Comparison of some properties of free and immobilized alpha-amylase by Aspergillus sclerotiorum in calcium alginate gel beads

Some properties of immobilized alpha-amylase by Aspergillus sclerotiorum within calcium alginate gel beads were investigated and compared with soluble enzyme. Optimum pH and temperature were found to be 5.0 and 40 degrees C, respectively, for both soluble and immobilized enzymes. The immobilized enzyme had a better Km value, but kcat/Km values were the same for both enzymes. Entrapment within calcium alginate gel beads improved, remarkably, the thermal and storage stability of alpha-amylase. The half life values of immobilized enzyme and soluble enzyme at 60 degrees C were 164.2, and 26.2 min, respectively. The midpoint of thermal inactivation (Tm) shifted from 56 degrees C (for soluble enzyme) to 65.4 degrees C for immobilized enzyme. The percentages of soluble starch hydrolysis for soluble and immobilized alpha-amylase were determined to be 97.5 and 92.2% for 60 min, respectively.     

温和气单孢菌YH311硫酸软骨素裂解酶的分离纯化与固定化

通过硫酸铵沉淀、QAESephadex-A50柱层析及Sephadex-G150凝胶过滤等纯化步骤,对源自温和气单孢菌YH311的ChSase进行了分离纯化。结果表明,ChSase经上述纯化步骤后被纯化了55倍,其最终纯度可达95%以上,比活为31.86u/mg。经SDSPAGE及IFE测定可知该酶的分子量约为80kD,等电点为4.3～4.8。将纯化后的ChSase用海藻酸钠或纤维素固定化后,ChSase的热稳定性及贮存稳定性均可得到大幅度的提高：固定化酶用80℃水浴处理120min或于4℃冰箱放置30d后仍可保留50%以上的相对活力;但固定化酶的收率较低,仅为18.56%和18.86%。     

Optimization of alpha-amylase immobilization in calcium alginate beads

alpha-Amylase enzyme was produced by Aspergillus sclerotiorum under SSF conditions, and immobilized in calcium alginate beads. Effects of immobilization conditions, such as alginate concentration, CaCl(2) concentration, amount of loading enzyme, bead size, and amount of beads, on enzymatic activity were investigated. Optimum alginate and CaCl(2) concentration were found to be 3% (w/v). Using a loading enzyme concentration of 140 U mL(-1), and bead (diameter 3 mm) amount of 0.5 g, maximum enzyme activity was observed. Beads prepared at optimum immobilization conditions were suitable for up to 7 repeated uses, losing only 35% of their initial activity. Among the various starches tested, the highest enzyme activity (96.2%) was determined in soluble potato starch hydrolysis for 120 min at 40 degrees C.     

漆酶在磁性壳聚糖微球上的固定及其酶学性质研究

以磁性壳聚糖微球为载体,戊二醛为交联剂,共价结合制备固定化漆酶。探讨了漆酶固定化的影响因素,并对固定化漆酶的性质进行了研究。确定漆酶固定化适宜条件为：50 mg磁性壳聚糖微球,加入10mL 0.8mg/mL 漆酶磷酸盐缓冲液（0.1mol/L,pH 7.0）,在4℃固定2h。固定化酶最适pH为3.0, 最适温度分别为10℃和55℃,均比游离酶降低5℃。在pH 3.0,温度37℃时,固定化酶对ABTS的表观米氏常数为171.1μmol/L。与游离酶相比,该固定化漆酶热稳定性明显提高,并具有良好的操作和存储稳定性。     

黄曲霉毒素解毒酶的固定化及其性质的研究

黄曲霉毒素是农作物常见的受污染的霉菌毒素,毒性大,稳定性高,是潜在的肝癌致癌物,对人的危害较大。该毒素的解毒与去毒一直是受到关注的问题。黄曲霉毒素解毒酶对黄曲霉毒素有特殊的去毒和降解作用,但是该酶的稳定性离解决实际问题尚有一段距离。报道了对黄曲霉毒素解毒酶的固定化,并对固定化处理后酶的稳定性、性质、催化活性、解毒活性进行了测定。结果表明,通过固定化操作酶的解毒活性被保留下来,酶的酸碱稳定性、热稳定性、放置稳定性等均得到显著的提高。     

Characterization of dextransucrase immobilized on calcium alginate beads from Leuconostoc mesenteroides PCSIR-4

Immobilization of dextransucrase from Leuconostoc mesenteroides PCSIR-4 on alginate is optimized for application in the production of dextran from sucrose. Dextransucrase was partially purified by ethanol upto 2.5 fold. Properties of dextransucrase were less affected by immobilization on alginate beads from soluble enzyme. Highest activities of both soluble and immobilized dextransucrase found to be at 35 degrees C and optimum pH for activity remain 5.00. Substrate maxima for immobilized enzyme changed from 125 mg/ml to 200 mg/ml. Incubation time for enzyme-substrate reaction for maximum enzyme activity was increased from 15 minutes to 60 minutes in case of immobilized enzyme. Maximum stability of immobilized dextransucrase was achieved at 25 degrees C with respect to time.     

Enzymatic properties of immobilized Alcaligenes faecalis cells with cell-associated beta-glucosidase activity

Enzymatic properties of Alcaligenes faecalis cells immobilized in polyacrylamide were characterized and compared with those reported for the extracted enzyme, and with those measured for free cells. Many of the properties reflected those of the extracted enzyme rather than those measured in the free whole cells prior to immobilization, suggesting cell disruption during immobilization. These properties included the pH activity profile, a slightly broader pH stability profile, and the activation energy. Electron micrographs showed evidence of cell debris among the polymer matrix. The immobilized cells were not viable, and did not consume glucose. Thermal stability was less after immobilization with a half-life of 16 h at 45 degrees C, and 3.5 h at 50 degrees C. The immobilized preparation was more stable when stored lyophilized rather than in buffer, losing 23 and 52% activity, respectively, after six months. The enzyme was irreversibly inhibited by both acetate and citrate buffers. If the immobilized enzyme is to be used in conjunction with cellulases from Trichoderma reesei for cellulase saccharification, the optimal conditions would be pH 5.5 and 45 degrees C in a buffer containing no carboxylic acid groups.     

Stabilization of immobilized cathepsin L in non-aqueous medium

A lysosomal cysteine protease cathepsin L (3.4.22.15) purified from goat brain has been immobilized in calcium alginate beads in the presence of BSA through entrapment. Most favorable conditions for the entrapment were standardized as 3.0%(w/v) alginate and 1.5%(w/v) calcium chloride. Comparing the properties of free and immobilized enzyme using Z-Phe-Arg-4mβNA as chromogenic substrate, it was found that the immobilized enzyme could retain～70% of the original activity after five successive batch reactions. Vis-à-vis the free enzyme, immobilization conferred high stability to the enzyme both in the acidic and alkaline range, the enzyme lost no activity up to 60°C (Temperature stability for free enzyme is only up to 50°C). The pH optima for the enzyme shifted from 6.2 to 6.6 on entrapment. The increase in activity and stability of the enzyme in immobilized form even in the presence of high concentration of DMSO and ethanol is surprising and may make it useful for catalyzing organic reactions like trans-esterification and trans-amidation.     

Immobilization of beta-galactosidase on fibrous matrix by polyethyleneimine for production of galacto-oligosaccharides from lactose

The production of galacto-oligosaccharides (GOS) from lactose by Aspergillus oryzae beta-galactosidase immobilized on cotton cloth was studied. A novel method of enzyme immobilization involving PEI-enzyme aggregate formation and growth of aggregates on individual fibrils of cotton cloth leading to multilayer immobilization of the enzyme was developed. A large amount of enzyme was immobilized (250 mg/g support) with about 90-95% efficiency. A maximum GOS production of 25-26% (w/w) was achieved at near 50% lactose conversion from 400 g/L of lactose at pH 4.5 and 40 degrees C. Tri- and tetrasaccharides were the major types of GOS formed, accounting for about 70% and 25% of the total GOS produced in the reactions, respectively. Temperature and pH affected not only the reaction rate but also GOS yield to some extend. A reaction pH of 6.0 increased GOS yield by as much as 10% compared with that of pH 4.5 while decreased the reaction rate of immobilized enzyme. The cotton cloth as the support matrix for enzyme immobilization did not affect the GOS formation characteristics of the enzyme under the same reaction conditions, suggesting diffusion limitation was negligible in the packed bed reactor and the enzyme carrier. Increase in the thermal stability of PEI-immobilized enzyme was also observed. The half-life for the immobilized enzyme on cotton cloth was close to 1 year at 40 degrees C and 21 days at 50 degrees C. Stable, continuous operation in a plug-flow reactor was demonstrated for about 3 days without any apparent problem. A maximum GOS production of 26% (w/w) of total sugars was attained at 50% lactose conversion with a feed containing 400 g/L of lactose at pH 4.5 and 40 degrees C. The corresponding reactor productivity was 6 kg/L/h, which is several-hundred-fold higher than those previously reported.     

锰过氧化物酶的耦合固定化及其性质研究

分别采用海藻酸钠、明胶和壳聚糖为载体,并以戊二醛为交联剂,通过包埋-交联和吸附-交联两种耦合固定化方法制备固定化锰过氧化物酶。探讨了酶的不同固定化条件和固定化酶的部分性能。与游离酶相比,制备的3种固定化酶最适反应pH分别由7·0降低到5·0、5·0和3·0,最适反应温度分别由35℃升高到75℃、55℃和75℃。3种固定化酶的耐热性都显著提高,其中用壳聚糖制成的固定化酶在pH2·2~11的宽范围内表现出很好的酸碱耐受性。30℃连续测定6~9次酶活力,重复使用的3种固定化酶显示出良好的稳定性。将固定化酶应用在偶氮染料的脱色中,用明胶制成的固定化酶在静置和摇床条件下,以及用海藻酸钠制成的固定化酶在摇床条件下,均表现出与游离酶相近的脱色能力,并且在重复进行的摇床实验中,脱色能力未降低,反应前后的酶活力均没有损失。     

Immobilization of the exo-maltohexaohydrolase by the irradiation method

Exomaltohexaohydrolase (E.C.3.2.1.98) was immobilized by radiocopolymerization of some synthetic monomers which were mixed in various combinations. Irradiation was carried out while the mixture of monomers and enzymes was frozen in petroleum ether-dry-ice bath. Recovery of the immobilized enzyme was 44-75%.The optimum pH of the enzyme slightly shifted to the acidic side. The pH stability was improved remarkably by immobilization. The enzyme was stable retaining more than 90% of its original activity in the range pH 4-11. The optimum reaction temperature of the enzyme increased about 2 degrees C. Heat stability was also improved by immobilization, and that the enzyme retained about 40% of its original activity after treatment at 75 degrees C for 15 min. The immobilized enzyme was stable to the repeated use of 20 cycles. The K(m) value of the enzyme for short-chain amylose was almost the same as that of native enzyme. When soluble starch was used as the substrate, the K(m), value of the enzyme was three times as large as that of native enzyme. Effects of various metal ions and inhibitors on the immobilized enzyme were also studied compared to the native enzyme.     

A novel matrix for the immobilization of acetylcholinesterase

In this study, a new matrix for immobilization of acetylcholinesterase was investigated by using alginate and kappa-carrageenan. The effects of pH, temperature, storage and thermal stability on the free and immobilized acetylcholinesterase activity were examined. Maximum reaction rate (V(max)) and Michaelis-Menten constant (K(m)) was also investigated for free and immobilized enzymes. For free and immobilized enzymes into Ca-alginate and alginate/kappa-carrageenan polymer blends, optimum pH and temperature was found to be 7 and 30 degrees C, respectively. For free enzyme, maximum reaction rate (V(max)) and Michaelis-Menten constant (K(m)) values were found to be 6.35 mM and 50 mM min(-1), respectively, the same values for immobilized enzymes were determined as 8.68, 12.7 mM and 39.7, 52.9 mM min(-1), respectively. Storage and thermal stability of acetylcholinesterase was increased by as a result of immobilization.     

Immobilization and characterization of lipase from an indigenous Bacillus aryabhattai SE3-PB isolated from lipid-rich wastewater

Abstract

Extracellular lipase from an indigenous Bacillus aryabhattai SE3-PB was immobilized in alginate beads by entrapment method. After optimization of immobilization conditions, maximum immobilization efficiencies of 77%?±?1.53% and 75.99%?±?3.49% were recorded at optimum concentrations of 2% (w/v) sodium alginate and 0.2?M calcium chloride, respectively, for the entrapped enzyme. Biochemical properties of both free and immobilized lipase revealed no change in the optimum temperature and pH of both enzyme preparations, with maximum activity attained at 60?°C and 9.5, respectively. In comparison to free lipase, the immobilized enzyme exhibited improved stability over the studied pH range (8.5–9.5) and temperature (55–65?°C) when incubated for 3?h. Furthermore, the immobilized lipase showed enhanced enzyme-substrate affinity and higher catalytic efficiency when compared to soluble enzyme. The entrapped enzyme was also found to be more stable, retaining 61.51% and 49.44% of its original activity after being stored for 30 days at 4?°C and 25?°C, respectively. In addition, the insolubilized enzyme exhibited good reusability with 18.46% relative activity after being repeatedly used for six times. These findings suggest the efficient and sustainable use of the developed immobilized lipase for various biotechnological applications.     

Immobilization of alpha-chymotrypsin on poly(urethane-graft-acrylic acid)

A study was made of the immobilization of alpha-chymotrypsin (alpha-CT) onto a previously well characterized synthetic polyurethane grafted with acrylic acid P(U-g-AA). The P(U-g-AA) had previously been prepared using 2,2'-azo-bis-isobutyronitrile (AIBN) as a radical initiator and acrylic acid as monomer in the presence of an unsaturated polyurethane in solution at 60 degrees C. Some kinetic parameters of both the native enzyme and the enzyme immobilized on the P(U-g-AA) were evaluated. Using a Lineweaver-Burk plot (double reciprocal), it was found that the Michaelis-Menten constant (Km(for the immobilized enzyme was (4.0 +/- 0.9) x 10(-3) M and that of the free enzyme was (3.0 +/- 0.2) x 10(-3) M. The enzyme alpha-chymotrypsin was immobilized on the grafted polyurethane micelles/aggregates with about 45% retention of activity. Also the immobilized alpha-CT retained this activity for at least 6 weeks. The immobilized enzyme was found to have a maximum stability at 43 degrees C compared with 36 degrees C in the case of free enzyme, and the pH optimum was shifted from pH 6.6 to pH 8.2. The long-term operational stability of the enzyme was investigated and this is of interest since the enzyme is probably trapped physically in a micellar environment. The assay of the enzyme was carried out in 0.01 M phosphate buffer, pH 7.5, using p-nitrophenyl acetate as a substrate. No inhibition of alpha-CT in the presence of the synthetic ungrafted and grafted polyurethane was observed.     

桦褶孔菌漆酶固定化及其对染料的降解

采用壳聚糖交联法和海藻酸钠-壳聚糖包埋交联法固定化桦褶孔菌产生的漆酶,探讨最佳固定化条件,固定化漆酶的温度,pH稳定性及操作稳定性,并以两种固定化酶分别对4种染料进行了降解.结果表明:(1)壳聚糖交联法固定化漆酶的最佳条件为:壳聚糖2.5%,戊二醛7%,交联时间2h,固定化时间5h,给酶量1g壳聚糖小球:1mL酶液(1U/mL),固定化效率56%;(2)海藻酸钠-壳聚糖包埋交联法固定化漆酶的最佳条件为:海藻酸钠浓度4%,壳聚糖浓度0.7%,氯化钙浓度5%,戊二醛浓度0.6%,给酶量4mL 4%海藻酸钠:1mL酶液(1U/mL),固定化效率高达86%;(3)固定化的漆酶相比游离漆酶有更好的温度和pH稳定性;(4)比较两种固定化漆酶,海藻酸钠-壳聚糖包埋交联法固定化酶的温度及酸度稳定性要优于壳聚糖固定化酶,但可重复操作性要弱于后者,两者重复使用8次后的剩余酶活比率分别为71%及64%;(5)两种固定化酶对所选的4种不同结构的合成染料均有较好的降解效果,其中壳聚糖固定化酶对茜素红的降解效果及重复使用性极佳,重复降解40mg/L的茜素红10次,降解率仍保持在100%.     

Preparation and application of poly(N,N-dimethylacrylamide-co-acrylamide) and poly(N-isopropylacrylamide-co-acrylamide)/kappa-Carrageenan hydrogels for immobilization of lipase

In the present of this study, two novel polymeric matrixes that are poly(N,N-dimethylacrylamide-co-acrylamide) and poly(N-isopropylacrylamide-co-acrylamide)/kappa-Carrageenan was synthesized and applied for immobilization of lipase. For the immobilization of enzyme, two different immobilization procedures have been carried out via covalently binding and entrapment methods. On the free and immobilized enzymes activities, optimum pH, temperature, storage and thermal stability was investigated. The optimum temperature for free, covalently immobilized and entrapped enzymes was found to be 30, 35 and 30 degrees C, respectively. Optimum pH for both free and immobilized enzymes was also observed at pH 8. Maximum reaction rate (Vmax) and Michaelis-Menten constant (Km) were determined for free and immobilized lipases. Furthermore, the reuse numbers of immobilized enzymes also studied. It was observed that after 40th use in 5 days, the retained activities for covalently immobilized and entrapped lipases were found as 39% and 22%, respectively. Storage and thermal stability of enzyme was also increased by as a result of immobilization procedures.     

Optimization of covalent immobilization of pectinase on sodium alginate support

Pectinase was immobilized on a sodium alginate support using glutaraldehyde and retained 66% activity. The optimal pH for activity shifted from 3.0 to 3.5 after immobilization; however, the optimum temperature remained unchanged at 40°C. The immobilized enzyme also had a higher thermal stability and reusability than the free enzyme, and retained 80% of initial activity after 11 batch reactions.     

Immobilization and characterization of D-amino acid oxidase.

Optimal conditions with respect to pH, concentration of glutaraldehyde and enzyme, and order of addition of enzyme and crosslinking reagent were established for the immobilization of hog kidney D-amino acid oxidase to an attapulgite support. Yields of 40 to 70% were generally attained although when low concentrations of enzyme were used yields were consistently greater than 100%. It is suggested that this is due to a dimer leads to monomer shift at low protein concentrations. The stability of soluble D-amino acid oxidase was dependent on the buffer in which it was stored (pyrophosphate-phosphate greater than borate greater than Tris). Stability of immobilized enzyme was less than soluble in pyrophosphate-phosphate buffer, but storage in the presence of FAD improved stability. In addition, treatment of stored, immobilized enzyme with FAD before assay restored some of its activity. The immobilized D-amino acid oxidase was less stable to heat (50 degrees C) than the soluble enzyme from pH 6 to 8 but was more stable above and below these values. Apparent Km values for D-alanine, D-valine, and D-tryptophan decreased for the immobilized enzyme compared to the soluble.     

Phytate degradation by immobilized<Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> phytase in soybean-curd whey

Saccharomyces cerevisiae CY phytase-producing cells were immobilized in calcium alginate beads and used for the degradation of phylate. The maximum activity and immobilization yield of the immobilized phytase reached 280 mU/g-bead and 43%, respectively. The optimal pH of the immobilized cell phytase was not different from that of the free cells. However, the optimum temperature for the immobilized phytase was 50°C, which was 10°C higher than that of the free cells; pH and thermal stability were enhanced as a consequence of immobilization. Using the immobilized phytase, phytate was degraded in a stirred tank bioreactor. Phytate degradation, both in a buffer solution and in soybean-curd whey mixture, showed very similar trends. At an enzyme dosage of 93.9 mU/g-phytate, half of the phytate was degraded after 1 h of hydrolysis. The operational stability of the immobilized beads was examined with repeated batchwise operations. Based on 50% conversion of the phytate and five times of reuse of the immobilized beads, the specific degradation (g phytate/g dry cell weight) for the immobilized phytase increased 170% compared to that of the free phytase.     

The preparation and characterization of an immobilized l-glutamic decarboxylase and its application for determination of l-glutamic acid

This paper is to study the preparation and characterization of an immobilized L-glutamic decarboxylase (GDC) and develop a sensitive method for the determination of L-glutamate using a new biosensor, which consists of an enzyme column reactor of GDC immobilized on a novel ion exchange resin (carboxymethyl-copolymer of allyl dextran and N.N'-methylene-bisacrylamide CM-CADB) and ion analyzer coupled with a CO(2) electrode. The conditions for the enzyme immobilization were optimized by the parameters: buffer composition and concentration, adsorption equilibration time, amount of enzyme, temperature, ionic strength and pH. The dynamic response of Na(2)HPO(4)-citric acid buffer system selected is much better than that of the others, 0.10 M HAc-0.10 M NaAc and 0.10 M sodium citrate-0.10 M citric acid. The initial rate of the enzyme reaction v(0) in this buffer system is 1.76 mol. l(-1) min(-1), moreover, the rate of the enzyme reaction appears linear in the first 4 min. The optimum adsorption equilibrium time is around 6 h. The amount of enzyme adsorbed on CM-CADB resin affects the response to substrate L-glutamic acid, the widest range of linearity is obtained with over 30 mg (GDC)/g(resin). The GDC activity immobilized on CM-CADB reaches a maximum when the immobilization temperature was kept around 40 degrees C. pH was kept at 4.4 when measuring the activity of the immobilized GDC. No variation of the activity of immobilized GDC is observed when the capacity is over 2.5 meq/g.(CM-CADB resin). The properties of the immobilized enzyme on CM-CADB were characterized. No significant improvement can be achieved when the substrate concentration exceeds 12.00 mmol/l, where the activity of immobilized GDC is equal to 1.58 mmol/l.min.g. The optimum pH is found to be 5.2, which changes 0.2 unit, comparing with that of the free GDC (5.0). The optimum temperature is found to be around 48 degrees C, which is lower than that of free GDC (55 degrees C). The critical temperature of the free GDC and the immobilized GDC is approximately 50 degrees C and 45 degrees C, respectively. The half-life of the activity is 127 days when the immobilized enzyme was stored in the cold (4 degrees C). An immobilized GDC enzyme column reactor matched with a flow injection system-ion analyzer coupled with CO(2) electrode-data collection system made up the original form of the apparatus of biosensor for determining of L-glutamic acid. The determination conditions are that the buffer solution is 0.10 M Na(2)HPO(4)-0.05 M citric acid at pH 4.4 and t = 37 degrees C. The limit of detection is 1.0 x 10(-)(5) M. The linearity response is in the range of 5 x 10 (-2) - 5 x 10 (-5) M. The equation of linear regression of the calibration curve is y = 43.3x + 181.6 (y is the milli-volt of electrical potential response, x is the logarithm of the concentration of the substrate of L-glutamic acid). The correlation coefficient equals 0.99. The coefficient of variation equals 2.7%.