Modeling of lactic acid fermentation of leguminous plant juices

Lactic acid fermentation of leguminous plant juices was modeled to provide a comparative efficiency assessment of the previously selected strains of lactic acid bacteria as potential components of starter cultures. Juices of the legumes fodder galega, red clover, and alfalfa were subjected to lactic acid fermentation in 27 variants of experiment. Local strains (Lactobacillus sp. RS 2, Lactobacillus sp. RS 3, and Lactobacillus sp. RS 4) and the collection strain Lactobacillus plantarum BS 933 appeared the most efficient (with reference to the rate and degree of acidogenesis, ratio of lactic and acetic acids, and dynamics of microflora) in fermenting fodder galega juice; Lactobacillus sp. RS 1, Lactobacillus sp. RS 2, Lactobacillus sp. RS 3, Lactobacillus sp. RS 4, and L. plantarum BS 933 were the most efficient for red clover juice. Correction of alfalfa juice fermentation using the tested lactic acid bacterial strains appeared inefficient, which is explainable by its increased protein content and a low level of the acids produced during fermentation.     

Fermentation of high-protein plant biomass by introduction of lactic acid bacteria

Lactic acid bacteria displaying increased ability to produce lactic acid, medium proteolytic activity, and tolerance to osmotic stress were isolated under selective conditions from phyllosphere and rhizosphere of registered and raised cultivars of legumes. Lactic fermentation of poorly ensilable leguminous plants (red clover and Caucasian goats rue) was performed by introduction of rifampin-resistant homofermenting representatives of the genus Lactobacillus (selected according to a set of technologically important characteristics). The results demonstrate that introduction of active local strains of lactobacteria, as well as the collection strain Lactobacillus plantarum BS933, enhances activation of ensiling and increases the quality of fodder, as assessed according to the standard criteria (a decrease in pH of the medium, the ratio of lactic acid to fatty acid homologues, and the composition of silage microflora).Translated from Prikladnaya Biokhimiya i Mikrobiologiya, Vol. 41, No. 1, 2005, pp. 79–89.Original Russian Text Copyright © 2005 by Shurkhno, Gareev, Abulkhanov, Validov, Boronin, Naumova.     

Fermentation of a high-protein plant biomass by introduction of lactic acid bacteria

Lactic acid bacteria displaying increased ability to produce lactic acid, medium proteolytic activity, and tolerance to osmotic stress were isolated under selective conditions from phyllosphere and rhizosphere of registered and raised cultivars of legumes. Lactic fermentation of poorly ensilable leguminous plants (red clover and Caucasian goat's rue) was performed by introduction of rifampin-resistant homofermenting representatives of the genus Lactobacillus (selected according to a set of technologically important characteristics). The results demonstrate that introduction of active local strains of lactobacteria, as well as the collection strain Lactobacillus plantarum BS 933, enhances activation of ensiling and increases the quality of fodder, as assessed according to the standard criteria (a decrease in pH of the medium, the ratio of lactic acid to fatty acid homologues, and the composition of silage microflora).     

Batch fermentations on synthetic mixed sugar and starch medium with amylolytic lactic acid bacteria

The green crop drying industry in Denmark uses Italian rye grass, clover, and alfalfa as raw materials for the production of green pellets. The green crop drying industry solves its energy economical problems by heating and pressing of the green crop before drying. The produced sidestream is called brown juice. Brown juice was shown to be an excellent medium for lactic acid fermentation. The aim of this study was to investigate the utilisation of brown juice in the production of polylactic acid, where wheat starch would be added to increase the lactic acid yield and, thus, the feasibility of the process. A number of amylolytic lactic acid bacteria have been identified, and in this work, six different strains were tested for their ability to produce α-amylase and to utilise all sugars with high lactic acid yield in a medium with a complex composition of free sugars (brown juice) and starch. Lactobacillus plantarum A6 was the only strain that showed both a good lactic acid production and utilisation of starch in this medium. The growth rate of this strain was approximately 0.4 h⁻¹ and the lactic acid yield was 0.7.     

Lactic acid production from agriculture residues

Various agriculture feedstock residues were evaluated for lactic acid production by simultaneous saccharification and fermentation (SSF) using Lactobacillus delbrueckii and Lactobacillus plantarum, without any additional nutrients. Lactic acid production was higher in alfalfa fiber and soya fiber compared to corncob (soft) and wheat straw. In Lactobacillus plantarum, the amount of lactic acid obtained from alfalfa fiber and soya fiber was 46 and 44 g/100 g fiber, respectively. However, in Lactobacillus delbrueckii, the lactic acid production in soya fiber was 44 g/100 g fiber and that of alfalfa was 32 g/100 g fiber. Small amounts of acetic acid were also produced from SSF of agricultural feedstocks residues. During SSF of alfalfa fiber, lactic acid production in both L. delbrueckii and L. plantarum was enhanced by adding pectinases and cellulases. Lactic acid production from alfalfa fiber did not change with increasing O₂ transfer rates in the fermentation medium, whereas acetic acid production in both Lactobacillus cultures increased with increasing O₂ transfer rates.     

Metabolic profile of ginkgo kernel juice fermented with lactic aicd bacteria: A potential way to degrade ginkgolic acids and enrich terpene lactones and phenolics

In this paper, the influence of lactic acid fermentation on the metabolic profile of ginkgo kernel juice was studied. For this purpose, three lactic acid bacteria (LAB), Lactobacillus acidophilus, Lactobacillus plantarum and Lactobacillus casei, were selected. The results showed that all the lactobacilli grew well in ginkgo kernel juice with viable cell counts exceeding 8.0 Log CFU/mL. The organic acid contents underwent dynamic changes, and the lactic acid production reached more than 3 g/L. The consumption of sugars and free amino acids by LAB was evident. Meanwhile, more than 70% of the ginkgolic acids were degraded by LAB, and the final concentrations in ginkgo kernel juice were below 1 mg/L after 48 h of fermentation. In contrast, the terpene lactones contents in fermented ginkgo kernel juice exceed 20 mg/L, which was 1.6-fold higher than that in the unfermented juice. Certain phenolics were significantly enriched, and the total phenolic content increased by approximately 9% through fermentation. In addition, lactic acid fermentation significantly enhanced the antioxidant and antimicrobial activities of ginkgo kernel juice. Overall, the results indicated that lactic acid fermentation can effectively improve the nutritional value and safety of ginkgo kernel juice.     

Lactic acid production from seaweed hydrolysate of Enteromorpha prolifera (Chlorophyta)

We examined the feasibility of using the green seaweed Enteromorpha prolifera as an alternative carbon source for chemical production. For this purpose, the chemical composition (proximate analysis, ultimate analysis, and mineral analysis) and acid hydrolysis of E. prolifera were investigated. In addition, lactic acid fermentation of E. prolifera hydrolysate was carried out using five Lactobacillus strains. The lactic acid yield, which is defined as the ratio of the lactic acid production to total sugar consumption, varied depending on the strains. Lactobacillus salivarius showed the highest lactic acid yield (68.5%), followed by Lactobacillus plantarum (66.0%), Lactobacillus rhamnosus (55.8%), Lactobacillus brevis (54.5%), and Lactobacillus casei (51.4%). The results shown in this study imply that E. prolifera would be competitive with lignocellulosic biomass such as corn stover in terms of lactic acid production yield and that green seaweed can be used as a feedstock for industrial production of chemicals.     

Fermentation of pomegranate juice by probiotic lactic acid bacteria

In this research, production of probiotic pomegranate juice through its fermentation by four strains of lactic acid bacteria: Lactobacillus plantarum, L. delbruekii, L. paracasei, L. acidophilus was examined. Fermentation was carried out at 30°C for 72 h under microaerophilic conditions. Microbial population, pH, titrable acidity, sugar and organic acid metabolism were measured during the fermentation period and the viability of all strains was also determined during the storage time at 4°C within 4 weeks. The results indicated that L. plantarum and L. delbruekii increased the pH sharply at the initial stages of fermentation and the sugar consumption was also higher in comparison with other strains, better microbial growth was also observed for these two strains during fermentation. Citric acid, as a major organic acid in pomegranate juice was significantly consumed by all probiotic lactic acid bacteria. L. plantarum and L. delbruekii showed higher viability during the storage time. Viable cells remained at their maximum level within 2 weeks but decreased dramatically after 4 weeks. Pomegranate juice was proved to be a suitable media for production of a fermented probiotic drink.     

Bioconversion of isoflavones during the fermentation of Samso-Eum with Lactobacillus strains

In this study, the possible application of Lactobacillus strains as a functional starter culture to ferment Samso-Eum (SE), an oriental herbal medicine formula, and the production of bioactive isoflavones (daidzein, genistein) were investigated. Four strains of Lactobacillus (Lactobacillus plantarum KFRI 144, L. amylophilus KFRI 161, L. curvatus KFRI 166, and L. bulgaricus KFRI 344) were used for SE fermentation. Declines in pH and in viable cell counts during fermentation were investigated and the quantification of isoflavones using HPLC were performed after fermentation at 37°C for 48 h. All the tested Lactobacillus strains lowered the pH level to approximately 3.6 after 48 h and showed the highest level of growth at 24 h during SE fermentation. During the SE fermentation of the four Lactobacillus strains, the conversion of isoflavone glycosides (daidzin, genistin) into bioactive aglycones (daidzein, genistein) was observed in all of the fermentations, but with different rates depending on the strains. L. plantarum KFRI 144 and L. amylophilus KFRI 161 exhibited the highest bioconversion rate of isoflavone glycosides into their bioactive aglycones. These results demonstrate that L. plantarum KFRI 144 and L. amylophilus KFRI 161 have potentials as functional starter cultures for manufacturing fermented SE with higher isoflavone bioavailability.     

Evolution of Yeasts and Lactic Acid Bacteria During Fermentation and Storage of Bordeaux Wines

The levels of yeasts and lactic acid bacteria that naturally developed during the vinification of two red and two white Bordeaux wines were quantitatively examined. Yeasts of the genera Rhodotorula, Pichia, Candida, and Metschnikowia occurred at low levels in freshly extracted grape musts but died off as soon as fermentation commenced. Kloeckera apiculata (Hanseniaspora uvarum), Torulopsis stellata, and Saccharomyces cerevisiae, the dominant yeasts in musts, proliferated to conduct alcoholic fermentation. K. apiculata and eventually T. stellata died off as fermentation progressed, leaving S. cerevisiae as the dominant yeast until the termination of fermentation by the addition of sulfur dioxide. At least two different strains of S. cerevisiae were involved in the fermentation of one of the red wines. Low levels of lactic acid bacteria (Pediococcus cerevisiae, Leuconostoc mesenteroides, and Lactobacillus spp.) were present in grape musts but died off during alcoholic fermentation. The malolactic fermentation developed in both red wines soon after alcoholic fermentation and correlated with the vigorous growth of at least three different strains of Leuconostoc oenos.     

Probiotic Strains Influence on Infant Microbiota in the In Vitro Colonic Fermentation Model GIS1

The main goal of our study was to evaluate the effect of the individual administration of five lyophilized lactic acid bacteria strains (Lactobacillus fermentum 428ST, Lactobacillus rhamnosus E4.2, Lactobacillus plantarum FCA3, Lactobacillus sp. 34.1, Weissella paramesenteroides FT1a) against the in vitro simulated microbiota of the human colon using the GIS1 system. The influence on the metabolic activity was also assessed by quantitative determination of proteins and polysaccharides at each segment of human colon. The obtained results indicated that the lactic acid bacteria L. rhamnosus E4.2 and W. paramesenteroides FTa1 had better efficiency in synthesising exopolysaccharides and also a better probiotic potential and therefore could be recommended for use in probiotics products or food industry.     

脱除游离棉酚乳酸菌的分离鉴定及益生性能研究

从藜麦茎叶样品中筛选分离出乳酸菌株,测定菌株脱除游离棉酚能力,通过人工胃液、人工肠液耐受实验、抑菌实验、抗生素敏感实验及表面特性研究菌株各项性能,并通过生理生化及16S rDNA法对菌株进行鉴定。结果表明,筛选出1株高效游离棉酚脱除乳酸菌LR002,其游离棉酚脱除率为62.87%,该菌株具有高效的耐人工胃液、肠液效果,且具有广谱抑菌作用,对抗生素不敏感,经鉴定该菌株为植物乳杆菌（Lactobacillus plantarum）。本研究旨在筛选出高效游离棉酚脱除乳酸菌菌株,为棉粕在畜禽生产中的合理利用提供参考。     

Natural populations of lactic acid bacteria associated with silage fermentation as determined by phenotype, 16S ribosomal RNA and recA gene analysis

One hundred and fifty-six strains isolated from corn (Zea mays L.), forage paddy rice (Oryza sativa L.), sorghum (Sorghum bicolor L.) and alfalfa (Medicago sativa L.) silages prepared on dairy farms were screened, of which 110 isolates were considered to be lactic acid bacteria (LAB) according to their Gram-positive and catalase-negative characteristics and, mainly, the lactic acid metabolic products. These isolates were divided into eight groups (A-H) based on the following properties: morphological and biochemical characteristics, γ-aminobutyric acid production capacity, and 16S rRNA gene sequences. They were identified as Weissella cibaria (36.4%), Weissella confusa (9.1%), Leuconostoc citreum (5.3%), Leuconostoc lactis (4.9%), Leuconostoc pseudomesenteroides (8.0%), Lactococcus lactis subsp. lactis (4.5%), Lactobacillus paraplantarum (4.5%) and Lactobacillus plantarum (27.3%). W. cibaria and W. confusa were mainly present in corn silages, and L. plantarum was dominant on sorghum and forage paddy rice silages, while L. pseudomesenteroides, L. plantarum and L. paraplantarum were the dominant species in alfalfa silage. The corn, sorghum and forage paddy rice silages were well preserved with lower pH values and ammonia-N concentrations, but had higher lactic acid content, while the alfalfa silage had relatively poor quality with higher pH values and ammonia-N concentrations, and lower lactic acid content. The present study confirmed the diversity of LAB species inhabiting silages. It showed that the differing natural populations of LAB on these silages might influence fermentation quality. These results will enable future research on the relationship between LAB species and silage fermentation quality, and will enhance the screening of appropriate inoculants aimed at improving such quality.     

Regulation of Lactobacillus plantarum contamination on the carbohydrate and energy related metabolisms of Saccharomyces cerevisiae during bioethanol fermentation

During the industrial bioethanol fermentation, Saccharomyces cerevisiae cells are often stressed by bacterial contaminants, especially lactic acid bacteria. Generally, lactic acid bacteria contamination can inhibit S. cerevisiae cell growth through secreting lactic acid and competing with yeast cells for micronutrients and living space. However, whether are there still any other influences of lactic acid bacteria on yeast or not? In this study, Lactobacillus plantarum ATCC 8014 was co-cultivated with S. cerevisiae S288c to mimic the L. plantarum contamination in industrial bioethanol fermentation. The contaminative L. plantarum-associated expression changes of genes involved in carbohydrate and energy related metabolisms in S. cerevisiae cells were determined by quantitative real-time polymerase chain reaction to evaluate the influence of L. plantarum on carbon source utilization and energy related metabolism in yeast cells during bioethanol fermentation. Contaminative L. plantarum influenced the expression of most of genes which are responsible for encoding key enzymes involved in glucose related metabolisms in S. cerevisiae. Specific for, contaminated L. plantarum inhibited EMP pathway but promoted TCA cycle, glyoxylate cycle, HMP, glycerol synthesis pathway, and redox pathway in S. cerevisiae cells. In the presence of L. plantarum, the carbon flux in S. cerevisiae cells was redistributed from fermentation to respiratory and more reducing power was produced to deal with the excess NADH. Moreover, L. plantarum contamination might confer higher ethanol tolerance to yeast cells through promoting accumulation of glycerol. These results also highlighted our knowledge about relationship between contaminative lactic acid bacteria and S. cerevisiae during bioethanol fermentation.     

Lactobacillus plantarum IFPL935 impacts colonic metabolism in a simulator of the human gut microbiota during feeding with red wine polyphenols

The colonic microbiota plays an important role in the bioavailibility of dietary polyphenols. This work has evaluated the impact on the gut microbiota of long-term feeding with both a red wine polyphenolic extract and the flavan-3-ol metabolizer strain Lactobacillus plantarum IFPL935. The study was conducted in the dynamic Simulator of the Human Intestinal Microbial Ecosystem (SHIME). The feeding of the gut microbiota model with red wine polyphenols caused an initial decrease in the counts of total bacteria in the ascending colon (AC), with Bacteroides, Clostridium coccoides/Eubacterium rectale and Bifidobacterium being the most affected bacterial groups. The bacterial counts recovered to initial numbers faster than the overall microbial fermentation and proteolysis, which seemed to be longer affected by polyphenols. Addition of L. plantarum IFPL935 helped to promptly recover total counts, Lactobacillus and Enterobacteriaceae and led to an increase in lactic acid formation in the AC vessel at the start of the polyphenol treatment as well as butyric acid in the transverse (TC) and descending (DC) vessels after 5 days. Moreover, L. plantarum IFPL935 favoured the conversion in the DC vessel of monomeric flavan-3-ols and their intermediate metabolites into phenylpropionic acids and in particular 3-(3′-hydroxyphenyl)propionic acid. The results open the possibilities of using L. plantarum IFPL935 as a food ingredient for helping individuals showing a low polyphenol-fermenting metabotype to increase their colonic microbial capacities of metabolizing dietary polyphenols.     

Kinetics and Modeling of Lactic Acid Production by Lactobacillus plantarum

An unstructured model was developed to describe bacterial growth, substrate utilization, and lactic acid production by Lactobacillus plantarum in cucumber juice. Significant lactic acid production occurred during growth, as well as stationary phases. The percentage of acid produced after growth ceased was a function of the medium composition. Up to 51% of the lactic acid was produced after growth ceased when NaCl was not present in the medium, whereas not more than 18% of the total lactic acid was produced after the growth ceased in presence of NaCl, probably because of an increase in the cell death rate. An equation relating the specific death rate and NaCl concentration was developed. With the kinetic model proposed by R. Luedeking and E. L. Piret (J. Biochem. Microbiol. Technol. Eng. 1:393-412, 1958) for lactic acid production rate, the growth-associated and non-growth-associated coefficients were determined as 51.9 (±4.2) mmol/g of cells and 7.2 (±0.9) mmol/g of cells h^-1 respectively. The model was demonstrated for batch growth of L. plantarum in cucumber juice. Mathematical simulations were used to predict the influence of variations in death rate, proton concentration when growth ceased, and buffer capacity of the juice on the overall fermentation process.     

Dynamics and Biodiversity of Populations of Lactic Acid Bacteria and Acetic Acid Bacteria Involved in Spontaneous Heap Fermentation of Cocoa Beans in Ghana

The Ghanaian cocoa bean heap fermentation process was studied through a multiphasic approach, encompassing both microbiological and metabolite target analyses. A culture-dependent (plating and incubation, followed by repetitive-sequence-based PCR analyses of picked-up colonies) and culture-independent (denaturing gradient gel electrophoresis [DGGE] of 16S rRNA gene amplicons, PCR-DGGE) approach revealed a limited biodiversity and targeted population dynamics of both lactic acid bacteria (LAB) and acetic acid bacteria (AAB) during fermentation. Four main clusters were identified among the LAB isolated: Lactobacillus plantarum, Lactobacillus fermentum, Leuconostoc pseudomesenteroides, and Enterococcus casseliflavus. Other taxa encompassed, for instance, Weissella. Only four clusters were found among the AAB identified: Acetobacter pasteurianus, Acetobacter syzygii-like bacteria, and two small clusters of Acetobacter tropicalis-like bacteria. Particular strains of L. plantarum, L. fermentum, and A. pasteurianus, originating from the environment, were well adapted to the environmental conditions prevailing during Ghanaian cocoa bean heap fermentation and apparently played a significant role in the cocoa bean fermentation process. Yeasts produced ethanol from sugars, and LAB produced lactic acid, acetic acid, ethanol, and mannitol from sugars and/or citrate. Whereas L. plantarum strains were abundant in the beginning of the fermentation, L. fermentum strains converted fructose into mannitol upon prolonged fermentation. A. pasteurianus grew on ethanol, mannitol, and lactate and converted ethanol into acetic acid. A newly proposed Weissella sp., referred to as “Weissella ghanaensis,” was detected through PCR-DGGE analysis in some of the fermentations and was only occasionally picked up through culture-based isolation. Two new species of Acetobacter were found as well, namely, the species tentatively named “Acetobacter senegalensis” (A. tropicalis-like) and “Acetobacter ghanaensis” (A. syzygii-like).     

Probiotic characteristics of Lactobacillus strains isolated from cheese and their antibacterial properties against gastrointestinal tract pathogens

In the present study, four Lactobacillus strains from the cheese were analyzed for its probiotic potential against enteropathogenic bacteria. The probiotic properties of the selected strains were also analyzed and the selected bacterial strains showed high tolerance in bile salts and organic acid. The strain L. plantarum LP049 showed maximum survival rate (92 ± 4.2% and 93.3 ± 2%) after 3 h of treatment at 0.25% (w/v) bile salts and 0.25% (w/v) organic acid concentrations. The ability of the Lactobacillus strains to adhere to human epithelial cells (HT-29 cell lines) was evaluated and L. plantarum LP049 showed maximum adhesion property (19.2 ± 1.1%) than other tested strains. The Lactobacillus strains produced lactic acid at various concentrations. Compared with other strains, maximum level of lactic acid (3.1 g/L), hydrogen peroxide (4.31 mM) and bacteriocin (31 AU/mg) was detected in LB049. The inhibitory activity of culture supernatant against various bacterial pathogens was observed. The zone of inhibition ranged between 6 ± 2 mm and 23 ± 2 mm. The cell free extract showed activity against, Escherichia coli (ATCC 10536), Salmonella enteritidis (ATCC 13076), Shigella flexneri (ATCC 29903), and Enterococcus faecium (ATCC 8459). Consequently, L. plantarum LP049 may be considered as a potential candidate for the production of novel bioactive metabolites for therapeutic and bio-protective applications.     

Characterization of Two Virulent Phages of Lactobacillus plantarum

We characterized two Lactobacillus plantarum virulent siphophages, ATCC 8014-B1 (B1) and ATCC 8014-B2 (B2), previously isolated from corn silage and anaerobic sewage sludge, respectively. Phage B2 infected two of the eight L. plantarum strains tested, while phage B1 infected three. Phage adsorption was highly variable depending on the strain used. Phage defense systems were found in at least two L. plantarum strains, LMG9211 and WCSF1. The linear double-stranded DNA genome of the pac-type phage B1 had 38,002 bp, a G+C content of 47.6%, and 60 open reading frames (ORFs). Surprisingly, the phage B1 genome has 97% identity with that of Pediococcus damnosus phage clP1 and 77% identity with that of L. plantarum phage JL-1; these phages were isolated from sewage and cucumber fermentation, respectively. The double-stranded DNA (dsDNA) genome of the cos-type phage B2 had 80,618 bp, a G+C content of 36.9%, and 127 ORFs with similarities to those of Bacillus and Lactobacillus strains as well as phages. Some phage B2 genes were similar to ORFs from L. plantarum phage LP65 of the Myoviridae family. Additionally, 6 tRNAs were found in the phage B2 genome. Protein analysis revealed 13 (phage B1) and 9 (phage B2) structural proteins. To our knowledge, this is the first report describing such high identity between phage genomes infecting different genera of lactic acid bacteria.