Concentration effect of Riesling Icewine juice on yeast performance and wine acidity

AIMS: The objective of this study was to determine the effect of increasing juice soluble solids above 40 degrees Brix on wine yeast's ability to grow and ferment the juice, with particular focus on acetic acid production, titratable acidity (TA) changes and the maximum amount of sugar consumed by the yeast. METHODS AND RESULTS: Riesling Icewine juices at 40, 42, 44 and 46 degrees Brix were inoculated with K1- V116 at 0.5 g 1(-1) and fermented at 17 degrees C until sugar consumption ceased. Increasing soluble solids showed strong negative linear correlations with yeast growth, sugar consumption and ethanol production (r = -0.999, -0.997 and 0.984, P < 0.001, respectively). Acetic acid, glycerol and TA production normalized to sugar consumed showed strong positive correlations to the initial juice concentration (r = 0.992, 0.963, and 0.937, P < 0.001 respectively) but no correlation was found for ethanol production. The acetic acid produced as a function of sugar consumed was positively correlated to the glycerol produced (r = 0.970, P < 0.001). The final TA of the wines ranged between 11.8 and 13.7 g 1(-1) tartaric acid, increasing by 2.3-3 g 1(-1) over the starting juice. The increase in TA was positively correlated to the increase in acetic acid produced after normalizing the data to the amount of sugar consumed (r =0.975, P < 0.001). The acid equivalents resulting from the increase in acetic acid accounted for 80-100% of the TA increase when converted to units of tartaric acid. In the final Icewines, acetic acid represented 19-20% of wine TA. CONCLUSIONS: Increasing Icewine juice concentration from 40 to 46 degrees Brix increases the proportion of yeast sugar metabolism towards glycerol and acetic acid production to cope with the increased osmotic stress by decreasing yeast growth, sugar consumption rate, the total amount of sugar consumed and the total amount of ethanol produced. The high proportional contribution of acetic acid to titratable acidity in Riesling Icewine may affect acidity perception. SIGNIFICANCE AND IMPACT OF THE STUDY: We have determined that 10% v/v ethanol would not be achievable with initial juice concentrations above 42 degrees Brix and that Riesling Icewine juice above 52.5 degrees Brix would be theoretically unfermentable. The high proportional contribution of acetic acid to TA may be an important factor in the organoleptic balance of these Icewines.     

Utilization of corn silage juice by Klyuveromyces marxianus

Corn silage juice was found to be a favorable substrate for production of fodder yeasts. Kluyveromyces marxianus NRRL Y-610 yielded significantly more cell dry weight than other cultures examined. In shake-flask experiments, the yeast produced over 13 g of cell dry weight per liter of corn silage juice and completely consumed the organic pollutants (lactic acid, acetic acid, and ethanol). The yeast settled rapidly and had a yeast volume index of 21 ml/g. The results indicate that K. marxianus NRRL Y-610 could be used to efficiently remove lactic acid and other organic compounds from corn silage juice with the concomitant production of fodder yeast.     

Response of wine yeast (Saccharomyces cerevisiae) aldehyde dehydrogenases to acetaldehyde stress during Icewine fermentation

AIMS: We previously reported that the aldehyde dehydrogenase encoded by ALD3 but not ALD6 was responsible, in part, for the increased acetic acid found in Icewines based on the expression profile of these genes during fermentation. We have now completed the expression profile of the remaining yeast aldehyde dehydrogenase genes ALD2, ALD4 and ALD5 during these fermentations to determine their contribution to acetic acid production. The contribution of acetaldehyde stress as a signal to stimulate ALD expression during these fermentations was investigated for all ALD genes. The expression of glycerol-3-phosphate encoded by GPD2 was also followed during these fermentations to determine its role in addition to the role we already identified for GPD1 in the elevated glycerol produced during Icewine fermentation. METHODS AND RESULTS: Icewine juice (38.5 degrees Brix, 398 +/- 5 g l(-1) sugar), diluted Icewine juice (20.8 degrees Brix, 196 +/- 4 g l(-1) sugar) and the diluted juice with sugar levels equal to the original Icewine juice (36.6 degrees Brix, 395 +/- 6 g l(-1) sugar) were fermented in duplicate using the commercial wine yeast K1-V1116. Acetic acid and glycerol production increased 8.4- and 2.7-fold in the Icewine vs the diluted juice fermentation, respectively, accompanied by a fourfold transient increase in acetaldehyde in the Icewine condition during the first week. Both mitochondrial aldehyde dehydrogenases encoded by ALD4 and ALD5 were expressed, with ALD5 expression highest at the start of all fermentations and ALD4 expression increasing during the first week of each condition. ALD2, ALD4, ALD5 and GPD2 showed no differential expression between the three fermentation conditions indicating their lack of involvement in elevating acetic acid and glycerol in Icewine. When yeast fermenting the diluted fermentation was exposed to exogenous acetaldehyde, the transient spike in acetaldehyde increased the expression of ALD3 but this response alone was not sufficient to cause an increase in acetic acid. Expression of the other aldehyde dehydrogenases was unaffected by the acetaldehyde addition. CONCLUSIONS: The aldehyde dehydrogenases encoded by ALD2, ALD4 and ALD5 do not contribute to the elevated acetic acid production during Icewine fermentation. Expression of GPD2 was not upregulated in high sugar fermentations and does not reflect the elevated levels of glycerol found in these wines. Acetaldehyde at a concentration produced during Icewine fermentation stimulates the expression of ALD3, but has no impact on the expression of ALD2, -4, -5 and -6. Upregulation of ALD3 alone in the dilute fermentation is not sufficient to increase acetic acid in wine and requires additional responses found in cells under hyperosmotic stress. SIGNIFICANCE AND IMPACT OF THE STUDY: This work confirms that increased acetic acid and glycerol production during Icewine fermentation follows upregulation of ALD3 and GPD1 respectively, but upregulation of ALD3 alone is not sufficient to increase acetic acid production. Additional responses of cells under osmotic stress are required to increase acetic acid in Icewine.     

Development of a beverage from red grape juice fermented with the Kombucha consortium

Kombucha is a health-promoting fermented beverage traditionally made by fermenting a sweetened tea with a symbiotic culture of yeast species and acetic acid bacteria. The aim of this work was to develop a beverage using red grape juice as an alternative substrate. Grape juice contains various nutrient elements and phytochemicals, such as polyphenols, which possess a wide range of biological activities. We investigated the chemical characteristics and sensory and antimicrobial activities of the fermented grape juice Kombucha beverage. The pH decreased from 3.95 to 2.9 during the fermentation process and remained fairly constant thereafter, and the acetic acid bacteria and yeast counts in the broth increased up to 6 days of fermentation and subsequently decreased. Phenolic and anthocyanin contents and the antioxidant activity of the fermented beverage were higher after fermentation, with the maximum increase observed on the sixth day of fermentation when values were approximately 2.47- and 1.59-fold higher than pre-fermentation values, respectively, as assessed by 2,2-diphenyl-1-picrylhydrazyl and 2,2′-azino-bis (3-ethylbenzothiazoline-6- sulfonic acid) radical scavenging assays. Fourier transform infrared spectroscopy was used for the qualitative analysis of the grape juice before and after fermentation. Distinct peak variations in the spectral region between 2500 and 1650 cm^?1 were observed, which matched the appearance of organic acids and changes in phenolic compounds. Fermented juice Kombucha showed antibacterial activity toward all tested bacteria, which can be primarily ascribed to the increased production of acetic acid, but also to the biosynthesis of other metabolites, during the fermentation process. The 6-day fermented juice was the most appreciated by the taste panel based on the overall quality evaluation; with prolongation of fermentation the fermented juice acquired a distinct sour flavor.     

Fermentative capability and aroma compound production by yeast strains isolated from Agave tequilana Weber juice

Five yeast strains isolated from agave juice were studied for their fermentative and aromatic capacity. The experiments were performed using agave juice supplemented with ammonium sulphate, as is commonly done in tequila distilleries. Three strains classified as Saccharomyces cerevisiae showed high biomass and ethanol production, as well as higher ethanol tolerance than those classified as Kloeckera africana and Kloeckera apiculata, which showed scarce growth. The results suggest that Kloeckera strains were affected by nutritional limitation and/or toxic compounds present in agave juice. Agave juice analyses showed a lower amino acid content than those reported in grape juice. S. cerevisiae strains produced predominantly amyl and isoamyl alcohols, n-propanol, 2-phenyl ethanol, succinic acid, glycerol, methanol, isoamyl acetate, ethyl hexanoate, acetaldehyde and isobutanol, whereas Kloeckera strains showed a high production of acetic acid, 2-phenyl ethyl acetate and ethyl acetate. The methanol concentration was significantly different among the yeasts studied. The diversity between three S. cerevisiae strains were higher for the aromatic profile than for genetic level and kinetic parameter. On the other hand, the diversity of Kloeckera yeasts were lower than Saccharomyces yeasts even when belonging to two different species.     

Gluconacetobacter sp. gel_SEA623-2, bacterial cellulose producing bacterium isolated from citrus fruit juice

Cellulose producing bacterial strain was isolated from citrus fruit juice fungus. The isolated strain was identified as Gluconacetobacter sp. gel_SEA623-2 based on several morphological characteristics, biochemical tests, and 16S rRNA conducted. Culture conditions for bacterial cellulose production by SEA623-2 were screened in static trays. Conditions were extensively optimized by varying the kind of fruit juice, pH, sugar concentration, and temperature for maximum cellulose production. SEA623-2 has a high productive capacity in citrus processing medium, but not in other fruits. The optimal combination of the media constituents for bacterial cellulose production is as follows: 10% citrus juice, 10% sucrose, 1% acetic acid, and 1% ethanol at 30 °C, pH 3.5. Bacterial cellulose produced by SEA623-2 has soft physical properties, high tensile strength, and high water retention value. The cellulose produced by the selected bacteria is suitable as a cosmetic and medical material.     

Effects of acetic and formic acid on ABE production by <Emphasis Type="Italic">Clostridium acetobutylicum</Emphasis> and <Emphasis Type="Italic">Clostridium beijerinckii</Emphasis>

The effect of acetic acid and formic acid on acetone-butanol-ethanol (ABE) production by solventogenic Clostridia was investigated. The ABE concentration in Clostridium acetobutylicum was found to have increased slightly on addition of 3.7 ∼ 9.7 g/L acetic acid, but was found to have drastically reduced in the presence of 11.7 g/L acetic acid. However, the solvent production of C. beijerinckii was not affected by addition of acetic acid in the range of 3.7 ∼ 11.7 g/L. C. acetobutylicum was more vulnerable to formic acid than C. beijerinckii. In C. acetobutylicum, the total ABE production decreased to 77% on addition of 0.4 g/L formic acid and 25% with 1.0 g/L formic acid. The total ABE production by C. acetobutylicum was also noted to have decreased from 15.1 to 8.6 g/L when 8.7 g/L acetic acid and 0.4 g/L formic acid co-existed. The solvent production by C. beijerinckii was not affected at all under the tested concentration range of formic acid (0.0 ∼ 1.0 g/L) and co-presence of acetic acid and formic acid. Therefore, C. beijerinckii is more favorable than C. acetobutylicum when the ABE is produced using lignocellulosic hydrolysate containing acetic and formic acid.     

Biotechnological suitability of Saccharomycodes ludwigii for fermented beverages

Nineteen Saccharomycodes ludwigii strains were tested for the production of secondary products in grape must fermentation. A predominant metabolic pattern characterized by high production of isobutyl alcohol, acetoin and ethyl acetate was obtained. The occurrence of some strains producing enhanced amounts of these compounds suggests a potential utilization of this species for industrial applications. Feijoa juice was inoculated with a selected S'codes ludwigii strain in comparison to a control strain of S. cerevisiae and evaluation of the fermented products was carried out by 30 consumers with respect to the odour, flavour and taste. The sample fermented by S'codes ludwigii was characterized by a fresh odour with a fruity flavour, identified as flavour of apple and kiwi-fruit. This product was compared to apple juice, with a more acid taste. Despite the high concentrations of acetic acid, this beverage might be considered a potential summer refreshing drink, addressed to a target of consumers who prefer fruit drinks that leave a slightly acid and little sugary taste in the mouth.     

嗜热子囊菌利用短链有机酸生产角质酶

以嗜热子囊菌(Thermobifida fusca WSH03-11)发酵生产角质酶为模型,研究微生物利用市政污泥厌氧酸化所产短链有机酸为碳源发酵生产高附加值产品的可能。发现：(1)以丁酸、丙酸和乙酸为碳源时,有机酸和氮元素浓度分别为8.0 g/L和1.5 g/L有利于角质酶的生产;而以乳酸为碳源时,最适有机酸和氮源浓度分别为3.0 g/L和1.0 g/L;(2)改变诱导物角质的浓度,以丁酸、丙酸、乙酸和乳酸为碳源,分别比优化前提高了31.0%、13.3%、43.8%和73.2%;(3)在四种有机酸中,T. fusca WSH03-11利用乙酸的速率最快,平均比消耗速率是丙酸的1.3倍,丁酸的2.0倍及乳酸的2.2倍;以丁酸为碳源时的酶活(52.4 U/mL)是乳酸的1.7倍、乙酸的2.5倍和丙酸的3.2倍;角质酶对乳酸的得率(12.70 u/mg)分别是丁酸的1.4倍、丙酸的3.0倍和乙酸的3.8倍;(4)以混合酸为碳源生产角质酶,T. fusca WSH03-11优先利用乙酸,而对丁酸的利用受到抑制。进一步研究发现,混合酸中0.5 g/L的乙酸将导致丁酸的消耗量降低66.7%。这是首次利用混合酸作碳源发酵生产角质酶的研究报道。这一研究结果进一步确证了利用市政污泥厌氧酸化所产有机酸为碳源发酵生产高附加值产品的可行性,为以廉价碳源生产角质酶奠定了良好的基础。     

嗜热子囊菌利用短链有机酸生产角质酶

以嗜热子囊菌(Thermobifida fusca WSH03-11)发酵生产角质酶为模型,研究微生物利用市政污泥厌氧酸化所产短链有机酸为碳源发酵生产高附加值产品的可能。发现：(1)以丁酸、丙酸和乙酸为碳源时,有机酸和氮元素浓度分别为8.0 g/L和1.5 g/L有利于角质酶的生产;而以乳酸为碳源时,最适有机酸和氮源浓度分别为3.0 g/L和1.0 g/L;(2)改变诱导物角质的浓度,以丁酸、丙酸、乙酸和乳酸为碳源,分别比优化前提高了31.0%、13.3%、43.8%和73.2%;(3)在四种有机酸中,T. fusca WSH03-11利用乙酸的速率最快,平均比消耗速率是丙酸的1.3倍,丁酸的2.0倍及乳酸的2.2倍;以丁酸为碳源时的酶活(52.4 U/mL)是乳酸的1.7倍、乙酸的2.5倍和丙酸的3.2倍;角质酶对乳酸的得率(12.70 u/mg)分别是丁酸的1.4倍、丙酸的3.0倍和乙酸的3.8倍;(4)以混合酸为碳源生产角质酶,T. fusca WSH03-11优先利用乙酸,而对丁酸的利用受到抑制。进一步研究发现,混合酸中0.5 g/L的乙酸将导致丁酸的消耗量降低66.7%。这是首次利用混合酸作碳源发酵生产角质酶的研究报道。这一研究结果进一步确证了利用市政污泥厌氧酸化所产有机酸为碳源发酵生产高附加值产品的可行性,为以廉价碳源生产角质酶奠定了良好的基础。     

Fine-tuning ethanol oxidation pathway enzymes and cofactor PQQ coordinates the conflict between fitness and acetic acid production by Acetobacter pasteurianus

The very high concentrations required for industrial production of free acetic acid create toxicity and low pH values, which usually conflict with the host cell growth, leading to a poor productivity. Achieving a balance between cell fitness and product synthesis is the key challenge to improving acetic acid production efficiency in metabolic engineering. Here, we show that the synergistic regulation of alcohol/aldehyde dehydrogenase expression and cofactor PQQ level could not only efficiently relieve conflict between increased acetic acid production and compromised cell fitness, but also greatly enhance acetic acid tolerance of Acetobacter pasteurianus to a high initial concentration (3% v/v) of acetic acid. Combinatorial expression of adhA and pqqABCDE greatly shortens the duration of starting-up process from 116 to 99 h, leading to a yield of 69 g l^-1 acetic acid in semi-continuous fermentation. As a final result, average acetic acid productivity has been raised to 0.99 g l^-1 h^-1, which was 32% higher than the parental A. pasteurianus. This study is of great significance for decreasing cost of semi-continuous fermentation for producing high-strength acetic acid industrially. We envisioned that this strategy will be useful for production of many other desired organic acids, especially those involving cofactor reactions.     

Production of Leuconostoc oenos Biomass under pH Control

Leuconostoc oenos was grown on apple juice-based media. The effect of pH control on metabolism and biomass production was studied. Without pH control, L. oenos acidified the apple juice media to approximately pH 3.6. More than 75% of the malic acid was used under these conditions, but less than half of the carbohydrates was assimilated. Under pH control, biomass yields increased by 60%; most of the malic acid was used, but high levels of unfermented carbohydrates remained. The addition of tomato juice, vitamins, nucleotides, Mn⁺, and malic acid did not permit further increases in the cell counts; however, malic acid did induce further acidification. Growth without pH control favored a more homofermentative metabolism. Biomass production was higher in filter-sterilized apple juice media compared with that in the autoclaved media.     

Statistical screening of medium components by Plackett-Burman design for lactic acid production by Lactobacillus sp. KCP01 using date juice

Statistical screening of media components for production of lactic acid by Lactobacillus sp. KCP01 using date juice as a sugar source was carried out by Plackett-Burman design. Date juice at 5% sugar concentration when used alone showed 2.6 g/l of lactic acid production. Increase in lactic acid production (15.1 g/l) was observed with supplementation of salts and organic nitrogen sources of MRS medium and after optimization of pH and temperature using date juice as a C-source. Plackett-Burman design showed peptone, K2HPO4, sodium acetate and date juice as significant components influencing the lactic acid production.     

絮凝基因FLO1及FLO1c高表达提高工业酿酒酵母乙酸耐受性及发酵性能

乙酸是生物质乙醇发酵过程中酵母细胞面临的重要抑制剂之一,对细胞生长及发酵性能有强烈的抑制作用。增强酵母菌对乙酸胁迫的耐受性对提高乙醇产率具有重要意义。用分别带有完整絮凝基因FLO1及其重复序列单元C发生缺失的衍生基因FLO1c的重组表达质粒分别转化非絮凝型工业酿酒酵母CE6,获得絮凝型重组酵母菌株6-AF1和6-AF1c。同时以空载体p YCPGA1转化CE6的菌株CE6-V为对照菌株。与CE6-V相比,絮凝酵母明显提高了对乙酸胁迫的耐受性。在0.6%(V/V)乙酸胁迫下,6-AF1和6-AF1c的乙醇产率分别为对照菌株CE6-V的1.56倍和1.62倍;在1.0%(V/V)乙酸胁迫下,6-AF1和6-AF1c的乙醇产率分别为对照菌株CE6-V的1.21倍和1.78倍。可见絮凝能力改造能明显提高工业酿酒酵母的乙酸胁迫耐受性及发酵性能,而且FLO1内重复序列单元C缺失具有更加明显的效果。     

代谢副产物乙酸对L-色氨酸发酵的影响

分析了重组大肠杆菌(E.coli TRTH/pSV-709)发酵生产L-色氨酸的发酵过程,检测结果表明发酵液中有大量代谢副产物乙酸的积累。利用外源添加试验研究了乙酸对L-色氨酸发酵的影响,结果表明乙酸浓度高于2g/L时对L-色氨酸生产菌的生长和产酸均有抑制作用。分析了乙酸的产生机制,并采取了调节溶氧水平、确定合适初始葡萄糖浓度、限制葡萄糖流加及控制菌体比生长速率等措施来减少乙酸的生成。在优化条件下,乙酸含量与原工艺相比降低了51.35%,菌体生物量和L-色氨酸产量分别提高了51.07%和46.54%,实现了高密度发酵培养的目的。     

Interaction effects of lactic acid and acetic acid at different temperatures on ethanol production by <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> in corn mash

The combined effects of lactic acid and acetic acid on ethanol production by S. cerevisiae in corn mash, as influenced by temperature, were examined. Duplicate full factorial experiments (three lactic acid concentrations × three acetic acid concentrations) were performed to evaluate the interaction between lactic and acetic acids on the ethanol production of yeast at each of the three temperatures, 30, 34, and 37°C. Corn mash at 30% dry solids adjusted to pH 4 after lactic and acetic acid addition was used as the substrate. Ethanol production rates and final ethanol concentrations decreased (P<0.001) progressively as the concentration of combined lactic and acetic acids in the corn mash increased and the temperature was raised from 30 to 37°C. At 30°C, essentially no ethanol was produced after 96 h when 0.5% w/v acetic acid was present in the mash (with 0.5, 2, and 4% w/v lactic acid). At 34 and 37°C, the final concentrations of ethanol produced by the yeast were noticeably reduced by the presence of 0.3% w/v acetic acid and ≥2% w/v lactic acid. It can be concluded that, as in previous studies with defined media, lactic acid and acetic acid act synergistically to reduce ethanol production by yeast in corn mash. In addition, the inhibitory effects of combined lactic and acetic acid in corn mash were more apparent at elevated temperatures.     

Metabolic profile of ginkgo kernel juice fermented with lactic aicd bacteria: A potential way to degrade ginkgolic acids and enrich terpene lactones and phenolics

In this paper, the influence of lactic acid fermentation on the metabolic profile of ginkgo kernel juice was studied. For this purpose, three lactic acid bacteria (LAB), Lactobacillus acidophilus, Lactobacillus plantarum and Lactobacillus casei, were selected. The results showed that all the lactobacilli grew well in ginkgo kernel juice with viable cell counts exceeding 8.0 Log CFU/mL. The organic acid contents underwent dynamic changes, and the lactic acid production reached more than 3 g/L. The consumption of sugars and free amino acids by LAB was evident. Meanwhile, more than 70% of the ginkgolic acids were degraded by LAB, and the final concentrations in ginkgo kernel juice were below 1 mg/L after 48 h of fermentation. In contrast, the terpene lactones contents in fermented ginkgo kernel juice exceed 20 mg/L, which was 1.6-fold higher than that in the unfermented juice. Certain phenolics were significantly enriched, and the total phenolic content increased by approximately 9% through fermentation. In addition, lactic acid fermentation significantly enhanced the antioxidant and antimicrobial activities of ginkgo kernel juice. Overall, the results indicated that lactic acid fermentation can effectively improve the nutritional value and safety of ginkgo kernel juice.     

The influence of pH and temperature on the behaviour of Salmonella enteritidis phage type 4 in home-made mayonnaise

The behaviour of Salmonella enteritidis phage type 4 in home-made mayonnaise was studied. Samples of mayonnaise were prepared with different pH values using wine vinegar or lemon juice in order to bring down the pH to 5,4.5,4 and 3.6, inoculate and incubated at 4, 24 and 35C for 5 days. The results showed a better bactericidal activity of the vinegar (acetic acid) than the lemon juice (citric acid), both of these acids being more active at higher temperatures. For preventing salmonellosis transmission by home-made mayonnaise the use of vinegar as an acidulant in order to achieve a pH between 3.6 and 4 and storage in a warm place is recommended.     

耐乙酸乳杆菌的筛选及其产乳酸特性

【背景】耐受乙酸的乳酸菌是传统谷物醋醋酸发酵过程中产生乳酸及其风味衍生物的重要功能微生物。【目的】从镇江香醋醋醅中分离鉴定具有耐乙酸特性的乳酸菌,并评价不同条件下该菌株的产乳酸能力。【方法】利用4%(体积比)乙酸含量的MRS培养基分离耐乙酸乳酸菌;对其进行16S rRNA基因鉴定、基因组测序、形态观察以及生理生化特性研究;考察不同乙酸浓度、葡萄糖浓度、发酵温度和时间对菌株产乳酸能力的影响。【结果】分离得到一株可耐受6%乙酸的乳杆菌Lactobacillus sp. JN500903;在厌氧静置、接种量5%、乙酸浓度5%、葡萄糖浓度40 g/L、发酵温度37°C、发酵时间10 d条件下,该菌株乳酸产量为16.1 g/L。【结论】乳杆菌JN500903能够耐受6%乙酸浓度,具有在酸性环境下合成乳酸的能力,有一定的应用潜力。