污泥厌氧消化产酸发酵过程中乙酸累积机制

[目的]研究污泥厌氧消化产挥发性脂肪酸(VFA)过程中的有机物碳流的转化机制,阐明乙酸累积机理。[方法]研究溴乙烷磺酸盐(BES)和氯仿(CHCl3)抑制模型下中间代谢产物和气体的累积,检测各产乙酸功能菌群数量,推断污泥产酸发酵过程中的有机物碳流方向和乙酸累积机理。[结果]BES模型乙酸浓度达27 mmol/L,fhs基因拷贝数比对照组高2-3倍,产氢产乙酸菌略有下降。CHCl3模型乙酸浓度达22 mmol/L,fhs基因拷贝数比BES组低一个数量级,产氢产乙酸菌下降明显。[结论]BES特异性较高,除产甲烷菌外对其他厌氧产酸细菌没有影响,乙酸浓度增加并且其主要来源于水解发酵产酸以及同型产乙酸过程。氯仿除抑制产甲烷菌外,对同型乙酸菌和产氢产乙酸菌也有强烈的抑制作用。     

有机溶剂对污泥厌氧发酵产酸的影响

有机酸是重要的化工原料,从市政污泥厌氧发酵过程提取有机酸、用于生产高附加值的产品可以实现废物资源化,本研究在确定最佳有机溶剂和萃取剂的基础上,考察了有机溶剂对城市污泥厌氧发酵生产有机酸的影响.结果表明,较合适的溶剂和萃取剂分别为磺化煤油和三烷基氧膦.少量磺化煤油对城市污泥发酵产生产有机酸有一定促进作用.     

城市污泥添加厨余垃圾厌氧发酵产挥发性脂肪酸的研究

为了考察污泥产酸工业化的可行性和添加食品废弃物对污泥产酸的影响,本实验在实验室的基础上进行扩大研究,考察了不同的底物总固体浓度对产挥发性脂肪酸的影响.结果显示添加厨余垃圾之后挥发性脂肪酸的累积量可达到17.62g/L.综合产挥发性脂肪酸效果、底物降解效果和产率等情况建议在较大规模的生产过程中选择130g/L的底物浓度为...     

多级逆流工艺促进城市污泥厌氧发酵生产挥发性脂肪酸

采用一种新型的厌氧发酵工艺——多级逆流发酵工艺对城市污泥进行厌氧发酵, 实现高效产挥发性脂肪酸的目的。结果表明, 实验条件下应用多级逆流发酵工艺, 挥发性脂肪酸浓度与产率分别达到(10.5±0.5) g/L和0.20 gVFAs/ gVS, 与普通厌氧发酵工艺相比, 分别提高了31%和54%。此外, 在多级逆流工艺中, 底物有机质去除率可达50%, 较普通厌氧发酵提高了37%。进一步分析多级逆流工艺产酸的机制, 发现产酸效率的提高在于降低了发酵产物对厌氧产酸细菌的抑制效应, 并且工艺的VFAs产率以及有机质去除率分别取决于第一级和第三级厌氧发酵过程。因此, 城市污泥采用多级逆流工艺厌氧发酵不仅能够有效促进挥发性脂肪酸的生成, 而且能够较大程度上提高污泥中有机质的去除率。     

对硝基苯酚冲击对UASB反应器中污泥活性和微生物种群的影响

研究了在稳定运行的上流式厌氧污泥床(Upflow Anaerobic Sludge Blanket,UASB)反应器中,对硝基苯酚(p-NP)冲击对反应器活性的影响。采用PCR-DGGE技术监测了反应器受对硝基苯酚冲击后微生物种群多样性的变化。实验结果表明,p-NP冲击对污泥的产甲烷活性和COD去除活性均有严重的抑制,污泥活性的恢复需要较长时间;高浓度冲击比低浓度冲击产生更严重的影响,20mg/L和40mg/Lp-NP冲击后污泥活性的恢复期分别为16d和27d。p-NP冲击后,真细菌和古菌的多样性均发生了显著的变化,而且p-NP冲击对真细菌的影响大于对古菌的影响。p-NP冲击后甲烷产量下降的主要与Methanosaetasp.的活性下降以及Methanomicrobia sp.丰度的下降有关。而冲击后真细菌的主要变化表现为Chloroflexisp.、Bacteroidesp.和Anaerovibrio sp.的丰度均下降;Rheinheimera sp.在受到20mg/Lp-NP冲击时丰度下降,继续受到40mg/Lp-NP冲击时该种群消失。Flavobacteria sp.是p-NP冲击后新出现的细菌种群,可能与p-NP的降解有关。     

降解苯胺和氯苯胺类污染物好氧污泥颗粒化及微生物种群结构分析

以序批式气提生物反应器(SABR)为平台,研究了苯胺和氯苯胺类有毒有机废水处理过程好氧污泥颗粒化。结果表明,通过缩短污泥沉降时间、逐步提升目标污染物进水负荷,反应器连续运行3个月,最终在污泥沉降时间5min、COD负荷1.0~3.6kg/(m3.d)、苯胺和氯苯胺负荷1kg/(m3.d)条件下实现污泥颗粒化,COD、苯胺和氯苯胺去除率分别稳定在90%、99.9%以上;获得的成熟好氧颗粒粒径在0.45~2.5mm,SOUR稳定在150mgDO/(gVSS·h)以上,颗粒污泥EPS中PN含量为28.0±1.9mg/gVSS,PN/PS比值为6.5mg/mg,苯胺类比降解速率达0.18g/(g·d);应用PCR-DGGE分子指纹图谱技术分析了稳定运行的颗粒化反应器内好氧污泥微生物种群结构,结果表明好氧颗粒内主要细菌分属β-Proteobacteria、γ-Proteobacteria及Flavobacteria等类群,优势菌为Pseudomonas sp.、Flavobacterium sp.;与已获得的降解氯苯胺好氧颗粒相比,苯胺存在下培养获得的好氧颗粒污泥微生物菌群结构更为丰富。     

构树的污泥适应性及养分和重金属吸收累积特征

构树是我国重要速生经济树种,具有适应性强、生物量大和重金属富集能力强等优点,而污泥中含有大量养分和重金属,在污泥中种植构树有望同时实现污泥生态修复和构树资源生产。本研究通过盆栽试验,分析在对照(赤红壤)、50%污泥(污泥、赤红壤混合基质,重量比各50%)和100%污泥基质中构树生长及不同部位(根、茎、叶)养分和重金属吸收累积特征,并通过主成分分析和隶属度函数对吸收累积能力进行综合评价。结果表明: 构树在50%和100%污泥中均可正常生长且株高、生物量显著高于对照,在100%污泥中长势最好,质量指数(1.02)分别是对照和50%污泥处理的4.3和2.4倍。50%和100%污泥处理构树各部位N含量和茎P含量显著高于对照,100%污泥处理构树茎、叶K含量显著低于对照。构树对Cu、Zn、Pb、Cd、Ni的吸收部位以根为主,根系重金属含量与污泥比例呈正相关,叶Pb、Cd含量符合《饲料卫生标准》(GB 13078—2017)。构树对Cd的吸收累积效果好于其他重金属元素。与对照相比,50%和100%污泥处理构树根部Zn、Pb、Cd滞留率显著提高(57.8%~85.8%),100%污泥处理构树根部Cu、Ni滞留率显著提高(67.5%和74.8%)。污泥处理全株养分和重金属累积量均显著大于对照,其中100%污泥处理显著大于50%污泥处理。与50%污泥处理相比,100%污泥处理构树各部位及全株养分和重金属累积量大幅提高。不同处理下构树污泥适应性和元素吸收累积的综合评价得分为100%污泥(0.848)>50%污泥(0.344)>对照(0.080)。构树对污泥具有良好的适应性,在纯污泥中能够正常生长并具有较强的吸收累积养分和重金属能力,可在修复污泥的同时进行构树资源生产。     

接种量及秸秆加入量对城市污泥厌氧发酵产气特性的影响

研究不同接种量及秸秆加入量条件下污泥的厌氧消化产气规律,并分析厌氧消化前后污泥性质的变化。实验结果表明:体积比(下同)为10%沼液接种回流污泥(碳氮比为6.16)的产气效率优于20%沼液接种回流的污泥(碳氮比为5.99),但不显著;秸秆的加入使污泥产气效率明显提高,且秸秆加入量对产气量也有显著影响。接种体积比为20%沼液的处理污泥(1600mL泥)加入20g秸秆(碳氮比为7.53)后,比加入15g秸秆(碳氮比为7.15)产气量增加783mL,碳氮比最高的为10%沼液、15g秸秆污泥,为7.94,其产气总量和CH4含量也较高。同时,厌氧消化改变了污泥的理化性质,消化后的污泥有机质质量分数(不包括秸秆)平均降低2.4%。     

导电碳颗粒促进污泥厌氧消化及微生物种间电子传递的研究进展

添加导电碳颗粒能够促进厌氧消化过程稳定性、底物降解率以及产沼气品质的同步提高。本文总结了以活性炭和生物炭为代表的导电碳颗粒对城市污泥厌氧消化的影响,探讨了导电碳颗粒促进城市污泥厌氧消化的机理,阐述了导电碳颗粒介导的微生物直接种间电子传递(Directinterspecies electrontransfer,DIET)在强化污泥厌氧消化中的作用机制,分析了复杂厌氧消化体系中微生物DIET互营关系的研究现状,同时对导电碳颗粒的物理化学特性及其对污泥厌氧消化产甲烷的影响进行了分析,最后对未来导电碳颗粒促进城市污泥厌氧消化的研究进行了展望。     

Degradation ofortho-chlorophenol,para-chlorophenol, and 2,4-dichlorophenoxyacetic acid by the bacterial community of anaerobic sludge

The bacterial community of anaerobic sludge could degradeo-chlorophenol,p-chlorophenol, and 2,4-dichlorophenoxyacetic acid at concentrations as high as 100 mg/l. The time needed for the degradation of a given chlorinated phenol derivative increased 1.5- to 2-fold upon a twofold increase in its concentration (from 50 to 100 mg/l). The duration of the adaptation period depended on the compound studied and on its concentration. The degradation of 2,4-dichlorophenoxyacetic acid proceeded via 2,4-dichlorophenol andp-chlorophenol as intermediates; the degradation ofo-chlorophenol occurred with the formation of phenol. The dynamics ofp-chlorophenol degradation and chloride ion accumulation were studied.     

Fermentative hydrogen production and bacterial community structure in high-rate anaerobic bioreactors containing silicone-immobilized and self-flocculated sludge

A novel continuously stirred anaerobic bioreactor (CSABR) seeded with silicone-immobilized sludge was developed for high-rate fermentative H2 production using sucrose as the limiting substrate. The CSABR system was operated at a hydraulic retention time (HRT) of 0.5-6 h and an influent sucrose concentration of 10-40 g COD/L. With a high feeding sucrose concentration (i.e., 30-40 g COD/L) and a short HRT (0.5 h), the CSABR reactor produced H2 more efficiently with the highest volumetric rate (VH2) of 15 L/h/L (i.e., 14.7 mol/d/L) and an optimal yield of ca. 3.5 mol H2/mol sucrose. The maximum VH2 value obtained from this work is much higher than any other VH2 values ever documented. Formation of self-flocculated granular sludge occurred during operation at a short HRT. The granule formation is thought to play a pivotal role in the dramatic enhancement of H2 production rate, because it led to more efficient biomass retention. A high biomass concentration of up to 35.4 g VSS/L was achieved even though the reactor was operated at an extremely low HRT (i.e., 0.5 h). In addition to gaining high biomass concentrations, formation of granular sludge also triggered a transition in bacterial community structure, resulting in a nearly twofold increase in the specific H2 production rate. According to denatured-gradient-gel-electrophoresis analysis, operations at a progressively decreasing HRT resulted in a decrease in bacterial population diversity. The culture with the best H2 production performance (at HRT = 0.5 h and sucrose concentration = 30 g COD/L) was eventually dominated by a presumably excellent H2-producing bacterial species identified as Clostridium pasteurianum.     

Efficient,high-speed methane fermentation for sewage sludge using subcritical water hydrolysis as pretreatment

A novel biomass-energy process for the production of methane from sewage sludge using a subcritical water (sub-CW) hydrolysis reaction as pretreatment is proposed. The main substances of sewage sludge hydrolyzed by sub-CW at 513 K for 10 min were acetic acid, formic acid, pyroglutamic acid, alanine, and glycine. Fermentation experiments were conducted in an anaerobic-sludge reactor for two different samples: real sewage sludge and a model solution containing components typically produced by the sub-CW pretreatment of sewage sludge. In the experiment for the sub-CW pretreatment of sewage sludge, methane generation was twice that for non-pretreatment after 3 days of incubation. In the model experiment, the methane conversion was about 40% with the application of mixture of organic acids and amino acids after 5 days of incubation. Furthermore, the methane conversion was about 60% for 2 days when only organic acids, such as acetic acid and formic acid, were applied. Because acetic acid is the key intermediate and main precursor of the methanogenesis step, fermentation experiments were conducted in an anaerobic-sludge reactor with high concentrations of acetic acid (0.01–0.1 M). Nearly 100% of acetic acid was converted to methane and carbon dioxide in 1–3 days.     

Effect of low power ultrasonic radiation on anaerobic biodegradability of sewage sludge

The effect of low power ultrasonic radiation on anaerobic biodegradability of sewage sludge was investigated. For this purpose, soluble substances and variation of microbial system of sewage sludge subjected to low power ultrasonic radiation were tested. The well known hydromechanical shear forces and heating effect of low frequency ultrasound plays a major role in the sludge pre treatment process. More, the increase of soluble substance may partly result from the destruction of microbial cell by excess ultrasonic pretreatment, which will inhibit the anaerobic process. By orthogonal tests, the optimal parameters were found to be an exposure time of 15 min, ultrasonic intensity of 0.35 W/cm² and ultrasonic power density of 0.25 W/ml. Under the optimal condition, anaerobic biodegradability of sewage sludge (R_(vss/ss) %) was increased by 67.6%. Consequently, it can be concluded that low power ultrasonic pretreatment is a valid method for improving anaerobic biodegradability of sewage sludge.     

Correlation between bacterial indicators and bacteriophages in sewage and sludge

The use of bacteriophages as potential indicators of faecal pollution has recently been studied. The correlation of the number of bacterial indicators and the presence of three groups of bacteriophages, namely somatic coliphages (SOMCPH), F-RNA-specific phages (FRNAPH) and phages of Bacteroides fragilis (BFRPH), in raw and treated wastewater and sludge is presented in this study. Raw and treated wastewater and sewage sludge samples from two wastewater treatment plants in Athens were collected on a monthly basis, over a 2-year period, and analysed for total coliforms, Escherichia coli, intestinal enterococci and the three groups of bacteriophages. A clear correlation between the number of bacterial indicators and the presence of bacteriophages was observed. SOMCPH may be used as additional indicators, because of their high densities and resistance to various treatment steps.     

pH、温度和癸酸对厌氧颗粒污泥产甲烷毒性关系的研究

在间歇培养中研究了癸酸对UASB反应器厌氧颗粒污泥的产甲烷毒性,并考察了pH、温度和癸酸抑制的关系。结果表明,癸酸对厌氧颗粒污泥产甲烷活性有强烈的抑制,对厌氧颗粒污泥比产甲烷活性产生50％抑制的浓度为1．9mmol/L。pH影响癸酸在液相中的存在形式,pH越低,游离癸酸比例越大,对厌氧颗粒污泥的抑制越严重。高温条件下癸酸使厌氧颗粒污泥的结构变得松散,对厌氧颗粒污泥产甲烷毒性较中温和低温条件下严重。     

Eliminating methanogenic activity in hydrogen reactor to improve biogas production in a two-stage anaerobic digestion process co-digesting municipal food waste and sewage sludge

Laboratory scale two-stage anaerobic digestion process model was operated for 280 days to investigate the feasibility to produce both hydrogen and methane from a mixture feedstock (1:1 (v/v)) of municipal food waste and sewage sludge. The maximum hydrogen and methane yields obtained in the two stages were 0.93 and 9.5 mL/mL feedstock. To eliminate methanogenic activity and obtain substantial hydrogen production in the hydrogen reactor, both feedstock and mixed liquor required treatment. The heat treatment (100 °C, 10 min) for feedstock and a periodical treatment (every 2-5 weeks, either heating, removal of biomass particles or flushing with air) for mixed liquor were effective in different extent. The methane production in the second stage was significantly improved by the hydrogen production in the first stage. The maximum methane production obtained in the period of high hydrogen production was more than 2-fold of that observed in the low hydrogen production period.     

Biomass adaptation over anaerobic co-digestion of sewage sludge and trapped grease waste

The feasibility of sewage sludge co-digestion using intermediate waste generated inside a wastewater treatment plant, i.e. trapped grease waste from the dissolved air flotation unit, has been assessed in a continuous stirred lab reactor operating at 35 °C with a hydraulic retention time of 20 days. Three different periods of co-digestion were carried out as the grease waste dose was increased. When the grease waste addition was 23% of the volatile solids fed (organic loading rate 3.0 kg_COD m⁻³ d⁻¹), an increase in methane yield of 138% was reported. Specific activity tests suggested that anaerobic biomass had adapted to the co-substrate. The adapted inoculum showed higher acetoclastic methanogenic and β-oxidation synthrophic acetogenic activities but lower hydrogenotrophic methanogenic activity. The results indicate that a slow increase in the grease waste dose could be a strategy that favours biomass acclimation to fat-rich co-substrate, increases long chain fatty acid degradation and reduces the latter’s inhibitory effect.     

厌氧颗粒污泥微生物群落结构与功能的研究进展

厌氧颗粒污泥(anaerobicgranularsludge,AnGS)是由多种功能微生物组成的自固定化聚集体,具有容积负荷高、工艺简单、剩余污泥产量低等优点,在废水处理领域中显示出巨大的技术和经济潜力,被认为是一种很有前景的低碳废水处理工艺。本文系统总结了近年来厌氧颗粒污泥微生物结构和功能的研究成果,从微生物学角度讨论了厌氧颗粒污泥形成及稳定的影响因素,并对今后厌氧颗粒污泥的研究进行了展望,以期为后续厌氧颗粒污泥技术的深入研究和实际工程应用提供参考。