A new method of autotrophic denitrification with spent sulfidic caustic as substrate and alkalinity source

A new method based on sulfide utilizing autotrophic denitrification was adopted to remove nitrate from wastewater and to reuse spent sulfidic caustic containing high sulfide and alkalinity levels. The experiments were performed using a bench-scale upflow anoxic hybrid growth reactor (UAHGR) and an upflow anoxic suspended growth reactor (UASGR) to characterize the stoichiometric relationship between sulfur and nitrate in the process as well as the performance of the reactors. The level of nitrate removal from the UAHGR and UASGR were maintained at over 90% at a nitrate loading rate ranging from 0.15∼0.40 kgNO₃ ⁻/m³·d and no significant nitrite accumulation was observed in either reactor. Although the influent pH values were higher than the optimum range of autotrophic denitrification at 8.7∼10.1, the effluent pH was stable at 7.2∼7.9 due to the production of hydrogen ions during operation. The stoichiometric ratio of sulfate production to nitrate removal was 1.5∼2.1 mgSO₄ ²⁻/mgNO₃ ⁻ in both reactors. A comparison of the reactor performance revealed that the chemical parameters of the UAHGR operation corresponded to a plug flow like type reactor while the chemical parameters of the UASGR operation corresponded to a completely stirred tank reactor like type reactor. UAHGR did not require sludge recycling due to the packed media while UASGR required 300∼700% sludge recycling. Therefore, spent sulfidic caustic could be used in the sulfur utilizing autotrophic denitrification processes as substrate and alkalinity sources.     

Study of a combined sulfur autotrophic with proton-exchange membrane electrodialytic denitrification technology: sulfate control and pH balance

A novel combined system established for nitrate removal from aqueous solution consisted of two parts: sulfur autotrophic denitrification and bio-electrochemical denitrification based on proton-exchange membrane electrodialysis (PEMED). The system was operated at various hydraulic retention times (HRT) and current intensities. Its optimum operation condition was also determined. The combined process had pH adjustment thus generating less nitrite than PEMED process. The denitrification rate of sulfur autotrophic part was dependent on HRT, while shorter HRT could reduce the sulfate generated by the sulfur autotrophic process. The denitrification rate of PEMED process depended on the applied current. For 32 ± 1 mg-N/L nitrate in influent, the optimum operation parameters of combined process were: HRT 2 h; applied current 350 mA. The combined reactor could achieve 95.8% nitrate removal without nitrite accumulation, the pH of effluent kept neutral and the sulfate of effluent was 202.1 mg/L, lower than the drinking water standard in China.     

Kinetics of a fluidized-bed reactor for ground-water denitrification

A fluidized-bed reactor, with sand as the carrier and ethanol as the carbon and electron source, was investigated for the biological denitrification of ground water. The paper concentrates on the reactor's kinetics, with special emphasis on nitrite as the intermediate product. Intrinsic zero-order kinetic parameters for both nitrate and nitrite were determined by batch and continuous experiments. Values for the maximum specific nitrate and nitrite removal rates of 11 g and 6 g NO _inf3 ^sup– (g volatile suspended solids)^–1 day^–1, respectively, were obtained. These values were used to interpret nitrate and nitrate concentration profiles in an experimental fluidized-bed reactor operating at different conditions of hydraulic loading and retention time.     

基于响应面法对一株好氧反硝化菌脱氮效能优化

【目的】水体富营养化是当今我国水环境面临的重大水域环境问题,氮素超标排放是主要的引发因素之一。好氧反硝化菌构建同步硝化反硝化工艺比传统脱氮工艺优势更大。获得高效的好氧反硝化菌株并通过生长因子优化使脱氮效率达到最高。【方法】经过序批式生物反应器(Sequencing batch reactor,SBR)的定向驯化,筛选获得高效好氧反硝化菌株,采用响应面法优化好氧反硝化过程影响总氮去除效率的关键因子(碳氮、溶解氧、pH、温度)。【结果】从运行稳定的SBR反应器中定向筛选高效好氧反硝化菌株Pseudomonas T13,采用响应面法对碳氮比、pH和溶解氧关键因子综合优化获得在18 h内最高硝酸盐去除率95%,总氮去除率90%。该菌株的高效反硝化效果的适宜温度范围为25?30 °C;最适pH为中性偏碱;适宜的COD/NO3?-N为4:1以上;最佳溶解氧浓度在2.5 mg/L。【结论】从长期稳定运行的SBR反应器中筛选获得一株高效好氧反硝化菌Pseudomonas T13,硝酸盐还原酶比例占脱氮酶基因的30%以上,通过运行条件优化获得硝氮去除率达到90%以上,对强化废水脱氮工艺具有良好应用价值。     

Autotrophic denitrification using hydrogen generated from metallic iron corrosion

Hydrogenotrophic denitrification was demonstrated using hydrogen generated from anoxic corrosion of metallic iron. For this purpose, a mixture of hydrogenated water and nitrate solution was used as reactor feed. A semi-batch reactor with nitrate loading of 2000 mg m⁻³ d⁻¹ and hydraulic retention time (HRT) of 50 days produced effluent with nitrate concentration of 0.27 mg N L⁻¹ (99% nitrate removal). A continuous flow reactor with nitrate loading of 28.9 mg m⁻³ d⁻¹ and HRT of 15.6 days produced effluent with nitrate concentration of ∼0.025 mg N L⁻¹ (95% nitrate removal). In both cases, the concentration of nitrate degradation by-products, viz., ammonia and nitrite, were below detection limits. The rate of denitrification in the reactors was controlled by hydrogen availability, and hence to operate such reactors at higher nitrate loading rates and/or lower HRT than reported in the present study, hydrogen concentration in the hydrogenated water must be significantly increased.     

Nitrite inhibition of denitrification by Pseudomonas fluorescens

Using a pure culture of Pseudomonas fluorescens as a model system nitrite inhibition of denitrification was studies. A mineral media with acetate and nitrate as sole electron donor and acceptor, respectively, was used. Results obtained in continuous stirred-tank reactors (CSTR) operated at pH values between 6.6 and 7.8 showed that growth inhibition depended only on the nitrite undissociated fraction concentration (nitrous acid). A mathematical model to describe this dependence is put forward. The maximum nitrous acid concentration compatible with cell growth and denitrification activity was found to be 66 mug N/L. Denitrification activity was partially associated with growth, as described by the Luedeking-Piret equation. However, when the freshly inoculated reactor was operated discontinuosly, nitrite accumulation caused growth uncoupling from denitrification activity. The authors suggest that these results can be interpreted considering that (a) nitrous acid acts as a proton uncoupler; and (b) cultures continuoulsy exposed to nitrous acid prevent the uncoupling effect but not the growth inhibition. Examination of the growth dependence on nitrite concentration at pH 7.0 showed that adapted cultures (grown on CSTR) are less sensitive to nitrous acid inhibition than the ones cultivated in batch. (c) 1995 John Wiley & Sons, Inc.     

Simultaneous nitrification and denitrification in a mixed methanotrophic culture

Simultaneous nitrification and denitrification using a mixed methanotrophic culture was investigated. When both NO₃ ^–-N (108 mg l^–1) and NH₃-N (59 mg l^–1) were added into batch reactors, nitrate removal was complete within 10 h at the rate of 47 mg NO₃ ^–-N g VSS^–1 day^–1 when dissolved oxygen (DO) concentration was maintained at 2 mg DO l^–1. Ammonia removal started simultaneously with nitrate removal at a slower rate of 14 NH₃-N g VSS^–1 day^–1. No significant accumulation of nitrite or nitrate during ammonia utilization suggested the occurrence of simultaneous nitrification and denitrification.     

Nitrite reduction by a mixed culture under conditions relevant to shortcut biological nitrogen removal

Dissimilative reduction of nitrite by nitrite-acclimated cellswas investigated in a batch reactor under various environmental conditions that can beencountered in shortcut biological nitrogen removal (SBNR: ammonia to nitrite andnitrite to nitrogen gas). The maximum specific nitrite reduction rate was as much as 4.3 times faster than the rate of nitrate reduction when individually tested, but the reaction was inhibited in the presence of nitrate when the initial nitrate concentration was greater than approximately 25 mg-N/l or the initialNO ₃ ^- N/NO ₂ ^- N ratio was larger than 0.5. Nitrite reduction was also inhibited by nitrite itself when theconcentration was higher than that to which the cells had been acclimated. Therefore, it was desirable to avoid excessively high nitrite and nitrate concentrations in a denitrification reactor. Nitrite reduction, however, was not affected by an alkaline pH (in the range of 7–9) or a high concentration of FA (in the range of 16–39 mg/l), which can be common in SBNR processes. The chemical oxygen demand (COD) requirement for nitrite reduction was approximately 22–38% lower than that for nitrate reduction, demonstrating that the SBNR process can be economical. The specific consumption,measured as the ratio of COD consumed to nitrogen removed, was affected by the availability of COD and the physiological state of the cells. The ratio increased when the cells grew rapidly and were storing carbon and electrons.     

Effects of temperature on simultaneous nitrification and denitrification via nitrite in a sequencing batch biofilm reactor

A laboratory scale experiment was described in this paper to enhance biological nitrogen removal by simultaneous nitrification and denitrification (SND) via nitrite with a sequencing batch biofilm reactor (SBBR). Under conditions of total nitrogen (TN) about 30 mg/L and pH ranged 7.15–7.62, synthetic wastewater was cyclically operated within the reactor for 110 days. Optimal operation conditions were established to obtain consistently high TN removal rate and nitrite accumulation ratio, which included an optimal temperature of 31 °C and an aeration time of 5 h under the air flow of 50 L/h. Stable nitrite accumulation could be realized under different temperatures and the nitrite accumulation ratio increased with an increase of temperature from 15 to 35 °C. The highest TN removal rate (91.9%) was at 31 °C with DO ranged 3–4 mg/L. Process control could be achieved by observing changes in DO and pH to judge the end-point of oxidation of ammonia and SND.     

The integration of methanogenesis with shortcut nitrification and denitrification in a combined UASB with MBR

A combined system consisting of an up-flow anaerobic sludge blanket (UASB) and an aerobic membrane bioreactor (MBR) was operated at 28-30 degrees C and pH 7.8-8.1 for the treatment of low-strength synthetic wastewater enriched with organic carbon and NH4Cl. The MBR slurry was recirculated into the UASB with a ratio of 50-800%. It was found that nitrite was able to accumulate steadily during the nitrification step in the MBR at a low TOC/NH4+-N ratio. The mixed liquid containing NOX(-)-N in the MBR was recirculated to the UASB, and denitrification rather than methanogenesis became the preferred pathway. Whereas, the less carbon requirement for denitrification via nitrite rather than nitrate allowed methanogenesis to proceed simultaneously in the same reactor. The combination of membrane filtration and partial nitrification in the MBR with simultaneous denitrification and methanogenesis in the UASB could stably reach 98% TOC removal and 48.1-82.8% TN removal with recirculation ratio increasing from 50% to 800%.     

Post-treatment of fish canning effluents by sequential nitrification and autotrophic denitrification processes

In this research study a nitrifying/autotrophic denitrifying system was used for the post-treatment of an effluent coming from an anaerobic digester treating the wastewater produced in a fish canning industry. The nitrifying reactor achieved 100% of ammonia oxidation into nitrate. The effluent from this unit was fed to the autotrophic denitrifying reactor which treated a maximum sulphide loading rate (SLR) of 200 mg S^2?/L d with removal percentages of 100% and 30% for sulphide and nitrate, respectively. The low nitrate removal efficiency is attributed to sulphide limitations.The operational costs of this system were estimated as 0.92 €/kg N_removed, lower than those for conventional nitrification/denitrification processes. For nitrogen removal the SHARON/anammox processes is the cheapest option. However the combination of nitrification and autotrophic denitrification (using elemental sulphur) processes would present a better operational stability compared to the SHARON/anammox system.     

Simultaneous nitrification,denitrification, and phosphorus removal in a lab-scale sequencing batch reactor

Simultaneous nitrification and denitrification (SND) via the nitrite pathway and anaerobic-anoxic-enhanced biological phosphorus removal (EBPR) are two processes that can significantly reduce the energy and COD demand for nitrogen and phosphorus removal. The combination of these two processes has the potential of achieving simultaneous nitrogen and phosphorus removal with a minimal requirement for COD. A lab-scale sequencing batch reactor (SBR) was operated in alternating anaerobic-aerobic mode with a low dissolved oxygen (DO) concentration (0.5 mg/L) during the aerobic period, and was demonstrated to accomplish nitrification, denitrification, and phosphorus removal. Under anaerobic conditions, COD was taken up and converted to polyhydroxyalkanoates (PHAs), accompanied by phosphorus release. In the subsequent aerobic stage, PHA was oxidized and phosphorus was taken up to <0.5 mg/L by the end of the cycle. Ammonia was also oxidized during the aerobic period, but without accumulation of nitrite or nitrate in the system, indicating the occurrence of simultaneous nitrification and denitrification. However, off-gas analysis showed that the final denitrification product was mainly nitrous oxide (N(2)O), not N(2). Further experimental results demonstrated that nitrogen removal was via nitrite, not nitrate. These experiments also showed that denitrifying glycogen-accumulating organisms (DGAOs), rather than denitrifying polyphosphate-accumulating organisms (DPAOs), were responsible for the denitrification activity.     

The denitrification capability of cluster 1 Defluviicoccus vanus-related glycogen-accumulating organisms

The denitrification capability of Cluster 1 Defluviicoccus vanus-related glycogen-accumulating organisms (DvGAOs) is investigated. A sequencing batch reactor (SBR) fed with acetate as the sole carbon source was operated under alternating anaerobic-aerobic conditions to enrich Cluster 1 DvGAOs. Fluorescence in situ hybridization (FISH) showed that more than 85% of the bacterial population present in the reactor bound to the probes previously designed for Cluster 1 DvGAOs. A series of batch tests were performed to evaluate the capability of the community to reduce nitrate and nitrite. The tests were carried out both before and after the adaptation of the culture to anoxic conditions, and with both the intracellularly stored carbon and acetate as the electron donors. It was found that Cluster 1 DvGAOs were able to reduce nitrate but most likely unable to reduce nitrite. When un-adapted Cluster 1 DvGAOs were exposed to nitrate for the first time, a lag phase of approximately 4 h occurred, which was likely required for the synthesis of the necessary enzymes.     

Heterotrophic nitrification and aerobic denitrification inAlcaligenes faecalis strain TUD

Heterotrophic nitrification and aerobic and anaerobic denitrification byAlcaligenes faecalis strain TUD were studied in continuous cultures under various environmental conditions. Both nitrification and denitrification activities increased with the dilution rate. At dissolved oxygen concentrations above 46% air saturation, hydroxylamine, nitrite and nitrate accumulated, indicating that both the nitrification and denitrification were less efficient. The overall nitrification activity was, however, essentially unaffected by the oxygen concentration. The nitrification rate increased with increasing ammonia concentration, but was lower in the presence of nitrate or nitrite. When present, hydroxylamine, was nitrified preferentially. Relatively low concentrations of acetate caused substrate inhibition (K_I=109 M acetate). Denitrifying or assimilatory nitrate reductases were not detected, and the copper nitrite reductase, rather than cytochrome cd, was present. Thiosulphate (a potential inhibitor of heterotrophic nitrification) was oxidized byA. faecalis strain TUD, with a maximum oxygen uptake rate of 140–170nmol O₂·min^-1·mg prot^-1. Comparison of the behaviour ofA. faecalis TUD with that of other bacteria capable of heterotrophic nitrification and aerobic denitrification established that the response of these organisms to environmental parameters is not uniform. Similarities were found in their responses to dissolved oxygen concentrations, growth rate and ammonia concentration. However, they differed in their responses to externally supplied nitrite and nitrate.     

Autotrophic denitrification via a novel membrane-attached biofilm reactor

AIMS: A laboratory-scale autotrophic membrane-attached biofilm reactor was developed to remove nitrate from drinking water. METHODS AND RESULTS: Hydrogen and carbon dioxide flowed together into the lumem side of a gas-permeable silicone tube. The gases diffused through the membrane wall to feed Alcaligenes eutrophus that formed a biofilm on the surface of the silicone tube for autotrophic denitrification. Hydrogen provided the energy source, and carbon dioxide, besides serving as the carbon source, was employed to neutralize the alkalinity from denitrification. The optimal carbon dioxide concentration in the silicone tube was between 20% and 50%. CONCLUSION: This study has demonstrated that a gas-permeable silicone tube is a convenient and efficient method to feed A. eutrophus for autotrophic denitrification. Supplying a suitable amount of carbon dioxide together with hydrogen into the silicone tube solved the problem that alkalinity formation caused during denitrification. The pH of the bioreactor was maintained at about 7 to avoid nitrite accumulation, and then the nitrogen removal rate was increased. A high specific nitrogen removal rate (1.6-5.4 g Nm(2)d(-1-1) of surface area of silicone tube) was achieved. SIGNIFICANCE AND IMPACT OF THE STUDY: In addition to combining the advantages of the hydrogenotrophic denitrification process and a membrane feeding substrate bioreactor (MFSB), this bioreactor achieved a high nitrogen removal rate and is simple to operate. It therefore is highly promising in drinking-water treatment.     

Membrane bioreactor for drinking water denitrification

The aim of this study is to evaluate the performance of a membrane bioreactor with cell recycle to be used for drinking water denitrification, when operated with a high nitrate load (up to 7.68?kgNO₃ ^?/m³?day) and low hydraulic retention time (down to 0.625?h). Nitrate and nitrite were always completely removed for all the operational conditions used. The effluent's nitrite concentration kept below 0.1?mg NO₂ ^?/l with exception of a short period, during the reactor start-up, when it accumulates. The performance of the membrane bioreactor was also evaluated using a groundwater containing 148?mg NO₃ ^?/l. Nitrate and nitrite concentration in the effluent were below the recommended values for drinking water when the reactor was controlled at pH 7.0. The membrane flux decreases during operation as a consequence of membrane fouling. The flux decrease was more severe during operation with synthetic medium than with contaminated groundwater due to the existence of molecular complexes in the synthetic broth. A backshock technique was used to reduce the surface fouling of the membrane. Combining this technique with the use of a reserve asymmetric structured membrane it was found that the membrane flux remains nearly unchanged.     

Concurrent nitrite oxidation and aerobic denitrification in activated sludge exposed to volatile fatty acids

The goal of this research was to investigate the simultaneous occurrence of nitrification and denitrification by activated sludge exposed to volatile fatty acids (VFAs) during aerobic wastewater treatment using a single-stage reactor. A mixture of VFAs was spiked directly into a continuous-stirred tank reactor (CSTR) to assess subsequent impacts on nitrite removal, nitrate formation, CO(2) fixation, total bacterial density, and dominant nitrite oxidizing bacteria (NOB) concentration (i.e., Nitrospira). The activity of the periplasmic nitrate reductase (NAP) enzyme and the presence of nap gene were also measured. A rapid decrease in the nitrate formation rate (>70% reduction) was measured for activated sludge exposed to VFAs; however, the nitrite removal rate was not reduced. The total bacterial density and Nitrospira concentration remained essentially constant; therefore, the reduction in nitrate formation rate was likely not due to heterotrophic uptake of nitrogen or to a decrease in the dominant NOB population. Additionally, VFA exposure did not impact microbial CO(2) fixation efficiency. The activity of NAP enzyme increased in the presence of VFAs suggesting that nitrate produced as a consequence of nitrite oxidation was likely further reduced to gaseous denitrification products via catalysis by NAP. Little, if any, nitrogen was discharged in the aqueous effluent of the CSTR after exposure to VFAs demonstrating that activated sludge treatment yielded compounds other than those typically produced solely by nitrification.     

Dichloromethane as the sole carbon source forHyphomicrobium sp. strain DM2 under denitrification conditions

Hyphomicrobium sp. strain DM2 was found to grow anaerobically in the presence of nitrate with methanol, formaldehyde, formate or dichloromethane. The estimated growth rate constants with methanol and dichloromethane under denitrification conditions were 0.04 h^–1 and 0.015 h^–1, respectively, which is twofold and fourfold lower than the rates of aerobic growth with these substrates. Slight accumulation of nitrite was observed in all cultures grown anaerobically with nitrate. Dichloromethane dehalogenase, the key enzyme in the utilization of this carbon source, was induced under denitrification conditions to the same specific activity level as under aerobic conditions. In a fed batch culture under denitrification conditionsHyphomicrobium sp. DM2 cumulatively degraded 35 mM dichloromethane within 24 days. This corresponds to a volumetric degradation rate of 5 mg dichloromethane/l·h and demonstrates that denitrificative degradation offers an attractive possibility for the development of anaerobic treatment systems to remove dichloromethane from contaminated groundwater.     

Hydrogenotrophic denitrification of synthetic aquaculture wastewater using membrane bioreactor

A hydrogenotrophic denitrification system was evaluated in removing nitrate from synthetic aquaculture wastewater for recirculation purposes. Two membrane bioreactor (MBR) systems, namely, aeration–denitrification system (ADS) and denitrification–aeration system (DAS) were studied with 50 mg/L of influent concentrations for both organic matter and nitrate nitrogen. The DAS achieved better removal efficiency of 91.4% total nitrogen (T-N) and denitrification rate of 363.7 mg/L.day at a HRT of 3 h compared to ADS. Further, there was no nitrite accumulation in the DAS effluent. The nitrite accumulation in ADS effluent was lesser when CO₂ was used as buffer rather than K₂HPO₄ and KH₂PO₄. Estimation of kinetic parameters of hydrogenotrophic bacteria indicated lesser sludge production compared to heterotrophic denitrification. In the DAS, membrane fouling was nonexistent in the aeration reactor that was used to produce the recirculating effluent. On the contrary, membrane fouling was observed in the denitrification reactor that supplied hydrogen to the mixed liquor. Thus, this study demonstrated DAS capability in maintaining the acceptable water quality appropriate for aquaculture, in which a closed recirculating system is typically used.