure did not contain abnormally large or morphologically deformed cells suggested that pressure did not inhibit cell division more than cell growth.     

Oxygen enriched air supply in Escherichia coli processes: production of biomass and recombinant human growth hormone

In order to investigate the impact of high oxygen and carbon dioxide concentrations, Escherichia coli was grown in batch cultivations where the air supply was enriched with either oxygen or carbon dioxide. The effect of elevated concentrations of oxygen and carbon dioxide on stochiometric and kinetic constants was studied this way. The maximum growth rate was significantly reduced, the production of acetic acid and the biomass yield coefficient on glucose increased in cultures with carbon dioxide enriched air, compared to reference cultivations and cultivations with oxygen enriched air. The application of oxygen enriched air was studied in high cell density cultivations of Escherichia coli. Two production processes were chosen to investigate the impact of oxygen enrichment. Biomass concentration, specific growth rate, yield coefficient, respiration, mixed acid fermentation products and the product yield and quality for the recombinant product were investigated. First, a process for the production of biomass was investigated. Exponential growth could proceed for a longer time and higher growth rates could be maintained with oxygen enriched air supply. However, a higher specific oxygen consumption rate per glucose was measured after the start of the oxygen enrichment, indicating higher maintenance and consequently the growth rate and yield coefficient decreased drastically in the end of the process. Second, a process for the production of recombinant human growth hormone (rhGH) was investigated. Although the glucose feed rate and all medium components were doubled, the amount of produced biomass could only be increased by 77% when oxygen enriched air (40% oxygen) supply was applied. This was due to a decreased yield coefficient of biomass per glucose. The total amount of produced product was decreased by almost 50% compared to the control, although less proteolytically degraded variants were produced.     

Amino acid utilization by L-M strain mouse cells in a chemically defined medium

Summary The amino acid requirements of strain L-M mouse cells grown in a chemically defined medium (2×Eagle) containing only the 13 essential amino acids (EAA) were investigated. Medium and acid hydrolysate samples were analyzed for amino acid content by the method of ion exchange chromatography. The extent of utilization of the EAA differed;e.g. after 120 hr of cell growth without medium change, glutamine was exhausted from the medium; methionine, leucine, isoleucine, cystine, arginine, and valine were depleted 60 to 80%; other EAA were used to lesser extents. Although the EAA were used in excess of their requirements for protein synthesis, a correlation could generally be made between utilization and protein amino acid composition. Glutamine appeared to be, a growth-limiting factor. Use of U-¹⁴C-labeled glutamine indicated that over one-half of the metabolized glutamine was converted to carbon dioxide, 17% to cell material, and 15% was extracted from the amino acid pools. Nonessential amino acids (NEAA), viz. alanine, aspartic acid, glutamic acid, glycine, proline, and serine, were released into the medium during growth, and some were reutilized. Exogenous provision of these did not improve cell growth. In contrast to the other NEAA, only serine showed net utilization when provided exogenously. When glutamic acid largely replaced the glutamine in the medium, it exerted a sparing effect on the glutamine requirement for protein synthesis. Suggestions are given for the improvement of Eagle medium for cell growth. Supported by Research Grants CA 03720 and CA 11802 from the National Institutes of Health. Predoctoral, fellow supported, by Grant F01-GM-42156-02 from the National Institutes of Health.     

Amino acid utilization by L-M strain mouse cells in a chemically defined medium

Summary The amino acid requirements of strain L-M mouse cells grown in a chemically defined medium (2×Eagle) containing only the 13 essential amino acids (EAA) were investigated. Medium and acid hydrolysate samples were analyzed for amino acid content by the method of ion exchange chromatography. The extent of utilization of the EAA differed;e.g. after 120 hr of cell growth without medium change, glutamine was exhausted from the medium; methionine, leucine, isoleucine, cystine, arginine, and valine were depleted 60 to 80%; other EAA were used to lesser extents. Although the EAA were used in excess of their requirements for protein synthesis, a correlation could generally be made between utilization and protein amino acid composition. Glutamine appeared to be a growth-limiting factor. Use of U-¹⁴C-labeled glutamine indicated that over one-half of the metabolized glutamine was converted to carbon dioxide, 17% to cell material, and 15% was extracted from the amino acid pools. Nonessential amino acids (NEAA), viz. alanine, aspartic acid, glutamic acid, glycine, proline, and serine, were released into the medium during growth, and some were reutilized. Exogenous provision of these did not improve cell growth. In contrast to the other NEAA, only serine showed net utilization when provided exogenously. When glutamic acid largely replaced the glutamine in the medium, it exerted a sparing effect on the glutamine requirement for protein synthesis. Suggestions are given for the improvement of Eagle medium for cell growth. Supported by Research Grants CA 03720 and CA 11802 from the National Institutes of Health. Predoctoral fellow supported by Grant F01-GM-42156-02 from the National Institutes of Health. Present address: Department of Community Medicine. Basic Science Building, University of California, San Diego, La Jolla, Calif. 92037.     

Reduction of sulfur by spirillum 5175 and syntrophism with Chlorobium.

A small spirillum, designated 5175, was isolated from an anaerobic enrichment culture for Desulfuromonas in which the major medium constituents were acetate and elemental sulfur. The organisms grew only under anaerobic or microaerophilic conditions. Elemental sulfur was formed anaerobically in a malate-sulfide medium, and cell densities of 10(8) cells/ml were obtained. Hydrogen and formate were actively oxidized as substrates for growth under anaerobic conditions; S0, S032-, or S2O32-, but not SO42-, served as electron acceptors and were stoichiometrically reduced to sulfide. Malate or fumarate likewise served as electron acceptors and were reduced to succinate. Nutritional requirements were simple, no vitamins or amino acids being required. For growth in inorganic media when carbon dioxide was the only carbon source, the addition of acetate was required as a source of cell carbon. The organism is gram negative. Cells had a diameter of 0.5 mum and a wavelength of 5.0 mum. Cell suspensions exhibited an absorption spectrum indicative of a cytochrome with peaks in the reduced form at 552, 523, and 416 nm. Well growing syntrophic cultures with Chlorobium were established with formate as the substrate.     

Growth of Pediococcus soyae nov. sp. in Highly Concentrated Solutions of Inorganic Salts and Sugars

Pediococcus soyae nov. sp., which has an inherited salt tolerant nature, is grown in solutions of high osmotic pressure. When this strain is transferred from 0.5% salted medium to a new medium containing 18% sodium chloride, the viable counts of this organism firstly decrease from about one half to one-third of the inoculated cells, and then normal growth occurs. This indicates the occurrence of physiological adaptation at an early stage of growth.

The growth of this lactic acid bacterium is observed in concentrated solutions of various inorganic salts. The solutions containing Na⁺, K⁺, Cl^?, NO₃^? and SO₄^{– –} ions are not toxic for the organism, and the organism can grow in solutions of 133 atm. osmotic pressure, generally. However, Li⁺, Ca⁺⁺, Mg⁺⁺ and Br⁺ are, toxic for growth.

In concentrated sugar solutions, this organism also propagates well, and growth is observed in the media containing 50% glucose or 60% sucrose, osmotic pressure being 105 and 84 atm., respectively. Therefore, Pediococcus soyae nov. sp. is osmotolerant.     

Effect of Cultural Conditions on Cellulase Formation by Trichoderma viride

In order to have increased extracellular production of cellulase by Trichoderma viride ITCC 1433, the organism was grown on various growth factors. Cellulose Powder ?123 was found to be the best C-source while amongst raw materials, alkali-treated rice straw gave the best yield. A combination of peptone, urea and ammonium sulphate gave better production of cellulase than when a single nitrogen source was used. Sugars when added into the cellulose medium, generally suppressed the yield. When the organism was grown on sugars as the sole source of carbon, only lactose and maltose induced any cellulase production. Acetate and ascorbate were conspicuous in increasing cellulase production and when given together they had a cummulative effect and the yeild was doubled.     

Nutrient modifications for improved growth of Brassica nigra cell suspension cultures

Cell pellet yield of two Brassica nigra suspension cultures was stimulated by amino acid supplements in the growth medium. This could confound the interpretation of amino acid feeding studies involved in characterizing amino acid metabolism mutants. The nutritional requirements of one of the Brassica nigra suspension cultures growing in modified Murashige & Skoog medium were therefore reviewed. Sucrose at 2% w/v was growth limiting and amino or organic acid supplements stimulated growth rate and yield. Increasing sucrose to 6% and supplementing with 15 mM sodium succinate increased maximum cell pellet volume by 2.7 times and maximum dry weight by 2.8 times, stimulated cell enlargement and produced similar maximum numbers of cells per culture. The further addition of an amino acid supplement of 4 mM alanine, 4 mM glutamine and 1 mM glutamate produced no further improvement. The revised medium was more strongly buffered, supported cell growth for a longer period and permitted a 30-fold reduction in the minimum cell inoculum. Cells grown in the revised medium are 10-fold more resistant to growth inhibition by the tryptophan analogue 5MT. These advantages recommend the revised medium for amino acid feeding, mutant isolation and similar studies.     

Some aspects of the regulation of the production of extracellular proteolytic enzymes by a marine bacterium

A highly proteolytic Gram-negative, rod-shaped bacterium was isolated from the gills of fresh plaice and the effect of culture conditions on the production of proteolytic enzymes was investigated. When the organism, strain SA 1, was grown in the presence of complex mixtures of proteins and amino acids, both endopeptidase and aminopeptidase activity was demonstrated in the cell-free culture medium. However, synthesis of these enzymes was not observed when the organism was grown in a mineral medium with lactate or succinate as the only carbon and energy source. Synthesis of both endopeptidase and aminopeptidase was induced by the presence of amino acids in the medium. Of the amino acids tested, l-phenylalanine was found to be the best single inducer for the production of endopeptidase. When in addition one or more different amino acids were added, endopeptidase production was found to increase with increasing complexity of the mixture, up to a maximum which was obtained with five different amino acids. Production of the aminopeptidase was optimal when l-glutamic acid was used as a single inducer. For this enzyme the amount of enzyme activity released in the medium decreased with increasing complexity of the amino acid mixture. Endopeptidase as well as aminopeptidase activity was found to accumulate in the medium at the end of the logarithmic growth phase, when the culture was no longer growing exponentially. When the stationary phase was reached, enzyme production stopped. Production of both enzymes was immediately halted upon addition of chloramphenicol and was found to be repressed by glucose and lactate. These results suggest that synthesis of proteolytic extracellular enzymes by the organism studied is controlled by an efficient regulatory mechanism, in which growth rate is an important parameter.     

Oxidation of selected alkanes and related compounds by aPseudomonas strain

The oxidation of octane and decane by a gram-negative bacterium, identified as aPseudomonas species, has been studied. The same rates of growth of the organism were observed in culture media supplemented with alkanes as sole source of carbon, irrespective of whether growth had previously taken place in media containing either octane or glucose. However, only cells previously grown in medium supplemented with octane oxidised this paraffin in the Warburg apparatus. Although 1-octene was not utilised for growth, the rate of oxidation of the olefin by resting cells was the same whether these were previously grown with octoic acid or with octane as sole source of carbon. Small amounts of 1-octanol and 1-octanal were oxidised by resting cells, but at higher concentrations respiration was inhibited.The organism was grown at the expense of radioactive decane (l-C¹⁴) and at least half of the added substrate was oxidised to carbon dioxide. No evidence was found for the accumulation of fatty acids either in the cells or in the culture medium.     

Control of respiration and growth yield in ammonium-assimilating cultures of Azotobacter vinelandii

Azotobacter vinelandii was grown in continuous culture at constant dilution rate and at different molar ratios of sucrose to ammonium (C/N) in the inflowing medium. The organisms used up essentially all of the carbon and fixed nitrogen sources. Therefore, the (C/N)-ratio in the influent was the same as the (C/N)-ratio of consumption. Starting close to unity, slight increases of the (C/N)-ratio resulted in increases of cellular respiration. Concomitantly, growth yield coefficients on sucrose decreased while the total biomass stayed constant. At there low (C/N)-ratios growth was limited by ammonium with a yield coefficient on ammonium of about 0.07 g protein per mmol of ammonium. Eventually, however, upon furhter increasing the (C/N)-ratio, respiration as well as the yield coefficient on sucrose approached constant values while the biomass levels increased linearly. This result indicated that a transition to sucrose-limited growth had occurred. The (C/N)-ratio, above which respiration and yield coefficients on sucrose approached constancy, increased when the cultures were grown at higher oxygen tension. When the oxygen tension was higher, and at the same (C/N)-ratios, respiratory values increased, and biomass levels as well as yield coefficients decreased. The data suggest control of respiration and thus of growth yield by the ratio of sucrose to ammonium consumed. These observations infer that commencement of dinitrogen fixation kept the internal (C/N)-ratio constant and consequently respiration as well as yield coefficients on sucrose were maintained.     

The Influence of High Concentrations of Carbon Dioxide on the Germination of Bacterial Spores

The influence of carbon dioxide at 1–55 atm on the germination of Clostridium sporogenes, Clostridium perfringens and Bacillus cereus spores in a complex medium was studied. The germination studies at atmospheric pressure were done in the pH range 5.2–6.7. Controls at the same pH were done in 100% nitrogen. Carbon dioxide at atmospheric pressure (1 atm) inhibited the spore germination of B. cereus spores but strongly enhanced the germination rate of those of the clostridia. Spore germination of Cl. sporogenes and Cl. perfringens was inhibited completely at 10 atm and at 25 atm, respectively. The germination rate in carbon dioxide or nitrogen was generally higher at pH 6.7 than at 5.2–6.0.     

Effect of sugars, hydrogen ion concentration and ammonium nitrate on the formation of citric acid by Aspergillus niger.

Aspergillus niger Mulder strain when grown on a synthetic medium containing urea as the sole source of nitrogen at pH 5.2, formed a mixture of citric and gluconic acids. On growing the organism at pH 2.0 the gluconic acid content was reduced but citric acid yield remained low. Addition of NH4NO3 to the medium lowered the gluconic acid yields to undetectable levels with a simultaneous increase in the citric acid content. Of the sugars used for the production of citric acid, sucrose in an unautoclaved medium was found to be the best carbon source. Sucrose medium if autoclaved at pH 2.0, or a mixture of glucose and fructose instead of sucrose gave lower yields of citric acid. Under optimum conditions only citric acid was produced and the yield was 66-68 per litre after a growth period of about 10 days.     

Regulation of internal solute concentrations of marine Vibrio alginolyticus in response to external NaCl concentration.

Slightly halophilic marine Vibrio alginolyticus grown in the range of NaCl from 0.2 to 1.5 M maintained the total internal solute concentration always higher than the external medium by about 0.25 osM. The concentrations of macromolecules such as DNA, RNA, and protein were little affected by the increase in medium NaCl. The internal K+ concentration was kept to about 400 mM in the range of medium NaCl from 0.4 to 0.8 M; it rose to 510 mM when the bacterium was grown in 1.5 M NaCl, indicating that K+ increased only slightly in response to the large increase in medium NaCl. Thus, in contrast to the case of nonhalophilic and extremely halophilic bacteria, K+ was unlikely to act as a major component to regulate the internal solute concentration of marine V. alginolyticus. The internal Na+ and Cl- concentrations were maintained always lower than those in the growth medium, but they increased in response to the increase in medium NaCl. The concentration of internal Na+ was close to that of K+ at the concentration of medium NaCl that supports the optimal growth of this organism. The total amino acid content of V. alginolyticus increased from 76 to 413 mM by the increase in medium NaCl from 0.2 to 1.5 M. The concentrations of glutamic acid and prolined were 254 and 72 mM, respectively, when grown in 1.5 M NaCl. These results indicated that Na+, Cl- and amino acids, especially glutamic acid and proline, contributed to the regulation of internal solute concentration of V. alginolyticus in response to the increased external NaCl.     

Activity of the enzymes of carbon metabolism in Sulfobacillus sibiricus under various conditions of cultivation

The thermoacidophilic iron-oxidizing chemolithotroph Sulfobacillus sibiricus N1T is characterized by steady growth and amplified cell yield when grown in vigorously aerated medium containing Fe2+, glucose, and yeast extract as energy sources. In this case, carbon dioxide, glucose, and yeast extract are used as carbon sources. Glucose is assimilated through the fructose-bisphosphate pathway and the pentose-phosphate pathway. Glyoxylate bypass does not function in S. sibiricus, and the tricarboxylic acid cycle is disrupted at the level of 2-oxoglutarate dehydrogenase. The presence of ribulose-bisphosphate carboxylase indicates that carbon dioxide fixation proceeds through the Calvin cycle. The activity of ribulose-bisphosphate carboxylase is highest in autotrophically grown cells. The cells also contain pyruvate carboxylase, phosphoenolpyruvate carboxylase, phosphoenolpyruvate carboxykinase, and phosphoenolpyruvate carboxytransphosphorylase.     

Defined medium for Aquaspirillum serpens VHL effective in batch and continuous culture.

A defined medium for Aquaspirillum serpens VHL allows the replacement of the complex media now in use. It was developed by batch culture methods but supports growth in continuous culture. A basal salts medium supplemented with L-aspartic acid, L-alanine, and L-glutamic acid provided the best growth (turbidity), as long as ammonium chloride was omitted. Ammonium chloride caused either a lag or a reduction or a complete inhibition of the growth of A. serpens VHL on the above amino acids and other organic supplements depending on the combination used. Ammonium sulfate and ammonium hydroxide with L-glutamic acid allowed growth, but the lag period was increased in shake flask cultures. Vitamins, cysteine hydrochloride, and carbon dioxide had no effect on the growth rate. Viability (less than 50%) was inadequate to maintain continuous culture with L-glutamic acid as the sole source of carbon and nitrogen. Combinations of amino and carboxylic acids were then tested and, of these, L-glutamic acid (1 g/liter) and L-histidine (75 mg/liter) without ammonium chloride in the basal salts medium supported growth in batch and continuous culture. L-Glutamic acid was the limiting substrate for growth.     

Effect of substrate on the regulation of exoprotease production by Pseudomonas aeruginosa ATCC 10145

Exoprotease production by Pseudomonas aeruginosa ATCC 10145 was growth-associated when cultures were grown on complex substrates such as proteins but it occurred during the decelerating growth phase when the organism was grown on amino acids, mixtures of amino acids or simple carbon sources. NH4Cl and simple carbon sources caused repression. Exoprotease was produced in chemostat cultures in response to growth under any of the nutrient limitations studied (carbon, nitrogen or phosphate). Furthermore, by growing at rates less than approximately 0.1 h-1, the repression of enzyme production could be overcome to a large degree. At low growth rates there was an inverse relationship between growth rate and exoprotease production. Thus, exoprotease production was depressed by available energy sources and was increased in response to any nutrient limitation.     

Metabolic changes during phosphate deprivation in Englena in air and in oxygen

1. Euglena cells were grown in culture media containing either 20mm-phosphate or 20mum-phosphate, with ethanol or glucose as the sole source of carbon, and gassed with either air+carbon dioxide (95:5) or oxygen+carbon dioxide (95:5) at atmospheric pressure. 2. After growth in low-phosphate medium with ethanol as substrate, the cells developed signs of oxygen toxicity, as indicated by a decreased rate of respiration, a decreased net synthesis of paramylum and a failure to resume growth on replenishment of phosphate. 3. After growth in low-phosphate medium with glucose as substrate, the signs of oxygen toxicity were less apparent. 4. During phosphate deprivation the carotenoid content of Euglena increased more than threefold. This increase was largely prevented by exposure of the cells to oxygen+carbon dioxide (95:5) during growth. Oxygenation appears to interfere with ring closure of the common carotenoid precursor. 5. Mitochondria obtained from Euglena exposed to oxygen during phosphate deprivation, i.e. when signs of oxygen toxicity were evident, had greatly decreased activities of succinate dehydrogenase, succinate-cytochrome c oxidoreductase and NADH-cytochrome c oxidoreductase, compared with mitochondria obtained from Euglena exposed to oxygen in medium containing 20mm-phosphate.