携多拷贝glaA的重组黑曲霉过量合成糖化酶的研究

以工业生产菌株黑曲霉CICIMF0410基因组DNA为模板,扩增出糖化酶glaA基因,测序并进行表达研究。GlaA基因的核苷酸序列长为2167bp,包含4个内含子。氨基酸序列比对表明此黑曲霉糖化酶与其他曲霉属来源的糖化酶有很高的同源性。将glaA基因克隆到pBC-Hygro载体中,构建重组质粒pBC-Hygro-glaA并转化A.nigerF0410。携多拷贝glaA的转化子用150μg/mL潮霉素抗性筛选并通过荧光实时定量PCR鉴定。结果表明,在染色体整合2~3倍糖化酶基因对糖化酶的过量合成是适宜的,有助于提高糖化酶活力。对转化子进行摇瓶发酵研究,发酵终止时转化子GB0506的糖化酶活力比出发菌株F0410提高了17.5%。因此,增加黑曲霉染色体糖化酶基因的拷贝数可以显著提高糖化酶活力。     

强启动子glaA介导cbhB基因在黑曲霉中的表达

黑曲霉纤维素酶三类不同酶系中,纤维二糖水解酶基因表达处于很低水平,导致纤维素酶总体活力水平不高。为构建黑曲霉纤维素酶高产菌株,采用基因工程方法,全基因合成拼接黑曲霉高表达葡萄糖淀粉酶基因glaA的强启动子片段与纤维二糖水解酶基因cbhB编码区片段,然后将杂合基因克隆到二元载体pCAMBIA1301上,重组质粒通过农杆菌介导转化黑曲霉分生孢子,携带杂合基因的T-DNA片段插入到黑曲霉转化子的染色体上,共筛选到48个具有潮霉素抗性的转化子。纤维素酶活力水平测定结果显示,转化子A3-9的CMC酶活力最高,为野生型黑曲霉菌株的1.31倍;转化子B1-7与A3-6的滤纸酶活力最高,为野生型黑曲霉菌株2.51倍。另外,初步分析了杂合基因在黑曲霉中的表达所需的诱导条件。     

黑曲霉糖化酶高产和低产菌株糖化酶基因调控区的克隆及其分析比较

以PCR合成的糖化酶高产菌株黑曲霉(Asp. Niger)T21糖化酶基因5’近端非编码区588bp(EcoRI-BamHI)的序列为探针,从T21染色体DNA中克隆到近2.0kb的糖化酶基因5’端非编码区序列,并以此序列为探针从糖化酶低产菌株黑曲霉3.795(T21的诱变出发株)的染色体DNA中克隆到1.5kb的糖化酶基因5’端非编码区序列。该二序列的分析测定结果表明,其结构特征与文献报道的黑曲霉糖化酶基因5’端非编码区的基本一致,被称为“核心启动子”(Core promoter)的TATAAAT框及GCAAT框,分别在翻译起始点的-109bp及-178bp处。此外,在曲霉amdS,amyB基因中已发现有调控功能的CCAAT序列存在于-449bp和-799bp处。高产和低产菌株糖化酶基因5’端非编码区序列的分析比较结果表明,有9个部位的碱基发生了变化。此实验结果为进一步研究黑曲霉糖化酶基因在转录水平上的调控规律打下了基础。     

瑞氏木霉表达黑曲霉葡萄糖氧化酶

利用高表达分泌纤维素酶的真菌瑞氏木霉表达重组的黑曲霉葡萄糖氧化酶。在大肠杆菌DH5α中构建瑞氏木霉纤维素酶CBHI启动子和CBHI信号肽基因黑曲霉葡萄糖氧化酶基因瑞氏木霉纤维素酶CBHI终止子构巢曲霉的甘油醛3磷酸脱氢酶启动子大肠杆菌抗潮霉素B磷酸转移酶基因构巢曲霉色氨酸C终止子pUC19(命名为pCBHGOD)质粒,线性化后用瑞氏木霉纤维素酶CBHI启动子和CBHI信号肽基因黑曲霉葡萄糖氧化酶基因瑞氏木霉纤维素酶CBHI终止子构巢曲霉的甘油醛3磷酸脱氢酶启动子大肠杆菌抗潮霉素B磷酸转移酶基因构巢曲霉色氨酸C终止子(命名为CBHGOD)核酸片段转化瑞氏木霉QM9414原生质体。用PCR扩增方法筛选出同源重组葡萄糖氧化酶基因的瑞士木霉突变株。用麦杆诱导瑞氏木霉突变株,生产黑曲霉葡萄糖氧化酶,Westernblot分析重组的葡萄糖氧化酶分子量与Sigma公司的天然黑曲霉葡萄糖氧化酶一致,生产的重组酶活性25umL,相当于Sigma公司葡萄糖氧化酶标准品的产量为0.5gL。瑞氏木霉可用于生产黑曲霉葡萄糖氧化酶。     

The Aspergillus niger acuA and acuB genes correspond to the facA and facB genes in Aspergillus nidulans

Mutants in Aspergillus niger unable to grow on acetate as a sole carbon source were previously isolated by resistance to 1.2% propionate medium containing 0.1% glucose. AcuA mutants lacked acetyl-CoA synthetase (ACS) activity and acuB mutants lacked both ACS and isocitrate lyase activity. An acuA mutant was transformed to the acu+ phenotype with a clone of ACS (facA) from Aspergillus nidulans. The acuB mutant was transformed with the A. niger facB clone which has been identified by cross-hybridisation of an A. nidulans facB clone. These results confirm that acuA in A. niger is the gene for ACS and acuB is analogous to the A. nidulans facB regulatory gene.     

Cloning and use of sC as homologous marker for Aspergillus niger transformation

The sC sequence from Aspergillus niger was cloned and developed into a homologous marker system for genetic transformation. The coding region of the sC gene amplified by PCR from the A. niger genome was provided with Aspergillus nidulans expression signals (gpdA promoter and trpC terminator). This chimeric construct was used to successfully transform a spontaneous sC- isolate of A. niger to prototrophy. The transformants analyzed by Southern analysis showed integration of multiple copies of the transforming DNA. They also exhibited much higher ATP sulfurylase activity than the wild-type A. niger strain reinforcing the molecular data. This demonstrates the usefulness of the sCniger construct, driven by PgpdA, as a marker for A. niger transformation.     

Cloning and characterization of the nagA gene that encodes beta-n-acetylglucosaminidase from Aspergillus nidulans and its expression in Aspergillus oryzae

We isolated a beta-N-acetylglucosaminidase encoding gene and its cDNA from the filamentous fungus Aspergillus nidulans, and designated it nagA. The nagA gene contained no intron and encoded a polypeptide of 603 amino acids with a putative 19-amino acid signal sequence. The deduced amino acid sequence was very similar to the sequence of Candida albicans Hex1 and Trichoderma harzianum Nag1. Yeast cells containing the nagA cDNA under the control of the GAL1 promoter expressed beta-N-acetylglucosaminidase activity. The chromosomal nagA gene of A. nidulans was disrupted by replacement with the argB marker gene. The disruptant strains expressed low levels of beta-N-acetylglucosaminidase activity and showed poor growth on a medium containing chitobiose as a carbon source. Aspergillus oryzae strain carrying the nagA gene under the control of the improved glaA promoter produced large amounts of beta-N-acetylglucosaminidase in a wheat bran solid culture.     

黑曲霉3.795glaA基因及其5'调控区的克隆和序列分析

黑曲霉Ｔ２１是由黑曲霉３．７９５经诱变育种获得的糖化酶高产菌株,为阐明其高产的分子机制,由黑曲霉３．７９５克隆了糖化酶结构基因及其５′旁侧序列,并与黑曲霉Ｔ２１的相应序列进行了比较．由黑曲霉３．７９５菌丝体分离染色体ＤＮＡ,Ｓｏｕｔｈｅｒｎ杂交分析表明,糖化酶结构基因位于～２．５ｋｂ的ＥｃｏＲⅠ－ＥｃｏＲⅤ染色体ＤＮＡ片段上,在此ＥｃｏＲⅠ位点上游约１．０ｋｂ处有一ＳａｌⅠ位点．为构建糖化酶结构基因及其５′旁侧序列的基因组文库,该染色体ＤＮＡ分别用ＥｃｏＲⅠ＋ＥｃｏＲⅤ和ＥｃｏＲ＋ＳａｌⅠ消化,琼脂糖凝胶电泳分离并回收长度在１．０ｋｂ左右和２．５ｋｂ左右的ＤＮＡ片段,分别与ｐＵＣ１９载体连接后转化入Ｅ．ｃｏｌｉＤＨ５．用原位杂交方法筛选到了携带糖化酶基因编码区及其１５０５ｂｐ５′旁侧序列的阳性克隆．对克隆片段的ＤＮＡ序列进行了测定并与黑曲霉Ｔ２１的相应序列进行了比较,结果表明,在糖化酶基因编码区及其１５０ｂｐ３′非编码区内,未发现碱基差异,但在－３４０～－１５０５的５′上游区内发生了９个位置的碱基变化,包括缺失、插入和替换．这些结果表明,黑曲霉Ｔ２１与３．７９５的糖化酶产量的差异与其结构基因无关,但可能与其     

嗜热糖化酶基因在重组黑曲霉工程菌中的表达及酶学性质初步研究

为了提高糖化酶的耐热性能,降低淀粉糖化发酵工艺的生产成本,构建了同源整合载体pEasy-glaAdir以及pEasyssg,将黑曲霉(Aspergillus niger)的糖化酶基因(glaA)灭活,并将硫磺矿硫化叶菌(Sulfolobus solfataricus)的嗜热糖化酶基因(ssg)插入到黑曲霉基因组中,筛选得到表达嗜热糖化酶的重组黑曲霉工程菌(A.nigerWW1)。重组菌的发酵结果显示,嗜热糖化酶在黑曲霉中得到了分泌表达,发酵液酶活达到3 030 U/mL。重组嗜热糖化酶的最适反应温度为90℃,最适pH为6.0,该酶具有较高的热稳定性,在80℃时的半衰期在60 min以上,具有良好的工业应用前景。     

The polygalacturonases of Aspergillus niger are encoded by a family of diverged genes.

Aspergillus niger produces several polygalacturonases that, with other enzymes, are involved in the degradation of pectin. One of the two previously characterized genes coding for the abundant polygalacturonases I and II (PGI and PGII) found in a commercial pectinase preparation was used as a probe to isolate five more genes by screening a genomic DNA library in phage lambda EMBL4 using conditions of moderate stringency. The products of these genes were detected in the culture medium of Aspergillus nidulans transformants on the basis of activity measurements and Western-blot analysis using a polyclonal antibody raised against PGI. These transformants were, with one exception, constructed using phage DNA. A. nidulans transformants secreted high amounts of PGI and PGII in comparison to the previously characterized A. niger transformants and a novel polygalacturonase (PGC) was produced at high levels by A. nidulans transformed with the subcloned pgaC gene. This gene was sequenced and the protein-coding region was found to be interrupted by three introns; the different intron/exon organization of the three sequenced A. niger polygalacturonase genes can be explained by the gain or loss of two single introns. The pgaC gene encodes a putative 383-amino-acid prepro-protein that is cleaved after a pair of basic amino acids and shows approximately 60% amino acid sequence similarity to the other polygalacturonases in the mature protein. The N-terminal amino acid sequences of the A. niger polygalacturonases display characteristic amino acid insertions or deletions that are also observed in polygalacturonases of phytopathogenic fungi. In the upstream regions of the A. niger polygalacturonase genes, a sequence of ten conserved nucleotides comprising a CCAAT sequence was found, which is likely to represent a binding site for a regulatory protein as it shows a high similarity to the yeast CYC1 upstream activation site recognized by the HAP2/3/4 activation complex.     

Heterologous gene expression in Aspergillus niger: a glucoamylase-porcine pancreatic prophospholipase A2 fusion protein is secreted and processed to yield mature enzyme.

The cDNA gene encoding porcine pancreatic prophospholipase A2 (proPLA2) was cloned into an Aspergillus niger expression vector downstream of the glucoamylase (glaA) gene promoter region. When this construct was transformed into A. niger, no detectable PLA2 was produced. Evidence was obtained showing that the PLA2 gene was transcribed and that PLA2 is extremely susceptible to both intracellular and extracellular proteases of A. niger, thus indicating that translation products would be rapidly degraded. By fusing the proPLA2-encoding sequence to the entire glaA gene, secreted yields of PLA2 up to 10 micrograms/ml were obtained from a transformed protease-deficient strain of A. niger. PLA2 was secreted in young cultures as a fusion protein, but in older cultures, it was processed from the glucoamylase carrier protein. Secreted PLA2 was shown to be enzymatically active and to have the correct N-terminal amino acid (aa) sequence, although another form of processed PLA2 was also produced. This form included two aa of the proregion from PLA2. The potential for improving yields of secreted heterologous proteins from A. niger still further is discussed.     

植酸酶产生菌黑曲霉N14的诱变选育及其基因分析

以植酸酶产生菌黑曲霉03214为出发菌株,经紫外线和亚硝基胍诱变,获得了产酶活性较出发菌株提高了22．3％,达422IU／ml发酵液的突变菌株黑曲霉N14,其最适pH值为2．5,最适温度为50℃。通过对黑曲霉N14植酸酶phyA基因进行PCR扩增,获得了一条长约1．5kb的特异性产物。以pMD18-T为载体,构建了含有目的基因片段的重组质粒。DNA序列测定表明,目的基因片段含有植酸酶phyA基因的完整序列(GenBank Accession：AY426977),phyA基因全长1506bp,其中包含一段长102bp的内含子,编码467个氨基酸,有10个潜在的糖基化位点,5’端有一编码19个氨基酸的信号肽序列。实验结果为植酸酶基因工程菌的构建奠定了基础。