Effect of initial cell density on hybridoma growth, metabolism, and monoclonal antibody production.

A murine hybridoma cell line (167.4G5.3) was cultivated in batch mode with varying inoculum cell densities using IMDM media of varying fetal bovine serum concentrations. It was observed that maximum cell concentrations as well as the amount of monoclonal antibody attainable in batch mode were dependent on the inoculum size. Specifically, cultures with lower inoculum size resulted in lower cell yield and lower antibody concentrations. However, in the range of 10(2) to 10(5) cells per ml, the initial cell density affected the initial growth rate by a factor of only 20%. Furthermore, specific monoclonal antibody production rates were independent of initial cell density and the serum concentration. Glutamine was the limiting nutrient for all the cultures, determining the extent of growth and the amount of antibody produced. Serum was essential for cell growth and cultures with initial cell concentrations up to 10(6) cells per ml could not grow without serum. However, when adapted, the cells could grow in a custom-made serum-free medium containing insulin, transferrin, ethanolamine, and selenium (ITES) supplements. The cells adapted to the ITES medium could grow with an initial growth rate slightly higher than in 1.25% serum and the growth rate showed an initial density dependency-inocula at 10(3) cells per ml grew 30% slower than those at 10(4) or 10(5). This difference in growth rate was decreased to 10% with the addition of conditioned ITES medium. The addition of conditioned media, however, did not improve the cell growth for serum-containing batches.     

Specific monoclonal antibody productivity and the cell cycle-comparisons of batch,continuous and perfusion cultures

A selection of mouse hybridoma cell lines showed a variation of approximately two orders of magnitude in intracellular monoclonal antibody contents. The different levels directly influenced apparent specific monoclonal antibody productivity during the death phase but not during the growth phase of a batch culture. The pattern of changes in specific productivity during culture remained basically similar even though at different levels for all cell lines tested. Arresting the cells in the G₁ phase using thymidine increased the specific productivity, cell volume and intracellular antibody content but at the same time led to decreased viability. In continuous culture DNA synthesis decreased with decreasing dilution rate though without an accompanying change in cell cycle and cell size distributions. The data shows both the decrease in viability and intracellular antibody content to be important factors which influence the negative association between specific antibody productivity and growth rate. In high cell density perfusion culture, when the cell cycle was prolonged by slow growth, viability was low and dead, but not lysed, cells were retained in the system, the specific antibody productivity was nearly two fold higher than that obtained in either batch or continuous cultures. The results imply that the prolongation of G₁ phase and the increase in death rate of cells storing a large amount of antibody together cause an apparent increase in specific antibody productivity.     

Transient Responses of Glucose-Limited Cultures of Cytophaga johnsonae to Nutrient Excess and Starvation

Cells from glucose-limited chemostat cultures of Cytophaga johnsonae were subjected to a sudden relaxation of substrate limitation by injecting the cells into fresh batch cultures. Starvation experiments were carried out by injecting glucose-limited cells into batch cultures lacking glucose. Transient responses of biomass, glucose uptake and mineralization, ATP content, and viability on different agar media were monitored during these nutrient-shift experiments. Cells reacted differently depending on growth rate and time spent in the chemostat. Fast-growing cells showed an immediate adaptation to the new growth conditions, despite some initial overshoot reactions in ATP and uptake potential. In contrast, slowly growing cells and long-term-adapted cells showed extensive transient growth responses. Glucose uptake and mineralization potentials changed considerably during the transient growth phase before reaching new levels. During the starvation experiments, all cell types displayed a fast decrease in ATP, but the responses of the substrate uptake and mineralization potentials were strongly dependent upon the previous growth rate. Both potentials decreased rapidly in cells with high growth rates. On the other hand, cells with low growth rates maintained 80% of their uptake and mineralization potentials after 8 h of starvation. Thus, slowly growing cells are much better adapted for starvation than are fast-growing cells.     

Examination of serum and bovine serum albumin as shear protective agents in agitated cultures of hybridoma cells.

A murine hybridoma cell line (167.4G5.3) was cultured in batch mode using IMDM containing different serum concentrations and bovine serum albumin (BSA). Cell growth and death, metabolism and antibody production were studied in these cultures. The cells were more susceptible to shear in the stationary and in the decline phase of growth as evidenced by higher death rates. Cell growth was best at high serum concentrations with high specific growth and low specific death rates. When BSA was used instead of serum in IMDM, no protective effect was observed. Cell metabolism and monoclonal antibody production rates were not influenced by the level of serum or by BSA. The use of serum in commercial serum-free media (OPTI-MEM) also resulted in no change in both growth and death rates.     

Magnesium and phosphate enrichment of culture medium stimulates the proliferation of epidermal cells from newborn and adult mice

The proliferation and differentiation of mouse epidermal cells can be sequentially analyzed by modification of extracellular calcium. Newborn cells cultured in low calcium medium (less than 0.1 mM) proliferate as a monolayer and maintain a typical basal cell phenotype in culture but have a limited proliferative capacity and short lifespan. Elevation of the magnesium content of the culture medium from 1 to 5 mM stimulated the proliferation of newborn mouse (1-3 days old) keratinocytes. Maximal DNA synthesis rates, as determined on day 5 of culture, were up to 2-3-fold higher in the magnesium-enriched cultures. Exposure to high magnesium caused 3-4-fold increases in the DNA content of newborn keratinocyte cultures, and extended the confluent phase of epidermal cell growth to over 10 days. Other divalent cations (strontium, copper, zinc, nickel, beryllium, and barium) did not improve keratinocyte growth in culture. Keratinocytes from the tail skin of adult (3 months old) mice displayed an absolute requirement for high phosphate in the culture medium. The medium containing an optimal (10 mM) phosphate concentration prevented the cell detachment caused by the standard low (1 mM) phosphate medium, and in combination with an elevated magnesium content (10-15 mM) it markedly increased both DNA synthesis rates and DNA content of the adult cell cultures. Optimally growing, newborn or adult cultures contained less cells in the G1 phase of the cell cycle and more cells in S and G2 +M. The addition of phosphate and magnesium per se did not induce keratinocyte differentiation and did not interfere with the high calcium (1 mM)-induced differentiation.     

Cyclic-2,3-diphosphoglycerate levels in Methanobacterium thermoautotrophicum reflect inorganic phosphate availability

Methanobacterium thermoautotrophicum was grown in phosphate-limited chemostat cultures at a dilution rate corresponding to a doubling time of 13.2 h. The cyclic-2,3-diphospho-D-glycerate content of these cells was 8 to 10-fold lower than that of cells grown in batch cultures having a doubling time of 11.5 h. This metabolite accounted for 5% of cell dry weight during batch growth on 2 mM phosphate. In the chemostat the steady-state concentration of phosphate was 4 microM, showing that this methanogen is adapted to highly efficient growth at low phosphate concentrations. Since growth rates were similar in both cultures, the growth rate clearly does not depend on intracellular levels of cyclic-2,3-diphosphoglycerate.     

Bovine mammary explant versus primary cell cultures: Effect of bovine somatotropin and insulinlike growth factor-I on DNA content and protein synthesis

Summary Cellular DNA, milk protein content, and protein secretion by bovine mammary explants were compared to cultures of confluent and growing primary bovine mammary secretory cells over 4 d. Explants were obtained at slaughter from eight Holstein cows (120 ± 35 d lactation). Primary cells were grown to confluence, cryopreserved, thawed, and cultured through five passages. Explants and cells were cocultured with liver and adipose tissue in the presence of somatotropin, insulinlike growth factor-I, and somatotropin + insulinlike growth factor-I. Cellular DNA and milk proteins were assayed using fluorescent probes and flow cytometry. Media proteins were assayed by densitometer scanning of electrophoresis gel bands. DNA content of explant, confluent, and growing primary cells increased similarly through the 96 h incubation. DNA content in G₀G₁ phase was increased by: (a) insulinlike growth factor-I in explant cells; (b) somatotropin, insulinlike growth factor-I, and their combination in confluent primary cells; and (c) the combination of somatotropin and insulinlike growth factor in growing primary cells. Approximately 65% of explant and confluent primary cells were in the G₀G₁ or differentiated phase compared to 47% for the growing primary cells. Whey protein content and secretion were similar among cell types. Explant cells contained and secreted more β-casein than primary cells but secretion trends for β-casein and k-casein were similar after 48 h for both cell types. Results suggest that primary cell cultures are comparable to explant cultures when used to study mechanisms of DNA and milk protein synthesis and secretion.     

Estimation of dormant Micrococcus luteus cells by penicillin lysis and by resuscitation in cell-free spent culture medium at high dilution

Abstract Micrococcus luteus starved for 2–7 months in spent medium following growth to stationary phase in batch culture exhibited a culturability (as estimated by direct plating on nutrient agar plates) of < 0.001%. However, following a lag, some 70% of the cells could be lysed upon inoculation into and cultivation in fresh lactate minimal medium containing penicillin, showing the capability of a significant portion of the cells at least to enlarge (and thus potentially to resuscitate). When the viable cell count was estimated using the most probable number method, by incubation of high dilutions of starved cells in liquid growth media, the number of culturable or resuscitable cells was very low, and little different from the viable cell count as assessed by plating on solid media. However, the apparent viability of these populations evidenced with the most probable number method was 1000–100 000-fold greater when samples were diluted into liquid media containing supernatants taken from the stationary phase of batch cultures of the organism, suggesting that viable cells can produce a factor which stimulates the resuscitation of dormant cells. Both approaches show, under conditions in which the growth of a limited number of viable cells during resuscitation is excluded, that a significant portion of the apparently non-viable cell population in an extended stationary phase is dormant, and not dead.     

Cultivation of the hyperthermophilic archaeonSulfolobus solfataricus in low-salt media

Two low-salt complex media, bactopeptone and desalted yeast extract, were used for high density cultivation of the hyperthermophilic archaeonSulfolobus solfataricus (DSM 1617). Bactopeptone, which has low mineral ion content among various complex media, was good for cell growth in batch cultures; the maximal cell density in bactopeptone was comparable to that in yeast extract. Howver, cell growth was rather poor when bactopeptone was added by the fed-batch procedure. Since several vitamins are deficient in bactopeptone, the effect of vitamins on cell growth was examined. Among the vitamins tested, pyridoxine was found to improve the growth rate ofS. solfataricus. To reduce the growth inhibition caused by mineral ions, yeast extract was dialyzed against distilled water and then fed-batch cultures were carried out using a feed medium containing desalted yeast extract. Although the concentrations of mineral ions in yeast extract were significantly lowered by the dialysis procedure, fed-batch cultivation with desalted yeast extract was unsatisfactory. To examine whether low molecular weight solutes in yeast extract are crucial for cell growth, we investigated the effect of trehalose, a most abundant compatible solute in yeast extract, on the growth pattern. Cell densities were increased and the length of the lag phase was markedly shortened by the presence of trehalose, indicating that trehalose plays an important role in the growth ofS. solfataricus.     

Changes in the lipid composition and maximisation of the polyunsaturated fatty acid content of three microalgae grown in mass culture

Three species of microalgae were grown in mass culture to investigate the influence of culture technique and growth phase on the production of 20:5(n?3) and 22:6(n?3). These polyunsaturated fatty acids (PUFA) are considered to be essential in many marine animals diets for high growth and survival rates. The species of microalgae examined wereNannochloropsis oculata, Pavlova lutheri andIsochrysis sp. (clone T.Iso). All batch cultures (logarithmic and stationary phase) and semi-continuous cultures (logarithmic phase) examined contained high levels of the long-chain (n?3) PUFA, but production could be maximised by harvesting at specific times and growth phases. Maximum cellular content (pg cell^-1) of long-chain PUFA was found in logarithmic phase batch cultures ofN. oculata and in stationary phase cultures ofP. lutheri. The cellular content of PUFA in cultures ofIsochrysis sp. did not change significantly with culture technique or growth phase. Alternatively, stationary phase cultures of all three species showed increased proportions (%) and cellular contents of triacylglycerols, and saturated and monounsaturated fatty acids with correspondingly decreased proportions of polar lipids and most PUFA relative to logarithmic phase cultures. The exception was the proportion and cellular content of 22:6(n?3) inP. lutheri which increased with triacylglycerol content. The mass of long-chain (n?3) PUFA per volume of culture was significantly higher in stationary phase cultures due to the higher cell counts per volume. These findings indicate that the opportunity exists to maximise PUFA production by microalgae with the potential to improve animal growth and reduce production costs in mariculture operations and may be of use in the large scale culture and harvesting of microalgae for the biotechnology industry.     

Effects of temperature on the size and shape of Escherichia coli cells

Two substrains of Escherichia coli B/r were grown to steady-state in batch cultures at temperatures between 22 and 42° C in different growth media. The size and shape of the cells were measured from light and electron micrographs and with the Coulter channelizer. The results indicate that cells are shorter and somewhat thicker at the lower temperatures, especially in rich growth media; cell volume is then slightly smaller. A lower temperature was further found to increase the relative duration of the constriction period. The shapes of the cell size distributions are indistinguishable, indicating that the pattern of growth of the cells is the same at all temperatures. The adaptation of the cells to a temperature shift lasted several generations, indicating that the morphological effects of temperature are mediated by the cell's physiology.     

Relationship between hybridoma growth and monoclonal antibody production.

Factors affecting cell growth and antibody production in a mouse hybridoma were investigated. Antibody was produced during the growth and decline phases of a batch culture with an increase in the specific rate of antibody production during the decline phase. The specific rate of antibody production was also increased in cells arrested by 2 mM thymidine, suggesting that cell proliferation and antibody production can be uncoupled. Reduced serum concentrations resulted in lower cell growth rates but increased antibody production rates. However, this trend was reversed in hybridomas which had been arrested by thymidine, since the highest antibody production rate was associated with high serum concentrations. Likewise, in proliferating cells, the optimum pH for antibody production (pH 6.8) was lower than the optimum pH for cell growth (pH 7.2), whereas in thymidine-blocked cells, the highest antibody production rate was at pH 7.2. High antibody production rates and product yields were also associated with low growth rates in continuous cultures. The possibility that antibody was under cell cycle control was investigated in synchronized hybridoma cultures. Antibody production occurred during G1 and G2 with a decline in the M phase and evidence of a further decline in the S phase. Thus antibody production was not restricted to the G1 and S phase in this hybridoma.     

Using Raman spectroscopy and chemometrics to identify the growth phase of <Emphasis Type="Italic">Lactobacillus casei</Emphasis> Zhang during batch culture at the single-cell level

Background

As microbial cultures are comprised of heterogeneous cells that differ according to their size and intracellular concentrations of DNA, proteins, and other constituents, the detailed identification and discrimination of the growth phases of bacterial populations in batch culture is challenging. Cell analysis is indispensable for quality control and cell enrichment.

Methods

In this paper, we report the results of our investigation on the use of single-cell Raman spectrometry (SCRS) for real-time analysis and prediction of cells in different growth phases during batch culture of Lactobacillus (L.) casei Zhang. A targeted analysis of defined cell growth phases at the level of the single cell, including lag phase, log phase, and stationary phase, was facilitated by SCRS.

Results

Spectral shifts were identified in different states of cell growth that reflect biochemical changes specific to each cell growth phase. Raman peaks associated with DNA and RNA displayed a decrease in intensity over time, whereas protein-specific and lipid-specific Raman vibrations increased at different rates. Furthermore, a supervised classification model (Random Forest) was used to specify the lag phase, log phase, and stationary phase of cells based on SCRS, and a mean sensitivity of 90.7% and mean specificity of 90.8% were achieved. In addition, the correct cell type was predicted at an accuracy of approximately 91.2%.

Conclusions

To conclude, Raman spectroscopy allows label-free, continuous monitoring of cell growth, which may facilitate more accurate estimates of the growth states of lactic acid bacterial populations during fermented batch culture in industry.

     

Flow cytometric study of cultured mammalian cells.

Flow cytometry provides a rapid, sensitive and accurate analytical means to monitor hybridoma cell cultures. The use of flow cytometry has enabled us to study the changes in DNA, RNA, protein, IgG, mitochondrial activity and cell size that take place during the growth cycle of batch culture. The temporal changes in the levels of these analytes and their heterogeneity have been related to the growth/death kinetics. The maximum proportion of S-cells was reached early in the growth phase while a population of low fluorescence cells with lower polidy than G1, dead cells and fragmented nuclei emerged during the death phase. Supplementation with amino acids during the exponential phase prolonged the growth cycle by enhancing cell proliferation. The fraction of S/G2 cells was much reduced by a reduction in serum concentration but was maintained during the prolonged non-proliferating "stationary" phase. The magnitude of Rhodamine 123 staining showed a consistent and general decrease during late exponential and decline phases. This trend was accompanied by an increase in the fraction of the Propidium Iodide-stained population which reflected the deteriorating metabolic and membrane integrity. Decrease in mean fluorescence intensity for DNA, RNA, protein and intracellular IgG was noted at the decline phase. Intracellular immunofluorescence was a more reliable indicator of antibody productivity than surface immunofluorescence.     

Effects of nitrogen on growth and carbohydrate formation in Porphyridium cruentum

The microalga Porphyridium cruentum (Rhodophyta) has several industrial and pharmaceutical uses, especially for its polysaccharide production. This study aimed to investigate the influence of nitrogen levels as reflected by altered N:P ratios on the production and content of biomass and carbohydrate. N:P molar ratios were altered in batch cultures to range from 1.6 to 50 using the Redfield ratio of 1:16 as reference. Algal growth (estimated as final cell number, biomass concentration and maximum specific growth rate) was negatively affected at low N:P ratios. The optimal N:P ratio for growth was identified at 35–50, with specific growth rates of 0.19 day^?1 and maximum cell concentrations of 59·10⁸ cells L^?1 and 1.2 g dry weight of biomass L^?1. In addition, variation in cell size was seen. Cells with larger diameters were at higher N:P ratios and smaller cells at lower ratios. The cellular carbohydrate content increased under reduced nitrogen availability. However, because accumulation was moderate at the lowest N:P ratio, 0.4 g per g dry weight biomass compared to 0.24 at the Redfield ratio of 16:1, conditions for increased total carbohydrate formation were identified at the N:P ratios optimal for growth. Additionally, carbohydrates were largely accumulated in late exponential to stationary phase.     

An alternate method for estimation of cell growth kinetics from batch cultures

An alternative to estimation of cell growth kinetics via continuous culture experiments is proposed in this article. The method employed is based on batch culture experiments with very small inocula (initial cell concentrations being typically less than 5000 cells/mL). Such low initial cell concentrations result in extended exponential cell growth phase during which culture conditions remain unchanged, thereby permitting precise estimation of specific cell growth rates from batch experiments especially for fast-growing microorganisms such as Bacillus species. The effectiveness and utility of this approach are demonstrated via several experiments conducted with a wild-type strain (Bacillus subtilis TN106) and a recombinant strain (B. subtilis TN106[pAT5]). True establishment of exponential growth phase requires insignificant variance of most of the culture conditions during the initial growth phase. Satisfaction of this requirement is demonstrated for microbial systems investigated here. This approach is especially well suited for recombinant microorganisms containing segregationally unstable plasmids, since estimation of growth kinetics of these from continuous cultures is very difficult and highly unreliable due to continual reversion of recombinant ceils to plasmid-free host cells unless some selection pressure is applied at levels sufficient to keep the presence of plasmid-free cells minimal.     

Study of asynchronous and synchronous yeast cultures using flow cytofluorometry]

Distribution of Saccharomyces cerevisiae, Candida boidinii and Candida tropicalis cells according to DNA content was investigated using laser flow cytofluorometry. Cells distribution curves according to DNA content possessed two maxima in case the sample belonged to the exponential phase of the asynchronous batch culture, or one maximum in case the sample was from the stationary phase of growth. In synchronous cultures variations of cells distribution curves according to DNA content (age structure of the population) were demonstrated and the curves with one maximum and plateau were observed.     

Continuous culture of Pseudomonas fluorescens with sodium maleate as a carbon source

Pseudomonas fluorescens (ATCC 11150) was grown in batch and continuous culture in minimal media with sodium maleate as growth-limiting sole organic carbon source. Growth was followed by turbidity and dry weight measurements. Gross composition of washed cells (relative amounts of protein, lipid, RNA, and DNA) and the distribution of amino acids in protein hydrolyses of the cells were determined for cells grown in continuous culture at various dilution rates. Extracellular concentrations of the original carbon source and a number of metabolites were monitored by a total carbon analysis, ion exchange chromatography, and ultraviolet-visible scans of cell-free supernatants and chromatographic fractions, thereof. Substrate inhibition by maleate was a major factor in the growth kinetics of both batch and continuous cultures. Excessive maleate concentration caused instability in continuous cultures. By appropriate operation, much higher specific growth rates (0.305/hr) could ultimately be achieved in continuous culture compared to batch culture (0.174/hr). Adaptation was responsible for only part of the differences between batch and continuous cultures; the differing distribution of metabolites were also major factors.     

Reduction of Chloroplast DNA Content in Solanum nigrum Suspension Cells by Treatment with Chloroplast DNA Synthesis Inhibitors

Suspension cell cultures of Solanum nigrum were grown in the presence of six different chloroplast DNA synthesis inhibitors in order to determine whether the pool size of chloroplast DNA (cpDNA) could be selectively reduced relative to the nuclear DNA content. One of the effects of the inhibitors was a reduction in cell growth and viability. Cell growth (fresh weight) was reduced 50% (in 8 day cultures) by: 100 micromolar bisbenzimide, 8 micromolar ethidium bromide, 0.3 micromolar 5-fluordeoxyuridine (Fudr), 200 micromolar nalidixic acid, 30 micromolar novobiocin, or 10 micrograms per milliliter rifampicin. At these concentrations, three of the inhibitors, ethidium bromide, Fudr, and rifampicin, also substantially reduced the viability of the cultures. Analyses of the chloroplast and nuclear DNA content per gram fresh weight by dot blot hybridizations indicated that the reduction of cpDNA content was greatest at inhibitor concentrations which reduced cell growth by more than 50% but this depended on the culture conditions. For example, the two DNA gyrase inhibitors, nalidixic acid and novobiocin, were more effective in lowering cpDNA content in cultures which were transferred (2 × 4 days) once during the eight day incubation. Because several inhibitors were toxic to cell growth, the DNA content of treated cells was also determined on the basis of cell (protoplasts) number. Analyses of nuclear and cpDNA content per cell for each treatment indicated that only the DNA gyrase inhibitors, nalidixic acid, and novobiocin reduced cpDNA content. Neither inhibitor reduced nuclear DNA content. These results suggest that DNA gyrases participate in cpDNA replication. The selective reduction of cpDNA content in regeneratable cultures may facilitate the generation and selection of cpDNA mutants or transformants from higher plants.     

Nucleoid structure and partition in Methanococcus jannaschii: an archaeon with multiple copies of the chromosome.

We measured different cellular parameters in the methanogenic archaeon Methanococcus jannaschii. In exponential growth phase, the cells contained multiple chromosomes and displayed a broad variation in size and DNA content. In most cells, the nucleoids were organized into a thread-like network, although less complex structures also were observed. During entry into stationary phase, chromosome replication continued to termination while no new rounds were initiated: the cells ended up with one to five chromosomes per cell with no apparent preference for any given DNA content. Most cells in stationary phase contained more than one genome equivalent. Asymmetric divisions were detected in stationary phase, and the nucleoids were found to be significantly more compact than in exponential phase.