Anaerobic digestion of source-segregated domestic food waste: Performance assessment by mass and energy balance

An anaerobic digester receiving food waste collected mainly from domestic kitchens was monitored over a period of 426 days. During this time information was gathered on the waste input material, the biogas production, and the digestate characteristics. A mass balance accounted for over 90% of the material entering the plant leaving as gaseous or digestate products. A comprehensive energy balance for the same period showed that for each tonne of input material the potential recoverable energy was 405 kWh. Biogas production in the digester was stable at 642 m³ tonne⁻¹ VS added with a methane content of around 62%. The nitrogen in the food waste input was on average 8.9 kg tonne⁻¹. This led to a high ammonia concentration in the digester which may have been responsible for the accumulation of volatile fatty acids that was also observed.     

Biodrying for mechanical–biological treatment of wastes: A review of process science and engineering

Biodrying is a variation of aerobic decomposition, used within mechanical–biological treatment (MBT) plants to dry and partially stabilise residual municipal waste. Biodrying MBT plants can produce a high quality solid recovered fuel (SRF), high in biomass content. Here, process objectives, operating principles, reactor designs, parameters for process monitoring and control, and their effect on biodried output quality are critically examined. Within the biodrying reactors, waste is dried by air convection, the necessary heat provided by exothermic decomposition of the readily decomposable waste fraction. Biodrying is distinct from composting in attempting to dry and preserve most of biomass content of the waste matrix, rather than fully stabilise it. Commercial process cycles are completed within 7–15 days, with mostly H₂O_(g) and CO₂ loses of ca. 25–30% w/w, leading to moisture contents of <20% w/w. High airflow rate and dehumidifying of re-circulated process air provides for effective drying. We anticipate this review will be of value to MBT process operators, regulators and end-users of SRF.     

Enhanced biomethanation of kitchen waste by different pre-treatments

Five different pre-treatments were investigated to enhance the solubilisation and anaerobic biodegradability of kitchen waste (KW) in thermophilic batch and continuous tests. In the batch solubilisation tests, the highest and the lowest solubilisation efficiency were achieved with the thermo-acid and the pressure-depressure pre-treatments, respectively. However, in the batch biodegradability tests, the highest cumulative biogas production was obtained with the pressure-depressure method. In the continuous tests, the best performance in terms of an acceptable biogas production efficiency of 60% and stable in-reactor COD_s and VFA concentrations corresponded to the pressure-depressure reactor, followed by freeze-thaw, acid, thermo-acid, thermo and control. The maximum OLR (5 g COD L⁻¹ d⁻¹) applied in the pressure-depressure and freeze-thaw reactors almost doubled the control reactor. From the overall analysis, the freeze-thaw pre-treatment was the most profitable process with a net potential profit of around 11.5 € ton⁻¹ KW.     

Effect of freezing and dehydration on ion and cryoprotectant distribution and hemolymph volume in the goldenrod gall fly, Eurosta solidaginis

Extracellular freezing and dehydration concentrate hemolymph solutes, which can lead to cellular injury due to excessive water loss. Freeze tolerant larvae of the goldenrod gall fly, Eurosta solidaginis, may experience extreme cold and desiccation in winter. To determine whether larvae employ protective mechanisms against excessive cellular water loss we examined the effect of extracellular freezing and dehydration on hemolymph volume, and cryoprotectant and ion levels in the hemolymph. Dehydrated larvae or ones that had been frozen at −5 or −20 °C had a significantly smaller proportion of their body water as hemolymph (26.0-27.4%) compared to controls (30.5%). Even with this reduction in water content, hemolymph osmolality was similar or only slightly higher in frozen or dehydrated individuals than controls (908 mOsm kg⁻¹), indicating these stresses led to a reduction in hemolymph solutes. Hemolymph and intracellular content of ions remained largely unchanged between treatment groups; although levels of Mg⁺⁺ in the hemolymph were lower in larvae subjected to freezing (0.21 ± 0.01 μg mg⁻¹ dry mass) compared to controls (0.29 ± 0.01 μg mg⁻¹ dry mass), while intracellular levels of K⁺ were lower in groups exposed to low temperature (8.31 ± 0.21 μg mg⁻¹ dry mass). Whole body glycerol and sorbitol content was similar among all treatment groups, averaging 432 ± 25 mOsm kg⁻¹ and 549 ± 78 mOsm kg⁻¹ respectively. However, larvae subjected to dehydration and freezing at −20 °C had a much lower relative amount of cryoprotectants in their hemolymph (∼35%) compared to controls (54%) suggesting these solutes moved into intracellular compartments during these stresses. The correlation between reduced hemolymph volume (i.e. increased cellular water content) and intracellular movement of cryoprotectants may represent a link between tolerance of dehydration and cold in this species.     

Shoot age as a confounding factor on detecting the effect of human-induced disturbance on Posidonia oceanica growth performance

The response of orthotropic rhizome elongation and primary production of Posidonia oceanica to anthropogenic perturbations and potential confounding effects of shoot age were assessed using a Linear Multilevel Model (LMM). This model examined the confounding effect of age by comparing the estimates of impact and variance components obtained by excluding and including Age as an explanatory variable. Age had a negative effect on rhizome elongation and primary production with an annual decrease of 0.6 mm y^− 1 and 7 mg dw y^− 1 respectively. According to the LMM when age effect was omitted, the differences between disturbed and control locations in rhizome elongation and primary production were 2.62 mm y^− 1 and 0.044 g dw y^− 1 respectively. These effects were statistically not significant. On the contrary, when age effect was included in the statistical model, impacts became evident for both variables, with significant differences between disturbed and control locations of 5.85 mm y^− 1 and 0.081 g dw y^− 1 for rhizome elongation and primary production, respectively. Thus, particular attention should be paid to the potential confounding effect of shoots age in analyses of impacts on growth performance of P. oceanica.     

Oxalate production at different initial Pb²+ concentrations and the influence of oxalate during solid-state fermentation of straw with Phanerochaete chrysosporium

The production of oxalate at different initial Pb²⁺ concentrations during solid-state fermentation of straw with Phanerochaete chrysosporium was investigated. It was found that the maximal peak value of oxalate concentration (22.84 mM) was detected at the initial Pb²⁺ concentration of 200 mg kg⁻¹ dry straw, while the minimum (15.89 mM) at the concentration of 600 mg Pb²⁺ kg⁻¹ dry straw, and at moderate concentration of Pb²⁺ the capability of oxalic acid secretion was enhanced. In addition, it was also found that more oxalic acid accumulation went together with better Pb²⁺ passivation effect and higher manganese peroxidase (MnP) activity. The present findings will improve the understandings of the interactions of heavy metals with white-rot fungi and the role of oxalate in lignin degradation system, which could provide useful references for more efficient treatment of Pb-contaminated lignocellulosic waste.     

Effects of heat treatment on hydrogen production potential and microbial community of thermophilic compost enrichment cultures

Cellulosic plant and waste materials are potential resources for fermentative hydrogen production. In this study, hydrogen producing, cellulolytic cultures were enriched from compost material at 52, 60 and 70 °C. Highest cellulose degradation and highest H₂ yield were 57% and 1.4 mol-H₂ mol-hexose⁻¹ (2.4 mol-H₂ mol-hexose-degraded⁻¹), respectively, obtained at 52 °C with the heat-treated (80 °C for 20 min) enrichment culture. Heat-treatments as well as the sequential enrichments decreased the diversity of microbial communities. The enrichments contained mainly bacteria from families Thermoanaerobacteriaceae and Clostridiaceae, from which a bacterium closely related to Thermoanaerobium thermosaccharolyticum was mainly responsible for hydrogen production and bacteria closely related to Clostridium cellulosi and Clostridium stercorarium were responsible for cellulose degradation.     

Synthesis and characterization of a molecularly imprinted polymer and its application as SPE enrichment sorbent for determination of trace methimazole in pig samples using HPLC-UV

A novel molecularly imprinted polymer that could be applied as enrichment sorbent was prepared using methimazole (MMZ) as the template molecule, methacrylic acid as functional monomer, ethylene glycol dimethacrylate as cross-linker. Though evaluated by static, kinetic and competitive adsorption tests, the polymer exhibited high adsorption capacity, fast kinetics and good selective ability. A method for determination of trace MMZ was developed using this polymer as enrichment sorbent coupled with high performance liquid chromatography focusing on complex biological matrices. Under the optimum experimental conditions, the MMZ standard is linear within the concentration range studied, that is, from 0.5 μg L⁻¹ to 150 μg L⁻¹ (r² = 0.9941). Lower limits of detection (LOD, at S/N = 3) and quantification (LOQ, at S/N = 10) in pig samples were 0.63 μg kg⁻¹ and 2.10 μg kg⁻¹ for kidney, 0.51 μg kg⁻¹ and 1.70 μg kg⁻¹ for liver, 0.56 μg kg⁻¹ and 1.86 μg kg⁻¹ for muscle, respectively. Recoveries and relative standard deviation (RSD, n = 9) values for precision in the developed method were from 71.14% to 88.41% and from 2.53% to 6.18%.     

Production of earthworm Allolobophora parva (Eisen) in cattle dung

Vermicomposting potential of Allolobophora parva is well proven in recent experiments but little is known about its growth and reproduction performance. Efforts were made in this study to assess the biological productivity of A. parva in cattle waste solids under laboratory conditions. The growth and reproduction performance of A. parva was monitored up to its termination state in experimental beddings. A. parva was weighed weekly and cocoons produced during the interval were also counted. The maximum individual biomass and maximum growth rate (wt. mg worm⁻¹ week⁻¹) was 190.9 ± 0.07 mg (after 13 weeks) and 2.66 (after 12th week), respectively. A. parva showed the maximum values of cocoon number (within a week) and reproduction rate: 26 ± 1.12 and 0.74 ± 0.05 cocoon worm⁻¹ week⁻¹, respectively, during the 8th week of vermiculture. Cocoon production in earthworms was terminated after the 17th week of culture. Data suggested that A. parva may acts as a potential candidate to convert negligible organic waste resources into worm biomass for sustainable environmental management.     

Feasibility of biogas production from anaerobic co-digestion of herbal-extraction residues with swine manure

The objective of this work was to examine the feasibility of biogas production from the anaerobic co-digestion of herbal-extraction residues with swine manure. Batch and semi-continuous experiments were carried out under mesophilic anaerobic conditions. Batch experiments revealed that the highest specific biogas yield was 294 mL CH₄ g⁻¹ volatile solids added, obtained at 50% of herbal-extraction residues and 3.50 g volatile solids g⁻¹ mixed liquor suspended solids. Specific methane yield from swine manure alone was 207 mL CH₄ g⁻¹ volatile solid added d⁻¹ at 3.50 g volatile solids g⁻¹ mixed liquor suspended solids. Furthermore, specific methane yields were 162, 180 and 220 mL CH₄ g⁻¹ volatile solids added d⁻¹ for the reactors co-digesting mixtures with 10%, 25% and 50% herbal-extraction residues, respectively. These results suggested that biogas production could be enhanced efficiently by the anaerobic co-digestion of herbal-extraction residues with swine manure.     

Optimising the biogas production from leather fleshing waste by co-digestion with MSW

Waste from the leather industry, known as limed leather fleshing (LF), has a low C:N (3.2) and an alkaline pH of 11.4. This is a major disadvantage for anaerobic digestion due to ammonia toxicity for methanogenesis. This study describes co-digestion of LF with biodegradable fraction of municipal solids waste optimised over a range of C:N and pH to minimise ammonia and to maximise biogas yield. The optimum conditions were found with a blend that provided C:N of 15 and pH of 6.5 and the cumulative biogas yield increased from 560 mL using LF fraction alone, to 6518 mL with optimum blend. At higher pH of 8.5, unionised ammonia was high (2473 mg L⁻¹) coincided with poor biogas yield (47 mL d⁻¹) that confirms ammonia toxicity. By contrast at a pH of 4.5 the ammonia was minimum (510 mg L⁻¹), but high VFA (26,803 mg L⁻¹) inhibited the methanogens. Biomass activity measured using ATP correlated well with biogas yield as reported previously.     

Evaluating industrial symbiosis and algae cultivation from a life cycle perspective

A comparative life cycle assessment (LCA) was conducted on 20 scenarios of microalgae cultivation. These scenarios examined the utilization of nutrients and CO₂ from synthetic sources and waste streams as well as the materials used to construct a photobioreactor (PBR). A 0.2-m³ closed PBR of Chlorella vulgaris at 30%-oil content by weight with the productivity of 25 g/m² × day was used as a case study. Results of the study show that the utilization of resources from waste streams mainly avoided global warming potential (GWP) and eutrophication impacts. Impacts from the production of material used to construct the PBR dominate total impacts in acidification and ozone depletion categories, even over longer PBR lifetimes; thus, the choice of PBR construction materials is important.     

Assessment of olive-mill wastewater as a growth medium for lipase production by Candida cylindracea in bench-top reactor

Olive-mill wastewater (OMW) was investigated for its suitability to serve as a medium for lipase production by Candida cylindracea NRRL Y-17506. The OMW that best supported enzyme production was characterized by low COD and low total sugars content. In shake flask batch cultures, OMW supplementation with 2.4 g l⁻¹ NH₄Cl and 3 g l⁻¹ olive oil led to an enzyme activity of about 10 U ml⁻¹. The addition of glucose or malt extract and supplements containing organic N (e.g., peptone, yeast extract) either depressed or did not affect the enzyme production. Further experiments were then performed in a 3-l stirred tank reactor to assess the impact of medium pH and stirring speed on the yeast enzyme activity. The lipase activity was low (1.8 U ml⁻¹) when the pH was held constant at 6.5, significantly increased (18.7 U ml⁻¹) with uncontrolled pH and was maximum (20.4 U ml⁻¹) when the pH was let free to vary below 6.5. A stirring regime, that varied depending on the dissolved oxygen concentration in the medium, both prevented the occurrence of anoxic conditions during the exponential growth phase and enabled good lipase production (i.e., 21.6 U ml⁻¹) and mean volumetric productivity (i.e., 123.5 U l⁻¹ h⁻¹).     

Biomass adaptation over anaerobic co-digestion of sewage sludge and trapped grease waste

The feasibility of sewage sludge co-digestion using intermediate waste generated inside a wastewater treatment plant, i.e. trapped grease waste from the dissolved air flotation unit, has been assessed in a continuous stirred lab reactor operating at 35 °C with a hydraulic retention time of 20 days. Three different periods of co-digestion were carried out as the grease waste dose was increased. When the grease waste addition was 23% of the volatile solids fed (organic loading rate 3.0 kg_COD m⁻³ d⁻¹), an increase in methane yield of 138% was reported. Specific activity tests suggested that anaerobic biomass had adapted to the co-substrate. The adapted inoculum showed higher acetoclastic methanogenic and β-oxidation synthrophic acetogenic activities but lower hydrogenotrophic methanogenic activity. The results indicate that a slow increase in the grease waste dose could be a strategy that favours biomass acclimation to fat-rich co-substrate, increases long chain fatty acid degradation and reduces the latter’s inhibitory effect.     

Molecular cloning,characterization and mRNA expression of selenium-dependent glutathione peroxidase from abalone Haliotis discus hannai Ino in response to dietary selenium,zinc and iron

A novel selenium-dependent glutathione peroxidase (Se-GPX) was cloned from abalone Haliotis discus hannai Ino (HdhGPx) by homology cloning with degenerate primers and RACE techniques. The full length of HdhGPx cDNA was 963 bp with a 669 bp open reading frame (ORF) encoding 222 amino acids and a 101 bp eukaryotic selenocysteine insertion sequence (SECIS) in 3′ untranslated region (UTR). It was showed that HdhGPx has a characteristic codon at ²³⁵TGA²³⁷ that corresponds to selenocysteine (SeC) as U₇₂. Sequence characterization revealed that HdhGPx contains a characteristic GPx signature motif 2 (₉₆LGLPCNQF₁₀₃), an active site motif (₁₇₉WNFEKF₁₈₄). In addition, two potential N-glycosylation sites (₁₁₂NGTE₁₁₅ and ₁₃₂NLTQ₁₃₅) were identified in HdhGPx. 3D modeling analysis showed that the overall structure of HdhGPx monomer had more similarity to human GPx3 than human GPx1. Relatively higher-level mRNA expression was detected in hepatopancreas, mantle and gonad by real-time PCR assays. The relative expression levels of HdhGPx mRNA in hepatopancreas and haemocytes were detected by real-time PCR in abalone fed with nine different diets containing graded levels of selenium (0.15, 1.32 and 48.7 mg kg^− 1), zinc (6.69, 33.85 and 710.63 mg kg^− 1) and iron (29.17, 65.7 and 1267.2 mg kg^− 1) for 20 weeks, respectively. The results showed that the expressions of HdhGPx mRNA were statistically higher at adequate dietary selenium (1.32 mg kg^− 1), zinc (33.85 mg kg^− 1) and iron (65.7 mg kg^− 1) than those in low dietary minerals, respectively. But HdhGPx mRNA expression levels were down-regulated by high contents of dietary selenium (48.7 mg kg^− 1), zinc (710.63 mg kg^− 1) and iron (1267.2 mg kg^− 1), respectively. These results indicated that adequate dietary minerals could increase the mRNA expression of HdhGPx, and then to increase the total antioxidant capacities in abalone.     

Hypoxia and seasonal temperature: Short-term effects and long-term implications for Acartia tonsa dana

Far more attention has been given to the short-term lethal impacts of reduced dissolved oxygen on commercially important fish and crabs than to the long-term sublethal impacts on these same species, or on lower trophic levels. This study demonstrates that chronic, sublethal effects of hypoxia on the copepod Acartia tonsa, a critical component of many pelagic coastal food webs, can lead to significant decreases in population growth. The results of laboratory experiments conducted at 15 °C (winter) and 25 °C (summer), under conditions of normoxia (Controls), sublethal hypoxia (1.5 ml l^− 1) and lethal hypoxia (0.7 ml l^− 1) show that egg production female^− 1 day^− 1 was significantly lower at 0.7 ml l^− 1 compared to Controls at both temperatures, while egg production female^− 1 day^− 1 was significantly lower at 1.5 ml l^− 1 compared to controls in both summer experiments and in one of the two winter experiments. Survival was significantly decreased in the 0.7 ml l^− 1 treatment compared to Controls and the 1.5 ml l^− 1 treatment. Copepods developed more slowly and matured at smaller adult body sizes at both temperatures under both lethal and sublethal hypoxia compared to normoxia. Under summer temperatures, egg production was reduced by hypoxia exposure on two counts: (1) exposure to hypoxia during development resulted in smaller adults, which translated into lower egg production, and (2) egg production was still significantly lower in hypoxia treatments compared to Controls even when differences in body size were taken into account. While copepods collected in winter and exposed to winter temperatures and hypoxia also matured at smaller body sizes than copepods exposed to normoxia, egg production in winter was almost entirely attributable to this reduction in body size. These results suggest that coastal hypoxia may have a significantly greater impact in the summer months, when copepod populations are most abundant and growing at their most rapid rate of the year. With the anticipated increases in global temperatures, hypoxia may have even greater impacts on pelagic food webs.     

Biohydrogen from thermophilic co-fermentation of swine manure with fruit and vegetable waste: maximizing stable production without pH control

Hydrogen production by dark fermentation may suffer of inhibition or instability due to pH deviations from optimality. The co-fermentation of promptly degradable feedstock with alkali-rich materials, such as livestock wastes, may represent a feasible and easy to implement approach to avoid external adjustments of pH.Experiments were designed to investigate the effect of the mixing ratio of fruit-vegetable waste with swine manure with the aim of maximizing biohydrogen production while obtaining process stability through the endogenous alkalinity of manure.Fruit-vegetable/swine manure ratio of 35/65 and HRT of 2 d resulted to give the highest production rate of 3.27 ± 0.51 L_H2 L⁻¹ d⁻¹, with a corresponding hydrogen yield of 126 ± 22 mL_H2 g⁻¹_VS-added and H₂ content in the biogas of 42 ± 5%. At these operating conditions the process exhibited also one of the highest measured stability, with daily productions deviating for less than 14% from the average.     

Physicochemical and spectroscopic characteristics of dissolved organic matter extracted from municipal solid waste (MSW) and their influence on the landfill biological stability

For the purpose of evaluating the stability of municipal solid waste (MSW) excavated from a landfill, dissolved organic matter was extracted and characterized by physicochemical and spectroscopic methods. Results showed that dissolved organic carbon concentration, ratio of dissolved organic carbon to dissolved organic nitrogen, and specific ultraviolet absorbance at 254 nm were in the range of 0.383-3.502 g kg⁻¹, 0.388-3.693 and 2.700-4.629 L mg⁻¹ m⁻¹, respectively, indicating the stability of MSW. Results obtained from Fourier transform infrared spectra have demonstrated that the stability of excavated MSW was characterized by disappearance of some easily biodegradable compounds; and the 1635/1406 ratio varied from 0.979 to 1.840 and was higher than that of the matured compost. The excitation-emission matrix spectra have shown that the principal components in excavated MSW comprised humic substances and the MSW was stable by the presence of a peak with wavelength pair of ∼280/420 nm.     

Biological treatment of refinery spent caustics under halo-alkaline conditions

The present research demonstrates the biological treatment of refinery sulfidic spent caustics in a continuously fed system under halo-alkaline conditions (i.e. pH 9.5; Na⁺ = 0.8 M). Experiments were performed in identical gas-lift bioreactors operated under aerobic conditions (80-90% saturation) at 35 °C. Sulfide loading rates up to 27 mmol L⁻¹ day⁻¹ were successfully applied at a HRT of 3.5 days. Sulfide was completely converted into sulfate by the haloalkaliphilic sulfide-oxidizing bacteria belonging to the genus Thioalkalivibrio. Influent benzene concentrations ranged from 100 to 600 μM. At steady state, benzene was removed by 93% due to high stripping efficiencies and biodegradation. Microbial community analysis revealed the presence of haloalkaliphilic heterotrophic bacteria belonging to the genera Marinobacter, Halomonas and Idiomarina which might have been involved in the observed benzene removal. The work shows the potential of halo-alkaliphilic bacteria in mitigating environmental problems caused by alkaline waste.