Pyruvate metabolism in rice coleoptiles under anaerobiosis

Relative importance of ethanolic, lactate and alanine fermentation pathways was estimated in coleoptiles of rice seedlings (Oryza sativa L.) subjected to anoxic stress. The in vitro activities of alcohol dehydrogenase (ADH, EC 1.1.1.1), pyruvate decarboxylase (PDC, EC 4.1.1.1) and alanine aminotransferase (AlaAT, EC 2.6.1.2) in the coleoptiles increased in anoxia, whereas no significant increase was measured in lactate dehydrogenase (LDH, EC 1.1.1.27) activity. At 48 h, the ADH, PDC and AlaAT activities in anoxic coleoptiles were 62-, 15- and 7.6-fold greater, respectively, than those in the presence of oxygen. Ethanol and alanine in the coleoptiles accumulated rapidly under anoxia, increasing by 48 h, 57- and 5.6-fold compared with those in the presence of oxygen, respectively. However, lactate concentration did not increase and no initial burst of lactate production was detected. The relative ratio of carbon flux from pyruvate to ethanol, lactate and alanine in anoxic coleoptiles was estimated to be 92, 1 and 7% of the total carbon flux, respectively. These results suggest that the potential carbon flux from pyruvate to ethanol may be much greater than the potential flux from pyruvate to lactate and alanine in rice coleoptiles during anoxia.     

Influence of NO3 - and NH4 + nutrition on fermentation,nitrate reductase activity and adenylate energy charge of roots of Carex pseudocyperus L. and Carex sylvatica Huds. exposed to anaerobic nutrient solutions

The adenylate energy charge, production of ethanol and lactate, and nitrate reductase activity were determined in order to study the influence of different nitrogen sources on the metabolic responses of roots of Carex pseudocyperus L. and Carex sylvatica HUDS. exposed to anaerobic nutrient solutions. Determination of adenylates was carried out by means of a modified HPLC technique. Total quantity of adenylates was higher in Carex pseudocyperus than in Carex sylvatica under all conditions. In contrast, the adenylate energy charge was only slightly different between the species and decreased more or less in relation to the applied nitrogen source under oxygen deficiency. The adenylate energy charge in roots of plants under nitrate nutrition showed a smaller decrease under anaerobic environmental conditions than plants grown with ammonium or nitrate/ammonium. Roots of nitrate-fed plants showed a lower ethanol and lactate production than ammonium/nitrate- and ammonium-fed plants. Ethanol production was higher in C. pseudocyperus, formation of lactate was lower compared to that in Carex sylvatica. The activity of enzymes involved in fermentation processes (ADH, LDH and PDC) was enhanced significantly after 24 hours of exposure to anaerobic nutrient solutions in roots of both species. The induction of these enzymes was only slightly influenced by different nitrogen supply. In vivo nitrate reductase activity increased almost 3-fold compared to the aerobic treatment in both species and overcompensated loss of NADH reoxidation capacity caused by decrease of ethanol and lactate development. Induction of in vitro nitrate reductase activity was enhanced 313% in C. pseudocyperus and 349% in C. sylvatica under anaerobic environmental conditions and nitrate supply. These results indicate that nitrate may serve as an alternative electron acceptor in anaerobic plant root metabolism and that the nitrate-supported energy charge may be due to an accelerated glycolytic flux resulting from a more effective NADH reoxidation capacity by nitrate reduction plus fermentation than by fermentation alone.Abbreviations ADH alcohol dehydrogenase - AEC adenylate energy charge - DMSO dimethyl sulfoxide - EDTA ethylen diamine tetraacetic acid - HPLC high performance liquid chromatography - LDH lactate dehydrogenase - NRA nitrate reductase activity - PCA perchloric acid - PDC pyruvate decarboxylase - PVP polyvinylpyrrolidone - PVPP polyvinylpolypyrrolidone - TCA trichloroacetic acid, Tris-tris(hydroxymethyl)aminomethane     

Double mutation of the <Emphasis Type="Italic">PDC1</Emphasis> and <Emphasis Type="Italic">ADH1</Emphasis> genes improves lactate production in the yeast <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> expressing the bovine lactate dehydrogenase gene

Expression of a heterologous l-lactate dehydrogenase (l-ldh) gene enables production of optically pure l-lactate by yeast Saccharomyces cerevisiae. However, the lactate yields with engineered yeasts are lower than those in the case of lactic acid bacteria because there is a strong tendency for ethanol to be competitively produced from pyruvate. To decrease the ethanol production and increase the lactate yield, inactivation of the genes that are involved in ethanol production from pyruvate is necessary. We conducted double disruption of the pyruvate decarboxylase 1 (PDC1) and alcohol dehydrogenase 1 (ADH1) genes in a S. cerevisiae strain by replacing them with the bovine l-ldh gene. The lactate yield was increased in the pdc1/adh1 double mutant compared with that in the single pdc1 mutant. The specific growth rate of the double mutant was decreased on glucose but not affected on ethanol or acetate compared with in the control strain. The aeration rate had a strong influence on the production rate and yield of lactate in this strain. The highest lactate yield of 0.75 g lactate produced per gram of glucose consumed was achieved at a lower aeration rate.     

Efficient production of L-Lactic acid by metabolically engineered Saccharomyces cerevisiae with a genome-integrated L-lactate dehydrogenase gene

We developed a metabolically engineered yeast which produces lactic acid efficiently. In this recombinant strain, the coding region for pyruvate decarboxylase 1 (PDC1) on chromosome XII is substituted for that of the l-lactate dehydrogenase gene (LDH) through homologous recombination. The expression of mRNA for the genome-integrated LDH is regulated under the control of the native PDC1 promoter, while PDC1 is completely disrupted. Using this method, we constructed a diploid yeast transformant, with each haploid genome having a single insertion of bovine LDH. Yeast cells expressing LDH were observed to convert glucose to both lactate (55.6 g/liter) and ethanol (16.9 g/liter), with up to 62.2% of the glucose being transformed into lactic acid under neutralizing conditions. This transgenic strain, which expresses bovine LDH under the control of the PDC1 promoter, also showed high lactic acid production (50.2 g/liter) under nonneutralizing conditions. The differences in lactic acid production were compared among four different recombinants expressing a heterologous LDH gene (i.e., either the bovine LDH gene or the Bifidobacterium longum LDH gene): two transgenic strains with 2microm plasmid-based vectors and two genome-integrated strains.     

Pyruvate decarboxylases from the petite-negative yeast<Emphasis Type="Italic"> Saccharomyces kluyveri</Emphasis>

Saccharomyces kluyveri is a petite-negative yeast, which is less prone to form ethanol under aerobic conditions than is S. cerevisiae. The first reaction on the route from pyruvate to ethanol is catalysed by pyruvate decarboxylase, and the differences observed between S. kluyveri and S. cerevisiae with respect to ethanol formation under aerobic conditions could be caused by differences in the regulation of this enzyme activity. We have identified and cloned three genes encoding functional pyruvate decarboxylase enzymes ( PDC genes) from the type strain of S. kluyveri (Sk-PDC11, Sk-PDC12 and Sk-PDC13). The regulation of pyruvate decarboxylase in S. kluyveri was studied by measuring the total level of Sk-PDC mRNA and the overall enzyme activity under various growth conditions. It was found that the level of Sk-PDC mRNA was enhanced by glucose and oxygen limitation, and that the level of enzyme activity was controlled by variations in the amount of mRNA. The mRNA level and the pyruvate decarboxylase activity responded to anaerobiosis and growth on different carbon sources in essentially the same fashion as in S. cerevisiae. This indicates that the difference in ethanol formation between these two yeasts is not due to differences in the regulation of pyruvate decarboxylase(s), but rather to differences in the regulation of the TCA cycle and the respiratory machinery. However, the PDC genes of Saccharomyces/Kluyveromyces yeasts differ in their genetic organization and phylogenetic origin. While S. cerevisiae and S. kluyveri each have three PDC genes, these have apparently arisen by independent duplications and specializations in each of the two yeast lineages.Communicated by C. P. Hollenberg     

Sucrose and overexpression of trehalose biosynthetic genes (<Emphasis Type="Italic">otsBA</Emphasis>) increase desiccation tolerance of recombinant <Emphasis Type="Italic">Escherichia coli</Emphasis>

Survival after desiccation was highest for recombinant strains of E. coli engineered to produce ethanol (KO11 and LY163) and lactate (TG106) when sucrose was provided as the fermentable sugar. Desiccation tolerance was lower with glucose and xylose. Further improvements in desiccation tolerance with sucrose were obtained by combining this with increased expression of otsBA genes encoding trehalose biosynthesis, removal of products from metabolism by resuspending in fresh medium, and harvesting cells prior to the end of log phase. With sucrose and otsBA expression, survivals of 20%–80% were readily achieved. Fermentation tests with EM2L, a derivative of LY163 expressing ostBA, demonstrated that ethanol production from seed fermentations begun with desiccated cells is equivalent to that of an undesiccated control.     

Functional Expression of Bacterial Zymobacter palmae Pyruvate Decarboxylase Gene in Lactococcus lactis

A pyruvate decarboxylase (PDC) gene from bacterial Zymobacter palmae (Zymopdc) was cloned, characterized, and introduced into Lactococcus lactis via a shuttle vector pAK80 as part of a research strategy to develop an efficient ethanol-producing lactic acid bacteria (LAB). The expression levels of Zymopdc gene in the host, as measured by a colorimetric assay based on PDC catalyzed formation of (R)-phenylacetylcarbinol ((R)-PAC), appeared to be dependent on the strength of corresponding Gram-positive promoters. A constitutive, highly expressed promoter conferred the greatest PDC activity, and an acid-inducible promoter demonstrated acid-inducible expression. The metabolic production of ethanol and other products was examined in flask fermentations. More than eightfold increases in acetaldehyde concentrations were detected in two recombinant strains. However, no detectable differences for ethanol fermentation in these engineered strains were observed compared with that of the strain carrying lacZ reporter.Names are necessary to report factually on available data; however, the USDA neither guarantees nor warrants the standard of the product, and the use of the names by USDA implies no approval of the product to the exclusion of others that may also be suitable.     

Characterization of wine Lactobacillus plantarum by PCR-DGGE and RAPD-PCR analysis and identification of Lactobacillus plantarum strains able to degrade arginine

Summary Screening of strains isolated from red wine undergoing malolactic fermentation allowed the identification of lactic acid bacteria able to degrade arginine. A denaturing gradient gel electrophoresis approach, using the rpoB gene as the molecular target, was developed in order to characterize the isolated strains. Several strains were identified as Lactobacillus plantarum and were typed by RAPD-PCR with several randomly designed primers. Almost all of the␣L. plantarum strains identified were able to produce citrulline and ammonia, suggesting that the ability of␣L.␣plantarum to degrade arginine is a common feature in wine. During the characterization of the newly identified L.␣plantarum strains, the presence of genes coding for the arginine deiminase (ADI) pathway was observed in the strains able to produce citrulline, while the lack of this genes was observed in strain unable to produce citrulline. These results suggest that the degradation of arginine in L. plantarum is probably strain-dependent.     

Engineering a native homoethanol pathway in Escherichia coli B for ethanol production

A native homoethanol pathway (pyruvate-to-acetyl-CoA-to-acetaldehyde-to-ethanol) was engineered in Escherichia coli B. The competing fermentation pathways were eliminated by chromosomal deletions of the genes encoding for fumarate reductase (frdABCD), lactate dehydrogenase (ldhA), acetate kinase (ackA), and pyruvate formate lyase (pflB). For redox balance and anaerobic cell growth, the pyruvate dehydrogenase complex (aceEF-lpd, a typical aerobically-expressed operon) was highly expressed anaerobically using a native anaerobic inducible promoter. The resulting strain SZ420 (ΔfrdBC ΔldhA ΔackA ΔfocA-pflB ΔpdhR::pflBp6-pflBrbs-aceEF-lpd) contains no foreign genes and/or promoters and efficiently ferments glucose and xylose into ethanol with a yield of 90% under anaerobic conditions.     

Oxygen dependent lactate utilization by Lactobacillus plantarum

Lactobacillus plantarum P5 grew aerobically in rich media at the expense of lactate; no growth was observed in the absence of aeration. The oxygen-dependent growth was accompanied by the conversion of lactate to acetate which accumulated in the growth medium. Utilization of oxygen with lactate as substrate was observed in buffered suspensions of washed whole cells and in cell-free extracts. A pathway which accounts for the generation of adenosine triphosphate during aerobic metabolism of lactate to acetate via pyruvate and acetyl phosphate is proposed. Each of the enzyme activities involved, nicotinamide adenine dinucleotide independent lactic dehydrogenase, nicotinamide adenine dinucleotide dependent lactic dehydrogenase, pyruvate oxidase, acetate kinase and NADH oxidase were demonstrated in cell-free extracts. The production of pyruvate, acetyl phosphate and acetate was demonstrated using cell-free extracts and cofactors for the enzymes of the proposed pathway.Abbreviations MRS Man, Rogosa and Sharpe (1960) medium modified as in Materials and methods - TY Tryptone Yeast Extract broth - OUL Oxygen uptake with lactate as substrate - DCPIP 2,6-Dichlorophenolindophenol - LDH Lactic dehydrogenase     

The influence of carbon sources and mononucleotides on the production of extracellular alkaline phosphatase by bacillus intermedium

The biosynthesis of extracellular alkaline phosphatase in the streptomycin-resistant strainsBacillus intermedius S3-19 and S7 in the presence in the medium of 5’-nucleoside monophosphates and different sources of carbon—glucose, sodium pyruvate, sodium lactate, or glycerol—was studied. It was established that, in the presence of mononucleotides, the content of extracellular alkaline phosphatase in both strains increased; the maximal effect was caused by 5’-AMP at a concentration of 20μg/ml. In medium with a low orthophosphate content, where active biosynthesis of alkaline phosphatase occurred, 1% glucose and 0.5% pyruvate stimulated this process 2.5–4 times, and 2% sodium lactate and sodium pyruvate, on the contrary, inhibited it by 20–40%. Analysis of the dynamics of growth and accumulation of extracellular phosphatase in the presence of different sources of carbon in the medium gives evidence of an interrelationship between the biosynthesis of alkaline phosphatase and carbon metabolism inBacillus intermedius.     

Increased ethanol resistance in <Emphasis Type="Italic">Ethanolic Escherichia coli</Emphasis> by Insertion of heat-shock genes BEM1 and SOD2 from <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis>

Ethanol is generally toxic to microorganisms, and intracellular and extracellular accumulation of ethanol inhibits cell growth and metabolism. In this study, pyruvate decarboxylase (pdc) and alcohol dehydrogenase (adhB) were cloned into pET-32a vector and then introduced into E. coli BL21 to produce ethanol. Heat shock genes (BEM1 and SOD2) from Saccharomyces cerevisiae were inserted into recombinant ethanolic E. coli using pET28_a vector to improve ethanol shock resistance. Three different strains were constructed: Ethanolic E. coli (adhB and pdc genes inserted using pET32_a vector), BEM1 gene-inserted E. coli (BEM1 inserted using pET_28a), and SOD2-inserted E. coli (SOD2 inserted using pET28_a). Construction of these three different strains allowed comparison of the functions of these heat shock genes as well as their roles in ethanol tolerance. The toxicity of ethanol in recombinant ethanolic E. coli was tested by measuring cell growth in response to various ethanol concentrations. The results show that SOD2-inserted E. coli showed higher ethanol resistance than ethanolic E. coli.     

Cloning and expression of the structural gene for pyruvate decarboxylase of Zymomonas mobilis in Escherichia coli

A genomic library of Zymomonas mobilis DNA was constructed in Escherichia coli using cosmid vector pHC79. Immunological screening of 483 individual E. coli strains revealed two clones expressing pyruvate decarboxylase, the key enzyme for efficient ethanol production of Z. mobilis. The two plasmids, pZM1 and pZM2, isolated from both E. coli strains were found to be related and to exhibit a common 4.6 kb SphI fragment on which the gene coding for pyruvate decarboxylase, pdc, was located.The pdc gene was similarily well expressed in both aerobically and anaerobically grown E. coli cells, and exerted a considerable effect on the amount of fermentation products formed. During fermentative growth on 25 mM glucose, plasmid-free E. coli lacking a pdc gene produced 6.5 mM ethanol, 8.2 mM acetate, 6.5 mM lactate, 0.5 mM succinate, and about 1 mM formate leaving 10.4 mM residual glucose. In contrast, recombinant E. coli harbouring a cloned pdc gene from Z. mobilis completely converted 25 mM glucose to up to 41.5 mM ethanol while almost no acids were formed.     

Sequence analysis of the α-galactosidase <Emphasis Type="Italic">MEL</Emphasis> gene governing the efficient production of ethanol from raffinose-rich molasses in the yeast <Emphasis Type="Italic">Lachancea thermotolerans</Emphasis>

The yeast Lachancea thermotolerans, formerly Kluyveromyces thermotolerans, was tested for the ethanol fermentation of raffinose-rich molasses. Two melibiose-fermenting strains, NBRC 10066 and NBRC 10067, produced more ethanol than eight other strains. The concentration of ethanol synthesized by NBRC 10066 was slightly higher than that by NBRC 10067, probably on the basis of the expression of α-galactosidase. The regions corresponding to the α-galactosidase MEL1 gene of Saccharomyces cerevisiae were amplified. The nucleotide sequences of the two genes designated as MELth1 and MELth2 revealed single open reading frames of 1,416 bp encoding 472 amino acids but differed from each other in one base that converted the amino acid composition. The sequences of the 5′-upstream region from −1 to −515 of the two genes are identical except for one base.     

Metabolic regulation of carbon and electron flow as a function of pH during growth of Sarcina ventriculi

The physiology and biochemistry of Sarcina ventriculi was studied in order to determine adaptations made by the organism to changes in environmental pH. The organism altered carbon and electron flow from acetate, formate and ethanol production at neutral pH, to predominantly ethanol production at pH 3.0. Increased levels of pyruvate dehydrogenase (relative to pyruvate decarboxylase) and acetaldehyde dehydrogenase occurred when the organism was grown at neutral pH, indicating the predominance of carbon flux through the oxidative branch of the pathway for pyruvate metabolism. When the organism was grown at acid pH, there was a significant increase in pyruvate decarboxylase levels and a decrease in acetaldehyde dehydrogenase, causing flux through the non-oxidative branch of the pathway. CO₂ reductase and formate dehydrogenase were not regulated as a function of growth pH. Pyruvate dehydrogenase possessed Michaelis-Menten kinetics for pyruvate with an apparent K _m of 2.5 mM, whereas pyruvate decarboxylase exhibited sigmoidal kinetics, with a S_0.5 of 12.0 mM. Differences in total protein banding patterns from cells grown at pH extremes suggested that synthesis of pyruvate decarboxylase and other enzymes was in part responsible for metabolic regulation of the fermentation products formed.     

Isolation and characterization of two novel ethanol-tolerant facultative-anaerobic thermophilic bacteria strains from waste compost

In a search for potential ethanologens, waste compost was screened for ethanol-tolerant thermophilic microorganisms. Two thermophilic bacterial strains, M5EXG and M10EXG, with tolerance of 5 and 10% (v/v) ethanol, respectively, were isolated. Both isolates are facultative anaerobic, non-spore forming, non-motile, catalase-positive, oxidase-negative, Gram-negative rods that are capable of utilizing a range of carbon sources including arabinose, galactose, mannose, glucose and xylose and produce low amounts of ethanol, acetate and lactate. Growth of both isolates was observed in fully defined minimal media within the temperature range 50–80°C and pH 6.0–8.0. Phylogenetic analysis of the 16S rDNA sequences revealed that both isolates clustered with members of subgroup 5 of the genus Bacillus. G+C contents and DNA–DNA relatedness of M5EXG and M10EXG revealed that they are strains belonging to Geobacillus thermoglucosidasius. However, physiological and biochemical differences were evident when isolates M5EXG and M10EXG were compared with G. thermoglucosidasius type strain (DSM 2542^T). The new thermophilic, ethanol-tolerant strains of G. thermoglucosidasius may be candidates for ethanol production at elevated temperatures.     

The effect of pyruvate decarboxylase gene knockout in Saccharomyces cerevisiae on L-lactic acid production

A plant- and crop-based renewable plastic, poly-lactic acid (PLA), is receiving attention as a new material for a sustainable society in place of petroleum-based plastics. We constructed a metabolically engineered Saccharomyces cerevisiae that has both pyruvate decarboxylase genes (PDC1 and PDC5) disrupted in the genetic background to express two copies of the bovine L-lactate dehydrogenase (LDH) gene. With this recombinant, the yield of lactate was 82.3 g/liter, up to 81.5% of the glucose being transformed into lactic acid on neutralizing cultivation, although pdc1 pdc5 double disruption led to ineffective decreases in cell growth and fermentation speed. This strain showed lactate productivity improvement as much as 1.5 times higher than the previous strain. This production yield is the highest value for a lactic acid-producing yeast yet reported.     

Engineering industrial <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> strains for xylose fermentation and comparison for switchgrass conversion

Saccharomyces’ physiology and fermentation-related properties vary broadly among industrial strains used to ferment glucose. How genetic background affects xylose metabolism in recombinant Saccharomyces strains has not been adequately explored. In this study, six industrial strains of varied genetic background were engineered to ferment xylose by stable integration of the xylose reductase, xylitol dehydrogenase, and xylulokinase genes. Aerobic growth rates on xylose were 0.04–0.17 h⁻¹. Fermentation of xylose and glucose/xylose mixtures also showed a wide range of performance between strains. During xylose fermentation, xylose consumption rates were 0.17–0.31 g/l/h, with ethanol yields 0.18–0.27 g/g. Yields of ethanol and the metabolite xylitol were positively correlated, indicating that all of the strains had downstream limitations to xylose metabolism. The better-performing engineered and parental strains were compared for conversion of alkaline pretreated switchgrass to ethanol. The engineered strains produced 13–17% more ethanol than the parental control strains because of their ability to ferment xylose.