Determination of isocyanate specific albumin-adducts in workers exposed to toluene diisocyanates

Toluene diisocyanates (2,4-TDI and 2,6-TDI) are important intermediates in the chemical industry. Among the main damages after low levels of TDI exposure are lung sensitization and asthma. It is therefore necessary to have sensitive and specific methods to monitor isocyanate exposure of workers. Urinary metabolites or protein adducts have been used as biomarkers in workers exposed to TDI. However, with these methods it was not possible to determine if the biomarkers result from exposure to TDI or to the corresponding toluene diamines (TDA). This work presents a new procedure for the determination of isocyanate-specific albumin adducts. Isotope dilution mass spectrometry was used to measure the adducts in albumin present in workers exposed to TDI. 2,4-TDI and 2,6-TDI formed adducts with lysine: N^?-[({3-amino-4-methylphenyl}amino)carbonyl]-lysine, N^?-[({5-amino-2-methylphenyl}amino)carbonyl]-lysine, and N^?- [({3-amino-2-methylphenyl}amino)carbonyl]-lysine. In future studies, this new method can be applied to measure TDI-exposures in workers.     

Determination of isocyanate biomarkers in construction site workers

4,4′-Methylenediphenyl diisocyanate (MDI) is the most important isocyanate in the manufacture of polyurethanes, dyes, pigments and adhesives. High concentrations of isocyanates are a potent respiratory irritant. Therefore, it is important to develop methods to monitor exposure to such compounds. We monitored biological samples from 40 non-exposed and 45 exposed construction site workers. 4,4′-Methylenedianiline (MDA) and N-acetyl-4,4′-MDA (AcMDA) were determined from untreated urine (U-MDA, U-AcMDA) and MDA was analysed from acid-treated urine (U-MDA-tot). Haemoglobin (Hb) adducts of MDA (Hb-MDA) were determined in all workers. The levels of biomarkers decreased in the following order: U-MDA-tot>U-AcMDA>U-MDA>Hb-MDA. The same order was found for the percentage of samples, which were found positive in exposed workers: 100%, 91%, 91%, 27%. The urine levels U-MDA-tot correlate with U-MDA, U-AcMDA and Hb-MDA with r=0.79, 0.86 and 0.39, respectively (Spearman rank order, p<0.01). U-AcMDA correlates with U-MDA and Hb-MDA with r=0.77 and 0.47, respectively (p<0.01). U-MDA correlates with Hb-MDA (r=0.38, p<0.05). The levels in the controls were significantly lower than in the exposed workers for all compounds (Mann–Whitney test, p<0.01). The median isocyanate-specific IgE-level was higher in the exposed workers, but the difference was statistically not significant. The change of the biomarker levels was compared in a group of workers (n=20), which were analysed prior to isocyanate exposure and after the exposure for ～4–7 months. All urine MDA metabolites and the Hb-adduct levels increased significantly (Wilcoxon sign test, p<0.01). Total IgE increased significantly after the exposure with isocyanate activity (p<0.01). With the present work it could be shown that outdoor workers are exposed to a similar extent as workers from a MDI factory.     

Determination of isocyanate biomarkers in construction site workers.

4,4'-Methylenediphenyl diisocyanate (MDI) is the most important isocyanate in the manufacture of polyurethanes, dyes, pigments and adhesives. High concentrations of isocyanates are a potent respiratory irritant. Therefore, it is important to develop methods to monitor exposure to such compounds. We monitored biological samples from 40 non-exposed and 45 exposed construction site workers. 4,4'-Methylenedianiline (MDA) and N-acetyl-4,4'-MDA (AcMDA) were determined from untreated urine (U-MDA, U-AcMDA) and MDA was analysed from acid-treated urine (U-MDA-tot). Haemoglobin (Hb) adducts of MDA (Hb-MDA) were determined in all workers. The levels of biomarkers decreased in the following order: U-MDA-tot>U-AcMDA>U-MDA>Hb-MDA. The same order was found for the percentage of samples, which were found positive in exposed workers: 100%, 91%, 91%, 27%. The urine levels U-MDA-tot correlate with U-MDA, U-AcMDA and Hb-MDA with r=0.79, 0.86 and 0.39, respectively (Spearman rank order, p<0.01). U-AcMDA correlates with U-MDA and Hb-MDA with r=0.77 and 0.47, respectively (p<0.01). U-MDA correlates with Hb-MDA (r=0.38, p<0.05). The levels in the controls were significantly lower than in the exposed workers for all compounds (Mann-Whitney test, p<0.01). The median isocyanate-specific IgE-level was higher in the exposed workers, but the difference was statistically not significant. The change of the biomarker levels was compared in a group of workers (n=20), which were analysed prior to isocyanate exposure and after the exposure for approximately 4-7 months. All urine MDA metabolites and the Hb-adduct levels increased significantly (Wilcoxon sign test, p<0.01). Total IgE increased significantly after the exposure with isocyanate activity (p<0.01). With the present work it could be shown that outdoor workers are exposed to a similar extent as workers from a MDI factory.     

Determination of hemoglobin adducts in workers exposed to 2,4,6-trinitrotoluene

2,4,6-Trinitrotoluene (TNT) is an important occupational and environmental pollutant. TNT can be taken up through the skin and by inhalation. It is therefore essential to have fast and reliable methods to monitor human exposure. In rat experiments, it has been shown that TNT binds covalently to blood proteins and to tissue proteins. Hemoglobin (Hb) adducts of TNT are markers for the internal dose and possibly for the toxic effects of TNT, e.g. cataracts. In the present paper we introduce a new efficient method to quantify Hb adducts of TNT. Precipitated Hb was hydrolyzed with base in the presence of the surrogate internal standard 3,5-dinitroaniline (35DNA). The released 2-amino-4,6-dinitrotoluene (2ADNT) and 4-amino-2,6-dinitrotoluene (4ADNT) were quantified against 35DNA by gas chromatography-mass spectrometry with negative-ion chemical ionization. Hb of 50 workers and controls from a Chinese munition factory were investigated. The Hb adduct levels ranged from 3.7 to 522 ng for 4ADNT and from 0 to 14.7 ng for 2ADNT per gram of Hb. However, in control samples from Germany no Hb adducts of 4ADNT or 2ADNT could be found.     

Evaluation of DNA damage by the Comet assay in shoe workers exposed to toluene and other organic solvents

The alkaline single-cell gel electrophoresis (or Comet) assay was applied to evaluate DNA damage in cryopreserved peripheral blood mononuclear leukocytes from 34 female shoe workers exposed to organic solvents and a group of 19 non-exposed women. We also investigated whether the polymorphisms of glutathione S-transferase M1 (GSTM1) and T1 (GSTT1) genes affect individual level of DNA damage possibly induced by the solvent exposure. Chemical measurements of workplace air in the two factories studied showed that the workers were exposed to acetone, gasoline, and toluene in both factories and to ethylacetate and diisocyanate in one factory. In the exposed workers, the average level of blood hemoglobin was lower and that of urinary hippuric acid higher than in the non-exposed individuals. However, the occupational exposure to organic solvents did not affect the Comet values. Neither did age, smoking, or the GSTM1 genotype have any effect on the outcome of this assay. The low prevalence of the GSTT1-null genotype precluded conclusions on the influence of GSTT1 polymorphism.     

Electroencephalographic findings in workers exposed to benzene

Preventive EEG examination was carried out in 40 workers significantly exposed to benzene. The EEG findings were compared with those of a control group of 48 healthy persons, a group of 110 workers significantly exposed to toluene and xylene and a group of 236 workers exposed to vinyl chloride. The individuals exposed to benzene exhibited 22.5% of abnormal and 45% threshold findings, the abnormalities being episodic, diffuse or a combination of the two. The effect of benzene entailed a frequent (32.5%) occurrence of a characteristic frequency lability. Sleep phenomena were found in a total of 60% cases (37.5% cases reached stage 1 B3 while 15% reached stage 2 according to Roth [14]). The rapid onset of deeper sleep stages (in 30% cases) is considered typical for benzene exposure. The photic driving response often had an extended frequency range (a total of 61.1%, to beta frequencies only in 30.55%, to both beta and theta frequencies also in 30.55% of cases). The different EEG features characteristic of the neurotoxic action of various types of organic solvents make possible a more efficient diagnostics of the effects of these chemicals on the CNS.     

Urinary metabolites of workers exposed to nitrotoluenes

Nitrotoluenes are important intermediates in the chemical industry. 2,6-Dinitrotoluene (26DNT), 2,4-dinitrotoluene (24DNT) and 2-nitrotoluene (2NT) are carcinogenic in animals and possibly carcinogenic in humans. Thus, it is important to develop methods to biomonitor workers exposed to such chemicals. The authors have monitored the air and urine metabolite levels for a group of workers in China exposed to 24DNT, 26DNT, 2NT and 4-nitrotoluene (4NT). The metabolites 2,4-dinitrobenzylalcohol (24DNBAlc), 2-amino-4-nitrobenzoic acid (2A4NBA), 4-amino-2-nitrobenzoic acid (4A2NBA) and 2,4-dinitrobenzoic acid (24DNBA) resulting from exposure to 24DNT were found in 89, 88, 91 and 78% of the exposed workers, respectively. The metabolites 2,6-dinitrobenzylalcohol (26DNBAlc) and 2,6-dinitrobenzoic acid resulting from 26DNT exposure were found in 99 and 86% of the exposed workers, respectively. Quantitatively, 2A4NBA, 4A2NBA and 26DNBAlc were the major metabolites. The nitrobenzoic acids were the major metabolites resulting from exposure to 2NT and 4NT and were present in 96 and 73% of the exposed workers, respectively. Air concentrations of DNT and 2NT did not correlate with the levels of metabolites in the urine. In conclusion, the dinitrobenzyl alcohols and aminonitrobenzoic acids determined in the urine provided a good marker for recently absorbed dose and were intrinsically related to the bioactivation and detoxification pathways of DNT. Air measurements were not a good measure to predict internal exposure.     

Cytogenetic study of workers exposed to methyl-parathion

When compared with non-exposed controls, a group of pesticide plant workers chronically exposed to methyl-parathion did not show an increased frequency of chromosome aberrations in lymphocyte cultures. Although methyl-parathion increased chromosome aberrations in cases of intoxication, a chronic exposure to small doses in the work place did not seem to produce the same effect.     

Mortality of plastic-ware workers exposed to radiofrequencies

The mortality experience of a cohort of Italian plastic-ware workers exposed to radiofrequency (RF)-electromagnetic fields generated by dielectric heat sealers was investigated. Follow-up extended from 1962 to 1992. The standardised mortality ratio (SMR) analysis was restricted to 481 women workers, representing 78% of the total person-years at risk. Mortality from malignant neoplasms was slightly elevated, and increased risks of leukemia and accidents were detected. The all-cancer SMR was higher among women employed in the sealing department, where exposure to RF occurred, than in the whole cohort. This study raises interest in a possible association between exposure to RF radiation and cancer risk. However, the study power was very small, and the possible confounding effects of exposure to solvents and vinyl chloride monomer (VCM) could not be ruled out. The hypothesis of an increased risk of cancer after radiofrequency exposure should be further explored by means of analytical studies characterised by adequate power and more accurate exposure assessment. Bioelectromagnetics 18:418–421, 1997. © 1997 Wiley-Liss, Inc.     

Chromosomic aberrations in female workers exposed to pesticides

The purpose of this work was to determine if the occupational exposure to those pesticides used at banana plantations' packaging plants produces genetic damage to somatic cells of female workers. Chromosomal aberrations were scored in lymphocytes of 20 women, 10 female exposed workers and 10 female controls. Workers were recruited from independent farms from two locations in Costa Rica, during January through June in 1996 and 1997. These females had a minimum of three months of work, had never received chemotherapy or radiotherapy and did some of these labors: sealing, spraying or weighting of bananas. Control unexposed females lived in the same area, were of similar age and neither them nor their husbands/mates had ever worked in pesticide related labors. For each female, 100 mitotic figures were scored. The kind of aberrations detected were acentric fragments, dicentric chromosomes, rings, gaps and breaks. Among workers, 16% of cells (n=1000) had one or more abnormalities, whereas control unexposed females had 6% of cells (n=1000) with comparable anomalies (p < 0.05). In conclusion, the pesticide exposure is a risk factor for chromosome aberrations in female somatic cells.     

Cytogenetic damage in workers exposed to ethylene oxide

Sister-chromatid exchanges (SECs) and chromosomal aberrations (CAs) were detected in the peripheral lymphocytes of 41 sanitary workers exposed to ethylene oxide (EO) in the sterilizing units of 8 hospitals in the Venice Region. The first group (19 workers) was exposed to 10.7 +/- 4.9 ppm EO, expressed as the time-weighted average concentration for an 8-h working day (TWA/8 h conc.), and the second group (22 workers) to 0.35 +/- 0.12 ppm. Each exposed worker was paired with a control of similar age and smoking habits. A highly significant (P less than 0.001) increase in the mean frequency of SCEs was found in the higher exposure group, 14 (74%) exposed subjects having significantly increased levels of SCEs compared to their matched controls. In the lower exposure group, the increase in mean frequency of SCEs was lower, though still significant (P less than 0.05): 7 (33%) exposed subjects had higher and 1 (5%) had a lower SCE level than the matched controls. From the first group, 10 subjects, 7 of whom had increased SCE levels, were reanalysed 12-18 months after their exposure had been lowered or interrupted: in only 2 of them the SCE level was significantly decreased. A statistically significant correlation between SCE frequency and level of EO exposure (TWA/8 h conc.), as well as a multiple correlation between SCE level and EO exposure, smoking and age were found. However, no interaction could be detected between EO exposure and smoking in the induction of SCEs. In controls, SCE frequency was correlated with smoking and age. In the higher exposure group, the number of both chromatid- and chromosome-type aberrations, independent of gaps, was significantly increased, whereas in the lower exposure group only the frequency of chromosome-type aberrations, excluding gaps, was statistically higher than in controls. The level of CAs remained to a great extent unchanged in the 10 subjects re-examined at a later stage after lowering or halting exposure. Taking the group as a whole, the frequency of cells with total CAs was found to be weakly (P = 0.05) correlated with EO exposure, and was not correlated with smoking, age or SCE frequency.     

Sister-chromatid exchanges in lymphocytes of workers exposed to trichloroethylene

To detect mutagenic effects of trichloroethylene (TCE) on humans, sister-chromatid exchanges (SCEs) were analyzed in lymphocytes of 22 workers occupationally exposed to TCE and 22 matched controls. Although urinalysis in the workers revealed their obvious exposure to TCE, no increase in SCE frequencies was found in lymphocytes of the workers. SCE analysis in lymphocytes could not detect mutagenic effects by occupational exposure to TCE on humans.     

Comparison of biomarkers in workers exposed to 2,4,6-trinitrotoluene

2,4,6-Trinitrotoluene (TNT) is an important occupational and environmental pollutant. In TNT-exposed humans, notable toxic manifestations have included aplastic anaemia, toxic hepatitis, cataracts, hepatomegaly, and liver cancer. Therefore, methods were developed to biomonitor workers exposed to TNT. The workers were employed in a typical ammunition factory in China. The external dose (air levels and skin exposure), the internal dose (urinary metabolites), the biologically effective dose (haemoglobin adducts, urinary mutagenicity), biological effects (chromosomal aberrations and health effects), and individual susceptibility (genotypes of xenobiotic-metabolizing enzymes) were determined. Haemoglobin-adducts of TNT, 4-amino-2,6-dinitrotoluene (4ADNT) and 2-amino-4,6-dinitrotoluene (2ADNT), and the urinary metabolites of TNT, 4ADNT and 2ADNT, were found in all workers and in some controls. The levels of the haemoglobin-adducts or the urinary metabolites correlated weakly with the skin or air levels of TNT. The urinary mutagenicity determined in a subset of workers correlated strongly with the levels of 4ADNT and 2ADNT in urine. The haemoglobin-adducts correlated moderately with the urinary metabolites and with the urinary mutagenicity. The genotypes of glutathione S-transferases (GSTM1, GSTT1, GSTP1) and N-acetyltransferases (NAT1, NAT2) were determined. In general, the genotypes did not significantly influence the haemoglobin-adduct levels and the urine metabolite levels. However, TNT-exposed workers who carried the NAT1 rapid acetylator genotype showed an increase in urinary mutagenicity and chromosomal aberrations as compared with slow acetylators. The haemoglobin adduct 4ADNT was significantly associated with a risk of hepatomegaly, splenomegaly and cataract; urine metabolites and genotypes were not associated with health effects. These results indicate that a set of well-selected biomarkers may be more informative regarding exposure and effect than routinely performed chemical measurements of pollutants in the air or on the skin.     

Comparison of biomarkers in workers exposed to 2,4,6-trinitrotoluene

2,4,6-Trinitrotoluene (TNT) is an important occupational and environmental pollutant. In TNT-exposed humans, notable toxic manifestations have included aplastic anaemia, toxic hepatitis, cataracts, hepatomegaly, and liver cancer. Therefore, methods were developed to biomonitor workers exposed to TNT. The workers were employed in a typical ammunition factory in China. The external dose (air levels and skin exposure), the internal dose (urinary metabolites), the biologically effective dose (haemoglobin adducts, urinary mutagenicity), biological effects (chromosomal aberrations and health effects), and individual susceptibility (genotypes of xenobiotic-metabolizing enzymes) were determined. Haemoglobin-adducts of TNT, 4-amino-2,6-dinitrotoluene (4ADNT) and 2-amino-4,6-dinitrotoluene (2ADNT), and the urinary metabolites of TNT, 4ADNT and 2ADNT, were found in all workers and in some controls. The levels of the haemoglobin-adducts or the urinary metabolites correlated weakly with the skin or air levels of TNT. The urinary mutagenicity determined in a subset of workers correlated strongly with the levels of 4ADNT and 2ADNT in urine. The haemoglobin-adducts correlated moderately with the urinary metabolites and with the urinary mutagenicity. The genotypes of glutathione S-transferases (GSTM1, GSTT1, GSTP1) and N-acetyltransferases (NAT1, NAT2) were determined. In general, the genotypes did not significantly influence the haemoglobin-adduct levels and the urine metabolite levels. However, TNT-exposed workers who carried the NAT1 rapid acetylator genotype showed an increase in urinary mutagenicity and chromosomal aberrations as compared with slow acetylators. The haemoglobin adduct 4ADNT was significantly associated with a risk of hepatomegaly, splenomegaly and cataract; urine metabolites and genotypes were not associated with health effects. These results indicate that a set of well-selected biomarkers may be more informative regarding exposure and effect than routinely performed chemical measurements of pollutants in the air or on the skin.     

Cytogenetic study of workers exposed to chromium compounds

The frequency of sister chromatid exchanges (SCEs), high SCE frequency cells (HFCs), and genetic polymorphism of genotypes glutathione S-transferase (GST) M1 and T1 were analyzed in peripheral lymphocytes of 35 workers occupationally exposed to chromium (Cr) and 35 matched control group. Results showed that workers exposed to Cr showed 6.07 SCE/cell, as compared to 4.76 SCE/cell for the control group (p<0.01). Smokers showed a statistically significant higher frequency of SCE than non-smokers in both groups. The work duration of Cr workers was an important factor. Workers exposed for more than 5 years showed a significantly higher level of SCEs (p<0.05). Workers exposed to Cr for 5 or more years had higher HFC rates (51.4%) than those exposed for less than 5 years (22.9%), with an odds ratio of 4.5 times than those exposed for less than 5 years. In HFC analysis, Cr workers who smoked showed a higher level of HFC (60%) than the control group (5.7%) and also had a higher odds ratio (60.4) compared with the control group. Among non-smokers, the odds ratio was 9.0. Another objective of this study is to investigate the relationship between SCE and genetic polymorphisms of GST M1 and T1 in Cr workers. The results showed that the incidence of GSTM1 null genotype was 60% in the control group and 77.1% in Cr workers, and percentages of GSTT1 deletion were 42.9% and 62.9% in control and exposed individuals, respectively. There was a slightly increased frequency of SCE among Cr workers with GSTM1 null genotype as opposed to non-null genotype individuals. A similar result was seen among the control group; however, there were no statistically significant differences. In conclusion, the current study found the positive induction of SCE in workers who smoked or/and were exposed to Cr. However, different GST genotypes did not influence the level of cytogenetic damage between groups. Despite slight variation in numbers, they all appear to be not different.