Purification and Some Properties of Cellulases from Aspergillus niger

Four types of cellulases, FI-1-b, FI-2-b, FI-2-c, and FII, were obtained from a commercial crude cellulase preparation produced from a water extract of a culture of A. niger.

Ammonium sulfate fractionation and column chromatography using DEAE-Sephadex A-25, Amberlite IRC-50 and Hydroxylapatite were employed for the purification of these cellulases.

Some properties of these enzymes were investigated: the optimum pH for the hydrolysis of glycol cellulose by FI-2-b and FI-2-c was pH 4.0 to 5.0, while that of FI-1-b was pH 2.3 to 2.5, and the optimum temperature for the activity of FI-2-b and FI-2-c was 40°C, but that of FI-1-b was 65°C.

The FII seemed to be most active toward cellobiose. Studies of the mode of action on glycol cellulose indicated that A. niger cellulases seemed not to be capable of attacking highly polymerized cellulose.     

Cellulases from Sporocytophaga myxococcoides. Purification and Properties.

Two extracellular cellulases active on carboxymethylcellulose have been isolated from the culture supernatant of Sporocytophaga myxococcoides by a series of gel-filtration and ion-exchange chromatography steps. Cellulase II, being present in highest amount, had a molecular weight determined by gel electrophoresis of 52000, pI 4.75 and a relatively broad pH optimum (5.5--7.5). Cellulase I had a molecular weight of 46000. pI was 7.5 and the pH optimum 6.5--7.5. Both cellulases had a very low carbohydrate content, possibly present as impurities. They had fairly similar amino acid compositions. The specific acitivity of cellulase I was about 6 times higher than that of cellulase II. Both cellulases acted as endoglucanases. A cell-associated cellulase, present in amounts corresponding to about 10% of total activity, was partly purified. It showed similarities with cellulase II.     

Purification and Properties of Cyclodextrin Glycosyltransferase of an Alkalophilic Bacillus sp.

Extracellular cyclodextrin glycosyltransferase (α-1,4-glucan 4-glycosyltransferase, cyclizing, EC 3.2.1.19) of an alkalophilic Bacillus sp. (ATCC 21783) was purified about 74-fold and shown to be a single, homogeneous protein by disc polyacryl amide gel electrophoresis and ultracentrifugation. The molecular weight and isoelectric point were 88,000 and pH 5.4. The optimum pH for the enzyme action was 4.5-4.7. The apparent V_max and Km values for α-, β- and γ-cyclodextrin at the constant concentration of sucrose were 133.3, 23.4, 12.3 µmoles glucose/min per mg protein and 5.88, 0.39, 0.25 mm, respectively. The enzyme converted about 73% of starch, 65% of amylopectin, 45% of glycogen and 25% of amylopectin (β-limit dextrin to cyclodextrins.     

Purification and Properties of Neutral-cyclodextrin Glycosyl-transferase of an Alkalophilic Bacillus sp.

Neutral-cyclodextrin glycosyltransferase (EC 3.2.1.19) of alkalophilic Bacillus sp. (ATCC 21783) was purified by starch adsorption, DEAE-cellulose chromatography and Sephadex G–150 gel filtration chromatography followed by preparative polyacrylamide gel electrophoresis. Molecular weight of the purified enzyme was 85,000-88,000 by SDS-disc gel electrophoresis. The enzyme was most active at pH 7 and 50°C, and stable up to 60°C at pH 7 and in the range of pH 6~8 at 60°C by 30 min incubation. The apparent V_max and Km values for α- and β-cyclodextrin at a constant concentration of sucrose were 417, 70 µmoles glucose/min · mg protein and 10, 0.83 nm, respectively. About 85~90% of amylose, 75~80% of potato starch, 65~70% of amylopectin, 55~60% of glycogen, 45~50% of amylopectin β-limit dextrin, 20~25% of maltotriose and 10~15% of maltose were converted to cyclodextrins with 0.5~1% (w/v) of each substrate.

Schardinger β-dextrin was preferentially produced from starch, and α- or γ-dextrin was gradually formed after prolonged incubation. After 20 min incubation, about 0.4, 14 and 2.5% of α-, β- and γ-dextrin were formed from starch, respectively.     

Purification and Characterization of Two Xylanases from Alkalophilic Cephalosporium sp. Strain RYM-202

Two different xylanases, CX-I and CX-II, from an alkalophilic fungus, Cephalosporium sp. strain RYM-202, have been purified to homogeneity. The enzymes had similar pH (7.5 to 8.0) and temperature (50(deg)C) optima and were stable over a wide pH range of 5.5 to 12.0. Both enzymes were shown to be cellulase-free endoxylanases with transglycosidation activity.     

Purification and Properties of d-Xylose Isomerase from Alkalophilic Bacillus No. KX-6

An alkalophilic Bacillus No. KX-6 isolated from soil produced a d-xylose isomerase in alkaline media. The striking characteristic of this bacterium was its especially good growth in alkaline media. The d-xylose isomerase of this bacterium was purified by ammonium sulfate fractionation, DEAE-Sepharose ion exchange column chromatography and G-200 gel Alteration. The molecular weight and sedimentation constant were approximately 120,000 and 9.35 S, respectively. The enzyme was most active at pH 7~10 and was stable at pH 6.0 to 11.0. Enzyme activity was stimulated by cobalt ion but inhibited by Hg^{2 +}, Ag^{2 +}, and Cu^{2 +}. Substrate specificity studies showed that this enzyme was active on d-xylose, d-glucose, d-ribose, and d-arabinose. The smaller Km value and larger V_max value for d-xylose indicated that this enzyme is essentially d-xylose isomerase.     

Purification and Characterization of a Maltotetraose-Forming Alkaline (alpha)-Amylase from an Alkalophilic Bacillus Strain, GM8901

An alkalophilic bacterium, Bacillus sp. strain GM8901, grown at pH 10.5 and 50(deg)C, produced five alkaline amylases in culture broth. At an early stage of the bacterial growth, amylase I (Amyl I) was produced initially and then, as cultivation progressed, four alkaline amylases, Amyl II, Amyl III, Amyl IV, and Amyl V, were produced from proteolytic degradation of Amyl I. A serine protease present in the culture medium was believed to be involved in Amyl I degradation. We purified Amyl I from the culture supernatant by ammonium sulfate precipitation, heparin-Sepharose CL-6B column chromatography, phenyl-Toyopearl column chromatography, and Mono Q HR5/5 high-performance liquid chromatography. The molecular weight of Amyl I was estimated to be about 97,000 by sodium dodecyl sulfate-polyacrylamide gel electrophoresis. Amyl I had an extremely high optimal pH of 11.0 to 12.0 and was stable in a broad pH range of 6.0 to 13.0. Amyl I had an optimal temperature of 60(deg)C and was stable up to 50(deg)C. Thermostability was increased in the presence of Ca(sup2+) and soluble starch. The enzyme required metal ions such as Ca(sup2+), Mg(sup2+), Cu(sup2+), Co(sup2+), Ag(sup+), Zn(sup2+), and Fe(sup2+) for its enzyme activity and was inhibited by 1 mM EDTA and 1 mM phenylmethylsulfonyl fluoride. According to the mode of action of Amyl I on starch, Amyl I was classified as an (alpha)- and exo-amylase. Amyl I produced maltotetraose predominantly from starch via intermediates such as maltohexaose and maltopentaose.     

Purification and Properties of Hypoxanthine Phosphoribosyltransferase from Streptomyces cyanogenus

Hypoxanthine phosphoribosyltransferase (EC 2.4.2.8) of a strain of Streptomyces cyanogenus was purified 1,900-fold to an apparent homogenity from cell-free extracts. The enzyme had a molecular weight of 150,000 and consisted of eight identical subunits with a molecular weight of 18,000. The isoelectric point was at pH 4.4. The enzyme required Mg²⁺ or Ma²⁺ for activity and had a pH optimum at 8.5. Hypoxanthine and guanine were good substrates for the enzyme. Xanthine was a very poor substrate and adenine was not a substrate. Apparent Km values of the enzyme for hypoxanthine, guanine and 5-phosphoribose-1-pyro-phosphate were 1.6 × 10^?8, 2.7 × 10^?6 and 6.3 × 10^?5 m, respectively. All purine nucleotides tested inhibited the activity significantly, apparently by competing with 5-phosphoribose-1-pyrophosphate.     

Purification and Properties of Phospholipase D from Streptomyces antibioticus

Phospholipase D was purified from Streptomyces antibioticus by column chromatography and chromatofocusing. The enzyme preparation was electrophoretically homogeneous and the molecular weight of the enzyme was estimated to be 64,000. Its isoelectric point was around pH 6.5. The enzyme was most active at pH 5.5 and at around 60°C. It was stable between pH 4 and 8, and below 50°C.     

特异腐质霉纤维素酶的分离纯化与性质

特异腐质霉Humicola insolens(YH-8)能高效合成高稳定性的纤维素酶.由该菌株所产的纤维素酶粗液经过1.5倍酒精沉淀、DEAE-SephadexA-50离子交换层析,SephadexG-100凝胶过滤,得到电泳纯的纤维素酶组分一个.对这个组分的催化性质(以羧甲基纤维素为底物)进行了研究,该酶的最适催化温度60℃,pH值为5.5,在50℃以下酶的稳定性较好,70℃条件下底物对酶有较强的保护作用,该酶的pH稳定性范围为4～8,zn2 ,ca2 ,Mg2 ,K ,Li 对酶活有促进作用,Mn2 、Co2 、Fe2 、Fe2 对酶活起抑制作用,酶对CMC-Na和水杨素有分解作用,而不分解脱脂棉和滤纸.     

Purification and Some Properties of a Protease from Streptomyces limosus

Streptomyces limosus was selected because it secreted a novel protease that catalyzed the synthetic reaction forming Pro-Pro-Pro from Pro-Pro. The protease was purified to an electrophoretically homogeneous state and an activity of more than about 20,000-fold that of the culture broth. The molecular mass of the enzyme was estimated to be 50 kDa by SDS-polyacrylamide gel electrophoresis. The enzyme was most active in alkaline pH for the synthetic reaction producing Pro-Pro-Pro from Pro-Pro, although for the hydrolytic reaction forming proline it was most active in neutral pH. The enzyme was inhibited by 1,2-epoxy-3-(p-nitrophenoxy)propane (EPNP) and diazoacetyl-DL-norleucine methyl ester (DAN). It can be considered that this enzyme belongs to the class of aspartic proteases. The substrate specificity indicates that this enzyme has a strong affinity for proline as a N-terminal amino acid of peptides.     

Purification and Properties of Lytic Enzymes from Streptomyces globisporus 1829

Two lytic enzymes capable of lysing Streptococcus mutans have been purified to give a single band on disc-gel electrophoresis, respectively. The M–1 and M–2 enzymes were both proved to be N-acetylmuramidases. However, these enzymes were entirely different on their enzymatic properties. The molecular weights were about 20,000 and 11,000 for M–1 and M–2 enzymes, respectively, The maximal lytic activity of M–1 enzyme was obtained at ionic strength 0.05, while lytic activity of M–2 enzyme did not change within the ionic strength range of 0 to 0.05. The M–1 enzyme constituted the majority of the total lytic activity against the cell walls of Streptococcus mutans BHT of cultured filtrate. The M–2 enzyme showed less specific lytic activity on the cell walls of Streptococcus mutans BHT than M–1 enzyme.     

Action and Specificity of a Streptomyces Alkalophilic Proteinase

Action of the crystalline alkalophilic proteinase of a Streptomyces sp. which was active at pH values around 13, was investigated. The enzyme attacked various keratinous proteins such as wool, hair, feather etc., dissolving them with hydrolysis degrees from 2 to 6%, and the degradation of several keratins was observed under a microscope and scanning electron-microscope. Specificity of the enzyme was also studied using oxidized insulin B-chain. The enzyme cleaved most easily the peptide linkages between -Ser · His-, -Leu · Val-, -Phe · Tyr- and -Lys · Ala-, though it split several other sites of oxidized insulin B-chain, too, indicating that the action pattern of the proteinase is distinguished from those of alkaline proteinases so far reported.     

Cellulases of Thermomonospora fusca and Streptomyces thermodiastaticus

The cellulases of Streptomyces thermodiastaticus (strain 2Sts) and thermomonospora fusca (strain 190Th) were produced with carboxymethyl-cellulose (CMC) serving as the carbon source during growth. Both cellulases act by random internal hydrolysis of the CMC chain, producing cellobiose, glucose, and intermediate length oligosaccharides. Cellobiase was not detected in culture filtrates produced under these conditions.     

Purification and characterization of an exoglucanase from Streptomyces flavogriseus

Streptomyces flavogriseus, a mesophilic actinomycete, produces high levels of extracellular enzymes capable of hydrolyzing cellulose and xylan. One such enzyme, an exoglucanase, has been purified to molecular homogeneity by a sequence involving DEAE Bio-Gel A chromatography, gel permeation chromatography on Bio-Gel P-60, preparative isoelectric focusing, and concanavalin A affinity chromatography. This purification sequence disclosed the presence of several distinct endoglucanase and xylanase fractions. Homogeneity of the purified enzyme was demonstrated by analytical isoelectric focusing and sodium dodecyl sulphate--polyacrylamide gel electrophoresis. The purified enzyme had a molecular weight of approximately 45 000 and an isoelectric point of 4.15. The enzyme demonstrated negligible activity with carboxymethylcellulose as the substrate. It was able to extensively hydrolyse acid-swollen cellulose; the main product of enzyme action was cellobiose.     

Purification and Properties of an Extracellular Agarase from Alteromonas sp. Strain C-1

A marine bacterial strain isolated from the Bay of San Vicente, Chile, was identified as Alteromonas sp. strain C-1. In the presence of agar, this strain produced high levels of an extracellular agarase. The production of agarase was repressed by glucose, with a parallel decrease in bacterial growth. The enzyme was purified to homogeneity by anion-exchange chromatography and gel filtration, with an overall yield of 45%. The enzyme has a molecular weight of 52,000, is salt sensitive, and hydrolyzes agar, yielding neoagarotetraose as the main product, with an optimum pH of about 6.5.     

Purification and Properties of Lipase Activator Produced by Streptomyces sp. Strain No. BR-1381

To obtain actinomycetes capable of producing new enzyme affectors such as enzyme inhibitors or activators, a screening test was carried out. Streptomyces sp. strain No. BR-1381 isolated in our laboratory produced a proteinous lipase activator abbreviated as LAV. LAV was purified from the culture filtrate by salting-out with ammonium sulfate, DEAE-cellulose column chromatography and gel filtration on Sephadex G-100. LAV was stable in the pH range from 3 to 7 at 37°c for 20 hr and in a wider range of pH at 4°C for 5 days. LAV itself was very stable against heat treatment, but LAV did not have any effect on the thermal stability of Phycomyces nitens lipase. LAV activated several microbial lipases, but did not activate pancreatic or rice bran lipases. LAV particularly showed strong activation for Phycomyces nitens lipase.     

Purification and characterization of an alkaline keratinase from Streptomyces sp

A protease producing bacterial culture ('S7') was isolated from slaughterhouse waste samples, Hyderabad, India. It was related to Streptomyces sp. on the basis of biochemical properties and 16S rRNA gene sequencing. Purification of the protease present in the culture medium supernatant on sephacryl S-100 indicated that it contains a keratinase with 67% recovery, 2.5-fold purification and an estimated molecular mass of approximately 44,000 Da. Keratinase showed an optimal activity at 45 degrees C and pH 11. Keratinase activity increased substantially in presence of Ca(2+) and was inhibited in presence of PMSF and EDTA identifying it as a serine metalloprotease. Stability in the presence of detergents, surfactants and solvents make this keratinase extremely useful for biotechnological process involving keratin hydrolysis or in the leather industry.