碱预处理玉米芯米根霉同步糖化发酵产富马酸

以碱预处理玉米芯渣为原料,采用单因素优化方法优化米根霉同步糖化发酵产富马酸。在此基础上,研究米根霉利用碱预处理玉米芯渣的同步糖化发酵,并与纯糖发酵进行对比。结果表明:在50 g/L底物、(NH4)2SO4质量浓度0.71 g/L、纤维素酶用量20 FPIU(以1 g纤维素计)、Ca CO3加入量30 g/L、接种量10%(体积分数)和装液量50 m L的条件下,米根霉同步糖化发酵过程产富马酸13.78 g/L,而纯糖发酵富马酸生成量仅6.21 g/L。     

Comparison of fumaric acid production by Rhizopus oryzae using different neutralizing agents

Fumaric acid fermentation in a 10-L bubble column fermenter using different neutralizing agents [CaCO(3), Ca(OH)(2), NaHCO(3)] by Rhizopus oryzae ATCC 20344 was examined. It was found that in the fermentation using CaCO(3 )as the neutralizing agent the highest fumaric acid weight yield and volumetric productivity were obtained, 53.4% and 1.03 g/L x h(-1) respectively. In the NaHCO(3) case, the fumaric acid weight yield and volumetric productivity were 33.7% and 0.69 g/L x h(-1), respectively, much lower than the CaCO(3) case. However, the NaHCO(3) alternative has advantages of cell reuse and simple downstream processing because of the high solubility of sodium fumarate. These advantages may offset the disadvantages of using NaHCO(3) as the neutralizing agent, and the overall fumaric acid weight yield and volumetric productivity will increase.     

A novel multi-stage preculture strategy of Rhizopus oryzae ME-F12 for fumaric acid production in a stirred-tank reactor

This study has developed a novel multi-stage preculture strategy to control the morphology of filamentous Rhizopus oryzae in a 3.3-l stirred-tank reactor (STR), consequently enhancing the fumaric acid production. Using multi-stage precultures as inoculum, the morphology of R. oryzae was maintained as large clumps, small fluffy pellets, and entangled filaments. The highest fumaric acid production of 42.5 g/l with a yield of 55.6% was obtained in association with the small fluffy pellets which were formed in the third preculture at pH 3.0. The results indicated that the use of the multi-stage precultures as inoculum in the STR is a promising approach for commercial production of fumaric acid.     

米根霉ME—F12发酵产富马酸的菌体形态控制

丝状真菌发酵体系中菌体形态对产量有着重要影响。考察富马酸产生菌Rhizopus oryzae ME—F12种子培养过程中不同pH条件、孢子悬浮液密度以及CaCl2添加量对其形态的影响。结果表明,当控制种子培养液pH2．3～2．7、接种孢子的终密度为1．5×10^8～3．0×10^8／L和添加0．5g／LCaCl2时,培养可获得直径约为0．65mm光滑规整茵球,后继的产酸发酵中富马酸量高达58．9g／L。正交实验表明,pH是影响菌球形成的最主要因素,孢子液密度主要影响菌体生物量,而CaCl2则是菌球表面光滑度的主要影响因素。     

米根霉发酵生产L-乳酸

报道了Ｌ－乳酸菌株的分离与筛选,探讨了不同碳源、氮源、通气量、温度等发酵条件对产Ｌ－乳酸的影响,从７８株米根霉中筛选出１３株产Ｌ－乳酸较高的菌株,其中米根霉（Ｒｈｉｚｏｐｕｓ ｏｒｙｚａｅ）Ｒｓ９２８产Ｌ－乳酸最高,产酸最稳定。试验结果表明,该菌株最适发酵培养组成（％）：淀粉水解糖１６,ＭｇＳＯ４ ０．０８,ＫＨ２ＰＯ４ ０．０５,ＺｎＳＯ４ ０．０１,ＣａＣＯ３ ７,ｐＨ自然。在６０ｔ发酵罐中,     

基于Desirability函数法对米根霉发酵制备富马酸的多目标优化

以富马酸产量和生产速率为目标,通过正交实验考察了种龄,接种量,葡萄糖和尿素浓度对两者的影响,进一步利用基于响应曲面方法的Desirability函数确定了葡萄糖和尿素的最佳浓度。结果表明,最佳的种龄和接种量分别为36h和15%,葡萄糖和尿素的优化浓度为132.73和0.0586g/l,此时模型预测的富马酸产量和生产速率达到71.42g/l和0.804g/(l.h),Desirability的函数值高达0.966。该条件下在5L发酵罐水平上进行验证试验,经过88h的发酵最终生成富马酸66.5g/l,生产速率达到0.755 g/(l.h),与未优化前相比,产量和生产速率分别提高了13.9%和15.8%,取得了理想的效果,实现了产量和生产速率的同时优化,为发酵法制备富马酸的工业化放大奠定了基础。     

米根霉交替呼吸途径高活性突变株的选育及其对富马酸合成的影响

米根霉交替呼吸强度与富马酸合成之间存在重要关联。以米根霉F-14为出发菌株,通过常压室温等离子体(ARTP)离子诱变技术,筛选出1株交替呼吸强度增强的突变菌株S-1。该菌株的交替呼吸初始强度是出发菌株F-14的3.5倍,然而,该菌株富马酸积累量(28 g/L)却远低于出发菌株(42 g/L)。进一步考察突变株S-1和出发株F-14菌株在发酵过程中交替呼吸及富马酸生产强度,总呼吸变化和还原力NADH/NAD+的变化。结果表明:突变株在富马酸发酵初始阶段,过高的交替呼吸强度反而降低了富马酸的生产速率,并导致了发酵后期菌体的早衰现象。交替呼吸强度与发酵进程存在适配性,只有当适配性达到最佳状态时,才有利于产物的高效积累。     

Potential of solid state fermentation for production of L(+)-lactic acid by Rhizopus oryzae

Production of l(+)-lactic acid by Rhizopus oryzae NRRL 395 was studied in solid medium on sugar-cane bagasse impregnated with a nutrient solution containing glucose and CaCO₃. A comparative study was undertaken in submerged and solid-state cultures. The optimal concentrations in glucose were 120 g/l in liquid culture and 180 g/l in solid-state fermentation corresponding to production of l(+)-lactic acid of 93.8 and 137.0 g/l, respectively. The productivity was 1.38 g/l per hour in liquid medium and 1.43 g/l per hour in solid medium. However, the fermentation yield was about 77% whatever the medium. These figures are significant for l(+)-lactic acid production.     

Lactic acid production by loofah-immobilized Rhizopus oryzae through one-step fermentation process using starch substrate

Rhizopus oryzae PTCC 5263 capacity in synthesis of lactic acid (LA) from 10 g/l of soluble potato starch was determined using one-step fermentation process. Pellets were the favorable growing form of the free cells. The extent of the natural ability of the test fungus on biofilm formation on loofah sponge was examined by immobilizing R. oryzae (LIRO). The maximum LA concentration for the free cells and LIRO within 96 h was 3 and 4 g/l, respectively. In terms of specific starch utilization rate (\(q_{\text{s}}\)) and specific LA formation (\(q_{\text{p}}\)), LIRO performed more favorably compared to the free cells (\(q_{{{\text{s}}_{\text{F}} }} > q_{{{\text{s}}_{\text{LIRO}} }}\) and \(q_{{{\text{p}}_{\text{F}} }} < q_{{{\text{p}}_{\text{LIRO}} }}\)). Cell immobilization strategy was undertaken for the column reactor studies based on the statistically optimized levels of the inoculum size and temperature. Maximum production of the LA by the LIRO using an airlift reactor with net draft tube was 5 g/l obtainable within 48 h.

     

Lactic acid and animal feeds production from Sophora flavescens residues by Rhizopus oryzae fermentation

In this study, the feasibility of producing lactic acid and animal feeds from Sophora flavescens residues (SFR) by Rhizopus oryzae was explored. Results showed that the simultaneous saccharification and fermentation (SSF) is the optimal fermentation mode, which was simple and high-efficiency. When the inoculation volume of R. oryzae was 10 % and the pH value was adjusted by adding CaCO₃ in stages during SSF, the maximum concentration of lactic acid was 46.78 g/L, and the maximum lactic acid productivity reached 0.97 g/L/h. Results also showed that the protein content of the solid residues after fermentation of R. oryzae reached 12.15 %. This content was 46 times higher than that by the original SFRs and nearly 4.3 times the protein content of the solid residues after fermentation by Enterococcus faecium. In addition, the solid residues after fermentation rich in Fe and Zn could be used as animal feeds or feed additives. Thus, it is expected that this study may provide a novel approach for Chinese medicine residues treatment towards full resource recovery.     

Reducing by-product formation in L-lactic acid fermentation by Rhizopus oryzae

During L-lactic acid fermentation by Rhizopus oryzae, increasing the phosphate level in the fermentation medium from 0.1 g l^–1 to 0.6 g l^–1 KH₂PO₄ reduced the maximal concentration of L-lactic acid and fumaric acid from 85 g l^–1 to 71 g l^–1 and from 1.36 g l^–1 to 0.18 g l^–1, respectively; and it decreased the fermentation time from 72 h to 52 h. Phosphate at 0.40 g l^–1 KH₂PO₄ was suitable for both minimizing fumaric acid accumulation and benefiting L-lactic acid production.     

Optimization of fumaric acid production from potato flour by Rhizopus arrhizus

Summary Fumaric acid production by Rhizopus arrhizus from potato flour was studied at different initial substrate concentrations (S), C/N ratios and fermentation times (t f) in a composite design experiment. By using response surface methodology and canonical analysis, the experimental values of fumaric acid and mycelial biomass yields and productivity were fitted to the only statistically significant factors with mean percentage errors of 11, 26 and 13%, respectively. Owing to the limited statistical significance of the C/N ratio, it was possible to determine the values of S (25–50 g/l of glucose equivalent) and t f(44–100 h) associated with fumaric acid yields ranging from 60 to 75% and productivities varying from 6 to 8.4 g/l per day. Since such results were in quite good agreement with previous experiments carried out on other starchy materials, the above operating conditions might be used to minimize fumaric acid production costs as a function of the feed-stock used. Offsprint requests to: M. Moresi     

Key technologies for the industrial production of fumaric acid by fermentation

The growing concern about the safety of food and dairy additives and the increasing costs of petroleum-based chemicals have rekindled the interest in the fermentation processes for fumaric acid production. The key problems of the industrial production of microbial fumaric acid are reviewed in this paper. Various strategies, including strain improvement, morphology control, substrate choice, fermentation process and separation process, are summarized and compared, and their economical possibilities for industrial processes are discussed. The market prospects and technological strategies for value-added fumaric acid derivatives are also addressed. The future prospects of microbial fumaric acid production are proposed at the end of this article.     

米根霉菌球特性对乳酸发酵的影响

摘要:【目的】考察了接种量、蛋白胨和CaCO3浓度对菌球特性(形态、大小、密度和内部结构)的影响,并结合菌球内部结构深入剖析了菌球特性对乳酸发酵的影响。【方法】将孢子液接入到含不同蛋白胨和CaCO3浓度的种子培养基,控制不同的初始孢子浓度,培养36 h,用图像分析软件进行菌球内部聚集形态结构分析,并进行乳酸发酵。【结果】结果表明,接种量是影响菌球形成以及大小的重要因素,接种量越大,菌球直径越小;蛋白胨浓度对菌球密度影响最大,浓度越高密度越大;CaCO3浓度主要影响孢子萌发以及菌丝分枝频率。【结论】菌球密度是影响乳酸产量最显著的因素,低密度的菌球易形成较薄外层和内部菌丝松散或者中空的结构,乳酸产量低,乳酸产量随着密度而增加,当密度增大到50－60 kg/m3时,菌球内部形成外层较厚且紧密程度分布均一和内部较为松散的结构,此时乳酸产量最大;当密度过大时,菌球内部结构致密,影响传氧传质,导致产量下降。     

Lactic acid fermentation of potato pulp by the fungus Rhizopus oryzae

Production of molecules with toxic activity by genetically transformed symbiotic bacteria of pest insects may serve as a powerful approach to biological control. The symbiont, Enterobacter gergoviae, isolated from the gut of the pink bollworm (PBW), has been transformed to express Cyt1A, a cytolytic protein toxin lethal to mosquito and black fly larvae, as a model system. These transgenic bacteria might be used to spread genes encoding insecticidal proteins to populations of agricultural insects or as replacement for chemical insecticides such as malathion used in bait formulation to control specific insect pests, because of extreme public pressure against organophosphate pesticide spraying. Received: 27 November 2000 / Accepted: 29 December 2000     

Isoenzyme pattern and subcellular localisation of enzymes involved in fumaric acid accumulation by Rhizopus oryzae

Summary Electrophoretic studies of fumarase and nicotine adenine dinucleotide (NAD)-malate dehydrogenase were carried out in the fumaric acid-accumulating fungus Rhizopus oryzae. The analyses revealed two fumarase isoenzymes, one localised solely in the cytosol and the other found both in the cytosol and in the mitochondrial fraction. The activity of the cytosolic isoenzyme of fumarase was higher during the acid production stage than during growth. Addition of cycloheximide inhibited fumaric acid production and decreased the activity of the cytosolic isoenzyme of fumarase. These results suggested that de novo protein synthesis is required for increase in the activity of the cytosolic isoenzyme and that such an increase in activity is essential for fumaric acid accumulation. Three distinct isoenzymes of NAD-malate dehydrogenase could be detected in R. oryzae. No changes were observed in the isoenzyme pattern of malate dehydrogenase during fumaric acid production.     

Direct fermentation of potato starch wastewater to lactic acid by Rhizopus oryzae and Rhizopus arrhizus

The biochemical kinetic of direct fermentation for lactic acid production by fungal species of Rhizopus arrhizus 3,6017 and Rhizopus oryzae 2,062 was studied with respect to growth pH, temperature and substrate. The direct fermentation was characterized by starch hydrolysis, accumulation of reducing sugar, and production of lactic acid and fungal biomass. Starch hydrolysis, reducing sugar accumulation, biomass formation and lactic acid production were affected with the variations in pH, temperature, and starch source and concentration. A growth condition with starch concentration approximately 20 g/l at pH 6.0 and 30°C was favourable for both starch saccharification and lactic acid fermentation, resulting in lactic acid yield of 0.87–0.97 g/g starch associated with 1.5–2.0 g/l fungal biomass produced in 36 h fermentation. R. arrhizus 3,6017 had a higher capacity to produce lactic acid, while R. oryzae 2,062 produced more fungal biomass under similar conditions.