利用纤维床反应器固定化发酵生产丙酸

构建了一种纤维床反应器(FBB), 并将其应用于丙酸的生产。将棉纤维绕成桶状, 固定于反应器中, 即可用于丙酸固定化发酵。以40 g/L的葡萄糖为碳源, 与游离细胞相比, 利用FBB生产丙酸, 丙酸产量由14.58 g/L提高至20.41 g/L, 发酵时间由120 h缩短至60 h。研究了不同糖浓度条件下FBB生产丙酸情况, 并将补料策略应用于丙酸发酵中。结果表明: 补料发酵能够有效改善Propionibacterium freudenreichii CCTCC M207015在高糖条件下丙酸对葡萄糖转化率较低、副产物较多的问题。经补料发酵280 h, 丙酸产量达45.91 g/L, 丙酸质量约占有机酸总质量比例为72.31%。     

利用纤维床反应器固定化发酵生产丙酸

构建了一种纤维床反应器(FBB), 并将其应用于丙酸的生产。将棉纤维绕成桶状, 固定于反应器中, 即可用于丙酸固定化发酵。以40 g/L的葡萄糖为碳源, 与游离细胞相比, 利用FBB生产丙酸, 丙酸产量由14.58 g/L提高至20.41 g/L, 发酵时间由120 h缩短至60 h。研究了不同糖浓度条件下FBB生产丙酸情况, 并将补料策略应用于丙酸发酵中。结果表明: 补料发酵能够有效改善Propionibacterium freudenreichii CCTCC M207015在高糖条件下丙酸对葡萄糖转化率较低、副产物较多的问题。经补料发酵280 h, 丙酸产量达45.91 g/L, 丙酸质量约占有机酸总质量比例为72.31%。     

Propionic acid fermentation by Propionibacterium freudenreichii CCTCC M207015 in a multi-point fibrous-bed bioreactor

Propionic acid was produced in a multi-point fibrous-bed (MFB) bioreactor by Propionibacterium freudenreichii CCTCC M207015. The MFB bioreactor, comprising spiral cotton fiber packed in a modified 7.5-l bioreactor, was effective for cell-immobilized propionic acid production compared with conventional free cell fermentation. Batch fermentations at various glucose concentrations were investigated in the MFB bioreactor. Based on analysis of the time course of production, a fed-batch strategy was applied for propionic acid production. The maximum propionic acid concentration was 67.05 g l⁻¹ after 496 h of fermentation, and the proportion of propionic acid to total organic acids was approximately 78.28% (w/w). The MFB bioreactor exhibited excellent production stability during batch fermentation and the propionic acid productivity remained high after 78 days of fermentation.     

Enhanced propionic acid production from Jerusalem artichoke hydrolysate by immobilized Propionibacterium acidipropionici in a fibrous-bed bioreactor

Propionic acid is an important chemical that is widely used in the food and chemical industries. To enhance propionic acid production, a fibrous-bed bioreactor (FBB) was constructed and Jerusalem artichoke hydrolysate was used as a low-cost renewable feedstock for immobilized fermentation. Comparison of the kinetics of immobilized-cell fermentation using the FBB with those of fed-batch free-cell fermentation showed that immobilized-cell fermentation gave a much higher propionic acid concentration (68.5 vs. 40.6 g/L), propionic acid yield (0.434 vs. 0.379 g/g) and propionic acid productivity (1.55 vs. 0.190 g/L/h) at pH 6.5. Furthermore, repeated batch fermentation, carried out to evaluate the stability of the FBB system, showed that long-term operation with a high average propionic acid yield of 0.483 g/g, high productivity of 3.69 g/L/h and propionic acid concentration of 26.2 g/L were achieved in all eight repeated batches during fermentation for more than 200 h. It is thus concluded that the FBB culture system can be utilized to realize the economical production of propionic acid from Jerusalem artichoke hydrolysate during long-term operation.     

Acetate production from whey lactose using co-immobilized cells of homolactic and homoacetic bacteria in a fibrous-bed bioreactor

Acetate was produced from whey lactose in batch and fed-batch fermentations using co-immobilized cells of Clostridium formicoaceticum and Lactococcus lactis. The cells were immobilized in a spirally wound fibrous sheet packed in a 0.45-L column reactor, with liquid circulated through a 5-L stirred-tank fermentor. Industrial-grade nitrogen sources, including corn steep liquor, casein hydrolysate, and yeast hydrolysate, were studied as inexpensive nutrient supplements to whey permeate and acid whey. Supplementation with either 2.5% (v/v) corn steep liquor or 1.5 g/L casein hydrolysate was adequate for the cocultured fermentation. The overall acetic acid yield from lactose was 0.9 g/g, and the productivity was 0.25 g/(L h). Both lactate and acetate at high concentrations inhibited the homoacetic fermentation. To overcome these inhibitions, fed-batch fermentations were used to keep lactate concentration low and to adapt cells to high-concentration acetate. The final acetate concentration obtained in the fed-batch fermentation was 75 g/L, which was the highest acetate concentration ever produced by C. formicoaceticum. Even at this high acetate concentration, the overall productivity was 0.18 g/(L h) based on the total medium volume and 1.23 g/(L h) based on the fibrous-bed reactor volume. The cells isolated from the fibrous-bed bioreactor at the end of this study were more tolerant to acetic acid than the original culture used to seed the bioreactor, indicating that adaptation and natural selection of acetate-tolerant strains occurred. This cocultured fermentation process could be used to produce a low-cost acetate deicer from whey permeate and acid whey.     

A novel recycle batch immobilized cell bioreactor for propionate production from whey lactose

Recycle batch fermentations using immobilized cells of Propionibacterium acidipropionici were studied for propionate production from whey permeate, de-lactose whey permeate, and acid whey. Cells were immobilized in a spirally wound fibrous sheet packed in a 0.5-L column reactor, which was connected to a 5-L stirred tank batch fermentor with recirculation. The immobilized cells bioreactor served as a breeder for these recycle batch fermentations. High fermentation rates and conversions were obtained with these whey media without nutrient supplementation. It took approximately 55 h to ferment whey permeate containing approximately 45 g/L lactose to approximately 20 g/L propionic acid. Higher propionate concentrations can be produced with various concentrated whey media containing more lactose. The highest propionic acid concentration obtained with the recycle batch reactor was 65 g/L, which is much higher than the normal maximum concentration of 35 to 45 g/L reported in the literature. The volumetric productivity ranged from 0.22 g/L . h to 0.47 g/L . h, depending on the propionate concentration and whey medium used. The corresponding specific cell productivity was 0.033 to 0.07 g/L . g cell. The productivity increased to 0.68 g/L . h when whey permeate was supplemented with 1% (w/v) yeast extract. Compared with conventional batch fermentation, the recycle batch fermentation with the immobilized cell bioreactor allows faster fermentation, produces a higher concentration of product, and can be run continually without significant downtime. The process also produced similar fermentation results with nonsterile whey media. (c) 1995 John Wiley & Sons, Inc.     

Enhanced butyric acid tolerance and bioproduction by Clostridium tyrobutyricum immobilized in a fibrous bed bioreactor

Repeated fed‐batch fermentation of glucose by Clostridium tyrobutyricum immobilized in a fibrous bed bioreactor (FBB) was successfully employed to produce butyric acid at a high final concentration as well as to adapt a butyric‐acid‐tolerant strain. At the end of the eighth fed‐batch fermentation, the butyric acid concentration reached 86.9 ± 2.17 g/L, which to our knowledge is the highest butyric acid concentration ever produced in the traditional fermentation process. To understand the mechanism and factors contributing to the improved butyric acid production and enhanced acid tolerance, adapted strains were harvested from the FBB and characterized for their physiological properties, including specific growth rate, acid‐forming enzymes, intracellular pH, membrane‐bound ATPase and cell morphology. Compared with the original culture used to seed the bioreactor, the adapted culture showed significantly reduced inhibition effects of butyric acid on specific growth rate, cellular activities of butyric‐acid‐forming enzyme phosphotransbutyrylase (PTB) and ATPase, together with elevated intracellular pH, and elongated rod morphology. Biotechnol. Bioeng. 2011; 108:31–40. © 2010 Wiley Periodicals, Inc.     

Enhanced propionic acid fermentation by Propionibacterium acidipropionici mutant obtained by adaptation in a fibrous-bed bioreactor

Fed-batch fermentations of glucose by P. acidipropionici ATCC 4875 in free-cell suspension culture and immobilized in a fibrous-bed bioreactor (FBB) were studied. The latter produced a much higher propionic acid concentration (71.8 +/- 0.8 g/L vs. 52.2 +/- 1.1 g/L), indicating enhanced tolerance to propionic acid inhibition by cells adapted in the FBB. Compared to the free-cell fermentation, the FBB culture produced 20-59% more propionate (0.40-0.65 +/- 0.02 g/g vs. 0.41 +/- 0.02 g/g), 17% less acetate (0.10 +/- 0.01 g/g vs. 0.12 +/- 0.02 g/g), and 50% less succinate (0.09 +/- 0.02 g/g vs. 0.18 +/- 0.03 g/g) from glucose. The higher propionate production in the FBB was attributed to mutations in two key enzymes, oxaloacetate transcarboxylase and propionyl CoA: succinyl CoA transferase, leading to the production of propionic acid from pyruvate. Both showed higher specific activity and lower sensitivity to propionic acid inhibition in the mutant than in the wild type. In contrast, the activity of PEP carboxylase, which converts PEP directly to oxaloacetate and leads to the production of succinate from glucose, was generally lower in the mutant than in the wild type. For phosphotransacetylase and acetate kinase in the acetate formation pathway, however, there was no significant difference between the mutant and the wild type. In addition, the mutant had a striking change in its morphology. With a threefold increase in its length and approximately 24% decrease in its diameter, the mutant cell had an approximately 10% higher specific surface area that should have made the mutant more efficient in transporting substrates and metabolites across the cell membrane. A slightly lower membrane-bound ATPase activity found in the mutant also indicated that the mutant might have a more efficient proton pump to allow it to better tolerate propionic acid. In addition, the mutant had more longer-chain saturated fatty acids (C17:0) and less unsaturated fatty acids (C18:1), both of which could decrease membrane fluidity and might have contributed to the increased propionate tolerance. The enhanced propionic acid production from glucose by P. acidipropionici was thus attributed to both a high viable cell density maintained in the reactor and favorable mutations resulted from adaptation by cell immobilization in the FBB.     

Fed-batch fermentation with and without on-line extraction for propionic and acetic acid production byPropionibacterium acidipropionici

Fed-batch propionic and acetic acid fermentations were performed in semi-defined laboratory medium and in corn steep liquor withPropionibacterium acidipropionici strain P9. On average, over four experiments, 34.5 g/l propionic acid and 12.8 g/l acetic acid were obtained in about 146 h in laboratory medium with 79 g/l glucose added over five feeding periods. The highest concentration of propionic acid, 45 g/l, was obtained when the glucose concentration was not allowed to drop to zero. In corn steep liquor 35 g/l propionic acid and 11 g/l acetic acid were produced in 108 h from 59.4 g/l total lactic acid provided as seven feedings of corn steep liquor. Extractive fed-batch fermentations were conducted in semi-defined medium using either flat-sheet-supported liquid membranes or hollow-fiber membrane extraction to remove organic acids from the culture medium. As operated during the course of the fermentation, these systems extracted 25% and 22% of the acetic acid and 36.5% and 44.5% of the propionic acid, respectively, produced in the fermentation. Total amounts of acids produced were about the same as in comparable nonextractive fermentations: 30–37 g/l propionic acid and 13 g/l acetic acid were produced in 150 h. Limitations on acid production can be attributed to limited substrate feed, not to failure of the extraction system.Journal paper J-16303 of the Iowa Agriculture and Home Economics Experiment Station, Ames, Iowa. Project 3122.     

Continuous propionate production from whey permeate using a novel fibrous bed bioreactor

Continuous production of propionate from whey lactose by Propionibacterium acidipropionici immobilized in a novel fibrous bed bioreactor was studied. In conventional batch propionic acid fermentation, whey permeate without nutrient supplementation was unable to support cell growth and failed to give satisfactory fermentation results for over 7 days. However, with the fibrous bed bioreactor, a high fermentation rate and high conversion were obtained with plain whey permeate and de-lactose whey permeate. About 2% (wt/vol) propionic acid was obtained from a 4.2% lactose feed at a retention time of 35 to 45 h. The propionic acid yield was approximately 46% (wt/vol) from lactose. The optimal pH for fementation was 6.5, and lower fermentation rates and yields were obtained at lower pH values. The optimal temperature was 30 degrees C, but the temperature effect was not dramatic in the range of 25 to 35 degrees C. Addition of yeast extract and trypticase to whey permeate hastened reactor startup and increased the fermentation rate and product yields, but the addition was not required for long-term reactor performance. The improved fermentation results with the immobilized cell bioreactor can be attributed to the high cell density, approximately 50 g/L, attained in the bioreactor, Cells were immobilized by loose attachement to fiber surfaces and entrapment in the void spaces within the fibrous matrix, thus allowing constant renewal of cells. Consequently, this bioreactor was able to operate continuously for 6 months without encountering any clogging, degeneration, or contamination problems. Compared to conventional batch fermentors, the new bioreactor offers many advantages for industrial fermentation, including a more than 10-fold increase in productivity, acceptance of low-nutrient feedstocks such as whey permeate, and resistance to contamination. (c) 1994 John Wiley & Sons, Inc.     

利用固定化米根霉在三相流化床中发酵生成L-乳酸

用聚氨酯泡沫吸附固定米根霉菌丝,在三相流化床中对葡萄糖、木糖以及木糖渣的纤维素酶解液等不同碳源进行Ｌ－乳酸发酵研究,并对游离菌丝和固定化菌丝发酵Ｌ－乳酸进行了比较。结果表明,聚氨酯泡沫是米根霉的良好载体,具有经济、高效等特点。实验条件下,不同碳源的乳酸转化率分别为：葡萄糖,８２．５％;木糖,５３．８％;木糖渣酶水解液,７１．９％。三相流化床中固定化米根霉产酸速率（对葡萄糖）为１９．１ｇ．ｈ＾－１．     

Propionic acid production by immobilized cells of a propionate-tolerant strain of Propionibacterium acidipropionici

Cells of the propionate-tolerant strain Propionibacterium acidipropionici P200910, immobilized in calcium alginate beads, were tested for propionic and acetic acid production both in a semidefined laboratory medium and in corn steep liquor in batch, fed-batch, and continuous fermentation. Cell density was about 9.8 × 10⁹ cells/g (wet weight) of beads, and beads were added to the medium at 0.1 g (wet weight) beads/ml. Beads could be reused for several consecutive batch fermentations; propionic acid production in the tenth cycle was about 50%–70% of that in the first cycle. In batch culture complete substrate consumption (glucose in semidefined medium, lactate in corn steep liquor) and maximum acid production were seen within 36 h, and acid yields from the substrate were higher than in free-cell fermentations. Fed-batch fermentations were incubated up to 250 h. Maximum propionic acid concentrations obtained were 45.6 g/l in corn steep liquor and 57 g/l in semidefined medium; this is the highest concentration achieved to date in our laboratory. Maximum acetic acid concentrations were 17 g/l and 12 g/l, respectively. In continuous fermentation of semidefined medium, dilution rates up to 0.31 h^–1 could be used, which gave higher volumetric productivities (0.96 g l^–1 h^–1 for propionic acid and 0.26 g l^–1 h^–1 for acetic acid) than we have obtained with free cells. Corn steep liquor shows promise as an inexpensive medium for production of both acids by immobilized cells of propionibacteria.Journal paper no. J- 15614 of the Iowa Agriculture and Home Economics Experiment Station, Ames, Iowa. Project no. 3122     

Extractive fermentation for butyric acid production from glucose by Clostridium tyrobutyricum

A novel extractive fermentation for butyric acid production from glucose, using immobilized cells of Clostridium tyrobutyricum in a fibrous bed bioreactor, was developed by using 10% (v/v) Alamine 336 in oleyl alcohol as the extractant contained in a hollow-fiber membrane extractor for selective removal of butyric acid from the fermentation broth. The extractant was simultaneously regenerated by stripping with NaOH in a second membrane extractor. The fermentation pH was self-regulated by a balance between acid production and removal by extraction, and was kept at approximately pH 5.5 throughout the study. Compared with conventional fermentation, extractive fermentation resulted in a much higher product concentration (>300 g/L) and product purity (91%). It also resulted in higher reactor productivity (7.37 g/L. h) and butyric acid yield (0.45 g/g). Without on-line extraction to remove the acid products, at the optimal pH of 6.0, the final butyric acid concentration was only approximately 43.4 g/L, butyric acid yield was 0.423 g/g, and reactor productivity was 6.77 g/L. h. These values were much lower at pH 5.5: 20.4 g/L, 0.38 g/g, and 5.11 g/L. h, respectively. The improved performance for extractive fermentation can be attributed to the reduced product inhibition by selective removal of butyric acid from the fermentation broth. The solvent was found to be toxic to free cells in suspension, but not harmful to cells immobilized in the fibrous bed. The process was stable and provided consistent long-term performance for the entire 2-week period of study.     

Continuous propionic acid fermentation by immobilized Propionibacterium acidipropionici in a novel packed-bed bioreactor

Continuous propionic acid fermentations of lactate by Propionibacterium acidipropionici were studied in spiral wound fibrous bed bioreactors. Cells were imobilized by natural attachment to fiber surfaces and entrapment in the void volume within the fibrous matrix. A high cell density of approximately 37 g/L was attained in the reactor and the reactor productivity was approximately 4 times higher than that from a conventional batch fermentation. The bioreactor was able to operate continuously for 4 months without encountering any clogging, degeneration, or contamination problems. Also, the reactor could accept low-nutrient and low-pH feed without sacrificing much in reactor productivity. This new type of immobilized cell bioreactor is scalable and thus is suitable for industrial production of propionate. (c) 1992 John Wiley & Sons, Inc.     

Propionic acid fermentation of lactose by Propionibacterium acidipropionici: effects of pH

Batch propionic acid fermentation of lactose by Propionibacterium acidipropionici were studied at various pH values ranging from 4.5 to 7.12. The optimum pH range for cell growth was between 6.0 and 7.1, where the specific growth rate was approximately 0.23 h(-1). The specific growth rate decreased with the pH in the acids have been identified as the two major fermentation products from lactose. The production of propionic acid was both growth and nongrowth associated, while acetic acid formation was closely associated with cell growth. The propionic acid yield increased with decreasing pH; It changed from approximately 33% (w/w) at pH 6.1-7.1 to approximately 63% at pH 4.5-5.0. In contrast, the acetic acid yield was not significantly affected by the pH; it remained within the range of 9%-12% at all pH values. Significant amounts of succinic and pyruvic acids were also formed during propionic acid fermentation of lactose. However, pyruvic acid was reconsumed and disappeared toward the end of the fermentation. The succinic acid yield generally decreased with the pH, from a high value of 17% at pH 7.0 to a low 8% at pH 5.0 Effects of growth nutrients present in yeast ex-tract on the fermentation were also studied. In general, the same trend of pH effects was found for fermentations with media containing 5 to 10 g/L yeast extract. However, More growth nutrients would be required for fermentations to be carried out efficienytly at acidic pH levels.     

Propionic acid fermentation by Propionibacterium acidipropionici: effect of growth substrate

Summary Batch propionic acid fermentations by Propionibacterium acidipropionici with lactose, glucose, and lactate as the carbon source were studied. In addition to propionic acid, acetic acid, succinic acid and CO₂ were also formed from lactose or glucose. However, succinic acid was not produced in a significant amount when lactate was the growth substrate. Compared to fermentations with lactose or glucose at the same pH, lactate gave a higher propionic acid yield, lower cell yield, and lower specific growth rate. The specific fermentation or propionic acid production rate from lactate was, however, higher than that from lactose. Since about equimolar acid products would be formed from lactate, the reactor pH remained relatively unchanged throughout the fermentation and would be easier to control when lactate was the growth substrate. Therefore, lactate would be a preferred substrate over lactose and glucose for propionic acid production using continuous, immobilized cell bioreactors. Correspondence to: S. T. Yang     

Whey fermentation by immobilized cells of Propionibacterium shermanii

Growth of Propionibacterium shermanii B-123 was faster on media containing lactate than on that containing lactose. Cheese whey was therefore fermented with Lactobacillus helveticus and neutralized with NaOH or Ca(OH)₂, before inoculation with B-123. Fermentation rate by immobilized propionibacteria was best in Ca(OH)₂-neutralized whey, and at lactate concentrations between 1 and 2%. Calcium propionate concentrations of 1 and 3% reduced fermentation rates by 40% and 55% respectively. Optimum temperature for propionate fermentation by immobilized cells was 37°C. Ratios of propionic acid to acetic acid increased as incubation temperature was increased. Agitation increased propionic acid fermentation rates but lowered the ratio of propionic acid to acetic acid. Beads containing immobilized propionibacteria were re-utilized for ten consecutive fermentations. Fermentation rates increased upon re-utilization. Escherichia coli and Staphylococcus aureus were inhibited by the propionic fermentation but did not die; they kept growing at a reduced rate.     

化学改性甘蔗渣对固定化细胞发酵产丁醇的影响

旨在研究化学改性的甘蔗渣作为固定化载体对丙酮丁醇梭菌Clostridium acetobutylicum XY16发酵制备生物丁醇的影响。首先利用不同浓度的聚乙烯亚胺(PEI)和1 g/L戊二醛(GA)对甘蔗渣表面进行化学改性,增强甘蔗渣对Clostridium acetobutylicum XY16的附载能力。经4 g/L聚乙烯亚胺和1 g/L戊二醛改性的甘蔗渣(添加量10 g/L)应用到固定化批次发酵中,发酵36 h后丁醇和总溶剂浓度最高,分别达到了12.24 g/L和21.67 g/L,同时溶剂的生产速率达到0.60 g/(L·h),生产速率比游离细胞和未改性甘蔗渣固定化细胞分批发酵分别提高了130.8%和66.7%。在此基础上对改性甘蔗渣固定化的细胞进行6次重复批次发酵,丁醇和总溶剂的产量稳定,溶剂生产速率逐渐提高至0.83 g/(L·h),同时转化率也提高至0.42 g/g。     

Engineering Propionibacterium acidipropionici for enhanced propionic acid tolerance and fermentation

Propionibacterium acidipropionici, a Gram‐positive, anaerobic bacterium, has been the most used species for propionic acid production from sugars. In this study, the metabolically engineered mutant ACK‐Tet, which has its acetate kinase gene knocked out from the chromosome, was immobilized and adapted in a fibrous bed bioreactor (FBB) to increase its acid tolerance and ability to produce propionic acid at a high final concentration in fed‐batch fermentation. After about 3 months adaptation in the FBB, the propionic acid concentration in the fermentation broth reached ～100 g/L, which was much higher than the highest concentration of ～71 g/L previously attained with the wild‐type in the FBB. To understand the mechanism and factors contributing to the enhanced acid tolerance, adapted mutant cells were harvested from the FBB and characterized for their morphology, growth inhibition by propionic acid, protein expression profiles as observed in SDS–PAGE, and H⁺‐ATPase activity, which is related to the proton pumping and cell's ability to control its intracellular pH gradient. The adapted mutant obtained from the FBB showed significantly reduced growth sensitivity to propionic acid inhibition, increased H⁺‐ATPase expression and activity, and significantly elongated rod morphology. Biotechnol. Bioeng. 2009; 104: 766–773 © 2009 Wiley Periodicals, Inc.     

Conversion of corn milling fibrous co-products into ethanol by recombinant Escherichia coli strains K011 and SL40

Corn hulls and corn germ meal were both evaluated as feedstocks for production of ethanol for biofuel. Currently, these fibrous co-products are combined with corn steep liquor and the fermentation bottoms (if available) and marketed as cattle feed. Samples were obtained from wet and dry corn mills. The corn hulls and germ meal were evaluated for starch and hemicellulose compositions. Starch contents were 12 to 32% w/w and hemicellulose (arabinoxylans) contents were 23 to 64% w/w. Corn fibrous samples were hydrolysed, using dilute sulphuric acid, into mixed sugar streams containing arabinose, glucose and xylose. Total sugar concentrations in the hydrolysate varied from 8.4 to 10.8% w/v. The hydrolysates were fermented to ethanol using recombinant E. coli strains K011 and SL40. Ethanol yields were 0.38 to 0.41g ethanol produced/g total sugars consumed and fermentations were completed in 60h or less. However, residual xylose was detected for each hydrolysate fermentation and was especially significant for fermentations using strain SL40. Strain K011 was a superior ethanologenic strain compared with strain SL40 in terms of both ethanol yield and maximum productivity.