Kinetics of multilayer immobilized enzyme-filter reactors: Behavior of urease-filter reactors in different buffers

A sequential model which describes the kinetic behavior of multilayer immobilized-enzyme filter reactors for systems obeying the Michaelis-Menten scheme and various types of inhibition by product and by substrate is proposed. The model was varified experimentaly using a single enzyme-filter-substrate system-urease bound to nylon-filter disks acting on urea-in different buffers to obtain the various inhibition patterns.     

Biomass control in waste air biotrickling filters by protozoan predation

Two protozoan species as well as an uncharacterized protozoan consortium were added to a toluene-degrading biotrickling filter to investigate protozoan predation as a means of biomass control. Wet biomass formation in 23.6-L reactors over a 77-day period was reduced from 13.875 kg in a control biotrickling filter to 11.795 kg in a biotrickling filter enriched with protozoa. The average toluene vapor elimination capacity at 1 g/m3 toluene and 64 m3/(m3. h) was 31.1 g/(m3. h) in the control and 32.2 g/(m3. h) in the biotrickling filter enriched with protozoa. At higher toluene inlet concentrations, toluene degradation rates increased and were slightly higher in the biotrickling filter enriched with protozoa. The lower rate of biomass accumulation after the addition of protozoa was due to an increase of carbon mineralization (68% as compared to 61% in the control). Apparent biomass yield coefficients in the control and enriched trickling filter were 0.72 and 0.59 g dry biomass/g toluene, respectively. The results show that protozoan predation may be a useful tool to control biomass in biotrickling filters, however, further stimulation of predation of the biomass immobilized in the reactor is required to ensure long-term stability of biotrickling filters.     

A mathematical model for the leukocyte filtration process

Leukocyte filters are applied clinically to remove leukocytes from blood. In order to optimize leukocyte filters, a mathematical model to describe the leukocyte filtration process was developed by modification of a general theoretical model for depth filtration. The model presented here can be used to predict the time-dependent leukocyte filtration as a function of cell-cell interaction in the filter, filter efficiency, filter capacity, filter dimensions, and leukocyte concentration in the suspension applied to the filter. The results of different leukocyte filtration experiments previously reported in the literature could be well described by the present model. (c) 1995 John Wiley & Sons, Inc.     

Comparison of microporous filters for concentration of viruses from wastewater.

The 1-MDS Virosorb filter and the 50S and 30S Zeta-plus filters, all with a net positive charge, were compared with the negatively charged Filterite filter for concentration of naturally occurring coliphages and animal viruses from sewage effluent. When Filterite filters were used, the effluent was adjusted to pH 3.5 and AlCl3 was added before filtration to facilitate virus adsorption. No adjustment was required with the positively charged filters. Sets of each filter type were eluted with 3% beef extract (pH 9.5) or eluted with 0.05 M glycine (pH 11.5). A maximum volume of 19 liters could be passed through 142-mm diameter Filterite filters before clogging, whereas only 11, 11, and 15 liters could be passed through the 1-MDS, 50S, and 30S filters, respectively. For equal volumes passed through the filters, coliphage recoveries were 14, 15, 18, and 37% in primary effluent and 40, 97, 50, and 46% in secondary effluent for the Filterite , 1-MDS, 50S, and 30S filters, respectively. No statistically significant difference was observed in the recovery of animal viruses among the filters from secondary effluent, whereas in the Filterite and 50S filters, higher numbers of viruses from primary effluent were recovered than in the 1-MDS and 30S filters in two of three collections. Glycine was found to be a less-efficient eluent than beef extract in the recovery of naturally occurring viruses.     

Comparison of microporous filters for concentration of viruses from wastewater

The 1-MDS Virosorb filter and the 50S and 30S Zeta-plus filters, all with a net positive charge, were compared with the negatively charged Filterite filter for concentration of naturally occurring coliphages and animal viruses from sewage effluent. When Filterite filters were used, the effluent was adjusted to pH 3.5 and AlCl3 was added before filtration to facilitate virus adsorption. No adjustment was required with the positively charged filters. Sets of each filter type were eluted with 3% beef extract (pH 9.5) or eluted with 0.05 M glycine (pH 11.5). A maximum volume of 19 liters could be passed through 142-mm diameter Filterite filters before clogging, whereas only 11, 11, and 15 liters could be passed through the 1-MDS, 50S, and 30S filters, respectively. For equal volumes passed through the filters, coliphage recoveries were 14, 15, 18, and 37% in primary effluent and 40, 97, 50, and 46% in secondary effluent for the Filterite , 1-MDS, 50S, and 30S filters, respectively. No statistically significant difference was observed in the recovery of animal viruses among the filters from secondary effluent, whereas in the Filterite and 50S filters, higher numbers of viruses from primary effluent were recovered than in the 1-MDS and 30S filters in two of three collections. Glycine was found to be a less-efficient eluent than beef extract in the recovery of naturally occurring viruses.     

Stability of anaerobic filters packed with different support materials

Summary Two anaerobic filters were subjected to shock treatments in similar conditions, by suddenly lowering the temperature of the reactors by 10 °C in one case and by suddenly stopping the addition of alkali to the feed in a second experiment. In both cases the reactor packed with polyurethane sponge showed no variations in the different analysed parameters with respect to the values of the steady-state of reference, while the filter packed with rocks was more affected by the temperature shock than by the decrease of the pH of the feed.     

Long-term microbial community dynamics at two full-scale biotrickling filters treating pig house exhaust air

In this study, the microbial community structure of two full-scale biotrickling filters treating exhaust air from a pig housing facility were evaluated using 16S metabarcoding. The effect of inoculation with activated sludge of a nearby domestic waste water treatment plant was investigated, which is a cheap procedure and easy to apply in practice. The study was performed at a three-stage and a two-stage full-scale biotrickling filter; of which, only the latter was inoculated. Both biotrickling filters evolved towards a rather similar community over time, which differed from the one in the activated sludge used for inoculation. However, the bacterial population at both biotrickling filters showed small differences on the family level. A large population of heterotrophic bacteria, including denitrifying bacteria, was present in both biotrickling filters. In the non-inoculated biotrickling filter, nitrite-oxidizing bacteria (NOB) could not be detected, which corresponded with the incomplete nitrification leading to high nitrite accumulation observed in this system. Inoculation with the wide spectrum inoculum activated sludge had in this study a positive effect on the biotrickling filter performance (higher ammonia removal and lower nitrous oxide production). It could thus be beneficial to inoculate biotrickling filters in order to enrich NOB at the start-up, making it easier to keep the free nitrous acid concentration low enough to not be inhibited by it.     

Concentration of enteroviruses from estuarine water.

Pleated cartridge filters readily adsorb viruses in estuarine water at low pH containing aluminum chloride. Adsorbed viruses are efficiently recovered by treating filters with glycine buffer at high pH. By using these procedures, it was possible to recover approximately 70% of the poliovirus added to 400 liters of estuarine water in 3 liters of filter eluate. Reconcentration of virus in the filter eluate in small volumes that are convenient for viral assays was more difficult. Reconcentration methods described previously for eluates from filters that process tap water or treated wastewater were inadequate when applied to eluates from filters used to process estuarine water containing large amounts of organic compounds. Two methods were found to permit efficient concentration of virus in filter eluates in small volumes. In both methods, virus in 3 liters of filter eluate was adsorbed to aluminum hydroxide flocs and then recovered in approximately 150 ml of buffered fetal calf serum. Additional reductions in volume were achieved by ultrafiltration or hydroextraction. By using these procedures 60 to 80% of the virus in 3 liters of filter eluate could be recovered in a final volume of 10 to 40 ml.     

A new VFA sensor technique for anaerobic reactor systems

A key parameter for understanding and controlling the anaerobic biogas process is the concentration of volatile fatty acids (VFA). However, this information has so far been limited to off-line measurements using labor-intensive methods. We have developed a new technique that has made it possible to monitor VFA on-line in one of the most difficult media: animal slurry or manure. A novel in situ filtration technique has made it possible to perform microfiltration inside a reactor system. This filter enables sampling from closed reactor systems without large-scale pumping and filters. Furthermore, due to its small size it can be placed in lab-scale reactors without disturbing the process. Using this filtration technique together with commercially available membrane filters we have constructed a VFA sensor system that can perform automatic analysis of animal slurry at a frequency as high as every 15 minutes. Reproducibility and recovery factors of the entire system have been determined. The VFA sensor has been tested for a period of more than 60 days with more than 1,000 samples on both a full-scale biogas plant and lab-scale reactors. The measuring range covers specific measurements of acetate, propionate, iso-/n-butyrate and iso-/n-valerate ranging from 0.1 to 50 mM (6-3,000 mg). The measuring range could readily be expanded to more components and both lower and higher concentrations if desired. In addition to the new VFA sensor system, test results from development and testing of the in situ filtration technique are being presented is this article.     

Concentration of enteroviruses from estuarine water.

Pleated cartridge filters readily adsorb viruses in estuarine water at low pH containing aluminum chloride. Adsorbed viruses are efficiently recovered by treating filters with glycine buffer at high pH. By using these procedures, it was possible to recover approximately 70% of the poliovirus added to 400 liters of estuarine water in 3 liters of filter eluate. Reconcentration of virus in the filter eluate in small volumes that are convenient for viral assays was more difficult. Reconcentration methods described previously for eluates from filters that process tap water or treated wastewater were inadequate when applied to eluates from filters used to process estuarine water containing large amounts of organic compounds. Two methods were found to permit efficient concentration of virus in filter eluates in small volumes. In both methods, virus in 3 liters of filter eluate was adsorbed to aluminum hydroxide flocs and then recovered in approximately 150 ml of buffered fetal calf serum. Additional reductions in volume were achieved by ultrafiltration or hydroextraction. By using these procedures 60 to 80% of the virus in 3 liters of filter eluate could be recovered in a final volume of 10 to 40 ml.     

Hydrolysis of organophosphate insecticides by an immobilized-enzyme system.

An enzyme preparation that could detoxify parathion and eight other organophosphate pesticides was covalently bound to either porous glass or porous silica beads. This immobilized-enzyme system was examined for its use in detoxification of pesticides in production wastewaters. The kinetics of parathion hydrolysis were examined at flow rates up to 96 liter/hr and at influent substrate concentrations ranging from 10--250 mg/liter. The enzyme reactor was able to hydrolyze 95% or more of the parathion added to industrial wastewaters generated during its production, thus reducing the effluent parathion concentration to below 500 ppb. Laboratory continuous-flow experiments were conducted for 70 days with industrial wastewater and indicated no loss in immobilized-enzyme activity. The influence of pH, temperature, solvents, and detergents on enzyme stability and activity and enzyme reactor kinetics will be discussed.     

Testing and evaluation of off-gas filters for bioreactors by a new bacterial aerosol challenge test method (TBAC).

A TNO bacterial aerosol challenge (TBAC) filter test rig was developed for direct assessment of the effectiveness of bioreactor off-gas filters as an alternative to routinely applied indirect wet integrity testing (IT). This TBAC test rig is based on bacterial aerosol challenging with Pseudomonas diminuta and dual monitoring by laser particle counting (LPC) and Andersen microbial sampling (AMS) of viable cells. The TBAC filter test rig is able to reproduce the various conditions encountered in fermentation processes. In experiments with several filters from one class, it was demonstrated that some filters were actually penetrated by up to 3,000 viable cells per test, despite their approval by commercially available IT test equipment. Repetitive filter use, prolonged use, and autoclaving of filters resulted in an increase in pressure drop over the filter but improved the performance of leaking/deviant filters due to building up of a filter cake (this phenomenon was identified by electron microscopy). The integrity tests used were found inadequate for accurate assessment of filter quality. Certification of filter lots by random tests of commercially available off-gas filters using sensitive direct methods such as those presented here might be advisable, as not all filters purchased were of appropriate quality.     

Detection of respiratory viruses on air filters from aircraft

Aims: To evaluate the feasibility of identifying viruses from aircraft cabin air, we evaluated whether respiratory viruses trapped by commercial aircraft air filters can be extracted and detected using a multiplex PCR, bead‐based assay. Methods and Results: The ResPlex II assay was first tested for its ability to detect inactivated viruses applied to new filter material; all 18 applications of virus at a high concentration were detected. The ResPlex II assay was then used to test for 18 respiratory viruses on 48 used air filter samples from commercial aircraft. Three samples tested positive for viruses, and three viruses were detected: rhinovirus, influenza A and influenza B. For 33 of 48 samples, internal PCR controls performed suboptimally, suggesting sample matrix effect. Conclusion: In some cases, influenza and rhinovirus RNA can be detected on aircraft air filters, even more than 10 days after the filters were removed from aircraft. Significance and Impact of the Study: With protocol modifications to overcome PCR inhibition, air filter sampling and the ResPlex II assay could be used to characterize viruses in aircraft cabin air. Information about viruses in aircraft could support public health measures to reduce disease transmission within aircraft and between cities.     

Survival of microorganisms on antimicrobial filters and the removal efficiency of bioaerosols in an environmental chamber

Exposure to bioaerosols causes various adverse health effects including infectious and respiratory diseases, and hypersensitivity. Controlling exposure to bioaerosols is important for disease control and prevention. In this study, we evaluated the efficacies of various functional filters coated with antimicrobial chemicals in deactivating representative microorganisms on filters or as bioaerosols. Tested functional filters were coated with different chemicals that included (i) Ginkgo and sumac, (ii) Ag-apatite and guanidine phosphate, (iii) SiO2, ZnO, and Al2O3, and (iv) zeolite. To evaluate the filters, we used a model ventilation system (1) to evaluate the removal efficiency of bacteria (Escherichia coli and Legionella pneumophila), bacterial spores (Bacillus subtilis spore), and viruses (MS2 bacteriophage) on various functional filters, and (2) to characterize the removal efficiency of these bioaerosols. All experiments were performed at a constant temperature of 25 degrees C and humidity of 50%. Most bacteria (excluding B. subtilis) rapidly decreased on the functional filter. Therefore, we confirmed that functional filters have antimicrobial effects. Additionally, we evaluated the removal efficiency of various bioaerosols by these filters. We used a six-jet collision nebulizer to generate microbial aerosols and introduced it into the environmental chamber. We then measured the removal efficiency of functional filters with and without a medium-efficiency filter. Most bioaerosol concentrations did not significantly decrease by the functional filter only but decreased by a combination of functional and medium-efficiency filter. In conclusion, functional filters could facilitate biological removal of various bioaerosols, but physical removal of these by functional was minimal. Proper use of chemical-coated filter materials could reduce exposure to these agents.     

Polymerase chain reaction-gene probe detection of microorganisms by using filter-concentrated samples.

To detect low levels of microorganisms in environmental samples by using polymerase chain reaction (PCR)-gene probe detection, samples were concentrated by filtration. Fluoropore (Millipore Corp.) filters were compatible with PCR DNA amplification, whereas various other filters including nitrocellulose and cellulose acetate filters inhibited PCR amplification. By concentrating cells on Fluoropore filters and releasing the DNA by freeze-thaw cycling, PCR DNA amplification could be performed without removing the filter. Concentration with Fluoropore FHLP and FGLP filters permitted the detection of single cells of microorganisms in 100-ml samples by PCR-gene probes.     

Polymerase chain reaction-gene probe detection of microorganisms by using filter-concentrated samples.

To detect low levels of microorganisms in environmental samples by using polymerase chain reaction (PCR)-gene probe detection, samples were concentrated by filtration. Fluoropore (Millipore Corp.) filters were compatible with PCR DNA amplification, whereas various other filters including nitrocellulose and cellulose acetate filters inhibited PCR amplification. By concentrating cells on Fluoropore filters and releasing the DNA by freeze-thaw cycling, PCR DNA amplification could be performed without removing the filter. Concentration with Fluoropore FHLP and FGLP filters permitted the detection of single cells of microorganisms in 100-ml samples by PCR-gene probes.     

The effect of different high-pass filter settings on peak latencies in the event-related potentials of schizophrenics,patients with Parkinson's disease and controls

Eighteen schizophrenic patients, 16 patients with idiopathic Parkinson's disease, and the same numbers of age, sex and education matched controls were examined with oddball experiments for the generation of P3. Individual averages were high-pass filtered at different cut-off frequencies with single-pole digital filters with equivalent analogue Butterworth filter profiles. The purpose of this procedure was to simulate analogue high-pass filters used in clinical studies from different centres and to examine their potential effect on group differences. Increasing high-pass filters resulted in a phase lead for all peaks examined (N1, P2, N2, P3). The only group differences were found for P3, which showed a greater phase lead in controls than in the patient groups, usually resulting in a more pronounced group difference. Similar wave forms and filter properties could be modelled by synthetic wave forms consisting of sine waves of different frequencies.     

Comparison of different glass fibre and silver metal filters for the determination of particulate organic carbon

The most retentive glass fibre filters were able to retain almost all bacteria from the water of an oligotrophic lake. Having satisfactory speed and capacity, of filtration this type of filter is quite near to the ideal which should be able to include all algae and bacteria in the category of particulate organic carbon. Similar retention could also be achieved by silver filters but, because of their high blank values, price, and lower filtration speed and capacity, they are not able to compete with glass fibre filters in practical work.     

Gentisate dioxygenase activity in immobilized cell-free extracts prepared from Salmonella typhimurium

Cell-free extracts of Salmonella typhimurium containing gentisate dioxygenase were immobilized by entrapment in carrageenan and polyacrylamide and adsorption to polyester filters. Carrageenan gels were very porous, and the enzyme was slowly inactivated in polyacrylamide. When adsorbed on polyester the enzyme could be lyophilized and reactivated. Batch reactors charged with the immobilized enzyme converted gentisate to maleylpyruvate with yields of 10–90%.     

Concentration of poliovirus from tap water using positively charged microporous filters.

Microporous filters that are more electropositive than the negatively charged filters currently used for virus concentrations from water by filter adsorption-elution methods were evaluated for poliovirus recovery from tap water. Zeta Plus filters composed of diatomaceous earth-cellulose-"charge-modified" resin mixtures and having a net positive charge of up to pH 5 to 6 efficiently adsorbed poliovirus from tap water at ambient pH levels 7.0 to 7.5 without added multivalent cation salts. The adsorbed virus were eluted with glycine-NaOH, pH 9.5 to 11.5. Electropositive asbestos-cellulose filters efficiently adsorbed poliovirus from tap water without added multivalent cation salts between pH 3.5 and 9.0, and the absorbed viruses could be eluted with 3% beef extract, pH 9, but not with pH 9.5 to 11.5 glycine-NaOH. Under water quality conditions in which poliovirus recoveries from large volumes of water were less than 5% with conventional negatively charged filters and standard methods, recoveries with Zeta Plus filters averaged 64 and 22.5% for one- and two-stage concentration procedures, respectively. Electropositive filters appear to offer distinct advantages over conventional negatively charged filters for concentrating enteric viruses from water, and their behavior tends to confirm the importance of electrostatic forces in virus recovery from water by microporous filter adsorption-elution methods.