Production of thermostable α-galactosidase from thermophilic fungusHumicola sp

The thermophilic fungus,Humicola sp isolated from soil, secreted extracellular -galactosidase in a medium cotaining wheat bran extract and yeast extract. Maximum enzyme production was found in a medium containing 5% wheat bran extract as a carbon source and 0.5% beef extract as a carbon and nitrogen source. Enzyme secretion was strongly inhibited by the presence of Cu²⁺, Ni²⁺ and Hg²⁺ (1mM) in the fermentation medium. Production of enzyme under stationary conditions resulted in 10-fold higher activity than under shaking conditions. The temperature range for production of the enzyme was 37° C to 55°C, with maximum activity (5.54 U ml^–1) at 45°C. Optimum pH and temperature for enzyme activity were 5.0 and 60° C respectively. One hundred per cent of the original activity was retained after heating the enzyme at 60°C for 1 h. At 5mM Hg²⁺ strongly inhibited enzyme activity. TheK _m andV _max forp-nitrophenyl--d-galactopyranoside were 60M and 33.6 mol min^–1 mg^–1, respectively, while for raffinose those values were 10.52 mM and 1.8 mol min^–1 mg^–1, respectively.     

Over-production of β-glucosidase by Aspergillus niger mutant from lignocellulosic biomass

The maximum yield of -glucosidase by A. niger KK2 mutant, grown on the basal medium for 7 days, was 514 I U g^–1 ground rice straw, and was about twice those obtained from wheat straw or bran by previous researchers. Optimal activity of -glucosidase was at 60–70 °C and pH 4.8.     

Improved xylanase production from a haloalkalophilic Staphylococcus sp. SG-13 using inexpensive agricultural residues

The production of an alkali-stable xylanase, with dual pH optima, from haloalkalophilic Staphylococcus sp. SG-13 has been enhanced using agro-residues in submerged fermentation and a biphasic growth system. The agro-residues such as wheat bran, sugarcane bagasse, corncobs and poplar wood when used as sole carbon source, improved the xylanase yield by five-fold as compared to xylose and xylan. Staphylococcus sp. SG-13 also produced equally good amounts of xylanase when grown simply in deionized water (pH 8.0) supplemented with agro-residues as sole carbon source. In the biphasic growth system (lower layer containing agricultural residue set in agar medium with liquid medium above it), the prime substrate, wheat bran (1% w/v), resulted in maximum xylanase production of 4525 U l^–1 (pH 7.5) and 4540 U l^–1 (pH 9.2) at an agar: broth ratio of 4.0 after 48 h of incubation at 37 °C under static conditions. In general, the cost-effective agro-residues were found to be more suitable inducers for xylanase production over expensive substrates like xylan.     

High activity xylanase from thermotolerantStreptomyces T7: Cultural conditions and enzyme properties

Summary A thermotolerantStreptomyces T₇ produced 70–72 U/ml of extracellular xylanase activity when grown at 50°C in submerged culture, in à medium containing 5% wheat bran as a carbon source. Among the various sugars tested, maltose showed the highest activity of 8 U/ml. Pure xylan was less effective as an inducer as compared to wheat bran. Ammonium sulphate at a concentration of 0.7% was found to be optimum for maximum yield of the enzyme. The optimum period and pH for maximum production were 72th and 7.0, respectively. The culture filtrate was devoid of amylase, cellulase and B-xylosidase activity. The xylanase was exceptionally stable and did not show any loss in activity after storage at 50°C at pH 5.0 for 6 days.     

Enhanced production and characterization of a highly thermostable alkaline protease from Bacillus sp. P-2

An obligatory alkalophilic Bacillus sp. P-2, which produced a thermostable alkaline protease was isolated by selective screening from water samples. Protease production at 30 °C in static conditions was highest (66 U/ml) when glucose (1% w/v) was used with combination of yeast extract and peptone (0.25% w/v, each), in the basal medium. Protease production by Bacillus sp. P-2 was suppressed up to 90% when inorganic nitrogen sources were supplemented in the production medium. Among the various agro-byproducts used in different growth systems (solid state, submerged fermentation and biphasic system), wheat bran was found to be the best in terms of maximum enhancement of protease yield as compared to rice bran and sunflower seed cake. The protease was optimally active at pH 9.6, retaining more than 80% of its activity in the pH range of 7–10. The optimum temperature for maximum protease activity was 90 °C. The enzyme was stable at 90 °C for more than 1h and retained 95 and 37% of its activity at 99 °C and 121 °C, respectively, after 1 h. The half-life of protease at 121 °C was 47 min.     

Studies on the alkalophilicStreptomyces with extracellular xylanolytic activity

Summary An alkalophilicStreptomyces which produced xylanase, isolated from soil, grew in a temperature range of 15–37°C. The pH optimum for growth was 10 and no growth occurred at pH 7. On a simple wheat bran medium the microorganism exhibited maximum enzyme secretion of 12 U/ml at pH 10. The enzyme had a broad pH optimum of 4.8–10 and the optimum temperature of 50°C. It was completely inactivated at 60°C in 2 h. The enzyme hydrolyzed xylan to a mixture of oligomeric products indicating that the main activity was of the endoxylanase type. The culture filtrate had no cellulase activity.     

Alkaline-active xylanase produced by an alkaliphilicBacillus sp isolated from kraft pulp

ABacillus sp (V1-4) was isolated from hardwood kraft pulp. It was capable of growing in diluted kraft black liquor at pH 11.5 and produced 49 IU (mol xylose min^–1 ml^–1) of xylanase when cultivated in alkaline medium at pH 9. Maximal enzyme activity was obtained by cultivation in a defined alkaline medium with 2% birchwood xylan and 1% corn steep liquor at pH 9, but high enzyme production was also obtained on wheat bran. The apparent pH optimum of the enzyme varied with the pH used for cultivation and the buffer system employed for enzyme assay. With cultivation at pH 10 and assays performed in glycine buffer, maximal activity was observed at pH 8.5; with phosphate buffer, maximal activity was between pH 6 and 7. The xylanase temperature optimum (at pH 7.0) was 55°C. In the absence of substrate, at pH 9.0, the enzyme was stable at 50°C for at least 30 min. Elecrophoretic analysis of the crude preparation showed one predominant xylanase with an alkaline pl. Biobleaching studies showed that the enzyme would brighten both hardwood and softwood kraft pulp and release chromophores at pH 7 and 9. Because kraft pulps are alkaline, this enzyme could be used for prebleaching with minimal pH adjustment.     

Dry matter production and photosynthetic capacity in Gossypium hirsutum L. under conditions of slightly suboptimum leaf temperatures and high levels of irradiance

Summary Gossypium hirsutum L. var. Delta Pine 61 was cultivated in controlled-environment chambers at 1000–1100 mol photosynthetically active photons m^-2 s^-1 (medium photon flux density) and at 1800–2000 mol photons m^-2 s^-1 (high photon flux density), respectively. Air temperatures ranged from 20° to 34°C during 12-h light periods, whereas during dark periods temperature was 25° C in all experiments. As the leaf temperature decreased from about 33° to 27° C, marked reductions in dry matter production, leaf chlorophyll content and photosynthetic capacity occurred in plants growing under high light conditions, to values far below those in plants growing at 27° C and medium photon flux densities. The results show that slightly suboptimum temperatures, well above the so-called chilling range (0–12° C), greatly reduce dry matter production in cotton when combined with high photon flux densities equivalent to full sunlight.Abbreviations DW dry weight - F _v variable fluorescence yield - F _M maximum fluorescence yield - PFD photon flux density (400–700 nm)     

Batch propagation of Lactobacillus helveticus for production of lactic acid from lactose concentrated cheese whey with microaeration and nutrient supplementation

Continuous mix batch bioreactors were used to study the kinetic parameters of lactic acid fermentation in microaerated-nutrient supplemented, lactose concentrated cheese whey using Lactobacillus helveticus. Four initial lactose concentrations ranging from 50 to 150 g l^–1 were first used with no microaeration and no yeast extract added to establish the substrate concentration above which inhibition will occur and then the effects of microaeration and yeast extract on the process kinetic parameters were investigated. The experiments were conducted under controlled pH (5.5) and temperature (42 °C) conditions. The results indicated that higher concentrations of lactose had an inhibitory effect as they increased the lag period and the fermentation time; and decreased the specific growth rate, the maximum cell number, the lactose utilization rate, and the lactic acid production rate. The maximum lactic acid conversion efficiency (75.8%) was achieved with the 75 g l^–1 initial lactose concentration. The optimum lactose concentration for lactic acid production was 75 g l^–1 although Lactobacillus helveticus appeared to tolerate up to 100 g l^–1 lactose concentration. Since the lactic acid productivity is of a minor importance compared to lactic acid concentration when considering the economic feasibility of lactic acid production from cheese whey using Lactobacillus helveticus, a lactose concentration of up to 100 g l^–1 is recommended. Using yeast extract and/or microaeration increased the cell number, specific growth rate, cell yield, lactose consumption, lactic acid utilization rate, lactic acid concentration and lactic acid yield; and reduced the lag period, fermentation time and residual lactose. Combined yeast extract and microaeration produced better results than each one alone. From the results it appears that the energy uncoupling of anabolism and catabolism is the major bottleneck of the process. Besides lactic acid production, lactose may also be hydrolysed into glucose and galactose. The -galactosidase activity in the medium is caused by cell lysis during the exponential growth phase. The metabolic activities of Lactobacillus helveticus in the presence of these three sugars need further investigation.     

Lactase production in continuous culture by Trichoderma reesei Rut-C30

Summary Trichoderma reesei Rut-C30 was found to produce extracellular lactase when grown on lactose medium. Maximum enzyme levels in continuous culture were observed at dilution rates (D) between 0.02 and 0.027 hr^-1. The enzyme productivity reached 27.3 U/L hr at D = 0.027 hr^-1. Lactase synthesis appears to be inducible and subject to catabolite repression. Optimal growth temperature and pH for enzyme production were 28°C and pH 5. Maximum enzyme activity was observed at 63°C and pH 4.6. The apparent K_m, based on the nitrophenyl-galactopyranoside assay was estimated as 0.4 mM. The enzyme is suitable for lactose hydrolysis in acid whey.     

Production and characterization of xylanases of a Bacillus strain isolated from soil

Xylanase production was performed by growing a Bacillus isolate on agricultural by-products, wheat straw, wheat bran, corn cobs and cotton bagasse. A maximum xylanase activity of 180 U/ml was obtained together with a cellulase activity of 0.03 U/ml on 4 (w/v) corn cobs. Electrophoretic analysis showed the presence of three endo--1, 4-xylanases having molecular weights of about 22, 23 and 40 kDa. Xylanolytic activity was stable up to 50 °C in the pH range of 4.5–10 and the highest activity was observed at 70 °C and pH 6.5.     

Pediocin production by recombinant lactic acid bacteria

Production of the anti-listerial bacteriocin, pediocin, by lactic acid bacteria (LAB) transformed with the cloning vector pPC418 (Ped⁺, 9.1 kb) was influenced by composition of media and incubation temperature. Maximum pediocin production, tested against Listeria innocua, by electrotransformants of Lactococcus lactis ssp. lactis was measured in tryptone/lactose/yeast extract medium after 24 h growth at 30 °C, while incubation at 40 °C was optimum for Ped⁺ transformants of Streptococcus thermophilus and Enterococcus faecalis. The amount of pediocin produced by S. thermophilus in skim milk and cheese whey supplemented with 0.5% yeast extract was estimated as 51000 units ml^–1 and 25000 units ml^–1, respectively. Pediocin production remained essentially unchanged in reconstituted skim milk or whey media diluted up to 10-fold. The results demonstrate the capacity of recombinant strains of LAB to produce pediocin in a variety of growth media including skim milk and inexpensive cheese whey-based media, requiring minimum nutritional supplementation.     

Growth kinetics of Thermus thermophilus

Summary The nonsporulating extreme thermophile Thermus thermophilus was grown in continuous culture at dilution rates up to 2.65 h^–1 at 75°C and pH 6.9 on complex medium. Concomitantly very low yield (Y=0.12 g cell dry weight g^–1 utilized organic carbon) and incomplete substrate utilization (always less than 45%) were found. In batch cultures T. thermophilus could be grown with _max =h^–1, in shake flasks only with _max =h^–1 with the same low yield and incomplete substrate utilization. Stable steady states at 84C and 45°C were realized at a dilution rate of 0.3 h^–1 whereas at 86°C and 40°C no growth could be detected. Artefacts arising from wall growth (in bioreactors) or improper materials must be ruled out. Inhibition of growth by organic substrates was demonstrated at low concentrations: a decrease in the yield obtained was found when more than 0.7 gl^–1 of meat extract were supplied in the medium. The maintenance requirement for oxygen is potentially very high and was determined to be 10 to 15 mmol g^–1 h^–1.     

Metabolic engineering for direct lactose utilization by Saccharomyces cerevisiae

A recombinant strain of Saccharomyces cerevisiae, secreting -galactosidase from Kluyveromyces lactis, grew efficiently with more than 60 g lactose l^–1. The growth rate (0.23 h^–1) in a cheese-whey medium was close to the highest reported hitherto for other recombinant S. cerevisiae strains that express intracellular -galactosidase and lactose-permease genes. The conditions for growth and -galactosidase secretion in this medium were optimized in a series of factorial experiments. Best results were obtained at 23 °C for 72 h. Since the recombinant strain produced less than 3% ethanol from the lactose, it was also assayed for the production of fructose 1,6-bisphosphate from cheese whey, and 0.06 g l^–1 h^–1 were obtained.     

Chitinase production by Beauveria felinaRD 101: optimization of parameters under solid substrate fermentation conditions

Major parameters affecting the production of chitinase by Beauveria felinaRD 101 under solid substrate fermentation conditions have been optimized. Wheat bran moistened with 100 MS-HCl medium adjusted to pH 5.0, inoculated with 1 × 10¹⁰ conidia g^–1 initial dry bran and incubated at 28 °C for 6 days produced maximum chitinase activity of 6.34 U g^–1 initial dry substrate.     

Solid state fermentation for production of higher titres of thermostable alpha-amylase with two peaks for pH optima byBacillus licheniformis M27

Summary Bacillus licheniformis M27 produced 21, 000 units of alpha-amylase/g dry bacterial bran under solid state fermentation in wheat bran medium enriched with 3.3% di-ammonium hydrogen phosphate. The crude enzyme, with temperature optimum at 90°C in 0.5% starch solution, showed pH optima at 6.5–7.0 and 9.5 and over 75% activity over the pH range 6.0–10.5.     

Production and properties of ∝-mannosidase from aspergillus sp.

Summary Aspergillus sp NCIM 508 produced 22 U/L of extracellular -mannosidase activity in a medium containing 8 % brewer's yeast cells. The optimum period and pH range for maximum production of the enzyme were 7 days and 4.0–6.0, respectively. The optimum pH and temperature for enzyme activity were 6.0 and 50°C, respectively. The enzyme was stable for 24 h at 28°C, in the pH range 6.0–7.0. The enzyme retained 100 and 65 % of its original activity after heating for 15 min at 45 and 55°C, respectively. The Km and V_max for p-nitrophenyl--D- mannoside (PNPM) were 71M and 7.5 × 10^–2 moles/min/mg, respectively. The enzyme was strongly inhibited by 1 mM Hg⁺⁺ and Cu⁺⁺ and partially by Co.⁺⁺ (NCL Communication No.; 5780)     

Hyper production of β-glucosidase by an Aspergillus sp.

Summary An Aspergillus sp. was isolated which secreted high levels of -glucosidase in growth medium. The maximum activity(10 IU/ml of -glucosidase and 22.6 IU/ml of cellobiase) was obtained in cellulose medium supplemented with wheat bran. The pH and temperature optima for this enzyme were 4.5 and 65°C respectively.NCL Communication No. 3616     

Effect of cultural conditions on production of eicosapentaenoic acid byPythium irregulare

Summary The effect of culture conditions upon lipid content and fatty acid composition of mycelia ofPythium irregulare was investigated with particular attention to increasing the yield of 5,8,11,14,17-eicosapentaenoic acid (205; –3) (EPA). All experiments were done by shake flask culture using a yeast extract + malt extract medium. The maximum growth rate was obtained at 25°C, but maximum EPA production was obtained at 12°C. The highest EPA production was 76.5 g EPA/ml 13 days fermentation at 12°C. Addition of glucose during fermentation increased the yield considerably. The highest yield was 112 g/ml, obtained at 13 days fermentation with spiking on day 11. Fermentation time could be shortened by initial incubation at 25°C for 2 days, followed by incubation at 12°C for 6 days. The culture also produced arachidonic acid and other -6 polyunsaturated fatty acids. EPA production was also obtained with lactose or sweet whey permeate, a by-product of cheese manufacture that contains lactose as the main carbohydrate.The mention of firm names or trade products does not imply that they are endorsed or recommended by the U.S. Department of Agriculture over other firms or similar products not mentioned.     

Quantitative physiology of Penicillium cyclopium grown on whey for production of microbial protein

Summary A filamentous fungus Penicillium cyclopium, capable of growing on deproteinized whey was isolated and characterized for the purpose of production of microbial protein.This organism has a maximum specific growth rate of 0.2 h^–1 at pH 3.0 to 4.5 and 28°C in a medium containing only ammonium nitrogen and deproteinized whey. The yield coefficients are 0.68 g biomass/g lactose, 12.0 g biomass/g nitrogen, and 2.10 g biomass/g oxygen, respectively.Crude protein and total nucleic acid contents of this organism are 47.5% and 7.4% (dry cell weight basis), respectively. The profile of essential amino acids shows that it could be a good source of animal feed or food protein.