An alkaline protease from Bacillus circulans BM15, newly isolated from a mangrove station: characterization and application in laundry detergent formulations

An investigation on the properties of an alkaline protease secreted by Bacillus circulans BM15 strain isolated from a mangrove sediment sample was carried out in order to characterize the enzyme and to test its potency as a detergent additive. The protease was purified to apparent homogeneity by ammonium sulphate precipitation and was a 30-kDa protease as shown by SDS-PAGE and its proteolytic activity was detected by casein zymography. It had optimum activity at pH 7, was stable at alkaline pH range (7 to 11), had optimum temperature of activity 40°C and was stable up to a temperature of 55°C after incubation for one hour. Hg²⁺, Zn²⁺, Co²⁺, and Cu²⁺completely inhibited the enzyme activity, while Ca²⁺, Mg²⁺, K⁺ and Fe³⁺ were enhancing the same. The serine protease inhibitor PMSF and metal chelator EDTA inhibited the activity of this protease while the classic metalloprotease inhibitor 1, 10 phenanthroline did not show inhibition. The enzyme was stable in SDS, Triton-X-100 and H₂ O₂ as well as in various commercial detergents after incubation for one hour. The extracellular production of the enzyme, the pH and temperature stability and stability in presence of oxidants, surfactants and commercial detergents suggest its possible use as a detergent additive.     

Purification and partial characterization of serine protease from thermostable alkalophilic <Emphasis Type="Italic">Bacillus laterosporus</Emphasis>-AK1

An extracellular thermostable alkaline protease isolated from Bacillus laterosporus-AK1 was purified by sephadex G-200 gel filtration and DEAE cellulose ion-exchange chromatography techniques. The purified protease showed a maximum relative activity of 100% on casein substrate and appeared as a single band on SDS-PAGE with the molecular mass of 86.29 kDa. The protease was purified to 11.1-folds with a yield of 34.3%. Gelatin zymogram also revealed a clear hydrolytic zone due to proteolytic activity, which corresponded to the band obtained with SDS-PAGE. The protease enzyme had on optimum pH of 9.0 and exhibited highest activity at 75°C. The enzyme activity was highly susceptible to the specific serine protease inhibitor PMSF, suggesting the presence of serine residues at the active sites. Enzyme activity strongly enhanced by the metal ions Ca²⁺ and Mg²⁺ and this enzyme compatible with aril detergent stability retained 75% even 1-h incubation. The purified protease remove bloodstain completely when used with Wheel detergent.     

Production and characterization of extracellular protease of mutant Aspergillus niger AB100 grown on fish scale

Fish scale, the chief waste material of fish processing industries was processed and tested for production of extracellular protease by mutant Aspergillus niger AB₁₀₀. Protease production by A. niger AB₁₀₀ was greatly enhanced in presence of processed fish scale powder. Where as among the three complex nutrients tested, soya bean meal shows maximum stimulatory effect over protease production (2,776 μmol/ml/min) when used in combination with glucose (5% w/v) and urea (2.5% w/v). The protease was optimally active at pH 7.0, retaining more than 60% of its activity in the pH range of 5–9. The enzyme was found to be most active at 50°C and stable at 30°C for 1 h. Purification of enzyme by CM-Cellulose and SDS-PAGE resulted in about 26-fold increase in the specific activity of the enzyme with a molecular weight of 30.9 kDa. HPLC study shows the purity of the enzyme as 75.92%. By the activating effect of divalent cations (Fe²⁺, Zn²⁺, Mn²⁺, Ca²⁺and Mg²⁺) and inhibiting effect of chelating agent (EDTA) and Hg²⁺, the enzyme was found to be a metalloprotease.     

Purification and biochemical characterization of a broad substrate specificity thermostable alkaline protease from Aspergillus nidulans

Aspergillus nidulans PW1 produces an extracellular carboxylesterase activity that acts on several lipid esters when cultured in liquid media containing olive oil as a carbon source. The enzyme was purified by gel filtration and ion exchange chromatography. It has an apparent MW and pI of 37 kDa and 4.5, respectively. The enzyme efficiently hydrolyzed all assayed glycerides, but showed preference toward short- and medium-length chain fatty acid esters. Maximum activity was obtained at pH 8.5 at 40°C. The enzyme retained activity after incubation at pHs ranging from 8 to11 for 12 h at 37°C and 6 to 8 for 24 h at 37°C. It retained 80% of its activity after incubation at 30 to 70°C for 30 min and lost 50% of its activity after incubation for 15 min at 80°C. Noticeable activation of the enzyme is observed when Fe²⁺ ion is present at a concentration of 1 mM. Inhibition of the enzyme is observed in the presence of Cu²⁺, Fe³⁺, Hg²⁺, and Zn²⁺ ions. Even though the enzyme showed strong carboxylesterase activity, the deduced N-terminal amino acid sequence of the purified protein corresponded to the protease encoded by prtA gene.     

Purification and characterization of a heat-stable alkaline protease from Bacillus stearothermophilus F1

A thermophilic Bacillus stearothermophilus F1 that produced an extremely thermostable alkaline protease was isolated from decomposed oil palm branches. The isolated protease was purified to homogeneity by heat treatment, ultrafiltration and gel filtration chromatography with a 128-fold increase in specific activity and 75% recovery. The protease, which is a serine-type enzyme, has a relative molecular mass of 33 500 by sodium dodecyl sulphate-polyacrylamide gel electrophoresis but only 20 000 by gel-filtration chromatography. The enzyme was optimally active at pH 9.0 and was stable for 24 h at 70° C and in the pH range from 8.0 to 10.0. It was capable of hydrolysing many soluble and insoluble protein substrates but no esterase activity was detected. The enzyme activity was markedly inhibited by Co²⁺ and Hg²⁺, whereas Mg²⁺, Fe²⁺, Cu²⁺, Zn²⁺ and Sr²⁺ had little or no inhibitory effect. However, Mn²⁺ strongly activated the protease activity. The protease exhibited a high degree of thermostability [t _1/2 (85° C) = 4 h, (90° C) = 25 min]. The stability at higher temperatures (85° C and above) was shown to be dependent on the presence of Ca²⁺. Correspondence to: A. B. Salleh     

Purification and Characterization of an Alkaline Protease from the Marine Yeast <Emphasis Type="Italic">Aureobasidium pullulans</Emphasis> for Bioactive Peptide Production from Different Sources

The extracellular alkaline protease in the supernatant of cell culture of the marine yeast Aureobasidium pullulans 10 was purified to homogeneity with a 2.1-fold increase in specific protease activity as compared to that in the supernatant by ammonium sulfate fractionation, gel filtration chromatography (Sephadex™ G-75), and anion-exchange chromatography (DEAE Sepharose Fast Flow). According to the sodium dodecyl sulfate-polyacrylamide gel electrophoresis data, the molecular mass of the purified enzyme was estimated to be 32.0 kDa. The optimal pH and temperature of the purified enzyme were 9.0 and 45°C, respectively. The enzyme was activated by Cu²⁺ (at a concentration of 1.0 mM) and Mn²⁺ and inhibited by Hg²⁺, Fe²⁺, Fe³⁺, Zn²⁺, and Co²⁺. The enzyme was strongly inhibited by phenylmethylsulfonyl fluoride, but weakly inhibited by EDTA, 1–10-phenanthroline, and iodoacetic acid. The K _m and V _max values of the purified enzyme for casein were 0.25 mg/ml and 0.0286 μmol/min/mg of protein, respectively. After digestion of shrimp protein, spirulina (Arthospira platensis) protein, proteins of marine yeast strains N3C (Yarrowia lipolytica) and YA03a (Hanseniaspora uvarum), milk protein, and casein with the purified alkaline protease, angiotensin I converting enzyme (ACE) inhibitory activities of the resulting peptides reached 85.3%, 12.1%, 29.8%, 22.8%, 14.1%, and 15.5%, respectively, while the antioxidant activities of these were 52.1%. 54.6%, 25.1%, 35%, 12.5%, and 24.2%, respectively, indicating that ACE inhibitory activity of the resulting peptides from the shrimp protein and antioxidant activity of those produced from the spirulina protein were the highest, respectively. These results suggest that the bioactive peptides produced by digestion of the shrimp protein with the purified alkaline protease have potential applications in the food and pharmaceutical industries.     

Regulation of the formation of protease inBacillus megaterium

During the growth of the asporogenous variant ofBacillus megaterium KM in medium containing NO₃ ⁻ as nitrogen source, the relative rate of extracellular protease synthesis is higher than in the presence of NH₄ ⁺. It approaches the relative rate of enzyme synthesis at the incubation of cells in nitrogen-free medium with glucose. This supports the suggestion that even amino acids which are synthesized endogenously slow down the protease production. In the postlogarithmic or stationary phase the protease production stops. The interruption of enzyme production does not appear as a result of insufficient aeration in a dense suspension, or of accumulation of amino acids or their metabolites in cells. The non-growing cells retain their ability to renew the enzyme synthesis when transferred into a fresh medium, even into a medium without nitrogen source. In the same way it is possible to “induce” the protease production, if Ca²⁺ is added to cells in the stationary phase when the population was grown in the Ca²⁺ free medium. The amount of enzyme produced at the expense of protein turnover by the non-growing populations is sufficient for the fast hydrolysis of exogenous protein in the medium and for assuring the influx of a sufficient amount of peptides into the cells. In such a case the growth of the culture is therefore very quickly renewed.     

Thermotolerant alkaline protease enzyme from Bacillus licheniformis A10: purification,characterization, effects of surfactants and organic solvents

In this study, the extracellular thermostable alkaline protease out of A10 strain was purified 1.38-fold with 9.44% efficiency through the ammonium sulfate precipitation-dialysis and DE52 anion exchange chromatography methods. The molecular weight of the enzyme in question along with sodium dodecyl sulfate-polyacrylamide gel electrophoresis was determined to be approximately 40.55?kDa, whereas the optimum pH and temperature ratings were identified as 9.0 and 70?°C, respectively. It was seen that the enzyme had remained stable between pH 7.5–10.5 range, protecting more than 90% of its activity in the wake of 1?h incubation at 60–70?°C. It was also observed that the enzyme enhanced its activity in the presence of Mg²⁺, Mn²⁺, K⁺, while Fe²⁺, Ni²⁺, Zn²⁺, Ag^+?and Co^2+? decreased the activity. Ca²⁺, however, did not cause any change in the activity. The enzyme was seen to have been totally inhibited by phenylmethylsulfonyl fluoride, therefore, proved to be a serine alkaline protease.     

Enhanced alternative oxidase and antioxidant enzymes under Cd<Superscript>2+</Superscript> stress in <Emphasis Type="Italic">Euglena</Emphasis>

To identify some of the mechanisms involved in the high resistance to Cd²⁺ in the protist Euglena gracilis, we studied the effect of Cd²⁺ exposure on its energy and oxidative stress metabolism as well as on essential heavy metals homeostasis. In E. gracilis heterotrophic cells, as in other organisms, CdCl₂ (50 μM) induced diminution in cell growth, severe oxidative stress accompanied by increased antioxidant enzyme activity and strong perturbation of the heavy metal homeostasis. However, Cd²⁺ exposure did not substantially modify the cellular respiratory rate or ATP intracellular level, although the activities of respiratory complexes III and IV were strongly decreased. In contrast, an enhanced capacity of the alternative oxidase (AOX) in both intact cells and isolated mitochondria was determined under Cd²⁺ stress; in fact, AOX activity accounted for 69-91% of total respiration. Western blotting also revealed an increased AOX content in mitochondria from Cd²⁺-exposed cells. Moreover, AOX was more resistant to Cd²⁺ inhibition than cytochrome c oxidase in mitochondria from control and Cd²⁺-exposed cells. Therefore, an enhanced AOX seems to be a relevant component of the resistance mechanism developed by E. gracilis against Cd²⁺-stress, in addition to the usual increased antioxidant enzyme activity, that enabled cells to maintain a relatively unaltered the energy status.     

The production of protease by dense suspensions ofBacillus megaterium KM Sp−

The synthesis and secretion of extracellular protease was demonstrated during the incubation of dense susponsions of the asporogenicBacillus megaterium KM. The overall production of the enzyme by cells incubated with glucose in a nitrogen-free medium was found to be only slightly lower than that in the presence of an inorganic nitrogen source. The capacity to form protease decreased exponentially with increasing density of the bacterial suspension. The synthesis of the enzyme was interrupted after the exhaustion of glucose. A repeated exchange of the medium made it possible to reach relatively high and continuous production of protease for several hours. The total amount of extracellular proteins synthesized during incubation of the dense suspension in media with or without a nitrogen source was less than 2% of a total of newly formed proteins. The amount of these extracellular proteins was slightly lower in the absence of Ca²⁺ being considerably decreased when the dense suspension was incubated with chloramphenicol.     

Regulation by Ammonium of Variation in Heterotrophic CO2 Fixation by Euglena gracilis During Growth Cycles*

SYNOPSIS Heterotrophic (dark) CO₂ fixation by Euglena gracilis strain Z varies with phase of batch culture growth and mode of nutrition. Increases in the fixation during growth cycles correlate closely with the depletion of exogenous NH₄* from the medium during growth. It is demonstrated that exogenous NH₄⁺ regulates a component of heterotrophic CO₂ fixation and that another component is independent of NH₄⁺. This is true for cells grown heterotrophically (glucose, dark), autotrophically (CO₂, light) and for a permanently bleached strain (E. gracilis SB3). Some kinetics of the NH₄⁺ regulation are presented.     

Overexpression of acid protease of <Emphasis Type="Italic">Saccharomycopsis fibuligera</Emphasis> in <Emphasis Type="Italic">Yarrowia lipolytica</Emphasis> and characterization of the recombinant acid protease for skimmed milk clotting

The gene encoding an acid protease natively produced by Saccharomycopsis fibuligera was cloned and overexpressed in Yarrowia lipolytica and the resultant recombinant acid protease was purified and characterized. The molecular mass of the purified enzyme was estimated as 94.8 kDa by gel filtration chromatography. The optimal pH and temperature of the purified acid protease were 3.5 and 33°C, respectively, and the enzyme was very stable over a pH range of 1.0 ∼ 3.0. The recombinant acid protease was activated by Zn²⁺, but was inhibited by Hg²⁺, Fe²⁺, Fe³⁺, and Mg²⁺, EDTA, EGTA, iodoacetic acid, and pepstatin. The purified recombinant acid protease from the positive transformant 71 had high milk clotting activity, suggesting that it may be used as a rennet substitute in the cheese industry.     

Purification and characterization of the cuticle-degrading protease produced by the entomopathogenic fungus,Beauveria bassiana in the presence of Sunn pest,Eurygaster integriceps (Hemiptera: Scutelleridae) cuticle

The extracellular protease from the entomopathogenic fungus, Beauveria bassiana in the presence of Eurygaster integriceps cuticle was isolated, purified and characterized. Isolate B1 of B. bassiana that shows high virulence against E. integriceps was examined for the production of the cuticle-degrading proteases. Results showed that both subtilisin-like (Pr1) and trypsin-like (Pr2) cuticle-degrading proteases were produced and the enzyme kinetic properties showed better activity of Pr1 in comparison with Pr2. The proteases were purified using acetone precipitation, Sephadex G-100 gel filtration and CM-Sepharose ion exchange chromatography, with a 5.09-fold increase in specific activity and 21.86% recovery. The enzyme molecular weight was estimated to be 47 kDa and the optimal pH and temperature were 8 and 45°C, respectively. The purified protease was activated by divalent cations, Ca^{2 +} and Mg^{2 +}, and inhibited by NaCl, KCl and determined as a serine protease by inhibition of its activity due to using PMSF, EDTA, mercaptoethanol and SDS. Studies on the timing of the protease secretion in the presence of cuticular substrates could provide information about the role of the accumulated hydrolytic enzymes during pathogenesis to better understand these processes.     

Studies on the production of extracellular protease by Alcaligenes faecalis

Alcaligenes faecalis produced extracellular protease when incubated in media containing protein substrates. Enzyme production was found to be influenced by various culture conditions. Enzyme production was growth-associated, expressed linearity with growth and reached a maximum at the end of the growth phase. Carbohydrates and inorganic nitrogen sources could not be utilized by the bacterium for its growth, and organic nitrogen appeared to be a primary determinant in protease production. Enzyme production reached its maximum level of 171.2 U/ml when the culture was incubated at 30 °C at pH 8.0. Ca²⁺ and Mg²⁺ enhanced the enzyme production. The crude enzyme powder was stable at high alkaline pH and stable upto 6 months at the storage temperature of 0–4 °C. This revised version was published online in July 2006 with corrections to the Cover Date.     

Purification and characterization of the cold-active alkaline protease from marine cold-adaptive <Emphasis Type="Italic">Penicillium chrysogenum</Emphasis> FS010

An extracellular cold-active alkaline serine protease from Penicillium chrysogenum FS010 has been purified. The purification procedure involved: ammonium sulfate precipitation, DEAE ion-exchange chromatography and sephadex G-100 gel chromatography. SDS–PAGE of the purified enzyme indicated a molecular weight of 41,000 ± 1,000 Da. The protease is stable in a pH range of 7.0–9.0 and has a maximum activity at pH 9.0. Compared with other industrial proteases, the enzyme shows a high hydrolytic activities at lower temperatures and a high sensitivity at a temperature over 50°C. The isoelectric point of the enzyme is approximate to 6.0. Enzymatic activity is enhanced by the addition of divalent cations such as Mg²⁺ and Ca²⁺ and inhibited by addition of Cu²⁺and Co²⁺. PMSF and DFP are its specific inhibitors. The application of the cold-active alkaline protease is extremely extensive, and widely used in detergents, feed, food, leather and many other industries.     

Purification and Characterization of a Fibrinolytic Protease from a Culture Supernatant of Flammulina velutipes Mycelia

In this study we purified a fibrinolytic enzyme from the culture supernatant of Flammulina velutipes mycelia by ion exchange and gel filtration chromatographies, it was designated as F. velutipes protease (FVP-I). This purification protocol resulted in 18.52-fold purification of the enzyme at a final yield of 0.69%. The molecular mass of the purified enzyme was estimated to be 37 kDa by SDS–PAGE, fibrin-zymography and size exclusion by FPLC. This protease effectively hydrolyzed fibrin, preferentially digesting α-chain over β-and γ–γ chain. Optimal protease activity was found to occur at a pH of 6.0 and a temperature of 20 to 30 °C. The protease activity was inhibited by Cu²⁺, Fe²⁺ and Fe³⁺ ions, but was found to be enhanced by Mn²⁺ and Mg²⁺ ions. Furthermore, FVP-I activity was potently inhibited by EDTA and EGTA, and it was found to exhibit a higher specificity for chromogenic substrate S-2586 for chymotrypsin, indicating that the enzyme is a chymotrypsin-like metalloprotease. The first 20 amino acid residues of the N-terminal sequence of FVP-I were LTYRVIPITKQAVTEGTELL. They had a high degree of homology with hypothetical protein CC1G_11771, GeneBank Accession no. EAU86463.     

Genetic and biochemical properties of an extracellular neutral metalloprotease from Staphylococcus hyicus subsp. hyicus

The gene encoding the extracellular neutral metalloprotease ShpI from Staphylococcus hyicus subsp. hyicus was cloned. DNA sequencing revealed an ORF of 1317 nucleotides encoding a 438 amino acid protein with Mr of 49698. When the cloned gene was expressed in Staphylococcus carnosus, a 42 kDa protease was found in the culture medium. The protease was purified from both S. carnosus (pCAshp1) and S. hyicus subsp. hyicus. The N-terminal amino acid sequences of the two proteases revealed that ShpI is organized as a pre-pro-enzyme with a proposed 26 amino acid signal peptide, a 75 amino acid hydrophilic pro-region, and a 337 amino acid extracellular mature form with a calculated Mr of 38394. The N-termini showed microheterogeneity in both host strains. ShpI had a maximum proteolytic activity at 55°C and pH 7.4–8.5. The protease, which had a low substrate specificity, could be inhibited by metal- and zinc-specific inhibitors, such as EDTA and 1,10-phenanthroline. Insensitivity to phosphoramidon separates ShpI from the thermolysin-like family. The conserved Zn²⁺ binding motif, the only homology to other proteases, and the reactivation of the apoenzyme by Zn²⁺, indicated that Zn²⁺ is the catalytic ion. Ca²⁺ very probably acts as a stabilizer. We also demonstrated the presence of a second extracellular protease in S. hyicus subsp. hyicus.     

A novel serine alkaline protease from Bacillus altitudinis GVC11 and its application as a dehairing agent

A serine alkaline protease from a newly isolated alkaliphilic Bacillus altitudinis GVC11 was purified and characterized. The enzyme was purified to homogeneity by acetone precipitation, DEAE-cellulose anion exchange chromatography with 7.03-fold increase in specific activity and 15.25% recovery. The molecular weight of alkaline protease was estimated to be 28 kDa by SDS PAGE and activity was further assessed by zymogram analysis. The enzyme was highly active over a wide range of pH 8.5 to 12.5 with an optimum pH of 9.5. The optimum temperature of purified enzyme was 45 °C and Ca²⁺ further increased the thermal stability of the enzyme. The enzyme activity was enhanced by Ca²⁺ and Mg²⁺ and inhibited by Hg²⁺. The present study is the first report to examine and describe production of highly alkaline protease from Bacillus altitudinis and also its remarkable dehairing ability of goat hide in 18 h without disturbing the collagen and hair integrity.     

Biochemical properties of a serine protease from Aspergillus flavus and application in dehairing

The proteases are enzymes produced by several filamentous fungi with important biotechnological applications. In this work, a protease from Aspergillus flavus was characterized. The culture filtrate of A. flavus was purified to homogeneity by Sephacryl S-200 column chromatography followed by CM–cellulose. The molecular weight of the purified enzyme was estimated to be approximately 32?kDa by SDS–PAGE. The enzyme hydrolysed BTpNA (N-α-benzoyl-dl-tyrosyl-p-nitroanilide), azo-casein and casein as substrates. Optimal temperature and pH were 55?°C and 6.5, respectively. The enzyme was stimulated by Mg²⁺, Ca²⁺, Zn²⁺ and inhibited by Hg²⁺ and Ag²⁺ and Cu²⁺. The protease showed increased activity with detergents, such as Tween 80 and Triton X, and was stable to the reducing agents, such as β-mercaptoethanol. The protease activity was strongly inhibited in the presence of phenylmethylsulfonyl fluoride, indicating it is a serine protease. The enzyme entrapped in calcium alginate beads retained its activity for longer time and could be reused up to 10 times. The thermostability was increased after the immobilization and the enzyme retained 100% of activity at 45?°C after 60?min of incubation, and 90% of residual activity at 50?°C after 30?min. In contrast, the free enzyme only retained 10% of its residual activity after 60?min at 50?°C. The enzymatic preparation was demonstrated to be efficient in the capability of dehairing without destruction of the hide. The remarkable properties such as temperature, pH and immobilization stability found with this enzyme assure that it could be a potential candidate for industrial applications.     

Characterization of a keratinolytic protease produced by the feather-degrading Amazonian bacterium Bacillus sp. P45

Abstract

An extracellular keratinolytic protease produced by Bacillus sp. P45 was purified and characterized. The keratinase had a molecular weight of approximately 26 kDa and was active over wide pH and temperature ranges, with optimal activity at 55°C and pH 8.0. However, this enzyme displayed low thermostability, being completely inactivated after 10 min at 50°C. Keratinase activity increased with Ca²⁺, Mg²⁺, Triton X-100, ethanol and DMSO, was stable in the presence of the reducing agent 2-mercaptoethanol, and was inactivated by SDS. PMSF (phenylmethylsulfonyl fluoride) completely inactivated and EDTA strongly inhibited the enzyme, indicating that the keratinase is a serine protease depending on metal ions for optimal activity and/or stability. Accordingly, analysis of tryptic peptides revealed sequence homologies which characterize the keratinase as a subtilisin-like serine protease. The purified enzyme was able to hydrolyze azokeratin and keratin azure. Casein was hydrolyzed at higher rates than keratinous substrates, and 2-mercaptoethanol tended to enhance keratin hydrolysis. With synthetic substrates, the keratinase showed a preference for aromatic and hydrophobic residues at the P1 position of tetrapeptides; the enzyme was not active, or the activity was drastically diminished, towards shorter peptides. Keratinase from Bacillus sp. P45 might potentially be employed in the production of protein hydrolysates at moderate temperatures, being suitable for the bioconversion of protein-rich wastes through an environmentally friendly process requiring low energy inputs.