Attached culture of Nannochloropsis oculata for lipid production

The influences of urea, nitrate and glycine with four concentration levels on attached culture of Nannochloropsis oculata were investigated. The organic nitrogen source glycine was effective on improving not only adhesion biomass productivity but also adhesion rate. The maximum adhesion biomass productivity of 15.76 ± 0.52 g m^?2 day^?1 with adhesion rate of 76.67 ± 0.42 % was achieved with 18 mM glycine. To increase the lipid production, three lipid enhancing strategies were conducted afterwards, including nitrogen starvation, high light, and the combination of nitrogen starvation and high light. In nitrogen starvation situation, although the lipid content was greatly increased, the adhesion biomass productivity dropped probably due to the low cell viability. Increasing light intensity was effective on enhancing both adhesion biomass productivity and lipid content. The results indicated that nitrogen starvation was effective on improving both lipid content and adhesion rate when high light was applied. The maximum lipid yield of 4.32 ± 0.14 g m^?2 day^?1 with adhesion biomass productivity of 21.32 ± 0.65 g m^?2 day^?1, adhesion rate of 86.81 ± 0.10 % and lipid content of 20.24 ± 0.06 % was achieved with the combination strategy.     

圆红冬孢酵母两阶段培养法生产微生物油脂

为缩短发酵时间,减少原料消耗,采用细胞增殖和油脂积累分离的两阶段模式,培养圆红冬孢酵母Rhodosporidium toruloides AS 2.1389生产微生物油脂。结果表明,细胞增殖阶段获得的R.toruloides AS 2.1389细胞,重悬接种在葡萄糖溶液中,可快速积累油脂,菌体油脂含量超过自身干重的55%。增殖阶段细胞的菌龄越高,产油能力越强。油脂积累阶段使用高浓度葡萄糖溶液或未灭菌的葡萄糖溶液,油脂合成可以有效进行。油脂中脂肪酸成分以含16和18个碳原子的长链脂肪酸为主,可作为制备生物柴油的新型原料。     

Enhanced lipid production in Nannochloropsis sp. using fluorescence‐activated cell sorting

To advance the utilization of microalgae as a viable feedstock for biodiesel production, the intracellular lipid content of three strains of the marine microalgae Nannochloropsis sp. was enhanced using flow cytometry (FC) coupled with cell sorting. Total lipid content was doubled to 55% (biomass dry weight) in the sorted, daughter cells of Nannochloropsis (strain 47) after consecutive three rounds of cell sorting, and this trait was maintained for approximately 100 subsequent cell generations. In addition, daughter cells had a fatty acid profile similar to that of the parent, wild‐type strain. The study demonstrates that FC coupled with cell sorting is a powerful tool for the enhancement of intracellular lipid content in microalgae exploited for biodiesel feedstock.     

Optimisation of biomass and lipid production by adjusting the interspecific competition mode of Dunaliella salina and Nannochloropsis gaditana in mixed culture

The high cost of algal cultivation has been a barrier associated with the commercialisation of algal biodiesel. Therefore, this study aimed to enhance lipid production by optimising the nutrient supply to benefit the coexistence of Dunaliella salina and Nannochloropsis gaditana. The effects on biomass and lipid production of using different proportions of D. salina and N. gaditana, urea and NaHCO₃ were optimised by response surface method with a 17-run Box–Behnken design. The optimal conditions for the algal growth are 58 % of D. salina in the mixture at OD₆₈₀, 150 μL day^?1 urea (0.0044 g day^?1) and no addition of NaHCO₃. The biomass concentration and lipid production reached 1.00 and 0.383 g L^?1, respectively, which are exceeded by the amount before optimisation, indicating the efficiency of the model obtained by response surface method.     

The effect of light, salinity, and nitrogen availability on lipid production by Nannochloropsis sp

We examined responses of batch cultures of the marine microalga Nannochloropsis sp. to combined alterations in salinity (13, 27, and 40 g/l NaCl) and light intensity (170 and 700 μmol photons/m²·s). Major growth parameters and lipid productivity (based on total fatty acid determination) were determined in nitrogen-replete and nitrogen-depleted cultures of an initial biomass of 0.8 and 1.4 g/l, respectively. On the nitrogen-replete medium, increases in light intensity and salinity increased the cellular content of dry weight and lipids due to enhanced formation of triacylglycerols (TAG). Maximum average productivity of ca. 410 mg TFA/l/d were obtained at 700 μmol photons/m²·s and 40 g/l NaCl within 7 days. Under stressful conditions, content of the major LC-PUFA, eicosapentaenoic acid (EPA), was significantly reduced while TAG reached 25% of biomass. In contrast, lower salinity tended to improve major growth parameters, consistent with less variation in EPA contents. Combined higher salinity and light intensity was detrimental to lipid productivity under nitrogen starvation; biomass TFA content, and lipid productivity amounted for only 33% of DW and ca. 200 mg TFA/l/day, respectively. The highest biomass TFA content (ca. 47% DW) and average lipid productivity of ca. 360 mg TFA/l/day were achieved at 13 g/l NaCl and 700 μmol photons/m²·s. Our data further support selecting Nannochloropsis as promising microalgae for biodiesel production. Moreover, appropriate cultivation regimes may render Nannochloropsis microalgae to produce simultaneously major valuable components, EPA, and TAG, while sustaining relatively high biomass growth rates.     

Optimization of a flat plate glass reactor for mass production of Nannochloropsis sp. outdoors

The relationships between areal (g m(-2) per day) and volumetric (g l(-1) per day) productivity of Nannochloropsis sp. as affected by the light-path (ranging from 1.3 to 17.0 cm) of a vertical flat plate glass photobioreactor were elucidated. In general, the shorter the length of the light-path (LP), the smaller the areal volume and the higher the volumetric productivity. The areal productivity in relation to the light-path, in contrast, yielded an optimum curve, the highest areal productivity was obtained in a 10 cm LP reactor, which is regarded, therefore, optimal for mass production of Nannochloropsis. An attempt was made to identify criteria by which to assess the efficiency of a photobioreactor in utilizing strong incident energy. Two basic factors which relate to reactor efficiency and its cost-effectiveness have been defined as (a) the total illuminated surface required to produce a set quantity of product and (b) culture volume required to produce that quantity. As a general guide line, the lower these values are, the more efficient and cost-effective the reactor would be. An interesting feature of this analysis rests with the fact that an open raceways is as effective in productivity per illuminated area as a flat-plate reactor with an optimal light path, both cultivation systems requiring ca. 85 m(2) of illuminated surface to produce 1 kg dry cell mass of Nannochloropsis sp. per day. The difference in light utilization efficiency between the two very different production systems involves three aspects - first, the open raceway requires ca. 6 times greater volume than the 10 cm flat plate reactor to produce the same quantity of cell-mass. Second, the total ground area (i.e. including the ground area between reactors) for the vertical flat plate reactor is less than one half of that occupied by an open raceway, indicating the former is more efficient, photosynthetically, compared with the latter. Finally, the harvested cell density is close to one order of magnitude higher in the flat plate reactor, which carries economic significance. The advantage of vertical lamination of photoautotrophic cells provided by vertical plate reactors, is thereby clearly seen. The optimal population density (i.e. which results in the highest areal productivity) in the 10 cm plate reactor was obtained by a daily harvest of 10% of culture volume, yielding an annual average of ca. 12.1 g dry wt. m(-2) per day (on the basis of the overall illuminated reactor surfaces, i.e. front and back) or 240 mg l(-1) per day.     

The cell composition of Nannochloropsis sp. changes under different irradiances in semicontinuous culture

Nannochloropsis sp. was grown semicontinuously with a rate of daily renewal of the culture media of 40% of the volume of the culture under different irradiances (40, 60, 80, 220 and 480 mol quanta m^–2 s^–1). Under the conditions tested, light saturation was achieved at 220 mol quanta m^–2 s^–1 with no significant increase in steady-state cell density or of dry weight productivity with higher irradiance, reaching values of 115 × 10⁶ cells ml^–1 and 375 mg l^–1 day^–1 respectively. C/N ratios clearly indicated the point of light saturation, decreasing with increasing irradiance for light-limited conditions and increasing for light-saturated conditions. Under light-limited conditions, an increase in the irradiance produced an increase in the protein percentage of the organic fraction to the detriment of lipids and carbohydrates, while small changes were recorded under light-saturated conditions. The degree of unsaturation of fatty acids was lower with increasing irradiance, with a three-fold decrease of the percentage of total n–3 fatty acids, from 29 to 8% of total fatty acids, caused mainly by a decrease of eicosapentaenoic acid (EPA) (20:5n–3). The microalga reached its maximal value of dry weight productivity (375 mg l^–1 day^–1), EPA productivity (3.2 mg l^–1 day^–1) and maximal protein content (36% of the organic content) at the point at which light saturation was achieved. Results demonstrate the efficiency of the use of the irradiance for the modification of the biochemical composition of Nannochloropsis sp.     

Growth and fatty acid composition of Nannochloropsis sp. grown mixotrophically in fed-batch culture

The cell growth and eicosapentaenoic acid (EPA) yields of Nannochloropsis sp. were enhanced in the fed-batch cultures. With feeding glucose solution, the biomass reached 1.1 g dry wt l(-1) after 10 days' culture, which was 40% higher than that obtained in the batch culture (0.8 g dry wt l(-1)). With supplement of nitrate solution, the biomass reached 1 g dry wt l(-1), and reached the stationary phase 2 days earlier than the others. The maximum of biomass (1.2 g dry wt l(-1)) was obtained with the supplement of the mixture of glucose and nitrate solution. The EPA yields of Nannochloropsis sp. after 10 days' growth in the fed-batch cultures were 52 mg l(-1), 43 mg l(-1) and 56 mg l(-1) with, respectively, addition of nitrate, glucose and both together. In batch culture only 35 mg EPA l(-1) was obtained.     

Growth characteristics and eicosapentaenoic acid production by Nannochloropsis sp. in mixotrophic conditions

Nannochloropsis sp. was grown under mixotrophic conditions with 30 mM glucose as carbon source, reaching 507 mg dry wt l(-1) after 8 d. This was 1.4-fold of that obtained under photoautotrophic conditions. Under mixotrophic and photoautotrophic cultivations, the net photosynthetic rate of Nannochloropsis sp. did not change but the respiratory rate increased in the mixotrophic cultivation. The yield of eicosapentaenoic acid was 22 mg l(-1) in the mixotrophic cultivation and 20 mg l(-1) under the photoautotrophic cultivation.     

Effects of initial population density (IPD) on growth and lipid composition of Nannochloropsis sp.

The microalga Nannochloropsis sp. was cultured under different initial population densities (IPDs) ranging from 0.11 to 9.09 g L^?1. The IPD affected the biomass and lipid accumulation significantly. The algal cultured with higher IPD resulted higher biomass concentration (up to 13.07 g L^?1) in 10 days growth. The biomass productivity with 0.98 g L^?1 IPD was 0.75 g L^?1 d^?1 which was higher than that of other IPDs. For IPDs ranging from 0.11 to 0.98 g L^?1, with the increase of IPD, the biomass productivity increased, while for IPD over 0.98 g L^?1, the biomass productivity decreased. Lipid content of the algal culture started with 0.11 g L^?1 IPD reached to 42 % of dry weight. But with the increase of IPD, the lipid content decreased. Lipid composition was analyzed using thin layer chromatography coupled with flame ionization detection (TLC/FID). Seven lipid classes were identified and quantified. The main reserve lipid, triacylglyceride (TAG), accumulated under all different IPD conditions. However, with the increasing IPD values, TAG content decreased from 59.1 to 23.5 % of the total lipids. Based on these results, to obtain the maximal biomass productivity and lipid productivity of Nannochloropsis sp. in mass cultivation systems, it is necessary to select an appropriate IPD.     

Mass cultivation of Nannochloropsis sp. in annular reactors

A study was made on the mass cultivation of Nannochloropsis sp. in newly designed annular reactors operated under natural, artificial or combined illumination. The annular reactor consists of two 2-m-high Plexiglas cylinders of different diameter placed vertically one inside the other so as to form an annular culture chamber. Artificial illumination is supplied by lamps placed inside the inner cylinder. Two annular reactors of different diameter (50 and 91 cm), light path (4.5 and 3.0 cm) and illuminated surface area (5.3 and 9.3 m²) were experimented with. The effect of two different artificial light sources (fluorescent tubes and metal halide lamps) on culture productivity was investigated in both systems. The highest productivity on a per reactor basis (about 34 g (d. wt) reactor^–1 24 h^–1) was achieved with the larger reactor illuminated by a 400-W metal halide lamp. From February to May a 91-cm reactor illuminated only with natural light was operated in parallel with a 91-cm reactor subjected to combined illumination. Under natural illumination productivity increased from 16.6 g (d. wt) reactor^–1 d^–1 in February to 34.1 g (d. wt) reactor^–1 d^–1 in May. Under combined illumination productivity was 41.3 g (d. wt) reactor^–1 d^–1 in February and increased up to 48.3 g (d. wt) reactor^–1 d^–1 in May. Although the culture exposed to combined illumination always attained higher yields, the productivity gap between the two cultures decreased gradually along the season as solar radiation and minimum night temperatures increased. A 1200-L plant made of ten 50-cm annular reactors was set up and operated for two years with combined illumination yielding an average of 270 g of dry Nannochloropsis sp. biomass per day. More than 2000 L of concentrate suspension (50 g (d. wt) L^–1) of Nannochloropsis sp. were produced and successfully used by fish hatcheries as live feed for rotifers and for rearing seabream larvae with the green-water technique. This study indicates that the annular reactor can be profitably used for long-term cultivation of Nannochloropsis in temperate climates. Besides reliability and ease of operation, the main advantage of the system is that it can be used under natural illumination, yet artificial light can be also supplied to maintain high productivity levels in winter or on cloudy days.     

Growth medium recycling in Nannochloropsis sp. mass cultivation

During cell division Nannochloropsis releases the thick and multilayered parent cell wall [Phycologia 35 (1996) 253]. The excretion of autoinhibitory substances in Nannochloropsis cultures has been also reported [J. Appl. Phycol. 11 (1999) 123]. Both wall remains and autoinhibitors may negatively affect culture growth and limit the recycling of the exhaust culture medium, a necessity in commercial microalgae plants to reduce production costs. The effect of medium recycling on growth and productivity of Nannochloropsis sp. cultures grown in 120 l annular reactors was investigated. The use of exhaust medium replenished with nutrients decreased significantly culture productivity. The partial removal of the cell walls alleviated, but did not solve the problem. In addition, medium recycling caused a massive formation of cell aggregates accompanied by a progressive deterioration of the culture. The structure of these aggregates was investigated by transmission electron microscopy. The images showed that the aggregates were held together by cell wall remains, which entrapped cells, bacteria and debris resulting from cell decay. Thus, in high density Nannochloropsis cultures, cell walls might play a key role in reducing productivity, favoring contamination and making the biomass unsuitable as aquaculture feed.     

小球藻联产油脂和虾青素的基元模式分析

构建了包含虾青素合成途径的小球藻代谢网络模型,集成文献报道同位素标定的小球藻代谢通量数据,估算了胞内代谢通量分布。在正常和缺氮培养条件下,虾青素的代谢通量分别为0.38和0.35。计算得到基元模式共640条,通过最大熵原理算法求取了正常培养和缺氮培养条件下的基元模式概率。存在4条关键基元模式,在2种培养条件下,其基元模式概率之和分别为60.95%和77.53%。虾青素的最大理论合成产率为11.27%,但是这4条关键基元模式并不包括虾青素的合成反应。     

Studies on quantitative physiology of Trichoderma reesei with two-stage continuous culture for cellulose production

By employing a two-stage continuous-culture system, some of the more important physiological parameters involved in cellulose biosynthesis have been evaluated with an ultimate objective of designing an optimally controlled cellulose process. The two-stage continuous-culture system was run for a period of 1350 hr with Trichoderma reesei strain MCG-77. The temperature and pH were controlled at 32°C and pH 4.5 for the first stage (growth) and 28°C and pH 3.5 for the second stage (enzyme production). Lactose was the only carbon source for the both stages. The ratio of specific uptake rate of carbon to that of nitrogen, Q(C)/Q(N), that supported good cell growth ranged from 11 to 15, and the ratio for maximum specific enzyme productivity ranged from 5 to 13. The maintenance coefficients determined for oxygen, M_O, and for carbon source, M_C, are 0.85 mmol O₂/g biomass/hr and 0.14 mmol hexose/g biomass/hr, respectively. The yield constants determined are: Y_X/O = 32.3 g biomass/mol O₂, Y_X/C = 1.1 g biomass/g C or Y_X/C = 0.44 g biomass/g hexose, Y_X/N = 12.5 g biomass/g nitrogen for the cell growth stage, and Y_X/N = 16.6 g biomass/g nitrogen for the enzyme production stage. Enzyme was produced only in the second stage. Volumetric and specific enzyme productivities obtained were 90 IU/liter/hr and 8 IU/g biomass/hr, respectively. The maximum specific enzyme productivity observed was 14.8 IU/g biomass/hr. The optimal dilution rate in the second stage that corresponded to the maximum enzyme productivity was 0.026 ～ 0.028 hr^?1, and the specific growth rate in the second stage that supported maximum specific enzyme productivity was equal to or slightly less than zero.     

半导体激光辐照对拟微绿球藻的生物学效应

目的:研究半导体激光对拟微绿球藻的生物学效应,进而利用激光诱变筛选高产优质藻株.方法:采用半导体激光辐照拟微绿球藻,辐照时间为l 0min、20min、30min.结果:诱变后藻的代谢物产量均有提高.结论:l0min、20min、30min辐照条件下,对拟微绿球藻细胞生长及代谢产物均有不同程度的促进作用,其中10min辐照组有利于拟微绿球藻的生长及色素的积累,分别比对照组提高了45.06％、86.59％、56.06％;但在20min剂量下更有利于胞外多糖、总多糖、蛋白质及油脂含量的积累,分别比对照组提高了67.7％、51.89％、19.16％、69.78％.     

Statistical optimization of culture media for production of phycobiliprotein by Synechocystis sp. PCC 6701

Synechocystis sp. PCC 6701 has a brilliantly colored pigment, phycobiliprotein containing phycoerythrin. Culture medium was optimized by sequential designs in order to maximize phycobiliprotein production. The observed fresh weights after 6 days were 0.58 g/L in BG-11, 0.83 g/L in medium for Scenedesmus sp. and 0.03∼0.52 g/L in the other tested media. Medium for Scenedesmus sp. was selected to be optimized by fractional factorial design and central composite design since the medium maintained a more stable pH within a desirable range due to higher contents of phosphate. The fractional factorial design had seven factors with two levels: KNO₃, NaNO₃, NaH₂PO₄, Na₂HPO₄, Ca(NO₃)₂, FeEDTA, and MgSO₄. From the result of fractional factorial design, nitrate and phosphate were identified as significant factors. A central composite design was then applied with four variables at five levels each: nitrate, phosphate, pH, and light intensity. Parameters such as fresh weight and phycobiliprotein contents were used to determine the optimum value of the four variables. The proposed optimum media contains 0.88 g/L of nitrate, 0.32 g/L of phosphate under 25 μE·m⁻²·s⁻¹ of light intensity. The maximum phycobiliprotein contents have been increased over 400%, from 4.9 to 25.9 mg/L after optimization.     

Emerging techniques for cell disruption and extraction of valuable bio-molecules of microalgae Nannochloropsis sp.

Bioprocess and Biosystems Engineering - Microalgae of Nannochloropsis sp. present valuable source of bio-molecules (pigments, lipids, proteins) that have nutritional potential for the...     

种子培养基成分对裂殖壶菌发酵产DHA的影响

考察种子培养基中谷氨酸钠质量浓度和NaCl质量浓度（盐度）对Schizochytrium sp. HX-308菌种质量及发酵性能的影响。结果表明：40 g/L谷氨酸钠条件下培养菌种,发酵后DHA质量分数达到（53.25±0.48）%,而其油产量、油脂质量分数和DHA产量分别为（24.9±0.4）g/L、（45.2±0.6）%、（8.6±0.35）g/L; 利用不含谷氨酸钠的种子培养基发酵,其油产量、油脂质量分数和DHA产量分别为（30.1±0.8）g/L、（54.3±0.5）%、（12.1±0.5）g/L,比含40 g/L谷氨酸钠时分别提高了20.88%、20.13%和40.70%,为菌种驯化提供了新的思路和方向。此外,低盐度培养条件有利于菌种生产性能的发挥,6.25 g/L NaCl条件下发酵后油质量分数、DHA产量及DHA质量分数最高,分别为（62.1±0.8）%、（10.0±0.3）g/L、（48.97±0.42）%。     

Influence of culture conditions on lipase production byBacillus sp. FH5

Lipases are a class of enzymes, which catalyse the hydrolysis of long chain triglycerides. Microbial lipases are currently receiving much attention with the rapid development of enzyme technology. Lipases have industrial potential in the chemical, pharmaceutical, medical, cosmetic, leather and paper manufacturing industries, biosurfactant synthesis, and agrochemicals. ABacillus strain isolated from soil was tested for the production of extracellular lipase, by batch culturing in shake flask. The growth conditions were optimised for the maximum production of enzyme. Various parameters for the production of lipase, such as temperature, incubation period, pH, carbon source, nitrogen source and lipids were studied. Maximum lipase production was found in 48-h-old culture filtrate at 37 °C, pH 8.0. Among all the carbon sources, salicin gave the maximum activity and among all the nitrogen sources yeast extract gave maximum production/activity. Tween (20 and 80) does not stimulate the growth much but assisted in enzyme production.