Optimization of a cultural medium for bacteriocin production by Lactococcus lactis using response surface methodology.

The medium composition for bacteriocin production by Lactococcus lactis ATCC 11454 was optimized using response surface methodology. The selected six factors based on CM medium were sucrose, soybean peptone, yeast extract, KH(2)PO(4), NaCl, and MgSO(4).7H(2)O. Fractional factorial designs (FFD) and the path of steepest ascent were effective in searching for the main factors and approaching the optimum region of the response. By a 2(6-2) FFD, sucrose, soybean peptone, yeast extract, KH(2)PO(4) were found to be significant factors and had positive effects on cell growth, however, only soybean peptone and KH(2)PO(4) were shown to be the two significant factors for bacteriocin production and had negative and positive effects, respectively. The effects of the two main factors on bacteriocin production were further investigated by a central composite design and the optimum composition was found to be 1% sucrose, 0.45% soybean peptone, 1% yeast extract, 2.84% KH(2)PO(4), 0.2% NaCl, and 0.02% MgSO(4) x 7H(2)O. The optimal medium allowed bacteriocin yield to be doubled compared to CM medium.     

海洋红酵母Y2发酵产类胡萝卜素条件的研究

目的 对海洋红酵母Y2高产类胡萝卜素的发酵条件进行优化.方法 在摇瓶条件下,研究培养基成分和培养条件对海洋红酵母Y2生长和类胡萝卜素合成的影响,同时进行海洋红酵母Y2发酵过程的动态分析.结果 海洋红酵母Y2优化培养基组合为葡萄糖45 g/L,蔗糖15 g/L,酵母粉5 g/L,蛋白胨2.5 g/L,磷酸二氢钾1 g/L,磷酸二氢钠3 g/L,硫酸镁7.5 g/L,氯化钾3 g/L,氯化钠5 g/L.最适培养参数为:温度20℃,培养基初始pH为5,接种量为10％,250 mL摇瓶装液量为10～50 mL.类胡萝卜素的合成主要集中在对数生长期和稳定期.海洋红酵母Y2最适收获时间为72 h.种龄以36 h为宜.结论 利用优化培养基,在最适条件下培养海洋红酵母Y2,类胡萝卜素产量达到4.97 mg/L,比基础培养基提高了60.32％.     

假丝酵母E-2产生物表面活性剂摇瓶发酵条件的优化

从扬子石化的废水淤泥中筛选到1株能发酵液体石蜡产脂肽类生物表面活性剂的假丝酵母Candida E-2.通过单因子实验和正交试验,得到了最佳发酵培养基组成(g/L):牛肉膏3.0,蔗糖2.0,酵母膏0.25,KH2PO4 12.5,MgSO4 0.3,NaCl 1.5,CaCl,0.05,尿素0.5 5;液体石蜡10％(体积分数).最佳培养条件:初始pH7.0,接种量0.12g/L,装液量为200mL三角瓶30mL,培养时间为5 d.最终产量提高了2.7倍,达1.582g/L.     

Application of statistical experimental designs for the optimization of medium constituents for the production of citric acid from pineapple waste

Statistical experimental designs were applied for the optimization of medium constituents for citric acid production by Yarrowia lipolytica NCIM 3589 in solid state fermentation (SSF) using pineapple waste as the sole substrate. Using Plackett-Burman design, yeast extract, moisture content of the substrate, KH(2)PO(4) and Na(2)HPO(4) were identified as significant variables which highly influenced citric acid production and these variables were subsequently optimized using a central composite design (CCD). The optimum conditions were found to be yeast extract 0.34 (%w/w), moisture content of the substrate 70.71 (%), KH(2)PO(4) 0.64 (%w/w) and Na(2)HPO(4) 0.69 (%w/w). Citric acid production at these optimum conditions was 202.35 g/kg ds (g citric acid produced/kg of dried pineapple waste as substrate).     

罗伦隐球酵母胞外多糖的研究 Ⅰ.发酵条件

研究了罗伦隐球酵母(cryptococcus laurentii)产生胞外多糖的适宜条件。培养基组成(g/L):葡萄糖80.00,酵母膏1.25,KH_2PO_3.00,MgSO_4·7H_2O0.05,CaCO_3 10.00,pH6.0。在30℃,旋转式摇床(200r/min)上培养6天。胞外多糖产量最高可达17.38g/L,对底物的转化率为21.725％。     

休哈塔假丝酵母HDYXHT-01利用木糖生产乙醇的发酵工艺优化

采用Plackett-Burman (PB) 方法和中心组合设计 (Ccentral composit design,CCD) 对休哈塔假丝酵母Candida shehataeHDYXHT-01利用木糖发酵生产乙醇的工艺进行优化。PB试验设计与分析结果表明：硫酸铵、磷酸二氢钾、酵母粉和接种量是影响木糖乙醇发酵的4个关键因素,以乙醇产量为响应目标,采用CCD和响应面分析法 (Response surface methodology,RSM),确定了木糖乙醇发酵的最佳工艺为：硫酸铵1.73 g/L、磷酸二氢钾3.56 g/L、酵母粉2.62 g/L和接种量5.66％,其他发酵条件为：木糖80 g/L,MgSO4·7H2O 0.1 g/L,pH 5.0,培养温度30 ℃,装液量100 mL/250 mL,摇床转速140 r/min,发酵时间48 h,在该条件下发酵液中乙醇产量可以达到26.18 g/L,比未优化前提高了1.15倍。     

Optimization of submerged culture requirements for the production of mycelial growth and exopolysaccharide by Cordyceps jiangxiensis JXPJ 0109

AIMS: The objective of the present study was to investigate the optimal culture requirements for mycelial growth and exopolysaccharide production by Cordyceps jiangxiensis JXPJ 0109 in submerged culture. METHODS AND RESULTS: The effects of medium ingredients (i.e. carbon and nitrogen sources, and growth factor) and other culture requirements (i.e. initial pH, temperature, etc.) on the production of mycelia and exopolysaccharide were observed using a one-factor-at-a-time method. More suitable culture requirements for mycelial growth and exopolysaccharide production were proved to be maltose, glycerol, tryptone, soya bean steep powder, yeast extract, medium capacity 200 ml in a 500-ml flask, agitation rate 180 rev min(-1), seed age 4-8 days, inoculum size 2.5-7.5% (v/v), etc. The optimal temperatures and initial pHs for mycelial growth and exopolysaccharide production were at 26 degrees C and pH 5 and at 28 degrees C and pH 7, respectively, and corresponding optimal culture age were observed to be 8 and 10 days respectively. According to the primary results of the one-factor-at-a-time experiments, the optimal medium for the mycelial growth and exopolysaccharide production were obtained using an orthogonal layout method to optimize further. Herein the effects of medium ingredients on the mycelial growth of C. jiangxiensis JXPJ 0109 were in the order of yeast extract > tryptone > maltose > CaCl2 > glycerol > MgSO4 > KH2PO4 and the optimal concentration of each composition was 15 g maltose (food-grade), 10 g glycerol, 10 g tryptone, 10 g yeast extract, 1 g KH2PO4, 0.2 g MgSO4, and 0.5 g CaCl2 in 1 l of distilled water, while the order of effects of those components on exopolysaccharide production was yeast extract > maltose > tryptone > glycerol > KH2PO4 > CaCl2 > MgSO4, corresponding to the optimal concentration of medium was as follows: 20 g maltose (food-grade), 8 g glycerol, 5 g tryptone, 10 g yeast extract, 1 g KH2PO4, and 0.5 g CaCl2 in 1 l of distilled water. CONCLUSIONS: Under the optimal culture requirements, the maximum exopolysaccharide production reached 3.5 g l(-1) after 10 days of fermentation, while the maximum production of mycelial growth achieved 14.5 g l(-1) after 8 days of fermentation. SIGNIFICANCE AND IMPACT OF THE STUDY: This is the first report on the submerged culture requirements for mycelial growth and exopolysaccharide in C. jiangxiensis, and this two-step optimization strategy in this study can be widely applied to other microbial fermentation processes.     

拉曼被孢霉产γ-亚麻酸的发酵条件优化

对影响发酵产γ-亚麻酸的因素（温度、N源、P源等）进行单因素考察。结果发现,各因素对拉曼被孢霉（Mortierella ramanniana NBRC 8187）产γ-亚麻酸均有不同程度的影响。通过正交试验设计对KH2PO4、NaNO3、酵母膏和温度进行了L9（34）试验设计,以γ-亚麻酸产量为优化目标,直观分析得出影响产量的因素大小顺序为酵母膏、温度、KH2PO4、NaNO3,最终确定最佳的培养条件：酵母膏5 g/L、25℃、KH2PO41 g/L、NaNO33 g/L。在此条件下,检测得出在第5天γ-亚麻酸产量达到0.968 g/L,相比优化前（0.583 g/L）提高了66%。     

Production of an extracellular maltase by thermophilic Bacillus sp. KP 1035.

Production of extracellular maltase was studied with thermophilic Bacillus sp. KP 1035, which was selected as the organism producing the highest levels of maltase. The final enzyme yield was increased by maltose, peptone, and yeast extract but reduced by succinate and fumarate. Maximum enzyme production was achieved at 55 degrees C and at an initial pH of 6.2 to 7.0 on a medium containing 0.3% maltose, 1% peptone, 0.1% meat extract, 0.3% yeast extract, 0.3% KH2PO4, and 0.1% KH2PO4. Maltase was synthesized in cytoplasm and accumulated as a large pool during the logarithmic growth phase, which preceded sporulation. At the end of this phase, the enzyme appeared in the culture broth, and its accumulation increased in parallel with a rise in the extracellular protein level. Maltase was stable for 24 h at 60 degrees C over a pH range of 5.6 to 9.0 and retained 95% of the original activity after treatment for 20 min at 70 degrees C at pH 6.8.     

Production of an extracellular maltase by thermophilic Bacillus sp. KP 1035.

Production of extracellular maltase was studied with thermophilic Bacillus sp. KP 1035, which was selected as the organism producing the highest levels of maltase. The final enzyme yield was increased by maltose, peptone, and yeast extract but reduced by succinate and fumarate. Maximum enzyme production was achieved at 55 degrees C and at an initial pH of 6.2 to 7.0 on a medium containing 0.3% maltose, 1% peptone, 0.1% meat extract, 0.3% yeast extract, 0.3% KH2PO4, and 0.1% KH2PO4. Maltase was synthesized in cytoplasm and accumulated as a large pool during the logarithmic growth phase, which preceded sporulation. At the end of this phase, the enzyme appeared in the culture broth, and its accumulation increased in parallel with a rise in the extracellular protein level. Maltase was stable for 24 h at 60 degrees C over a pH range of 5.6 to 9.0 and retained 95% of the original activity after treatment for 20 min at 70 degrees C at pH 6.8.     

High-level production of astaxanthin by Xanthophyllomyces dendrorhous mutant JH1 using statistical experimental designs

Medium composition was optimized for high-level production of astaxanthin by Xanthophyllomyces dendrorhous mutant JH1 using statistical experimental designs. Glucose and yeast extract were the most important factors affecting astaxanthin production. Glucose 3.89%, yeast extract 0.29%, KH2PO4 0.25%, MgSO4 0.05%, MnSO4 0.02%, and CaCl2 0.01% were optimum for high-level production of astaxanthin. Under optimized conditions, the maximum concentration of astaxanthin obtained after 7 d of cultivation was 36.06 mg/l. The concentration of astaxanthin predicted by a polynomial model was 36.16 mg/l.     

Citrus residues isolates improve astaxanthin production by Xanthophyllomyces dendrorhous

The wild strain and two astaxanthin-overproducing mutant strains, W618 and GNG274, of Xanthophyllomyces dendrorhous were analyzed in order to assess their ability to grow and synthesize astaxanthin in a minimal medium containing (per liter): 2 g KH2PO4, 0.5 g MgSO4, 2 g KNO3, and 1 g yeast extract, and supplemented with citrus residues isolates as a carbon source (citrus medium). The selected strain W618 was evaluated under various contents of citrus juice. At the content of 20% (v/v), the highest astaxanthin production reached 22.63 mg L(-1), which was two-fold more than that observed in yeast malt medium. Addition of 8% (v/v) n-hexadecane to the citrus medium was found to be optimal, increasing the astaxanthin yield by 21.7%.     

产朊假丝酵母全细胞转化合成谷胱甘肽的营养条件

为了进一步提高产朊假丝酵母全细胞转化生物合成谷胱甘肽(GSH)的能力,利用响应面分析方法对酵母培养的发酵培养基进行优化。在单因素实验的基础上,通过Plackett-Burman设计筛选出显著影响GSH转化力的2个主要因素:葡萄糖和KH2PO4。采用最陡爬坡试验和响应面设计预测了葡萄糖和KH2PO4的最佳质量浓度分别为58.5和17.2 g/L。验证实验结果表明,在该优化培养基条件下,酵母细胞的GSH转化力为1.54 mg/(g·h),比优化前提高了1倍。该结果为类似的采用全细胞转化法高效合成有用化学品的研究与开发提供了可行的优化思路。     

响应面法优化产酰胺酶发酵培养基

采用响应面分析方法,对阿萨希丝孢酵母（Trichosporon asahii）ZZB-1产酰胺酶的发酵培养基进行了优化。运用单N子试验筛选出麦芽糖和酵母浸膏为最适碳源、氮源,金属离子Ca^2＋、Mn^2＋可提高发酵酰胺酶产量;通过最陡爬坡实验逼近以上4个因子的最大响应区域后,采用Box—Behnken响应面分析法,确定产酰胺酶最佳发酵培养基为麦芽糖18．84g／L、酵母浸膏9．55g／L、NaC15g／L、KH2PO41g／L、MgSO4·7H2O0．2g／L、FeS040．001g／L、CaC0370．84μmol／L、MnS0465．39肚mo[／L（1％丙烯酸诱导）,NH4·H2O调节pH至7．0。培养基优化后酰胺酶产量由初始2554U／L提高到4156U／L,为原始发酵培养基配方酶活产量的1．63倍。     

Components of fermentation medium regulate bacteriocin synthesis by the recombinant strain Lactococcus lactis subsp. lactis F-116

The regulation of the synthesis of bacteriocin produced by the recombinant strain Lactococcus lactis subsp. lactis F-116 has been studied. The synthesis is regulated by the components of the fermentation medium, the content of inorganic phosphate (KH2PO4), yeast autolysate (source of amine nitrogen), and changes in carbohydrates and amino acids. The strain was obtained by fusion of protoplasts derived from two related L. lactis subsp. lactis strains, both exhibiting a weak ability to synthesize the bacteriocin nisin. Decreasing the content of KH2PO4 from 2.0 to 1.0 or 0.5% caused bacteriocin production to go down from 4100 to 2800 or 1150 IU/ml, respectively; the base fermentation medium contained 1.0% glucose, 0.2% NaCl, 0.02% MgSO4, and yeast autolysate (an amount corresponding to 35 mg % ammonium nitrogen). The substitution of sucrose for glucose (as the source of carbon) increased the antibiotic activity by 26%, and the addition of isoleucine, by 28.5%. Elevation of the concentration of yeast autolysate in the low-phosphate fermentation medium stimulated both the growth of the lactococci and the synthesis of bacteriocin. Introduction of 1% KH2PO4, yeast autolysate (in an amount corresponding to 70 mg % ammonium nitrogen), 2.0% sucrose, and 0.1% isoleucine increased the bacteriocin-producing activity of the strain by 2.4 times.     

桑木层孔菌液体培养条件的研究

对桑木层孔菌(Phellinus mori)液体发酵条件进行了研究,以生物量和胞外多糖为指标,通过L16(45)和L9(34)正交表进行了两次正交试验,筛选出桑木层孔菌最适液体培养条件为:麦芽糖30 g/L,酵母浸粉和蛋白胨15 g/L(质量比2 1),KH2PO4和CaCl25.5 g/L(质量比1 1),初始pH6.0;通过单因素试验筛选出最适装液量为120 mL/250 mL,最适接种量为10%。在此条件下液体发酵培养7 d后,桑木层孔菌生物量达到23.375 g/L,胞外多糖产量达到3.993 g/L。     

适合飞虱虫疠霉菌丝生产的液体培养基组分及发酵条件

蚜虫、飞虱、叶蝉等是威胁农业生产的刺吸式口器害虫,长期以来依赖化学农药防治,严重影响农产品的安全性和农业生态环境.探讨这类害虫的生物防治途径,减轻农产品化学农药的残留污染,一直受到国内外学者的关注.虫霉(En-tomophthorales)的许多种类具有优异的诱病杀虫能力,尤其通过主动弹射孢子而在害虫种群中高强度流行的特征,可在短期内迅速压低虫口密度,是极其重要的杀虫微生物资源[1～3].     

Factors affecting mycelial biomass and exopolysaccharide production in submerged cultivation of Antrodia cinnamomea using complex media

Submerged cultures were used to identify growth-limiting nutrients by Antrodia cinnamomea strains. The mycelial biomass and EPS production by A. cinnamomea BCRC 35396 were markedly higher than other A. cinnamomea strains. A relatively high C/N ratio was favorable for both the mycelial growth (5.41 g/l) and EPS production (0.55 g/l); the optimum ratio was 40. The glucose was available utilized preferentially for mycelial growth, rather than for EPS production. Flushing the culture medium with nitrogen had a stimulating effect on both mycelial growth and EPS production. In addition, peptone, yeast extract and malt extract appeared to be important and significant component for EPS production. Phosphate ion, magnesium ion and thiamine were probably not essential for mycelial growth. By optimizing the effects of additional nutrition, the results showed that 5% (w/v) glucose, 0.8% (w/v) peptone, 0.8% (w/v) yeast extract, 0.8% (w/v) malt extract, 0.03% (w/v) KH2PO4, 0.1% (w/v) MgSO4 .7H2O and 0.1% (w/v) thiamine could lead to the maximum production of EPS (1.36 g/l).     

圆红冬孢酵母菌发酵产油脂培养基及发酵条件的优化研究

采用均匀设计和单因子试验法,系统考察了圆红冬孢酵母菌(Rhodosporidiumtoruloides)在不同碳氮比条件下产油发酵情况以及添加无机盐对产油发酵的影响,通过均匀设计软件对二次多项回归方程求解及单因素分析得知在培养基组成分别为葡萄糖70g/L,硫酸铵0.1g/L,酵母粉0.75g/L,磷酸二氢钾0.4g/L,七水硫酸镁1.5g/L,初始pH6.0,在灭菌(121℃15min)后添加ZnSO41.91×10-6mmol/L、CaCl21.50mmol/L、MnCl21.22×10-4mmol/L、CuSO41.00×10-4mmol/L。发酵摇瓶装液量为250mL三角瓶装培养基50mL,接种量为10%(种龄28h)。在上述条件下,30℃振荡(200r/min)培养120h,所得菌体油脂含量高达76.1%,脂肪得率系数可达22.7。     

聚乙烯醇降解酶产生菌的分离的发酵条件

A bacterium D8 strain which high efficiently degrading PVA was isolated from waste water of factory. The strain possesses the abilities of completely degrading 0.5 per cent of PVA (500, 1700) included in the culture medium for four days. It was identified Pseudomonas pseudoalcaligenes. Fermentation conditions of the strain have been investigated. The suitable medium consisted of PVA 1.5% (NH4)2SO40.1%, K2HPO4 0.24%, KH2PO4 0.04%, MgSO4.7H2O 0.035%, NaCl 0.01%, FeSO4 0.001%, yeast extract 0.15%, pH 7.5. The optimal condition for enzyme production are as follows: 250 ml shake filled with 30 ml medium, 30 degrees C, 160n/min incubation period 72 h. Under such conditions enzyme activity is highest.