Effect of endoglucanase and cellobiohydrolase from Trichoderma reesei on cellulose microfibril structure

Abstract Cellobiohydrolase (CBH, EC 3.2.91) was purified to homogeneity from Trichoderma reesei culture fluids by means of preparative isoelectric focussing (IEF). Its isoelectric points was 4.2. The degradation product of crystalline cellulose (Avicel and cotton) was predominantly cellobiose. The action of purified endoglucanase (EG) and CBH on cellulose microfibrils was followed by transmission electron microscopy (TEM) observations after Pt-C shadowing of the specimen. EG pretreatment of microfibrils resulted in submicrofibril formation. Addition of CBH induced the conversion of submicrofibrils into heterogeneous cellulose clusters and into homogeneous cellulose plaques. One structural effect of CBH was the increase in accessible cellulose surface area, possibly providing intermolecular entrace of water molecules between adjacent cellulose chains. Plaque formation is interpreted as a visible CBH action on crystalline cellulose to form swollen water-insoluble cellulose intermediates.     

里氏木霉液体发酵产纤维素酶的研究

在摇瓶试验基础上,采用里氏木霉(Trichoderma reesei)HC-415菌株进行5L自控罐产纤维素酶深层发酵试验。在通气量为 0.2—0.6vvm、搅拌速度为 400r/min、发酵液pH控制在5.8—6.1的条件下,发酵液的羧甲基纤维素(CMC)酶酶活最高为325.0mg糖/ml,滤纸糖酶(FPA)酶活最高达17.9mg糖/ml。发酵周期为108h。所得冻干纤维素酶粉CMC酶活最高3111IU/g,FPA最高135IU/g ,对发酵液得率平均6.7g/L。酶活总收率CMC酶活平均78.2％,FPA酶活平均73.5％。     

Purification of cellobiohydrolase I fromTrichoderma reesei using monoclonal antibodies in an immunomatrix

Summary The several components of the fungal cellulase system present practical problems in devising facile and efficient schemes for their purification. We report on a new single-step affinity chromatographic method for purification of cellobiohydrolase I ofTrichoderma reesei based on its selective absorption and elution using an immunomatrix constructed with CnBr-activated Sepharose 4B and monoclonal antibody specific for the enzyme. Isoenzymes of cellobiohydrolase I were purified directly from crude culture filtrate. The method is fast, simple, and of high resolution.     

Stimulatory effect of oxidized cellulose on cellulase formation by Trichoderma reesei

Crystalline cellulase has been electrochemically oxidized to yield preparations containing various different percentages of oxidized end-groups. These celluloses have been used as carbon sources for growth and cellulase production by Trichoderma reesei . A low content of oxidized end groups in the celluloses (0.1–0.65%) stimulated cellulase production but not growth, whereas higher contents (> 1%) where inhibitory to both. The cellulolytic enzyme system secreted under stimulated conditions contained the same proportion of individual cellulase enzymes (cellobiohydrolase I and II, endoglucanase I) as the control, indicating a general stimulatory effect of oxidized cellulose. Activity of cellulases against oxidized celluloses in vitro was not stimulated, and only slightly inhibitory at high degrees of oxidation. The data support a potential role of cellulose oxidation in regulating cellulase formation by T. reesei .     

Enhanced cellulase production in fed-batch culture of Trichoderma reesei C30

The use of a fed-batch cultivation of the fungus Trichoderma reesei (C30) allows cellulase [see 1,4-(1,3;1,4)-β-d-glucan 4-glucanohydrolase, EC 3.2.1.4] production to occur under optimum conditions, and results in extremely high enzyme titres and productivities. Enzyme levels of 26 U ml^?1 at productivities >130 U l^?1 h^?1 have been achieved. These results are compared with the values obtained in two-stage continuous cultivation of the organism at optimum pH and temperature.     

Competitive inhibition of cellobiohydrolase I by manno-oligosaccharides

In the hydrolysis of softwood, significant amounts of manno-oligosaccharides (MOS) are released from mannan, the major hemicelluloses in softwood. However, the impact of MOS on the performance of cellulases is not yet clear. In this work, the effect of mannan and MOS in cellulose hydrolysis by cellulases, especially cellobiohydrolase I (CBHI) from Thermoascus aurantiacus (Ta Cel7A), was studied. The glucose yield of Avicel decreased with an increasing amount of added mannan. Commercial cellulases contained mannan hydrolysing enzymes, and β-glucosidase played an important role in mannan hydrolysis. Addition of 10 mg/ml mannan reduced the glucose yield of Avicel (at 20 g/l) from 40.1 to 24.3%. No inhibition of β-glucosidase by mannan was observed. The negative effects of mannan and MOS on the hydrolytic action of cellulases indicated that the inhibitory effect was at least partly attributed to the inhibition of Ta Cel7A (CBHI), but not on β-glucosidase. Kinetic experiments showed that MOS were competitive inhibitors of the CBHI from T. aurantiacus, and mannobiose had a stronger inhibitory effect on CBHI than mannotriose or mannotetraose. For efficient hydrolysis of softwood, it was necessary to add supplementary enzymes to hydrolyze both mannan and MOS to less inhibitory product, mannose.     

Improved heterologous gene expression in Trichoderma reesei by cellobiohydrolase I gene （cbh1） promoter optimization

To improve heterologous gene expression in Trichoderma reesei, a set of optimal artificial cellobiohydrolase I gene （cbhl） promoters was obtained. The region from -677 to -724 with three potential glucose repressor binding sites was deleted. Then the region from -620 to -820 of the modified cbhl promoter, including the CCAAT box and the Ace2 binding site, was repeatedly inserted into the modified cbhl promoter, obtaining promoters with copy numbers 2, 4, and 6. The results showed that the glucose repression effects were abolished and the expression level of the glucuronidase （gus） reporter gene regulated by these multi-copy promoters was markedly enhanced as the copy number increased simultaneously. The data showed the great promise of using the promoter artificial modification strategy to increase heterologous gene expression in filamentous fungi and provided a set of optional high-expression vectors for gene function investigation and strain modification.     

Action of purified Trichoderma reesei cellulases on cotton fibers and yarn

In this work the possibility and potential of treating cotton fibers and yarns instead of fabrics with monocomponent cellulases was investigated. Different pretreatments on fibers were performed and tested in order to improve the accessibility of cotton to enzymatic modification. The enzymatic treatments were evaluated microscopically and by analysing the effects of treated fibers on spinnability, yarn evenness, tenacity and pilling. The accessibility of the cotton fibers for cellulases could be increased by different pretreatments. Steaming of fibers prior to enzymatic treatment was found to be an efficient way to increase hydrolysis levels. Cellulase treatments of carded yarns resulted in modification of yarn properties. Decrease in yarn hairiness was observed and the knitted fabric made of the treated yarn showed a lowered tendency towards pilling. In all cases endoglucanase activity rather than cellobiohydrolase activity was responsible for these modifications.     

Adsorption and synergism of cellobiohydrolase I and II of Trichoderma reesei during hydrolysis of microcrystalline cellulose

Hydrolysis of microcrystalline cellulose (Avicel) by cellobiohydrolase I and II (CBH I and II) from Trichoderma reesei has been studied. Adsorption and synergism of the enzymes were investigated. Experiments were performed at different temperatures and enzyme/substrate ratios using CBH I and CBH II alone and in reconstituted equimolar mixtures. Fast protein liquid chromatography (FPLC) analysis was found to be an accurate and reproducible method to follow the enzyme adsorption. A linear correlation was found between the conversion and the amount of adsorbed enzyme when Avicel was hydrolyzed by increasing amounts of CBH I and/or CBH II. CBH I had lower specific activity compared to CBH II although, over a wide concentration range, more CBH I was adsorbed than CBH II. Synergism between the cellobiohy-drolases during hydrolysis of the amorphous fraction of Avicel showed a maximum as a function of total enzyme concentration. Synergism measured as a function of bound enzyme showed a continuous increase, which indicates that by decreasing the distance between the two enzymes the synergism is enhanced. The adsorption process for both enzymes was slow. Depending on the enzyme/substrate ratio it took 30-90 min to reach 95% of the equilibrium binding. The amount of bound enzyme decreased with increasing temperature. The two enzymes compete for the adsorption sites but also bind to specific sites. Stronger competition for adsorption sites was shown by CBH I. (c) 1994 John Wiley & Sons, Inc.     

Complexity of cellulases from Trichoderma reesei with acidic isoelectric points: A two-dimensional gel electrophoretic study using immunoblotting

Antibody specific to Trichoderma reesei cellulase (65 kDa, isoelectric point, pI, 7.7) shows immuno-cross reactivity with acidic hydrolase complexes containing other cellulases, (pI_app. 3.4–4.5) when tested under conditions of 2D-electrophoresis (1^st dim. PAGIF, 2^nd dim. SDS-PAGE) together with Western blotting. Degradation pattern of ¹⁴C(U)-labeled G₁–G₅ of the 65 kDa cellulase was followed by a 2-directional oligodextrin mapping procedure.Using preparative IEF, homologous antigen portions were detected in cellulases present within acidic hydrolase complexes showing mainly identical molar weight (M_r 65 kDa and 57 kDa) but a range of charge (pI 3.4–4.5). The pattern of acidic cellulases as found after analytical 2D-electrophoresis was reconstituted by preparative IEF (pI_app. 2.7–5.1) followed by SDS-PAGE separation. Homogeneous fractions (upon IEF) gave up to 8 different polypeptides per complex upon SDS-PAGE (M_r 70−20 kDa). Charge heterogeneity of individual acidic hydrolase complexes upon IEF is discussed as one reason for ‘multiplicity’ of acidic cellulases.     

Application of image analysis in the fungal fermentation of Trichoderma reesei RUT-C30

Trichoderma reesei was grown in a stirred-tank bioreactor (STB) and a reciprocating plate bioreactor (RPB) at four different agitation speeds. A semiautomatic image analysis protocol that was developed to characterize the mycelium morphology during the fermentation process based on four morphological types (unbranched, branched, entangled, and clumped microorganisms) was applied to study the effect of agitation on the morphology of T. reesei. It was shown via statistical validation that broth samples used for image analysis represented the whole population of the fungi in the bioreactor. High shear was found to be damaging to T. reesei grown in the STB. The gentler shear produced in the RPB was not detrimental to the microorganism even at higher agitation speed. Better productivity was obtained for T. reesei grown in the STB and the highest productivity, 0.121 IU/mL h, was obtained at 400 rpm. The morphological parameter, the hyphal growth unit, was found to be correlated to the productivity. Understanding the effect of agitation on the morphology and productivity of T. reesei could lead to the design of better bioreactors and the selection of operating conditions of bioreactors to optimize the production of cellulase.     

Analysis of Cre1 binding sites in the Trichoderma reesei cbh1 upstream region

Abstract A 1.5-kb XbaI-SacII fragment containing the upstream region of the Trichoderma reesei cellobiohydrolase I gene ( cbh1 ) has been sequenced. The 1.5-kb fragment contains eight 6-bp sites having an identical or similar sequence to the consensus sequence for binding a catabolite repressor, Aspergillus nidulans CreA. Results of binding assays with the maltose-binding protein: :Cre1(10–131) fusion protein (Cre1 is a catabolite repressor of T. reesei ) and the cbhI upstream region revealed that a 504-bp XbaI-NspV fragment (nucleotide position − 1496 to − 993) bearing three 6-bp sites, Al, A2, and A3, and a 356-bp NspV-MunI fragment (nucleotide position −994 to −639) bearing three 6-bp sites, B1, B2, and B3, were shifted in the electrophoretic mobility shift assay. DNase I footprinting experiments showed that the 6-bp sites A2, B1, B2, and B3 were protected from DNase I digestion.     

Structural and functional domains of cellobiohydrolase I from trichoderma reesei

Limited proteolysis (papain) of the cellobiohydrolase I (CBH I, 65 kDa) from Trichoderma reesei led to the seperation of two functional domains: a core protein (55 kDa) containing the active site, and a C-terminal glycopeptide (10 kDa) implicated in binding to the insoluble matrix (cellulose). The quaternary structures of the intact CBH I and its core in solution are now compared by small angle X-ray scattering (SAXS) measurements. The molecular parameters derived for the core (Rg=2.09 nm, D_max=6.5 nm) and for the intact enzyme (Rg=4.27 nm, D_max=18 nm) indicate very different shapes. The resulting models show a tadpole-like structure for the intact enzyme where the isotropic part coincides with the core protein and the flexible tail part should be identified with the C-terminal glycopeptide. Thus in this enzyme, functional differentiation is reflected in structural peculiarities.Abbreviations SAXS small angle X-ray scattering - SDS-PAGE SDS-polyacrylamide gel electrophoresis - IEF-PAG polyacrylamide gel isoelectric focusing; cellobiohydrolase (CBH, 1,4--glucan cellobio hydrolase (E.C.3.2.1.91)) - D_max maximum diameter - Rg radius of gyration     

Induction of cellulase formation in Trichoderma reesei by cellobiono-1,5-lacton

Induction of synthesis of cellulolytic enzymes in Trichoderma reesei QM 9414 by cellobiono-1,5-lactone (CBL) has been investigated in a replacement system lacking additional carbon source. CBL induced cellulase secretion optimally at pH 5 and a concentration of 70 g/ml. Higher concentrations lead to lower induction. De novo induction of cellulases was proven by the inhibitory effect of cycloheximide addition. Induction by CBL was shown to act synergistically on induction by sophorose, as it decreased the concentration of sophorose required for maximal induction. Maximal endo--1,4-glucanase activities induced by either sophorose or CBL were comparable. The CBL-induced cellulase system contained all the major cellulolytic enzymes of T. reesei, i.e. cellobiohydrolase I and II, and endoglucanase I, as shown by SDS-PAGE, Western blotting and detection with specific mono- and polyclonal antibodies. No differences were seen in the types of individual enzymes formed upon induction by either sophorose or CBL. No other hydrolytic enzymes appear to be induced by CBL (i.e. amylase, laminarinase, xylanase).Abbreviations SDS-PAGE polyacrylamide gel electrophoresis in the presence of sodium-dodecylsulfate - CBL cellobiono-1,5-lacton - CBH cellobiohydrolase - EG endoglucanase - IgG immunoglobulin G     

黑曲霉与里氏木霉固态混合发酵产β-葡萄糖苷酶

对黑曲霉NL02与里氏木霉RUT-C30固态混合发酵产β-葡萄糖苷酶的发酵培养基进行优化,研究培养基含水率、C源、N源、接种量、温度和2种菌种不同延长接种时间与接种比例对β-葡萄糖苷酶活力的影响。研究表明：麸皮17.5 g、玉米芯7.5 g、（NH4）2SO4 0.40 g、尿素0.37 g、黑曲霉孢子接入量为107个接种到250 mL三角瓶中,温度30 ℃、摇床转速100 r/min时,里氏木霉以105个孢子与黑曲霉同时接入,每克干曲所得β-葡萄糖苷酶的活力为132.45 IU,较黑曲霉单独培养时的104.35 IU提高了26.94%。     

Effects of pH and high ionic strength on the adsorption and activity of native and mutated cellobiohydrolase I from Trichoderma reesei

Cellobiohydrolase I (CBHI) is the major cellulase of Trichoderma reesei. The enzyme contains a discrete cellulose-binding domain (CBD), which increases its binding and activity on crystalline cellulose. We studied cellulase-cellulose interactions using site-directed mutagenesis on the basis of the three-dimensional structure of the CBD of CBHI. Three mutant proteins which have earlier been produced in Saccharomyces cerevisiae were expressed in the native host organism. The data presented here support the hypothesis that a conserved tyrosine (Y492) located on the flat and more hydrophilic surface of the CBD is essential for the functionality. The data also suggest that the more hydrophobic surface is not directly involved in the CBD function. The pH dependence of the adsorption revealed that electrostatic repulsion between the bound proteins may also control the adsorption. The binding of CBHI to cellulose was significantly affected by high ionic strength suggesting that the interaction with cellulose includes a hydrophobic effect. High ionic strength increased the activity of the isolated core and of mutant proteins on crystalline cellulose, indicating that once productively bound, the enzymes are capable of solubilizing cellulose even with a mutagenized or with no CBD. © 1995 Wiley-Liss, Inc.     

里氏木霉GH61家族糖苷酶的高效表达及酶学特性研究

【目的】GH61家族糖苷水解酶具有葡聚糖氧化酶活性,通过对葡聚糖链的随机氧化而破坏木质纤维素的结晶结构,从而使木质纤维素容易被纤维素酶降解。重组表达、纯化获得里氏木霉的GH61家族糖苷水解酶(TrGH61,原名为EGⅣ),并研究其在纤维素酶水解木质纤维素中的作用。【方法】通过Overlap PCR将里氏木霉丙酮酸脱羧酶的启动子、纤维二糖水解酶cbh1的信号肽、EGⅣ基因和PDC终止子依次连接构建了里氏木霉的表达盒,通过该表达盒使TrGH61蛋白基因整合到里氏木霉的基因组DNA上进行同源表达。研究表达产物TrGH61的水解活性、与纤维素酶水解协同效应,以及TrGH61作为金属氧化酶的特性研究。【结果】在PDC启动子的作用下,TrGH61得到高效表达,摇瓶培养的表达量达到2.33 g/L。TrGH61有微弱的内切葡萄糖苷酶活性,比活力为0.02 IU/mg,但能显著提高纤维素酶水解稻草粉的活性,协同度最高可达1.998。低浓度的金属离子Cu2+、Co2+和还原性电子供体还原型谷胱甘肽、L-抗坏血酸、焦性没食子酸均能显著促进其水解效应。TrGH61能够降低稻草粉纤维素聚合度和结晶度。【结论】通过PDC启动子可以实现TrGH61蛋白高效组成型表达,TrGH61作为纤维素酶活性促进因子,通过破坏纤维素结晶结构作用机制协同增强纤维素酶水解木质纤维素。     

工业纤维素诱导里氏木霉RUT C-30产葡聚糖酶的条件

为了研究工业纤维素诱导里氏木霉RUT C-30产葡聚糖酶的最佳条件,根据单因素实验结果,以工业纤维素、(NH4)2SO4和生物素为实验因素,滤纸酶活为响应值,进行中心组合设计,建立一个二次多项式数学模型,进行响应面优化,寻找最优产酶结果.经过优化,选出工业纤维素、(NH4)2SO4和生物素的添加量分别为39.485 g/L、6.232 g/L和249.872 μg/L,最高的滤纸比酶活为6.298 U/mL,实验验证,滤纸比酶活为6.118 U/mL,与预测值相差了2.86%.     

The active sites of cellulases are involved in chiral recognition: a comparison of cellobiohydrolase 1 and endoglucanase 1

The cellulases cellobiohydrolase 1 (CBH 1) and endoglucanase 1 (EG 1) from the fungus Trichoderma reesei are closely related with 40% sequence identity and very similar in structure. In CBH 1 the active site is enclosed by long loops and some antiparallel β-strands forming a 40 Å long tunnel, whereas in EG 1 part of those loops are missing so that the enzyme has a more common active site groove. Both enzymes were immobilized on silica and these materials were used as chiral stationary phases for chromatographic separation of the enantiomers of two chiral drugs, propranolol and alprenolol. The CBH 1 phase showed much better resolution than did the EG 1 phase, suggesting that the tunnel structure of the protein may play an important role in the chiral separation. The chiral compounds were found to be competitive inhibitors of both enzymes when p-nitrophenyl lactoside (pNPL) was used as substrate. (S)-enantiomers showed stronger inhibitory effects and also longer retention time on the stationary phases than the (R)-enantiomers. The consistency between kinetic data and retention on the stationary phases clearly shows that the enzymatically active sites of CBH 1 and EG 1 are involved in chiral recognition.     

Desorption of zinc by extracellularly produced metabolites of Trichoderma harzianum, Trichoderma reesei and Coriolus versicolor

AIMS: To determine the role of fungal metabolites in the desorption of metals. METHODS AND RESULTS: Desorption of Zn from charcoal by three different fungi was compared against metal desorption with reverse osmosis water, a 0.1% Tween 80 solution and a 0.1 mol l(-1) CaCl(2) solution. All three fungal filtrates desorbed three times more Zn than either 0.1% Tween 80 or 0.1 mol l(-1) CaCl(2). Metal chelator production in Trichoderma harzianum and Coriolus versicolor was constitutively expressed while chelator production in Trichoderma reesei was induced by Zn. The presence of Zn inhibited the production of metal chelators by C. versicolor. Only C. versicolor was found to produce oxalic acid (a strong metal chelator). All fungi caused a marked decrease in pH, although this was not enough to explain the increased desorption of the metals by the different fungal filtrates. CONCLUSIONS: Metal chelation via organic acids and proteins are the main mechanisms by which the fungal filtrates increase zinc desorption. SIGNIFICANCE AND IMPACT OF THE STUDY: The results of this study explain why plants inoculated with T. harzianum T22 take up more metal from soil, than noninoculated plants while metabolites produced by fungi could be used for metal leaching from contaminated soils.