Respiratory pathways in Agaricus bisporus and Scytalidium thermophilum

Abstract The respiratory pathways of Agaricus bisporus and Scytalidium thermophilum were studied. A. bisporus appeared to possess both a cyanide-sensitive and a cyanide-insensitive respiration while in S. thermophilum the cyande-insensitive respiration was absent. Growth experiments showed the ecological advantage for A. bisporus under conditions where cytochrome mediated respiration is inhibited.     

Ecology of Thermophilic Fungi in Mushroom Compost, with Emphasis on Scytalidium thermophilum and Growth Stimulation of Agaricus bisporus Mycelium

Twenty-two species of thermophilic fungi were isolated from mushroom compost. Scytalidium thermophilum was present in the compost ingredients, fresh straw, horse droppings, and drainage from compost and dominated the fungal biota of compost after preparation. Of 34 species of thermophilic fungi tested, 9 promoted mycelial growth of Agaricus bisporus on sterilized compost: Chaetomium thermophilum, an unidentified Chaetomium sp., Malbranchea sulfurea, Myriococcum thermophilum, S. thermophilum, Stilbella thermophila, Thielavia terrestris, and two unidentified basidiomycetes. These species will be considered for future experiments on inoculation and more controlled preparation of compost.     

Scytalidium thermophilum-colonized grain, corncobs and chopped wheat straw substrates for the production of Agaricus bisporus

We examined the possibility of cultivating Agaricus bisporus (Ab) on various grains and agricultural by-products, with the objective of improving yield capacity of substrate pre-colonized by Scytalidium thermophilum (St). Radial growth rate (RGR) of St at 45 degrees C ranged from no growth on sterile wheat grain to 14.9 mm/d on whole oats. The linear extension rate (LER) of Ab, grown on St-colonized substrate (4 days at 45 degrees C), ranged from a low of 2.7 mm/d on 100% corncobs to 4.7 mm/d on a 50/50 mixture of ground corncobs/millet grain. Several other substrates containing wheat straw+ground corncobs+boiled millet and pre-colonized by St (4 days at 42+/-3 degrees C), were evaluated for production of Ab. The biological efficiency (BE) of production increased linearly with the addition of millet to the formula. However, substrates with millet levels 84% often were contaminated before mushroom harvest. Maximum BE (99%) and yield (21.6 kg/m(2)) were obtained on St-colonized wheat straw+2% hydrated lime supplemented with 9% commercial supplement added both at spawning and at casing.     

Influence of the casing on the microflora of compost colonized by Agaricus bisporus

The role of the casing soil during mushroom cultivation was studied with respect to the composition of the microflora. The thermophilic bacteria became more numerous and the number of mesophiles was clearly enhanced. The casing soil had a protective action against antagonistic microflora. Interactions between the microflora and the mushroom were also studied. Moreover, lignocellulose degradation was evaluated by enzymatic measurements during cultivation and process, and was documented by an ultrastructural study.     

Avicel-adsorbable endoglucanase production by the thermophilic fungus Scytalidium thermophilum type culture Torula thermophila

Scytalidium thermophilum type culture Torula thermophila was isolated from mushroom compost and the total cellulase, endoglucanase, Avicel-adsorbable endoglucanase activities, as well as the fungal biomass generation and cellulose utilisation were analyzed in shake flask cultures with Avicel (microcrystalline cellulose) as the carbon source. Results were compared with an industrial strain of Scytalidium thermophilum type culture Humicola insolens. The pH and temperature optima for endoglucanase activities during enzyme assays were also analyzed for both organisms and determined to be pH 6.0 and 65 degrees C for type culture Torula thermophila, and pH 6.5 and 60 degrees C for type culture Humicola insolens. Analysis of the effect of growth temperature showed that type culture T. thermophila can grow and produce cellulases in the range of 35 to 55 degrees C although 40 to 50 degrees C seemed to favor growth and cellulase production. Although 45 degrees C was found optimal for fungal growth, both the specific endoglucanase and Avicel-adsorbable endoglucanase activities (U/mg protein) as well as the percentage of Avicel-adsorbable endoglucanase activity reached maxima at 50 degrees C and were higher as compared to type culture H. insolens. Results indicate that type culture T. thermophila, with further optimisations, is of potential use in the industrial production of cellulases.     

嗜热革节孢多糖单加氧酶氧化方式

多糖单加氧酶(polysaccharidemonooxygenase,PMO)是一种铜离子依赖的氧化酶,属于辅助活性酶类第九家族(auxiliary activity 9,AA9),在存在电子供体维生素C(vitamin C,Vc)的情况下,可以氧化裂解纤维素的多糖链,显著提高纤维素的酶解效率。本文克隆了嗜热革节孢Scytalidium thermophilumAA9家族的一个编码基因pmo7651,并在毕赤酵母GS115进行诱导表达,通过His标签获得了重组蛋白PMO7651-His。以磷酸膨胀纤维素(PASC)为底物进行酶促反应,薄层层析法(TLC)结果显示PMO7651酶解产物主要为纤维二糖至纤维五糖;飞行时间质谱法(MALDI-TOF-MS)和溴氧化法确定PMO7651具有C1、C4、C6位的氧化活性;底物结合平面的3个芳香族氨基酸位点突变对酶的活性具有不同程度的影响;在PMO7651帮助下,纤维素酶的降解效率均具有不同程度的提高。     

Optimization of culture conditions for production of cellulases and xylanases by Scytalidium thermophilum using Response Surface Methodology

Summary Scytalidium thermophilum type culture Humicola insolens MTCC 4520 isolated from composting soil was optimized for production of cellulolytic and hemicellulolytic enzymes (endoglucanase, Avicel-adsorbable endoglucanase, FPase, β-glucosidase, xylanase and mannanase) by solid-state fermentation (SSF). Initial experiments showed that culture medium containing rice straw and wheat bran (1:3) as carbon source prepared in a synthetic basal medium supported maximal enzyme production at 45 °C. Further optimization of enzyme production was carried out using Box-Behnken design of experiments to study the influence of process variables (inoculum level, (NH₄)₂SO₄ and pH) on enzyme production. The response surface plots revealed the conditions for obtaining optimal enzyme levels. The models computed for R ² value ranged between 95% and 98.7% indicating they are appropriate and can be useful to predict the effect of inoculum level, (NH₄)₂SO₄ and pH on enzyme production. Under optimized conditions 62.5 ± 0.50, 23.0 ± 0.58, 3.0 ± 0.50, 151.00 ± 8.194, 196 ± 5.033 and 4.9 ± 0.32 (units/g substrate) of endoglucanase (EG), Avicel-adsorbable endoglucanase (AAEG), FPase, β-glucosidase, xylanase and mannanase were produced, respectively. Isoelectric focusing (IEF) of the crude extract showed that S. thermophilum produced six different EG isoforms, of which the EG corresponding to pI values of 8.4, 7.9 and 6.5 showed affinity for Avicel, thereby indicating the presence of a cellulose-binding domain (CBD). Furthermore, seven isoforms of β-glucosidase and ten multiple forms of xylanase distributed over a wide range of pI were also detected.     

Adapting substrate formulas used for shiitake for production of brown Agaricus bisporus

A pasteurized, non-composted substrate (basal mixture) consisting of oak sawdust (28%), millet (29%), rye (8%), peat (8%), alfalfa meal (4%), soybean flour (4%), wheat bran (9%), and CaCO3 (10%) was adapted from shiitake culture to produce the common cultivated mushroom (brown; portabello), Agaricus bisporus. Percentage biological efficiency (ratio of fresh mushroom harvested/oven-dry substrate weight, %BE) ranged from a low of 30.1% (when wheat straw was substituted for sawdust) to 77.1% for the basal mixture. Special, high gas-exchange bags were required to optimize mycelial growth during spawn run. Our formula may allow specialty mushroom growers to produce portabello mushrooms on a modified, pasteurized (110 degrees C for 20 min) substrate commonly used for shiitake production without the added expense of compost preparation.     

Ethylene production by axenic fruiting cultures of Agaricus bisporus

Axenic cultures of Agaricus bisporus were used to show that the rise in ethylene production during fruiting derives from its own metabolism.     

双孢蘑菇堆肥中真菌群落多样性分析

以农作物玉米秸和稻草、牛粪为原料,分别设计双孢蘑菇Agaricus bisporus堆肥配方并进行堆肥发酵,研究二者堆肥过程中真菌多样性。在建堆、一次发酵结束和二次发酵结束3个时期分别采集堆肥样品,提取总DNA,以真菌18S rDNA基因通用引物,进行PCR-DGGE扩增和序列分析。累计获得39条特异条带18S rDNA基因信息,分属于真菌14个属、藻类7个属和原生动物3个属。子囊菌是两种配方堆肥过程中的优势菌群,建堆时期的优势类群为Pichia和Wickerhamomyces,一次和二次发酵时期的优势类群为Chaetomium和Lecythophora。多样性指数分析显示,稻草配方微生物多样性大于玉米秸配方;主成分分析（PCA）显示,玉米秸配方一次发酵结束时期与稻草和玉米二次发酵结束时期聚为一类,说明玉米秸配方堆肥提前腐熟。     

Fruiting of Agaricus bisporus

Several enzymes were assayed in extracts from mycelium-colonised compost during growth and fruiting of Agaricus bisporus (Lange) Imbach. Comparison of changes of enzyme levels in axenic and nonaxenic cultures and in cultures of non-fruiting strains indicated that they were associated directly with the fungal mycelium. Large changes were found in the amounts of laccase and cellulase which were correlated with fruit body development. Laccase concentration increased during mycelial growth and then declined rapidly at the start of fruiting. Cellulase activity could be detected throughout growth but increased at fruiting. No such changes were observed in xylanase, alkaline protease, laminarinase and acid and alkaline phosphatases. Activities of laccase and cellulase were measured in axenic cultures arrested at various stages of fruiting development. Such cultures showed that the changes in concentration of laccase and cellulase were associated with the enlargement of fruit bodies.     

Chitinase production during interaction of Trichoderma aggressivum and Agaricus bisporus

The competitor fungus Trichoderma aggressivum causes green mould disease, a potentially devastating problem of the commercial mushroom Agaricus bisporus. Due to the recent appearance of this problem, very little is known about the mechanisms by which T. aggressivum interacts with and inhibits A. bisporus. A mechanism generally used by Trichoderma species in the antagonism of other fungi is the secretion of cell wall degrading enzymes. In this study, we determined the activities of chitinases produced in dual cultures of these fungi over a 2 week period. Both intracellular and extracellular enzymes were studied. Agaricus bisporus produced N-acetylglucosaminidases with apparent molecular masses of 111, 105, and 96 kDa. Two resistant brown strains produced greater activities of the 96 kDa N-acetylglucosaminidase than susceptible off-white and white strains. This result suggested that this enzyme might have a role in the resistance of commercial brown strains to green mould disease. Trichoderma aggressivum produced three N-acetylglucosaminidases with apparent molecular masses of 131, 125, and 122 kDa, a 40 kDa chitobiosidase, and a 36 kDa endochitinase. The 122 kDa N-acetylglucosaminidase showed the greatest activity and may be an important predictor of antifungal activity.     

Immobilization of Xylan-Degrading Enzymes from Scytalidium thermophilum on Eudragit L-100

Summary Xylanase from Scytalidium thermophilum was immobilized on Eudragit L-100, a pH sensitive copolymer of methacrylic acid and methyl methacrylate. The enzyme was non-covalently immobilized and the system expressed 70% xylanase activity. The immobilized preparation had broader optimum temperature of activity between 55 and 65 °C as compared to 65 °C in case of free enzyme and broader optimum pH between 6.0 and 7.0 as compared to 6.5 in case of free enzyme. Immobilization increased the t_1/2 of enzyme at 60 °C from 15 to 30 min with a stabilization factor of 2. The K_m and V_max values for the immobilized and free xylanase were 0.5% xylan and 0.89 μmol/ml/min and 0.35% xylan and 1.01 μmol/ml/min respectively. An Arrhenius plot showed an increased value of activation energy for immobilized xylanase (227 kcal/mol) as compared to free xylanase (210 kcal/mol) confirming the higher temperature stability of the free enzyme. Enzymatic saccharification of xylan was also improved by xylanase immobilization.     

Manganese peroxidase of Agaricus bisporus: grain bran-promoted production and gene characterization

The main manganese peroxidase (MnP) isoenzyme of Agaricus bisporus ATCC 62459 produced in lignocellulose-containing cultures was isolated, cloned and sequenced. In liquid medium, where MnP was previously detected only in trace amounts, the production of MnP was enhanced by rye and wheat bran supplements. The pI (3.25) and N-terminal amino acid sequence (25 aa) of the enzyme from bran-containing cultures were identical to those reported from compost-isolated MnP1. MnP1 is a 328-aa long polypeptide preceded by a 26-aa leader peptide. The nucleotide sequence and putative amino acid sequence of MnP1 reveal its similarity to Pleurotus ostreatus MnP3 (62.5%), Lepista irina versatile peroxidase (VP) (61.8%) and Pleurotus eryngii VPs VPL2 and VPL1 (61.9% and 61.2%, respectively). The intron-exon structure resembles that of P. ostreatus MnP1 and P. eryngii VPL1. Despite the sequence similarity to VPs, in the A. bisporus MnP1 sequence, alanine (A163) is present instead of tryptophane (W164), distinguishing it from the veratryl alcohol oxidising P. eryngii VPLs. The MnP sequence can be used as a tool to examine the pattern of ligninolytic gene expression during the growth and fruiting of A. bisporus to optimise compost composition, fungal growth and mushroom production.     

Germination of basidiospores of Agaricus bisporus

The type of dormancy and conditions necessary for germination of Agaricus bisporus basidiospores (BS) were studied. BS failed to germinate on starvation agar and required the presence of carbon and nitrogen (asparagine and/or glucose) sources in the medium. Upon 3-week storage, BS germinated after 4-5 days. Heat shock (20 min at 45 degrees C) and the decreased temperature facilitated activation of germination. Heterocyclic compounds stimulating germination of endogenously dormant spores, such as furfural, failed to activate germination. The data obtained suggested an endogenous dormancy of A. bisporus BS differing from zygospores of Mucorales. BS contained 17-19% lipids with a composition of fatty acids differing from those of pileus and stipe of the fruiting body. The soluble carbohydrates of the cytosol amounted to 12% dry spore weight and consisted of mannitol (74%) and trehalose (26%). Unlike BS stored at 2 degrees C, the BS stored for 5 months at 20 degrees C lost their ability to germinate, which correlated with a decrease in the content of trehalose.     

A life cycle assessment of Agaricus bisporus mushroom production in the USA

The International Journal of Life Cycle Assessment - Stakeholders across the food product supply chain are increasingly interested in understanding the environmental effects of food production....