Occurrence of 3-Hydroxy-3-methyl-glutaryl Coenzyme A Reductase in Sweet Potato

Illumination of the dark-grown Euglena gracilis, both the wild-green type and a permanently bleached mutant, for 4 hr at 2,000 lux caused about 6-fold increase of the cellular content of total l-ascorbic acid. The increase was mainly due to an increase of reduced-form l-ascorbic acid. From the action spectrum only blue light was found to be effective for the increase. Darkening stopped the increase and reillumination started a renewed increase. The activity of l-gulono-γ-lactone dehydrogenase, catalyzing the last step of l-ascorbic acid biosynthesis, was also increased two fold by illumination for 2 hr, and was changed in parallel to that of the cellular content of l-ascorbic acid depending on the presence or absence of illumination. The augmentation of l-ascorbic acid formation was markedly inhibited by various inhibitors and uncouplers, but not by dichlorophenyldimethylurea. The results in sum suggest that the light-dependent increase of l-ascorbic acid formation in E. gracilis is not primarily associated with photosynthesis, but is apparently related to the adaptation of the dark-grown cells to the illuminated state.     

Continuous Production of l-Alanine with NADH Regeneration by a Nanofiltration Membrane Reactor

A conjugated enzyme system, alanine dehydrogenase (AIDH) for stereospecific reduction of pyruvate to l-alanine and glucose dehydrogenase (GDH) for regeneration of NADH, were coimmobilized in a nanofiltration membrane bioreactor (NFMBR) for the continuous production of l-alanine from pyruvate with NADH regeneration. Since pyruvate was proved to be unstable at neutral pH, it was kept under acidic conditions and supplied to NFMBR separately from the other substrates. As 0.2 m pyruvate in HCl solution (pH 4), 10 mm NAD, 0.2 m glucose, and 0.2 m NH₄Cl in 0.5 m Tris buffer (pH 8) were continuously supplied to NFMBR with immobilized AIDH (100 U/ml) and GDH (140 U/ml) at the retention time of 80 min, the maximum conversion, reactor productivity, and NAD regeneration number were 100%, 320 g/liter/d, and 20,000, respectively. To avoid the effect of pyruvate instability, a consecutive reaction system, lactate dehydrogenase (l-LDH) and AIDH, was also used. In this system, the l-LDH provides pyruvate, the substrate for the AIDH reaction, from l-lactate regenerating NADH simultaneously, so the pyruvate could be consumed as soon as it was produced. As 0.2 m l-lactate, 10 mm NAD, 0.2 m NH₄Cl in 0.5 m Tris buffer (pH 8) were continuously supplied to NFMBR with immobilized l-LDH (100 U/ml) and AIDH (100 U/ml) at the retention time of 160 min, the maximum conversion, reactor productivity, and the NAD regeneration number were 100%, 160 g/Iiter/d, and 20,000, respectively.     

Monodehydro-2,2′-iminodi-2(2′)-deoxy-l-ascorbic Acid,a Radical Product from the Reaction of Dehydro-l-ascorbic Acid with an α-Amino Acid

One of the radical species produced by the reaction of dehydro-l-ascorbic acid with an α-amino acid gave a very characteristic hyperfine structure in its electron spin resonance spectrum. The same spectrum was also obtained when l-scorbamic acid was oxidized with some oxidants, indicating the formation of the radical via the oxidation of l-scorbamic acid. From the results of deuterium exchange experiments, simulation spectra and the reduction of 2,2′-nitrilodi-2(2′)-deoxy-l-ascorbic acid monoammonium salt, the radical was concluded to be monodehydro-2,2′-iminodi-2(2′)-deoxy-l-ascorbic acid. Possible formation mechanism of the radical was also discussed.     

Conversion of the Extracellular Dextransucrase Isoenzymes from Leuconostoc mesenteroides NRRL B-1299

Effect of oxygen tension on l-lysine, l-threonine and l-isoleucine accumulation was investigated. Sufficient supply of oxygen to satisfy the cell’s oxygen demand was essential for the maximum production in each fermentation. The dissolved oxygen level must be controlled at greater than 0.01 atm in every fermentation, and the optimum redox potentials of culture media were above ?170 mV in l-lysine and l-threonine and above ?180 mV in l-isoleucine fermentations. The maximum concentrations of the products were 45.5 mg/ml for l-lysine, 10.3 mg/ml for l-threonine and 15.1 mg/ml for l-isoleucine. The degree of the inhibition due to oxygen limitation was slight in the fermentative production of l-lysine, l-threonine and l-isoleucine, whose biosynthesis is initiated with l-aspartic acid, in contrast to the accumulation of l-proline, l-glutamine and l-arginine, which is biosynthesized by way of l-glutamic acid.     

Branched Chain Amino Acid Aminotransferase of Pseudomonas sp

Branched chain amino acid aminotransferase was partially purified from Pseudomonas sp. by ammonium sulfate fractionation, aminohexyl-agarose and Bio-Gel A-0.5 m column chromatography.

This enzyme showed different substrate specificity from those of other origins, namely lower reactivity for l-isoleucine and higher reactivity for l-methionine.

Km values at pH 8.0 were calculated to be 0.3 mm for l-leucine, 0.3 mm for α-ketoglutarate, 1.1 mm for α-ketoisocaproate and 3.2 mm for l-glutamate.

This enzyme was activated with β-mercaptoethanol, and this activated enzyme had different kinetic properties from unactivated enzyme, namely, Km values at pH 8.0 were calculated to be 1.2 mm for l-leucine, 0.3 mm for α-ketoglutarate.

Isocaproic acid which is the substrate analog of l-leucine was competitive inhibitor for pyridoxal form of unactivated and activated enzymes, and inhibitor constants were estimated to be 6 mm and 14 mm, respectively.     

Current studies on the enzymatic preparation 2-O-α-d-glucopyranosyl-l-ascorbic acid with cyclodextrin glycosyltransferase

2-O-α-d-glucopyranosyl-l-ascorbic acid (AA-2G) is one of the most important l-ascorbic acid derivatives because of its resistance to reduction and oxidation and its easy degradation by α-glucosidase to release l-ascorbic acid and glucose. Thus, AA-2G has commercial uses in food, medicines and cosmetics. This article presents a review of recent studies on the enzymatic production of AA-2G using cyclodextrin glycosyltransferase. Reaction mechanisms with different donor substrates are discussed. Protein engineering, physical and biological studies of cyclodextrin glycosyltransferase are introduced from the viewpoint of effective AA-2G production. Future prospects for the production of AA-2G using cyclodextrin glycosyltransferase are reviewed.     

Regulatory Properties of Chorismate Mutase from Corynebacterium glutamicum

Regulatory properties of chorismate mutase from Corynebacterium glutamicum were studied using the dialyzed cell-free extract. The enzyme activity was strongly feedback inhibited by l-phenylalanine (90% inhibition at 0.1~1 mm) and almost completely by a pair of l-tyrosine and l-phenylalanine (each at 0.1~1 mm). The enzyme from phenylalanine auxotrophs was scarcely inhibited by l-tyrosine alone but the enzyme from a wild-type strain or a tyrosine auxotroph was weakly inhibited by l-tyrosine alone (40~50% inhibition, l-tyrosine at 1 mm). The enzyme activity was stimulated by l-tryptophan and the inhibition by l-phenylalanine alone or in the simultaneous presence of l-tyrosine was reversed by l-tryptophan. The Km value of the reaction for chorismate was 2.9 } 10^?3 m. Formation of chorismate mutase was repressed by l-phenylalanine. A phenylalanine auxotrophic l-tyrosine producer, C. glutamicum 98–Tx–71, which is resistant to 3-amino-tyrosine, p-aminophenylanaine, p-fluorophenylalanine and tyrosine hydroxamate had chorismate mutase derepressed to two-fold level of the parent KY 10233. The enzyme in C. glutamicum seems to have two physiological roles; one is the control of the metabolic flow to l-phenylalanine and l-tyrosine biosynthesis and the other is the balanced partition of chorismate between l-phenylalanine-l-tyrosine biosynthesis and l-tryptophan biosynthesis.     

Studies on the Pentose Isomerases of Lactic Acid Bacteria

Production of d-xylose and l-arabinose isomerases by lactic acid bacteria was greatly promoted by the addition of manganese ions in cultural medium. Effective concentration of the ions was 5 × 1O^-3 m. Ferrous ions were also effective for the production of d-xylose isomerase and cobaltous ions were somewhat effective for the production of l-arabinose isomerase. Zinc and cadmium ions inhibited bacterial growth. It was possible to increase the production of isomerase by changing MnSO₄ concentration to 5× 10^-3 m (0.l1 %) in place of 0.001 per cent in the normal medium.

Column chromatographic procedures for the purification of pentose isomerases were carried out. Cation and anion exchange resins were not suitable because of their low exchange capacities and instability of the enzyme at acidic pH range. But the isomerases were successfully purified by DEAE-cellulose column chromatography with high recovery (85~90%). Using a Tris buffer, KCl concentration was increased in gradient. d-Xylose isomerase was eluted at pH 7.0 at 0~0.2 m KCl, and l-arabinose isomerase at pH 8.0 at 0~0.4 m KCl. The purified isomerases, d-xylose isomerase and l-arabinose isomerase, both required manganese ions specifically for their activities.

D-Xylose isomerase and l-arabinose isomerase are different enzymes which can be separated from each other with acetone fractionation at pH 4.8~5.0, heat treatment or chromatography on a colnmn of DEAE-cellulose. In DEAE-cellulose chromatography with a linear gradient elution method, d-xylose isomerase is recovered in the first peak at pH 7.0 (Tris bnffer) with 0~0.2 m KCl, and l-arabinose isomerase is eluted in the second peak at pH 8.0 (Tris buffer) with a larger ionic strength.     

Regulatory Properties of Prephenate Dehydrogenase and Prephenate Dehydratase from Corynebacterium glutamicum

Regulatory properties of the enzymes in l-tyrosine and l-phenyalanine terminal pathway in Corynebacterium glutamicum were investigated. Prephenate dehydrogenase was partially feedback inhibited by l-tyrosine. Prephenate dehydratase was strongly inhibited by l-phenylalanine and l-tryptophan and 100% inhibition was attained at the concentrations of 5 × 10^?2mm and 10^?1mm, respectively. l-Tyrosine stimulated prephenate dehydratase activity (6-fold stimulation at 1 mm) and restored the enzyme activity inhibited by l-phenylalanine or l-tryptophan. These regulations seem to give the balanced synthesis of l-tyrosine and l-phenyl-alanine. Prephenate dehydratase from C. glutamicum was stimulated by l-methionine and l-leucine similarly to the enzyme in Bacillus subtilis and moreover by l-isoleucine and l-histidine. C. glutamicum mutant No. 66, an l-phenylalanine producer resistant to p-fluorophenyl-alanine, had a prephenate dehydratase completely resistant to the inhibition by l-phenylalanine and l-tryptophan.     

A Novel Synthesis of l-Ascorbic Acid

A three steps synthesis of l-ascorbic acid (I) from d-glucuronolactone (III) is described.     

Purification and Crystallization of d-Arabinose (l-Fucose) Isomerase from Aerobacter aerogenes by Polyethylene Glycol

d-Arabinose(l-fucose) isomerase (d-arabinose ketol-isomerase, EC 5.3.1.3) was purified from the extracts of d-arabinose-grown cells of Aerobacter aerogenes, strain M-7 by the procedure of repeated fractional precipitation with polyethylene glycol 6000 and isolating the crystalline state. The crystalline enzyme was homogeneous in ultracentrifugal analysis and polyacrylamide gel electrophoresis. Sedimentation constant obtained was 15.4s and the molecular weight was estimated as being approximately 2.5 × 10⁵ by gel filtration on Sephadex G-200.

Optimum pH for isomerization of d-arabinose and of l-fucose was identical at pH 9.3, and the Michaelis constants were 51 mm for l-fucose and 160 mm for d-arabinose. Both of these activities decreased at the same rate with thermal inactivation at 45 and 50°C. All four pentitols inhibited two pentose isomerase activities competitively with same Ki values: 1.3–1.5 mm for d-arabitol, 2.2–2.7 mm for ribitol, 2.9–3.2 mm for l-arabitol, and 10–10.5 mm for xylitol. It is confirmed that the single enzyme is responsible for the isomerization of d-arabinose and l-fucose.     

Substrate Specificity of Alkaline Proteinases from Aspergillus sydowi and Aspergillus sulphureus

l-Fucose (l-galactose) dehydrogenase was isolated to homogeneity from a cell-free extract of Pseudomonas sp. No 1143 and purified about 380-fold with a yield of 23 %. The purification procedures were: treatment with polyethyleneimine, ammonium sulfate fractionation, chromatographies on phenyl-Sepharose and DEAE-Sephadex, preparative polyacrylamide gel electrophoresis, and gel filtration on Sephadex G-100. The enzyme had a molecular weight of about 34,000. The optimum pH was at 9 — 10.5 and the isoelectric point was at pH 5.1. l-Fucose and l-galactose were effective substrates for the enzyme reaction, but d-arabinose was not so much. The anomeric requirement of the enzyme to l-fucose was the β-pyranose form, and the reaction product from l-fucose was l-fucono- lactone. The hydrogen acceptor for the enzyme reaction wasNADP⁺, and NAD ⁺ could be substituted for it to a very small degree. Km values were 1.9mm, 19mm, 0.016mm, and 5.6mm for l-fucose, l- galactose, NADP⁺, and NAD⁺, respectively. The enzyme activity was strongly inhibited by Hg^{2 +}, Cd^{2 +}, and PCMB, but metal-chelating reagents had almost no effect. In a preliminary experiment, it was indicated that the enzyme may be usable for the measurement of l-fucose.     

An Aminopeptidase of Aspergillus sojae

An aminopeptidase was purified from Aspergillus sojae X–816. The molecular weight of the enzyme was estimated to be 220,000. The isoelectric point was at pH 5.3. The optimum pH for l-leucylglycylglycine was 7.5. The enzyme was stable up to 37°C against temperature treatment for 15 min. Some chelating agents inhibited the enzyme activity. The Km value for l-leucylglycylglycine at pH 7.5 and 37°C was 45 mm. The Km value for l-leucyl-β-naphthylamide at pH 7.0 and 37°C was 2.2 mm.     

Determination Method for l-Ascorbic Acid in Foods with Immobilized Ascorbate Oxidase

Pumpkin (Cucurbita moschata) ascorbate oxidase was entrapped within 6% (w/v) Ca-alginate gel beads, and then the beads were treated with 1% (w/v) glutaraldehyde for 20 hr at 4°C. The immobilized ascorbate oxidase was much more stable than the free form. Under the optimum conditions, the immobilized enzyme remained fully active for 3 months and after 50 assays. A linear relationship was found between immobilized ascorbate oxidase activity and l-ascorbic acid concentration in the range of 2 ~ 20 μg/ml. The immobilized preparation could be employed for the simple and rapid determination of l-ascorbic acid in foods.     

Inhibition of l-Alanine Adding Enzyme by Glycine

l-Alanine adding enzymes from Bacillus subtilis and Bacillus cereus which catalyzed l-alanine incorporation into UDPMurNAc were partially purified and the properties of the enzymes were examined. The enzyme from B. subtilis was markedly stimulated by reducing agents including 2-mercaptoethanol, dithiothreitol, glutathione and cysteine. Mn²⁺ and Mg²⁺ activated l-alanine adding activity and their optimal concentrations were 2 to 5 mm and 10 mm, respectively. The optimum pH was 9.5 and the Km for l-alanine was 1.8×10^?4m. l-Alanine adding reaction was strongly inhibited by p-chloromercuribenzoate and N-ethyl-maleimide. Among glycine, l- and d-amino acids and glycine derivatives, glycine was the most effective inhibitor of the l-alanine adding reaction. The enzyme from B. cereus was more resistant to glycine than that from B. subtilis. Glycine was incorporated into UDPMurNAc in place of l-alanine, and the Ki for glycine was 4.2×l0^?3m with the enzyme from B. subtilis. From these data, the growth inhibition of bacteria by glycine is discussed.     

Biosynthetic Threonine Deaminase from Proteus morganii

Biosynthetic threonine deaminase was purified to an apparent homogeneous state from the cell extract of Proteus morganii, with an overall yield of 7.5%. The enzyme had a s⁰_20,w of 10.0 S, and the molecular weight was calculated to be approximately, 228,000. The molecular weight of a subunit of the enzyme was estimated to be 58,000 by sodium dodecyl sulfate gel electrophoresis. The enzyme seemed to have a tetrameric structure consisting of identical subunits. The enzyme had a marked yellow color with an absorption maximum at 415 nm and contained 2 mol of pyridoxal 5′-phosphate per mol. The threonine deaminase catalyzed the deamination of l-threonine, l-serine, l-cysteine and β-chloro-l-alanine. Km values for l-threonine and l-serine were 3.2 and 7.1 mm, respectively. The enzyme was not activated by AMP, ADP and ATP, but was inhibited by l-isoleucine. The Ki for l-isoleucine was 1.17 mm, and the inhibition was not recovered by l-valine. Treatment with mercuric chloride effectively protected the enzyme from inhibition by l-isoleucine.     

Kinetic Study on the Formation of Tripeptide Amide by the Protease from Streptomyces cellulosae

The protease from Streptomyces cellulosae preferentially catalyzed the condensation reaction producing tripeptide amides in highly concentrated mixture solutions of various dipeptides and amino acid amides, although it weakly hydrolyzed the substrates at the same time. The tripeptide amides formed were l-Leu-Gly-Gly-NH₂ (P_LGGN) from l-Leu-Gly and Gly-NH₂ and l-Leu-Gly-l-Leu-NH₂ (P_LGLN) from l-Leu-Gly and l-Leu-NH₂. Moreover, the ratio of the rate of P_LGLN formation per the proteolytic activity of this enzyme was much larger than those of the other proteases tested.

The formation of P_LGLN was studied at various concentrations of the substrates (l-Leu-Gly and. l-Leu-NH₂). The dependences of the initial velocities of P_LGLN formation on the substrates concentrations could be explained by a two-substrate, one-product reaction mechanism involving a single active center forming the peptide bonds and two substrate-binding sites. The values of the substrate dissociation constants for enzyme-substrate complexes were about 0.6 m for l-Leu-Gly and 0.008 m for l-Leu-NH₂.     

2-Keto-l-gulonic Acid Fermentation

l-Sorbose metabolism in Pseudomonas aeruginosa IFO 3898 was studied. When the strain was cultivated in l-sorbose medium, l-idonic and 2-keto-l-gulonic acids were detected in the culture broth.

From the results on the metabolism of various sugars and sugar acids with the cell suspension and the metabolites accumulated, the following pathway was proposed for the l-sorbose metabolism in Ps. aeruginosa IFO 3898.

l-Sorbose → l-idose → l-idonic acid → 2-keto-l-gulonic acid.     

Studies on the Synthesis of l-Amino Acids

l-Homoserine was prepared by the reduction of l-aspartic acid β-methyl ester with sodium borohydride in water solution without any racemization. The yield of l-homoserine was about 25% of the theoretical amount, and no product other than l-homoserine, l-aspartic acid and l-aspartic acid β-methyl ester was present in the reaction mixture. The low yield of l-homoserine was ascribed to the hydrolysis of the ester.

l-Azetidine-2-carboxylic acid could not be detected in the reaction mixture. In contrast with the reduction of l-glutamic acid γ-esters, the reduction of l-aspartic acid β-ester was not accompanied by the cyclization.     

Synergistic Antimicrobial Effect of Acetic Acid,Sodium Chloride and Essential Oil Components

Acetic acid, NaCl and essential oil components were examined for their synergistic antimicrobial effect, using air-borne microorganisms and purely cultured fungi. Antimicrobial assays were carried out at 27°C, using 2% glucose Sabouraud agar. In order to completely suppress the growth of all the contaminating air microorganisms over a period of one month, more than 0.2% acetic acid or more than 25% NaCl was required in the medium. Any one of the essential oil components examined, at a concentration of as high as 1 mm or more, permitted considerable growth of various air microorganisms within several days after contamination. However, in combination with both 0.1% acetic acid and 3% NaCl, perillaldehyde, citral (αβ-unsaturated aliphatic aldehydes), citronellol, geraniol, perillalcohol (primary alcohols) or cuminaldehyde, at a concentration of 0.5 mm, completely suppressed the growth of all the contaminating air microorganisms over a period of one month.

Cinnamaldehyde was approximately twice as potent as these compounds in this respect, l-Menthol (secondary alcohol) and d-carvone (α,β-unsaturated ketone), at a concentration of 1 mm but not 0.5 mm, completely suppressed such microbial growth under the same exprimental conditions. Citronellal (α,β-saturated aldehyde) and linalool (tertiary alcohol) were somewhat less effective than l-menthol and d-carvone. Hydrocarbons examined (d-limonene, α-pinene, α-pinene, camphene, β-myrcene, β-caryophyllene and p-cymene), even at 2 mm, were only moderately effective in this respect.

Similar synergistic antimicrobial effects of these substances were observed when using purely cultured fungi.

These results strongly suggest that acetic acid, NaCl and certain essential oils (or their components), when combined together, are applicable at relatively lower concentrations for effective preservation of certain foods without applying synthetic preservatives.